| 1 | 0 | 3 | 4 | 3 | 4 |
2002 Ford F-150 repairs by problem area
Engine (38%)
Transmission and Drivetrain (15%)
Brakes and Traction Control (4%)
Suspension and Steering (13%)
Electrical and Air Conditioning (22%)
Paint, Rust, Leaks, Rattles, and Trim (2%)
Other (5%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 144 repairs.
2002 Ford F-150 transmission repair cost distribution
$2500+ (10%)
$1000 - $2499 (0%)
$500 - $999 (29%)
$100 - $499 (38%)
< $100 (24%)
Chart based on 21 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2002 Ford F-150 4dr Extended Cab 8ft bed
260-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range
| 212000 mi | r/r motor in transfer case |
2002 Ford F-150 4dr Extended Cab 6.5ft bed
260-horsepower 5.4L V8 4-speed automatic RWD
| 128000 mi US $800 |
Transmission fluid hose ruptured |
2002 Ford F-150 4dr Extended Cab 6.5ft bed
260-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range
| 125000 mi | Universal joints. |
| 129000 mi US $4000 |
Transmission lines. |
| 151000 mi US $170 |
replaced rear axle seals and bearings |
| 164000 mi | replaced front wheel bearings prior to a trip...more preventative, then acknowledged symptom. but after the repair I noticed the radio antenna lost its wiggle when going down the road. |
| 182000 mi US $30 |
replace a leaking transmission cooler line |
| 184000 mi US $26 |
Replaced transmission cooler line (again, 1st was a Dorman, This time it was replaced with a Motorcraft). It leaked in the same location as the original, the fittings around or near the flex rubber line area. |
| 191000 mi US $375 |
the upper transmission line developed a buldge. replaced aux trans cooler as well as the upper trans cooler line was warrantied replacement |
| 118000 mi US $655 |
Replaced rear differential yoke seal and differential cover. New u-joints front and rear driveshafts. Replaced fluids in both differentials, transmission and transfer case |
| 124000 mi US $4200 |
Transmission torque converter failed leading to no 3rd gear or overdrive. Total transmission rebuild. |
| 68000 mi US $430 |
Rear end pinion seal leak. |
2002 Ford F-150 4dr Extended Cab 6.5ft bed
220-horsepower 4.6L V8 4-speed automatic RWD
| 57040 mi C $188 |
leaking transmission cooler lines |
| 60960 mi | rear axle seals leaking The axle seals began leaking again after a few days. Returned and had seals replaced again. Checked back two weeks later and leaking was stopped. Was either faulty seals or relocating the seals worked (minor pitting on axle). |
| 83080 mi C $190 |
replace front and rear u-joints |
2002 Ford F-150 4dr Extended Cab 6.5ft bed
202-horsepower 4.2L V6 5-speed manual RWD
| 80000 mi US $700 |
Clutch slave cylinder failed. |
| 82000 mi US $300 |
Replaced slave cylinder and clutch assembly. |
2002 Ford F-150 4dr Crew Cab 5.5ft bed
260-horsepower 5.4L V8 4-speed automatic RWD
| 166000 mi US $300 |
Transmission cooler line rusted and leaking. Limited slip axel problems not repaired. |
2002 Ford F-150 4dr Crew Cab 5.5ft bed
220-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range
| 118000 mi US $500 |
Replace neutral sensor. Tighten shifting lever linkage |
| 118000 mi US $800 |
replace leaking transmission lines |
See TrueDelta's information for all Pickups
See TrueDelta's information for all Ford models.
