◆

Toyota Highlander repairs by problem area

Engine (25%)

Transmission and Drivetrain (6%)

Brakes and Traction Control (12%)

Suspension and Steering (13%)

Electrical and Air Conditioning (27%)

Paint, Rust, Leaks, Rattles, and Trim (8%)

Other (8%)

Select a problem area

Need advice about a specific Toyota Highlander problem?

Chart based on 1174 repairs.

See TSBs and recalls for the Toyota Highlander.

Toyota Highlander repair cost distribution

$2500+ (3%)

$1000 - $2499 (14%)

$500 - $999 (20%)

$100 - $499 (34%)

< $100 (29%)

See most expensive repairs

Worried about potential repair costs? An extended warranty can provide peace of mind.

Chart based on 845 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

See repairs for all Toyota Highlander model years.

Toyota Highlander in New York, United States Feb 2022 - Jun 2022
Jun 2022 3000 mi	Recall to correct traction control software issue.

Return to top

Toyota Highlander in California, United States Jun 2021 - Jul 2022
Jul 2022 21000 mi	After much frustration of various inconsistent HD FM radio reception performance from the same locations I did more I investigation and I learned that apparently for marketing and budgetary reasons Toyota decided that not enough people listen to FM anymore to make it important enough to treat properly so they located the FM antenna inside of the rear cargo area driver side window(WHAT ???) This results in poor reception in general however, when you are driving in a direction where the station transmitter has no portion of the vehicle between it and the window with the imbedded antenna, the reception can be OK for a period of time until the route of travel causes the upper portions of the SUV itself to then be in-between the transmitter and the transmitter then the sig al drops immediately.

Toyota Highlander in New Hampshire, United States Apr 2021 - Jun 2022
Jun 2021 2000 mi	4 wheel Alignment, it was out and warranty covered, no charge to customer

Return to top

Toyota Highlander in Tennessee, United States Sep 2021 - Jun 2022
Jun 2022 21000 mi	Recall for software update to address potential traction control issue.

Toyota Highlander in New Mexico, United States Jan 2021 - Jul 2022
Jun 2021 5298 mi	oil change
Oct 2021 10580 mi	Replaced oil & filter
Apr 2022 1524 mi	Sunglass holder door did not work properly. It was replaced under warranty

Toyota Highlander in Ohio, United States Oct 2020 - Jul 2022
Jul 2021 8000 mi	integral seat fan on drivers side makes a high frequency noise (THINK dog whistle) while on the high position. Dealer refused to remedy the noise. They said it was "working" and there for not under warranty. You can only hear it if radio etc. is off while it is running. We are living with it.

Return to top

Toyota Highlander in California, United States Oct 2021 - Jul 2022
Jul 2022 5000 mi	Recall for computer problem

Return to top

Toyota Highlander in Wisconsin, United States Jun 2021 - Jun 2022
Mar 2022 45343 mi US $1071	Replace both front struts due to leakage

Return to top

Toyota Highlander in Ontario, Canada Oct 2020 - Jun 2022
Aug 2021 26660 mi	Right front strut leaking.None in stock,no estimated date of arrival. Dealer replaced both front struts with Monroe aftermarket struts under warranty.Lifetime part warranty. No courtesy car.Toyota Canada would only pay for rental up to Can.$40/day and only after 10 days waiting for the part.
Oct 2021 27900 mi	Burning oil smell.Transfer case which is bolted to the transmission was leaking oil onto exhaust pipe.Transfer case had to be removed and its cover re sealed with a liquid gasket maker.Paid by warranty.Repair took 3 days. No courtesy car.Toyota Canada would only pay for $40/day after 10 days waiting for car to be repaired.

Return to top

Toyota Highlander in Missouri, United States Dec 2020 - Jul 2022
Jan 2022 15000 mi	Replaced low pressure fuel pump. Recall item.

Return to top

Toyota Highlander in Texas, United States Jun 2021 - Feb 2022
Feb 2022 11000 mi	Rattle in dash

Toyota Highlander in Louisiana, United States Dec 2019 - Jun 2022
Jan 2019 5 mi	Dash rattle in front of driver.
Jul 2019 8 mi	All 4 tires feathered. Alignment out of adjustment.
Mar 2022 31000 mi US $380	Vehicle wouldn’t start and needed a boost from a jump starter. Went straight to the dealer who replaced the battery without issue.
Apr 2022 32000 mi US $300	Front and rear brakes were replaced. Rotors machined.

Toyota Highlander in Alabama, United States Jan 2018 - Jun 2018
Mar 2018 1000 mi	Transmission is not as smooth as I would like, especially when vehicle is cold. I haven't taken in for a check yet, but think public should be aware of this issue if they are considering this vehicle.

Toyota Highlander in Texas, United States Jun 2020 - Nov 2023
Oct 2022 69000 mi US $858	Brakes had been shimmying for a couple of years. Started out very mild and got worse with time. Dealer resurfaced rotors and replaced brake pads. Water pump seeping coolant. Water pump replaced.

Return to top

Toyota Highlander in Nebraska, United States Dec 2017 - Sep 2018
Mar 2018 2000 mi	Broken liftgate arm that damaged inside of vehicle upon closing. Repaired arm and paint damage.

Toyota Highlander in British Columbia, Canada Jun 2018 - Jan 2020
Oct 2019 12438 mi	Front grill chrome finish was faulty, replaced grill under warranty.

Toyota Highlander in Delaware, United States Apr 2018 - Dec 2023
Jan 2023 49000 mi US $5000	Oil leak between engine block and timing chain cover. This is a well known problem with Toyota 2GR engines. Just Google "Toyota 2GR timing cover leak" and you will find dozens of articles and videos. It's a small leak but requires complete removal of the subframe, engine, transmission and steering rack from the car. 16 effort hours. Parts cost is negligible but the amount of labor is incredible. I strongly recommend you to check your car for this leak. There are good youtube videos how to look for this problem.
Jul 2023 54000 mi US $500	P0356 - Ignition Coil F Primary/Secondary Circuit Malfunction. Replaced ignition coil cylinder #6. $150 diagnostics, $200 parts, $150 labor

Toyota Highlander in British Columbia, Canada Sep 2021 - Mar 2024
Aug 2023 63240 mi C $75	Repaired leak. New Front pump Seal (torque converter to Oil pump).
Oct 2023 63860 mi C $1400	Replaced all brakes and rotors
Nov 2023 64480 mi C $225	Replaced Battery

Toyota Highlander in Washington, United States Feb 2018 - Oct 2021
Feb 2020 22000 mi US $180	Replace battery. Not really routine at 22K miles, but that was the problem.

Toyota Highlander in Florida, United States Jun 2021 - Jul 2022
Jan 2022 39000 mi	Persistent squeak in rear of vehicle when going over bumps. Turns out it was a loose spare tire mount… it was tighten down the squeak disappeared. No suspension issues.

Toyota Highlander in Georgia, United States Aug 2021 - Jun 2022
Jun 2022 201000 mi US $190	Needed Freon

Return to top

Toyota Highlander in Massachusetts, United States Jun 2018 - Nov 2018
Nov 2018 6000 mi	Entune navigation system randomly reboots while driving. Dealer said no faults found.

Return to top

Toyota Highlander in Washington, United States Apr 2017 - Jun 2022
Mar 2018 14000 mi	Replaced transmission AND transaxle of car purchased new. 13,998 miles. Lemon Law qualified. Additionally DEALER SCRATCHED THE HOOD AND TORE BODY MOLDING FROM VEHICLE. While waiting for body parts, a vibration while driving was discovered. Repaired body and CORRECTLY REASSEMBLED THE EXHAUST. All caused by the dealer.
May 2018 16000 mi	Centered steering wheel and complete alignment. This should have been done as part of the transmission and transaxle replacement.

Return to top

Toyota Highlander in Alberta, Canada Apr 2017 - Jun 2022
Sep 2021 36580 mi C $800	Car had to be boosted 3x. Initial checks found nothing wrong. After 3rd time battery was found weak and was replaced,

Toyota Highlander in Pennsylvania, United States Jun 2017 - Jul 2022
Jan 2018 2000 mi	Audio/Video in-dash radio display stopped working. Screen is off, no settings or backup camera etc. They had to order new in-dash display/radio from manufacturer NOT toyota.

Toyota Highlander in Indiana, United States Jul 2017 - Aug 2020
Jan 2018 5000 mi	Weatherstrip around sunroof had buckled requiring the replacement of the sunroof glass.

Toyota Highlander in New York, United States Feb 2017 - Mar 2018
Mar 2018 10000 mi	Rattle or creak in middle of dash by base of windshield. Not fixed. Only reproducible when it’s cold. Very loud.

Toyota Highlander in Saskatchewan, Canada Dec 2016 - Jun 2022
Sep 2017 7440 mi	Aftermarket electric brake control causes error to appear on screen. Also caused cruise control to stop working. All safety sense to stop working. They say they need to run tests with my trailer attached to do a proper diagnostic. The problem is that my trailer is in storage 4 hours away, so it'll have to wait until spring. I'm pretty sure that they are full of crap, but I don't have the energy to fight with them.
Jul 2018 12400 mi	Finally fixed electronic brake controller.

Toyota Highlander in Massachusetts, United States Nov 2016 - Jun 2022
Sep 2017 6000 mi	Computer / software had to be reset for engine valve to function correctly. Under warranty.
Oct 2021 47000 mi US $1200	Replaced brakes and rotors

Toyota Highlander in Illinois, United States Nov 2017 - Jan 2022
Jan 2022 31000 mi US $257	Alignment, first time. This vehicle is great. I have no issues with this car/

Toyota Highlander in Ontario, Canada May 2017 - Oct 2021
Jan 2018 4340 mi	Control arm replacement, both sides rear. Replaced due to noise. Unresolved.

Toyota Highlander in Ontario, Canada Mar 2017 - Jan 2021
Apr 2017 93 mi	Tire pressure warning light will not turn off. Must return for sensor replacement.
May 2017 62 mi	The tire pressure warning sensor light would not turn off. The technician re-registered the sensor with main computer model.
Mar 2018 3720 mi	The tire pressure warning light comes on regularly when the temperature falls below freezing. It goes off when it gets a bit warmer. Update: started keeping the pressure at least 36 psi.

Toyota Highlander in Alberta, Canada Jan 2021 - Jun 2022
Jun 2022 77500 mi C $1600	replaced wheel. bearings, hubs, brakes and rotors

Toyota Highlander in Ohio, United States Jan 2017 - Jan 2018
May 2017 3000 mi	Harsh shifting, lack of power. Updated the software for the transmission as mine was built before a certain date which had the problem as noted in a Toyota TSB

Toyota Highlander in Kentucky, United States Jun 2017 - Apr 2018
Apr 2018 22000 mi	At 22,000 miles on the odometer, the check engine lights and skid lights came on. I had reduced power. A local auto parts store released the engine from Limp Mode which allowed me to drive it to the dealership where a computer chip was reset. At least, that is what I was told.

Toyota Highlander in Michigan, United States Jan 2017 - Jun 2018
Jun 2018 31800 mi	fuel vapor re-circulation valve stuck open

Return to top

Toyota Highlander in Pennsylvania, United States Jul 2017 - Jun 2022
Aug 2021 34000 mi US $700	Mouse ate through knock sensor wire, replacement required significant engine disassembly.

Return to top

Toyota Highlander in Florida, United States Oct 2015 - Jul 2019
Sep 2016 10000 mi	Cruise control stalk light would flicker occasionally. Handled under Toyota TSB, no charge. Took about an hour once parts were available.

Toyota Highlander in Florida, United States Sep 2019 - Mar 2023
Nov 2019 126778 mi	Clicking when steering and wheel forces itself back to center when turning. Dealer diagnosed as failed electric power steering motor and column, both replaced. AutoNation extended warranty covered all costs. Invoice shows total parts and labor equal to $2,227.86. Works like new now.
Aug 2020 134000 mi US $421	Passenger-side CV boot torn; CV joint beginning to click when in reverse and steering wheel moved all the way to left. Tire Kingdom replaced entire passenger CV axle with OEM part.

Toyota Highlander in Texas, United States Sep 2016 - Jan 2022
Mar 2017 9000 mi	Replaced window trim piece along bottom of passenger front window. Was catching wind and whistling while driving. Required part to be ordered again and another trip to get it correctly installed.
Dec 2017 25000 mi	Rear shock needs to be replaced. Dealer ordered part but has not contacted that part is in.
May 2020 70000 mi US $100	Replaced battery

Toyota Highlander in South Carolina, United States Oct 2016 - Nov 2018
Aug 2017 7000 mi	Cruise control stalk illumination would flicker, only detectable at night. Replaced/repaired ground wire.

Toyota Highlander in Texas, United States Aug 2016 - Oct 2021
Mar 2017 12000 mi	Front left speakers intermittent, this turned out to be problem with wife's iphone
Oct 2017 24500 mi	Clunking noise from front left wheel . Left front brake caliper replaced and CV axle nut was found to be loose Brakes work well, but clunk when applying after moving in reverse

Toyota Highlander in California, United States Nov 2016 - Jun 2022
Dec 2016	I had 125 miles on the car and the transmission jolted...I couldn't get the car past 1st gear (auto trans) . They towed it to the dealer. Check engine light was on. Dealer said it was 1.5 quarts low on trans fluid. This car was brand new.
Feb 2017 1000 mi US $75	Rear passenger tire side wall started separating. Dealer and Toyo Tire company said it wasn't their fault and they said it was road damage. , but the separation clearly wasn't road damage as there was no other marks or damage on the tire. The tire company agreed to a one time "good will" settlement of 75% coverage of the cost . I paid $75.00 out of pocket .

Return to top

Toyota Highlander in Massachusetts, United States Mar 2016 - Jan 2019
Feb 2018 25000 mi US $300	Front Passenger brake pad had premature wear and signs of rotor overheating. 3 other wheels were fine.
Jun 2018 28000 mi	Rear hatch pistons needed to be replace. Premature rusting and noisy when opening.
Jan 2019 37000 mi US $450	Premature front brake "Warping". Brakes were only 1 year old. Something went wrong!

Toyota Highlander in Colorado, United States Nov 2015 - Mar 2018
Aug 2016 8300 mi	Something in the driver seat is moving and "popping" out of place. Irritating when driving. Dealership then broke side of seat trim and needs to replace it. And now the original "fix" is already not working again.
Oct 2016 11500 mi	Seat was doing same "popping" as before, this time the dealer disassembled the seat in house and diagnosed it as the lumbar needing grease which they did and solved it (so far!).

Toyota Highlander in Maryland, United States Mar 2016 - Dec 2017
Sep 2016 4000 mi	The automatic rear hatch does not reliably open using the inside button. The repair was unsuccessful and will have to go back. Update: We discovered that it was happening because you first have to unlock all doors of the vehicle before the tailgate will raise. If you are used to having a sedan and someone wants you to pop the truck, you just pull the lever. However, in the Highlander, you have to first unlock all doors then push the tailgate button. Seems unnecessary to me, but so be it.

Toyota Highlander in Idaho, United States Jan 2017 - Jun 2022
Mar 2017 100 mi	Light came on and was reset by dealer.

Toyota Highlander in Wisconsin, United States Aug 2016 - Mar 2023
Sep 2016 1000 mi	L front passenger window not operable from driver side, only partially worked from passenger side; L sideview mirror puddle light did not work, power mirror did not work, door lock did not work electrically.
Nov 2016 2800 mi	wind noise R side mirror--attempted repair, not successful
Dec 2016 4000 mi	front passenger side door wind noise
Aug 2020 48000 mi	water pump replaced

Toyota Highlander in California, United States May 2016 - Jun 2016
Jun 2016 79000 mi	Brakes needed routine maintenance brake pads were replaced upon driving unexpectedly breaks locked up in order to gain control pumps brakes several times only for this to reoccur and eventually cause smoking of rear brakes

Toyota Highlander in Virginia, United States Jun 2016 - Dec 2017
Mar 2017 9000 mi	Cruise control stalk light was going in and out TSB existed and repairs were made under warrantly

Toyota Highlander in Colorado, United States Aug 2016 - Sep 2023
Jun 2023 148000 mi US $2000	Replace rear hatch motor which has been damaged in a collision several years earlier

Toyota Highlander in New York, United States Apr 2011 - Dec 2011
Jun 2011 65000 mi US $2500	The rear wheels (left and right) sealed bearings wore out.

Toyota Highlander in Alabama, United States Feb 2016 - Jun 2022
Jun 2017 19190 mi	Entune software update per T-SB-0103-16 Cruise control stalk illumination intermittent operation repair per T-SB-0031-16; replaced (1) flange bolt, (2) plate washers, & (1) repair w/ wire terminal
Nov 2017 25825 mi	Replaced OEM battery (bad cell in Johnson Controls p/n 28800-03044 582A/125RC) with Toyota (Interstate) TruStart 575CCA/130RC

Toyota Highlander in New Brunswick, Canada Apr 2016 - Jun 2022
Aug 2017 14880 mi C $75	Wheel Alignment

Toyota Highlander in Ohio, United States Feb 2017 - Jun 2022
Apr 2018 33500 mi	Infotainment system was locking up on startup. Dealer updated the software.
Apr 2019 49000 mi US $550	Replace front pads and rotors. Normal wear maintenance.

Toyota Highlander in Manitoba, Canada Jun 2017 - Jan 2022
Jun 2017 2480 mi	A pump in the fuel system turns on and runs for extended periods when vehicle has been sitting without use for days. Concerned over possible fire hazard with vehicle being in attached garage.
Jun 2018 6820 mi	Right rear shock absorber leaking fluid, leaving puddle on ground. Required two trips to dealer, one to see problem then second to install replacement, as there are no parts stocked in Winnipeg for Toyota and they have to be ordered from Toronto.

Toyota Highlander in Missouri, United States Dec 2016 - Jun 2022
Mar 2022 114545 mi US $1099	Replaced all 4 wheel rotors and pads. Routine service also, Oil, Oil filter, rotate tires.

Return to top

Toyota Highlander in Ohio, United States Sep 2014 - Oct 2020
Sep 2017 42000 mi US $160	Cell in battery went bad. Basic warranty was over and it was not covered.

Toyota Highlander in Alabama, United States Nov 2015 - Apr 2021
Jun 2016 28000 mi	fuel gauge and odometer worked sometimes and not others 2 days in a row. took it in to dealer they ordered part should get back tomorrow.
Jul 2020 205000 mi US $650	Struts front and rear

Toyota Highlander in California, United States Aug 2015 - Jun 2019
Sep 2016 11000 mi US $135	Car would not start, after repeated jumpstarts, determined battery needed to be replaced.
Mar 2018 24500 mi	Driver's door power window was making a strange sound when closing. Dealer replaced power window motor under warranty.

Toyota Highlander in Tennessee, United States Apr 2015 - Jun 2018
Jul 2017 58000 mi US $100	Rubber window trim came out of door frame when window rolled down. Dealer replaced for labor cost only
May 2018 85000 mi US $450	Passenger door lock switch failed

Toyota Highlander in California, United States Sep 2014 - Sep 2020
Feb 2017 24000 mi	Front Doors Lock actuator replaced

Toyota Highlander in North Carolina, United States Jun 2015 - Feb 2022
Oct 2019 30000 mi US $500	Rear hatch powerlifters were making a bad binding sound on opening & closing. Lubrication did nothing, replacement of both lifters was required.

Toyota Highlander in Texas, United States May 2015 - Jun 2018
May 2016 11700 mi US $100	Bad smell from air vents

Toyota Highlander in Hawaii, United States Aug 2015 - Jun 2018
Jul 2016 3200 mi	A/C not functioning due to low refrigerant. No leak could be found. System recharged.
Mar 2017 5000 mi	Found leak in AC expansion valve. Ordered part.
Apr 2017 5000 mi	Install AC expansion valve.

Toyota Highlander in Florida, United States Sep 2016 - Jul 2018
Sep 2017 32000 mi	Window motor malfunction.

Toyota Highlander in California, United States Jan 2015 - Jan 2022
Dec 2017 2100 mi	cigarette ligher didnt have power.
Aug 2021 68000 mi US $1200	the spring arm of hatch door got jammed

Return to top

Toyota Highlander in Minnesota, United States Aug 2014 - Sep 2017
Dec 2014 7000 mi	After only 5000 miles the center console is showing wear through on the finish. Ours has a tan interior so the wear shows a darker plastic under the paint. Dealer says they'll replace it when it's worse or closer to end of warranty.
Mar 2015 14000 mi	There was a popping sound heard on harder bumps. Dealer could not replicate it. It may have gone away now that the weather has warmed up.
Mar 2016 37000 mi	When going over bumps there was a clunk sound. Turned out to be a loose plastic shield. Filled with foam and sound is gone.
Apr 2017 61000 mi	The Entune navigation and audio system began to occasionally freeze and do a self-restart. Other oddities accompanied these issues as well. They installed an update to fix it. Time will tell if it is, in fact, fixed.

Toyota Highlander in Alberta, Canada Oct 2014 - Jun 2018
Sep 2015 19840 mi	The settings for bass and treble would keep resetting to default in a day or two, Toyota updated the software and all is well. Also had a squeak in the drivers door card, they removed and added a sound deadening kit, this took care if it.

Toyota Highlander in Arkansas, United States Nov 2014 - Dec 2016
Nov 2015 12000 mi	The cruise control light on the knob went out.
Dec 2015 15000 mi	The driver side window makes a squeaking noise when being rolled up.
Nov 2016 26900 mi	Window strip on driver side began rubbing against the window after being repaired. Would have needed repair again, had I kept the vehicle.

Toyota Highlander in New York, United States Nov 2014 - Jan 2022
Dec 2016 29000 mi	Noticed water in driver side tail light. Dealer order new part under warranty. Waiting for part to come in.
Mar 2018 46000 mi	The left tail light was half filled with water. Was worried that it would short out. Dealer said it was out of warranty. I told him it was a common problem with these cars. He laughed and said I would have to pay for the tail light and installation.

Toyota Highlander in Maryland, United States Apr 2015 - Jun 2017
May 2015	AWD system warning light came on and disabled AWD system. Dealer cleared the code, and couldn't reproduce error. They believed when dealership filled up gas, they didn't tighten the cap.

Toyota Highlander in Oregon, United States Apr 2015 - Jun 2022
Jan 2018 55000 mi US $850	Right rear wheel bearing failed. Loud humming noise during driving. Replace under warranty at 55,000 miles. Right rear brake caliper was stuck. Inside pad worn down to ~ 0mm, outside pad still at 6mm
Jun 2022 135000 mi US $240	TPMS sensors replaced due to battery failure in at least one of the 4 sensors

Toyota Highlander in Virginia, United States Apr 2018 - Jun 2018
Jun 2018 28500 mi	Replaced driver's seat cushion.

Toyota Highlander in Ontario, Canada Oct 2015 - Jun 2022
Dec 2021 111600 mi	Rear wiper wouldn't sweep fully unless rear window was really wet. I removed rear wiper arm, cleaned and lubricated the shaft and reinstalled. It has been working fine since.
May 2022 122760 mi C $1600	Noticed a strange sound from the passenger side of the engine. It was diagnosed as the water pump.

Toyota Highlander in Alberta, Canada May 2015 - Feb 2022
Dec 2015 9300 mi C $12	Blew two fuses for auxillary plugs, after attempting to run small air compressor. Replaced fuses no other issues.
Dec 2021 83700 mi C $20	replace low beam headlight on passenger side in dec 2021
Jan 2022 C $20	then drivers side [headlight] in Jan 2022

Toyota Highlander in Quebec, Canada Nov 2014 - Nov 2019
Nov 2018 34100 mi C $500	Rear caliper
Jun 2019 34100 mi C $300	Front brake (pad and rotors)

Toyota Highlander in Quebec, Canada Apr 2015 - Jun 2022
May 2017 13020 mi C $175	Car would not start, battery was dead. I call the dealer and did not requirer an appointment drop in the next day after I boosted my car with another battery. They replace it at no charge.

Toyota Highlander in British Columbia, Canada Mar 2015 - Jan 2022
Aug 2017 36580 mi	water pump gone
Jan 2018 41540 mi C $600	pads and drums for front wheels worn out

Toyota Highlander in Arizona, United States Sep 2015 - Jun 2018
Nov 2017 24000 mi	Battery died; replaced under warranty

Toyota Highlander in New York, United States Jun 2015 - Jul 2022
Aug 2017 10000 mi	Battery needed replacement after just 9000 miles and 23 month's
Jan 2022 25000 mi US $1500	Pan leak
Jul 2022 29000 mi US $500	dont know - fixed issue with sudden brake effectiveness

Toyota Highlander in New York, United States Oct 2014 - Jun 2018
May 2015 4000 mi	Heater is erratic in behavior temp control takes 30 minutes to stabilize. A/c controls normal Door locks do not always respond to key fob and unlock, rear hatch get stuck in open position requires manual closing (this SUV is not made for manual closing have to overcome the force of the actuator)

Toyota Highlander in Ontario, Canada Jun 2017 - Jun 2018
Dec 2017 29450 mi	car engine not turning over
May 2018 32860 mi	door panel wrinkled discoloured

Toyota Highlander in New York, United States Sep 2014 - Sep 2017
Sep 2017 44000 mi US $500	Front rotors badly warped

Toyota Highlander in Colorado, United States May 2015 - Apr 2021
May 2018 43000 mi US $445	Coil Spring replacement

Toyota Highlander in Pennsylvania, United States Aug 2017 - Sep 2017
Sep 2017 89000 mi US $3900	crankshaft pulley shattered breaking my serpentine belt, water pump, alternator, and put a hole in my radiator.

Return to top

Toyota Highlander in California, United States Dec 2014 - Nov 2017
Nov 2015 13000 mi	Update to Bluetooth connection system.

Return to top

Toyota Highlander in New Mexico, United States Feb 2017 - Apr 2017
Feb 2017 11000 mi	Power lift-gate intermittently failed to open. Dealer replaced lift-gate control module and door struts as per service bulletin.

Toyota Highlander in Texas, United States Apr 2014 - Jun 2022
Feb 2015 9600 mi	Battery had a bad cell and was dead. Could not jump start so had to tow.
Dec 2015 24000 mi	GPS/Radio Locked up repeatedly and required a hard restart each time. Became more frequent over the last 3 months
May 2017 48000 mi US $600	Brake pads were wearing and needed to be replaced as well as the 2 rear rotors.

Toyota Highlander in Texas, United States Oct 2014 - Jun 2022
Apr 2015 7700 mi	Head unit constantly reboots Coin compartment door broke
Jun 2015 11000 mi	Sunroof kept retracting on closing.would not close, as if obstructed.
Oct 2015 16200 mi	Rubber boot on sunroof fell off and tore.
Dec 2015 18000 mi US $18100	Head unit constantly freezes and reboots. Dealer states nothing can be done until they witness it.
Feb 2016 22000 mi	Rear hatch electric struts were replaced after originals completely failed.

Toyota Highlander in Arizona, United States Mar 2015 - Feb 2022
Jul 2015 16500 mi	AC condensate drain line was installed improperly and was blocked and all AC condensate was collecting under flooring/carpet on the passenger side of the car both front and back seats. All flooring was soaked and smelly & had to be replaced.

Toyota Highlander in Virginia, United States Nov 2014 - Jun 2017
Jun 2017 35000 mi	Automatic rear lift gate did not function correctly. Sensors, computer, and more components (unknown) had to be replaced

Toyota Highlander in California, United States Nov 2014 - Jun 2018
Aug 2017 54015 mi US $550	Replace front and rear brake rotors and pads.

Toyota Highlander in Tennessee, United States Mar 2016 - Jul 2018
May 2018 92000 mi US $2000	automatic powergate stopped working

Toyota Highlander in Alabama, United States Apr 2014 - Jun 2018
May 2016 34000 mi	software upgrade

Return to top

Toyota Highlander in New York, United States May 2014 - Dec 2015
Jan 2015 8800 mi	Problem with electric tailgate

Toyota Highlander in North Carolina, United States Mar 2014 - Jun 2017
Feb 2015 10000 mi	Radio speaker rattled
Sep 2015 17000 mi	Rattling stereo speaker, fixed for the 3rd time in 1.5 years. Bad retainer clip.
Dec 2015 20000 mi	Rattling speaker. This was the fourth time.
Apr 2016 25500 mi	The radio would freeze ( not accept volume or channel changes) then cut off while driving, followed by a safety screen for the backup camera which would display for about 60 seconds. Afterwards, the radio would return to normal.
Jan 2017 23500 mi US $46	PCV cracked. They replaced it with a new one.

Toyota Highlander in New York, United States Feb 2014 - Mar 2022
Sep 2014 10000 mi	Entune keeps dropping Bluetooth calls. Had to get it updated to newer version @ dealer which included the fix.

Toyota Highlander in Ontario, Canada Feb 2014 - Feb 2019
Jan 2016 34780 mi	Headlights replaced due to manufacturing defect. Marks on the inside of both lenses. Faint now but I wasn't sure they wouldn't get worse over time.
Feb 2016 25160 mi	Roof rail gasket shrunk, dealer replaced roof rail and gasket.
Jul 2016 29740 mi	Head unit would lock up/reboot and lose all navigation POIs. Started happening weekly, dealer replaced head unit.
Feb 2017 38440 mi	Rear window struts rusted and were replaced.
Dec 2018 63240 mi C $200	I thought the battery was low because it started hard in the morning. Went to have my oil changed and it died in the garage, which was the best possible place to have it fail - considering it was December 31. They changed the battery and I was good to go.

Toyota Highlander in South Carolina, United States Jun 2015 - Nov 2016
Jan 2016 32800 mi	sun roof drain tube was crimped and had been leaking for awhile into the car under the carpets. All seats and floor carpet removed, mold killed on floor, replaced headliner, carpet and drain tubes.

Toyota Highlander in New York, United States Feb 2014 - Jul 2022
Dec 2015 30000 mi	Bolts that hold the struts to the window on the tailgate were starting to rust and we're repaired under warranty
Apr 2018 64000 mi	Right door speaker blown
Aug 2021 114000 mi US $400	Sunroof motor and controller failed

Toyota Highlander in Indiana, United States Jan 2016 - Mar 2018
Aug 2016 31700 mi US $48	Touch screen problem, entire radio unit replaced.

Toyota Highlander in Texas, United States Dec 2014 - Jan 2022
Jul 2015 15500 mi	the car keep rolling back with the parking brake Driving over 60mph rattle and side trim came off. The trim was installed from the factory incorrect and then Toyota installed it incorrect.
Sep 2015 18000 mi	Toyota decide to take it to a body shop to fix the trim. It got fixed by the body shop four time visit.
Dec 2015 22000 mi	Bluetooth issues and tire repair
Jun 2016 29000 mi US $1	again the side trim came off. second time. also the sunroof trim
Dec 2016 38000 mi	The trim came apart again. They had to take it to a professional Body & Shop repair place. Still not right.
Apr 2017 41000 mi	The power lock on rear right door have stop working with the remote and manual door unlock/lock power. I have not taken into repair yet
May 2017 42154 mi	The NAV would restart on its owned. Also it would blank out and nothing would work. I think this a software or Bluetooth problem.
Mar 2018 55000 mi US $1000	Both door actuators would not open. Toyota replace both under my extended warranty that I bought through Toyota.
Apr 2018 58000 mi	liftgate struts. Update: I have to go back to Toyota to get struts replace because it finally failed and I cant close the liftgate properly. Also the door actuator have failed on three doors. It seem that the designs of the door actuator are known problem when calling the extend warranty.

Toyota Highlander in Florida, United States Jun 2017 - Feb 2023
Aug 2017 39000 mi	Oil change, tire rotation
Jan 2022 89000 mi US $1400	Sunroof leaked and required track replacement. Don’t buy panoramic sunroofs! Sunroof interior covering not retracting.
Apr 2022 91000 mi US $1400	Cost $1,400 to repair retraction roller after $4,000 spent in replacing sunroof track system. Which is to say the sunroof still does not work. Repair coverage denied by Toyota Financial Services Platinum Extended Warranty.
Feb 2023 103000 mi US $750	Resurfaced rear rotors and installed new pads Replace thermostat; flush cooling system and replace coolant.

Toyota Highlander in Louisiana, United States Jan 2015 - Feb 2022
Dec 2021 81000 mi US $1500	Replacement of rear power lift gate that had quit working.
Jan 2022 81000 mi US $200	Leaking noted from roof of car into interior, owner removed trim of roof rails on both sides, caulked around the gaps present in drain holes, no more leaks

Toyota Highlander in Virginia, United States Nov 2015 - Dec 2016
Nov 2015 23000 mi	Automatic rear hatch brought in to dealer twice for malfunction. After second trip, dealer replaced mechanism. Works better now, but is very slow to open and close.

Return to top

Toyota Highlander in British Columbia, Canada Jun 2021 - Jun 2022
May 2022 159960 mi C $800	Brake pads on the 4 wheels needed replacing

Toyota Highlander in Quebec, Canada May 2018 - Jul 2022
Nov 2021 101680 mi C $1500	Complete repair of braking system

Toyota Highlander in Colorado, United States Jun 2014 - Jul 2018
Jan 2015 5200 mi	Trunk power liftgate wouldn't close all the way. Replaced actuators

Return to top

Toyota Highlander in Texas, United States Dec 2013 - Aug 2014
May 2014 2000 mi	Battery had to be replaced

Toyota Highlander in Florida, United States Jan 2013 - Jun 2022
Jan 2014 21300 mi	Defective windshield replaced under warranty. Windshield cracked from the edge up toward the center and left under the rear view mirror. Windshield was either defective glass or damaged during manufacture. Replaced without any problems.
Mar 2017 52000 mi US $125	Dead battery
Jun 2022 100000 mi US $10	One headlight (low beam) died. Replaced both

Toyota Highlander in California, United States Sep 2015 - Jun 2017
Feb 2016 31300 mi	computer

Toyota Highlander in Wisconsin, United States Sep 2015 - Jun 2023
Jun 2016 55000 mi	Drivers side window noisy when closing. Window drive mounting bolts needed tightening
Oct 2017 62000 mi	Replace rear wheel bearing
Dec 2021 88000 mi US $150	Tire light on Replaced 3 tire monitors that were not responding

Toyota Highlander in Wisconsin, United States Feb 2013 - Sep 2018
Dec 2014 45000 mi US $150	Replace failed tire pressure sensor
Jun 2015 55000 mi	Water pump failed Rear wiper failed. Replaced
Feb 2017 101000 mi US $400	Rear brake job.

Return to top

Toyota Highlander in Vermont, United States Jul 2021 - Sep 2022
Apr 2022 113000 mi US $600	Replaced front passenger brake caliper and all brake pads and rotors

Toyota Highlander in Illinois, United States Feb 2013 - Jun 2018
Mar 2018 60000 mi	Popping and rattling noise from under dash. Diagnosed as worn intermediate steering shaft in need of replacement. Decided not to repair at that time.

Toyota Highlander in California, United States Jan 2013 - Jun 2018
Dec 2013 12000 mi	Tire pressure monitoring system required recalibration for persistent warning light
Dec 2016 62000 mi US $175	Driver side window motor
Jun 2017 72000 mi US $239	Seat latch on rear seat was broken and had to be replaced

Toyota Highlander in Ontario, Canada Nov 2013 - Jun 2018
Jul 2016 34900 mi	Rear strut failed. Both were leaking fluid. Both rear struts replaced under warranty.

Toyota Highlander in New York, United States Dec 2013 - Jun 2018
Jun 2015 35000 mi	Replaced rear wiper motor
Jun 2018 78000 mi US $250	Battery died and was unchargeable.

Toyota Highlander in Ontario, Canada May 2015 - Jul 2022
Jul 2022 120280 mi C $800	Front brake pads and rotors. An oil change was also completed.

Toyota Highlander in Illinois, United States Oct 2012 - Jun 2018
Nov 2017 185000 mi US $700	Water pump failed and was replaced.
Jun 2018 208000 mi US $475	Airbag control module and sensor in passenger seat failed requiring replacement.

Toyota Highlander in Alberta, Canada Feb 2017 - Jun 2018
Jun 2017 48360 mi	Tire blow out on highway Power lift arm ripped out of rear hatch door frame. Estimate cost $5000.00- Out of Warranty
Jan 2018 54609 mi	Power Lift Arm ripped out of rear hatch door rame stripping threads. (Reported Japanese Aluminum Refinery sold contaminated aluminium to Honda used in rear hatch. New Toyota Canada Enhanced Warranty is for 8 years or 240000km).
May 2018 57041 mi C $230	Replace Windshield, Rock Shots, Sub Zero Temperature

Toyota Highlander in South Carolina, United States Nov 2013 - Jun 2022
Aug 2021 45000 mi US $300	Replace battery

Toyota Highlander in Washington, United States Nov 2013 - Mar 2018
Dec 2015 55000 mi	Rear differential pinion seal replaced. Could see fluid blowback upon inspection 3 months earlier; subsequent visit showed it to be quite wet. Sign of a problem applies, but there were no non-visual/mechanical symptoms.

Toyota Highlander in New York, United States Jan 2013 - Mar 2016
Jul 2013 5300 mi	door locks not working properly

Toyota Highlander in Alabama, United States Aug 2015 - Aug 2015
Aug 2015 50000 mi	Lots of air noise from day one

Toyota Highlander in Connecticut, United States Nov 2012 - Jun 2017
Jan 2015 6300 mi US $60	battery terminals excessively corroded leaving a white mess on each. Mechanic said it was due to 2 different metals in contact with each other while acid leaked from battery. Told me Toyota does not support a sealed battery for vehicle.

Toyota Highlander in Virginia, United States Nov 2013 - Jan 2022
Jan 2015 24300 mi	Speaker passenger side sounds broken especially when using cell phone over system.
Dec 2016 56000 mi	Tsb for whine around 40 mph. Transmission replaced under warranty.

Toyota Highlander in Minnesota, United States Nov 2012 - Jan 2022
Dec 2018 68000 mi US $57	Rattle in the front end while turning. Phillips Toyota of Leesburg said they could not see any problems. No repair made. After doing my own research it was possibly the intermediate shaft problem or front wheel bearing. I'll have to keep an eye on it myself.

Toyota Highlander in Ontario, Canada Jun 2013 - Jun 2017
Nov 2013 3720 mi	Replace loose driver's side grip assist handle, adjust top of driver's side door to eliminate wind noise.
Dec 2013 4960 mi	Slight steering wander. Alignment was done to correct. Noise in headliner repaired.
Aug 2014 12340 mi	Brake booster noisy. Replaced unit.
Sep 2014 14260 mi	Headlight assy. defect required replacement along with rear hatch name plate trim piece due to corrosion.
Jul 2015 24260 mi	Rear wiper seized, replaced linkage and motor.

Toyota Highlander in Colorado, United States Mar 2014 - Apr 2016
Apr 2016 36000 mi	Bad battery cell. Dealer replaced battery under warranty.

Return to top

Toyota Highlander in Maryland, United States May 2022 - Jul 2022
Jul 2022 105000 mi US $950	Worn brakes Replaced front discs and pads

Toyota Highlander in Montana, United States Dec 2014 - Apr 2018
Dec 2016 31000 mi	Loud whine from hybrid drive train under light load, speeds 35 to 50 mph. Dealer acknowledges noise but says it is not sufficient to warrant repair. Pursuing with Toyota national now.

Toyota Highlander in Tennessee, United States Oct 2017 - Dec 2020
May 2018 45000 mi US $82	A headlight stopped working. Replaced bulb.

Toyota Highlander in Wisconsin, United States Feb 2013 - Jul 2018
Sep 2014 18000 mi	Auxiliary battery shorted out

Toyota Highlander in New York, United States Oct 2013 - Oct 2019
Feb 2014 3000 mi	Check Engine Light came on with message on display to "Check Hybrid System".
Apr 2017 47500 mi US $729	One rear brake caliper was sticking causing rotor to overheat. Replaced 2 calipers, 2 rotors, and pads.

Return to top

Toyota Highlander in Virginia, United States Mar 2012 - Jun 2018
Aug 2017 52000 mi	Drivers side sun visor will not stay put & keeps falling down to obscure the view. I am living with it for now because the new parts alone are estimated at close to $300.

Toyota Highlander in Florida, United States Jul 2016 - Jul 2023
Sep 2016 40000 mi	Strut tower broke, made a loud noise going over bumps. Repaired under the dealer 60 day warranty. During repair they stripped a bolt and had to replace entire strut.
Jun 2021 120000 mi US $1600	Replaced all 4 VVT solenoids
Apr 2023 155000 mi US $700	Replaced rear struts

Toyota Highlander in South Carolina, United States Mar 2015 - Jun 2022
Oct 2021 163560 mi US $24	Replace thermostat.

Toyota Highlander in Nevada, United States Mar 2012 - Apr 2013
Apr 2013 13000 mi	Seat belt buckle needed replacement

Toyota Highlander in Texas, United States Nov 2011 - Sep 2019
Jul 2013 27000 mi	Drip rail molding came loose on both sides of the roof. Dealer replaced them with an updated piece at no charge.
Nov 2013 32000 mi	Battery was leaking around terminal post causing corrosion. Battery was replaced under warranty.
Jan 2017 40300 mi	Driver seat frame broken.

Toyota Highlander in Texas, United States May 2015 - Jun 2018
Jan 2018 50000 mi US $150	Battery and terminal replacement

Toyota Highlander in Texas, United States Nov 2011 - Jul 2022
Dec 2015 123000 mi US $1000	Replaced faulty wheel bearing left rear.

Return to top

Toyota Highlander in New Hampshire, United States Oct 2017 - Jan 2022
Dec 2017 67000 mi	Bought car with a little bit of factory extended powertrain warranty still valid. Heard pinion gear whine when driving, found that Toyota has a Service Bulletin out for a batch of improperly honed pinion gears, took to dealer. Dealer verified and put in a remanufactured transaxle under warranty per the service bulletin. Excellent service, no hassles, car is now perfect! Way to go, Toyota!
Mar 2018 76000 mi US $40	One headlight burned out. I replace all four rather than wait for them to go one at a time. Also, I live in rural NH so I put in a full set of extra bright but legal bulbs rather than standard bulbs. Much better on back roads with no street lights!
Oct 2021 124000 mi US $300	normal servicing (oil, filter, tire rotation, etc) plus installed all LED exterior lighting. Nice improvement in night driving (we live in rural NH and there is not much street lighting here).

Toyota Highlander in Ohio, United States Aug 2017 - Jan 2022
Dec 2017 78000 mi US $120	5 percent of the time the starter would not crank. Starter was replaced and issue went away.

Toyota Highlander in Ontario, Canada May 2014 - Jun 2017
Mar 2017 81840 mi C $150	Replaced rear brakes

Toyota Highlander in Ohio, United States Sep 2021 - Dec 2022
Jun 2022 161000 mi US $200	Flush & fill transmission fluid
Dec 2022 156000 mi US $1200	Alternator and battery

Toyota Highlander in Arizona, United States Feb 2014 - Jan 2022
Apr 2018 72000 mi US $4500	Torque converter threw a "check engine" code...dealer replaced entire transmission.
Sep 2020 97000 mi US $889	Defective alternator

Toyota Highlander in Oregon, United States Dec 2013 - Jul 2015
Feb 2013 8000 mi	Replace master power window control unit.

Toyota Highlander in New Jersey, United States Oct 2014 - Jun 2022
Aug 2020 85000 mi US $100	Tire pressure sensor. Fault was not fixed

Toyota Highlander in California, United States Oct 2014 - Mar 2015
Oct 2014 112000 mi US $425	Water pump was leaking - replaced water pump and then replaced the serpentine belt due to the condition of it at the time while they were in there (saved us on labor)

Toyota Highlander in Massachusetts, United States Apr 2014 - Dec 2016
Oct 2016 111700 mi US $420	Brought it in to have the tires rotated and a brake component got bent and they needed to replace the brakes for the noise to go away.

Toyota Highlander in Tennessee, United States Feb 2016 - Jun 2018
May 2017 69000 mi US $100	T-SB-0034-13 (Steering Intermediate Shaft Noise) Quote: Some 2008 – 2013 model year Highlander and Highlander HV vehicles may exhibit a clunk, pop, or knock-type noise when turning the steering wheel left or right. A new intermediate shaft has been developed to address this condition.

Toyota Highlander in New York, United States Apr 2012 - Sep 2014
Jun 2013 10000 mi	Replace of dead battery

Toyota Highlander in Kentucky, United States Sep 2016 - Jun 2018
Oct 2017 145000 mi	Popping noise from back door opening and closing, Toyota extended the warranty for this problem

Toyota Highlander in California, United States Jun 2013 - Jun 2021
Jan 2014 54300 mi	struts in the hatch started squeaking. Toyota ordered the part for replacement.
Dec 2014 30000 mi	Blower for air condition and heater had to be replaced. Seal in back hatch window was coming off so dealer replaced it. Air condition has a slight squeak when it runs.
Apr 2017 68000 mi US $200	A bolt had come out of the window making it not roll down and up correctly. The bolt was put back on.
Jun 2017 70000 mi US $347	Right Rear Wheel Bearing went bad.

Toyota Highlander in Kansas, United States Jan 2012 - Apr 2021
Feb 2016 74600 mi US $60	Headlight Out
Jan 2017 87000 mi US $180	New Battery

Toyota Highlander in Washington, United States Feb 2012 - Oct 2021
Jun 2017 81000 mi US $300	Replace front and rear brakes.
Mar 2018 95000 mi US $200	Brake service rear

Toyota Highlander in Washington, United States Jul 2012 - Mar 2013
Oct 2012 3000 mi	high pitched engine whine at varied speeds.
Mar 2013	high pitch engine whine that the dealer said was normal

Toyota Highlander in Michigan, United States Jul 2016 - Jan 2022
Jun 2017 58000 mi US $150	Replaced Battery
Jul 2018 69500 mi	Swollen lug nuts caused OEM wrench not to fit. Belle Tire replaced all 24 with different lugs FREE.

Toyota Highlander in Minnesota, United States Aug 2015 - Jun 2018
Jun 2018 63000 mi US $150	Replaced coil on one cylinder

Toyota Highlander in Washington, United States Jun 2012 - Jun 2018
Sep 2012 4000 mi	Drivetrain making a growling/grinding noise. Noise confirmed by dealer. Source not found. Crankcase oil changed. No sign of wear or grinding. Unknown if other components inspected. Holding open ticket.
Nov 2012 5800 mi	Growling noise was still present when the car was due for its 5000 mile maintenance. Brought it to a different dealer who found the left rear wheel bearing had failed internally. Replaced bearing. Problem gone.

Toyota Highlander in Missouri, United States Sep 2012 - Oct 2012
Oct 2012 11000 mi	Clicking noise 50% of the time when shifting from park to drive/reverse. Dealer has replaced the shift mechanism twice. Now they are telling me that this is a common sound on highlanders.

Toyota Highlander in Wisconsin, United States Mar 2012 - Jun 2018
Dec 2016 73000 mi US $750	Driver door handle broke off
Oct 2017 95000 mi US $300	Outrageous issue: The positive terminal for the battery is Not a replaceable item, but costs $2,700 in parts plus 5-6 hours of labor: the full electrical engine harness must be replaced. Who made this incredibly stupid decision? When I told the dealer that I would never buy a Toyota again, they decided to make a repair of their own, where they sawed through the harness and made it possible to replace the terminal only.

Toyota Highlander in Illinois, United States Nov 2017 - Feb 2022
Jan 2018 104000 mi US $380	Check engine light on accompanied with erratic shifting. Car would die at stop lights and could only be re-started in neutral. Dealer found park-neutral safety switch faulty. Replaced switch and car now drives normal. Cyclical loud whirring noise similar to tire noise heard from rear of car. Noise would get louder the faster it was driven. Left and right rear wheel bearings bad. Replaced with aftermarket from an independent shop.

Toyota Highlander in Delaware, United States Oct 2012 - Dec 2015
Nov 2014 48600 mi	Heavy corrosion

Toyota Highlander in Missouri, United States Jan 2015 - Jul 2020
May 2016 69000 mi US $100	R/H rear wheel bearing failed. Replaced by dealer under extended warranty

Toyota Highlander in Massachusetts, United States Nov 2014 - Feb 2020
Oct 2015 54700 mi US $1000	Doors not locking with fob or door buttons. Replaced body ECU
Aug 2016 68000 mi US $100	Replaced original battery due to leaking
Apr 2018 88000 mi US $30	Replaced brake light switch due to codes and ABS warning light

Toyota Highlander in Massachusetts, United States Aug 2015 - Oct 2018
Aug 2015 58000 mi	Rear end locked up/Froze on highway. Toyota certified when purchased and maintenance at same dealership. Total replacement covered under warranty.
Apr 2017 75000 mi	Complete right side of Audio system failed, replaced amplifier. Amplifier did not fix problem, had to replace entire radio/GPS system

Return to top

Toyota Highlander in New Brunswick, Canada Nov 2011 - Dec 2016
Apr 2012 4220 mi	faulty speaker. replaced under warranty

Toyota Highlander in Quebec, Canada Oct 2014 - Jun 2022
Apr 2017 69440 mi C $950	Front drum has been replace after only 35000 KM!
May 2019 105400 mi C $2100	Had to replace complete caliber and disk on 4 wheel rust on back door near Need to replace the cable that allow to unlock the hood
May 2022 129580 mi C $700	Change break disk on allnwhell

Toyota Highlander in Ontario, Canada Feb 2016 - Jun 2018
May 2018 68820 mi C $2253	The oil pump control circuit of the hybrid system malfunctioned.

Return to top

Toyota Highlander in South Carolina, United States Dec 2011 - Apr 2017
Jul 2014 33700 mi	Door alarm for key in ignition was not functioning due to electrical ground issue.

Toyota Highlander in California, United States Oct 2016 - Jun 2018
Jan 2018 66000 mi US $350	All 4 brake pads

Return to top

Toyota Highlander in New Zealand Jul 2012 - Oct 2012
Aug 2012 12900 mi	a bump or knocking in the steering when turning left, toyota replaced steering intermediate shaft as per the 2008 T-SB-0296-08, but problem remains the same, I guess this is a new problem that Toyota has not come across before
Oct 2012 15500 mi	foot brake was going to the floor replacing foot brake parts

Return to top

Toyota Highlander in Texas, United States Sep 2013 - Apr 2022
Sep 2021 168000 mi US $720	Replaced the worn springs and struts with KYB StrutPlus Complete Assembly at all four corners.

Toyota Highlander in Texas, United States Dec 2010 - Jul 2018
Jul 2012 44200 mi US $500	driver side locking mechanism/electrical motor quit working. Was covered under warranty.
Jul 2018 176000 mi	Door lock actuators replaced. Toyota Corp agreed to pay for repair. This was the fifth time they have gone out.

Toyota Highlander in New York, United States Dec 2010 - Apr 2012
Mar 2012 16000 mi	Clunking noise with sharp turn

Toyota Highlander in Texas, United States Aug 2012 - Jan 2022
Dec 2015 90000 mi	Liftgate piston was squealing and not lifting rear gate to 100%. Replaced piston.
Jul 2016 101000 mi	Clicking noise coming from the steering system when turning. Thought it might be CV joints, but Toyota replaced the intermediate steering shaft and problem was fixed. Hinges for rear liftgate have been slightly bent such that a feeler gauge between the hinge and body exceeds 0.005'. Hinges were replaced per Toyota TSB.
Jan 2018 121000 mi US $100	Replaced TPMS sensors in wheels.

Toyota Highlander in Kentucky, United States Apr 2014 - Jun 2022
Jun 2020 99000 mi US $200	Battery was corroding
Jun 2021 102000 mi	Oil cooler pipe burst

Toyota Highlander in California, United States Feb 2012 - Jun 2018
Jul 2012 39000 mi US $250	Moulding coming loose around driver's door and rear hatch windows.
Apr 2015 75300 mi US $1	Battery had gotten super weak, would require jumpstarting after leaving lights on for <1 min.

Toyota Highlander in Florida, United States Jun 2014 - Jul 2018
Nov 2015 38000 mi	Left tailgate hinge bent by automatic lift. Apparently well known, but ignored defect by Toyota.
Dec 2015 38000 mi	Dealer replaced two bent hinges[at my expense] Then said it was the motor. Cost of motor $1200 plus labor. Opted to go to manual operation. Well known Toyota problem that should be a recall item. Toyota no help.
Feb 2017 50000 mi	Entire rear tailgate and motor replaced. Dealer did repair after persistence.

Toyota Highlander in Texas, United States Feb 2011 - Jun 2018
Oct 2016 34000 mi	Driver side visor hinge mechanism broke, will not flip up

Toyota Highlander in Ohio, United States Nov 2015 - Sep 2018
Sep 2018 84000 mi US $1	Muffler heat shield rotted out by bolt holes. Repaired by adding larger washer to secure shield in place.

Return to top

Toyota Highlander in Maryland, United States Feb 2016 - Feb 2022
Jan 2019 86000 mi US $70	The sun visor on the driver side broke. You could not lift it up or pull it down. Husband bought a new one offline and replaced it.
Jun 2020 86000 mi US $40	The arm that controls the power liftgate snapped. Husband bought a new part from the dealer and repaired it.
Sep 2021 87000 mi US $60	A part inside the door panel broke, and the window would not roll up. Husband bought the part online. He had to take the panel off the door. He took out the broken part, installed the new, and the window works fine.
Jan 2022 88000 mi	The arm that connects the power liftgate broke again, about a year after it was repaired the first time. This time we need other parts, as the part we replaced is stripped and the part needs to be welded on this time.

Toyota Highlander in Colorado, United States Jul 2017 - Jan 2022
May 2018 70000 mi US $130	Battery Replaced $129.95

Toyota Highlander in Ontario, Canada Mar 2014 - Oct 2016
Aug 2014 47560 mi C $3500	front end, rack and pinion, intermediate steering shaft
Jan 2016 68200 mi C $4200	rack and pinion , intermediate shaft
Sep 2016 76260 mi C $2600	2nd time problems with the transfer case. This time seals, and transmission seal

Toyota Highlander in Maryland, United States Jul 2012 - Jun 2022
Sep 2021 208000 mi US $100	Oil drip

Toyota Highlander in New Jersey, United States Aug 2015 - Jun 2018
Jun 2016 74000 mi US $130	Alarm system -- would go off by itself. Dealer disabled the alarm (cost to repair the system would have been much higher).
Jan 2018 90000 mi	Routine oil change/tire rotation Car would not start once. Started the next morning - took into dealer, who said battery and systems were fine. No charge for the visit and no problem since.

Toyota Highlander in Colorado, United States Mar 2011 - Sep 2015
Sep 2013 20000 mi	Seal for rear window replaced due to shrinking of original

Toyota Highlander in Massachusetts, United States Dec 2010 - Sep 2011
Aug 2011 12700 mi	Alarm system goes off by itself. Dealer said that was due to the sensor on the hood latch.

Toyota Highlander in Maryland, United States Sep 2014 - Sep 2023
Jul 2015 30000 mi	Worn bearing replaced
Dec 2021 123000 mi US $2000	New shocks/struts installed.
Dec 2022 139000 mi US $100	Looking for issue with decreased fuel economy. Exact problem area unknown.

Toyota Highlander in Connecticut, United States Jan 2015 - Jun 2022
Dec 2015 65000 mi US $200	Check engine light and traction control lights were on. Mechanics trouble shot the evap system for leaks and determined that the problem must exist in a very difficult and expensive to reach area in the exhaust system. We elected not to fix.
Jun 2022 135000 mi US $400	Rubber oil cooler line burst while driving.

Toyota Highlander in Indiana, United States Dec 2009 - Jun 2011
Jan 2010 61000 mi US $27	front suspension bushing worn. Need to replace by taking out strut, installing new bushing, and aligning. Est cost $600

Toyota Highlander in Wisconsin, United States Dec 2010 - Mar 2013
Oct 2012 25000 mi	Driver's side window had developed a rattling noise at speed, so I took it in to get it diagnosed and fixed.
Nov 2012 25700 mi	Rattle was still occurring in driver's side window. Took the car back to the dealer, took them with me on a test drive so they could hear the noise for themselves, and then had them fix it. Had a weird metal-on-metal scraping sound at times when braking quickly. Took the car to the dealer, reproduced the noise for them on a test drive, and then had them diagnose and fix it.

Toyota Highlander in California, United States Dec 2014 - Apr 2017
Dec 2016 29000 mi US $300	car alarm keeps going off once/ twice a week; could not identify problem nor knew about issue, by the way this model is a 2011 highlander AWD

Toyota Highlander in New York, United States Aug 2014 - Oct 2019
Apr 2017 82000 mi US $800	Pads and rotors replaced
Apr 2018 87000 mi US $25	Loose heat shield

Toyota Highlander in Massachusetts, United States Aug 2011 - Jul 2022
Feb 2013 63400 mi US $669	Vehicle made a 'whump whump whump' sound that paced the speed the vehicle was at, started at 30mph and continued through highway speeds. Drivers side wheel bearing hub assembly was replaced.
Jun 2014 101000 mi	Drivers side window was opening at an angle and not closing correctly. Bolt holding the window clamp had come loose and vibrated out inside the door. New coat of loc-tite and 20 minutes of work fixed the issue.
Nov 2015 127600 mi US $115	Replaced the battery, had a couple of rough starts, had battery tested and was showing ready to replace
Aug 2017 162000 mi US $474	Vehicle wouldnt start, just heard a click and then nothing. Started was replaced.
Feb 2018 176000 mi US $740	Vehicle was making a loud noise when driving above 35 MPH. Shop replaced the passenger side rear wheel hub.
Jul 2022 246000 mi US $80	headlight replacement - driver side out

Toyota Highlander in Ontario, Canada Feb 2011 - Dec 2015
Apr 2015 35320 mi C $200	Rear wiper motor, linkage and rear window struts have failed. Despite low mileage and extended warranty only motor will be covered.Dealer has patched as best he could while we wait for parts. Dealer went to bat for me with Toyota to have them honour my warranty on rear wiper. Dealer was helpful but Toyota had an adversarial approach from the start. Powered rear hatch strut came away from car body.

Toyota Highlander in Massachusetts, United States Jun 2011 - Oct 2011
Oct 2011 2000 mi	Loud clicking noise in left front wheel area when shifting from park to reverse and accelerating. Was told that because of the torque, the calipers may shift a little and that it is common in the newer highlanders and tacomas.

Toyota Highlander in New York, United States Mar 2011 - Dec 2012
Jul 2012 23500 mi	bolt which holds drivers side window track fell out

Toyota Highlander in Massachusetts, United States Mar 2013 - Jul 2015
Apr 2013 14000 mi	Rubber roof molding strip came loose

Toyota Highlander in Quebec, Canada Dec 2010 - Mar 2016
Jul 2014 37820 mi	some paint bubble up and some rust.

Toyota Highlander in Alaska, United States Sep 2012 - Jun 2018
Feb 2013 13400 mi	rubber molding that forms part of the rain gutter system blew out, again.
Dec 2015 38000 mi US $100	One lift strut for rear hatch has developed some sort of defect. Unsuccessful attempt to repair it. Repairable only by replacing the strut, a cost of over $500 with part and labor. Not worth this.
Jul 2016 41000 mi US $180	Drivers side window glass became separated from mounting and fell into door cavity. Dealer stated bolts had fallen out of mechanism.
Sep 2016 49000 mi US $300	Power lift strut for rear hatch failed
Feb 2018 67000 mi	Entire rear hatch replaced under some kind of unpublicized recall.

Toyota Highlander in New Jersey, United States Jun 2011 - Jun 2013
Jan 2013 26700 mi	Headlight failure
May 2013 31400 mi	Rear hatch automatic opener/closer failed & dislodged from mounting point resulting in part replacement & body work

Return to top

Toyota Highlander in Quebec, Canada Dec 2010 - Jul 2018
Jan 2014 38300 mi	Driver side window not closing.
Mar 2014 59520 mi	Driver side window previous problem was fixed
Aug 2015 85800 mi C $90	Check engine light diagnosis. Exhaust part required for repair was not available. Light went off by itself after 2 days. Rust on the tailgate. Car is less than 5 years but more than 100000 km dealer said nothing can be done.
Jul 2016 104460 mi C $1600	Rear left wheel bearing Some steering rod part was noisy.
Aug 2016 105400 mi C $25	Right headlight replaced
Dec 2016 109740 mi C $25	Left headlight replaced
Feb 2017 111600 mi C $1200	Right Front & Right rear wheel bearings replaced Since leaving dealer shop ABS, AWD Traction Control lights come on and off.
Sep 2017 120590 mi C $2500	EGR VALVE ASSY CHANGE THE EGR VALVE REPLACED EGR VALVE CLEANED PIPES CLEARED CODES CHANGE THE FRONT RIGHT SPEED SENSOR REPLACED RIGHT FRONT ABS SPEED SENSOR CLEARED CODE NEW RIGHT FRONT SPEED SENSOR FAULY OPEN CIRCUIT AT TIMES ABS LIGHT ON PART ON ORDER ABS ACTUATOR ASSY REPLACED SKID CONTROL ECU AND REPROGRAMED ALL ABS SYSTEM
Mar 2018 130200 mi C $300	Paint over 3 big spots of rust on tailgate. Rust came again. Replaced Windshield Wiper Transmission Linkage
May 2018 132060 mi C $200	REPLACE LICENCE PLATE BULBS AND SOCKET SEIZED [parking brake] CABLE WAS REPLACED

Toyota Highlander in New York, United States Mar 2015 - Jan 2022
May 2016 48500 mi US $550	12V Battery died. Unable to jumpstart due to Hybrid system. Special Toyota Hybrid 12V battery resulted in $500+ repair

Return to top

Toyota Highlander in Quebec, Canada Oct 2011 - Oct 2021
May 2015 48360 mi C $46	Driver's window not descending properly, sometimes a portion of the window not in the door completely.
Apr 2016 61460 mi C $120	Driver Sunvisor broke. Later Toyota issued a recall, apparently wide spread sunvisor problem.
Sep 2016 68200 mi C $160	change back sway bar bushings. Rubber deteriorates probably because antirust treatment (oil) and bad roads.
May 2018 91760 mi C $130	Right side sunvisor replaced (noise, trepidation, very loose)
Oct 2021 106640 mi C $2000	Torque converter to be changed, shaky transmission and shuddering. Estimate CAD $2,000. Didn't do it, added a bottle of additive and traded at the same dealer i bought it from for a new Camry.

Toyota Highlander in Illinois, United States Dec 2010 - Jun 2015
Mar 2013 26000 mi	Loose roof trim. Long piece of rubber trim under passenger of roof. Under the roof-rack
Apr 2013 26500 mi	Loose roof trim. Long piece of rubber trim under passenger of roof. Under the roof-rack

Return to top

Toyota Highlander in Illinois, United States Jul 2011 - Aug 2011
Aug 2011 29000 mi	Bearing worn out. Replaced under warranty.

Return to top

Toyota Highlander in Districto Federal, Mexico Jun 2011 - Oct 2021
Oct 2011 12400 mi	Check engine light turned on while on a 400 km trip back from sea level to Mexico City (2,300m OSL). Car was left for two days at dealership. The mechanic said the cause was transmission overheating, fluid changed as a precaution.
Aug 2012 24260 mi	Driver window elevator failed to work properly. Window could not be kept closed. Dealership changed window elevator for free, as part of original warranty.
Sep 2014 47120 mi $800	Steering column was replaced after identifying extreme wear in a joint.
Apr 2016 63840 mi $1500	Steering column noise first occurred in 2015. After dealer analysis, replacement of steering column was necessary and done. In early March, steering column noise appeared again which required replacement of parts again.

Toyota Highlander in California, United States Sep 2013 - Jun 2018
Jan 2015 104200 mi	Intermediate Shaft replaced due to popping/knocking when turning at low speeds Radio volume knob intermittent. Rotary encoder going bad. Entire Radio Replaced. Non Nav, Non JBL, OEM deck Driver Sunvisor Stuck in down position
Jun 2016 111000 mi	Sun visor repair covered under extended warranty

Toyota Highlander in Kentucky, United States Nov 2014 - Jul 2018
Apr 2015 70000 mi	Driver sun visor broke. Dealer replaced no charge. Toyota stands behind their product.

Toyota Highlander in Arkansas, United States Jun 2011 - Feb 2017
Sep 2015 87000 mi US $400	Struts were worn out so that car suspension felt wobbly on bumps Lower steering shaft needed to be replaced. Steering shaft would "clunk" when steering wheel was turned at very slow speed. This is a common problem reported on the internet (there is a TSB and Toyota redesigned the shaft)

Toyota Highlander in Texas, United States - Mar 2011
Oct 2010 5000 mi	Interior trim replacement Rear window replacement

Toyota Highlander in Alabama, United States Jan 2016 - Jul 2016
Jun 2016 97000 mi US $400	The back hatch/door's struts/shocks fail to keep it raised and open-- as in the only way to open and keep it open is to physically hold it up. All methods of raising it have this same result (key fob, manually, driver button)

Return to top

Toyota Highlander in Wisconsin, United States Feb 2013 - Jun 2018
Sep 2013 37000 mi	One of the pins holding the drivers side window fell out, inside the door. The glass tilted erratically when raising/lowering the window. Dealer fixed it "no charge" while in for an oil change and out of warranty, since oil change took 4hr!
Sep 2017 100000 mi US $1199	Brake job + Rotors for shaking/vibration and excessive wear.

Toyota Highlander in New York, United States Jun 2013 - Jun 2022
Jun 2014 29000 mi	Alarm system - defective hood sensor
Oct 2014 30000 mi	Rust forming around tailgate rear wiper and below license plate. Toyota Rep said it was caused by scratches, but at goodwill would cover 1/2 the cost to repaint, should we choose to have it repainted

Toyota Highlander in Ohio, United States Jun 2011 - Mar 2016
May 2015 56000 mi US $100	Driver door window was making a popping sound. Dealer repaired following Toyota TSB.

Toyota Highlander in Kansas, United States Jun 2011 - Feb 2012
Jul 2011 24000 mi	Strut leaking, replace strut.

Toyota Highlander in Quebec, Canada Jun 2011 - Apr 2016
May 2014 55840 mi	had to replace the motor for rear window wiper

Toyota Highlander in Texas, United States Apr 2012 - Dec 2012
May 2012 16000 mi	One of the end caps on the running boards fell off.

Toyota Highlander in California, United States Jun 2011 - Apr 2012
Sep 2011 31000 mi	Windows do not function properly (cannot open or close). Dealer ordered part but did not repair. Transmission leak. Shop could not find where leak originated from, and painted transmission over to identify leak next time. Front shocks leak Water freezes in doors. Shop could not figure out why because weep holes were clear of junk
Nov 2011 33000 mi	oily transmission. Dealer conclusion was that this is not unusual leak, not a problem. Windows do not function properly

Toyota Highlander in Missouri, United States Nov 2016 - Dec 2017
Dec 2017 67000 mi US $1200	Water pump was replaced.

Toyota Highlander in Missouri, United States Jan 2012 - Nov 2012
Aug 2012 43500 mi US $750	Rear hatch latch was defective causing constant warnings about the rear hatch being open. Car alarm would occasionally be set off, too.

Toyota Highlander in Missouri, United States Jun 2011 - Jun 2022
Sep 2011 34000 mi	Bolt fell out from drivers side electric window. The window would not go all the way down and would slam shut in the up position.
Oct 2011 35400 mi	Replaced Left head light, drivers side. Replaced Left head light, drivers side!!!
Jan 2012 40000 mi	Excessive corrosion on Positive battery terminal and Bat lock down bracket. Never happened to my 2005. Battery has gone dead twice with just the radio on. Doesn't seem to be long lasting. Probably need a new bat less than 2 yrs old.
May 2012 48100 mi	Electrolyte level low in three cells of the battery. Added that filtered water.
Jul 2013 81200 mi	Recurring problem- loose bolt in window scissor mechanism. Caused window to slam shut in closed positipn. Repaired myself this time. Used lock-tight to secure bolt.
Mar 2015 118000 mi US $4	Per Costco mechanic-aluminum cover on lug nuts allows road water and salt to get between lug nut and cover causing corrosion. The cover swells up larger than the 24mm. It is Difficult to remove the lug nuts. Replace lug nuts or gap.
Jan 2018 158900 mi	Alarm would indiscriminately sound off. Most times where 2 or 4 AM. Per internet removed the hood latch limit switch. No more problem but now can’t set up alarm. Dealer Getty too expensive and too evasive about repairs to consider using that company!!!

Toyota Highlander in California, United States Sep 2011 - Jan 2014
Jun 2013 41000 mi US $240	Driver's side sun visor broke, and it would not properly go down. It went down too far (in the down position) which was a safety issue because I couldn't see in front of me.

Toyota Highlander in Indiana, United States Jun 2011 - Jul 2013
Jun 2012 55000 mi US $100	Drivers side power window motor fell out of its mounts. The window was inoperable and fell out of the track.
Oct 2012 63200 mi	Transmission was slipping. After EXTENSIVE (6 days) analysis, no problem was found.

Toyota Highlander in New Jersey, United States Jun 2011 - Apr 2013
Jan 2012 12000 mi	Oil leak. Faulty hose that started leaking after standard oil change.

Return to top

Toyota Highlander in Wisconsin, United States Jun 2011 - Jul 2019
Jul 2011 10000 mi	driver window, clip & track. window would drop, not stay up.
May 2012 16000 mi	noises from the wheel area. Dealer was not able to replicate, so we don't know what the exact problem was/is.
Sep 2012 26000 mi	steering became much looser over a very short period of time. dealer could not find anything wrong.
Nov 2013 37700 mi	wouldn't always start on the first try.

Toyota Highlander in California, United States Feb 2014 - Jan 2022
Feb 2016 64400 mi US $189	Drivers window made noise when lowered
Aug 2016 68900 mi US $1800	Replaced right & left bushings Replaced one motor mount
Jan 2022 109000 mi US $500	Front axle boot torn - replaced boot and other axle parts

Return to top

Toyota Highlander in Arizona, United States Jun 2011 - Jun 2022
Feb 2017 82000 mi US $600	The rear hatch sensor was always showing ajar, even when closed.

Toyota Highlander in Minnesota, United States Oct 2011 - Jun 2022
Apr 2013 34200 mi US $154	Engine light came on - opened the gas cap and replaced it tightly as instruced in manual. We were out of town so brought it to dealer. They reset the computer and light went off. driver side window not operating correctly. Bolt replaced.

Toyota Highlander in Florida, United States Jun 2012 - Nov 2014
May 2014 63900 mi US $78	Window was making noise when going up. Second time it happen since owning vehicle. Passenger arm rest on door panel broke and sunk in. Dealer refuse to fix it. Ridiculous to pay $600 for a door panel just because of arm rest. Vehicle is only four years old and interior parts shouldn't break like this.
Sep 2014 71000 mi	Aux jack wasn't working.
Nov 2014 71000 mi	Passenger arm rest on door panel broke and sunk in. Returned to dealer to have the aux jack repaired, ended up trading the Highlander for a Sienna.

Return to top

Toyota Highlander in New Hampshire, United States Sep 2014 - Apr 2017
Jul 2015 77700 mi US $375	Power window mechanism - wouldn't work
Sep 2015 81000 mi US $50	ignition coil failed

Return to top

Toyota Highlander in California, United States Jan 2012 - Nov 2023
Apr 2012 57000 mi	Replaced water pump. Under warranty.
Nov 2017 153000 mi US $100	Replaced cracked engine mount
Dec 2017 157000 mi US $15	headlamps
Dec 2021 193000 mi	Replaced Rear Brakes and Rotors
Sep 2022 192100 mi US $450	oil cooler line assembly

Toyota Highlander in Alabama, United States Aug 2013 - Sep 2018
Sep 2013 76000 mi	Power steering electric assist motor failed. Twice during the week prior to the failure an intermitant humming noise was heard in the driver side dash area. (At parking lot speeds while turning) Dealer said they'd never seen this before. After the power steering repair, the same whirring noise occured at slow speed turns. The dealer admitted to hearing the noise. They couldn't identify what was wrong and sprayed some sort of lubricant on the steering parts under the dash.
Jan 2014 96200 mi US $500	Rear hatch motor failed.
May 2016 118000 mi US $200	Many electrical failures/issues, seemingly unrelated. Door locks inoperative, engine starting intermittent, security system going off on it's own. The battery was bad. Replaced battery.
Jan 2018 142000 mi US $240	Left front tire pressure sensor failed.

Toyota Highlander in Florida, United States Dec 2013 - Jun 2022
Jul 2015 86700 mi US $523	Intermediate steering shaft replaced.

Toyota Highlander in Florida, United States Feb 2013 - Dec 2015
Mar 2013 39000 mi US $650	replaced two front struts

Return to top

Toyota Highlander in Massachusetts, United States Jul 2017 - Jul 2020
Jun 2018 85000 mi US $6	Replaced passenger side headlight

Toyota Highlander in Michigan, United States Dec 2014 - Apr 2018
Dec 2014 45000 mi US $1200	Replace radiator
Sep 2016 78000 mi US $812	Radiator replaced at 78,000; original radiator had been replaced at 33,000. Strong suspicion that this is a defect which Toyota should report.

Toyota Highlander in Michigan, United States Apr 2012 - Jun 2018
Jan 2014 49500 mi US $120	rear windshield washer pump replaced

Toyota Highlander in Indiana, United States - Aug 2010
Aug 2010 28000 mi	Radio display went out. Replaced radio under warranty.

Toyota Highlander in Ontario, Canada Oct 2012 - Jul 2018
Apr 2013 84520 mi C $193	Replaced rubber oil cooler hose with one made of steel. This due to TSB not being covered by Toyota as car is out of warranty.
Oct 2016 108020 mi C $420	Rear wiper arm seized, and the electrical grid didn't fully work. Solution was to replace the rear window.
Jul 2018 132680 mi C $950	Replaced the rear rotors/pads and emergency brake pads due to wear. The replaced components were not OEM and wore out in one year's time.

Toyota Highlander in New Jersey, United States Jan 2012 - Jun 2022
Feb 2012 35000 mi	Hood latch alarm failure. Hood latch was replaced under warranty. Hood latch alarm failure. Hood latch was replaced under warranty.
Jul 2014 54300 mi US $951	new water pump
Dec 2015 67000 mi US $393	replaced the exhaust gasket, bolt and spring.
Jan 2018 88000 mi US $400	Outer control arm joint cover was ripped. Muffler heat shield mounts rusted.
Aug 2020 122000 mi US $900	they said alternator died and replaced it and tried to charge me $1200 but I had a coupon from email that saved $200. Rip off.
Sep 2021 122000 mi US $700	OIL PAN RUSTED OUT
May 2022 128000 mi US $500	NEW ROTORS AND PADS STRUTS AND SPRINGS

Toyota Highlander in Alberta, Canada Jan 2010 - Mar 2018
Dec 2010 11160 mi	Interior fan stopped working. No air blowing into the cabin at any fan speed. Taken into dealership, supposedly a loose connector, easy repair, no charge as still under warranty.
Mar 2015 32240 mi C $350	Water pump leaking. Require replacement. dealer willing to goodwill 50%.

Toyota Highlander in Alberta, Canada Jan 2012 - Jun 2022
Aug 2017 71920 mi	automatic tailgate stopped working. Nothing done, Toyota says they cannot fix it!
Feb 2018 83080 mi	Replace [power] rear tailgate
Jun 2021 110360 mi C $600	alternator failure. replaced
Aug 2021 112220 mi C $2000	Replace leaking radiator

Toyota Highlander in Maryland, United States Jan 2013 - Feb 2013
Feb 2013 32000 mi US $512	Check engine light came on. Codes revealed Bank 2 o2 sensor 1 faulty

Toyota Highlander in Quebec, Canada Sep 2018 - Oct 2019
Oct 2019 104160 mi C $300	rear-left bearing changed

Return to top

Toyota Highlander in New York, United States Apr 2017 - Jun 2018
Dec 2017 68000 mi US $20	License plate light bulb change. Took more than ten minutes.
May 2018 69000 mi US $400	Changed break pads and rotors

Toyota Highlander in Illinois, United States Jan 2012 - Sep 2021
Jan 2014 60700 mi US $600	Noise heard while turning. Determined to be Intermediate steering shaft failing. Replaced shaft.

Toyota Highlander in Ontario, Canada Mar 2017 - Apr 2017
Apr 2017 124002 mi C $400	replaced all pads and rotors

Return to top

Toyota Highlander in Pennsylvania, United States Jan 2010 - Feb 2019
Feb 2010 13500 mi US $70	Alignment. Problem with tire feathering.
Sep 2010 20200 mi	Replaced Water pump
Jun 2018 121000 mi US $150	Accessory belt tensioner started to lean on one side and only part of the belt was rolling over it. Replaced the tensioner.
Nov 2018 129500 mi US $20	PCV Valve Leaking main seal. Added seal sealant, conditioner Leaking struts. Not replaced

Toyota Highlander in Oklahoma, United States Jan 2012 - Jul 2022
Mar 2012 38000 mi	Radio display goes crazy, especially when cold. You can't adjust anything when it does this. This is the 2nd radio that been installed. Also sometimes the tune knob will not change the station or any other adjustments you make with it.
Apr 2022 168000 mi US $122	Windshield washer pump replaced

Toyota Highlander in Massachusetts, United States - Jul 2011
Jul 2011 28000 mi	Alarm system going off. TSB identified problem as hood switch. Hood switch replaced under warranty.

Toyota Highlander in Florida, United States Oct 2016 - Oct 2021
Aug 2018 140000 mi US $600	Alternator, belt, and tensioner replace

Return to top

Toyota Highlander in Texas, United States Oct 2014 - Nov 2015
Nov 2014 106800 mi US $415	Magnet attached to compressor unbolted itself and fell off car. AC is not able to engage magnetic compressor clutch. Caused AC light to flash on dash. Had to replace
Oct 2015 117000 mi	V6 Cam issue that makes noise upon start. $5000 cost to be repaired covered by Toyota.
Nov 2015 117000 mi	Needed a new top radiator hose, which I bought at dealership and handed over at trade-in time.

Toyota Highlander in Florida, United States Jun 2014 - Jun 2016
Jun 2014 100000 mi US $800	Water pump leaking. Replaced at 100K miles.

Toyota Highlander in Illinois, United States Feb 2010 - Nov 2015
Sep 2013 85000 mi US $250	TSB for oil cooler line replacement. Replaced Rubber hoses with metal tubes.
Aug 2014 99600 mi US $500	Oxygen sensor replaced.

Toyota Highlander in Florida, United States Nov 2007 - Sep 2013
May 2012 66900 mi US $450	Driver's side front window came off track, track was bent, new window assembly installed
Jun 2013 87000 mi US $450	Automatic window opener came off track, driver side front, bent the lifter which had to be replaced

Toyota Highlander in Texas, United States Mar 2008 - Apr 2021
Jun 2015 170000 mi US $1200	Would only blow hot air, would not cool
Mar 2016 189000 mi US $35	Fuse for electric power ports
Mar 2017 205000 mi US $2000	Leaking water pump Replace Axle Boots
Jun 2017 212000 mi US $250	Plastic trim on drivers seat with seat controls came loose
Nov 2017 222284 mi US $365	Replace leaking inner CV boot

Toyota Highlander in California, United States Sep 2012 - Oct 2014
Sep 2014 48000 mi	Water pump bearing

Toyota Highlander in Alabama, United States Feb 2009 - Sep 2011
Dec 2010 56000 mi	Car exhibits a rattling like a collapsed lifter. Dealer says they all do that but could not find me another car of that age and vintage that exhibited the symptom. TSB for engine rattle, replaced timing chain tensioner.
Aug 2011 72000 mi	Aftr earlier work on a TSB instalation the timing chain tensioner came loose tearing up all kinds of internal parts and flooding the engine with metal particles.

Toyota Highlander in Virginia, United States Feb 2018 - Jun 2022
Aug 2018 105000 mi US $566	Water pump leakage.

Toyota Highlander in North Carolina, United States Jan 2013 - Jun 2018
Sep 2017 134000 mi	Main seal leaking oil; had to pull engine to repair A part in the rear brake was broken Brake noise- no problem found

Toyota Highlander in Georgia, United States Nov 2011 - Mar 2013
Feb 2012 29000 mi	Replaced defective cam gears in engine, addressed air bag TSB

Return to top

Toyota Highlander in Ontario, Canada May 2014 - Jun 2017
Dec 2014 94240 mi C $650	O2 And fuel/air flow sensors caused check engine light to come on. Car was drivable but.....
Nov 2015 106020 mi C $70	Loose heat shield
Jun 2016 111600 mi C $90	Exhaust seal
Apr 2017 122760 mi C $1700	Slider seized back pads worn Alt belt

Toyota Highlander in Texas, United States May 2008 - Sep 2015
Jul 2012 99800 mi US $550	Clunking noise when turning fixed by replacing the "core in the steering column". The car now drives better than ever - good road feel. This fixed the mediocre steering feel we had from day 1 owning the car. First ever repair on car!
Jan 2013 95300 mi US $800	Water pump replaced
Mar 2013 117000 mi US $200	Rear brake lights in turn signal housing were not working. Only center light on tailgate worked. Required new harness and connector to restore function. Good samaritan told us brake lights were out - no dashboard warning or alert.
Aug 2014 134400 mi US $200	Air conditioner was not cooling on driver's side of the car. Dealer recharged with dyed coolant to detect possible leak. No leak was found and AC now works perfectly
Sep 2014 136000 mi US $65	Burned out headlamp - Not OEM but previously replaced 3rd party bulb. Replaced with another 3rd party bulb.
Jun 2015 154000 mi US $2100	Interior evaporator was leaking Freon and needed to be replaced. Involved entire dismantling of dashboard to get to it.

Toyota Highlander in Maryland, United States Nov 2009 - Aug 2012
Sep 2011 84000 mi US $330	Truck was having occasional shift flares when shifting in lower gears. The transmission oil was reported as being dirty, so we changed the fluid which took care of the problem.

Toyota Highlander in Minnesota, United States Nov 2011 - Sep 2016
Feb 2016 129000 mi US $389	Front struts making noise. Replaced along with strut links and mounts.
Jun 2016 134000 mi US $400	Navigation

Toyota Highlander in Ontario, Canada Aug 2008 - Mar 2010

Toyota Highlander in Georgia, United States Jan 2010 - Dec 2015
Jul 2012 64700 mi US $75	The water pump was making a lot of noise, and the shaft felt loose, but it had not completely failed. The service manual actually says to pull the engine for this. I was able to change it with the engine in place, but it was a major pain.

Toyota Highlander in Maryland, United States Jun 2018 - Jun 2022
Jun 2018 135000 mi US $600	Front struts
Apr 2022 161000 mi US $300	Driver front wheel bearing

Toyota Highlander in New Jersey, United States Oct 2016 - Jun 2022
Nov 2021 97000 mi US $300	Sunroof drains clogged. Shop drilled new holes for drainage.

Toyota Highlander in Alabama, United States Jun 2014 - Dec 2017
Jun 2014 49450 mi US $50	Car alarm was going off all by itself at random times. Read on Toyota owner's forums that the hood latch could be faulty. Since I had the same problem on my Acura a few years prior, I replaced the hood latch. Found instructions online and replaced in about an hour. Problem solved and alarm system works properly.
Jun 2017 94000 mi US $650	Check engine light came on 1st time in 9 yrs., 94K miles. Engine was misfiring. Problem was oil control valve sensor related to the variable valve timing in cylinder head. Toyota dealer replaced for $650 parts and labor. At the same time, I had dealer replace spark plugs because Toyota recommends at 110K. Total bill $820. Check engine light has stayed off.

Toyota Highlander in Colorado, United States Mar 2015 - Mar 2016
Sep 2015 87000 mi US $450	Strut replacement

Toyota Highlander in Massachusetts, United States Jul 2013 - Jun 2017
Feb 2017 166000 mi US $800	replaced struts alternator failed and replaced
Jun 2017 168000 mi US $400	Drive shaft replacement due to worn u-joints; u-joints are staked-in and not replaceable

Toyota Highlander in Illinois, United States Jan 2011 - May 2014
Jun 2013 60000 mi US $107	Heard grinding noise from engine, no visible leak, replaced water pump, discovered small leak once removed. Replacing water pump solved issue. Dealer cost was very high to perform fix.

Toyota Highlander in Pennsylvania, United States Sep 2010 - Jun 2018
May 2014 97300 mi US $481	Check engine light, dealer found codes for air fuel sensors. Replaced air fuel sensor.
Feb 2017 140000 mi US $1500	Needed new tie-rod but Toyota doesn't sell separate part so had to replace entire steering mechanism.
Jun 2017 144000 mi US $770	replace hub bearing
Nov 2017 152000 mi US $1200	Leak in oil cooler hose. Went through about 8 quarts of oil with multiple stops to buy more oil and refill before I could get it to the dealer. Numerous complications from the leaking oil that had run all over the back and bottom of the car but fortunately the engine itself was still OK. Just saw a post on the web from someone who says they issued a recall for this in 2010, but the dealer mentioned that to us!

Toyota Highlander in Nebraska, United States Dec 2014 - May 2015
Feb 2015 119000 mi US $550	Perform air induction system service. Dealer discovered carbon build up in throttle body when they checked the air filter.

Toyota Highlander in North Carolina, United States Nov 2008 - Mar 2014
Mar 2014 24000 mi US $300	Dead battery. Would not start with a jump. Towed to dealer.

Toyota Highlander in Maryland, United States Nov 2012 - Dec 2012
Dec 2012 100000 mi US $900	Water Pump needed replaced.

Toyota Highlander in California, United States Jul 2015 - Apr 2017
Aug 2015 95000 mi US $1600	The AC was leaking INSIDE the car. Had to pull dash etc.
Apr 2016 109200 mi US $1146	Alternator went out while in a trip out of town, $746 CV boot was torn, $400
Aug 2016 115000 mi US $287	Corrosion on wires on passenger side panel caused alert light to trigger.
Nov 2016 118500 mi US $325	Front and back struts Driver visor no longer stayed up Starter needed replacement
Apr 2017 122000 mi US $850	Rear axle leak. Rear brakes.

Toyota Highlander in Ontario, Canada Sep 2012 - Jul 2015
Mar 2014 76880 mi C $900	the car did not start. thought it was the battery (which was earlier replaced). turned out to be alternator.
May 2014 77980 mi C $1000	Engine oil line "blew up"

Toyota Highlander in Ontario, Canada Dec 2011 - Feb 2022
Nov 2016 107880 mi C $1000	Alternator required replacement.
Jun 2021 151900 mi	A/C lines from front to back require replacement. Parts not available at the time. Job still to be performed.

Toyota Highlander in Colorado, United States Feb 2016 - Sep 2018
Jun 2016 122000 mi US $35	Spark plugs need to be changed.
Jan 2017	HVAC issue. I could not figure it out. Drivers Window not functioning well jerks when going up.
Mar 2017 142000 mi US $200	CV axle passenger side
Sep 2018 155151 mi US $35	Window regulator was bent out of shape.

Toyota Highlander in Ontario, Canada Jun 2010 - Aug 2016
Aug 2011 19220 mi	Abnormal Noise from tailgate. Shocks defect identified by Dealer. Parts ordered. All covered by warranty parts installed free of charge 1 week later. problem resolved.
Jul 2014 31820 mi C $450	coolant pump leakage. replacement done

Toyota Highlander in New York, United States Sep 2008 - Jul 2011
Nov 2010 51300 mi	Water pump began leaking at 50,000 miles. Water pump covered under 5 yr/60K mile power train warranty. Also discovered and repaired an oil seal that was leaking during the same visit.

Toyota Highlander in California, United States Aug 2011 - Jan 2012
Sep 2011 73000 mi	In July the car was in the dealers shop for a grinding sound when starting the car. It was diagnosed as a VVTI problem. The VVTI was replaced under EXT warranty.After a few weeks the car is making the same sound dealer said to keep driving.
Nov 2011 79000 mi US $100	The other VVTI gear went out and had to replaced.

Toyota Highlander in Ohio, United States Jul 2009 - Mar 2016
Aug 2010 46000 mi US $87	Plugged AC condenser hose caused water to seep in and drench front footwells. Dealer cleared the hose and wash/dry carpet.
Apr 2012 54200 mi	Door panel rusting at bottom. Dealer will not fix until rusted completely through. Will be covered until 5 year warranty expires in October.
Dec 2013 61000 mi US $153	Heatshield was loose. Was Replaced
Sep 2014 66000 mi US $56	Engine heat shield disintegrated, making loud metallic noises. Required replacement.
Jun 2015 71000 mi US $958	Needed fuel to air ratio sensors and mass airflow sensors.

Toyota Highlander in New Hampshire, United States Aug 2009 - Mar 2011
Dec 2010 58000 mi US $20	intermittent problems with console features turning off at random. mechanic found a loose connection and problem seems to be fixed.

Toyota Highlander in New York, United States Nov 2007 - Jun 2015
Aug 2009 15000 mi	Had a TSB installed to fix problem with alarm system intermittenly going off. Dealer replaced good latch sensor.
Jul 2012 46000 mi	Replaced noisy water pump under warranty (bearing going)
Sep 2014 86000 mi	Rubber oil hose to cooler failed and was replaced per TSB with a metal hose.
May 2015 96000 mi US $900	Alternator and battery needed replacement

Toyota Highlander in Quebec, Canada Sep 2008 - Jul 2022
Jun 2009 3720 mi	Passenger seat airbag not working, seat was replaced.
Feb 2013 39060 mi	Replacing engine head gasket
Jul 2014 51660 mi	Oil transmision cooler leaking, had to replace the whole unit
Jun 2017 78120 mi C $600	Replaced front disc and pads and rear pads
Nov 2017 82460 mi C $260	Front pipe gasket failed , replaced gasket and bolts/springs
Jan 2018 83700 mi C $950	replaced noisy water pump
Jul 2022 109740 mi C $330	AC not working , found nothing wrong , recharge the system with colored fluid to check for leak

Toyota Highlander in New York, United States Sep 2007 - Aug 2017
May 2008 6000 mi	Smell emitted from air vents. Akin to mulch smell. Dealer replaced Hepa filter and treated system with Ozium.
Oct 2008 11000 mi US $30	Under the drivers side door arm rest cushion is a plastic support piece. This piece cracked. It supports the arm rest cusion from inside the arm rest.
Jan 2010 23000 mi	Radio volume would not function with dial. It did function with steering wheel buttons. Dealer replaced radio under warranty.
Dec 2012 45000 mi US $1000	Replaced bad O2 sensor
Dec 2016 89000 mi US $900	All four struts replaced
Feb 2017 91000 mi US $100	Heat shield rattle

Toyota Highlander in Texas, United States Nov 2016 - Dec 2017
Apr 2017 216334 mi US $380	Plugs and coils replaced to try and cure a P0303 code; did not work.
May 2017 217985 mi	Diagnosed bad CV joint in front; not replaced. Vibration is present starting at 68 mph (gets much worse around 90) and does not abate with change in throttle input.
Jul 2017 219625 mi US $100	Attempted to replace rear bank fuel injectors (cylinders 1, 3, 5) to cure P0303 code. Paused repair due to a stripped bolt that denied me access to the rear bank.
Oct 2017 222565 mi US $350	Front struts replaced to ameliorate a front-end vibration; repair was successful, but front end still vibrates.

Toyota Highlander in West Virginia, United States Jul 2015 - Jul 2022
Feb 2016 123800 mi	Engine oil cooler pipe failed and all engine oil leaked out. Vehicle was towed to dealer and the oil cooler pipe was replaced under an extended warranty.
Jun 2021 207000 mi	Dealer diagnosed leakage from timing chain cover. Estimated cost to repair at $3500.00. No signs of leakage on garage floor yet so will wait until leakage in detected.

Toyota Highlander in Washington, United States Dec 2014 - Mar 2016
Jan 2016 78500 mi US $2000	Oil gasket replacement

Toyota Highlander in New Jersey, United States Apr 2015 - Dec 2022
Feb 2022 234000 mi US $1900	parking brake would not hold. Replaced shoes, hardware, 2 cables.

Toyota Highlander in New York, United States Oct 2011 - Sep 2020
Aug 2013 55300 mi US $104	Paint was wearing off on all exterior handles
Nov 2015 84000 mi	check engine light on, said it was repaired ...it came back on 15 mile away from the dealer Oxygen sensor replaced. Light came back on 30 miles away. Another oxygen sensor was replaced.
Jun 2017 105000 mi US $80	AC not cooling, refilled rather than test for leak to see if it holds. Discussed rust by door handles and around doors - didn't fix
Jul 2017 105000 mi	AC lines to back leaking, replaced

Toyota Highlander in Colorado, United States Oct 2014 - Jan 2015
Dec 2014 95000 mi US $50	Intermediate Steering Shaft was replaced and Drivers Side Heated Seat Replaced under CNA Extended Warranty. Also had Front Brake Pads and Brake Fluid Replaced while at Dealer.

Toyota Highlander in Ontario, Canada Jan 2012 - May 2020
Jun 2012 59520 mi C $600	Drivers window bracket bolt came loose, fell out and resulted in the bracket breaking. Window was fine but dealer stated the bracket couldn't be repaired only replaced at a cost of 300 plus install plus inspection, plus retinting.
Sep 2012 62000 mi	Started feeling weird vibration when driving in the 80km/hr range. Felt like AWD system was acting up. I pulled over switched to low speed 2wd, drove for a couple of blocks at low speed, switched off low range and kept going without issue.
Jul 2014 77500 mi C $250	Alarm started going off for no reason. Hood latch sensor failure. Told it was due to vibrations over time rattling it loose. $150 part
Oct 2015 94120 mi	Inspected vehicle following repeated (and random) flash discharge of battery. Already replaced the battery in October 2014 following the first instance. Issue remains unresolved.
Feb 2016 96720 mi C $1050	Water pump had a crack in it. Replaced it. 6hrs charged time. Fak! O2 sensor spoiling resulted in VSC and engine light warning. VSC not functioning because sensor failure prompted computer to turn it off as it is an "auxiliary function". 3 of 4 sensors failed. Suspect use of injector cleaner. Lower control arm apparently has a seal failure and has to be replaced.
Sep 2018 131440 mi C $450	Rear hub assembly replaced. Constant hum coming from the back wheel with some vibration at around 60-80 km/hr. Same problem occurred on passenger rear wheel about 2 years ago.
Feb 2019 133300 mi C $850	Alternator failed to recharge battery while driving. Replacement was needed, but due to the location of the unit it was a 4 hour repair.

Return to top

Toyota Highlander in Ontario, Canada Nov 2016 - Nov 2021
Oct 2017 122636 mi C $450	Level of engine oils are dropping between oil changes and emissions gazes are entering the cabin somehow from somewhere. This has been ongoing ( emission gas) ever since they changed the heat and a.c. fan about 4 years ago

Toyota Highlander in Ontario, Canada Apr 2008 - Jun 2022
Jan 2009 4960 mi	Check Brake System and Check VSC messages came on. Brake pressure accumulator replaced due to internal leak.

Toyota Highlander in Florida, United States Apr 2016 - Jun 2022
May 2016 115000 mi US $909	Replace relays for hybrid battery
May 2018 182000 mi US $3500	Replace booster pump & brake distributor
Sep 2018 187000 mi US $1500	Replace hybrid battery relay box.
Aug 2021 242000 mi US $2700	AC not cooling. Dash air handler needed replacement.
Apr 2022 252000 mi US $2000	Replace both front end struts and 1 drive shaft.

Toyota Highlander in Oregon, United States Jul 2017 - Jun 2022
Jul 2017 120000 mi US $1250	Repaired front boots that were leaking.
Dec 2017 122000 mi	Suspension was making creaking noises when I turned the car. Shop mechanic said everything was fine, but that the cold weather was probably causing the creaking sound. Since the suspension is a closed system, there is nothing to grease. I can live with the problem.

Toyota Highlander in Wisconsin, United States Feb 2015 - Jun 2018
Apr 2015 105300 mi US $25	R headlight burned out. Replaced bulb.

Toyota Highlander in Florida, United States Feb 2013 - Feb 2016
Sep 2014 90000 mi US $744	Intermediate steering shaft was broken; dealer replaced.

Toyota Highlander in Germany Nov 2008 - Jun 2018
Sep 2009 11160 mi €70	Oem (not toyota) metal valve cap sticks to the valve because of galvanic corrosion. During yearly service the garage mechanic broke the valve by unscrewing it. Tire pressure warning sensor inside tire had to be replaced with a used one ($35+shipping).
Jul 2015 66960 mi €400	Factory default rust points hatchback below tailgate. Toyota would fix that for nothing in USA - but not in Germany...

Toyota Highlander in New Jersey, United States Jul 2010 - Aug 2017
Jun 2013 59000 mi	Evaporator drain clogged. Blew out with compressed air. Still water collecting on passenger side floor.
Aug 2015 100000 mi US $700	Replaced failing water pump

Return to top

Toyota Highlander in Ontario, Canada Sep 2011 - Oct 2011
Oct 2011 62000 mi C $1400	Squeaks from wheel while moving

Return to top

Toyota Highlander in Virginia, United States Feb 2015 - Mar 2018
Sep 2017 145000 mi US $675	Suspension bearing making noise when turning. Replaces front coilovers.

Toyota Highlander in Pennsylvania, United States Oct 2010 - Jul 2013
Jul 2012 117000 mi US $300	replaced lower control arms

Return to top

Toyota Highlander in California, United States Aug 2011 - Jan 2021
Oct 2013 85700 mi	Required replacement of timing chain at 90K miles.
Jan 2016 91700 mi US $476	Struts and shocks no longer have initial bump resistance and shock absorption is declined, so time to replace with KYB units front and rear, new cartridge strut towers in front also.
Jul 2016 110700 mi	Passenger side windshield wiper does not spray.
Sep 2016 114000 mi	Right front passenger side CV axle making a clanking noise. Fixed windshield wiper jet nozzle by replacing wirh new dealer part.
Dec 2016 122000 mi US $150	Stereo head unit losing power, especially on hot days rhe sound is less than volume know setting and muddy = amplifier is going bad.
May 2018 144000 mi US $350	Passenger side front brake was making a noise and upon inspection, the pad wear was more on the outside pad than the caliper side. Dissaembly found that the upper caliper pin was frozen, and required a torch to heat up after soaking with penetrating oil and hammer to drive rusted pin out, lower pin was not rusted. Due to uneven wear on pads ,all brake pads we're replaced with Akebono Pro ACT Ceramic pads but the caliper hanger that the pad is fitted into required replacement on this side only, the driver side was fine. I found out that frozen caliper pins was a problem with many Toyotas in this year from a TSB. Due to uneven pad wear the passenger disc had to be turned as the pad had gotten low enough and off angle to have pad backing run against the rotor. Rotor was still above minimum thickness. Rears were checked and brake caliper pins were fine but all pins were lubricated with Permatix ceramic pin lubricant as the stock moly based lubricant dries out and hardens. The root cause of the pin seizure is the pin rubber boots had torn and let water in to rust the pin.
Mar 2020 163000 mi US $760	Replaced the struts on all wheels with KYB gas adjust units, did not replace springs, but did replace all upper and lower mounts, rubber bushings, front bearings on th shock tower and drives much better = no more body roll.
Apr 2020 164000 mi US $350	Replaced A/F sensors upstream and downstream of the front bank catalytic converter after getting P0430 code from check engine light and VSS warning light coming on. Now car runs much stronger, smoother and is more responsive. One sensor had lazy response and one had a failing heater Circuit. Used DENSO parts and a bottle of Cat-A-Clean by Berryman for $26 and now car runs like new!
May 2020 164000 mi US $1400	Spark plugs were replaced by dealer as you must pull off intake manifold on V6, and had not been done sinc car was new as Iriduim plugs are good for 125-140k miles, but found valve cover gaskets, water pipe gasket leaking, so all was fixed and for a trans full service with 15 qts of Redline D4 ATF 100% synthetic fluid provided by me and now shifts super smooth with no slipping,(it was starting to slip, especially in reverse).
Nov 2020 164000 mi US $900	Right rear wheel started to make howl at 40 mph on sharp right hand turn, worse when back of vehicle was loaded, suspected wheel hub bearing wear. Pulled wheel and turned hub by hand noting significant bearing drag when jacked up off ground on right rear hub of AWD. Bought original Toyota hub and bearing assembly with new wheel lugs, after seeing aftermarket hub quality was not as good as Toyota and decided to not buy Timken bearings separately to put into old hub as most likely the bearing race was damaged. Installed both right and left hub and axle bearing assembly, which requires complete disassembly of drum parking brake inside hub and removal of brake rotor and caliper. Axles now turn freely both sides. Car had been used to tow, go into snow, off road and factory part lasted 160k miles. Toyota buns were $400 each, new axle nuts, caliper mount bolts, and bearings are sealed so good for another 160k!

Toyota Highlander in Rhode Island, United States Jan 2013 - Mar 2016
Jul 2015 145700 mi US $2000	Replaced calipers and rotors in front wheels

Toyota Highlander in New Jersey, United States Sep 2013 - Dec 2016
Oct 2013 96700 mi US $760	Noise/ replaced rear wheel bearing

Toyota Highlander in Maryland, United States Jun 2010 - Sep 2018
Jan 2014 135500 mi US $755	Car exhibited intermittent vibrations at various speeds. Car was sometimes reluctant to move forward in idle on flat surface or slight incline. Driver caliper found to be sticking. Caliper/rotor replaced.
Apr 2014 138300 mi US $700	Rear caliper frozen/sticking. Replaced rear calipers, pads, and rotors.
Aug 2014 140000 mi US $1200	Steel drain plug had been over torqued, stripped threads from aluminum oil pan. Oil pan replaced.
Sep 2018 172000 mi US $180	Serpentine tensioner failed, serpentine belt broke.

Toyota Highlander in Massachusetts, United States Nov 2015 - Sep 2018
Nov 2015 93000 mi	Sunroof drainhose blocked Repair Shop blew air through hose and washed out the blockage. No Charge for Repairs.
Jan 2016 US $750	Right Rear Caliper was frozen an inoperable. Both Rear Brakes, Rotors and Calipers Replaced.
Jun 2018 105000 mi US $120	Moonroof leak. We've had people use compressed air to open the drain hose but it just gets blocked again and again. It may very well be that the drain hose from the front passenger corner is perforated somehow.

Return to top

Toyota Highlander in Texas, United States Aug 2018 - Jun 2022
Sep 2019 165000 mi US $100	This car is just slowly going bad; it's a hybrid and the battery is going out. I had my favorite mechanic go through it, and he said that there are issues with an airflow sensor that are causing a rough idle.
Nov 2021 204000 mi US $1500	General 100,000 mile service + diagnosis of check engine light (evaporative emissions system)

Toyota Highlander in Florida, United States Jan 2020 - Jun 2022
Mar 2020 134000 mi US $2523	Replaced ABS control module. Known problem with this vehicle, date of failure outlasted extended warranty deadline.

Toyota Highlander in New Mexico, United States Dec 2014 - Sep 2015
Sep 2015 63000 mi	The driver's side sun visor had lost its "grip" and would not hold when I tried to fold it up out of sight.

Toyota Highlander in Texas, United States Apr 2013 - Aug 2019
Jul 2013 101700 mi US $300	Radiator's plastic tank (passenger side) cracked o. Radiator replaced.
Oct 2013 105000 mi	dried coolant found around the water pump seal. replaced water pump

Toyota Highlander in Georgia, United States Jun 2010 - Sep 2013
May 2013 68000 mi US $965	water pump leak. Replaced pump and damaged timing belt.

Toyota Highlander in Maryland, United States Feb 2017 - Mar 2018
Mar 2017 203000 mi	Hybrid inverter transistor replacement They recommended the timing belt and water pump be replaced along with leaking cam and crank seals (11 hrs labor). The tech showed me the covers were sprayed with oil inside from the cam seals leaking.

Return to top

Toyota Highlander in Massachusetts, United States Sep 2010 - Jun 2011
Oct 2010 21000 mi US $500	Wheel bearing noise was the Front Left Bearing - replaced under factory extended warranty, but dealer said it wouldn't have been covered if it was a rear bearing.

Toyota Highlander in Massachusetts, United States Apr 2016 - Nov 2016
Jul 2016 130800 mi US $1000	Mechanic noticed that boots on left front axle were torn. He tried to pull axle apart to clean and grease, but was unable to. Hybrid axles are different than standard. Ended up getting new axle from dealer.
Nov 2016 135000 mi US $100	Left rear brake backer plate was bent and rubbing on something moving. They removed it. They told me that putting a new one back on will be expensive.

Toyota Highlander in Kentucky, United States Jun 2010 - Mar 2017
Apr 2011 51000 mi US $25	CAR WOULD NOT START AFTER MAJOR RAIN STORM. CAR TAKEN TO DEALER WHERE CAR STARTED EASILY AND PROBLEM NOT DIAGNOSED WITH ALL TESTING NEGATIVE.
Nov 2012 69700 mi US $517	GPS became unreliable and diagnosis was damaged Data DVD which was replaced
Nov 2014 88000 mi US $1581	Coils (2) quit, replaced timing belt and water pump at same time
Sep 2015 93000 mi US $780	Replacement of rear brakes, rotors & calipers
Feb 2016 96000 mi US $1400	tHE FRONT BRAKE SYSTEM WAS REPAIRED/REPLACED AND SOMETHING ELSE WAS DONE (I DON'T KNOW WHAT HE SAID).

Toyota Highlander in Maryland, United States Jun 2015 - Oct 2020
Jan 2017	Window off track

Return to top

Toyota Highlander in North Carolina, United States Jul 2012 - Jun 2016
Mar 2016 147000 mi US $475	Catalytic converter failed -- replaced. Alternator failed -- replaced.

Toyota Highlander in Ohio, United States Jan 2012 - Jun 2022
Mar 2017 121000 mi US $312	Alternator bearing wearing out. Alternator replaced.
Jan 2022 150000 mi US $1224	Serpentine Belt replaced. Battery Replaced Rear Brakes; Calipers, Pads, Rotors. Valve cover gasket replaced.

Toyota Highlander in Illinois, United States Dec 2014 - Jul 2018
Jul 2015 112700 mi US $167	Noise in front brakes, replaced left front caliper, adjusted brakes.
Mar 2016 124000 mi US $225	Car was loosing power and battery light came on dash, eventually lost power. Replaced the battery which was in older anyway to avoid a tow, drove to mechanic and replaced the alternator with aftermarket part.

Toyota Highlander in West Virginia, United States Oct 2016 - Oct 2016
Oct 2016 156000 mi US $700	wheel bearing so bad that they did not recommend that I drive the vehicle home due to safety issues.

Toyota Highlander in Maryland, United States Mar 2012 - Mar 2013
Mar 2013 101000 mi US $700	Front struts replaced and rear brake job completed

Toyota Highlander in New York, United States Nov 2014 - Jul 2017
Dec 2014 112000 mi US $1000	Car wouldn't turn over, or was intermittently turning over. Claimed the dead battery had messed up throttle control valve (whatever that means) Replaced it. All I know is the car starts now.

Return to top

Toyota Highlander in Texas, United States Feb 2017 - Mar 2017
Mar 2017 174000 mi US $100	Leaking coolant , close to the oil filter

Return to top

Toyota Highlander in North Carolina, United States Sep 2009 - Jun 2011
Apr 2010 76000 mi	Gas cap improperly closed so the car detected an exhaust leak. Engine and Traction Control lights were on. Once the gas cap was installed properly and the codes reset the lights did not return.

Toyota Highlander in Virginia, United States Oct 2009 - Oct 2012

Toyota Highlander in West Virginia, United States Feb 2012 - Sep 2012
Mar 2012 198000 mi US $1465	Water pump replacement, including timing belt

Toyota Highlander in North Carolina, United States Sep 2009 - Jul 2022
Mar 2014 179000 mi US $190	Check engine light came on. Took a few days to diagnose the problem - something with EVAP system. Canister was suspect but they replaced gas cap and tightened a hose clamp. So far this has been sufficient.
Jun 2015 205000 mi US $620	Rear passenger electric window failed. Replaced motor
Apr 2017 228000 mi US $2	Automatic climate control was broken. I repaired the wiring to temp switch. No cost but some hours of labor.

Return to top

Toyota Highlander in Venezuela Apr 2018 - Nov 2018
Nov 2018 119040 mi $1200	Right rear strut broke internally. Both rear struts replaced

Toyota Highlander in Virginia, United States Feb 2015 - Dec 2017
Jul 2015 133300 mi US $850	Window stuck in down position. Had to replace both window and regulator.
Jun 2017 151000 mi US $1000	Replaced both front lower control arms.
Aug 2017 156000 mi US $950	Alternator failed and was replaced with an OEM unit.

Toyota Highlander in Maryland, United States Mar 2015 - Apr 2018
Dec 2015 155000 mi US $47	Power steering pump and hose failure. Low tire pressure gauge reset.
Feb 2016 156700 mi US $300	Rusty exhaust part replaced.
Nov 2016 165800 mi	Reported leak in ABS module - waiting to determine the extent before repairing. Update after sold car: As it turns out it was a very minor leak and never really caused an issue with the brakes. We drove it as it was and no service center ever mentioned it again.

Toyota Highlander in Massachusetts, United States Oct 2011 - Jun 2012
Nov 2011 56000 mi	Problems known at time of purchase and agreed by dealer to be repaired. No cost & loaner supplied. Both rear wheel bearings and spindles replaced, worn. Front brake pads replaced. Water pump leaking. Replaced pump and T-belt.

Toyota Highlander in British Columbia, Canada Aug 2010 - Sep 2016
May 2011 55180 mi C $90	Purge valve cleaned
Apr 2014 95560 mi C $1500	Rear wheel bearings

Toyota Highlander in Ontario, Canada Jan 2013 - Jan 2016
May 2013 48360 mi C $1800	Had transmission oil leak that required the drive-shaft and other components to be removed in order to fix the leak. Parts were only 10% of the repair, the rest was labor.
Aug 2015 58280 mi C $1200	Replaced leaking transfer case seals

Toyota Highlander in Massachusetts, United States Aug 2016 - Jun 2018
Oct 2017 68000 mi US $900	New battery Replaced two accessory belts except for drive (serpentine) belt.

Toyota Highlander in Minnesota, United States Feb 2009 - Jan 2022
Jul 2017 152000 mi US $400	Tune up - plugs/wires also front rotors were warped a bit so replaced them and new brake pads Replace Alternator. The battery light came on so I checked voltage with a multimeter and did a self diagnosis. I kept a charger on it at night and turned off electronics and limited driving until I could get it in for repair.

Toyota Highlander in Virginia, United States Aug 2015 - Apr 2017
Mar 2016 82000 mi US $400	Had Timing Belt, Drive Belt and Water Pump replaced. Timing Belt was past due due to the age of the car. The water pump was leaking slightly.

Toyota Highlander in Ontario, Canada Nov 2007 - Mar 2010
Aug 2009 31000 mi C $523	Slight intermittant "clunk" type feeling through the steering wheel, mainly when turning wheel hard over to left and then correcting when backing out of a parking spot. Replaced steering wheel shaft. Replaced rear brake pads and calipers and refinished rotors.

Toyota Highlander in Michigan, United States Nov 2007 - Jun 2022
Jan 2011 61000 mi	Transmission was intermittently "hard shifting". No codes were set. Mechanic was able to replicate by driving vehicle. Toyota replaced the transmission & covered 100% of cost of repair (although out of warranty), as I had brought it in twice previously for same issue with no resolution.

Toyota Highlander in South Carolina, United States Jul 2008 - Feb 2018
Dec 2016 74000 mi US $752	Key fobs stopped working and system wouldn't enter programming mode (tried changing fob batteries first). After two days of intermittent success, replaced sending unit located in year hatch.

Toyota Highlander in Minnesota, United States Sep 2012 - Jan 2013
Jan 2013 99000 mi US $380	passenger side rear wheel bearing failed.

Return to top

Toyota Highlander in Texas, United States Mar 2012 - Feb 2014
Aug 2013 153400 mi US $1300	AC Condenser leak

Toyota Highlander in Alabama, United States Mar 2016 - Dec 2016
Jun 2016 85000 mi US $100	Replaced CV axle on front passenger side. Vehicle had lots of shaking when brakes were applied. Once replaced, vehicle drives like new.

Toyota Highlander in Nebraska, United States Dec 2014 - Jul 2018
Apr 2017 138000 mi US $1200	leaky transmission seal needed to be replaced
Jul 2018 149000 mi US $1100	[blend door] motor for thermostat change botton

Toyota Highlander in Illinois, United States Nov 2008 - Dec 2015
Mar 2009 36000 mi	Adjusted brake pedal for brake light switch to activate.

Toyota Highlander in Missouri, United States Sep 2013 - Feb 2017
Mar 2015 130000 mi US $250	The framework the operates the passenger window was bent and had to be replaced.
Jul 2016 153700 mi US $759	Water pump for hybrid system failed: had to be replaced
Dec 2016 164000 mi US $310	Replace right rear wheel bearing due to VCS/ABS warning lights activated.

Toyota Highlander in Minnesota, United States Feb 2008 - Mar 2010
Jan 2008 32000 mi	Failure of Hybrid Inverter.

Toyota Highlander in Puerto Rico Sep 2013 - Jun 2018
Sep 2014 91000 mi US $1600	Break actuator fail again in a year.
Nov 2015 103000 mi US $3100	Hybrid Battery
May 2018 130000 mi US $1600	Brake actuator again
Jun 2018 131000 mi US $317	Replaced shocks

Toyota Highlander in California, United States Mar 2008 - Apr 2011
Mar 2011 45000 mi	Replaced hybrid inverter

Toyota Highlander in Ohio, United States Nov 2012 - Jun 2022
Jun 2014 132000 mi US $450	Radiator replaced
Jul 2015 144500 mi US $900	AC condenser needed replaced as AC stopped working
Jun 2022 237000 mi US $550	AC Condenser had a hole it in, so AC stopped working

Toyota Highlander in California, United States May 2016 - Jan 2022
Jun 2018 150000 mi US $169	Our non-hybrid battery died after a door failed to latch and the interior lights stayed on for 36 hours. Our fault completely!
Sep 2021 197000 mi US $700	Replace radiator and water pump

Toyota Highlander in Jordan Jan 2015 - Jul 2015
Jan 2015 93000 mi $250	Car started overheating very quickly. Turns out the radiator was busted. Part of the radiator needed to be replaced.
Feb 2015 93400 mi $1000	My ABS started malfunctioning, driving was ok except for odd noises and choppy brakes at very low speeds. Had to replace the ABS which is very costly at the dealership, so I bought it used instead.
Jun 2015 95480 mi $50	AC has been problematic for the last couple of years, but replacing the gas at a respectable shop fixed this. Problem started when the car's radiator failed and ended up with a small hole (details in a different entry).

Toyota Highlander in California, United States Jul 2010 - Mar 2013
May 2011 51000 mi	Tear in leather fixed under warranty.
Mar 2012 88000 mi US $180	Needed new battery

Toyota Highlander in Indiana, United States Jan 2010 - Mar 2018
Jul 2014 126800 mi US $400	Power windows in rear stopped working due to sliding of glass-holding trim piece out of place.
Jul 2015 143500 mi	Sunroof stopped opening and closing. Left rear window came off track.
Dec 2015 150000 mi US $400	Half shaft (Left)
Nov 2017 174000 mi US $600	O2 sensor and hose
Feb 2018 181000 mi	Right Rear Window came off track. Was replaced under warranty by SAFELITE

Return to top

Toyota Highlander in Virginia, United States Oct 2009 - Oct 2012
Jul 2009 38500 mi US $50	Purged brake actuator as recommended by Toyota dealer to address actuator squeak issue. Process was not successful. Was informed I need a new actuator at ~$2000 repair cost.

Toyota Highlander in New York, United States Sep 2013 - Nov 2016
May 2015 114000 mi US $110	Hood latch replacement
Aug 2016 130000 mi US $70	Milliamp drain on battery traced to the security circuit. Pulled the fuse and reinserted it. Drain went away

Toyota Highlander in Michigan, United States Dec 2014 - Dec 2017
Aug 2017 170000 mi US $350	Light stayed on

Toyota Highlander in Connecticut, United States Sep 2014 - Dec 2014
Sep 2014 120000 mi US $95	Check Hybrid, check VSC lights; diagnosed as under-charged regular (non-hybrid) battery; topped off charge Problem not solved.
Oct 2014 120000 mi US $800	Check hybrid light and check VCS light; diagnosed as un-attached ground wire; re-attached wire. Problem not solved. Check hybrid light and check VCS light; car lost power on highway, reverted to "limp home" mode. Towed to dealer. Diagnosed hybrid water pump broken. They say they will not know whether $9000 inverter is broken until they fix water pump. Diagnosed problem as the "other water pump." Paid $800 for repair, but seems to have solved the problem described above.

Toyota Highlander in Arizona, United States May 2012 - Jun 2022
Dec 2012 110000 mi US $350	The seat belt would not retract and it could not be repaired. front passenger seat belt was replaced. not covered under warranty due to age and mileage.
Nov 2013 119400 mi US $500	radiator leak
Nov 2014 129700 mi US $1100	front struts
Jun 2018 159000 mi	rear window track actuator slipped out of track

Toyota Highlander in Minnesota, United States Nov 2007 - May 2013
Dec 2008 38000 mi US $39	Windshield washer pump clogged with gravel,dirt.
Mar 2009 39000 mi US $30	Window jumped track, replaced into proper position.
Apr 2009 41000 mi US $30	Noisy belt, tightened
Jul 2012 68300 mi US $800	New wheel bearing
Nov 2012 71700 mi US $300	remote needed to be replaced

Toyota Highlander in New Jersey, United States Nov 2007 - Jan 2017
Dec 2007 27000 mi	ALL brake warning lights appeared on the dashboard along with "CHECK VSC SYSTEM". I had only manual (push pedal HARD) brakes. Dealer replaced ABS Actuator under warranty and paid 2 days of rental under warranty.
Mar 2008 30000 mi	Felt a "click" in the steering when holding wheel in a constant position in a turn. Dealer replaced intermediate steering shaft.

Toyota Highlander in Missouri, United States Nov 2010 - Mar 2012
Sep 2011 95000 mi US $500	Bad ignition coil caused the car to stop running completely. Still able to pull to side of road under "Limp Home" mode in electric.

Toyota Highlander in Colorado, United States Sep 2009 - Sep 2016
Sep 2016 93000 mi US $700	Radiator blew, needed to be replaced

Toyota Highlander in Vermont, United States Nov 2007 - Jul 2018
Jun 2010 28000 mi	Igniter on one cylinder failed
Jul 2015 48300 mi US $2497	Cracked mounting points on shock absorber and suspension arm sub-assembly.

Toyota Highlander in Alabama, United States Jan 2013 - Mar 2018
Dec 2017 195500 mi	VSC displayed as well as check ABS. Hissing should has been heard for several months when applying brake unless applied lightly. Nothing done VSC and check ABS went away hasn't reappeared for a month still has hissing sound.
Jan 2018 200000 mi US $30	Shop determined the VSC module went out. No longer under under recall extended warranty Toyota would not make exception to cover. I am not fixing it as will trade vehicle soon.

Toyota Highlander in Rhode Island, United States Apr 2012 - Aug 2015
Feb 2015 131300 mi US $650	some steering wheel vibration
May 2015 140000 mi US $1200	3 of the 4 brake calipers seized. had to replace all pads, rotors, and 3 calipers.

Toyota Highlander in Virginia, United States Nov 2010 - Dec 2017
Mar 2012 122000 mi US $50	Issue with battery holding charge even with new battery. Hybrid system charges vehicle and if you don't drive it much or long distances the battery can discharge. No fix available. Charging the battery at home and have emergency jumper.
Jan 2017 149000 mi US $800	Front struts were leaking oil and making noise. Drives like new now. Really needed this work. Common issue with this vehicle at these miles
Dec 2017 154000 mi	Battery cooling fans died leading to battery meltdown. Repairs exceeded value of vehicle

Toyota Highlander in Texas, United States May 2008 - Dec 2012
Oct 2008 30000 mi	TSB on brake actuator getting air trapped a causing it to clunk during braking. Bleading of the brake system provided a temporary fix, but it will need to be redone again as the noise has returned.
Dec 2008 31000 mi	Brake Actuator is still having issues with trapped air causing a malfunction.
Feb 2009 35000 mi	Brake Actuator is still having issues with trapped air and Toyota has not fix in place. I have been told it's a non-safety issue and can not be repaired.

Toyota Highlander in Washington, United States Nov 2009 - Jun 2018
Dec 2009 22000 mi	VSC light and message on dashboard. Dealer stated "brake accumulator" needed replacing.
Jul 2017 79000 mi US $350	factory radio started to fail; replaced it with aftermarket unit

Toyota Highlander in California, United States Jan 2011 - May 2019
Jan 2014 105000 mi US $500	Tailgate latch failed. Tailgate could not be opened at all due to failure. Repair required replacement of entire latch mechanism inside tailgate.
Dec 2015 119000 mi US $30	Changed headlight bulb
Jun 2018 145000 mi US $1150	Radiator cracked and leaked

Toyota Highlander in Virginia, United States Nov 2010 - Jul 2018
Jan 2013 66000 mi US $63	Dead battery replaced.
Mar 2016 142000 mi US $590	Leaking Radiator. Replaced Radiator.
Jul 2018 172000 mi US $3	Replace rear marker bulbs

Return to top

Toyota Highlander in Indiana, United States Nov 2020 - Nov 2021
Sep 2021 175000 mi US $250	Rear pinion seal

Toyota Highlander in Florida, United States Mar 2017 - Mar 2018
Apr 2017 170000 mi US $125	Alternator failed, was replaced for $125, doing it myself

Toyota Highlander in North Carolina, United States May 2013 - Jun 2016
Jul 2014 167000 mi US $890	Alternator failure Emissions sensor replacement
Sep 2014 167000 mi US $2000	Catalytic converter replacement, $1400 Valve cover gasket replacement, $600
Jan 2016 197000 mi US $325	Oxygen sensor replacement

Toyota Highlander in Tennessee, United States Feb 2014 - Sep 2015
Aug 2014 111200 mi US $710	Replacement of alternator

Toyota Highlander in Puerto Rico Dec 2014 - Dec 2014
Mar 2014 58000 mi US $250	Alternator and battery replacement. Leak in the condenser Replaced radiator and cooling fans.

Return to top

Toyota Highlander in Maryland, United States Oct 2010 - Nov 2013
Nov 2013 85000 mi US $200	Routine replacement of battery.

Return to top

Toyota Highlander in Victoria, Australia Mar 2011 - Dec 2012
Dec 2011 81220 mi A $1600	transfer case rebuild

Return to top

Toyota Highlander in Alberta, Canada Nov 2010 - Jan 2011
Jan 2011 C $3200	We found the heater to blow cooler air on passenger side than the drivers side to repair it was quoted at 3200.00. for a new one so, never fixed it.

Toyota Highlander in Florida, United States Nov 2011 - Apr 2017
Mar 2012 202000 mi US $325	Wheel bearing
May 2012 206000 mi	Pulley crank needed to be replaced. TSB issued, repair was covered.
Jul 2012 208800 mi US $675	Power steering pump failed
Aug 2012 211700 mi	Storage vibration/ loss of power. Mechanic says its CV joints, but not sure I believe it. Need 2nd opinion from dealership.
Mar 2013 242000 mi US $160	Bad brake pads, stuck caliper
Jul 2013 244000 mi US $500	Hesitation and loss of power. Replaced coil, injectors cleaned.
Aug 2013 244000 mi US $1500	Vibration in front end. Front axle replaced. Loss of power. Replaced catalytic converter.
Jun 2014 249000 mi US $1500	Worn shocks, worn brake rotors, worn tires
Nov 2016 301200 mi US $1000	Torn CV boot- axle went bad. Timing belt, water pump
Mar 2017 307000 mi US $300	Passenger rear window actuator

Toyota Highlander in Florida, United States May 2012 - May 2013
Apr 2013 99000 mi	Condensor clutch failing

Toyota Highlander in California, United States Jul 2010 - Dec 2017
Jul 2014 82500 mi US $10	Driver door electric lock failed. Toyota quoted estate $560.00. I fixed in 1.5 hrs for cost of a $10.00 part. Thanks to youtube tutorial. Dare to do it yourself.
Mar 2017 111000 mi US $400	alternator

Toyota Highlander in Ohio, United States Oct 2013 - Feb 2018
Apr 2017 135000 mi US $464	Brake piston seized; both front rotors and calipers replaced
May 2017 139000 mi US $100	brakes worn; rear rotors and pads replaced

Toyota Highlander in California, United States Apr 2011 - Jun 2018
Nov 2012 65600 mi US $100	battery
Sep 2017 84444 mi US $250	Oil change, tire rotation, cabin filter

Toyota Highlander in Georgia, United States Jul 2010 - Jul 2012
Aug 2011 64000 mi US $350	Alternator was whining - had it replaced.

Toyota Highlander in Arizona, United States Dec 2012 - Feb 2017
Feb 2013 67700 mi US $500	Front upper control arms replaced.
Mar 2013 69000 mi US $350	Heater hoses replaced.
Oct 2014 80000 mi US $140	front passenger tire had a lot of wiggle room. Noticed at initial speed of 40 mph. Eventually got worse, and more easily heard at 20 mph.
Feb 2017 120000 mi US $149	Heard brakes squealing intermittently. Also noticed when parking brake engaged, car still moved and squealing was louder. R/R rear pads, R/F brake fluid, caliper and rotor inspected - determined still good, Parking brake reset.

Return to top

Toyota Highlander in Pennsylvania, United States Jul 2010 - Mar 2012
Jun 2011 59000 mi	Park brake cable jammed, locking rear wheel. Fixed by owner. Leak developed in the transfer case, repaired by the dealer.
Dec 2011 64000 mi US $550	Rear Wheel Bearing

Toyota Highlander in Minnesota, United States Jul 2011 - Aug 2011
Aug 2011 110000 mi US $1500	both rear wheel bearings had to be replaced

Toyota Highlander in Pennsylvania, United States Jul 2007 - Jul 2020
Apr 2007 28994 mi	Recalibrate ECM to reduce hesitation under warranty Replaced HVAC damper servo under warranty
Sep 2008 39604 mi	Replaced oxygen sensor under warranty
Aug 2014 76000 mi US $1780	Brakes shuddered upon firm application. Three calipers/pistons were found siezed. All calipers plus rotors replaced. Possible factor was non-usage of the vehicle for days or more last winter after driving over salted, slushy roads.
Dec 2015 96000 mi US $260	Replaced corroded power steering fluid return line.
Apr 2017 113000 mi US $732	Rear caliper seized. Replaced both rear calipers, pads, rotors, and hoses. Changed brake fluid.
Oct 2018 134000 mi US $35	Verify small oil leak from front differential (4WD). Top off oil.

Toyota Highlander in Ontario, Canada Mar 2018 - Jun 2022
Apr 2019 102300 mi C $1500	Rear brakes are rusted out and it had to be replaced
Dec 2019 109740 mi C $650	Power steering pump return line to reservoir was rusted out and leaking
Aug 2020 111113 mi C $1100	Front brakes are rusted out and it had to be replaced

Toyota Highlander in New Jersey, United States Aug 2010 - Jul 2018
Nov 2010 51300 mi	"frozen" caliper rear brake; replaced under Toyota extended warranty.
Mar 2013 67000 mi US $900	frozen caliper (right front)
Jun 2013 69000 mi US $50	repaired rusted exhaust system brackets.
Nov 2013 73700 mi US $200	Right rear caliper pins "frozen"
Oct 2014 90000 mi US $2200	Rear brakes rusted rotors, rt rear sliding pins frozen. Power steering line leaking, rotted.
Dec 2016 118000 mi US $200	Rear calipers "frozen".
Jun 2017 125000 mi US $50	Adjust rear brakes for noise.

Toyota Highlander in Virginia, United States - Jul 2007
Jul 2007 40000 mi US $700	Sunroof came off track and the gears that open and close it became jammed. Had to have entire sunroof replaced.

Toyota Highlander in California, United States Jul 2010 - Nov 2014
Sep 2010 118000 mi US $1000	Worn struts replaced

Toyota Highlander in New Jersey, United States Dec 2011 - Mar 2016
Dec 2015 112000 mi US $100	Dirty injector causing rough idle. Injector cleaner cleared it put after using 1/2 tank of gas.

Toyota Highlander in Ontario, Canada Jul 2010 - Jul 2012
Jun 2011 83700 mi C $3000	Heater failed- problem was wiring to controls

Toyota Highlander in Colorado, United States Mar 2011 - Jul 2022
Jul 2016 80300 mi US $200	Cabin temp was not being controlled per setting of temp knob. Temp control assy removed from dash and found broken wires between potentiometer and circuit board. Desoldered broken wires, soldered new wires and reinstalled temp control assy.
Sep 2016 82000 mi	Could not raise right rear passenger window

Toyota Highlander in Missouri, United States Feb 2015 - Dec 2016
Mar 2015 161000 mi US $1147	R front caliper froze. Replaced calipers (both), pads, turned both rotors. Replaced steering link. Replaced worn U joints.
Sep 2015 179000 mi US $40	Headlight connector had melted. Wiring loom was replaced. Replaced the bulb but was out again a week later.

Toyota Highlander in Colorado, United States Jul 2012 - Dec 2015
Jul 2015 203500 mi US $1100	Wheel bearings needed to be replaced
Nov 2015 206000 mi US $1000	Water pump leak. Dead battery

Toyota Highlander in Utah, United States Jul 2013 - Jun 2022
Aug 2013 104000 mi	Some sensors were replaced under used car sale warranty.
Jul 2014 117500 mi	Back passenger side power window quit working. The lifting arm had come off the track. Fixed it and then it happened again. Ended up putting it back on, raising window completely, and pulling fuse so the problem wouldn't repeat.
Sep 2016 158000 mi	The other rear passenger power window has also now quit staying on the track and had to manually raise it and remove fuse. Now both rear passenger power windows are inoperable.

Return to top

Toyota Highlander in Florida, United States Jul 2010 - Sep 2015
Dec 2011 78000 mi US $382	I had to have the alternator and battery replaced.
Jul 2012 84500 mi US $375	replaced a/c control head with reconditioned one.
Sep 2012 87000 mi US $1000	replaced ac compressor and evaporator
Jun 2014 103000 mi US $1600	I had a/c repairs done approx. 3 years ago. At that time, unknown to me, the repair shop did their own electrical modification to the a/c system. It shorted out this June and resulted in major repairs to the a/c system.
Sep 2015 116000 mi US $4400	blown engine replaced with a used engine

Toyota Highlander in Massachusetts, United States Aug 2017 - Apr 2018
Feb 2018 156680 mi US $450	Battery wasn’t charging, random dash warning lights came on. Alternator, serpentine belt replaced
Apr 2018 159000 mi US $110	The rear windows wouldn't go up using the driver's seat switch. I believe the switch got too wet when the car was detailed. I replaced the power window master switch replaced (with a used switch from eBay)

Toyota Highlander in North Carolina, United States Jul 2010 - Mar 2011
Nov 2010 71000 mi US $400	Leaking water pump housing

Return to top

Toyota Highlander in Georgia, United States Feb 2015 - May 2017
Sep 2015 119000 mi US $100	Passenger rear window came off track and was repaired. No parts required.

Toyota Highlander in South Carolina, United States Dec 2013 - Apr 2015
Nov 2014 133900 mi US $550	driver's side wheel bearing, so replaced the whole assembly
Dec 2014 135000 mi US $180	Front Catalytic converter was clogged. Replaced both o2 sensors first per manual. Ended up pulling a part to replace. New would've been $800 from the dealer.

Toyota Highlander in Pennsylvania, United States Sep 2015 - Oct 2016
Jul 2016 173000 mi US $130	in for routine maintenance. got call from dealer. hood latch failed. hood will not stay closed. dealer ordered part. returned next day to install.

Toyota Highlander in North Carolina, United States Feb 2012 - Sep 2017
Jun 2013 195000 mi	We had to replace the center control switch knob on the A/C system( which appears to be the heart of the system). The problem was the A/C would go from hot to cold at random, which became annoying. Left passenger front window motor fails intermittently and needs to be replaced. Starter is making high pitch noise intermittently, suggesting imminent failure

Toyota Highlander in Tennessee, United States Sep 2012 - Mar 2013
Dec 2012 137000 mi US $224	I took it in because I was only getting 14 miles to the gallon, check engine light came on, and another light I believe it was called a vcs came on. It was fixed by checking with computer, a new gas cap.

Toyota Highlander in Washington, United States May 2008 - Aug 2019
Aug 2016 76000 mi US $65	When operating the passenger window, via either switch, the window motor would operate the window down and then back up, but then it would not work after that. If I waited an hour it would work the same way again. The window holder drive motor was bad. I bought the motor and the arm as an assembly and replaced it myself. If you can follow a Youtube of the repair you can do it yourself. $65 on Amazon

Toyota Highlander in Texas, United States Jun 2015 - Jun 2022
Jun 2016 150000 mi US $39	Inconsistent A/C temp
Nov 2016 151900 mi US $445	Replaced gasket valve cover set to fix small oil leak

Toyota Highlander in Texas, United States Dec 2010 - Feb 2014
Apr 2012 54300 mi US $298	fuel leak, replaced line

Toyota Highlander in Alabama, United States Nov 2017 - May 2018
Jan 2017 285000 mi	Catalytic Converters and O2 sensors not working properly. Gas mileage has decreased significantly, but car runs fine.
Dec 2017 295000 mi US $50	both rear windows were not rolling up/down. Had to glue window back onto bottom rail, as it had come loose on both windows.

Return to top

Toyota Highlander in North Dakota, United States Feb 2012 - Apr 2013

Toyota Highlander in Ontario, Canada Apr 2008 - Sep 2018
Apr 2008 94860 mi C $35	Air conditioner stops working. Added refrigerant with anti-leak.
May 2008 95480 mi C $120	A/C failure did not last for a long time after repair. Will take it to shop this or next month.
Jun 2008 98580 mi C $300	A/C system cleaned by shop, filled out with sealant and leak detector (UV dye).
Oct 2009 137888 mi C $250	Caliper replacement
Mar 2011 174220 mi C $250	Exhaust system gaskets replacement ( 2 burned out) Exhaut system gaskets replacement ( 2 burned out)
May 2012 203360 mi C $4300	Replace control arms and bearing. Replace struts and shocks. Replace parking shoes and cables.
Jun 2012 203360 mi C $826	lose bolts on joints, one bolt missing condencer replaced; eletrical issue with compressor is fixed
Jan 2013 198880 mi C $1021	Left from strut start leaking (noticed my mechanic at the previous visit) Done by another shop (fixmycar.ca) less that 6 month ago
Jun 2013 226300 mi C $600	stabilizer bar, joint one of the calipers
Nov 2013 234840 mi C $950	replace broken control arms; joints
Apr 2014 241760 mi C $160	Rear wiper blade assemply
Mar 2015 261020 mi C $250	upper radiator hose replacement
Aug 2015 268600 mi C $1300	Both rear wheels bearings were broken
Sep 2015 275900 mi	Front Calipers
Apr 2016 284740 mi C $300	driveshaft assembly replacement over the broken U-joint coolant leak; radiator block is resealed by shop
Aug 2017 310620 mi C $500	Hood cable has been replaced, $200. Battery replacement. Earlier in a month I have decided to clean up the battery which has to be replaced before the winter anyway. One of the bolts that holds the battery in place but that was solidly rusted in snapped. The attempt to drill it out was not successful (shop had to use welding to fix it). So I took car to the shop to fix it and replace battery at the same time as the cost of servicing the battery is a one third of replacing. $250. O2 sensor failed and needs to be replaced to pass emission test Rear stabilizer links were making extensive noice over uneven terrain
May 2018 330460 mi C $680	transmission leak, replaced transmission pan(?) and gasket
Jul 2018 333560 mi C $3000	Shocks, struts, control arm, bushing
Aug 2018 336 mi C $600	Oil pan and oil pan plug replacement over the oil leak ( thread on the oil pan was damaged over the time due to number of oil changed over the span of time)
Sep 2018 334180 mi C $540	Re-seal oil pan

Toyota Highlander in Saskatchewan, Canada Dec 2008 - Mar 2016
Dec 2010 62620 mi	left front wheel bearing and hub. Warranty
May 2011 64480 mi	vibration noise - told it was the tire. Replace two more rear bearings

Toyota Highlander in Pennsylvania, United States Sep 2009 - Jun 2017
Mar 2013 84000 mi US $325	Front right brake caliper seized, resulting in need for replacement of calipers, rotor turning, new front brake pads and brake flush.
Apr 2016 107200 mi US $572	Rear wheel bearing replaced after increasingly louder noise heard while driving. Parking solenoid lubricated after shifter would not engage from Park into Reverse without several attempts, especially when cold.

Toyota Highlander in Kentucky, United States Nov 2013 - Mar 2018
Dec 2014 152000 mi US $210	replaced front rotors and pads with caliper pins and seals due to sticking brake caliper pin. Rotor warping and reduced fuel economy as a secondary symptom of stuck caliper.
Jul 2016 165000 mi US $65	erratic shifting. sticking shift solenoid 2nd to 3rd shift problem
Feb 2017 172000 mi US $150	Caliper and pad replacement. The front calipers were sticking and causing poor fuel economy and poor braking.

Toyota Highlander in Colorado, United States Jun 2017 - Jun 2018
Jan 2018 144000 mi	left rear door window no longer operates. driver's door lock no longer works electrically (by remote or inside electrical control). only functions when operated manually, by key or by manual lever in car.
May 2018 149000 mi	head light out. replaced

Toyota Highlander in New Jersey, United States Jun 2014 - Jul 2018
Jun 2014 155000 mi US $550	power window motor and assembly needed to be replced, on 2 windows
Jun 2016 193000 mi US $350	Replace power window motor

Toyota Highlander in Connecticut, United States Mar 2011 - Apr 2013
Jun 2011 131000 mi	AC drive belt was slipping and needed tensioning

Toyota Highlander in Ontario, Canada Oct 2009 - Aug 2013
Nov 2011 97960 mi C $150	Replaced front differential seal.
Oct 2012 113540 mi C $500	replace wheel bearings

Toyota Highlander in New Jersey, United States Sep 2013 - Jun 2014
Oct 2013 205800 mi US $800	Replaced rear wheel bearing

Toyota Highlander in Massachusetts, United States Jan 2009 - Mar 2014
Mar 2009 66000 mi US $1400	Frozen caliper; rusted discs.
Aug 2013 102000 mi US $1000	Water pump and timing belt. This is the second water pump and timing belt replaced. The first replacements occurred at 60K miles.

Toyota Highlander in North Carolina, United States Mar 2016 - Jun 2018
Oct 2016 83000 mi US $1200	Replace left rear wheel bearing

Toyota Highlander in North Carolina, United States May 2008 - Jun 2011
Jun 2010 44000 mi	Cable on sunroof snapped

Toyota Highlander in Nevada, United States Apr 2008 - Jun 2018
Aug 2012 89500 mi US $806	Both front door locks quit working and had to be replaced.
Aug 2017 132000 mi US $1400	Replaced leaking struts on the front and the rear.

Toyota Highlander in Illinois, United States Mar 2016 - Apr 2017
Apr 2017 142000 mi US $600	Front drive shaft section had to be replaced due to non replaceable ujoint failure.

Toyota Highlander in Colorado, United States Feb 2016 - Jan 2017
Feb 2016 130000 mi	seat belt would not buckle
Jun 2016 140000 mi US $250	ac recharge

Toyota Highlander in Massachusetts, United States Oct 2013 - Dec 2017
Sep 2014 75000 mi US $500	Humming or revving noise from rear end noticed at speeds over 40mph. Mechanic said sounded like bad wheel bearing and confirmed it on lift. replaced right rear wheel bearing and hub assembly.
Nov 2016 104000 mi US $1300	Car developed a vibration when accelerating in lower gears. Took it to transmission shop. Could not find any codes or transmission issues. Diagnosed as a bad u-joint in the drive shaft. Not U-joint staked to shaft. Must replace entire shaft.
Jul 2017 112000 mi US $450	Car began making loud humming/growling noise coming from rear of vehicle after 20 MPH. Classic bad wheel bearing sound. We had already replaced the left rear wheel bearing at 75K. Mechanic replace with new wheel bearing, sound is gone. Mechanic said he replaces manywheel bearings on these cars. Design is faulty and lets road salt and dirt in from the back side. Says we will eventually have to replace them all.
Nov 2017 125000 mi US $200	Power Steering pump was making loud sound. Fluid Reservior was low. discovered leak in line at bottom of engine compartment on passenger side. line had corroded. Mechanic recommended replacing replace section of line rather than entire line. (several metal to rubber connections on entire line) added new fluid. everything fine. Brake light came on. Stayed on. Fluid Low. discovered small leak in brake line near caliper.replace. everything fine

Toyota Highlander in Ontario, Canada Feb 2011 - Mar 2011
Mar 2011 89280 mi C $150	Check engine light was on. Mechanic replaced a worn out seal.

Toyota Highlander in West Virginia, United States Aug 2011 - Dec 2013
Dec 2013 234000 mi US $235	caliper slide stuck and inside pad was grinding on rotor

Toyota Highlander in Idaho, United States Aug 2008 - Sep 2015
Mar 2011 40000 mi US $200	Replaced leaking water pump. Replaced leaking output shaft seal. Replaced brake master cylinder seal.

Toyota Highlander in New York, United States Aug 2010 - Mar 2018
Apr 2013 101300 mi US $250	wheel speed sensor
Feb 2017 127000 mi US $500	seal rear

Toyota Highlander in New York, United States Aug 2012 - Jun 2015
Nov 2013 180900 mi US $400	Shop said that my front brake caliper and drum needed replacing.

Toyota Highlander in Nova Scotia, Canada Oct 2010 - Jun 2011
Nov 2010 96100 mi C $300	Clunking sound/feeling in steering column.

Toyota Highlander in New Brunswick, Canada Apr 2006 - Dec 2013
Feb 2006 44640 mi	Noise coming from front fender drivers side when driving into the wind, was inner plastic guard in wheel well

Toyota Highlander in Ontario, Canada Apr 2008 - Jul 2009
Nov 2008 78120 mi	Faulty oil change by dealer. Required truck to be towed back to dealer to be fixed.

Toyota Highlander in Michigan, United States Jan 2015 - Sep 2017
Apr 2015 71500 mi US $485	Calipers failed requiring pads, rotors and calipers to be replaced, on both sides in the rear.
Mar 2016 90000 mi US $1900	Replced drive shaft from front to rear due to play in shaft.
May 2017 112000 mi US $50	Replaced front brake pads

Toyota Highlander in District of Columbia, United States Feb 2015 - Mar 2019
Feb 2017 97000 mi US $150	new battery
Sep 2017 100000 mi US $2000	alternator replaced
Dec 2017 104000 mi US $800	corrosion of wiring harness and sensor

Toyota Highlander in California, United States Jun 2010 - Jan 2011
Nov 2010 81000 mi US $250	Check engine light code indicated exhaust sensor problem. Replaced cannister. Appears to be working now.

Toyota Highlander in New York, United States Jun 2008 - Jan 2013
Jan 2013 131000 mi US $970	Rear brake pads/rotors/calipers were replaced. One side was frozen. Belts needed replacing, they were getting very noisy.

Toyota Highlander in Illinois, United States Oct 2012 - Dec 2013
Jul 2013 90300 mi US $200	With A/C on heat would randomly come out of vents. 2 of 3 wires in climate control adjuster had to be re-soldered. This problem with 04 Highlanders is well documented on various websites.

Return to top

Toyota Highlander in Maryland, United States Nov 2016 - May 2020
May 2018 225000 mi US $100	rough idling after battery change. Clean the throttle

Toyota Highlander in Wisconsin, United States Apr 2010 - Oct 2018
Oct 2013 109200 mi US $75	Rear window fell off the track and got stuck in the 'open' position.
Jun 2014 114000 mi US $40	Power steering return line began to corrode and leak fluid in the driveway. New return line was about 30 dollars and required one hour to replace. Was very easy to do myself. Still drove it waiting for part.
Dec 2015 133000 mi US $200	Replaced both o2 sensors
Feb 2017 147000 mi US $300	Exhaust rusted through and leaking upstream of downstream cat. Replaced pipe and downstream cat. 200 for parts plus labor.

Toyota Highlander in Florida, United States Nov 2010 - Jun 2018
Jan 2013 52000 mi US $135	Replaced cracked engine mount

Toyota Highlander in Michigan, United States May 2008 - Jul 2015
Oct 2011 71000 mi US $225	replaced power steering tube
Feb 2014 91000 mi US $375	had climate controller replaced

Toyota Highlander in Delaware, United States Sep 2010 - Jun 2011
Oct 2010 100000 mi US $250	Air temperature problem. Cold air blew out vents all time. Mechanic said it needed new computer board at cost of $1200. I ended up disconnecting actuator from air damper and now control air temp. by manually adjusting damper.

Toyota Highlander in Arizona, United States Sep 2014 - Jun 2018
Jul 2015 130500 mi US $210	Alternator went out.

Toyota Highlander in Florida, United States Jan 2012 - Dec 2014
Feb 2012 148500 mi US $500	Bad mass airflow sensor

Return to top

Toyota Highlander in New York, United States May 2012 - May 2012
May 2012 138000 mi US $500	fuel pump problems

Return to top

Toyota Highlander in Connecticut, United States Jan 2010 - Oct 2011
Aug 2010 66000 mi US $300	Replace A/F Sensor Bank 2 position 1
Jun 2011 84000 mi US $500	Stuck caliper wasted left rotor. Full front brake job + one caliper
Jul 2011 84000 mi	Rear left brake lights went out. Had to retension plug adapter to get it working agin. Fixed at home.
Oct 2011 87000 mi	Tranny started slipping. Burned oil smell from leaky engine seals near exhaust. AC system started faulting.

Toyota Highlander in Hawaii, United States Dec 2015 - Jul 2021
Dec 2016 208000 mi US $2500	new power steering rack, pump and hoses.
Jul 2021 248000 mi US $800	Transmission Mount; Engine Mount front & right and torque strut.

Toyota Highlander in California, United States May 2015 - Jul 2018
Jun 2015 112000 mi US $800	Replaced the Idle Control Valve

Toyota Highlander in Texas, United States Feb 2015 - Sep 2018
Jun 2015 120000 mi US $20	added 1 can Freon to AC
Jun 2016 113000 mi	Ac condensor coil had a leak Drivers side electric window lift weak, window would not raise all the way
Jan 2017 117000 mi US $700	Brakes wore out. front rotors out of round. rears rotors were too thin to machine, ended up getting all four new. AC lost its charge. Had window motor replaced, another $650
Jul 2017 120000 mi US $10	headlight lens cloudy and yellowed, we buffed them clear with 3M cleaner.

Toyota Highlander in California, United States Mar 2015 - Apr 2015
Apr 2015 279000 mi US $615	Routine brake maintenance, calipers replaced on rear, pads and rotor machining on front

Toyota Highlander in North Carolina, United States Apr 2015 - Jul 2015
Apr 2015 115000 mi US $1100	Replaced faulty condensor Replaced rear struts
Jul 2015 117000 mi US $123	O2 sensor fault

Return to top

Toyota Highlander in Georgia, United States Jan 2011 - Jun 2015
Sep 2013 165000 mi US $2000	Replaced timing and accessory belts, also replaced charcoal canister and other emissions items

Toyota Highlander in Colorado, United States Jan 2007 - Jul 2011
Jun 2007 90220 mi US $38	canister valve vacuum hose loose from air box

Toyota Highlander in New Hampshire, United States Apr 2011 - Jul 2012
Jul 2012 164000 mi US $125	Flex pipe and gasket rusted out...replaced

Toyota Highlander in Virginia, United States Jan 2011 - Jul 2016
Jul 2013 103800 mi US $286	Needed to replace a fuel evaporative control valve.
Nov 2013 108000 mi US $500	Replaced oxygen sensor. Rear side window stuck in down position.
Jan 2014 99000 mi US $160	A sensor in the exhaust system had loosened and its gasket blew out resulting in a loud exhaust noise. The dealer tightened the sensor and replaced the gasket.
Dec 2014 113000 mi US $260	The area around the rear anti-lock brake sensors was rusty, and was creating a mechanical situation where the antilock brakes were activating each time the car stopped. My mechanic was able to diagnose the problem and fix it.
Dec 2015 130000 mi US $1300	Replace catalytic converter.

Toyota Highlander in Pennsylvania, United States Jul 2016 - Jul 2016
Jul 2016 195000 mi US $1060	Rear pistons frozen; pads, rotors, calipers needed replaced. both serpentine belts needed replacement due to prior mechanic never adjusting tensioner.

Toyota Highlander in California, United States Feb 2009 - Dec 2012
Jan 2009 64000 mi	Front mud flaps started to tear due to wind resistance on freeway

Toyota Highlander in New Jersey, United States Sep 2012 - Jul 2013
Apr 2013 158800 mi US $370	Pinion oil seal with new 80W90 Gear oil. Noisy exhaust system - repair and weld exhaust pipe and bracket.
Jun 2013 163000 mi US $536	Sensor # 2. Gas too lean.

Toyota Highlander in Massachusetts, United States Jan 2018 - Jul 2020
Feb 2018 151000 mi US $65	sticky left rear brake

Toyota Highlander in Massachusetts, United States Aug 2012 - Jun 2013
Oct 2012 152700 mi US $1200	check engine light was on; the shop diagnosed that there were several sensors (for emissions) that were no longer working and needed to be replaced.

Toyota Highlander in New York, United States Jan 2020 - Jun 2022
Oct 2020 134000 mi US $600	Exhaust leak. Replaced exhaust and muffler
Mar 2021 136000 mi US $56	replace passenger-side power window motor
Jun 2022 141000 mi US $35	Replace driver's power window motor.

Return to top

Toyota Highlander in Quebec, Canada Feb 2014 - Jun 2014
Jun 2014 122140 mi	Head bolts stripped, causing coolant leak. Fix is replacement of short block = beaucoup de $$$

Toyota Highlander in Massachusetts, United States May 2011 - Jun 2014
Jun 2011 129000 mi US $1800	Struts replaced and alignment
Jun 2014 164000 mi	Transmission gave out after 3+ years of minor power fluctuations.

Toyota Highlander in New Hampshire, United States Jan 2011 - Jul 2016
Dec 2011 175000 mi US $40	RR caliper overheating. Removed, cleaned and greased sliders. Seems better.
Jul 2012 189000 mi US $1750	Classic head bolt failure, Time-Cert thread repair done.
Aug 2013 209600 mi US $100	A single coil pack failed causing misfire and the check engine light to come on. A trip to the parts store for a code reading showed a failed coil pack on cylinder 3. Replaced coil pack.
Dec 2013 216000 mi US $920	Repairs to the gas tank emissions control components. Involved removing the tank and replacing abour $250 in parts. Heavy labor cost. Had CEL on and strong gasoline odors with a full tank.
Jul 2014 225000 mi US $94	Metal return line of steering system rusted and developed a leak causing power steering issues. Temporarily fixed by topping up fluid then replaced metal line. Used Toyota part.
Jan 2015 233000 mi US $105	Failed coil pack - was actually the one that failed before and was replaced. I took the opportunity to replace them all. They are old.
Aug 2015 240800 mi US $275	LR wheel ABS sensor failed. It is less expensive to replace the whole axle hub. Brake backing plate had to be replace due to rust.Job took longer than it should due to frozen bolts and corrosion on the backing plate.
Nov 2015 244000 mi US $425	Alternator failed and battery was weak enough that it was recommended to replace it at the same time.
May 2016 251000 mi US $330	Replaced the catalytic converter. I had installed an Eastern Catalytic catalytic converter about two years ago when the OEM original failed. The Eastern unit failed about 10 months ago but I am just getting around to fixing it.

Toyota Highlander in British Columbia, Canada Sep 2011 - Oct 2011
Oct 2011 111600 mi C $800	Spent $800 dismantling engine to find problem. Bolts on engine mount stripped. Needed new engine, too costly, about $7000.

Return to top

Toyota Highlander in Ontario, Canada Aug 2014 - Jan 2017
Sep 2014 144460 mi C $560	Worn-out Front universal joint
Oct 2015 159640 mi C $200	Rusted hose
Dec 2015 161200 mi C $270	One defective coil
Jan 2017 161200 mi C $250	Windshield Wiper transmission broke. Replaced

Return to top

Toyota Highlander in Texas, United States Mar 2017 - Sep 2018
Jun 2018 148000 mi US $1400	The electrical system was replaced. The air conditioner would not work.

Return to top

Toyota Highlander in California, United States Jun 2010 - Jul 2017
Nov 2010 161423 mi US $3658	Would not change out of 1st gear.

Toyota Highlander in California, United States Feb 2015 - Mar 2015
Feb 2015 110000 mi US $300	Fuel-oxegyn sensor replaced.

Toyota Highlander in California, United States May 2015 - Oct 2022
Nov 2015 106600 mi US $200	Battery replaced - would not hold a charge after storage for several months. Driver-side sun visor replaced - would not stay up.
Feb 2018 114000 mi US $300	Mass airflow sensor faulty - replaced. Rear center-mount brake light bulb burned out - replaced.
Jan 2019 112 mi US $100	Thermostat faulty - replaced
Mar 2022 122000 mi US $7	Replaced burned out left rear brake light.

Return to top

Toyota Highlander in Maryland, United States Feb 2017 - Jun 2022
Feb 2018 157000 mi US $20	replaced exhaust pipe
Mar 2022 190000 mi US $150	flex pipe

Toyota Highlander in Massachusetts, United States Dec 2014 - Mar 2015
Mar 2015 128000 mi US $390	Serpentine belt replacement; drivers' side front caliper seized and replaced.

Toyota Highlander in West Virginia, United States May 2010 - Mar 2011
Dec 2010 220000 mi US $400	replace fuel sensor

Toyota Highlander in Oregon, United States Jul 2010 - Sep 2010
Aug 2010 101000 mi	Service indicated the check engine light came on due to a damaged gas cap which was replaced. Light is now back on again so the car is going back in tomorrow. Vacuum hose was not attached correctly causing the check engine light to come on. No charge for resolution.

Toyota Highlander in Illinois, United States Sep 2010 - Feb 2017
Apr 2014 101300 mi US $930	Exhaust leak. Replaced rear gasket on converter assembly. Passenger side rear shock absorber leaking. Replaced left and right rear shock absorber assemblies and associated support assemblies.
Dec 2014 106000 mi US $337	Replaced oxygen sensor, part no. 89465-49075.
Jan 2015 100500 mi US $103	Passenger side sun visor would not stay up. Replaced visor.
Jul 2015 110500 mi	Exhaust pinhole leak. Welded by Midas .... no charge.
Aug 2016 118400 mi US $530	Replaced air/fuel ratio sensor.
Oct 2016 119500 mi US $300	Replaced noisy/misaligned driver side rear brake caliper. 120,000 mile maintenance done on same trip.
Feb 2017 122000 mi US $2064	Fuel tank leak. Replaced tank and regulator.

Toyota Highlander in Virginia, United States Nov 2012 - Dec 2016
Dec 2013 134000 mi US $436	Dealer left valve cover bolts loose after replacing timing belt. Oil leakage, loss of oil.
Jun 2014 136000 mi US $200	Engine sludge required multiple oil changes, flush and inspections. Will need to replace valve covers, PCV valve and valve cover gaskets
Oct 2015 149300 mi US $400	Replacing defective valve covers and PCV valve
Aug 2016 153600 mi US $434	New PCV valve, new spark plugs, water pump, timing belt.
Dec 2016 155000 mi	Replaced rear valve cover and gasket due to defective design. Cover was not replaced 4 months ago

Toyota Highlander in Pennsylvania, United States - Nov 2011
Mar 2005	Electrical, other than above, repair

Toyota Highlander in Pennsylvania, United States Jan 2015 - Jul 2021
Mar 2015 114000 mi US $7	Oxygen Sensor nuts came loose and had an exhaust leak
Jun 2015 116000 mi US $100	Check engine with a P1135 code. Replaced Fuel/Air Sensor in exhaust pipe. Sensor is near back of engine.
Jul 2015 116300 mi US $200	Rear calipers were seized, rear brakes were not working at all, replaced both rear calipers and rotors, replaced rear pads as well.
Feb 2016 121000 mi US $110	Exhaust leak. Front exhaust flex pipe separated. I replaced the pipe and two gaskets. Had to cut bolts off.

Toyota Highlander in Montana, United States Nov 2011 - Oct 2018
Aug 2014 154100 mi US $650	Replacement (non-OEM) parking brake broke apart and required replacement.
Sep 2016 177000 mi US $536	Rotors, pads, calipers
Feb 2018 190000 mi US $800	Replaced transmission fluid Unplugged and replaced intake filter

Toyota Highlander in North Carolina, United States Jul 2013 - Jul 2015
Jul 2013 131000 mi US $1880	Left front hub bearing. I asked Toyota to replace the remaining 3 hub bearings because I still heard the same noise that I heard the first time I took the car in; thinking it was another bearing. However after doing all that I still hear the noise when slowing down
Nov 2014 147100 mi US $757	Water pump replacement, belts, ignition work, battery.

Toyota Highlander in Pennsylvania, United States Mar 2008 - May 2011
Mar 2008 58548 mi US $300	Replace Bank 1 Sensor 1 O2 Sensor
Mar 2009 64329 mi US $300	Car wouldn't hold idle. Cleaned Throttle body and FI system. No cause found.
Mar 2011 78000 mi US $850	Required new front calipers + pads and rotors all around. 3 days in the shop-first 2 days at dealer who couldn't diagnose a vibration/grumble problem.
May 2011 79000 mi	AC light would blink when the car drove through very rainy conditions, and the AC would cut off for a few seconds. Supposedly was some sort of accessory belt clutch relay, but a new relay never solved the problem. In very cold temps (below 10-15 degrees F) the Airbag light would come on until the car got warmed up. Supposedly this indicated that there was a faulty airbag sensor, but Toyota never really fixed it. "Couldn't reproduce" was their usual diagnosis. Slight squeak from the steering column in cold temps.

Return to top

Toyota Highlander in Ohio, United States Dec 2010 - Feb 2017
Oct 2011 121000 mi	AC/Heat would blow intermittent, and flip back between hot and cold. $600+ repair quoted to replace circuit board. Self repair performed by pulling off AC control knob and tightening a very loose nut. No intermittent problems since.
Aug 2012 129700 mi US $603	P0420 and P0430 engine light codes. Replaced O2 sensors.
Feb 2015 157600 mi US $2500	Engine header bolts worn to where required torque not possible. Machinest bore new holes into engine block so that new bolts could take hold. The overall problem caused by this was engine coolant leaking all over. Old and worn out water pump replaced.
May 2015 161400 mi US $75	Engine was idling slow. Cleaned throttle control mechanism.

Toyota Highlander in Texas, United States Jan 2011 - Jun 2018
Jun 2013 156000 mi	My AC was blowing hot and cold. An internet search suggested that the most common reason for this is a broken temperature control knob cable. Sure enough that was my issue and was resolved for $0.
Oct 2014 169500 mi US $200	Changed Oxygen Sensor Bank 1 Sensor 2.rnStill has not resolved all the Engine codes being reported.

Toyota Highlander in New Jersey, United States Jul 2010 - Jun 2013
Jan 2011 117400 mi US $600	One oxygen sensor failed.
Jun 2013 142000 mi	Car emits puff of white smoke on cold start

Return to top

Toyota Highlander in New Jersey, United States May 2010 - Sep 2013
Jul 2010 105000 mi US $600	calipers sticking, causing car to wobble when braking plus rotors wore out as a result.
Nov 2010 113000 mi US $200	car misfiring after oil change. replaced ignition coil
Dec 2010 113000 mi	engine light on. mechanic indicated possible sensor error. decided not to replace possible problem due to cost
Jun 2012 134000 mi US $180	One of the ignition coils required replacement
Jan 2013 140500 mi	one of ignition coils required replacement
Mar 2013 143000 mi	ignition coil replaced last January was defective. replaced again.
Sep 2013 146000 mi US $100	replaced drive belt

Return to top

Toyota Highlander in Texas, United States Jun 2010 - Jun 2011
Jul 2010 142000 mi US $1150	AC not coooling
Aug 2010 142300 mi US $700	Check engine light came on and replaced emissions part?

Return to top

Toyota Highlander in Florida, United States Jul 2010 - Apr 2016
May 2012 42000 mi US $70	check lights for skid control and tracking turned on.
Jun 2012 42000 mi US $1500	Check lights turned on again, had to visit the dealer as instructed by my local repair shop. Although only 42k miles, but it has been 11 years, the dealer replaced timing belts, rubber belts, leaky valves.
Jul 2013 43000 mi US $771	Air/fuel ratio (O2) sensors need to be replaced.
Sep 2013 43000 mi	Drip oil.
Aug 2015 52200 mi US $83	clean master air sensor

Toyota Highlander in California, United States Feb 2010 - Oct 2012
Jun 2011 89000 mi	Check engine light. Shop advised to replace battery prior to any further work. Said this may solve the problem. Light is off for now. Will drive vehicle a few days to see if light comes back on.
Jul 2011 90000 mi US $250	Same shop to re-check. Indicated code that air/fuel mixture was too lean. Adjusted to spec. (no charge). Light came on again. Returned to same shop, diagnosed as bad Mass Air Flow Sensor.

Toyota Highlander in Georgia, United States Jan 2015 - Jun 2022
Jun 2017 224305 mi US $800	Would not shift into overdrive. Engine misfire on cylinder 2. replaced antiknock sensors and harness, spark plugs and all associated gaskets.
Oct 2017 227837 mi US $383	roaring when turning in a left hand turn. Right front wheel bearing replaced.
Apr 2020 252434 mi US $3154	Transmission failed. Had to replace it.

Return to top

Toyota Highlander in Massachusetts, United States Feb 2010 - Apr 2014
Mar 2010 172000 mi US $500	A/C condenser leak, replaced
Jan 2011 194100 mi US $75	Replaced exhaust gasket which had deteriorated, minor repair.
May 2011 193300 mi US $156	Failed emissions inspection for CEL. Codes indicated system too lean, cleaned MAF sensor, CEL cleared and passed emissions inspection.
Jul 2011 194500 mi US $900	Replaced midpipe including catalytic converter Exhaust leak and CEL, replaced mid pipe including catalytic converter
Mar 2012 196000 mi US $70	Repaired sticking/inoperative parking brake
May 2012 196900 mi US $75	CEL, diagnosed as evap system sensor problem. Estimate of $700 to fix, but since the vehicle is running fine we decided not to repair at this time.
Jun 2012 198000 mi US $110	Reported AC inop, shop recharged system and found no obvious leaks. Dye was included in the refrigerant and an additional visit will be needed to check.
Mar 2013 200000 mi US $400	Replaced leaking condenser
Apr 2013 200200 mi US $500	Replaced AC compressor
Jul 2013 201000 mi	AC not working, shop found that evaporator coil was cracked. Estimate of over $800, decided not to perform the repair.
Apr 2014 203000 mi	Oxygen sensors bad, car failed inspection. Estimate $600 to fix. AC never fixed.

Toyota Highlander in California, United States May 2010 - Dec 2012
Apr 2011 101700 mi US $650	Tune up, fluids replaced. Suspension needs replacing but not replaced on this visit.
Jul 2011 105000 mi US $1400	new suspension parts installed

Toyota Highlander in New Hampshire, United States Jul 2010 - Mar 2016
Sep 2010 146000 mi US $450	Oxygen sensor failed

Toyota Highlander in British Columbia, Canada Feb 2010 - Mar 2016
Jun 2015 44640 mi	Engine check light, required new O2 sensor 1 bank 1.

Toyota Highlander in New York, United States Jan 2011 - Jul 2011
Jul 2011 170000 mi US $650	AC was very low on Freeon.

Toyota Highlander in Illinois, United States Feb 2010 - Feb 2015
Feb 2012 120100 mi US $1700	Worn struts caused uneven tire wear
Jan 2013 120300 mi US $75	Engine started misfiring. Traced it down to a bad ignition coil and replaced the coil
Jul 2014 135000 mi US $180	Worn stabilizer bar needed to be repaired. Not successful, need to go back.
Feb 2015 135000 mi	Worn stabilizer bar needed attention.

Toyota Highlander in Hawaii, United States Mar 2011 - Jun 2016
Jun 2011 153000 mi US $150	O2 sensor and clean throttle body plate...full of carbon limiting the throttle cable movement.
Mar 2015 192000 mi	Changed the right front and rear wheel bearings with TImkin.
May 2016 198000 mi US $1422	Front end alignment could not be performed due to tie rods with no more adjustment available. Removed and replaced inner & outer tie rods, stabilizer links for front and rear, lower ball joints along with rotors, calipers and pads for front.

Toyota Highlander in New York, United States Sep 2010 - Jul 2013
Jun 2013 120000 mi US $300	re charged a c
Jul 2013 120000 mi US $100	Likely a leak in the a/c system

Toyota Highlander in New York, United States Mar 2013 - Mar 2016
May 2013 118100 mi US $800	Check engine light on - replaced O2 sensor

Toyota Highlander in Massachusetts, United States Apr 2016 - Apr 2016
Apr 2016	Engine light went on brought to dealer. Needed new engine due to sludge and new brakes. total repaIR would have been $7000. ended up selling car without doing work. Engine sludge was a problem Toyota knew abo did extend warrantee for 8 years

Toyota Highlander in British Columbia, Canada Sep 2012 - Dec 2018
Dec 2018 148180 mi C $184	starter replaced

Toyota Highlander in Tennessee, United States Nov 2012 - Jun 2018
Mar 2013 80000 mi US $350	Caliper stuck on right side.

Toyota Highlander in Michigan, United States Jul 2013 - Nov 2017
Aug 2013 136500 mi US $70	change frozen brake calipers. exhaust system gasket
Dec 2013 139000 mi	Intermittant electrical short causing front and rear defroster, a.c. clock and fan position switch to malfunction. Will cost over $1,000 replace climate control unit.
Sep 2014 143000 mi US $284	Now the front calipers locked up. Just paid for the rears last year

Toyota Highlander in Washington, United States Mar 2010 - Jul 2022
Apr 2010 92000 mi US $350	Engine sensor.

Return to top

Toyota Highlander in Michigan, United States Sep 2013 - Jul 2015
Jul 2015 138000 mi US $675	Emissions sustem

Return to top

Toyota Highlander in New York, United States Feb 2010 - Apr 2014
Dec 2011 88000 mi US $100	check engine light is on stated heated oxygen sensor bank 1 sensor 2. Could not determine if problem was sensor or catalytic converter. Replaced one sensor, light still on. Will have to keep working to try and solve problem as car needs inpsection asap. replaced second 02 sensor and check engine light went off was able to have inspected. Repair shop discovered small hole in oil pan which was leaking on regular basis. Brother-in-law replaced with new oil pan, oil & filter Transmission cooler hose was split and leaking. Replaced with new hose & new hose clamps

Toyota Highlander in Kansas, United States Jun 2011 - Jan 2015
Nov 2013 142000 mi US $300	right door stopped operating

Toyota Highlander in Ontario, Canada Sep 2010 - Jul 2012
Oct 2010 60760 mi C $400	transmission leaked and brake pads replaced
Jul 2012 66960 mi C $300	parking brake needed new cable

Return to top

See TrueDelta's information for all SUVs

See TrueDelta's information for all Toyota models.

Toyota Highlander repairs by problem area

Toyota Highlander repair cost distribution

2022 Toyota Highlander 4dr SUV

2021 Toyota Highlander 4dr SUV

2021 Toyota Highlander 4dr SUV

2020 Toyota Highlander 4dr SUV

2019 Toyota Highlander

2019 Toyota Highlander 4dr SUV

2019 Toyota Highlander 4dr SUV

2018 Toyota Highlander 4dr SUV

2018 Toyota Highlander 4dr SUV

2018 Toyota Highlander 4dr SUV

2017 Toyota Highlander 4dr SUV

2017 Toyota Highlander 4dr SUV

2017 Toyota Highlander 4dr SUV

2016 Toyota Highlander 4dr SUV

2016 Toyota Highlander 4dr SUV

2015 Toyota Highlander 4dr SUV

2015 Toyota Highlander 4dr SUV

2015 Toyota Highlander 4dr SUV

2014 Toyota Highlander 4dr SUV

2014 Toyota Highlander 4dr SUV

2014 Toyota Highlander 4dr SUV

2013 Toyota Highlander 4dr SUV

2013 Toyota Highlander 4dr SUV

2013 Toyota Highlander 4dr SUV

2012 Toyota Highlander 4dr SUV

2012 Toyota Highlander 4dr SUV

2012 Toyota Highlander 4dr SUV

2012 Toyota Highlander 4dr SUV

2011.5 Toyota Highlander

2011 Toyota Highlander 4dr SUV

2011 Toyota Highlander 4dr SUV

2011 Toyota Highlander 4dr SUV

2011 Toyota Highlander 4dr SUV

2010 Toyota Highlander

2010 Toyota Highlander 4dr SUV

2010 Toyota Highlander 4dr SUV

2010 Toyota Highlander 4dr SUV

2010 Toyota Highlander 4dr SUV

2010 Toyota Highlander 4-door

2009 Toyota Highlander 4dr SUV

2009 Toyota Highlander 4dr SUV

2009 Toyota Highlander 4dr SUV

2009 Toyota Highlander 4dr SUV

2008 Toyota Highlander 4dr SUV

2008 Toyota Highlander 4dr SUV

2008 Toyota Highlander 4dr SUV

2007 Toyota Highlander

2007 Toyota Highlander 4dr SUV

2007 Toyota Highlander 4dr SUV

2007 Toyota Highlander 4dr SUV

2007 Toyota Highlander 4dr SUV

2007 Toyota Highlander 4dr SUV

2006 Toyota Highlander

2006 Toyota Highlander 4dr SUV

2006 Toyota Highlander 4dr SUV

2006 Toyota Highlander 4dr SUV

2006 Toyota Highlander 4dr SUV

2006 Toyota Highlander 4dr SUV

2006 Toyota Highlander 4dr SUV

2005.5 Toyota Highlander 4dr SUV

2005 Toyota Highlander 4dr SUV

2005 Toyota Highlander 4dr SUV

2005 Toyota Highlander 4dr SUV

2004 Toyota Highlander 4dr SUV

2004 Toyota Highlander 4dr SUV

2004 Toyota Highlander 4dr SUV

2003 Toyota Highlander

2003 Toyota Highlander 4dr SUV

2003 Toyota Highlander 4dr SUV

2003 Toyota Highlander 4dr SUV

2003 Toyota Highlander 4dr SUV

2003 Toyota Highlander 4dr SUV

2002 Toyota Highlander 4dr SUV

2002 Toyota Highlander 4dr SUV

2002 Toyota Highlander 4dr SUV

2002 Toyota Highlander 4dr SUV

2001 Toyota Highlander

2001 Toyota Highlander 4dr SUV