2014 Ford Fusion Ford Fusion 2014

We are 103,000+ car owners sharing real-world car information.

Join Us

2014 Ford Fusion repairs by problem area

Engine (18%)

Transmission and Drivetrain (5%)

Brakes and Traction Control (0%)

Suspension and Steering (9%)

Electrical and Air Conditioning (31%)

Paint, Rust, Leaks, Rattles, and Trim (21%)

Other (16%)

Chart based on 121 repairs.
See TSBs and recalls for the 2014 Ford Fusion.

2014 Ford Fusion repair cost distribution

$2500+ (0%)

$1000 - $2499 (1%)

$500 - $999 (4%)

$100 - $499 (25%)

< $100 (70%)

Worried about potential repair costs? An extended warranty can provide peace of mind.

Chart based on 76 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

2014 Ford Fusion 4dr Sedan

turbocharged 240hp 2.0L I4 6-speed shiftable automatic FWD

Ford Fusion in New York, United States
Sep 2015 - Feb 2022
Oct 2016

40300 mi

US $100
AC compressor clutch "blew up". Replaced with entire new compressor, included a recharge. 
Feb 2022

70000 mi

US $600
ball joint assembly 
Ford Fusion in Virginia, United States
Oct 2015 - Oct 2016
Mar 2016

32000 mi
Car would not start, battery dead, nothing was left on, and battery successfully recharged. 
Ford Fusion in Florida, United States
Jun 2014 - Sep 2017
Dec 2015

13000 mi
Replaced Worn Steering Wheel 
Mar 2016

22000 mi
Inside of sunroof was rusted, no evident leaks. 
Ford Fusion in Kansas, United States
May 2015 - Jun 2016
May 2015

12000 mi
Bad fuel pressure sensor. 
Ford Fusion in California, United States
May 2014 - Sep 2014
Jul 2014

2500 mi
Sync voice activated mic not working. 
Ford Fusion in Washington, United States
Nov 2015 - Nov 2016
Jul 2016

36500 mi
Front and rear leather seats started to show wear. Both front leather seatbacks were replaced along with rear leather bench. 
Ford Fusion in Pennsylvania, United States
Aug 2016 - Jul 2018
Jun 2017

51000 mi
Recall repair performed on front seat belt pretensioners 
Ford Fusion in Ohio, United States
Aug 2014 - Jan 2022
Mar 2018

27000 mi
Safety recall on Seatbelt Latch 
Jan 2022

74000 mi

US $2150
Driver side would only blow cold air. The climate control unit had a broken door so couldn't flip to hot air. Needed to pull out dash to replace $1100 part. 
Ford Fusion in Texas, United States
Feb 2014 - Jun 2018
Jan 2018

37000 mi

US $85
Dead Battery 
Ford Fusion in California, United States
Jan 2014 - Oct 2018
Aug 2017

43500 mi

US $109
Replaced swollen log nuts on all four wheels. 
Ford Fusion in California, United States
Sep 2015 - Sep 2016
Dec 2015

19000 mi

US $40
Driver-side headlight would flicker when turn signal was engaged. Dealer mechanics corrected the issue with a BCM update. Nearly a year later, the issue has never returned. 
Ford Fusion in California, United States
Jan 2014 - Jun 2022
Dec 2016

29000 mi
Firewall sound deadening in the engine compartment was falling apart. Replaced under warranty. 
Dec 2017

36000 mi
Recall performed for seatbelt pre-tensioner corrosion issue. Lubricant applied to affected cable. 
Ford Fusion in Oklahoma, United States
Apr 2014 - Dec 2015
Nov 2014

10000 mi
Backseat (probably inflatable rear seatbelt buckles) rattles at highway speed no matter the road surface. Couldn't replicate rattle in backseat. Window trim piece on driver's front unclipped (maybe broken). "Fixed" wrong trim piece. 
Mar 2015

15000 mi
Harsh shifting Trans, missing Rev matches, and occasional hesitation. Also radio volume increasing with no driver input. Supposedly dealer performed PCM software update and reflash of My Ford touch software. Volume:fixed, Trans: not fixed 
Ford Fusion in New Jersey, United States
Oct 2013 - Jul 2022
Apr 2015

13200 mi
Spring in the rear seat grab handle above the window broke and needed to be replaced. 
Ford Fusion in New York, United States
Sep 2013 - Oct 2016
Dec 2013

4000 mi
Radio stopped receiving HD broadcasts. 
Feb 2014

6000 mi
Various parts needed to be replaced inside transmission due to slippage in first three gears. Problem was aggravated by the cold weather. 
Mar 2014

7000 mi
HD radio stopped receiving HD broadcasts. 
May 2014

10000 mi
Popping sound coming from underneath driver's side of the car. The dealer tried refastening a panel underneath the car.  
Jul 2014

12700 mi
Popping noise from underneath left side of the car. Unable to pinpoint and fix. They tried a few more things. Will attempt again in October. 
Feb 2016

29000 mi
Rear left hub bearing replaced. 

Return to top

2014 Ford Fusion 4dr Sedan

turbocharged 240hp 2.0L I4 6-speed shiftable automatic AWD

Ford Fusion in Michigan, United States
Jul 2014 - Jun 2018
Dec 2015

19000 mi
Gas tank filler system needed to be replaced 
Ford Fusion in Michigan, United States
Feb 2014 - Oct 2018
May 2015

18300 mi

US $250
Noticed right rear ball bearing noise, took to shop. Found bent right rear rim, replaced bearings and re-aligned. Covered under insurance. Days later noticed front bearings needed to be replaced. Covered under warranty. 
Ford Fusion in Massachusetts, United States
Dec 2014 - Mar 2019
Dec 2014

5000 mi
Heated Steering wheel failed to get warm when activated. Heating controller replaced. Left headlight flickers when blinkers activated. Replaced BCM and reprogram to fix problem 
Jun 2015

9000 mi
Collision System disabled (sensor blocked). System worked fine after car restart. Service tech found code c1a67 and performed horizontal aim procedure. Banging noise coming from rear deck / trunk over certain bumps. Trunk torsion bars were banging against metal. Dealer added padding to prevent noise. Driver seatbelt would lock under medium acceleration & turns and not release easily. Tech replaced Pretensioner & Seat Belt - Part DG9Z 54611B09 
Nov 2015

16000 mi
Drivers seatbelt is sticking and not unlocking. Same part replaced as last time, I expect the problem will return again 
Jan 2016

7700 mi
Replaced rear passenger shock and mounting bracket because of metallic noise over potholes. Problem still present. 
Feb 2016

19700 mi
rattle when going over pothole. Amp loose in mounting bracket in trunk. 
May 2017

35500 mi
Drive axel boot seal leaking. Replaced seal with new one 

Return to top

2014 Ford Fusion 4dr Sedan

turbocharged 178hp 1.6L I4 6-speed manual FWD

Ford Fusion in California, United States
Jan 2014 - Jul 2022
Aug 2016

23900 mi
Air conditioner was not blowing cold. Dealer replaced parts. 
Feb 2017

28000 mi
Wire clip was loose in headliner, producing rattling noise. Fix covered under warranty. 
Ford Fusion in Texas, United States
Aug 2014 - Jun 2018
Dec 2016

41000 mi

US $177
Purge valve needed replacement due to delayed closing 
Nov 2017

56000 mi

US $50
Air intake was no longer affixed to turbo causing increased turbo whine and decreased performance requiring replacement of bolts-not covered under warranty  Water pump found to be leaking during service and replaced under warranty recall repairs to coolant sensor performed 
Jun 2018

61000 mi

US $250
Interior hood latch broken requiring replacement to allow for opening of hood 

Return to top

2014 Ford Fusion 4dr Sedan

turbocharged 178hp 1.5L I4 6-speed shiftable automatic FWD

Ford Fusion in California, United States
Sep 2015 - Oct 2018
Mar 2016

44000 mi

US $100
Power door lock remote not working 
Jun 2017

60000 mi

US $100
Replaced the purge valve assembly after check engine light revealed code P 01450. The Ford dealer fixed it while also doing the 60 thou mile service. Cost me the 100 dollar ESP care deductible. It was causing the car to have trouble starting after refueling. 
Dec 2017

70000 mi

US $100
Powertrain fault resulting in sudden deceleration. Required replacing existing part. UnderESP warranty to 100 thou miles 
Ford Fusion in California, United States
Aug 2016 - Dec 2016
Nov 2016

31000 mi
Bad fuel sensor caused car to die when idling 
Ford Fusion in Illinois, United States
Aug 2014 - Sep 2018
Sep 2015

26000 mi
Water pump was replaced 
Ford Fusion in Quebec, Canada
Dec 2015 - Jul 2018
Jun 2017

14260 mi
Recall for faulty part in seat belt tensionner 
Ford Fusion in Wisconsin, United States
Aug 2014 - Jun 2016
Feb 2016

17000 mi
Power steering (and traction control) went out one day. Dealer replaced a steering gear. 
Ford Fusion in Louisiana, United States
Jun 2014 - Jun 2022
Aug 2014

1200 mi
The right interior grab handle was defective from the factory and was replaced under warranty. 
Ford Fusion in Michigan, United States
May 2014 - Jan 2015
Jun 2014

1000 mi
Had a piece of interior trim replaced for an injection molding visual defect (splay). 
Aug 2014

5000 mi
The car wouldn't start because it wouldn't recognize any of my keys. The remote start function also failed. Body computer and wireless control module were both bad. 
Sep 2014

6000 mi
After the body computer and wireless control module were replaced, the car still didn't start after 1 day. Wires were pinched between the instrument panel and firewall, creating a short on the wake up signal wire. 
Ford Fusion in Maine, United States
Apr 2014 - Sep 2018
Dec 2015

34000 mi
Engine vibrating at idle, both in gear or in neutral. Chaffed wires in dash were suggested as the culprit. Fixing them didn't fix the vibration. Also, radio would not turn on during one trip. They thought the chaffed wires were responsible, and it hasn't happened again. 
May 2017

60000 mi

US $120
Replaced rear shocks due to rear end noise. 
Ford Fusion in New Jersey, United States
Aug 2014 - Sep 2016
Feb 2015

9000 mi
Bezel to drivers side exterior door handle fell of car. Needed replacement piece. 

Return to top

2014 Ford Fusion 4dr Sedan

175-horsepower 2.5L I4 6-speed shiftable automatic FWD

Ford Fusion in Maryland, United States
Feb 2015 - Jun 2018
Jun 2015

4000 mi
Headliner replace as per ssm 44717 
Ford Fusion in Michigan, United States
Mar 2017 - Feb 2022
Jul 2017

36200 mi

US $42
Driver's power mirror would not adjust left-to-right. Dealer charged $100 to diagnose the problem and wanted an additional $280 for the repair. I declined the estimate. I purchased a genuine Ford power mirror motor for $40 plus tax -- about 30% less than what the dealer wanted for the same part -- and spent half an hour installing it. 
Apr 2018

43000 mi
The torsion spring that holds the left rear grab handle up against the headliner popped out of its seat, allowing the handle to hang down. I used a screwdriver and a needle-nose pliers to push the spring tail back into its seat. The job took less than half an hour and cost me nothing. 
May 2020

62400 mi

US $200
Battery was replaced to address a slow cranking issue. 
Ford Fusion in British Columbia, Canada
Apr 2014 - Jan 2017
Jan 2015 Trunk hinges squeeked when opening and closing 
May 2015

31000 mi
Drivetrain repair 
Feb 2016

47640 mi

C $200
Rear air vents broken. 
Apr 2016

52700 mi

C $200
Fuel Door Housing Replaced 
Jun 2016

55180 mi

C $600
Overhaed Counsole replace because glasses holder door broke...stayed open, would not close. 
Jan 2017

68200 mi

C $135
Replaced battery. 
Ford Fusion in Minnesota, United States
Jan 2014 - Nov 2015
Feb 2015

11000 mi

US $25
Tire seal at rim was leaking air. Applied sealant. 
Ford Fusion in Ohio, United States
May 2014 - Apr 2017
Sep 2014

3000 mi
seat belt stuck------ replacement 
Ford Fusion in California, United States
Aug 2014 - Jun 2016
Aug 2015

5100 mi
Plastic trim around sun visor fell off; plastic peg that kept it in place fell off. 
Ford Fusion in New York, United States
Jul 2013 - Nov 2016
Aug 2016

58000 mi
Flat tie. Lug nuts were swelled. Wrench included with car did not fit lug nuts. Lug nets that swell so you can't change the tire yourself strikes me as a design defect. 
Nov 2016

61000 mi
Lug nuts were swollen, such that the wrench included with the car could not longer be used to remove them to change a tire. 
Ford Fusion in Virginia, United States
Aug 2015 - Sep 2015
Sep 2015

12000 mi
Engine lags @ times after stopping for traffic light.MECHANIC DROVE VEHICLE APPROX 20 MILES WITH ME AS RIDER IT DID NOT OCCUR. 
Ford Fusion in Michigan, United States
Jun 2014 - Jul 2017
Mar 2016

15000 mi
Engine icon came on. 1st reported as gas tank pressure leak. replaced a seal on gas tank. Engine icon came back. 2nd reported as wiring problem. 
Ford Fusion in Texas, United States
Mar 2015 - Oct 2019
May 2016

19600 mi
Change oil prompt will not reset, dealer is unable to repair. 
May 2017

32000 mi
seat tensioner failure? failure of door lock and latch right rear door covered under recall 

Return to top

2014 Ford Fusion 4dr Sedan

141-horsepower 2.0L I4 Plug-in Hybrid CVT FWD

Ford Fusion in Georgia, United States
Nov 2016 - Jul 2018
Dec 2016

20000 mi
Charging light port ring replaced under warranty 
Ford Fusion in California, United States
Nov 2013 - Jun 2018
Apr 2014

3500 mi
Reflash computer per TSB to remove check engine light. Replaced grab handle above front passenger door. Spring had snapped out and could not be reseated. 
Dec 2014

12000 mi
Driver's headlight flickers when headlights and turn signals on. Replaced BCM. Trim between windows on drivers door kept popping out, causing wind noise. Replaced driver and passenger trim. 
Ford Fusion in Alabama, United States
Apr 2014 - Jun 2016
Dec 2014

11000 mi
Emissions sensor replaced 
Ford Fusion in Virginia, United States
Jun 2014 - Feb 2019
Dec 2014

5000 mi
Seat motor started sounding different. Worked perfectly fine but I didn't want it to later go out after the warranty was over. I had the auto-easy-entry/exit option on. Ford replaced it the same day for free without hassle. 
Ford Fusion in North Carolina, United States
Apr 2014 - Feb 2022
Aug 2014

3000 mi
Sunroof wind noise. Dealer adjusted the sunroof. Repair was covered under warranty. 
Oct 2014

5300 mi
Musty smell when first turning on AC. Black piano trim around window switches on both rear doors were bowing up. Ambient lighting color would revert to ice blue after car was power cycled. Dealer installed new software to fix problem. High Definition (HD) stopped working in the radio function. Dealer installed new software to fix the problem. 
Mar 2018

34000 mi
Center console kept rebooting itself continuously. Dealer replaced the APIM under warranty. 
Sep 2021

65500 mi

US $45
Lug nuts were “swollen” and were replaced. 
Ford Fusion in New York, United States
Mar 2014 - Mar 2017
Aug 2016

35000 mi
seal in the gas door was was allowingfumes to escape. 
Ford Fusion in California, United States
Aug 2014 - Sep 2016
Jan 2016

32200 mi
Charge port for Hybrid battery was replaced 

Return to top

2014 Ford Fusion 4dr Sedan

141-horsepower 2.0L I4 Hybrid CVT FWD

Ford Fusion in California, United States
Jun 2014 - Jan 2018
Jan 2018

68000 mi

US $34
Nav, hvac, audio display keeps shutting off and shoeing error message. Dealer not able to diagnose or replicate intermittent issue 
Ford Fusion in Texas, United States
May 2014 - Jul 2017
Jun 2016

20000 mi
Passenger side blind spot module defect. 
Ford Fusion in Florida, United States
Aug 2013 - Jun 2022
Mar 2015

10000 mi
Defective cam shaft sensor Part was not in stock. 
Ford Fusion in California, United States
Nov 2013 - Jun 2018
Jun 2015

31000 mi
Daylight sensor for automatic headlights was not functioning. 
Ford Fusion in Minnesota, United States
Apr 2015 - Jun 2018
Mar 2016

35000 mi
R&R timing chain cover due to oil leak. 120V AC outlet in back was broken and not providing power to plugged in device. 
Ford Fusion in Illinois, United States
Dec 2013 - Sep 2021
Sep 2016

38000 mi

US $140
leaking shock absorber 
Aug 2017

51000 mi
Door interior handle and seat belt recalls done Previously replace shock absorber started leaking fluid 
Ford Fusion in Manitoba, Canada
Nov 2016 - Dec 2016
Nov 2016

59520 mi

C $350
120 V outlet in the rear cabin wasn't working when I plug in a laptop despite wattage within 150W limit (laptop was only 90W) also the power lumbar stopped functioning on the driver's seat 
Ford Fusion in Virginia, United States
Aug 2014 - Jun 2018
Dec 2014

6000 mi
When the car runs on the gas motor it vibrates thru the steering wheel, gas pedal, brake pedal.And makes a lot of noise from the engine. When it goes back to electric, it has no vibration & no noise. Dealer said this is normal for the hybrid 
Jun 2015

15000 mi
When the car runs in gas mode only the engine is very noisy and has a lot of vibration coming thru steering wheel, center console etc. The tech had me drive a new Fusion Hybrid & it did the same thing. Plan on getting rid of car ASAP. 
Oct 2015

21800 mi

US $45
Gas engine vibrates & makes excessive noise. Runs fine when in electric mode. 
Jan 2018

63000 mi
Recall on seatbelt tensioner 
Ford Fusion in New York, United States
Dec 2013 - Jan 2022
Oct 2015

49000 mi
Cruise Control button on steering wheel stopped working. The button was replaced under warranty. 
Apr 2017

113000 mi

US $397
The left front headlight burned out, necessitating a removal of the entire front end of the car (a design "feature" of all 2013 and beyond Fusions). I had both headlights replaced (might as well) and also changed the oil (it was due). 
Sep 2017

128000 mi

US $762
I originally went in to change my four tires, but Mavis Tire talked me into replacing my front struts. Turns out the car started making a terrible scraping noise. 
Oct 2017

129000 mi
Mavis Tire replaced one of their new struts from September that was making a scraping noise with a new Ford OEM strut. And the noise persisted. Freedom Ford confirmed that the correct strut had been installed by Mavis Tire, but that it was installed incorrectly. The top edge of the strut was scraping against the inside of the car's body. Ford re-installed the strut correctly and now, the car makes no noise. 
Ford Fusion in Virginia, United States
Nov 2013 - Jun 2022
Jul 2015

13300 mi
Check engine light was on. Diagnosis was done but no fault was found. The check engine light was reset. 
Sep 2016

25000 mi
The 110V 3-pin socket was too loose, did not hold the plug in. The socket had to be replaced. 
Sep 2017

40000 mi
The 110v AC outlet had problems with inverter. Dealer claimed this was due to plugging in an appliances rated more than the maximum the outlet can handle (150W). I do not recall using an appliance rated at more than 150W. Dealer fixed the issue under warranty. 
Ford Fusion in California, United States
Jan 2018 - Jun 2018
Jun 2018

130000 mi

US $229
Transmission leak. Removed bottom transmission case bolts, reseal with adhesive and install case bolts and refill transmission. 

Return to top

2014 Ford Fusion 4-door

6-cylinder hybrid automatic 2WD

Ford Fusion in Texas, United States
Sep 2013 - Jun 2022
Jul 2014

16000 mi
Rear passenger belt would not buckle and a new one had to be ordered and destroyed. 
Jan 2017

36700 mi

US $202
Back up camera went out 

Return to top

See TrueDelta's information for all Sedans
See TrueDelta's information for all Ford models.

2014 Ford Fusion Repair Histories

See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how frequently 2014 Ford Fusion problems occur, check out our car reliability stats.