| 1 | 0 | 3 | 4 | 3 | 4 |
2004 Chevrolet Silverado HD repairs by problem area
Engine (31%)
Transmission and Drivetrain (18%)
Brakes and Traction Control (10%)
Suspension and Steering (18%)
Electrical and Air Conditioning (13%)
Paint, Rust, Leaks, Rattles, and Trim (3%)
Other (7%)
Chart based on 61 repairs.
2004 Chevrolet Silverado HD engine repair cost distribution
$2500+ (11%)
$1000 - $2499 (5%)
$500 - $999 (11%)
$100 - $499 (53%)
< $100 (21%)
Chart based on 19 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2004 Chevrolet Silverado HD
Engine not specified
| 153000 mi US $4000 |
replaced leaking fuel injectors, lousy GM problem running away from a needed recall "extended warranty" |
| 155000 mi US $200 |
replaced water pump |
| 74000 mi US $450 |
Water pump replacement |
| 97000 mi US $200 |
Glow plug controller |
| 99000 mi US $330 |
Idler pulley bearing ceased up and shredded the serpentine belt. Was about 3 miles from dealer and able to drive without power brakes / steering. |
| 109600 mi US $300 |
Check engine light on for faulty glow plug |
2004 Chevrolet Silverado HD 4-door
turbocharged 8-cylinder diesel automatic 4WD
| 131300 mi US $400 |
OBDII Code P0238: Bad Turbocharger sensor needed to be replaced (required removing part of cooling line for access) |
| 146000 mi US $1800 |
Radiator replaced - factory original broke when shop was replacing transmission lines |
| 147000 mi US $225 |
Replaced leaking radiator hose |
| 155000 mi US $150 |
Exhaust pressure code thrown, slight "whistle" when operating while engine is cold or under heavy load. Problem was not pinpointed, will attempt a repair later. |
2004 Chevrolet Silverado HD 4-door
turbocharged 8-cylinder diesel automated manual 4WD
| 71000 mi US $119 |
Glow plug module control circuit Engine Code P0670. I replaced the Glow plug control circuit module with a new one and it fixed the problem. |
| 87000 mi US $917 |
Water pump replaced 89000 miles |
2004 Chevrolet Silverado HD 4-door
8-cylinder automatic 4WD
| 133760 mi C $6065 |
Engine was replaced with engine from an auto wrecker. The head gasket had gone. |
| 232000 mi US $250 |
Fuel lines rusted through. |
| 106000 mi US $30 |
Replaced a broken exhaust mount. |
| 106327 mi US $50 |
Replaced coolant reservoir, which had become opaque (and sludged) making the coolant level impossible to see. |
2004 Chevrolet Silverado HD 4-door
8-cylinder automatic 2WD
| 138000 mi US $580 |
Replace oil pan, front and rear seals and cover gaskets. Timing service and water pump |
| 147000 mi US $800 |
O2 sensor. |
| 104000 mi US $60 |
Emissions dash light...faulty gas cap |
See TrueDelta's information for all Chevrolet models.
