| 1 | 0 | 3 | 4 | 3 | 4 |
2009 Chrysler Town & Country repairs by problem area
Engine (25%)
Transmission and Drivetrain (7%)
Brakes and Traction Control (14%)
Suspension and Steering (17%)
Electrical and Air Conditioning (23%)
Paint, Rust, Leaks, Rattles, and Trim (6%)
Other (7%)
Chart based on 151 repairs.
2009 Chrysler Town & Country repair cost distribution
$2500+ (1%)
$1000 - $2499 (6%)
$500 - $999 (9%)
$100 - $499 (41%)
< $100 (43%)
Chart based on 122 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2009 Chrysler Town & Country
Engine not specified
| Chrysler Town & Country in Missouri, United States Jun 2013 - Jun 2014 | |||
| Jun 201432000 miUS $299 | replace rear and front rotors and pads new battery | ||
2009 Chrysler Town & Country 4dr Minivan, ext.
251-horsepower 4.0L V6 6-speed shiftable automatic FWD
| Chrysler Town & Country in Michigan, United States Nov 2010 - May 2011 | |||
| Dec 201050000 miUS $200 | brake issue, disc not fully disengaging... | ||
| Chrysler Town & Country in Vermont, United States Jul 2017 - Aug 2017 | |||
| Jul 2017137000 miUS $400 | Rear brakes were done | ||
| Chrysler Town & Country in California, United States Sep 2010 - Jun 2022 | |||
| Oct 201037000 mi | Drain tube for AC was causing water to seep into the passenger compartment. First problem was taken care of by TSB by dealer. Problem occurred again 1 year later and was taken care of by owner. | ||
| Feb 201496000 miUS $300 | Experiencing 20% to 25% drop in fuel efficiency. Whith no OBD code, had oxygen sensors replaced, all four of them, as a possible solution to problem. Did not solve the issue. | ||
| Apr 201497300 mi | Lost performance (mpg) and rough idle. Occasional OBD code P0300. With leak-down test found poor compression in cyclinders 2 and 3 from leaky valve guides. Replace both heads. Covered under Lifetime drive train warranty. | ||
| Aug 2014100700 mi | right front axle | ||
| Mar 2015109000 miUS $110 | Left front wheel hub. | ||
| Dec 2015122000 miUS $325 | Stability sensor (aka clockspring) in steering column replaced | ||
| Aug 2016130000 miUS $80 | Left sliding door exterior door handle. | ||
| Jan 2017137000 mi | Replace starter ring gear. | ||
| Mar 2017137000 mi | Transmission rebuild. The transmission failed only a quarter mile from the dealer just after a cracked starter ring gear was replaced. I was able to nurse the car about 100 ft where I was then able to coast downhill to the dealer. Replace timing belt. | ||
| Chrysler Town & Country in Minnesota, United States May 2009 - Jun 2018 | |||
| Jun 201015000 mi | front passenger door sqeak while closing | ||
| Dec 201021000 mi | TSB on sliding side door cables | ||
| Mar 201125000 mi | replaced key fob - wasn't always unlocking doors and opening sliding doors; dealer said there was a circuit board issue with the fobs | ||
| Aug 201131000 mi | Calipers failing intermittently - were replaced; rotors warped - were replaced; pads replaced as goodwill gesture bad calipers - calipers, rotors and pads replaced | ||
| May 201456000 miUS $100 | Drivers power mirror wasn't going in or out and was slow going up and down. Entire mirror was replaced under extended warranty with 100 dollar deductible. | ||
| Oct 201567500 miUS $100 | right bearing replaced left shock replaced | ||
| Sep 201676000 miUS $100 | steering fluid line leak passenger exterior mirror turn signal inoperable | ||
| Mar 201780000 miUS $100 | Laeking transmission lines replaced Exterior mirror-embedded turn signal cover fell off Broken rear wiper replaced; arm cracked | ||
| Sep 201784000 miUS $100 | Power steering failed. Leak in lines. Lines replaced. | ||
| Chrysler Town & Country in Alabama, United States Jan 2018 - Jan 2022 | |||
| Oct 2021123000 miUS $150 | Replaced ABS Control Module. Had to buy a $750.00 OBD scanner to complete this repair as the new (old stock, salvage) module has to be "programmed?" to the vehicle to complete repair. Physically replacing module was simple only four bolts. | ||
| Chrysler Town & Country in Georgia, United States Nov 2009 - Jun 2022 | |||
| Dec 20096000 mi | Dash display failed to light. | ||
| Mar 201131000 mi | Cruise control will not shift to hold speed on hills until speed drops exactly 5mph. Not acceptable, should hold speed to 1mph or at worst 2mph. Programming problem which has to be fixed by Chrysler. TSB applied did not help. | ||
| Oct 201488700 miUS $50 | Plastic tee to rear heater core in engine cooling line developed pin hole leak. Detected problem immediately, no engine overheat. Replaced OEM molded plastic tee and triple hose with steel tee and individual lengths of hose. | ||
| Oct 2015102300 mi | Replaced EGR valve. Skipping during warm up in 60 degree temperatures at 40-50 mph, sometimes set an EGR code, but would clear code after driving a few miles. Problem first appeared at about 55,000 miles, hard to diagnose,no other symptoms. | ||
| Nov 2017130000 miUS $350 | Code 2200 ABS module internal fault, replaced module | ||
| Jun 2022180000 mi | Transmission failure, repaired under lifetime factory warranty. Zone rep insisted on dealer rebuild rather than reman replacement. Reman was in stock at local dealer, flat rate 11 hour time. Should have taken two days. Car was shuffled to two dealers twice and then a third before one of them was authorized to rebuild. Took over 5 months out of service time. I own 5 Chrysler minivans and 5 RAM diesels. Loyal Chrysler customer since 1970. Will not buy another Chrysler product or recommend one ever again. Totally unacceptable treatment for warranty service. Was never allowed to talk to zone rep or contact him in any fashion. Three letters to Chairman of Chrysler went unanswered. Just completely unacceptable behavior by the firm. There is no Chrysler anymore, it's now Stellantis (Peugeot). If that's how Peugeot treated their U.S. customers I understand why they vanished from the U>S. market decades ago. They appear to be attempting to replicate that performance. I like the products, but cannot tolerate such treatment. | ||
2009 Chrysler Town & Country 4dr Minivan, ext.
197-horsepower 3.8L V6 6-speed shiftable automatic FWD
| Chrysler Town & Country in South Dakota, United States Sep 2014 - Feb 2017 | |||
| Jul 201591500 mi | Replaced right front wheel bearing. | ||
| Feb 2017125000 mi | Head gasket failure. Decided not to repair. Traded vehicle in. | ||
| Chrysler Town & Country in Michigan, United States Jun 2010 - Sep 2018 | |||
| Aug 201018176 mi | Oil leak. Found oil pan bolts loose. Problem persisted. Replaced lower oil pan seal; removed upper oil pan seal & replaced gasket. | ||
| Feb 201122427 mi | Key fob stopped working. Dealer replaced no charge. | ||
| Jun 201126276 mi | Loud squealing from rear when brakes applied. Left rear brake sticking. Resurfaced rotors, replaced pads & hdwe. Chrysler factory reps happened to be at dealer, otherwise dealer charges would have applied. | ||
| Sep 201129400 miUS $100 | Front rotors warped. Reconditioned the front brakes. Customer paid $100 deductible only. | ||
| Jan 201455329 mi | Left front door lock actuator not working. Dealer tested, tried new switch. Problem unresolved. | ||
| May 201455655 miUS $515 | High pitched chirp heard at slow speed driving. Replaced rear rotors, caliper & pads. | ||
| Nov 201460646 miUS $154 | Scanned DTC P0456 (evap leak). Defective ESIM (evap. system integ. monitor). Replaced. | ||
| Mar 201564395 miUS $336 | Diagnose & repair faulty EGR valve & gasket | ||
| May 201566120 miUS $136 | Check engine light on, Scanned DTC P0456 (small evap. leak). Performed smoke test. Found fuel cap not sealing. | ||
| Aug 201568295 miUS $98 | A/C stopped working. Found rear evaporator connection tube leaking. Cust. declined repairs due to excessive cost. | ||
| May 201673590 miUS $658 | Trans cooler lines leaking. Replaced cooler line set; refilled ATF Leaking oil. Found lower intake gasket leaking, also leakage from both valve cover gaskets. Front brake rotors warped. Reconditioned front brakes. | ||
| Jul 201675114 miUS $103 | Diagnostic tests: Vehicle intermittently will not start. All dash lights come on with key but starter solenoid doesn't engage. Repeated attempts will result in normal start after 2-4 tries. This has been an ongoing issue. No correlation to temperature, weather conditions, duration of van being turned off, or use of different key. Dealer could find nothing. | ||
| Oct 201677947 miUS $82 | Liftgate fails to complete latching sequence. Latch slips then repeatedly tries to re-latch, indefinitely, until battery dies. Dealer recommended latch replacement. Customer reconnected electrical plug, performed repeated checks, couldn't get problem to repeat. Watched for recurrence but didn't happen again for 15 months & counting. | ||
| Jul 201783104 miUS $440 | Right front wheel bearing noise. Bad wheel bearing replaced. Front coolant hose separated at "Y". Replacement required. | ||
| Aug 201784190 miUS $52 | Disconnect electrical connection to driver side sliding door due to sliding door operation failure. | ||
| Chrysler Town & Country in Connecticut, United States Feb 2016 - Mar 2016 | |||
| Feb 2016104000 miUS $25 | original spark plug wires were replaced with 8mm new wires. Original were beginning to arc in damp weather. | ||
| Chrysler Town & Country in Michigan, United States Oct 2009 - Jun 2022 | |||
| Apr 201782000 miUS $62 | replaced a faulty instrument cluster with a used one | ||
| Oct 2021117000 mi | Replaced right rear caliper | ||
| Chrysler Town & Country in New York, United States Jul 2017 - Jul 2018 | |||
| Jul 201798000 miUS $600 | Sirius radio stopped working. Needed software update and new radio | ||
| Chrysler Town & Country in Iowa, United States Jul 2013 - Aug 2014 | |||
| Sep 201387000 mi | replaced the left rear auto door opening mechanism | ||
| Jun 201498000 mi | On vacation it flat out died due to a problem with some wire in the electrical main cabling bundle. Luckily they were able to replace just the bad wire (a ground wire?) instead of the entire bundle--$3000 and not covered by the Costguard POS warranty. | ||
| Chrysler Town & Country in Wisconsin, United States Nov 2017 - Nov 2018 | |||
| Oct 201782000 miUS $245 | Front brake pads failed, damaged rotors Last done 34k miles ago | ||
| Dec 201784000 miUS $100 | Vehicle has developed an intermittent shifting problem. When cold transmission will lock in “limp-in” mode. Correctable by stopping, shutting vehicle off then restarting. Repair shop experienced problem 1x but could not determine cause. | ||
| Chrysler Town & Country in Minnesota, United States Mar 2013 - Apr 2014 | |||
| Apr 201455000 miUS $100 | Driver side sliding door, not opening or closing when activated using keyfob and door button. Flash update on DMRR and PSDMR were performed, and mechanic diagnosed the problem to be door track wiring shorted. Wiring was replaced. | ||
| Chrysler Town & Country in Indiana, United States Sep 2010 - Sep 2014 | |||
| Dec 201058000 mi | RADIO WAS NOT PICKING UP STATIONS..TOOK TO DEALER..THEY FOUND THE CABLE FROM ANT.TO RADIO WAS CORRODED BEHIND THE PASSENGER SIDE KICK PLATE WHERE THE CABLE COMES INTO THE CAR. SAID IT WAS FROM MOISTURE..PARTS ON ORDER. | ||
| Feb 2014103700 miUS $400 | LOWER INTAKE MANIFOLD LEAKING .ERG PELACED | ||
| Apr 2014103800 miUS $377 | LEFT REAR WHEEL BEARING ASSEMBLY REPLACED | ||
| Chrysler Town & Country in New York, United States Mar 2009 - Jul 2018 | |||
| May 201134000 mi | Side door hatch rattles. Try to repair several times, still have rattle. | ||
| Oct 201137000 mi | Bearings were worn due to city driving. There was no cost because I purchased a service contract with Zurich for 60mths or 100K miles. Satellite radio needs to be replaced due to module failure? Radio is on order for one week. replaced satellite radio broken rear hatch door chain | ||
| Nov 201141000 mi | Radiator fix per Zurich policy, $454, reason unknown, possibly hit by debris. | ||
| Feb 201462400 miUS $1500 | Struts and shocks replaced. Went for oil change and recommended maintenance | ||
| Mar 201463000 miUS $745 | Oil pan had a leak. Recommended maintenance was performed. Replaced power steering hose $380 Coolant bypass hose leaking $365 | ||
| Jun 201578000 miUS $500 | Plastic Y splitter has a common defect and split. Dealer made me replace all cooling system hoses and pipes for engine cooling system. Also, they fixed an ignition recall on supplied two new FOBS at no cost. | ||
| Oct 201581300 miUS $185 | Lift gate bolt cracked. Replaced entire lift gate support. Also fog light replaced. Battery needed to be replaced after 18 months | ||
| Dec 201583000 miUS $1570 | Struts, stabilization bars, absorbers were replaced again. I thought bearings were worn, but they told me it was suspension. I think it's bearings - still noise. In 2011, received wheel bearing recall TC/DC 2008-10 models - 5 yrs/90K miles. | ||
| Sep 201689000 miUS $832 | The bushings needed replacement The door harness that powers the electric sliding plastic covering fell apart. Btw, the dealer provide a free loaner 2016 Town and Country car for 8 days at no charge, as I bought the car from the dealer! Unheard of! | ||
| Dec 201692000 miUS $418 | Leaking transmission fluid and transmission was banging. Transmission lines had to be replaced. Cost to replace lines $418 parts and labor Oil seal was leaking and cost was covered under power train lifetime warranty | ||
| Jun 201797000 miUS $1500 | Driver's front axle was repaired under lifetime powertrain warranty at no cost Front brake calipers needed replacement | ||
| Jul 2018102000 miUS $2700 | Back rotors, caliper pins and back rear pads were replaced. Abs module was replaced | ||
| Chrysler Town & Country in Michigan, United States Nov 2009 - Sep 2011 | |||
| Sep 201131000 mi | minor rust in door seem | ||
| Chrysler Town & Country in New York, United States Jun 2009 - Jun 2013 | |||
| Sep 20095000 mi | Discovered part of the a/c drainage system installed backwards at factory causing condensation to back up into interior. After several trips to dealer, issue resolved, carpets replaced and received $2000 check from Chrysler, for my patience. | ||
| Jul 201011000 mi | Replaced the temperature sensor for the thermometer, it always said the outside ambient temperature was 10 degrees warmer that it actually was. | ||
| Jul 201118300 mi | While car was in drive, it lost power and engine shut off. Could not re-start. Towed to dealer replaced starter. | ||
| Chrysler Town & Country in Michigan, United States Jun 2012 - Jun 2018 | |||
| May 2013107400 miUS $466 | recharged A/C with dye | ||
| Jun 2014131000 miUS $100 | Evaporator replaced | ||
| Jul 2014132300 miUS $100 | Strut mount and bearing was replaced. Van is under warranty from Chrysler but with a $100.00 deductible. | ||
| Feb 2015149000 miUS $100 | During routine inspection (oil/filter work)dealer discovered that the power steering pressure pump hose was leaking. As the vehicle is under Lifetime warranty from Chrysler it only cost me $100.00. Don't know what the actual repair cost. | ||
| Dec 2015168000 miUS $190 | Had the tires rotated and balanced when the tire shop mechanic noticed that the front right inner tie rod was worn. Took the car to a repair shop who confirmed the issue and replaced the worn part. Also, the front end alignment was done. | ||
| Mar 2017194445 miUS $100 | The engine ran fine until put into gear, regardless from Park or Neutral. Complete Valve Body had to be replaced, item #RL078723AD plus all the transmission fluids and seals. | ||
| Jun 2017204000 mi | Replaced, sway bar links or bushings? | ||
| May 2018222000 miUS $100 | front wheel bearings, head gasket and rear wheel speed sensors (something to do with the Anti lock brake system). It only cost me the deductible as I had purchased the Chrysler Life Time Warranty back in 2010 for $2100.00. | ||
| Jun 2018240000 miUS $36 | Heater "Y" hose split open. Purchased a "T" fitting, hoses and clamps and one gal of anti-reeze. | ||
| Chrysler Town & Country in New York, United States Sep 2010 - Dec 2019 | |||
| Dec 201013000 miUS $55 | Power sliding doors open by themselves. Repaired by factory recall. remotes unlock doors intermittantly, new remotes ordered | ||
| Jan 201113000 mi | transmission downshifting by itself. solenoids bad in shifter assy, entire shifter assy replaced | ||
| Feb 201222000 mi | new keyfobs programmed, continuation of previous call when parts were ordered due to windows opening & doors unlocking by themselves | ||
| Nov 201334900 miUS $110 | car would not start, required jump start. drove to shop, battery bad, replaced battery | ||
| Oct 201661000 miUS $142 | battery dead, jumped to get car started, not holding charge. battery replaced | ||
| Chrysler Town & Country in Wisconsin, United States Jan 2012 - Feb 2019 | |||
| Feb 201261300 miUS $1600 | All dash lights illuminated, windshield wipers activated, and gauges zeroed out. Van was gutted and a bare wire was found above the third row seat near the seat belt harness. Problem solved (finally!) | ||
| Mar 2015134000 miUS $900 | Oil pan gasket, transimission pan gasket, upper manifold gasket replaced under lifetime powertrain warranty. Front wheel bearings replaced. | ||
| Apr 2016163000 miUS $178 | Van would lose power when put into drive after start. Remained running when put into reverse. Dealer replaced VLP sensor under lifetime powertrain warranty. Transmission filter and complete fluid replacement performed due to metal in pan. | ||
| Jun 2016168000 miUS $135 | A/C was intermittent and eventually blew warm air. Shop placed system under pressure and found no leaks. Added dye and recharged with 2.5 pounds of R134a. Blows cool air again. | ||
| Apr 2017189000 miUS $375 | Initially thought it was the starter, which is making noise at startup. Van would not start. Full electrical system check and replaced 3 yr old battery. On the road again...starter sounds the same. | ||
| Mar 2018214000 miUS $350 | Water pump replaced. | ||
| Chrysler Town & Country in New York, United States Jun 2012 - Jul 2012 | |||
| Jul 201255000 mi | Car shakes between 60 and 65MPH. Strong Antifreeze smell coming from the back of the engine. Shakes and vibrates between 60 and 65 MPH. | ||
| Chrysler Town & Country in Michigan, United States Nov 2008 - Aug 2020 | |||
| Apr 20094000 mi | Electronic compass was not working, wire had shorted, this was a topic of a recall. Passenger side power sliding door only opening manually (not power). Part ordered. | ||
| May 20096000 mi | Passenger side power sliding door fixed, part replaced | ||
| Jan 201031500 miUS $15 | Valve stem on tire broke while filling with air. This required replacement of valve stem. Since the TPMS sensor is attached to the valve stem, I will now have to return to dealer to replace TPMS sensor. | ||
| Aug 201127900 miUS $50 | Rattle in back, braking problem. TSB on brakes, but not the ones we had to replace. | ||
| Feb 201346800 miUS $550 | Check Engine lisght on, EGR Valve needed replacement. Cost was for EGR valve replacement and fuel system cleaning. | ||
| Nov 201355500 miUS $150 | Valve stem broke and had to replaced entire tire pressure sensor. | ||
| Jun 201463000 miUS $50 | Excessive oil consumption. Doing oil consumption test over next 3000 miles | ||
| Jul 201465000 mi | Sticking brakes right rear | ||
| Oct 201466300 mi | Excessive oil consumption | ||
| Nov 201467000 miUS $120 | Tire pressure sensor replaced - broken valve stem requires the whole Tpms to be changes | ||
| Dec 201468000 miUS $420 | Excessive oil consumption - changed rings, gaskets covered under warranty Coolant leak | ||
| Oct 201578000 miUS $900 | Bushings | ||
| Feb 201685000 miUS $180 | Rear wiper stopped working | ||
| Jun 2017105000 miUS $650 | Air conditioning not working - New condensor, coolant, and other AC items Bearings replaced (2 or 3) | ||
| Sep 2017107000 miUS $30 | Engine light went on - dealer said no problem reset light | ||
| Dec 2017109000 miUS $1000 | Rotors and pads. Pads replaced under warranty Engine light on | ||
| Sep 2018114000 miUS $1200 | New shocks and struts | ||
| Dec 2018120000 miUS $150 | Sticking brakes | ||
2009 Chrysler Town & Country 4dr Minivan, ext.
175-horsepower 3.3L V6 4-speed shiftable automatic FWD
| Chrysler Town & Country in Texas, United States Sep 2013 - Mar 2018 | |||
| Jun 2014167000 miUS $500 | Catalytic converter was replaced. | ||
| May 2015198000 miUS $150 | front wheel bearings. Replaced wheel hubs& Bearings | ||
2009 Chrysler Town & Country 4-door
6-cylinder automatic 2WD
| Chrysler Town & Country in Pennsylvania, United States Mar 2011 - Sep 2021 | |||
| Dec 201265000 miUS $370 | A small cooling system plastic part sprung a leak. 160 just for the part. | ||
| Nov 201375700 miUS $135 | Pads and rotors routine change, caliper (rear) was broken and needed to be replaced. | ||
| Oct 2015101500 miUS $900 | Right front wheel bearing | ||
| Jun 2016111000 miUS $185 | Pair of coolant hoses needed to be replaced Cam position sensor | ||
| Jan 2018126000 miUS $110 | Sway bar links replaced due to loud clunking going over bumps. | ||
| Aug 2018131000 miUS $423 | Rear condenser developed a leak. Had it blocked off with kit installed. | ||
| Sep 2018132000 miUS $411 | Coil pack replaced. Cylinder 5 misfire. Also plugs and plug wires. | ||
See TrueDelta's information for all Minivans
See TrueDelta's information for all Chrysler models.
