| 1 | 0 | 3 | 4 | 3 | 4 |
2002 Ford Ranger repairs by problem area
Engine (31%)
Transmission and Drivetrain (9%)
Brakes and Traction Control (9%)
Suspension and Steering (14%)
Electrical and Air Conditioning (23%)
Paint, Rust, Leaks, Rattles, and Trim (3%)
Other (9%)
Chart based on 64 repairs.
2002 Ford Ranger engine repair cost distribution
$2500+ (5%)
$1000 - $2499 (11%)
$500 - $999 (16%)
$100 - $499 (21%)
< $100 (47%)
Chart based on 19 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2002 Ford Ranger
Engine not specified
| 140000 mi | Hadn't done any repairs in a while. It hasn't been worth putting money into. Many unrepaired problems: it over heats... there is a low rpm hesitation... |
2002 Ford Ranger 4dr Extended Cab 6ft bed
207-horsepower 4.0L V6 5-speed manual 4WD, part-time w/low range
| 81890 mi US $16 |
Replace idler pully on acc. belt drive. |
| 160000 mi US $200 |
Radiator replaced. |
| 103000 mi US $1300 |
Fuel pump needed to be replaced. |
2002 Ford Ranger 4dr Extended Cab 6ft bed
207-horsepower 4.0L V6 5-speed automatic RWD
| 97100 mi US $3700 |
Leaking head gasket at 97000 miles. While was being done had all gaskets and oil pan done. New plugs, hoses and belts replaced along with regular maintenance items. Ranger looks and runs like it did when new. Better due to upgrades. |
2002 Ford Ranger 4dr Extended Cab 6ft bed
207-horsepower 4.0L V6 5-speed automatic 4WD, part-time w/low range
| 72000 mi US $165 |
Leak in vacuum line caused "Service Engine Light" to appear on dashboard. Vacuum hose was leaking and was replaced. |
| 117000 mi US $750 |
Diagnose faulty fuel pump and replace |
2002 Ford Ranger 4dr Extended Cab 6ft bed
146-horsepower 3.0L V6 5-speed automatic RWD
| 98000 mi US $65 |
chirping coming from engine. Found worn belt tensioner. Replaced belt and tensioner |
| 99000 mi US $17 |
Truck would not start. Traced problem to the fuel pump relay |
2002 Ford Ranger 2dr Regular Cab 6ft bed
146-horsepower 3.0L V6 5-speed manual RWD
| 149000 mi US $85 |
Check engine light and squeal from rear passenger side of engine. Replaced camshaft synchronizer and camshaft synchronizer sensor. |
2002 Ford Ranger 2dr Regular Cab 6ft bed
146-horsepower 3.0L V6 5-speed automatic RWD
| 60000 mi | fuel pump relay replaced |
| 61200 mi | Electric fuel pump |
2002 Ford Ranger 2dr Regular Cab 6ft bed
135-horsepower 2.3L I4 5-speed manual RWD
| 126000 mi US $900 |
fuel pump replaced |
| 208000 mi US $50 |
replaced muffler |
2002 Ford Ranger 2dr Regular Cab 6ft bed
135-horsepower 2.3L I4 5-speed automatic RWD
| 82000 mi US $1000 |
Malfunctioning OBD system |
2002 Ford Ranger 2dr Extended Cab 6ft bed
146-horsepower 3.0L V6 5-speed automatic RWD
| 137000 mi US $150 |
Plastic tank on radiator cracked, replaced with new aftermarket radiator. |
| 149000 mi US $400 |
Front catalytic converters became restricted, causing misfiring and occasional flashing check engine light. Engine was running properly, but had symptoms of exhaust restriction at higher RPM. Replaced y-pipe assembly with new Walker unit. |
| 198000 mi US $560 |
Water pump developed severe leak. Water pump replaced. Lower radiator hose and belt replaced as preventive maintenance. |
| 201000 mi US $80 |
Left valve cover gasket leaking, replaced. Replaced intake plenum o-rings as part of repair. Replaced PCV tube and damaged spark plug wire. |
See TrueDelta's information for all Pickups
See TrueDelta's information for all Ford models.
