2007 Ford Five Hundred Ford Five Hundred 2007

We are 103,000+ car owners sharing real-world car information.

Join Us

2007 Ford Five Hundred repairs by problem area

Engine (30%)

Transmission and Drivetrain (6%)

Brakes and Traction Control (8%)

Suspension and Steering (23%)

Electrical and Air Conditioning (25%)

Paint, Rust, Leaks, Rattles, and Trim (3%)

Other (5%)

Chart based on 77 repairs.
See TSBs and recalls for the 2007 Ford Five Hundred.

2007 Ford Five Hundred engine repair cost distribution

$2500+ (0%)

$1000 - $2499 (5%)

$500 - $999 (14%)

$100 - $499 (33%)

< $100 (48%)

Worried about potential repair costs? An extended warranty can provide peace of mind.

Chart based on 21 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

2007 Ford Five Hundred 4dr Sedan

203-horsepower 3.0L V6 CVT FWD

13805 mi replaced water pump under warranty 

Return to top

2007 Ford Five Hundred 4dr Sedan

203-horsepower 3.0L V6 CVT AWD

75300 mi Engine surging at idle or near idle. Would pull ahead when crawling ahead while parking, etc.. Turned out after talking to the dealer that there had been a factory recall for that problem in the past (I had not received a notice). 
46500 mi

C $330
left and right upper mounts replaced 
100000 mi Pressure sensor in AWD system failed. AWD system was not functional. Oil leak on rear valve cover gasket. Gasket replaced. 
155000 mi Low idle surging, caused UN-intended acceleration. TSB issued indicated re-flash of computer and cleaning of throttle body. Issue is fixed. 
10280 mi Had intermittent traction control light-turns out to be the rear differential control module and pump. This is the second 500 that I have had it on and had problems with both units. This one at 10,000, my 2005 at 47,000. send your story to shane.mattix 
54000 mi

US $2000
all wheel drive stopped working 

Return to top

2007 Ford Five Hundred 4dr Sedan

203-horsepower 3.0L V6 6-speed automatic FWD

88600 mi

US $300
Map sensor had water in the lines. They blew them out and said my EGR valve might be bad. 
124000 mi

US $300
Spark plugs replaced 
149000 mi

US $550
Valve cover oil leak and spark plugs 
103000 mi

US $477
Replace engine mounts Replaced valve cover gasket 
108000 mi

US $250
Replace EGR valve 
140000 mi

US $700
Replace leaking fuel tank gaskets 
113000 mi Codes indicated both sides of engine too lean. I believe cause was failure to start when key not held long enough in starter position. Repeatable. 
146700 mi "rollover mount" holding engine to frame broken. Causes slight vibration. Felt light engine running rough when cold idle. (Didn't last long in 100+ temperatures.) Would be $300. Thinking of selling car. 
150000 mi

US $500
Replaced anti-roll engine mount. Bushing in two pieces. 
201000 mi

US $349
Replaced air sensor. It was flaky, ran rough, but not always, so it took a long time to find problem. Another 589 for 200,000 mile service. Take engine almost apart to change plugs. 
46000 mi Catalytic converter flange cracked--part ordered. New catalytic converter flange installed. 
82000 mi

US $160
Cylender 6 misfiire, bad coil 
44600 mi crankshaft seal replaced under warranty 

Return to top

See TrueDelta's information for all Sedans
See TrueDelta's information for all Ford models.

2007 Ford Five Hundred Engine Problems

See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how frequently 2007 Ford Five Hundred problems occur, check out our car reliability stats.