| 1 | 0 | 3 | 4 | 3 | 4 |
2003 Ford Expedition repairs by problem area
Engine (35%)
Transmission and Drivetrain (10%)
Brakes and Traction Control (8%)
Suspension and Steering (8%)
Electrical and Air Conditioning (32%)
Paint, Rust, Leaks, Rattles, and Trim (5%)
Other (3%)
Select a problem area
Chart based on 171 repairs.
2003 Ford Expedition suspension repair cost distribution
$2500+ (0%)
$1000 - $2499 (8%)
$500 - $999 (33%)
$100 - $499 (42%)
< $100 (17%)
Chart based on 12 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2003 Ford Expedition
Engine not specified
| 183100 mi US $734 |
Rear wheel bearing. |
2003 Ford Expedition 4dr SUV
260-horsepower 5.4L V8 4-speed automatic RWD
| 298300 mi | Wheel Bearings |
| 165000 mi | ball joints needed replacing when traded |
2003 Ford Expedition 4dr SUV
260-horsepower 5.4L V8 4-speed automatic 4WD w/low range
| 114080 mi C $250 |
Rear drivers side wheel bearing getting growly, was replaced. A 1 hour job. |
| 178381 mi US $396 |
Replaced worn out inner and outer tie rods on drivers side. |
| 220900 mi US $300 |
Replaced shocks myself. Bilsteins front and Ranchos rear. Used Ranchos because nobody had Bilstein rears. Problems getting coil over assembly out/in because I did one wheel vice lifting front/rear axle and doing both sides at same time. |
| 137000 mi US $1100 |
4 struts replace.....Transmission/fluid 12 qt |
| 48000 mi US $500 |
Front wheel bearing, vehicle is 4WD so repair part was an expensive unit. |
| 97000 mi US $285 |
Replaced left front hub |
| 124720 mi $250 |
both tie-rod ends replaced then laser geometry set (prices calculated from PLN to USD: 100 USD for parts (including postal delivery service), 60 USD for replacement, 35 USD for geometry calculated from PLN to USD is about 60 USD for everything : bar itself, postal delivery and replacement |
2003 Ford Expedition 4dr SUV
232-horsepower 4.6L V8 4-speed automatic 4WD w/low range
| 110200 mi US $505 |
Replaced left front inner tie rod end. |
| 111600 mi US $500 |
Hub was making noise, had it replaced. |
See TrueDelta's information for all SUVs
See TrueDelta's information for all Ford models.
