Worried about potential repair costs? An extended warranty can provide peace of mind.
Chart based on 107 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
Side mirror control switch had shorted. Replaced under warranty. Replaced side-mirror control switch, under warranty (no charge).
45200 mi
US $146
Rear high brake light socket was replaced, along with bulb. Replaced cigar lighter element.
23000 mi
US $56
Both brake lights failed simultaneously. Took it to the dealer because I assumed it was the switch, but it was both bulbs.
60600 mi
US $10
Brake switch failure causing ABS led failure and brake lights not to come on when activated.
37000 mi
ABS ESC lights passenger seat
80000 mi
US $15
All three tail light bulbs burned out. Dealer replaced brake light switch for free. I replaced the bulbs and purchased them at autozone, dealer wanted 170$ to replace bulbs.
98000 mi
air conditioner light comes on but does not blow cold air. local mechanic says it could be several things but Hyundai does not share complete AC schematics so he is not sure of voltage readings at specific components.
16000 mi
Rear drivers side door lock actuator inoperable. Door removed and door lock actuator repaired/replaced.
48000 mi
US $20
Replaced burned out passenger side low beam halogen bulb.
51000 mi
US $30
Replaced low-beam headlamp on driver's side.
74000 mi
US $20
High brake lamp replaced - rear seat and package shelf had to be removed by dealer in order to replace. Driver's side headlight required replacement.
75000 mi
US $70
Drivers airbag sensor showed as faulty. After troubleshooting it was discovered that technician at other dealership replacing high brake lamp previously had knocked airbag connector loose.
22950 mi
US $2
Needed a new rear driver side brake light
24000 mi
Windshield Fluid Pump died. Dealer replaced under factory warranty.
37900 mi
C $550
Starter had to be replaced
43600 mi
C $450
Starter was no good
44220 mi
C $500
Condenser replaced
125300 mi
US $340
Driver's side window wouldn't go up. Window regulator broken.
94000 mi
The newest issue the ac compressor which sounded like it wanted to fall off.
48360 mi
airbag light - sensor relaced
89600 mi
replaced the windshield washer pump
39060 mi
Air Bag light was on. Issue was a short within the seat belts buckle.
44020 mi
C $210
windshield washer pump stopped working - replaced.
99820 mi
C $491
Lost A/C fluid due to hole in condenser. Replaced condenser - then recharged.
99820 mi
Red airbag dash light stayed on. Seat buckle pre-tensioner was set too high - adjusted and airbag light goes off now.
45000 mi
Air bag light on. Drivers side seat belt buckle failure.
185000 mi
US $400
Starter solenoid went bad. Needed to replace it.
22000 mi
power window switch had bad connection
57000 mi
Power mirror switch functioning intermittently. Was replaced under warranty once after showing identical symptoms. Warranty is over and not going to waste money fixing it again.
70000 mi
Low tone horn broke. High torn hone is behind headlight and easily replaceable. Getting at low horn behind bumper is difficult so decided not to repair.
74000 mi
US $100
driver's side power window regulator broke.
101000 mi
Low tone horn never repaired.
42000 mi
door locks worked intermittently
45000 mi
KEY FOB REPLACEMENT
45200 mi
Received new fob.
70800 mi
US $400
Seatbelt sensor made airbag light come on. Attempt repair twice
39000 mi
The motors for both outside power mirrors needed to be replaced after I noticed that neither of them worked properly.
73000 mi
screeching sound from the engine compartment, owner's guess probably the alternator or water pump
25000 mi
Passenger air bag light stays on when passenger is in seat.
29000 mi
windshield washer pump failure.
29000 mi
right rear power door lock not working
22320 mi
Driver's power seat not functioning properly... switch replaced under warranty New switch installed.
35000 mi
Although I noticed the sensor was having issues detecting a passenger, I didn't received any explanation when regular serviced was done. Hyundai sent me a recall letter and the dealer then removed the seat and send it to a facility for rep.
112700 mi
US $30
outside temperature sensor replaced
116000 mi
US $500
Passenger seat belt sensor needed replacing.
48000 mi
electric door lock actuator replaced
36000 mi
Left rear automatic door lock did not operate properly either by using the remote switch or onboard door switch. Repairs were made and unit is working properly.
37000 mi
Driver's outside power mirror was not working. Dealer installed new switch to correct problem.
63000 mi
US $116
Compressor has a freon leak. Too expensive to fix. Had the shop evac the system and recharge.
40000 mi
Motorist stopped me--No brake lights AT ALL. Switch problem suspected as all three lights did not work. HOwever all three bulbs were indeed burned only 18 months after I bought a new car. Dealer replaced left and right ones at no charge. However I did
82000 mi
US $25
Car suddenly failed to start. Just clicked. Battery was good. Fuel good. Fuses and relays good. Towed to dealer and diag was bad starter. No warning signs, it just died. No warranty coverage for this repair. $600 with tow. Headlight bulb failed almost exactly one year after it was installed. H7 bulbs not lasting long in this car.
85000 mi
US $335
Brake light switch failed, triggering warning light. Switch was known defective had already been replaced 50K miles ago under warranty. This re-repair was essentially covered for the part cost but the labor was not covered.
91000 mi
US $30
Standard annual headlight bulb failure. They last 12 months and die.
65000 mi
US $125
Door lock actuator
24000 mi
Windshield washer stopped working. Dealer replaced pump motor under warranty.
36000 mi
auto-dimming mirror was not functioning
31000 mi
a/c will go extended periods (in excess of 15 minutes) blowing hot air. also smells musty. shop says operating within normal parameters. blew over 85 degrees most of way home.
88300 mi
US $1621
airbag passenger seat mat defective & unrepairable resulting in no functional air bags for car; have to replace seat
90000 mi
US $1500
After having passenger seat replaced approx 4000 miles ago for defective seat sensor which disabled air bag system, replacement seat had same defect and has to be replaced. $1550 for a seat. 100s of complaints reported for this to NHTSA.
42000 mi
headlights would not turn off and alarm would randomly activate. Dealer found shorted fuse box and replaced faulty fuse box.
56500 mi
Seat belt warning lite came on. Dealer removed passenger seat and sent it out to be reprogrammed.
71000 mi
Airbag warning light on. They seem to be backed up on fixing this problem right now and will try next month.
53000 mi
Airbag light issue never fixed. Hyundai said they'd only fix it once.
63860 mi
C $491
Alternator voltage dropped significantly, shop installed a new one
28000 mi
Passenger door would not unlock.
32000 mi
Broken horn
56900 mi
US $310
Could not turn off heater.
66000 mi
US $726
No cooling. Compressor and expansion valve replaced.
23000 mi
Driver front door and rear passenger door would not lock.
31000 mi
Passenger side window regulator replaced.
39000 mi
Same CEL light. District Hyundai Rep. drove car said he drove 50 miles, no CEL light came on. All in all, wasted my time and gas. Problem still not fixed. Guess they didn't learn anything from the Toyota fiasco.
78000 mi
US $160
leak in A/C condensor
94000 mi
US $210
Needed to replace the starter.
105000 mi
US $109
New battery
24000 mi
check engine light indicated a problem with the accelerator position sensor
Intermittent - running or dash lights would come on after turning off ignition. Ran battery down several times. Service thinks might be fuse box controller, but hard to isolate if not occurring continuously.
110800 mi
The horn has started to fail intermittently. I tried taking the front end of the car apart to get at the two horn elements to evaluate them.
115000 mi
High-note horn failed. Low-note horn intermittent.
Took off grille, removed horn, adjusted striker bolt, and re-installed. Horn works perfectly, all the time. Neighbors becoming annoyed with my constant testing.
141400 mi
US $100
Replaced OEM battery
106000 mi
US $90
The rear left door lock actuator wasn't locking/unlocking the door. The unit needed to be replaced
145000 mi
HVAC: Blend door had to be moved manually--actuator failed.
12000 mi
oil change, replace rr taillight
15000 mi
oil change, replace rear third taillight
33000 mi
oil change, replace front fog light
100000 mi
US $340
Airbag light on
56000 mi
Reprogrammed front passenger seat airbag.
95500 mi
Airbag light stayed on, due to malfunction in the passenger seat detection. It's a recall case.
96000 mi
Replacement battery did not charge.
62000 mi
US $360
"Air Bag" idiot light was on. The front passenger seat belt (don't remember which end) had to be replaced. Extended warranty did not cover seat belt replacement.
105500 mi
US $220
Recharged the air conditioning refrigerant. No leak found.
40000 mi
bad door lock actuator causing alarm to not arm or disarm
48000 mi
Headlights burned out.
58000 mi
US $20
Headlight burned out again...left side. RIGHT side burned out again.
21000 mi
AC worked intermittently. Dealer replaced a shorted thermocon. All covered under warranty.
50000 mi
Cruise control would not start consistently. Dealer updated/fixed under warranty. Airbag light stays on due to a broken seat belt sensor. Dealer has ordered necessary part. Waiting to take it in for final fix.
61000 mi
Air bag sensor to detect if there is a rider in front passenger seat had wiring problem.
68000 mi
Air bag sensor in passenger seat had to be replaced. Wiring repair did not hold. Lower portion of passenger seat replaced.
36000 mi
US $20
Replaced a bulb in my left rear brake light.
59520 mi
Airbag lite came on. Something in buckle/tensioner was replaced
89900 mi
C $105
Windows regulator changed due to broken cord. Windows regulator changed due to broken cord. Paid 105 $ for part, installed myself.
132680 mi
C $136
Battery changed
77000 mi
US $345
Pasenger seat belt retainer. Electrical problem. Air bag light came on. Seat belt ; no passenger in seat.
82000 mi
Air bag driver side light on dash. intemittentat times mostly stays on .. heard of many probelms in this area and year. was told to bring for inspection cost 150??? may cost if harness wire is damage. cost 1000 + ..
92000 mi
Air bag light near odometer tried to test , only Hyundai may have proper test equipment .. Told cost 150.00 to 1100.00
95000 mi
dash airbag light on,, after inspection found a warrenttee repair seat belt tessioner resistance out of rangr ,, fixed under warrenttee
97000 mi
US $85
Drivers side air bag light..... Second time in 3 months Drivers side windows control panel, left front window stop working .. swicth not changable needed new panel Dealer parts and label 275.00 did self 1 hour offand on part is made by Borg -Warner check prices , VARY
264000 mi
Passenger seat airbag sensor recall. Seat cushion was removed and repaired.
278100 mi
US $13
Replaced brake stop lamp switch
105000 mi
Airbag system. Dealer sent seat out to have a part replaced. Dropped car off on Monday AM and picked up on Wed PM. Dealer provided a new loaner car.
123980 mi
C $75
Replaced dead horn
78900 mi
US $150
I replaced both front disc rotors and brake pads.
I replaced rear brake pads. Rotors were in good shape.
Air bag light on dash will not turn off due to bad sensor in front passenger seat. Refused to pay $1500.00 to repair. Will live with it.
87000 mi
Passenger seat air bag sensor faulty. Seat was removed & sent to California for repair. Hyundai paid for 8 day car rental.
See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how
frequently 2006 Hyundai Sonata problems occur, check out our car reliability stats.