2007 Ford Expedition Ford Expedition 2007

We are 103,000+ car owners sharing real-world car information.

Join Us

2007 Ford Expedition repairs by problem area

Engine (28%)

Transmission and Drivetrain (15%)

Brakes and Traction Control (6%)

Suspension and Steering (10%)

Electrical and Air Conditioning (28%)

Paint, Rust, Leaks, Rattles, and Trim (7%)

Other (5%)

Select a problem area

Show all problems

Need advice about a specific Ford Expedition problem?

Chart based on 155 repairs.
See TSBs and recalls for the 2007 Ford Expedition.

2007 Ford Expedition suspension repair cost distribution

$2500+ (0%)

$1000 - $2499 (21%)

$500 - $999 (29%)

$100 - $499 (36%)

< $100 (14%)

Worried about potential repair costs? An extended warranty can provide peace of mind.

Chart based on 14 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

2007 Ford Expedition

Engine not specified

103000 mi

US $350
power steering radiator leak 

Return to top

2007 Ford Expedition 4dr SUV, ext.

300-horsepower 5.4L V8 6-speed automatic RWD

122000 mi

US $500
R and r lower ball joints 

Return to top

2007 Ford Expedition 4dr SUV, ext.

300-horsepower 5.4L V8 6-speed automatic 4WD w/low range

85700 mi

US $400
Wheel bearing replaced. 
106600 mi

US $950
The steering shaft u-joint was binding (felt like PS pump failure, grab then loose, then grab again). Also had rear hub changed. Bearings were getting rusty, but still worked. 
84940 mi Bearing replacement in driver front wheel. 
142600 mi Needs bodywork and front end work as well so it would be a losing cause to keep it going. 
139600 mi

US $1500
Replace all 4 ball joints 
152000 mi

US $1600
Alignment needed, upper control arm bushing replaced. Previous shop did not align after replacing upper control arm. 

Return to top

2007 Ford Expedition 4dr SUV

300-horsepower 5.4L V8 6-speed automatic RWD

173386 mi

US $450
replaced rear axle seals 
176000 mi

US $380
Rear bearing replaced 
135000 mi

US $926
Right rear strut was losing fluid. Due to mileage on original struts; had all four replaced. 

Return to top

2007 Ford Expedition 4dr SUV

300-horsepower 5.4L V8 6-speed automatic 4WD w/low range

116000 mi

US $875
Power steering pump growling. Took it to the shop to be diagnosed. Found power steering cooler leaking. Power steering cooler is part of the A/C condenser assembly which required the A/C system to be serviced when the assembly was replaced 
154000 mi

US $290
replace right rear shock - leaking 
180188 mi

US $1068
replace right rear hub/wheel bearing and sensor replace left rear strut and worn left rear upper control arm (rear ward) 

Return to top

See TrueDelta's information for all SUVs
See TrueDelta's information for all Ford models.

2007 Ford Expedition Suspension Problems

See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how frequently 2007 Ford Expedition problems occur, check out our car reliability stats.