◆

2006 Volvo S60 repairs by problem area

Engine (31%)

Transmission and Drivetrain (6%)

Brakes and Traction Control (7%)

Suspension and Steering (23%)

Electrical and Air Conditioning (26%)

Paint, Rust, Leaks, Rattles, and Trim (4%)

Other (4%)

Select a problem area

Need advice about a specific Volvo S60 problem?

Chart based on 226 repairs.

See TSBs and recalls for the 2006 Volvo S60.

2006 Volvo S60 repair cost distribution

$2500+ (3%)

$1000 - $2499 (9%)

$500 - $999 (21%)

$100 - $499 (31%)

< $100 (36%)

See most expensive repairs

Worried about potential repair costs? An extended warranty can provide peace of mind.

Chart based on 160 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

See repairs for all Volvo S60 model years.

Volvo S60 in California, United States Jun 2009 - Jun 2011
Jul 2009 83000 mi US $100	Air conditioner blowing warm air.
May 2010 94000 mi US $920	Replaced timing belt and water pump.

Volvo S60 in Alabama, United States May 2008 - Mar 2010
Jun 2008 35000 mi	Rear headrests would not retract. Climate control console was replaced under warranty, turns out there was a kinked wire. Problem is fixed now.

Volvo S60 in Pennsylvania, United States Dec 2009 - Jun 2011
Jan 2010 63000 mi	gas cap replaced for evaporation leak detection

Return to top

Volvo S60 in Montana, United States Jan 2012 - Mar 2013
Feb 2012 69000 mi US $120	Faulty Mass Air Flow Sensor. Found a BOSCH part and replaced with Genuine Volvo Part. Air filter was dirty. Replaced air filter. No problems to date.

Volvo S60 in California, United States Aug 2011 - Nov 2011
Oct 2011 43000 mi US $800	Front brake pad replace, Mass air flow sensor replace after check engine light/throttle surging Check engine light "Engine system service required". Throttle body cleaned, PCV, MAF replaced.

Volvo S60 in California, United States Jun 2009 - Dec 2012
Jul 2009 24000 mi	Emissions solenoid. Had auto trans valve body replaced by dealer under warranty due to harsh downshifting.
Jun 2011 48000 mi	replaced both front struts, both front spring seats, both front swaybar endlinks, and finally, the front swaybar swaybar and mounts (which was the culprit)

Volvo S60 in Colorado, United States Jun 2010 - Dec 2013
Dec 2013 50000 mi US $125	Rear door speaker panel was cracked (cause unknown). Replacement panel installed (panel replacement requires removal of door trim) successfully.

Volvo S60 in Oklahoma, United States Jul 2009 - Aug 2020
Aug 2009 24800 mi	turn signal was shorting out. Was told that this was a very common problem and eventually all of the turn signal stalks from the factory go bad. They were ready for me with a part. Signal stalk replacement
Nov 2009 28000 mi	premature leather dye failure revised valve body replacement
Jul 2010 33000 mi	Driver seat popping noise nav software update interior A pillar noise. I think I fixed it by pressing/tapping on the A pillar trim.
Aug 2010 34000 mi	Seat popped when turning left
May 2015 46000 mi US $550	PCV hose cracked, replaced entire PCV system.

Volvo S60 in Ontario, Canada Feb 2009 - Mar 2013
Mar 2009 45880 mi	Door lock (was causing alarm malfunction). Steering stops noisy - lubed to fix. Driver seat creaking under load (eg. lean) - fixed by lube.
Aug 2009 49600 mi	Leaking radiator Intercooler for turbo Valve body Angle gear (AWD)
Jan 2010 62440 mi C $600	High pitched whine from speakers when car is running (even if radio is off). Rear passenger door lock was defective (showed code)
Oct 2010 66440 mi	Front wheel bearings replaced Struts and shocks defective/worn out.
Dec 2010 66960 mi C $225	Front 4C struts replaced under extended warranty and related spring seats (this part paid by owner).
Mar 2011 70680 mi C $100	Steering knuckle was failing
Jun 2011 74400 mi C $100	Front driveshafts were bad due to torn boots causing leak and contamination.
Dec 2011 81840 mi	Blower motor required replacement (noisy)
Apr 2012 85560 mi	Rear shocks need to be replaced
Jun 2012 88040 mi C $850	Replace rear shocks
Oct 2012 94240 mi C $500	Bad front strut Serviced PCV system including broken PCV hose

Volvo S60 in California, United States Apr 2011 - Dec 2016
Jan 2014 US $1400	ABS sensor on left rear needed replacing. Same wheel needed new bearing.

Volvo S60 in California, United States Jan 2013 - Aug 2014
Oct 2013 34200 mi US $1200	coolant have to be added every couple of days, no leaks can be found. apparently went in the engine.

Return to top

Volvo S60 in Colorado, United States Dec 2009 - Jun 2011
Jan 2010 27000 mi	Noticed what felt like a broken spring seat. Took it in to the dealer, they replaced both of them in the front. The whole thing was covered under warranty.

Volvo S60 in Pennsylvania, United States Jan 2008 - Apr 2018
Mar 2009 38000 mi	AWD began slipping on initial takeoff under full throttle. Initial diagnosis was nothing wrong. AWD then failed 1 year later. Collar was broken and stuck to shaft, which warranted a new tranmission. The angle gear was also replaced.
Nov 2009 47200 mi	Turn signal stalk replacement.
Apr 2013 112300 mi US $570	Front Left/Right Control Arm Bushings (F/R)
Jun 2013 114000 mi US $65	Intake camshaft reset solenoid valve had faulty connection and would not energize causing the engine to run in a low performance state.
Oct 2013 118700 mi US $300	2 Failed ignition coils. Replaced all 5 coil packs and all 5 spark plugs.
Feb 2015 142000 mi US $600	Replaced front/rear shocks/struts (one was leaking), strut tops, front wheel bearings

Volvo S60 in Minnesota, United States Sep 2007 - Mar 2013
Jun 2007 20000 mi	- vibration under braking from highway speeds - smoke from rear of engine bay after driving hard - Axle ping/clicking performing garage maneuvers (TNN77-08-2004-03-25) - Excessive leather wear on and excessive play of back of drivers seat - various in
Jul 2007 22500 mi	One headlamp was vibrating badly and replaced.
Aug 2007 23300 mi	Had to go to a second dealer to get headlamp repair done.
Sep 2007 24000 mi	Wiring harness replaced after headlamp repair was done incorrectly and the accessory drive belt rubbed through some wiring!
Apr 2008 30600 mi	- squeak/creak in suspension - distorted sound from front passenger door speakers at ANY volume - wind noise from corner of drivers door, seal isn't flush on door compared to passenger side
Jun 2008 35000 mi	Outer tie rod end was loose and replaced. Door seals falling off and were replaced. Various interior rattles fixed.
Jul 2008 38500 mi	Wheel bearings noisy and needed to be replaced AWD system failed and needed to be replaced Axles are clicking and were glued Cost was zero as it was covered by warranty
Aug 2008 39000 mi	Had to visit a second dealer to get AWD system covered under warranty.
Apr 2009 57000 mi	Clutch position sensor failed. Also, clutch pedal springs fell off the car.
Oct 2009 63000 mi US $70	Fuel lines became detached from car
Dec 2009 68000 mi US $150	Parking brake stuck on, immobilizing car. Outer tie rod was loose More parts in the parking brake system needed replacing. Brake was still dragging after first repair attempt.
Jan 2010 68000 mi	The spline sleeve/collar and angle gear of the AWD system failed with a loud metallic BANG and had to be replaced. This is a very common failure for modern Volvo AWD systems and as such was easy for myself and the dealer to diagnose.
Jan 2011 94800 mi	throttle body cleaned
May 2011 92000 mi	Suspension was getting noisy and crashing somewhat over bumps. Various suspension parts replaced (bushings, mounts, etc).

Volvo S60 in California, United States Dec 2008 - Jun 2009
Mar 2009 50000 mi	Had to go in for faulty clutch position switch. took 3 days to repay. it threw everything off -- turbo, fan, intercooler, and engine timing. Fixed the switch, that worked. problem solved. prior to that, it would backfire, stutter on acceleration, and the
Jun 2009 50000 mi	Clutch position switch replaced again. Right front strut replaced. Needed a software code reset to fix a faulty window that wouldn't roll up properly.

Volvo S60 in North Carolina, United States Apr 2009 - Jun 2009
Jun 2009 35000 mi	$700 to repair a blower motor that was damaged due to Volvo letting debris fall into the blower when they did a windshield change. Volvo would not cover it under warranty. Still not fixed.

Volvo S60 in Maryland, United States Feb 2010 - Jun 2011
Mar 2010 60000 mi US $550	Gas gauge intermittent.

Return to top

Volvo S60 in Florida, United States Dec 2011 - Jun 2018
Jan 2012 47000 mi	I had the bulbs replaced in November - then the passenger side went out within two weeks and they said it was because the connector melted. Then it happened on the driver's side - but no melting. Now it has happened AGAIN. Replaced another headlight bulb, other side. Will be having more tests performed.
Feb 2012 47300 mi US $113	Took to an ASE certified mechanic w/Volvo expertise to diagnose the premature light failure. Had to replace both bulbs on the right side and rewire the pigtail. Future repair needed on left headlight.
Dec 2013 62000 mi US $1300	New alternator required. Noticed due to a whining noise. Could have continued to drive but it may have gone out at any time. Indicator signal had issues - intermittently would not keep the signal on, signal tempo would be irregular, etc. The strut holding up the hood was broken.
Jul 2016 81000 mi US $100	Still being diagnosed. My mechanic replaced fuel filter but issue continued. Dropped offat Volvo on Jul 30 and they will run diagnostics on Aug 1. Has to do with fuel pressure and car stalling while accelerating or at a stop.
Aug 2016 81500 mi US $1270	Broken engine mount Fuel pressure sensor not working Right front spring seat broken Excessive play in right front link rod
Oct 2016 84000 mi US $400	Sun shade on moon roof would jam when trying to retract. Turned out that one of the plastic rails is slides on had cracked and needed to be replaced.

Return to top

Volvo S60 in Malaysia May 2011 - Dec 2012
Jun 2011 89280 mi	The sensor light was triggered. (transmission service required urgent) Sensor light triggered. STC and ABS system need urgent service.

Volvo S60 in California, United States Jul 2009 - Mar 2010
Oct 2009 43000 mi US $360	loose steering wheel
Dec 2009 44000 mi US $225	Loose steering wheel.

Volvo S60 in California, United States May 2018 - Nov 2022
Jun 2018 120000 mi	Check engine light came on. Diagnosed and replace MAF.

Volvo S60 in Texas, United States Jan 2008 - Oct 2009
Sep 2009 27000 mi	Problem on startup - engine cranking but not igniting right away. Faulty temperature sensor.

Volvo S60 in Minnesota, United States Apr 2008 - Jul 2017
Feb 2013 48000 mi US $540	both camshaft sensors were bad. replaced both sensors.
Jun 2016 55000 mi US $500	replaced a few non brake pad/rotor parts and bled brake system. Steering wheel had movement forward and back of about 3/8 to 1/2 inch. Not sure how they fixed, but told me it was a pain.
Oct 2016 56000 mi US $75	drivers side brake light
Mar 2017 56650 mi	Ticking noise diagnosed as probably being a semi stuck lifter. More of an advisory trip, told to use premium gas and a couple of tanks of gas with Seafoam, alternating two with additive, one without in between. Update, July: seems to have worked.

Return to top

Volvo S60 in California, United States Dec 2016 - Feb 2017
Jan 2017 US $1000	O2 Sensor replaced. PCV and breather hose replaced
Feb 2017 122000 mi US $2000	Large A/C leak, estimated repair but not done. PCV system clogged. Oil trap and hoses replaced. Fuel pressure sensor went bad. Transmission mounts failed

Volvo S60 in Connecticut, United States Mar 2010 - Dec 2021
Nov 2010 66150 mi US $100	In-warranty repair of radio antenna lead wire. In-warranty repair of radio antenna lead wire. Replace broken gas door hinge.
Jul 2011 74000 mi US $500	Defective rear caliper. R&R caliper, both rear rotors & pads, parking brake shoes.
Oct 2011 78000 mi	Replace alternator, noisy bearing Replaced upper engine mount
Aug 2015 122700 mi US $1100	Check engine light lit. Replaced fuel pump.
Jun 2018 144125 mi US $35	Replace burnt low beam headlight bulbs

Volvo S60 in California, United States Feb 2008 - Jan 2022
Sep 2016 141000 mi US $65	replaced fuel level sensor
Dec 2021 182000 mi US $110	Front pads and rotors

Return to top

Volvo S60 in Quebec, Canada May 2010 - Dec 2016
Jun 2010 29140 mi	Engine warning light comes on. Performed diagnostic of computer; no clear cause identified. reset computer and told to wait and see.
Jul 2010 30070 mi	Engine warning light comes on. This is a recurring problem. light came on again after resetting of the computer. Performed computer diagnostic. No clear cause identified. Reset the computer again. Engine warning light comes on. This is a recurring problem. light came on again after resetting of the computer. Performed computer diagnostic. No clear cause identified. Reset the computer again.
Dec 2010 34100 mi	Engine light is always on. Shop has done the computer diagnostics on several occasions (5 so far) with no clear cause identified. After reset, the light comes back on within a few hours. Not sure if this is a hidden defect subject to recall
Nov 2011 41540 mi C $800	Transmission fluid, winterize, and new battery
Jan 2012 53700 mi C $500	Front end Connecting rod replacement. Reset on-board computer. Problem is apparently with an exhaust sensor that gives false readings.
Mar 2012 43400 mi C $800	Replace front brake pads and shocks
Jun 2013 48980 mi C $700	damaged rear spindle and hand brake mechanism
Sep 2013 50220 mi C $500	Exhaust retention clamps broke
Jan 2014 43960 mi C $1500	Ignition to steering interlock failed. Could not turn key past 1st position to start engine.
Mar 2014 52700 mi C $40	Power Steering fluid leak. Hose and clamp replaced.
Sep 2014 54560 mi C $980	Steering lock up due to failed seal in steering rack. Replaced with used rack unit (50% of price of new factory part). Had to wait 3 days to source part.
Feb 2015 56420 mi C $100	Replaced tail Pipe clamp.
Aug 2015 57860 mi C $804	Replaced right rear spindle, failed due to rust damage. Note( left rear previously repaired in 2013)
Mar 2016 59520 mi	Rear wheel bearing replacement (left)
Jun 2016 60760 mi C $450	Check Engine light/CO2 Sensor replaced
Aug 2016 61380 mi C $1300	Haldex Differential Electronic Module
Dec 2016 62620 mi	Impending repairs prompted sale of car.

Volvo S60 in Ohio, United States Oct 2016 - Jun 2018
Feb 2016 130000 mi US $3000	ABS/AWD failed, had to replace a lot ABS/Awd failed

Return to top

Volvo S60 in Tennessee, United States Feb 2008 - Aug 2016
Jun 2008 38000 mi US $110	MAF sensor causing CEL code. Monitored OBD2 output of MAF sensor to identify no response from MAF.
Sep 2011 92000 mi US $275	Worn bushing on sway bar link creaking & clunking on bumps. Replaced link, rotated tires and performed alignment as periodic maintenance.
Sep 2012 111000 mi US $75	Replace worn sway bar link.
Sep 2014 139000 mi US $400	Replaced lower control arms, and struts. The struts were basically preventative. The lower arms were functional but compromised and were showing signs of torn rubber in the bushings. Replaced brake pads while working there. $290. Replaced right and left Axles/CV joints due to torn boots and noisy CV joints. $110.

Volvo S60 in California, United States Nov 2008 - Sep 2016
Aug 2010 65000 mi US $300	Loss of coolant noticed and tracked for four weeks. Plastic side cover of radiator chamber split. Passenger side. Replaced with Volvo original part.
Apr 2013 87000 mi US $200	Bushings and A-arms replaced.
Aug 2013 87600 mi US $150	A faulty regulator at the air filter was causing hard and stumbling starts. Part replaced and issue solved.
Dec 2013 89000 mi US $100	Left headlamp failed. Plastic cover designed to R&R bulb too close to other components. Entire bumper had to be removed. All lamps replaced.

Volvo S60 in Massachusetts, United States Dec 2015 - Jun 2018
Dec 2015 119000 mi US $525	Replaced original starter
Sep 2016 127000 mi US $300	Replaced faulty A/C Compressor and recharged system Worn Sway bar links. Replaced sway bar links
Jun 2017 136000 mi US $300	A common problem with Volvos S60s (and similar models) after 100,000 miles. The Oil Breather Trap get clogged and the engine starts burning multiple quarts of oil very quickly. Unfortunately this repair requires you to remove the intake manifold and multiple hoses and electrical connections. The Oil Breather Trap is just a simple plastic box with an extra hole to increases airflow to the engine. I did the repair and the car is running fine again. Replaced Tie-rod ends.

Volvo S60 in Idaho, United States Mar 2016 - Jun 2018
Feb 2018 54950 mi US $100	Tranny had started to slip once every few days. Took car in to check condition/level of fluid and it was full but dark and smelled burnt. Had it changed but problem was not resolved.

Volvo S60 in Ohio, United States Feb 2016 - Mar 2017
Dec 2016 105700 mi US $2725	Suspension making noise while driving. Shop found right front strut leaking, spring seats are broken, and control arm bushings are cracking. Removed and replaced struts, spring seats, and control arm bushings ($1663.86 including labor). Alignment ($94.95) Replaced timing belt kit and axuliary belt ($739.96 including labor). Also replaced a few bulbs.

Volvo S60 in South Carolina, United States Mar 2015 - Apr 2016
Jun 2015 185000 mi US $164	Had tie rods replace

Volvo S60 in California, United States Jul 2008 - Apr 2019
Jan 2008 44000 mi	rear window trim was replaced...
Jul 2011 79000 mi	Replaced headlight.
Apr 2013 87300 mi US $600	Head light repair. I would replace the bulb and it would last around a week and go out again. So the whole passenger side assembly was the problem. And aftermarket wheel prob.
Apr 2014 96500 mi US $1200	had to replace driver side head light assmly
Oct 2015 115000 mi US $650	key ignition went bad, 600 bucks later...
Apr 2016 123300 mi	AC recharged; ignition switch went bad
Oct 2016 130000 mi US $650	Had to replace starter. An in line turbo oil leak.
Mar 2018 147000 mi US $300	oil pump was leaking.
Jun 2018 152000 mi US $300	recharge, oil change, flush ac/ vent
Feb 2019 159000 mi US $350	replace radiator.

Volvo S60 in Connecticut, United States Mar 2011 - Dec 2016
Dec 2011 62000 mi	gas gauge did not work, brought to dealker to have repaired, they replaced sensor, when we got car home, all gasoline leaked out of car, had car towed back to dealer and they resealed sensor
Jun 2012 74000 mi US $297	Front of AC compressor fell off due to broken bolt. repaired and cleared faults in computer and topped off freon.
Sep 2015 109000 mi US $500	Serpentine belt was replaced
Mar 2016 117000 mi	battery connection loose

Volvo S60 in Pennsylvania, United States Aug 2010 - Sep 2016
Sep 2011 88000 mi	radiator tank leaking-seam leaking-plastic intermediate start problem-dealer found no cause but as a token redid the starter motor connector. I believe it will resurface. Because very intermittent it may take 6 months to show again. When it happens it results in a tow.
Dec 2012 106000 mi US $100	headlight bulb-earlier repair by previous owner caused bulb not to be able to release. Had to remove entire headlight assembly, thus, bumper cover etc to get this out to remove bulb due to lack of space.This 10 min job turned into a 3 days
Mar 2013 107000 mi US $1000	PCV crankcase tank box (kit is about $400 in parts and a 1 day job-(well over 1000 at dealer). Also changed spark plugs, flushed coolant, changed brake fluid, timing belt, serpentine belt, water pump, tensioners and idler pulleys.
Jul 2013 109500 mi US $80	Clunks in front end of car with small bumps, especially at low speeds. diagnosed as front sway bar ends, replaced sway bar ends only, resolved completely. S60 known for this problem.

Volvo S60 in Quebec, Canada Aug 2010 - Jun 2011
Oct 2010 52700 mi C $50	Car would not start. Cranked but no fuel was being delivered. Gas line valve replaced.

Volvo S60 in Pennsylvania, United States Sep 2009 - Dec 2017
May 2010 27900 mi US $2700	complete suspension rebuild. struts, shocks and bushings. Previous owner must have been a salesperson for a book company and always driving on cobblestone roads. This makes the car like new!!!
Apr 2017 57000 mi US $350	Complete pcv replacement
Jun 2017 59000 mi	Plugs, air filter,fuel filter, cleaned MAF

Volvo S60 in Oklahoma, United States Mar 2010 - Oct 2015
Jun 2012 127000 mi US $150	A/C was blowing cooler on one side. Recharged system appears to be fine.
Mar 2013 143000 mi US $900	The A/C Condenser was bad. So I forked over the painful $900. Now it works great! Plus oil change. Total bill $975.00
Jul 2013 150000 mi	Oil change, spark plugs and Replace pcv hose from cylinder head to pcv box
Feb 2014 157900 mi US $700	Reset window switch. The window would auto roll up halfway and then reverse and roll back down. They reset the auto/up window switch.
Aug 2014 167000 mi US $600	Check Engine Light came on. Needed new starter
Sep 2014 169000 mi	The check engine light is back on. Mechanic not sure what the problem is exactly.I'll have them shut it off on next oil change.
Nov 2014 171300 mi US $1100	Car needed struts
Feb 2015 175000 mi US $87	Routine Oil Change. Shut off Check Engine light--but back on... I gave up on that 10K miles ago.
Jun 2015 180000 mi	Coolant leak. Just a loose clamp.
Jul 2015 180800 mi US $190	Seam split on drivers seat. Trim Shop
Oct 2015 185000 mi	Check engine light on.

Volvo S60 in Alabama, United States Aug 2010 - Dec 2015
Aug 2011 70000 mi US $100	Unsure of location of leak - waiting on future analysis
Oct 2011 75000 mi US $400	Passenger door locks no longer worked with auto lock
Jan 2014 99200 mi US $1500	Compressor needed to be replaced
Apr 2015 127500 mi US $935	Fuel sensor, Strut plate replacement

Volvo S60 in California, United States Jul 2009 - Sep 2018
Jun 2010 104000 mi US $850	Air conditioner stopped working; crack discovered in condenser; part replaced @ $500 plus labor.
Jul 2016 195700 mi US $160	Misfiring, power loss. Replaced bad ignition coil
Aug 2018 224000 mi US $1430	Front strut caps degrade after about 100k miles producing rattling in suspension Also replaced front struts and rear shocks.

Return to top

Volvo S60 in British Columbia, Canada Jun 2010 - Dec 2011
Jul 2010 11780 mi	Over-revving fan -- Poor connection to water temp sender. Fixed by simply removing and then reattaching connecter.

Volvo S60 in Arizona, United States May 2014 - Jul 2016
Jun 2014 101000 mi US $50	AWD went out Radiator slow leak $900 estimate.
Sep 2014 105000 mi	Washer fluid bottle broken, leaks
Jul 2016 120000 mi US $1170	Upper strut mount passenger side PCV system including breather box $550

Volvo S60 in New Hampshire, United States Apr 2010 - Jun 2015
Dec 2011 103000 mi US $500	A bad ball bearing was creating noise. A clip holding a brake pad had broken off.
Apr 2012 106000 mi US $175	Bad ball bearing discovered and replaced when snow tires were changed.
Aug 2012 110800 mi US $200	Parking brake broke such that car wouldn't move. Evaporative leak causing Check Engine light to come on.
Feb 2014 130700 mi US $3150	Initial problem was insufficient cabin heat. Bad cabin thermometer. Bad fuel pump, replaced timing belt.
Dec 2014 143000 mi US $190	I don't remember.
Jun 2015 145000 mi US $319	Tie-rod replaced.

Volvo S60 in New York, United States Jul 2012 - Jul 2013
Feb 2013 100400 mi US $300	I don't remember what the problem was but they recommended more than I could financially handle so they agreed to repair what they could to ensure the car was safe and recommended I return for the remaining work. I just don't remember and can't locate service record for this. There was so much noise generated by the car and it continued even after repairs were made.
Jul 2013 109000 mi	Car didn't drive well. The mechanic informed me the car was not safe to drive faster than 30-40 miles an hour, that it needed a great deal of expensive repairs and suggested I immediately trade the car.

Volvo S60 in New York, United States Dec 2015 - Jun 2020
Dec 2015 104000 mi US $3800	Engine would stall when coming to a stop light. Dealer diagnosed a faulty fuel pressure sensor and a couple of bad emissions hoses. After repairs were done the engine CPU was reprogrammed. Car was making a very noticeable clunking noise when driving over bumps and potholes. Dealer diagnosed faulty rear suspension control arms and stabilizer bar. After repairs the noise disappeared.
Mar 2016 105000 mi US $1300	Long standing coolant leak. Radiator was replaced. Leak is gone. Braking was poor. Had rotors, pads and parking brake mechanism replaced. Braking is normal now.

Return to top

Volvo S60 in Netherlands May 2009 - Jun 2018
Jun 2009 11780 mi	airco stops when outside temp. is higher then 20. deg. diag. comp says all is oke, even if its 35 deg. inside the car.
Jul 2009 12400 mi	airco got fixed, former owner replaced airco pump. metal particals of old pump were in aircosystem and clogged it up. there is a venturi were high pressure liquid gets sprayed in low pressure part. here is a fine mesh filter, this was clogged.
Jul 2010 93600 mi	1 strut have to be replaced 1 torsion bar needed some work, misfit from new.
Apr 2012 123460 mi	Xenon bulb changed,
Dec 2012 133920 mi €300	left side seal of the powersteering cylinder was leaking oil
Mar 2013 137640 mi €470	I ordered the magnetic cluths, thinking that was the problem with the AC. But the cluths was burned because the ac pump siezed up. I will replace pump later.
Nov 2013 151280 mi	Seized ac pump
Feb 2014 154380 mi €600	Gearcase flush, replacing steering strut, cleaning lenses of headlights.
May 2014 158100 mi €80	Rear brake claw got stuck
Oct 2014 165820 mi €75	Mid engine strut got souple
Nov 2015 186620 mi €400	End muffer leaked after 9 years
Sep 2017 217620 mi €600	Replaced fronts trust, steering arm, brakes and pads

Return to top

Volvo S60 in United Arab Emirates Jan 2008 - Nov 2008
Feb 2008 9300 mi	Fuel door hinge replaced.
May 2008 11160 mi	Indicator relay in dashboard replaced.

Return to top

See TrueDelta's information for all Sedans

See TrueDelta's information for all Volvo models.

2006 Volvo S60 repairs by problem area

2006 Volvo S60 repair cost distribution

2006 Volvo S60

2006 Volvo S60 4dr Sedan

2006 Volvo S60 4dr Sedan

2006 Volvo S60 4dr Sedan

2006 Volvo S60 4dr Sedan

2006 Volvo S60 4dr Sedan

2006 Volvo S60 4dr Sedan

2006 Volvo S60 4dr Sedan

2006 Volvo S60 4dr Sedan

2006 Volvo S60 4dr Sedan

2006 Volvo S60 4dr Sedan

2006 Volvo S60 Repair Histories