Worried about potential repair costs? An extended warranty can provide peace of mind.
Chart based on 58 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2018 Ford Fiesta 4dr Sedan
120-horsepower 1.6L I4 5-speed manual FWD
2000 mi
After purchasing the vehicle new and driving it home, noticed that the spare tire well had about a gallon of water in it. The well cover was also wet. Sponged out the water and dried out the cover. Checked the trunk lid, rear window, and wheel wells for leaks but found none. Apparently, the dealer spilled water in the trunk during the detailing of the vehicle but cannot confirm this. The cover warped and the carpet is delaminating from the fiber board. Dealer has ordered a new cover.
Recall reprogramming of transmission, replace window seals, replaced back hatch door cover that warped in the sun. Replaced plastic dip on window trim that bubbled. Has to go back for latch replacement. Recall
19500 mi
Mirror scratched
26000 mi
Driver's side door mirror vibrates and disrupts visibility. They replaced the mirror assembly, it didn't fix the problem. They refused to do anything else stating that it didn't prevent operating the vehicle and replacing the door was unreasonable. Parcel shelf bracket broke. Dealer refused to fix it on warranty.
When replacing shift cables on a previous repair, noticed that the frame bracket that straddles the exhaust was severely rusted. Purchased new bracket, primed and painted it with Rustoleum, and installed it.
There was a crack formed on the left side mirror. Took it back to the dealer and got checked. Next week I was told that it's under warranty, so I took it back and got it fixed.
22300 mi
Plastic Clip on Tonneau cover came off and needed to be reattached.
Both rear pass door moldings were falling off. The seat was burnt while they had it.
23000 mi
Inside rubber door seal was peeling from rear driver door near window. Repaired under warranty by dealer. Seal failed again at same spot within a week and dealer glued it down on return trip. That seems to have done the trick.
12000 mi
US $10
Weather stripping came loose on RR door. New weather gasket installed. Weather stripping came loose on LR door, Parts ordered.
13000 mi
Dealer replaced LR door weather stripping, came loose next day. Restuck weather stripping- still holding.
15396 mi
Re-Secure rear bumper cover (loose bolts)
18870 mi
Left Front Wheel: Adjust and re-install clips in splash shield assembly. (missing bolts)
Front Bumper Assembly: Re-seat and secure front grill. (missing bolts)
34680 mi
Headlight housing burning on left headlight. Unit replaced under warranty
21700 mi
Rear window seal falling off.
30900 mi
Vibration/rubbing noise near front vent window.
40000 mi
Vibration never fixed. Twice they stuffed some double-sided tape into the crack and told me there was nothing else they could do. I ended up folding a piece of paper over several times and stuffing it in. Worked but looked ridiculous.
20080 mi
Drivers side mirror has a minor jitter or vibration from the glass itself. Noticeable over rough or uneven road surfaces.
14980 mi
Drivers side mirror has a minor jitter or vibration from the glass itself. Noticeable over rough or uneven road surfaces.
10800 mi
Rear door weatherstripping needed new adhesive application. Covered under TSB.
Thumping noise in rear of vehicle while driving over uneven pavement at low speed.
1860 mi
the vinyl strip about the drivers side window was peeling on delivery .. I have been to the shop 3 times to have it repaired and each time there has been a problem with the part and it has had to be returned...not repaired as of today
2480 mi
the covers for the 12 volt plug-ins on the console did not stay closed. Both front and back. The total plug-ins were replaced not just the lids. The console was damaged by the repair person. Outcome pending.
3100 mi
the rear shelf panel on the right side of the cargo area was split. the piece along with the trim was replaced
16300 mi
Weatherstrips peeling off from both rear doors
2800 mi
Rattle in interior drivers door handle at highway speeds, goes away if you grip handle. Dealer verified noises and removed door trim panel and applied felt tape to area behind handle and switches. Road tested and noises are gone.
2000 mi
Door edge trim peeling off.
25000 mi
No water had leaked, but the weatherstripping on the rear passenger door was coming loose.
28800 mi
US $60
Both rear doors weather stripping was coming off.
32860 mi
Broken piece of trim in liftgate hinge.
43400 mi
Replaced driver leather seat cover upper portion.
5500 mi
2" of seal around left rear door came loose. Dealer replaced entire upper door seal under warranty. 2" of seal around left rear door came loose. Dealer replaced entire upper door seal under warranty.
23699 mi
US $165
Trim at bottom of rear passenger side widow is coming loose at the front. Causing vinyl strip on door to bunch up at bottom. Replaced the trim piece. Did nothing about the bunching vinyl.
12000 mi
Fuse panel near driver's right foot not clipped properly, so panel would periodically detach from the center console. mechanic said a clip was missing, fixed easily.
59000 mi
Rubber lining around the rear driver-side window began to pull away from its setting; dealer needed to replace the rubber lining.
4500 mi
air leak in moonroof, replaced seal
8000 mi
water leak, interior musty and moldy
10000 mi
replace head liner and carpet ordered new seat cushions
21000 mi
weather strip on both rear windows coming off
22400 mi
strip still coming loose
24000 mi
weather strips on rear windows coming loose, finally glued it myself
26000 mi
Damage from water leak never fully repaired.
9000 mi
Rattling noise coming from passenger side dash. Dealer said it was coming from the mounts of the coolant tank. Adjustments made and noise has mostly gone away. May need to be revisited.
16000 mi
Weatherstrip on both rear doors began falling off again. Dealer ordered replacement parts and work was completed over the next 2 days.
5000 mi
US $10
Center cap for alloy wheel fell off and lost. I purhcased a new one and installed ($10) - not covered by Warr.
Weatherstripping along leading edge of rear windows on both sides of car tearing and coming loose. TSB 11-2-17 addressed problem, weatherstripping replaced.
7000 mi
weather stripping came off on driver side rear door
22940 mi
Door seal loose and repaired under warranty
19980 mi
C $79
Replaced weather stripping around door.
45000 mi
water in hatch area. missing body plug installed
65000 mi
US $350
Rear hatch seal developed leak. Carpet on right rear foot well was over an inch deep after a moderate rainstorm.
Interior carpet removed and dried seal replaced. Ford customer service paid all but extended warranty deductable.
19800 mi
Passenger door gasket failed. New gaskets installed.