| 1 | 0 | 3 | 4 | 3 | 4 |
2008 Mercury Milan repairs by problem area
Engine (30%)
Transmission and Drivetrain (7%)
Brakes and Traction Control (4%)
Suspension and Steering (22%)
Electrical and Air Conditioning (26%)
Paint, Rust, Leaks, Rattles, and Trim (4%)
Other (7%)
Chart based on 27 repairs.
2008 Mercury Milan repair cost distribution
$2500+ (0%)
$1000 - $2499 (4%)
$500 - $999 (8%)
$100 - $499 (32%)
< $100 (56%)
Chart based on 25 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2008 Mercury Milan 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic FWD
| Mercury Milan in Illinois, United States Sep 2014 - Mar 2019 | |||
| Jan 2015US $240 | Battery Died, was a brand new battery when i purchased the car. Dealer gave me a Jump start and battery boost. Power Steering Gone Steering pump replaced with new one. car was put in shop on Saturday morning and received it on Monday afternoon. | ||
| Mercury Milan in Tennessee, United States Jan 2013 - Feb 2013 | |||
| Feb 201378000 miUS $500 | O2 sensor | ||
| Mercury Milan in Pennsylvania, United States Apr 2012 - May 2016 | |||
| Apr 2016136000 miUS $1664 | Hydraulic booster failure | ||
| May 2016136000 mi | Total ECU failure | ||
| Mercury Milan in New York, United States Sep 2008 - Mar 2011 | |||
| Jun 200912000 mi | left rear "door check" which holds door open defective. Part ordered for replacement. new rear " door check" replaced with ordered part. | ||
| Nov 200918000 mi | SYNC mic replaced with remote mounted new mic and software reprogrammed. | ||
| Sep 201025000 mi | Replaced SYNC remote mic for the 2nd time. Still working OK | ||
| Mercury Milan in California, United States Jun 2010 - Dec 2013 | |||
| Jan 201272100 miUS $17 | Left low beam bulb replacement. | ||
| Feb 201265000 miUS $100 | Check engine light code indicated air/fuel ratio sensor, diagnosed as leaky intake manifold gasket, which was replaced. | ||
| Nov 201395000 miUS $100 | Power driver's seat fore and aft motion became irregular - had to wiggle switch to get movement. Replaced motor and switch. Bill was $325, covered by Ford extended warranty less $100 deductible. | ||
2008 Mercury Milan 4dr Sedan
160-horsepower 2.3L I4 5-speed automatic FWD
| Mercury Milan in Minnesota, United States Oct 2018 - Jun 2020 | |||
| Nov 2018164000 miUS $437 | Water pump and thermostat failed and were replaced Valve cover gasket failed | ||
| Oct 2019169000 miUS $25 | The valve cover gasket was leaking and was replaced. | ||
| Mercury Milan in Illinois, United States Apr 2013 - Dec 2014 | |||
| Aug 2014112000 miUS $140 | Lower sway bar nut got blown off by a pot hole. Replaced both with aftermarket parts. | ||
| Mercury Milan in New York, United States Mar 2013 - Jan 2022 | |||
| Nov 2014127800 miUS $705 | Worn out CV Shaft on passenger side. Worn out wheel bearing on passenger side. | ||
| Aug 2016159600 miUS $20 | Had to replace air injection bypass checkvalve | ||
| Nov 2017185000 miUS $20 | Replaced front struts with new loaded strut kits. Valve cover gasket leaking oil into spark plug wells | ||
| Mercury Milan in New York, United States Aug 2008 - Feb 2011 | |||
| Mar 201017000 mi | squeal while climate control system blowing air. | ||
| Mercury Milan in Wisconsin, United States Dec 2010 - Oct 2012 | |||
| Jan 201159500 miUS $3 | Silicone on trunk trim and door panels. Aftermarket audio causing too many vibrations. | ||
| Jul 201175000 miUS $180 | Replaced shock absorbers | ||
| Jan 2012100800 miUS $90 | Replaced driver side motor mount | ||
| Apr 201294000 miUS $210 | Experienced rough shifting between 3-4 (45mph) after driving for a while. Replaced transmission shift solenoids. | ||
See TrueDelta's information for all Sedans
See TrueDelta's information for all Mercury models.
