| 1 | 0 | 3 | 4 | 3 | 4 |
2010 Ford Flex repairs by problem area
Engine (16%)
Transmission and Drivetrain (9%)
Brakes and Traction Control (9%)
Suspension and Steering (20%)
Electrical and Air Conditioning (21%)
Paint, Rust, Leaks, Rattles, and Trim (18%)
Other (6%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 311 repairs.
2010 Ford Flex electrical repair cost distribution
$2500+ (0%)
$1000 - $2499 (2%)
$500 - $999 (7%)
$100 - $499 (42%)
< $100 (49%)
Chart based on 57 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2010 Ford Flex
Engine not specified
| 55000 mi US $225 |
blend door motor was replaced to correct heat coming out instead of cool air |
2010 Ford Flex 4dr SUV
turbocharged 355hp 3.5L V6 6-speed shiftable automatic AWD
| 33000 mi | liftgate motor inoperative, reset motor contol |
| 61000 mi US $539 |
refrigerant recharge replaced actuator $ 202 fixed leaks in AC , $539 Blown turbo, car in shop 22 days, cost > $3000 |
| 27580 mi C $480 |
Replaced rear pad and rotors at my expense. Replaced right front tire pressure sensor covered under warranty. |
| 36160 mi | Air bag warning light. Passenger side air bag faulty. Back ordered. Replaced by dealer after 3 weeks. |
| 46000 mi US $250 |
Factory passenger side headrest DVD player stopped working. Replaced with takeout unit from other flex. |
| 65000 mi US $20 |
Replaced heater blend door actuator |
| 116645 mi US $211 |
Blend door motor |
| 105000 mi US $350 |
multiple blend door actuator failures causing hot air to flow from the vents on the passenger side. |
| 35000 mi | Passenger side of the dual zone A/C quit working. Dealer rep[laced actuator. |
| 84600 mi | Heater blowing cold at idle. TSB recall. |
| 60500 mi C $100 |
AC blows warm |
| 30480 mi C $302 |
Rear driver side factory DVD headrest monitor failed. Was replaced under pro-rated warranty coverage and costs shared with dealer and Ford. |
| 45000 mi | Plate covering number pads on door rattle. Dealer relaced |
| 86460 mi C $300 |
Replace actuator motor for heater doors. |
| 60760 mi C $100 |
Power window drivers side stopped working, found to be faulty switch, replaced under Ford Extended Warranty just paid $100 deductible. |
| 56000 mi | A/C Vent actuator needed to be replaced. |
| 53000 mi | Passenger side mirror will not operate through range of motion when switch is pressed, mirror moves one "notch" then stops until switch is pressed again. Update: later cleared up, water intrusion? |
| 64000 mi | Blend door motor. |
| 66500 mi US $600 |
Blend door motor defective and replaced. |
| 41540 mi | Heater Damper motor was making load clicking noise |
| 59700 mi US $20 |
Blend Door Clicking at start and occasionally while driving. System still working, just makes occasional ratcheting noise. I'm fixing it. Parts on order. |
| 32000 mi | Rear DVD players will not turn off. |
| 7440 mi | TPMS sensor fault message received intermittently. Brought car in to dealer but the message was not on at that time. Dealer said to come back when the message was on. |
| 11780 mi | Dealer still cannot figure out the faulty TPMS message. |
| 15500 mi | Passenger side DVD player monitor turns on and off intermittently and on it's own. New headrest DVD ordered to be installed later. TPMS sensor fault message. |
| 16120 mi | New DVD Headrest ordered and replaced. Works fine now. |
| 25420 mi | Monitor "A" (behind driver) would not turn off. When pressed off, it would restart after 3-4 seconds. Dealer could not replicate. |
| 27900 mi | Monitor A would not turn off. Replaced under warranty now. |
| 23000 mi | Erratic Remote Start operation. When engaging the Remote Start, the alarm would active, and the car didn't remotely start. The Fix: The remote Start Module was replaced under warranty. |
| 18800 mi | leaks freon. dye added. return trip required |
| 57000 mi US $600 |
"Vane" for mixing warm / cold air was stuck. |
| 68000 mi US $100 |
blender solenoid behind instrument cluster was ticking with a clock like noise |
| 44000 mi US $100 |
Two separate trips for different actuators Second actuator |
| 61000 mi US $100 |
heat went out on passenger side. solenoid were replaced under extended warranty |
2010 Ford Flex 4dr SUV
262-horsepower 3.5L V6 6-speed automatic FWD
| 71000 mi | Loud whistling noise when the heating/AC system is set to the floor. Air flow door seems to be stuck. No repair done, Ford would not cover under extended warranty. |
| 71000 mi | Loud whistling noise when the heating/AC system is set to the floor. Air flow door seems to be stuck. No repair done, Ford would not cover under extended warranty. |
| 15000 mi | power assist feature on rear hatch operated intermittently Installed SPO , linear strut motor on rear hatch, repair appears to be successful |
| 88000 mi US $60 |
Drivers side mirror motor replacement |
| 29000 mi US $100 |
Replace recirc door actuator |
| 37000 mi US $100 |
Windshield Washer pump/motor |
| 139500 mi C $300 |
The damper between the front split heat/cool control was not functional. Service was required and a component was replaced. An actuator was replaced. |
| 69000 mi US $100 |
Replace broken switch on rear power window. |
| 98000 mi US $800 |
Leak in one of the A/C lines |
| 56600 mi US $290 |
replace air intake door actuator |
| 6000 mi | Sirrus radio plays at low volume while AUX line is being played. replaced radio seems to have resolved problem |
| 24000 mi | Passenger-side window switch had become disconnected. |
| 65000 mi US $100 |
Cluster light came on for airbag. Two loose wire connections found on passenger side airbags. Cleaned connections and plugged in at a cost of $100 deductable from extended warranty. |
| 73000 mi | The air bag light came on - found loose cable. |
| 159000 mi US $1000 |
Replaced condensor |
| 15000 mi | Satellite radio bled through the Aux input |
| 24300 mi | Actuater fan needed to be replaced. Warranty work |
2010 Ford Flex 4dr SUV
262-horsepower 3.5L V6 6-speed automatic AWD
| 5000 mi | Driver's side headlight shuts off. Had to order a ballast. |
| 59920 mi C $120 |
Battery died |
| 46000 mi US $100 |
heat/cold actuator |
| 39680 mi | Front blower motor was slightly noisy and was replaced. |
| 65000 mi US $400 |
Motor in heating system failed resulting in cold air only on passenger side. |
| 6000 mi | Interior light dimmer switch broke. Was repaired in about 1.5 hours. |
| 33300 mi US $146 |
Replace recirculation door actuator that had been clicking. |
| 4300 mi | - Rear Passenger side window not opening - fixed |
See TrueDelta's information for all SUVs
See TrueDelta's information for all Ford models.
