Chevrolet TrailBlazer Chevrolet TrailBlazer

We are 103,000+ car owners sharing real-world car information.

Join Us

Chevrolet TrailBlazer repairs by problem area

Engine (32%)

Transmission and Drivetrain (11%)

Brakes and Traction Control (5%)

Suspension and Steering (22%)

Electrical and Air Conditioning (25%)

Paint, Rust, Leaks, Rattles, and Trim (2%)

Other (4%)

Chart based on 617 repairs.
See TSBs and recalls for the Chevrolet TrailBlazer.

Chevrolet TrailBlazer repair cost distribution

$2500+ (1%)

$1000 - $2499 (7%)

$500 - $999 (15%)

$100 - $499 (43%)

< $100 (33%)

Worried about potential repair costs? An extended warranty can provide peace of mind.

Chart based on 499 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

2021 Chevrolet TrailBlazer 4dr SUV

turbocharged 155hp 1.3L I3 9-speed shiftable automatic 4WD

Chevrolet TrailBlazer in Minnesota, United States
Jan 2021 - Jun 2022
Jan 2022

4000 mi
Vehicle was equipped with a plastic jack due to a shortage of the metal type in production. A metal jack was installed. 

Return to top

2009 Chevrolet TrailBlazer 4dr SUV

285-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Missouri, United States
Jun 2017 - Jul 2022
Jul 2022

98450 mi

US $620
Water pump failure - leaking 

Return to top

2009 Chevrolet TrailBlazer 4dr SUV

285-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Washington, United States
Jul 2017 - Jun 2018
Dec 2017

54000 mi

US $500
Four wheel drive selector motor that switches between 2 and 4 wheel drive. 

Return to top

2009 Chevrolet TrailBlazer 4dr SUV

281-horsepower 3.6L V6 6-speed shiftable automatic FWD

Chevrolet TrailBlazer in Tennessee, United States
Jun 2017 - Jun 2022
Feb 2018

106000 mi

US $250
Hub bearing was replaced 

Return to top

2008 Chevrolet TrailBlazer 4dr SUV

390-horsepower 6.0L V8 4-speed automatic AWD

Chevrolet TrailBlazer in Pennsylvania, United States
Oct 2017 - Dec 2017
Dec 2017

115000 mi

US $150
ABS encoder failed 
Chevrolet TrailBlazer in Washington, United States
Jul 2014 - Jan 2022
May 2016

95900 mi

US $3335
hvac control head, temp LH and door actuator all failed. Had to pull the complete dash apart to get to the pieces and fix. System had heat on one side and ac on the other. 
Feb 2017

113000 mi

US $1315
Time for complete brake job, rotors replaced, new pads, complete flush of system. 
Mar 2017

112711 mi

US $274
Left Front hub went out. When you replace the headlights on the Trailblazer SS, you need to also go ahead and replace the Headlight relay unit. They seem to go hand in hand with failing. 
Oct 2017

123000 mi

US $672
Regular synthetic oil change and replacement of all O2 sensors. 
Mar 2018

130000 mi

US $144
Basic Oil change and safety check of entire auto before the wife took it on a winter road trip with a friend. 
Jun 2018

137000 mi

US $444
Windshield was hit by a rock, cracked, had replaced with GM certified part. 

Return to top

2008 Chevrolet TrailBlazer 4dr SUV

300-horsepower 5.3L V8 4-speed automatic RWD

Chevrolet TrailBlazer in Texas, United States
Jun 2013 - Jun 2018
Nov 2013

58000 mi
AC Delco battery wouldn't charge. 
Dec 2014

65000 mi

US $176
Alternator started "chirping". 
Jun 2015

68000 mi

US $460
Shock and strut replacements. 
Oct 2016

84000 mi

US $120
Cabin fan wouldn't stop running. Electronic regulator was replaced. 

Return to top

2008 Chevrolet TrailBlazer 4dr SUV

285-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Puerto Rico
Oct 2013 - Jun 2018
Dec 2013

71000 mi

US $1700
Bushings, tie rods, 4 new tires, leaking rack and pinion 
Sep 2015

90000 mi

US $300
A/C does not activate. Replacement of thermostat was done. 
Dec 2016

101000 mi

US $200
Tie rod 
Jun 2017

107000 mi

US $40
Worn rear pads 
Chevrolet TrailBlazer in Texas, United States
- Feb 2011
Dec 2009

28802 mi
replaced back door weather stripping on both sides 
Jan 2010

32128 mi
replaced passenger seat. stitching was coming apart 
Aug 2010

42115 mi

US $429
replaced air injection pump and pump relay 
Feb 2011

45791 mi

US $250
replaced steering position sensor bearings went bad on alternator. replaced alternator 
Chevrolet TrailBlazer in Texas, United States
Dec 2015 - Jun 2018
Jul 2017

237000 mi

US $500
exhaust manifold was cracked and leaking a substantial amount causing a reduction in engine compression. 
Apr 2018

254000 mi

US $80
ac seemed warm, check revealed pressure was a little low, no leaks were found using pressure test and sniffer test 
Chevrolet TrailBlazer in Texas, United States
Feb 2014 - Dec 2017
Apr 2014

76300 mi

US $126
Cylinder 3 is misfiring 
Aug 2016

110000 mi

US $186
Went through full diagnostics. No parts were replaced other than those for regular maintenance. It was determined that the sensors were bad and none of the tires had issues. Decided not to replace sensors due to age of car and the fact that it would still pass state inspection. This was a computer issue- communication with sensors 

Return to top

2008 Chevrolet TrailBlazer 4dr SUV

285-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Texas, United States
Mar 2007 - Dec 2021
Oct 2007

50 mi
On-Star did not work. Software was re-installed. 
Oct 2012

37000 mi
Warranty repair. Front differential (4WD) pinion seal was leaking. It was replaced. This was the first repair on the truck in the 5 years that I have owned it. First time that has ever happened. 
Jun 2013

43000 mi

US $461
Right front wheel hub bearing went bad and was replaced. 
Sep 2013

44000 mi
Pinion seal on front differential went bad, again. This was re[paired by dealer 11 months ago, and the repair failed. 
Feb 2015

55000 mi

US $227
Right front passenger power window failed in the "window down" position 
Aug 2017

73000 mi

US $880
Electronic control module failed, and was replaced. 
Chevrolet TrailBlazer in Texas, United States
Dec 2011 - Jun 2018
Jan 2015

120000 mi

US $200
a.c. would just stop cooling. temp gauge would stop working. sometimes on restart, everything would work again. completely intermittent 
Jan 2016

136000 mi

US $500
Bearings and right front drive hub worn out and needed replacementreplacement. Drive hub replaced. 
May 2016

152600 mi

US $120
Fluid change in four wheel drive differential, etc. Slight leak from gasket/seal . Was repaired quickly 
Nov 2016

169300 mi

US $300
O2 pump, switch, etc all reported faulty. Pump was replaced as was relay, and check valve 
Jan 2017

169200 mi

US $670
Engine light on, found to be defective o2 sensors, also found leaky low pressure a.c. Switch. 
Chevrolet TrailBlazer in New Mexico, United States
Mar 2011 - Sep 2015
Sep 2014

66000 mi

US $800
Traction Control Service light had been on for 6 months. Dealer replaced steering wheel position sensor. Driver washer sprayer failed, replaced by dealer. 
Jan 2015

63100 mi

US $320
Dealer replaced ignition switch to rectify intermittent no start conditions 
Feb 2015

72000 mi
Dealer sent techs to my house for no start. They diddled with things and said it might be starter connector or starter. Just jiggle this wire .... Another no start. Techs back at the house. Now they recommend replacing the starter connector. Maybe the starter too, not sure. Manager does not call back 
Apr 2015

72200 mi

US $300
Starter was replaced. 
Chevrolet TrailBlazer in Nova Scotia, Canada
Mar 2011 - Mar 2017
Jun 2014

49600 mi

C $250
worn left front wheel bearing 
Sep 2014

51460 mi

C $194
replaced rusted power steering cooler 
Mar 2015

54560 mi

C $420
replaced lower left tie rod, $250 replaced rear diff u-joint, $170 
Jun 2015

55800 mi

C $475
although only the rack to cooler line was leaking I found it judicious to replace all three lines. 
Chevrolet TrailBlazer in Ontario, Canada
Dec 2012 - Dec 2017
May 2013

71300 mi

C $635
Replaced steering wheel position sensor 
Jan 2014

75240 mi
DRL and low beams did not work. Replaced headlight switch. Low beams on headlights did not work. Replaced headlight switch. First switch was faulty. 
Aug 2015

82460 mi

C $149
Lights wouldn't shut off. Changed low light relay. 
Sep 2015

82460 mi
Steering arm Ball joints 
Jan 2016

74340 mi
Car would not start in cold weather. Bad cell in battery. Changed battery. Problem fixed. 
Sep 2016

84940 mi

C $650
Front windshield wiper motor 
Chevrolet TrailBlazer in Ohio, United States
May 2011 - Mar 2012
Sep 2011

63000 mi
fan rheostat was faulty---it was burning! 
Chevrolet TrailBlazer in New Jersey, United States
May 2011 - Nov 2020
Jul 2011

23300 mi
Front bumpeer cover was loose on one side. Noticed when I cleaned car for the first time. Dealer replaced clip that may have been damaged by previous owner 
Oct 2012

34300 mi

US $133
Battery died while parked overnight. Checked charging system and all was OK. Replaced battery. 
Nov 2014

49600 mi
Horn was inop - replaced switch mechanism in steering wheel 
Dec 2016

64000 mi

US $150
Bad ignition switch 
Nov 2017

69000 mi

US $375
Wheel Bearing and hub assembly to correct stabilitrak error codes 
Jun 2018

72000 mi

US $275
Bad sensor for air pump 
Chevrolet TrailBlazer in Kentucky, United States
Apr 2013 - Apr 2017
Aug 2013

78900 mi

US $180
I had multiple problems. The most serious one was a broken tie rod.  I still have an electrical problem that affects the stabilizers, speed, and brakes. 
Jun 2014

93000 mi
This intermittent electrical problem with the stabilizers, brakes and speed has not been resolved after repeated trips to a dealer. No codes show and the dealer hasn't been able to identify the problem. This is the fourth try to fix it. 
Aug 2014

95000 mi

US $100
Problems w/brakes, acceleration, stabilitrak: vehicle would jerk, limp along w/deceleration. Same problem as before. Suspected electrical problem. Smoke came from L/F wheel base and tire would grab. Had to be towed. Replaced wheel bearing. Same problem as previous visit but worse. Replaced the other front wheel bearing and pinion seal. 
Oct 2014

95800 mi

US $850
Same problem as previous August visit. Vehicle unsafe to drive as problem continues to worsen. New re-wiring harness/brake module, seems to have fixed problem. 
Mar 2016

119000 mi

US $310
Needed a thermostat 
Apr 2017

139000 mi

US $900
clamp for front bumper broke on one side, couldn't order piece so the bumper cover had to be replaced 
Chevrolet TrailBlazer in Maine, United States
Nov 2014 - Jun 2018
Mar 2015

56000 mi

US $15
fan belt squeal at startup and when cold. Replace idler pulley, fixed noise. 
Apr 2015

56200 mi

US $18
Both sway bar end links snapped within a few days of each other. Replaced front end links. 
Jun 2015

57000 mi

US $86
Replaced both rear shocks. The OEM shock sleeves were rusted through. 
Apr 2016

64200 mi

US $232
Power steering lines rusted through going through a rubber grommet. Bad section cut out and a new section of line patched in. 
May 2017

71000 mi

US $225
Condenser was leaking. Replaced the condenser, orifice tube and evaporator 
Nov 2017

75500 mi

US $720
Replaced cracked exhaust manifold Both front lower ball joints replaced. Caused non uniform wear to tires 
Chevrolet TrailBlazer in California, United States
Dec 2015 - Mar 2018
Dec 2016

95000 mi

US $200
Steering position sensor was throwing trouble light. Changed sensor and recalibrated. First replacement sensor was defective so had to install a second one. Took a couple of days for repair to be completed. 
Chevrolet TrailBlazer in Minnesota, United States
Jan 2013 - Jan 2015
Nov 2013

88900 mi

US $900
vehicle had a exhaust manifold crack. repair cost 900, was quoted 692. It wasn't till after that that I was told about the exhaust bolts that are difficult to remove. 
Aug 2014

97000 mi

US $600
leaking front axel seal. broken sway bar bolts. it was doing nothing but it was not very noticable with the exception of slightly loose steering, no clunking. 
Chevrolet TrailBlazer in Nebraska, United States
Oct 2014 - Dec 2016
Oct 2016

118500 mi
Exhaust manifold cracked 
Chevrolet TrailBlazer in British Columbia, Canada
Dec 2013 - Dec 2014
Nov 2014

116720 mi

C $950
Another cracked exhaust manifold. 

Return to top

2007 Chevrolet TrailBlazer 4dr SUV

395-horsepower 6.0L V8 4-speed automatic RWD

Chevrolet TrailBlazer in Michigan, United States
Jul 2012 - Jul 2012
Jul 2012 Spun #6 rod bearing. There is a design issue with the GM oilpan which starves the #6 rod bearing on 'hard' launches. Several occurrences can be found on the online forums. Avoid these vehicles if you enjoy spirited driving. 

Return to top

2007 Chevrolet TrailBlazer 4dr SUV

395-horsepower 6.0L V8 4-speed automatic AWD

Chevrolet TrailBlazer in South Carolina, United States
Nov 2010 - Feb 2011
Jan 2011

51000 mi
Driver's power window stuck down, would not roll back up. 
Feb 2011

52000 mi
Misc. random intermittent failures and warning lights. Finally set a code P1682. Had dealer replace ignition switch. Appears to be a common problem with the Trailblazers. 
Chevrolet TrailBlazer in New Jersey, United States
- Oct 2007
Oct 2007

8000 mi
transmission failure 
Chevrolet TrailBlazer in Michigan, United States
Jan 2017 - Jan 2018
Oct 2017

191000 mi

US $389
loosing transmission fluid, no power repair the lines leading to the transmission, had the pump replaced. 
Chevrolet TrailBlazer in Saskatchewan, Canada
Apr 2017 - Jun 2018
Nov 2017

106020 mi

C $45
Bad positive cable and terminal on the battery. 
Jan 2018

106640 mi

C $200
Power steering hoses were leaking. Replaced Power steering hoses 
Jun 2018

107880 mi

C $600
Replace AC compressor and lines 

Return to top

2007 Chevrolet TrailBlazer 4dr SUV

302-horsepower 5.3L V8 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in South Dakota, United States
Jan 2010 - Mar 2014
Mar 2010

31000 mi
Windshield washer nozzle damaged/plugged up. Control module for driver's door faulty. No power window, mirror or lock. Part on national back order. No estimate of when part will be available. 
Apr 2010

31500 mi
Electrical control module arrived at dealer after being on nationwide backorder for several weeks. Part replaced and problem fixed. 

Return to top

2007 Chevrolet TrailBlazer 4dr SUV

291-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Indiana, United States
Apr 2011 - Dec 2016
May 2011

42800 mi
Taillight assembly let water in; right tail light burned out and was 1/2 full of water. 
Apr 2012

55000 mi

US $300
Fuel system problem - fuel gauge reading E at all times regardless of fuel level in tank & Check Engine Light Rear hatch glass will not lock. 
Jun 2013

86000 mi

US $1000
Repair/replace 4 corners shock, springs, struts, and related hardware. 
Jun 2014

100000 mi

US $900
Water pump bearings failing; new water pump. Otherwise, normals 100k tune-up 
Chevrolet TrailBlazer in Washington, United States
Feb 2014 - Jun 2021
Aug 2014

110000 mi

US $300
Window regulator, happened to be the Front Passenger, broke. Not uncommon on vehicles of this vintage. Cheaper to fix than the same issue on a BMW sedan! 
May 2015

150000 mi

US $1500
brake pads and rotors were showing serious signs of wear. It still stopped. about 500 dollars and the brakes are like new, including "adjusting" the rear parking brake shoes.(parking brake works with shoes inside of hat-section in rear rotors). Not the strongest design, but adequate for protecting the parking pawl when used correctely 
Chevrolet TrailBlazer in Alabama, United States
Mar 2011 - Sep 2015
Jun 2015

126000 mi

US $30
Replaced Thermostat 
Chevrolet TrailBlazer in South Carolina, United States
Dec 2012 - Sep 2017
Jul 2014

101700 mi
Gas gauge went from 1/4 tank to empty with gas still in tank 
Jan 2017

97700 mi

US $30
bad evap purge valve solenoid. Replaced part 
Chevrolet TrailBlazer in Georgia, United States
Jan 2010 - Jun 2013
Dec 2010

97000 mi

US $115
Replaced idler pulley. 
Mar 2011

103000 mi

US $90
Replaced drivers side window regulator.  
Jun 2013

127000 mi

US $200
Window regulator for drivers window 
Chevrolet TrailBlazer in Texas, United States
Jun 2010 - Jun 2014
Mar 2010

37000 mi

US $150
Gas gauge stopped working. Replaced fuel sending unit in gas tank. 
Oct 2011

61000 mi

US $30
Vapor canister vent solenoid replaced.  
Feb 2014

95000 mi

US $130
Front passenger door window regulator broke (cable failure). Replaced regulator. 
Chevrolet TrailBlazer in Saudi Arabia
Jun 2013 - Jul 2013
Jul 2013

19840 mi

﷼800
High speed vibration when braking. Found calipher on front left hand side seized and rotor warped. Both front brake disc and pads replaced. Vehicle only has 32,000 kms. 
Chevrolet TrailBlazer in Texas, United States
May 2013 - Jun 2022
Aug 2013

25700 mi

US $250
Replace the Alternator @ $250 deductable under Carmax warranty after noticing noise coming from it while driving. 
May 2015

43000 mi

US $250
Replaced Air Pump Assembly and Relay. Replaced left front tire pressure sensor. Replaced Driver's Side Washer Nozzle. 
Dec 2016

60000 mi

US $275
Replaced leaking condensor and recharged AC. Replaced Serpentine Belt tensioner with bad bearings. Reattached drivers seat cover to seat that was coming loose. 
Jan 2017

US $600
Had to install new calipers on front brakes. Had to replace tie rod ends on front suspension. 
Jan 2018

73000 mi

US $250
Replaced Motor Mounts Cleaned all water drains in doors etc. Replaced faulty tire pressure sensor and reset warning light. 
Mar 2018

73000 mi

US $250
Carmax Warranty Repair $250 Deductable. Traction Control Warning Light on and they replaced steering wheel position sensor. They then updated the trucks traction control firmware through a local Chevy dealer after the repair. Light is off now. Problem solved. 

Return to top

2007 Chevrolet TrailBlazer 4dr SUV

291-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Michigan, United States
Feb 2010 - Dec 2012
Jun 2011

74000 mi

US $100
Vehicle would not start in 20+ attempts. Only after connecting jumper cables would it start. Drove right to the dealer. Low voltage detected at ignition. Ignition replaced. Problem fixed. 
Chevrolet TrailBlazer in New York, United States
May 2012 - Mar 2016
Sep 2013

73000 mi

US $150
Rear washer motor turned on intermittently - drained washer tank then SCREAMED, even with engine off. Disconnected. Then everything dead. Had towed to dealer. Previously owner installed aftermarket remote starter - removed - car fine now 
Oct 2013

73700 mi

US $320
Rear wheel bearing replaced 
Chevrolet TrailBlazer in Michigan, United States
Feb 2016 - Dec 2016
Sep 2016

81000 mi

US $600
Wheel bearings worn out. Front hub assembly, both sides. Passenger side outer tie rod was a little bit loose also, so both sides were replaced. 
Dec 2016

85000 mi

US $118
Dealer had to replace rear hatch window wiper arm, blade, and lock nut. 
Chevrolet TrailBlazer in Colorado, United States
Feb 2014 - Mar 2016
Sep 2015

109000 mi

US $100
Full evac and replacement of R134a 
Chevrolet TrailBlazer in Virginia, United States
May 2014 - Apr 2015
Jun 2014

97000 mi
Apparently these models have had issues with the main fuse block under the hood. Sometimes the car just would not start at all. It took a savvy mechanic to figure it out. All connections needed to be reset in the fuseblock. 
Chevrolet TrailBlazer in Pennsylvania, United States
Dec 2010 - Aug 2015
Feb 2011

85000 mi

US $200
Stabilitrak light intermittently on. Dealer in VA said system needed to be "reprogrammed" but recurred months later. New dealer in PA said steering position sensor, but part was out of stock. Returned for replacement with no problems since. 
Mar 2011

86000 mi

US $60
Noise (metallic scraping) was found to be rust and brake dust buildup on rear caliper. This was determined after demanding a technician go for a drive with me so they could hear what I heard. No noise since. 
Apr 2011

88000 mi

US $2
Engine light intermittently on. Dealership could not find code. Purchased my own code scanner and found two codes pertaining to EGR and TPS (low voltage). Cleaned throttle body at home and cleared codes. Vehicle runs better than ever. 
Aug 2011

93000 mi

US $530
Transmission cooler lines replaced after noticing transmission fluid dripping from underside (no abnormal mechanical operation). All four lines were corroded; two failed. Replaced all four lines to ensure no future problems. 
Apr 2012

103000 mi

US $140
Front driver side hub bearing began "roaring." It became progressively worse, especially after driving through a rain storm. 
Jun 2012

104000 mi

US $130
Fuel level sensor causes gauge on cluster to read erratically -- known problem; have TSB from GM. Paid half of repair cost. 
Apr 2013

113300 mi

US $170
Grinding/rubbing noise when turning. Replaced passenger side wheel hub. 
Jan 2014

112300 mi

US $500
Rear hatch glass exploded while driving on 35mph two-lane road. Temps below freezing; rear defrost on. After some research, it seems to be common - albeit not often discussed - with GMT360 vehicles. 
Dec 2014

137000 mi

US $175
All four ball joints required to pass PA state inspection. Over $1000 at the dealer. I bought the ball joints and rented a press and spent a weekend repairing myself for less than $200. 
Aug 2015

150000 mi

US $3500
Camshaft actuator sensor code was actually due to no oil in engine. No check engine oil light or anything. Rod knock began; determined spun rod bearing. Engine toast. Traded vehicle. 
Chevrolet TrailBlazer in New Mexico, United States
Jan 2009 - Jun 2018
Feb 2009

30015 mi
fuel gauge erratic-replaced sender in fuel tank chev. emblem in grille de-laminating Replaced both under warranty-no charge 
Jul 2012

71200 mi
both gas shocks were replaced for the rear liftgate airbag service required light came on 
Nov 2012

77800 mi

US $40
right front low beam headlamp replaced 
Dec 2013

93000 mi

US $62
2nd left headlight in 13 months 
Jun 2015

106000 mi
passenger front window wont roll up 
Dec 2015

114000 mi

US $1500
Aamco replaced the cat converter and both o2 sensors even though there was no code set for them (per dealer, autozone) This fixed the problem I had of no power and seemingly trans slipping. I suspect it was only a disconnected trans vac hose 
Chevrolet TrailBlazer in Massachusetts, United States
Sep 2013 - Oct 2013
Oct 2013

97000 mi
tire pressure monitor needed to be replaced. dealer covered all costs 

Return to top

2006 Chevrolet TrailBlazer

Engine not specified

Chevrolet TrailBlazer in California, United States
Jun 2010 - Jun 2011
Jul 2010

51000 mi

US $600
RESISTOR PACK FOR DASH AIR. FUEL SENDING UNIT. I AM REPLACING THE WINDSHIELD TOMORROW. STRUTS WENT BAD AT 37000 MILES. THE CHEVY DEALER WOULD NOT REPAIR EVEN THOUGH IT WAS ONLY 1000 MILES AFTER WARRANTY EXPIRED. 
Chevrolet TrailBlazer in Pennsylvania, United States
Sep 2009 - Mar 2010
Oct 2009

26000 mi

US $258
My truck would make a loud noise when it was sitting still and when I would drive it. The mechanic said the idler pulley was broken and needed to be replaced. 

Return to top

2006 Chevrolet TrailBlazer 4dr SUV, ext.

300-horsepower 5.3L V8 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Pennsylvania, United States
Dec 2008 - Sep 2017
Mar 2009

19000 mi
Rust on Trailblazer was where the outer doorskin was folded over inner doorskin on the bottom inside of rear liftgate. Paint was bubbled due to rusting.  
May 2009

21000 mi
I discovered that a piece of foam between the AC condenser and Radiator had not been installed on the passenger side (both top and driver's side had been).  
Jul 2009

23000 mi
I noticed florescent green fluid under front bumper. After further inspection found it was coming from lower passenger side of the A/C condenser. Took vehicle in to confirm and also for emission, safety inspec. and oil and filter change. 
Aug 2009

23000 mi
Air conditioner condenser ordered and then installed. 
Jul 2010

34500 mi
Noticed the steering rack was leaking when I replced anti-sway bar bushings with urethane bushings. Dealership inspected, ordered parts and replced two weeks later. 
Mar 2011

41000 mi
Fuel level sending unit was faulty. Replaced. 
Jul 2011

46000 mi
Car failed safety inspection due to leaking RF shock. I replaced both shocks as I had bought heavier duty ones 2 years ago. Needed to be aligned. Shop that did an alingment 1 week earlier when 4 new tires bought did alignment gratis. 
Dec 2011

51000 mi
Driver Door Module needed to be replaced. Windows quit working, 4WD quit, panic sound went off for no reason. Had to disconnect battery to get car to start to drive to dealership. Repaired next day and it needed new battery. 
Sep 2012

61000 mi
Left front wheel bearing replaced. Noticed whining and grinding when turning right. 
Sep 2013

73000 mi
Friday Sept. 13 Starter failed completely. Called AAA and had car towed to dealer. Technician tapper starter and got car to start. Ordered starter from Carquest (lifetime)installed monday Sept 16. 
Oct 2013

73500 mi

US $4
Oct. 9, Vehicle would not stop after pulling off overlook on I-64 on Blue Ridge. could not get key out or shift into gear. Called AAA then decided to look in fuze box. Found ign A fuze blown (40 amp)finally removed 60 amp ABS fuze and pu 
Apr 2014

79300 mi

US $40
Paasenger Front bearing was making noise. Called salesman who sold me an aftermarket warrantee to see if covered, said yes. Service mgr said no. Fixed at home same night with a moog bearing and hub. $154 
Aug 2014

82400 mi

US $73
Went to pick up Travel Trailer. Car would not start or turn over. Kept blowing Ing A 40 amp fuze. Had it towed. Bare wire under fuze box. Repaired. I Had this happen summer 2013 but got it going. Had dealer check did not find why. 
Jan 2016

79700 mi
CEL came on coded for Bank 1 Sensor 1 O2 sensor. Removed, cleaned and put back in. If this doesn't work will replace. 
Feb 2016

96100 mi

US $40
Cleaning O2 sensor in January did not work. I replaced O2 sensor and CEL went off. 
Aug 2017

109000 mi

US $60
During annual safety inspection it was discovered that the parking brake needed to be adjusted in order to work. 

Return to top

2006 Chevrolet TrailBlazer 4dr SUV, ext.

291-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Kentucky, United States
Nov 2014 - Oct 2017
Mar 2015

86000 mi

US $262
Water Pump shaft was bent causing a bad vibration and the fan was shaking... 
May 2015

86800 mi
brake light switch replaced 
Sep 2015

91000 mi

US $478
Tested cause Track stability light was coming on...Diagnosed as ABS Brake Control Module.. 
Jan 2016

86700 mi

US $325
Still having issue with track stability light coming on quite often... Was told that it could be a module that is in the steering wheel column.. But since I am on a very limited income, Disabled due to two failed back surgries.. I can't fix. 
Apr 2017

102000 mi

US $307
Catalytic Converter became stopped up lost most of power... This just after getting Spark Plugs put in.... 

Return to top

2006 Chevrolet TrailBlazer 4dr SUV, ext.

291-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Colorado, United States
Feb 2015 - Jun 2018
Feb 2015

154000 mi

US $35
I took vehicle in for ps fluid leak and was told there were repairs totaling 3,500. necessary on the steering system, front suspension and A/C. Also needs sensors for ABS. Limited use, adding ps fluid every couple days. 
Sep 2015

164000 mi

US $80
Replaced water pump. Still driving vehicle, adding power steering fluid as necessary. 
Jun 2016

166000 mi

US $200
Bad bearing in water pump Replaced t-stat and radiator while apart. 
Chevrolet TrailBlazer in West Virginia, United States
Oct 2014 - Jun 2022
Oct 2014

183000 mi

US $400
Right wheel bearing and new rain sensor/solar windshield which was cracked when bought. 
May 2015

185000 mi

US $46
Plastic side cover for power seat. Crappy plastic that cannot be glued or easily repaired. New one will likely be the same, however, I will re-enforce prior to installing. 
Oct 2015

187200 mi

US $32
Replaced driver side power seat cover. Took a while to find my hot glue gun to assure the buttons would not pop out after installation. Once you seat the cover clip, you won't get it back out without breaking the cheap plastic. Bad design. 
Apr 2016

190200 mi

US $15
Just thought this was note worthy. The Service Engine light came on. I first check fluids. Surprisingly, I found the oil was just over 2 qts down! I cannot understand why no oil or other light came on long before this. Very, very slow leak. 
Oct 2016

191200 mi

US $40
10/10 took to replaced back tires as they wore thin only in the center-Fortera. But also diagnosing for where the oil is slowly leaking (only at high speeds) Drips under the middle of the motor sometimes? No exhaust smoke detected. After several mechanics have looked at the issue of oil 'sometimes' being over a quart low after a long trip, then city driving, the last mechanic believes it is just bypassing the rings at Interstate speeds. 
Dec 2016

192000 mi
Engine light code read by AutoZone: "too cold" condition (bad temp sensor?). But when the electric driver seat forward/back position button started working again(upon a start), the light went out. Issue over a month, no restriction found. 
Mar 2017

193000 mi
Sensors seem to produce false display messages indicating repairs needed that are not. The secondary service engine icon comes on for unknown reasons and goes back off randomly. So there is no way to determine its origin. The last code check said the engine coolant was not hot enough... Makes no sense unless it would produce some signs that the sensor was bad, its not. 
May 2018

198000 mi

US $126
Replaced Power Steering Cooler and front bumper cover clips. plus two bolts that broke upon removal. Upon reassembling, I found that a part of the bumper cover that was lying loose and appeared to have slid apart was actually broken. It is a part that clips inside the bumper cover and is held by 5 tabs. All tabs were completely separated from the bumper. I am using a plastic glue compound and hoping it allows me to re-install the cover after drive testing the car tomorrow. I have never seen clamps on the power steering hoses such as these. I could not hammer them back into place after replacing the cooler. They refused to slide over top of the line. I could have taken the line back off, put the clamps on the line, then try to slide them on that way. But it was just too hard and the space was too limited for me. So I just used a standard clamp and can only hope it holds under the pressure of the system. 
Jul 2019

202000 mi

US $400
Actually no work was done on the transmission (needs kit, missing gear 3 and gear 4). A tree fell in the lot across the hood and left mirror. Replaced mirror. Hood not available here and too expensive to ship. Added new battery, windshield wipers and drove home. Will update ... 
Chevrolet TrailBlazer in Texas, United States
Mar 2010 - Jun 2011
Apr 2010

77000 mi

US $230
right front hub bearing worn, replaced under extended warranty. 
Chevrolet TrailBlazer in Oregon, United States
Nov 2009 - Mar 2015
Oct 2010

55500 mi

US $450
Sounded and felt like TB was stuck in 4 wh drive. Took it to dealer; it had a "bad" hub. Was replaced under my extended warranty within a day and is back to running smooth and quiet. Back passenger door was creaking when opening and closing. My daughter noticed it getting worse. Had it looked at when car was in for another repair. Dealer ordered a new "door strap". Took 3 days to come in. Installed this morning. 
Mar 2012

70000 mi

US $100
Bad hub on passenger front. 
May 2013

87000 mi
Engine light was on. Took it in for diagnosis. Emissions problem...need to find a leak in a hose likely since nothing was obvious. Still need to have this repair done. Only diagnosis was done. 
Jun 2013

88000 mi

US $274
Am really not sure if this was engine or transmission 
Apr 2014

103700 mi

US $132
front differential pinion seal was leaking 
Chevrolet TrailBlazer in Kentucky, United States
Jan 2010 - Jun 2018
Dec 2014

155000 mi

US $230
replace leaking water pump and fan clutch 
Sep 2016

184000 mi

US $2951
Transmission had tcc slip and lockup problems due to age and mileage.Unit was replaced with GM service replacement transmission assembly. Transmission still had tcc slip after replacement.Throttle body with throttle position sensor was replaced next.Now all tcc problems have been repaired 
May 2018

213000 mi

US $60
replaced weak thermostat 
Chevrolet TrailBlazer in Minnesota, United States
Feb 2017 - Feb 2020
Oct 2017

108000 mi

US $250
Fuel pump replaced sending unit was going bad 
Chevrolet TrailBlazer in Washington, United States
Mar 2016 - Aug 2016
May 2016

99400 mi
Transmission would not shift into 3rd. 

Return to top

2006 Chevrolet TrailBlazer 4dr SUV

395-horsepower 6.0L V8 4-speed automatic RWD

Chevrolet TrailBlazer in Florida, United States
Sep 2015 - Dec 2016
Dec 2016

69000 mi

US $650
Tailgate monitor 
Chevrolet TrailBlazer in Florida, United States
Feb 2008 - Sep 2013
Jul 2008

35000 mi
Ignition switch failure. 
Nov 2009

46100 mi

US $360
struts replaced 
Nov 2010

54000 mi

US $337
Ignition switch had to be replaced (2nd time). Car would not start at times. The rear brake pads had to be replaced and rotors machined. 
Apr 2012

61200 mi

US $220
Alternator was only charging at 13.2 volts causing the battery to drain. 
Sep 2013

66000 mi
There was a constant drain on the battery and the dealer could not find the source or fix. 

Return to top

2006 Chevrolet TrailBlazer 4dr SUV

395-horsepower 6.0L V8 4-speed automatic AWD

Chevrolet TrailBlazer in Ohio, United States
- Jul 2008
Jun 2008

45000 mi
Fuel pump went out 
Jul 2008

47000 mi
Computer went out 
Chevrolet TrailBlazer in Iowa, United States
Jun 2016 - Jun 2022
Nov 2016

146400 mi

US $500
replaced starter 
Feb 2022

188000 mi

US $800
replaced all control arm bushihgs ,ball joints and tie rod ends 
Chevrolet TrailBlazer in Pennsylvania, United States
Jun 2013 - Jul 2014
Jul 2014

60000 mi

US $300
Water pump leaking, replaced 
Chevrolet TrailBlazer in Kansas, United States
Nov 2010 - Jun 2012
Jan 2011

70000 mi

US $1212
Air bag light was on - Replaced Passenger presence module, passenger seat & sensor, passenger seat belt pretensioner. Problem solved. 
Mar 2011

71000 mi

US $482
Ignition switch replacement. Airbag light came on after owner had removed and reinstalled steering wheel during ignition switch replacement. Dealer troubleshooted and replaced clockspring assembly in the steering column. 
Dec 2011

82000 mi

US $55
Alignment was performed to try and fix "Service Stabilitrak light" 
Chevrolet TrailBlazer in California, United States
Oct 2008 - Jun 2011
Jun 2008

20000 mi
rear end replaced 
Mar 2009

35000 mi
Sun gear went out in transmission, whole transmission replaced 
Chevrolet TrailBlazer in Indiana, United States
Apr 2009 - Mar 2011
Oct 2009

48000 mi
Replaced bad catalytic converter. (under GM 8yr/80,000 mile warranty) 
Jul 2010

60000 mi

US $671
Radiator failure, Auto trans cooler broke inside the radiator 
Chevrolet TrailBlazer in Indiana, United States
Jun 2011 - Oct 2017
Feb 2012

69400 mi

US $120
Replaced bearings and thrust washers in passenger side carrier for CV axle. Also ported for gear oil as stock grease fill is not serviceable and is prone to failure. 
Apr 2012

71000 mi

US $115
Changed front hubs. Significant humming noise like tires with heavy tread noticed in driver side which prompted the change. Noise completely gone with new hubs. Changed front hubs. Significant humming noise like tires with heavy tread noticed in driver side which prompted the change. Noise completely gone with new hubs. 
Aug 2012

73800 mi

US $23
Check engine light for "loose gas cap" code. Replaced Canister Purge Solenoid. Check engine light still persists. Will replace Vent Solenoid next. 
Oct 2012

76000 mi

US $80
Replaced starter; bearings worn out. Purchased new replacement on eBay for 30% of retail. 
Jan 2013

70200 mi

US $170
Excessive coolant leak, suspect faulty water pump known to fail at 50-70K miles. Replaced thermostat, serpentine and AC tensioner assy's, and water pump plus seals. 
Aug 2013

83600 mi

US $250
Replaced ignition coils for intermittent idle and noticeable ignition miss during wide open throttle. Also replaced coil wires and O2 sensors as preventive measure. 
Sep 2013

86000 mi

US $120
Rear air ride springs had leak; compressor experienced symptoms of fatigue. Replaced with stock Trailblazer springs new from Ebay. Removed compressor and lines completely. 
Nov 2013

88000 mi

US $163
Replaced loose upper ball joints with Driveworks brand and replaced CV axles with Cardone. No alignment necessary. Added fill tube to passenger carrier housing and sealed with RTV silicone 
Jan 2014

91000 mi

US $285
Replaced front wheel hubs for excessive noise due to wear. Existing set were 20 months old and basic brand-X from online supplier. New set are heavy-duty Timken bearing. Necessary for AWD application with Trailblazer SS. 
Jun 2014

99000 mi

US $20
AC Compressor belt broke last season. Replaced with new. Cleaned throttle body and air filter while clutch fan was out. 
Nov 2014

104800 mi

US $40
Replaced air filter due to Mass air flow sensor causing erratic shifting from first gear. Air filter was washable and oiled after washing, was in for 3+ years before replacement. 
May 2015

110400 mi

US $995
New brake rotors, calipers, pads, and stainless brake lines. 
Jul 2015

112300 mi

US $20
Replaced spark plugs for hard start. Battery terminal bolt replaced due to stripped thread. 
Sep 2015

114000 mi

US $25
Replaced upper and lower control arm bushings, sway bar links, inner and outer tie rods. Cleaned and repainted all parts with rust preventive paint. Had professional alignment completed. Replaced rear hatch struts due to excessive rust at ends. 
Dec 2016

123000 mi

US $96
Replaced water pump for failing bearings and coolant leak. Also replaced accessory belt idler below alternator (preventive). 
Jan 2017

109200 mi

US $20
Replaced tensioner for accessory belt. Squeak in accessory belt did not go away after tensioner and stationary idler were replaced. Replaced belt tensioner for the A/C compressor. It appeared to be the factory part and bearing was worn. Squeak gone. 
Jun 2017

127000 mi

US $100
Replaced oil sending unit for low oil pressure readings on dash gauge. Had to purchase special socket to remove sensor, but not expensive and made job very easy. Replaced front sway bar links with high performance aftermarket parts. Parts taken off appeared to be near failure as one stud sheared off when loosening. Not a high quality part and was purchased online, likely for standard trailblazer. 

Return to top

2006 Chevrolet TrailBlazer 4dr SUV

300-horsepower 5.3L V8 4-speed automatic RWD

Chevrolet TrailBlazer in Tennessee, United States
Aug 2010 - Jun 2016
Jul 2012

145700 mi

US $35
idler pulley belt 
Mar 2014

186000 mi

US $446
Hub bearing replaced (and additional preventative maintentance done) 
May 2016

235000 mi

US $280
New alternator and battery and serpentine belt 
Jun 2016

235000 mi
Gas gauge failed at 36,300 miles. We were told to wait until the fuel pump failed to replace it. The fuel pump never failed. 

Return to top

2006 Chevrolet TrailBlazer 4dr SUV

291-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Alabama, United States
Jun 2008 - Jun 2011
Jun 2008

35000 mi
Replace HVAC mode door actuator 
Jun 2009

52000 mi

US $600
Replace fan clutch 
Jul 2009

53000 mi

US $100
Faulty gas gauge HVAC mode door actuator was faulty fan clutch was faulty 
Chevrolet TrailBlazer in Ohio, United States
Nov 2008 - Mar 2010
Dec 2008

21000 mi
Intermittent check engine light on. Diagnosis indicated bad O2 sensor and was advised there was a TSB for problem. 
Chevrolet TrailBlazer in Tennessee, United States
Nov 2008 - Jun 2017
Dec 2008

45000 mi
AC/ Heater blower inop. Dealer replace blower motor and controls. 
Mar 2010

71000 mi

US $15
Tail lamps blown, repaired in 10 minutes 
Dec 2010

73000 mi

US $440
Fuel gauge sensor inoperative. Serviceman replaced. 
Apr 2012

86200 mi

US $40
Headlamps, both sides out. Replaced. 
Nov 2012

91000 mi

US $1750
Ruptured seal in the rear differential. Diff oil leaked onto brakes which also needed to be replaced as a result. Rear diff seals replaced. 
Dec 2014

133000 mi

US $600
Thermostat and other issues. Engine service MIL set. 
Chevrolet TrailBlazer in New York, United States
Mar 2012 - Jun 2012
Apr 2012

61500 mi

US $400
fuel pump sending unit died leaving the gas guage on empty. 

Return to top

2006 Chevrolet TrailBlazer 4dr SUV

291-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Oregon, United States
Feb 2006 - Jul 2014
Jun 2006

19000 mi
Driver's door power module died and had to be replaced. No electronic functions on the door would work. 
Oct 2007

46900 mi

US $230
Ignition switch went on the fritz. Replaced out of warranty. 
Dec 2008

73000 mi

US $230
ENGINE LIGHT ON - Diagnosed as clogged injector, recommended fuel system flush, which owner OK'd. Engine light was out for less than an hour when it came back on. Returned to shop 3 weeks later. Same diagnosis, free fuel system flush, EL stayed off 10 min 
Apr 2009

79000 mi

US $350
Once again, the engine light that has been on for months was addressed. This time, the dealership claimed it was an O2 sensor that was bad, but wouldn't guarantee that would solve the problem. They were right about the last part. Light on a day later. 
Chevrolet TrailBlazer in Michigan, United States
Aug 2010 - Jun 2011
Sep 2010

48000 mi
The the rear upper molded in retention hook on the front power seat plastic side shield trim broke. The rear middle clip tower also broke. I believe the parts broke because of fatigue from my weight on the trim as I entered and exited. 
Jan 2011 During a routine oil change I was told I had a front differental pinion seal leak. I am going to my local mechanic for a second opinion. Repair could cost $150 - $300. 
Jun 2011

63000 mi
Front differential bearing seal leak. Rear 4 months earlier. Water pump was leaking and was replaced. 
Chevrolet TrailBlazer in Maryland, United States
Feb 2008 - Dec 2009
Oct 2008

30000 mi
Emblem on rear gate peeling. 
Dec 2008

32000 mi
Fluid leak at the front diff pinion seal. 
Jun 2009

38000 mi

US $60
ses light for heater control circuit o2 sensor 1 bank 1 
Dec 2009

42000 mi
heater core leaking 
Chevrolet TrailBlazer in Massachusetts, United States
Feb 2008 - Jun 2022
Jun 2010

9000 mi

US $50
Blower Motor Resistor had to be replaced.  
Sep 2011

12000 mi

US $40
Harness wire replaced to blower resistor.  
Mar 2016

21000 mi

US $130
Replaced entire RR lens. Connections rotted on inside from water leaking in. Replaced both front speakers as they were dead. 
Jun 2022

28000 mi

US $100
Transmission bushing broke. 
Chevrolet TrailBlazer in Oklahoma, United States
Feb 2014 - Jan 2015
Apr 2014

117500 mi

US $715
Replace worn front struts and preventively replace rear shocks 
Sep 2014

121000 mi

US $386
Check engine was on. Diagnostic test pointed to gas cap. Replaced 
Chevrolet TrailBlazer in Minnesota, United States
Feb 2014 - Apr 2017
Nov 2014

100000 mi
Replaced water pump 
Jul 2015

105800 mi

US $135
Changed front hub assembly on left side. 
Dec 2015

113000 mi

US $100
Replaced upper control arm on left and right sides. 
Jun 2016

117000 mi

US $150
Replace front pinion seal. 
Chevrolet TrailBlazer in California, United States
Dec 2012 - Jan 2016
Jun 2013

113000 mi

US $300
Idler pulley & water pump worn out and making noise. Replaced before they stopped working. 
Apr 2014

126500 mi

US $30
Thermostat needed to be replaced. Was able to do it myself with common tools. 
Jul 2015

145000 mi

US $50
Tailgate supports failed, required replacement. Vehicle was rental and subject to abnormal wear of tailgate. 
Jan 2016

142000 mi

US $600
Forward sprag broke, according to shop. Too expensive to repair, so I sold the truck in a broken state. 
Chevrolet TrailBlazer in Alberta, Canada
Mar 2010 - Dec 2015
Jan 2010

52948 mi
The fuel guage no longer worked. Depsite having a full fuel tank, the guage indicated that the fuel was low. The low fuel chime constantly alerted. The fuel sensor was replaced. The dealer paid for this repair, having the vehicle for 8 hours. 
Apr 2010

57411 mi

C $154
The check engine light for the traction control came on. A diagnostic revealed code CO455 in steering sensor. Found in DOC ID to reprogram EBCM. Performed reprogram code 29FFD. This was not under warranty. The check engine light for the traction control came on. A diagnostic revealed code CO455 in steering sensor. Found in DOC ID to reprogram EBCM. Performed reprogram code 29FFD. This was not under warranty. 
May 2010

57908 mi

C $313
Windshield replaced. 
Jan 2012

120900 mi

C $1000
The front wheel bearings and ball joints were replaced, as the vehicle was riding rough with a vibration. Once replaced, it rides smooth and quiet. 
May 2013

89520 mi

C $180
The belt and belt tensioner were replaced, due to constant squeaking. 
Dec 2015

130200 mi

C $1100
Ball joint and sway bar replacement water pump and serpentine belt 
Chevrolet TrailBlazer in West Virginia, United States
Aug 2009 - Jun 2011
Sep 2009

59000 mi

US $1135
Shocks weak replaced front and rear 
Chevrolet TrailBlazer in New Hampshire, United States
Dec 2015 - Mar 2018
Aug 2016

167000 mi

US $674
replace 2 outer tie rods, replace front springs struts, replace rear shocks, replace pulley, replace front bearing drivers side 
Jan 2018

190 mi

US $1700
Front transfer case assembly replaced and axle rod. 
Chevrolet TrailBlazer in Michigan, United States
- Dec 2006
Dec 2006

30000 mi
Replaced rear cargo mat for tear. Under warranty. 
Chevrolet TrailBlazer in Arizona, United States
Sep 2013 - Dec 2013
Nov 2013

82900 mi

US $650
upper control arms were shot-both-and tie rods 

Return to top

2005 Chevrolet TrailBlazer

Engine not specified

Chevrolet TrailBlazer in North Carolina, United States
Dec 2012 - Jan 2013
Jan 2013

US $120
replaced thermostat 

Return to top

2005 Chevrolet TrailBlazer 4dr SUV, ext.

300-horsepower 5.3L V8 4-speed automatic RWD

Chevrolet TrailBlazer in South Carolina, United States
Oct 2014 - Jun 2018
Dec 2017

83000 mi

US $350
water pump and hoses 

Return to top

2005 Chevrolet TrailBlazer 4dr SUV, ext.

300-horsepower 5.3L V8 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Pennsylvania, United States
- Nov 2007
Jun 2005

9500 mi
Driver's side power window regulator replaced 
Nov 2007

60400 mi
I/P cluster replaced due to faulty speedometer 
Chevrolet TrailBlazer in Michigan, United States
Jun 2016 - Jan 2018
Jan 2018

150000 mi

US $50
Power steering system leaking badly due to bad high pressure hose. This was replaced. Replaced oil pressure sensor and filter screen. 

Return to top

2005 Chevrolet TrailBlazer 4dr SUV, ext.

275-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in California, United States
Jul 2012 - Sep 2013
Sep 2013

189000 mi
Smog repairs were very expensive 

Return to top

2005 Chevrolet TrailBlazer 4dr SUV, ext.

275-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Saskatchewan, Canada
Apr 2011 - May 2013
May 2011

52680 mi

C $750
Cracked manifold 
Apr 2012

62000 mi
Thumping sound coming from left rear when front heat control on Defrost - back AC actuator in rear of vehicle. Update: later went away on its own. 
Mar 2013

68820 mi

C $150
Serpentine belt replaced - normal wear 
Chevrolet TrailBlazer in Washington, United States
Feb 2018 - Jun 2018
Mar 2018

147000 mi

US $1300
Full front and rear suspension including a rods, mounts, brakes all around and rotors 
Jun 2018

150000 mi

US $450
Catalytic converter went out  and had windshield washer tank replaced as it leaked to empty in less than a day 

Return to top

2005 Chevrolet TrailBlazer 4dr SUV

275-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Louisiana, United States
Nov 2011 - Dec 2017
Dec 2011

76000 mi

US $400
water pump replacement Transmission sensor went out. 2 other parts were changed at the same time b/c it was suggested. 
Aug 2012

81100 mi

US $190
fan clutch needed to be replaced 
Aug 2017

156000 mi
Total front end rebuild 

Return to top

2005 Chevrolet TrailBlazer 4dr SUV

275-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Indiana, United States
Aug 2015 - Jun 2016
Oct 2015

148500 mi

US $50
Power steering Line had pinhole. Shop cut and flared new piece of tubing to replace 
Chevrolet TrailBlazer in Tennessee, United States
Apr 2015 - Apr 2015
Apr 2015

185000 mi

US $250
2 coils replaced along with plugs 
Chevrolet TrailBlazer in North Carolina, United States
Dec 2008 - Mar 2010
Jun 2008

35000 mi
Replace faulty rack and pinion steering assembly. 
Chevrolet TrailBlazer in Kentucky, United States
Nov 2014 - Jun 2017
Jun 2017

212000 mi

US $2100
Defective transmission. Got rid of it after repaired. 
Chevrolet TrailBlazer in New Jersey, United States
Dec 2014 - Oct 2021
Jun 2015

107000 mi
Changed condenser and evaporator. Plus vacuumed out the lines and recharged 
Oct 2015

111200 mi

US $1700
Worn ball joints and end links Brake was malfunctioning. All parking brake parts replaced. 
Jan 2016

112200 mi

US $180
Replace alternator, idler pulley and belt tensioner 
Aug 2016

120000 mi

US $1195
Replace both end links Replaced front drive shaft u joints and seals Fan cluch replaced 
Oct 2017

128000 mi

US $400
Pads and rotors all the way around and new front calipers.. 
Chevrolet TrailBlazer in Virginia, United States
Jun 2012 - Sep 2016
Oct 2012

75500 mi

US $153
Coolant Temp Below Threshold. Repair poor connection at Engine Coolant Temp. Sensor. Note: bill is this much b/c I had other work done. Oil change with synthetic blend, tire rotation. 
Jan 2014

80200 mi

US $300
Replace Blower Motor Resistor. After market and factory part the same. Mechanic has to solder wires together, GM recommendation, cannot "plug in." 
Jul 2014

95200 mi
Fuel Sensor stopped working. Service Bulletin from GM was available. Took to nearby GM dealership and replaced fuel sensor inside tank for free. Had to remove tank, some connecting parts were corroded but dealer replaced these for free to 
Dec 2014

99000 mi

US $700
Both Wheel bearing assemblies replaced, has ABS sensor attached. Replace Secondary Air Injection Pump. Replacement was faulty, replaced-under warranty. The new pump caused engine light to come back on, mechanic cleaned and lubricated pump, seems to work fine now... 
Nov 2015

107000 mi

US $955
Power Steering both lines leaking. Replace pressure and return lines. And outlet hose. And BG flush kit. Parts-$595. Labor-$360. 
Chevrolet TrailBlazer in Minnesota, United States
Oct 2011 - May 2017
Oct 2012

76000 mi

US $300
Sway bars replaced front and back. 
Oct 2013

83200 mi

US $675
Replaced shocks and struts 
Feb 2014

84000 mi

US $450
Sway bar links and bushings were worn. One side was under warranty, but the other was not. 
Aug 2014

89700 mi

US $350
Replacement of both tie rods also included an alignment Replaced left front half axle. 
Jan 2016

86000 mi

US $1200
Replaced water pump and completed 100,000 mile tuneup (radiator flush, transmission flush and gasket replacement, 4-wheel drive flush). 
Jun 2016

103000 mi
Replaced rear sway bar for second time. 
Aug 2016

104100 mi

US $550
Replaced front and back sway bars (one under warranty) and front bushing. 
Chevrolet TrailBlazer in Illinois, United States
Jul 2010 - Sep 2011
Jun 2011

108000 mi

US $680
Replace Air Injection Check Valve and New Air Pump 
Chevrolet TrailBlazer in Oregon, United States
Jan 2010 - Feb 2014
Mar 2011

80500 mi

US $325
Broken wire at switch for front wipers...repaired Repair broken wire in ignition that control wipers 
Feb 2012

85000 mi

US $250
Needed new themostat and sensor because it was throwing code P0128 
Chevrolet TrailBlazer in Wisconsin, United States
Sep 2012 - Mar 2013
Dec 2012

77000 mi

US $900
Idler pulley was loose, water pump was beginning to fail and leak. Both also added a high pitched whine proportional to RPM. P0128 - engine too cold. Issue was a stuck thermostat. Thermostat was replaced and engine temperature now approaches 210C as expected. 
Chevrolet TrailBlazer in North Carolina, United States
Sep 2011 - Oct 2011
Oct 2011

74000 mi
Radio Stopped Working 
Chevrolet TrailBlazer in Colorado, United States
Sep 2012 - Oct 2012
Oct 2012

145000 mi

US $400
A check engine light was diagnosed with low water temperature, the thermostat fixed the problem. Play in the water pump, (a bearing?) was causing a troubling sound, so it was replaced. 
Chevrolet TrailBlazer in Washington, United States
Dec 2014 - Jun 2018
Sep 2015

160000 mi
Remote Fob quit working. I went online and found that there are wires in the rear hatch that could be loose. Found the broken wires and replace them. Fob works and the rear wiper now works. 
Dec 2016

172000 mi
Leaking Transmission Pan, time for service. 
Apr 2017

176000 mi

US $350
The Heater Fan quit working. It was shorted in a wiring harness. Repaired and good now 
Jul 2017

182000 mi

US $500
Water pump was leaking. Pump was replaced. 
Jun 2018

189000 mi
Leaking Transfer case. Filled it up and put some dye in it to find the leak. It quit leaking 
Chevrolet TrailBlazer in Illinois, United States
Feb 2015 - Mar 2015
Feb 2015

109000 mi

US $491
battery, alternator 
Chevrolet TrailBlazer in Iowa, United States
May 2013 - Aug 2015
Jun 2013

158000 mi

US $353
Radiator was leaking from the trans cooler. Decided to replace serpentine belt, water pump, tensioner and idler pulley while the radiator was out. With the milage showing figured the rest were not far behind 
Jan 2014

US $285
instrument cluster, speedometer, gas gauge, both have not worked for several months. Finally broke down and ordered a rebuilt unit with a lifetime guarantee. 
Sep 2014

148000 mi

US $345
Everyone I talked to replaced the entire front Hub. Got very lucky and found one of the fr ont hubs on inventory clearance for $75.00. ACdelco no less. Word to the wise. Do not by cheap hubs that are available. I did, replaced less than yea. 
Oct 2014

148200 mi

US $90
Tie-rod, normal wear item considering over 130,000 miles. 
Apr 2015

150500 mi

US $19
added 2 quarts. 1 quart was the Lucas brand, AUTOMATIC TRANSMISSION FLUID CONDITIONER. Embarrassed about this, I have never let this happen before. Was wondering why on cold mornings I had to rev a bit to get it moving. power steering. Wandered when driven. could barley keep it in a straight line. I thought it was a suspension part going bad. Nope, low power steering fluid. Used the Lucas Oil, POWER STEERING FLUID W/conditioner. Drives like new. embarrassed. 
Aug 2015

153000 mi

US $350
The transmission fluid lines that circulate the fluid through the radiator transmission fluid cooler, both corroded. I had to replace the lines. 

Return to top

2004 Chevrolet TrailBlazer

Engine not specified

Chevrolet TrailBlazer in Louisiana, United States
Apr 2011 - Sep 2011
Jun 2011

108000 mi
Gauges stopped working after warrenty. 
Chevrolet TrailBlazer in North Carolina, United States
Nov 2009 - Jun 2011
Dec 2009

57000 mi

US $172
Replaced the electric ignition switch under dash, 3rd time since we bought the TrailBlazer new 
Jul 2010

65000 mi

US $50
Had to replace the HVAC Mode Actuator after battery was replaced. 

Return to top

2004 Chevrolet TrailBlazer 4dr SUV, ext.

290-horsepower 5.3L V8 4-speed automatic RWD

Chevrolet TrailBlazer in Georgia, United States
Aug 2012 - Dec 2016
Mar 2013

65000 mi

US $502
water pump replaced 
Mar 2014

76000 mi

US $920
replace catalytic converter 
Aug 2016

121000 mi

US $360
Replaced factory shocks and struts 

Return to top

2004 Chevrolet TrailBlazer 4dr SUV, ext.

290-horsepower 5.3L V8 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in California, United States
Mar 2009 - Jun 2012
Mar 2012

127000 mi

US $800
Speedometer not working 

Return to top

2004 Chevrolet TrailBlazer 4dr SUV, ext.

275-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Arizona, United States
Nov 2009 - Sep 2012
Aug 2012

121100 mi

US $400
Car acted like there was a fuel interuption/stoppage. Would simply shutdown for no reason. 
Chevrolet TrailBlazer in Tennessee, United States
Nov 2012 - Dec 2015
Oct 2013

239500 mi

US $10
An ongoing problem - headlamp low-beam bulbs burn out regularly and repeatedly. 
Jan 2015

244300 mi

US $600
had to replace alternator 
Jul 2015

256000 mi

US $1100
Failed emissions. Had to replace catalytic converter, other parts. 

Return to top

2004 Chevrolet TrailBlazer 4dr SUV, ext.

275-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Illinois, United States
May 2014 - Oct 2018
Jun 2014

135000 mi
air conditioning line to rear ac system developed pin hole leaks as is common in these vehicles but have not fixed .. just the lines cost almost $900 to replace and the gas tank has to be removed to do so. patched some holes, must be others. 
Dec 2014

136000 mi

US $360
cracked exhaust manifold replaced  also replaced spark plugs and ignition coils at this time. 
Jan 2015

136300 mi
Replaced all brake pads. Inner pads worn far more than outer pads. The right front caliper guide was frozen and had to be unstuck and cleaned up and greased. 
Jan 2016

148000 mi

US $400
RIGHT SIDE RACK SEAL BLEW OUT 20 MILES FROM HOME, EMPTIED THE RESERVOIR, LEFT MY DRIVEWAY COVERED IN OIL, DAMAGED PS PUMP, REPLACED ENTIRE STEERING RACK & PINION & TIE ROD ENDS - TRAILBLAZERS ARE LEMONS - NOW REGRET SELLING 2000 JIMMY. 
Mar 2016

149000 mi

US $300
wheel bearings going - brakes pulsating - when applying pressure to brake pedal - this vehicle is the biggest piece of GM crap I have ever owned and only gets 13mpg !!I should never have gotten rid of my 2000 fully loaded jimmy !!!! 
Jun 2016

150000 mi

US $175
RAIN SENSOR CAUSED WINDSHIELD TO CRACK IN SEVERAL DIRECTIONS - TOOK TO AUTO GLASS SHOP AND HAD NEW AFTERMARKET WINDSHIELD INSTALLED - TOOK 2 HOURS - HAD TO DRIVE SLOW FOR THE NEXT 24 HRS- TO LET RTV GLUE FIRM UP.. 
Oct 2016

151000 mi
left front wheelbearing play and shrill howling at high speed - ordered wheelbearing rockauto.com and replaced 
Dec 2016

151000 mi

US $150
REPLACE LOUD GRINDING SOUNDING RIGHT FRONT WHEEL BEARING 
Jul 2017

154250 mi

US $150
INSTALLED AC BLOCKING KIT TO REAR AC UNIT BECAUSE ALUMINUM LINES TO REAR UNIT HAD PIN HOLES THAT WERE LEAKING - Bought blocking kit online and installed so that only front AC system works now .. replace burned out low beam and high beam bulbs on opposite sides .. drain & replace oil, oil filter, and air filter, and discovered several burned out fuses and also replaced them .. 
Mar 2018

162000 mi

US $85
floating caliper guide pins rusted no longer moved, causing excessive rotor and brake pad wear on front rotors .. replaced rotors pads, guide pins and guide pin rubber seals .. 
Jun 2018

166000 mi

US $300
replace upper and lower ball joints - and changed oil afterwards .. 
Oct 2018

169700 mi

US $1250
broken rear bolt that holds on exhaust manifold, cracked manifold, burned up gasket for rear cylinder 2nd new exhaust manifold put on in 4 years time - this chevy trailblazer is the biggest piece of crap vehicle I have ever owned.. the designers should be lynched !!! parking brakes locked up and were dragging the right rear wheel after hitting a pot hole in the pavement. removed rear rotor drum to see problem, all the interna parts were all torn up - ordered parking brake parts for both rear wheels ball joints replaced and front end aligned, front end aligned after new tires and new ball joints were put on vehicle no reverse or forward drive transmission slipping 
Chevrolet TrailBlazer in Kentucky, United States
Oct 2011 - Apr 2012
Jan 2012

US $25
bad fuse 

Return to top

2004 Chevrolet TrailBlazer 4dr SUV

275-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Florida, United States
Jul 2010 - Jun 2011
Aug 2010

84000 mi

US $980
A/C compressor stopped functioning.  TrailBlazer would not move. Transmission required a complete rebuild. 
Sep 2010

86000 mi

US $438
Tachometer needle began moving erratically from 0 rpm to over 7000 rpm at idle or driving on the highway. The entire dash was disassembled to replace a small motor running the tachometer. Engine light came on. The temperature gauge was showing very high temperature. Mechanic showed the code to be a thermostat AND sensor malfunction. Thermostat was stuck closed. Thermostat and sensor replaced. 
Oct 2010

86000 mi

US $89
Engine stopped running at idle. Code showed MAP sensor was bad. Replaced sensor. 
Chevrolet TrailBlazer in Alabama, United States
May 2015 - Oct 2015
Oct 2015

175000 mi
Cuts off occasionally at a stop. 

Return to top

2004 Chevrolet TrailBlazer 4dr SUV

275-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Ontario, Canada
- Mar 2009
Mar 2009

97960 mi

C $30
low beam sockets on both sides melted... replaced with high temp sockets from canadian tire 
Chevrolet TrailBlazer in Missouri, United States
May 2016 - May 2016
May 2016

110000 mi

US $600
Replace bearing 
Chevrolet TrailBlazer in Michigan, United States
Mar 2010 - Jan 2012
Dec 2011

91000 mi

US $400
heater blower and resister 
Chevrolet TrailBlazer in North Dakota, United States
Mar 2008 - Dec 2016
Apr 2009

93000 mi

US $15
Replaced A/C compressor bearing myself. 
May 2011

129600 mi

US $30
Replaced faulty O2 sensor. 
Jul 2011

135200 mi

US $130
Faulty gauges, including tach and speedometer. Acting up since winter. Wife tired of using the GPS as a substitute. Installed new motors. faulty wheel bearing hub. replaced hub assembly. 
May 2012

153900 mi

US $100
Changed rear shocks 
Jun 2013

168000 mi

US $45
#4 cylinder coil dead 
Oct 2013

175500 mi

US $120
replaced wheel hub due to dry bearing 
Chevrolet TrailBlazer in Illinois, United States
Mar 2008 - Aug 2013
May 2009

48000 mi
Rear Tailgate struts failed. They were replaced under the extended warranty purchased from dealer when vehicle was new. 
May 2012

79500 mi

US $853
Replaced Thermostat & Coolant. Front Brakes & Rotors, brake fluid replaced. Replaced engine air filter. 
Chevrolet TrailBlazer in Illinois, United States
Feb 2009 - Apr 2011
Apr 2011

42000 mi

US $600
Radiator fan clutch needed replacement together with water pump. Changed spark plugs at same time and flushed transmission oil 
Chevrolet TrailBlazer in Wisconsin, United States
Dec 2014 - Jun 2015
Dec 2014

157000 mi

US $120
Engine operating temperature running below spec by 10 degrees. Replaced thermostat 
Jun 2015

167000 mi

US $375
Transmission cooler lines rusted and leaking where they connect to inner fender well with clip. Replaced all four pieces of the line. 
Chevrolet TrailBlazer in Arizona, United States
Apr 2018 - Jun 2022
Jun 2022

209000 mi

US $550
Replaced spark plugs and coil packs and fuel pressure regulator. 
Chevrolet TrailBlazer in Michigan, United States
Sep 2015 - Dec 2016
Oct 2016

162200 mi

US $75
Rusted power steering line 
Chevrolet TrailBlazer in Nebraska, United States
Feb 2013 - May 2013
May 2013

153000 mi
losing map sensor and air pump 
Chevrolet TrailBlazer in Tennessee, United States
Dec 2009 - Jan 2011
Jun 2009

89000 mi

US $1200
Replace Air Conditioning Condensor and Evaporator Core 
Jan 2011

133000 mi

US $1190
Replace Transmission Replace Transmission 
Chevrolet TrailBlazer in Pennsylvania, United States
Aug 2005 - Jun 2018
Mar 2005

6000 mi
Front wiper module board. 
Aug 2007

36000 mi
Camshaft position sensor 
Sep 2008

47700 mi

US $244
Replaced transmission cooler lines. 
Oct 2008

47950 mi

US $382
Fan clutch/water pump 
Dec 2008

49800 mi

US $246
Front left wheel bearing. 
Sep 2009

59500 mi

US $53
Water pump rechanged. N/C. New belt and 60$ labor HVAC blower-resistor module and 8-prong pigtail. 
Dec 2009

62500 mi

US $230
Front-Right wheel bearing. 
Sep 2011

80000 mi

US $450
Gas smell but no apparant leak. Dealer dropped tank and replaced fuel pump/tank lines. This was done at NO COST!!! based on VIN# and a letter received from GM some years earlier stating that this failure was likely to happen. Hats off to GM Exhaust manifold cracked. Replaced w/aftermarket. 2 bolts broken in head and new O2 sensor needed. 
Oct 2011

83000 mi

US $10
Engine idle would drop low and sometimes even stall when heater or AC was engaged. Problem was fixed by removing air intake system and cleaning the accumulated gunk from throttle body butterfly. 
Oct 2015

117700 mi

US $80
Front right outer tie rod replaced. 
Sep 2016

125000 mi

US $25
power steering hose leaking. repaired the low pressure side wth rubber hose and clamps. 
Jan 2017

122300 mi

US $290
Replaced high pressure and return power steering lines with new. 
Jun 2017

131000 mi

US $250
replaced faulty fan clutch--also replaced waterpump ,belt,and belt tensioner. 
Sep 2017

139000 mi

US $30
Fan Clutch solid state relay replaced. Fan clutch running constantly at hi speed. 
Chevrolet TrailBlazer in New Hampshire, United States
Feb 2016 - Jul 2016
Jun 2016

207000 mi

US $750
Both original half axels CV joints were leaking, replaced both and seals. Serpentine belt had cracks on it 
Chevrolet TrailBlazer in Utah, United States
Feb 2014 - Sep 2015
Feb 2015

84000 mi

US $15
Replaced nonfunctioning stepper motor on speedometer 
Mar 2015

85000 mi

US $30
Endlinks replaced due to excessive play in ball joints 
Chevrolet TrailBlazer in Saudi Arabia
Feb 2011 - Jan 2014
Mar 2011

168020 mi

﷼300
Vibration during idle and moving. Changed the engine mounts. Problem solved 
Sep 2011

179800 mi

﷼300
Major vibration detected and engine light blinking. Computer check showed faulty thermal sensor. Turned out a cable connecting the sensor was not working. Repair included cable, spark plugs, engine tuning. 
Nov 2011

184140 mi

﷼500
Screeching noise and tire vibration were noticed. Upon inspection, it was found that the suspension stoppers and rubber rings in the balance bar (front) need to be replaced. They were replaced. 
Dec 2011

185380 mi

﷼1300
Engine sputter was noticed. Turned out the thermosatat not working. It was changes and engine tuning and reprogramming made. Noise coming from under the car. Upon inspection turned out that a part of the front axle was loose. It was the base of the front axle. 
May 2012

193820 mi

﷼210
Engine is not running smoothly. Sometimes switch off all of a sudden especially when the car is turning. AC is not cooling any more. There was a leak in the system. One pipe was repaired and some rubber joints also repaired then gas was filled again. 
Sep 2012

199020 mi

﷼100
AC is cooling but air is not coming out of vents. Turned out the control unit was not working. So, it was replaced. 
Dec 2012

203980 mi

﷼113
Oil leak from the pipe on top of the engine. A valve was repaired and a hose replaced. Rubber parts on front axle wore down. Grease was leaking. Rubber parts were changed. 
May 2013

212040 mi

﷼253
Substantial oil leakage from the upper part of the engine. The Upper gasket was change along with spark plugs and one injector. 
Jul 2013

214300 mi

﷼176
Timing belt was cut. It turned out the water pump was failed and it could be the reason for the belt failure. Both were replaced. 
Sep 2013

216380 mi

﷼500
All rubber rings connecting the suspension parts were replaced. Oil leaks in various places especially in the steering oil tank. The mechanic tried a temporary fix for the time being to bring the repair cost down but was not successful. No full repair was tried so far. 

Return to top

2004 Chevrolet TrailBlazer 4-door

6-cylinder automatic 2WD

Chevrolet TrailBlazer in Oklahoma, United States
Mar 2008 - Mar 2010
Apr 2008

50000 mi

US $50
Clamp on the gas inlet valve was loose. Had to be tightened. 

Return to top

2003 Chevrolet TrailBlazer

Engine not specified

Chevrolet TrailBlazer in Georgia, United States
Aug 2013 - Nov 2013
Aug 2013

134000 mi

US $280
Fuel tank leaking gas from pump module. Found last person who worked on it did not move the pump module into the safety detent to keep it from backing out of tank. Replaced the seal and reassembled the tank. Fuel gauge erratic and Speedometer inop. Removed instrument module and had it rebuilt. Engine will not idle. Searches for idle rpm. Had to reflash engine control module and clean throttle body. Left door speakers stopped working. Had shop trouble shoot speakers. Found driver door speaker was inop and had to replace that one speaker and reflash body module to clear errors. 
Nov 2013

135000 mi

US $300
Fuel level sensor in fuel tank sticks at 1/4 tank. Ran out of fuel twice. Had to have shop drop tank again and replace fuel sending module. 
Chevrolet TrailBlazer in California, United States
Sep 2011 - May 2012
Mar 2012

79000 mi

US $1000
Replaced alternator. Replaced thermostat. Replaced radiator hoses.  Replaced gas cap three times. Installed proper oil filter. Properly installed oil pan plug and gasket. Changed the oil and filled it correctly. Replaced the radiator. Replaced alternator again. Replaced ignition system electronics. 
Chevrolet TrailBlazer in Michigan, United States
Nov 2008 - Mar 2010
Dec 2008

51000 mi

US $5
Replace right front headlight harness plug and wire leads melted. 

Return to top

2003 Chevrolet TrailBlazer 4dr SUV, ext.

290-horsepower 5.3L V8 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Wisconsin, United States
Apr 2008 - Mar 2011
Jul 2010

53200 mi

US $500
Front left axle seal leaking; seal replaced & axle fluid re-filled. 

Return to top

2003 Chevrolet TrailBlazer 4dr SUV, ext.

275-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Ohio, United States
Nov 2011 - Dec 2012
Jan 2012

87000 mi

US $25
BOTH POWER STEERING LINES NEEDED REPLACED DUE TO DEGRADATION 
Dec 2012

94000 mi

US $1700
ALL UPPER AND LOWER CONTROL ARMS NEEDED REPLACED ALONG WITH ALL FOUR BALL JOINTS, REPLACED BOTH FRONT SWAY BAR LINKS, REPLACE BOTH FRONT STRUTS. 

Return to top

2003 Chevrolet TrailBlazer 4dr SUV, ext.

275-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Ohio, United States
Dec 2012 - Oct 2014
Jan 2013

US $1397
frt & rear link pin loose, both frt wheel bearing very noisy, algmenment & serp belt 
Chevrolet TrailBlazer in North Carolina, United States
Feb 2014 - Jun 2016
Sep 2014

138000 mi

US $2200
Rebuilt transmission due to bad torque converter causing internal damage. 
Feb 2015

143000 mi

US $10
Shifter cable bushing fell out, causing shifter to disconnect from transmission. Purchased and installed new bushing. 
Apr 2015

143700 mi

US $17
Electronic ignition switch went bad...replaced 
Dec 2015

156000 mi

US $15
Ignition control module replacement. 
Mar 2016

164000 mi

US $42
Replaced faulty ignition coil. 
Chevrolet TrailBlazer in Pennsylvania, United States
May 2009 - Mar 2016
Jun 2009

77000 mi

US $200
Leaking front axle shaft seal 
Mar 2016

135000 mi

US $150
Replaced alternator 
Chevrolet TrailBlazer in Northwest Territory, Canada
May 2011 - Oct 2015
Apr 2012

63840 mi

C $1500
Replaced coolant line under vehicle. Replaced water pump leaking. Replaced power steering pressure hose leaking. 
Oct 2012

73160 mi

C $800
Problem with rattle. 
Jun 2013

77500 mi

C $1300
Leak in rack and pinion 
Oct 2015

96720 mi

C $1800
Struts worn out, ball joint, bushings, 
Chevrolet TrailBlazer in Michigan, United States
Sep 2009 - Aug 2022
Oct 2010

115000 mi

US $700
Roaring sound from front, louder with higher engine speed. Dealer tech diagnosed bad radiator fan clutch. Replacement part fixed the problem. Check engine light - dealer replaced fuel cap. 
May 2011

126600 mi

US $1100
Transmission would not shift automatically. Manual selection on shifter still worked to upshift and downshift. 
Nov 2011

139200 mi

US $2700
Worn sway bar link bushings. Squeaking noise over bumps. Replaced all links. Growling noise from front while driving. Bad bearings. Replaced both front wheel hubs. 
Jan 2013

144200 mi

US $1800
Transmission leak repair 
May 2014

171000 mi

US $305
Loose part in muffler causing rattling noise, especially at idle. The shop welded up a fix because it was much cheaper than OEM replacement part. Pulled over for brake lights not working. Center high brake lamp worked and turn signals worked, but not tail brake lights. Shop replaced circuit boards for tail lamps. 
Feb 2015

181900 mi

US $400
Front wipers not working. Found blown fuse, replaced fuse, blown fuse again. Replaced Wiper motor. 
Jun 2015

189000 mi

US $1100
AC compressor failed. Replaced with new compressor. Rattling noise in front axle. Shop discovered loose connection to passenger-side front half axle at transfer case. Decoupler needed to be replaced. No new parts available at any price. Replaced with rebuilt used part. 
Jun 2016

200000 mi

US $500
Rough idle and low power. Diagnosed one spark plug not firing. Replaced ignition coil. 
Chevrolet TrailBlazer in Iowa, United States
Jul 2012 - Sep 2012
Aug 2012

152000 mi

US $250
Bad clutch on AC Compressor--replaced this as well as accumulator. 
Chevrolet TrailBlazer in Massachusetts, United States
Feb 2015 - Dec 2016
Mar 2015

120000 mi

US $2000
front differetial 
Jul 2016

132700 mi

US $120
Blower fan resistor died. AC ok but fan won't run. 
Chevrolet TrailBlazer in Indiana, United States
Dec 2014 - Jan 2015
Mar 2014

118000 mi

US $10
Instrument cluster failed. Cost of repair was estimated at $250. I ordered an eBay stepper motor and replaced it myself for $10. Another has since failed. 
Dec 2014

141000 mi

US $100
Failed coil pack. Caused cylinder misfire 
Jan 2015

US $300
Replaced all tie rod ends. Passenger front wheel tie rod broke and caused wheel to loose steering ability. 

Return to top

2003 Chevrolet TrailBlazer 4dr SUV

275-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Texas, United States
Aug 2010 - Jun 2011
Mar 2011

125000 mi

US $120
A/C not cooling. Checked for leaks and recharged system. 
Chevrolet TrailBlazer in Texas, United States
- Jun 2007
Jun 2007

45000 mi
High Fan has quit working 
Chevrolet TrailBlazer in Texas, United States
Feb 2009 - May 2009
Apr 2009

132000 mi

US $120
Thermostat stuck open. Changed it myself. 
Chevrolet TrailBlazer in Kentucky, United States
Mar 2011 - Jun 2022
Feb 2013

126000 mi

US $70
Replaced caliper on drivers side, front. 
Nov 2013

127000 mi

US $53
caliper 
Nov 2015

129000 mi

US $50
Window regulator and motor 
Jan 2022

153000 mi

US $230
alternator Battery 
Jun 2022

168000 mi

US $25
coil pak 
Chevrolet TrailBlazer in Texas, United States
Nov 2008 - Jul 2018
Nov 2008

138000 mi

US $860
R&R fan clutch and water pump. 
Apr 2009

142000 mi

US $330
Replace gauge cluster stepper motors, replace thermostat. 
Nov 2010

165000 mi

US $650
Complete transmission rebuild. 
Jan 2011

167000 mi
Broken transmission pump, replaced under garage's warranty. 
Apr 2011

169500 mi
Complete transmission rebuild. 

Return to top

2003 Chevrolet TrailBlazer 4dr SUV

275-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Washington, United States
Apr 2008 - Dec 2014
Jan 2011

62000 mi

US $200
Heater fan control module failed.  
Sep 2012

70000 mi

US $150
Replaced defective thermostat. 
Chevrolet TrailBlazer in Wisconsin, United States
Nov 2013 - Jan 2017
Dec 2014

107000 mi

US $1300
Upper and lower balljoints and one tierod end. 
Dec 2016

125000 mi

US $65
Replaced tie rod. 
Chevrolet TrailBlazer in Texas, United States
Oct 2010 - Sep 2012
Sep 2010

79000 mi

US $30
Resealed differential due to leaking. Drained and refilled with new gear oil. 
Jan 2011

80000 mi

US $150
replaced driver side inner tie rod, outer tie rod, and lower ball joint due to wear. The steering felt lose and unpredictable before being fixed. 
Aug 2011

86000 mi

US $200
Fan clutch was replaced due to it not spinning anymore. Had been having trouble for a year with it staying on and it finally gave out and the truck would overheat. 
Chevrolet TrailBlazer in Georgia, United States
Jun 2020 - Jan 2023
Aug 2020

204000 mi

US $1000
The front end was almost completely replaced, including upper and lower arms and everything attached to them. 
Oct 2021

211000 mi

US $700
Replaced solenoids 
May 2022

214000 mi

US $100
Leaking gas hose was replaced 
Jun 2022

214000 mi
Car required additive and adjusting spark plugs. A hose was loose 
Jan 2023

214700 mi

US $200
Sensor replaced 
Chevrolet TrailBlazer in Wisconsin, United States
Nov 2009 - Jul 2018
Mar 2013

116000 mi

US $200
Replaced front right hub assembly 
Jul 2014

126200 mi
Replace both front upper ball joints replace both front link pins replace fuel pump and filter due to gas smell caused by metal fittings on pump leaking 
Aug 2014

126000 mi

US $400
hard turning to the right. Replaced steering rack unit both outer tie rods 
Dec 2014

128000 mi

US $2
Replace all transmission line due to leaks from corrosion on lines. Leaks from power steering lines. Replaced all power steering fluid lines and power steering cooler due to leaks from corroded lines. 
May 2016

137400 mi

US $2
replace front lower ball joints on both sides and wheel alignment 
May 2018

150000 mi

US $450
warning light indicated engine not reaching operating temperture. replaced thermostat and housing along with water pump 
Chevrolet TrailBlazer in Minnesota, United States
May 2008 - Mar 2009
Jun 2008

72000 mi

US $35
Transmission had to be overhauled 
Chevrolet TrailBlazer in New York, United States
Nov 2015 - Jun 2016
Jun 2016

115000 mi

US $475
Shift linkage and shift cable. Previous owner had fixed it with zip-ties. 
Chevrolet TrailBlazer in Missouri, United States
Jul 2015 - Oct 2015
Aug 2015

177300 mi

US $60
Loud squeaking noise noticed in front right wheel area. Diagnosed at shop that the ball joint was bad. After difficult time figuring out removal, successfully installed new ball joint and reassembled. 
Chevrolet TrailBlazer in New York, United States
May 2010 - Jun 2011
Jun 2010

84000 mi

US $400
Tie rod 
Chevrolet TrailBlazer in Illinois, United States
Jan 2016 - Jun 2016
Jun 2016

144000 mi

US $300
Ball joints had to be replaced. 
Chevrolet TrailBlazer in Minnesota, United States
Jan 2015 - Feb 2015
Jan 2015

225000 mi

US $100
A sensor in the tail light 
Chevrolet TrailBlazer in New York, United States
- Jul 2003
Jul 2003 scratch on car before Purchase 
Chevrolet TrailBlazer in Manitoba, Canada
Mar 2010 - Dec 2011
Apr 2010

99820 mi

C $900
Poor gas mileage 
Aug 2011

112920 mi

C $1083
New Exhaust Fan Clutch Replaced 
Chevrolet TrailBlazer in Texas, United States
Oct 2010 - Jun 2011
Nov 2010

119000 mi

US $900
Both headlamps replaced ($400 each). Can't just replace a bulb "successfully" in this car - entire assembly must be replaced. Chevy wanted $700 per. Got them on aftermarket for $400 per. Chevy stinks. 

Return to top

2002 Chevrolet TrailBlazer

Engine not specified

Chevrolet TrailBlazer in Colorado, United States
Jun 2016 - Jul 2016
Jul 2016

131000 mi

US $80
Regulator on rear driver's window went out 
Chevrolet TrailBlazer in Michigan, United States
Dec 2012 - Dec 2013
Feb 2013

65300 mi

US $80
Cooling pump failed 
Mar 2013

67000 mi
one month later the new water pump failed 
Chevrolet TrailBlazer in Kentucky, United States
Dec 2012 - Jan 2013
Jan 2013

100000 mi

US $400
Check engine light came on. Trailblazer started rumbling (shaking), mostly while idling. Mechanic said one of the cylinders wasn't firing. Replaced a sensor, plugs and a coil in the cylinder that wasn't firing. 

Return to top

2002 Chevrolet TrailBlazer 4dr SUV, ext.

270-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in California, United States
Dec 2012 - Jun 2013
Jan 2013

229500 mi

US $350
Replaced alternator and computer lost it's memory. Had to reprogram computer.  This did not correct the stalling issue. Ended up having to remove and clean the throttle body. 
Feb 2013

230100 mi

US $20
Antifreeze leak at rear heating and cooling system. I purchased the proper fittings and water hose clamps and cut off and isolated the rear heater core and reattached the hoses into a loop. Eliminated the leaking antifreeze and odor. 
Chevrolet TrailBlazer in Texas, United States
Mar 2013 - Jun 2016
Oct 2013

139300 mi

US $70
Replaced cpas sensor (vvt exhaust cam solenoid) because it was leaking oil. Probably only needed new o ring, but it was original to the car. Replaced with ac delco part and no more drips. 
Mar 2014

147000 mi

US $300
Replaced fan clutch and water pump after getting a code for fan speed. Replaced water pump as precaution but pump appeared to be in good shape, even the bearings. 

Return to top

2002 Chevrolet TrailBlazer 4dr SUV, ext.

270-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Indiana, United States
Mar 2008 - Mar 2010
May 2008

118000 mi

US $125
Replaced right side rear door window regulator & motor after the cable in the window regulator came out of the spool. 

Return to top

2002 Chevrolet TrailBlazer 4dr SUV

270-horsepower 4.2L I6 4-speed automatic RWD

Chevrolet TrailBlazer in Alabama, United States
Mar 2008 - Jun 2018
Jul 2008

88000 mi

US $284
Engine check light. Two codes regarding catalyst flow. Catalytic converter replaced. 
Aug 2008

90000 mi

US $284
Fan control nob quit working for the second time. 
Jul 2011

120000 mi

US $115
Motor for Vent Control Solenoid went out on driver side. 
Dec 2011

122000 mi
Rear oxygen sensor failed again. 
Sep 2012

127000 mi

US $157
Pre and post cat oxygen sensors burnt out again. Only reset warning light. 
Apr 2013

130200 mi

US $85
Paid labor for shop to replace the "failed" yet still under warranty oxygen sensors and catalytic converter. 
Apr 2014

136300 mi

US $325
Replaced sway bar end links and front shocks. 
Jul 2015

142200 mi

US $200
Upper and Lower ball joints replaced. 
Apr 2018

147000 mi

US $59
Motor mounts were replaced to stop the vibration at idle while vehicle was in drive. 
Chevrolet TrailBlazer in Kentucky, United States
May 2010 - Jan 2013
Jan 2013

34000 mi

US $45
Had to replace the blower motor resistor. 
Chevrolet TrailBlazer in Wisconsin, United States
Dec 2011 - Mar 2013
Jan 2012

US $650
Replaced both lower control arms, bushings, and ball joints. Also replaced both front stabilizer links and outer tie rod ends. 
Mar 2012

104000 mi

US $24
replaced left rear stabilizer bar link. 
Chevrolet TrailBlazer in Arizona, United States
Feb 2013 - Mar 2013
Mar 2013

147000 mi

US $300
Fix air conditioner 

Return to top

2002 Chevrolet TrailBlazer 4dr SUV

270-horsepower 4.2L I6 4-speed automatic 4WD w/low range

Chevrolet TrailBlazer in Tennessee, United States
Dec 2015 - Jun 2016
Mar 2016

277000 mi

US $800
Coil pack 
Chevrolet TrailBlazer in Illinois, United States
Jul 2008 - Mar 2012
Sep 2008

83000 mi

US $800
Front tie-rods replaced. Injector cleaning. 
Jul 2010

96000 mi

US $1400
Cooling tubes between trans and radiator broke while driving. Also leaking front joints required replacement. Had coolant flushed and replaced. Other maintenance cost. 
Oct 2010

97000 mi

US $450
rear passenger window motor failed. replaced. 
Feb 2011

101000 mi
yet another power window failure. This time rear passeger side. cannot replace as not time to leave car. Living with until school break. Now rear passenger window stopped working. Son in school 12 hours each day so the repair cannot be addressed. Window stays closed as long as nobody tries to use. 
Jun 2011

104000 mi

US $250
passenger rear window motor failed. replaced. 
Oct 2011

105300 mi

US $478
Noise when checking my kid's car made me very uncomfortable. Drove to open Sunday repair shop, turned out to be worn driver front wheel bearings. Really struggled...do not know why. Also had trouble with very rusted tire heat shield. 
Chevrolet TrailBlazer in North Carolina, United States
Jun 2008 - Mar 2010
Jul 2008

63000 mi
Outside ambient temp sensor bad. Replaced with new one. 
Chevrolet TrailBlazer in Nebraska, United States
Mar 2009 - Jun 2011
Feb 2010

126000 mi

US $200
They were getting three engine actuator errors so they replaced it. They had to flush out a sensor on the engine and do a computer update The 4wd was not working and they had to replace the switch. 
Jun 2010

130000 mi

US $280
Rear outer tie rod was loose and worn 
Chevrolet TrailBlazer in Indiana, United States
May 2009 - Jul 2011
Oct 2010

158000 mi

US $161
Front differential seal replacement including labor and parts. 
Dec 2010

159000 mi

US $200
Starting noticing coolant leaking directly under engine; observed coolant residue on block and knew water pump seal leak. Went ahead with replacement of water pump since age of current one is unknown. Replaced fan clutch, thermostat, and coolant temp sensor. Refilled coolant. 159K miles. 
Jun 2011

166000 mi

US $250
Replaced both low and high beam headlights left and right side. Found right side housing was loose from the mounting clip. Adjusted left side housing up w/ adjustment screw to even out headlights. Noticed increased hesitance in starting over several trips in one day. Finally would not start. Had a friend help tow back home (<1/2 mile). Determined starter was issue (OEM part). Replaced with new and also replaced ignition switch. 
Jul 2011

166000 mi

US $20
Vent solenoid on gas tank causing CEL. Problem was exacerbated by running tank low on hot day. Tried filling up tank and overflow occurred. Cooled down and was able to fill. Part purchased but not installed; given to new owner. 
Chevrolet TrailBlazer in Minnesota, United States
Jul 2009 - May 2012
Sep 2009

89000 mi

US $400
Exhaust manifold replaced (cracked) 
Oct 2010

110000 mi

US $100
Rear shocks replaced 
Apr 2012

136000 mi

US $750
Missing. Replaced one coil and 6 spark plugs. 
Chevrolet TrailBlazer in Ohio, United States
Oct 2009 - Sep 2016
Mar 2009

90000 mi

US $250
replaced fan and clutch on cooling system 
Jun 2010

100000 mi

US $800
Rear breaks were dragging 
Jan 2011

133500 mi

US $350
Ac compressor bearing very noisy  
Nov 2011

133000 mi

US $55
Replaced water pump Replaced water pump 
Aug 2014

151200 mi

US $120
right front wheel had grinding noise. Replaced wheel bearing hub assembly 
Nov 2014

152000 mi

US $380
Fuel smell when driving vehicle. Fuel pump has a flaw in the design that caused the fuel lines to corrode (rust) through. Removed the fuel tank, replaced the fuel pump, replaced the fuel tank.  
Dec 2014

152000 mi

US $450
Had to replace fuel pump because fuel lines rusted due to poor design and materials. 
Aug 2015

154600 mi

US $350
Transmission fluid leak. A transmission line to the radiator had corroded through and started leaking. All 4 lines were replaced to save a future trip to the shop. 
Chevrolet TrailBlazer in New York, United States
May 2010 - Aug 2011
Jun 2010

106000 mi

US $80
Front Headlight out 
Jul 2011

120000 mi

US $850
Power steering lines leaking, needed to be replaced 
Chevrolet TrailBlazer in North Carolina, United States
Mar 2014 - Mar 2015
Jun 2014

147000 mi

US $425
Lines to Transmission corroded, leaked, and popped off. 
Jan 2015

149200 mi

US $3000
Lines popped off, overheating Transmission, destroyed transmission, caused engine fire, burned wire harness and computer. This happened twice, the 2nd time causing fire and destroying car. Based on initial tranny repair by shop. 
Chevrolet TrailBlazer in Colorado, United States
May 2014 - Mar 2015
May 2014

86000 mi

US $880
R/F CV and Bearings 
Aug 2014

86900 mi

US $450
fan clutch 
Chevrolet TrailBlazer in Iowa, United States
Sep 2009 - Aug 2016
Nov 2010

71000 mi

US $830
noise from front end,sounded like a wheel bearing or front differential. dealer determined it was right front wheel bearing.  Also found CV joint boot defective. dealer also found several other high cost items defective. 
Jun 2013

89000 mi

US $85
all bushings associated with the sway bar system including frame mount sway bar links.  also replaced lower ball joints both sides and I replaced 3rd brake light myself. the part cost 85.00 

Return to top

2002 Chevrolet TrailBlazer 4-door

6-cylinder automatic 4WD

Chevrolet TrailBlazer in Pennsylvania, United States
Nov 2007 - Mar 2010
Dec 2007

85000 mi

US $450
Front and rear linkages 

Return to top

See TrueDelta's information for all SUVs
See TrueDelta's information for all Chevrolet models.

Chevrolet TrailBlazer Repair Histories

See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how frequently Chevrolet TrailBlazer problems occur, check out our car reliability stats.