Worried about potential repair costs? An extended warranty can provide peace of mind.
Chart based on 95 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
Water was leaking through the headlights into the car. Stuff has to be removed, cleaned, changed and put back
The problem reoccurred after a few weeks and on the second time the repair was successful. Or it’s been a few weeks and so far so good.
roof trim replaced because it was a little bit torn upon delivery. It was torn during a recall for side curtain made before arrival to the dealer. they noticed it on pre-delivery inspection.
8000 mi
Water leaks and AC hose recall. They performed AC hose recall. Water leaks along the passenger footwell still occur. Not fixed and awaiting for leaks to re-occur before being able to diagnose per dealer.
4000 mi
Driver door had rattling when driving on any kind of road surface.
13000 mi
Passenger seatbelt squeaked when passenger was using it. Required dis-assembly and re-assembly by dealer to fix.
72540 mi
C $500
Sunroof cracked in left front corner for no reason, replaced thru insurance @$1450. With $500 deductible.
44300 mi
Moonroof sun shade fell down out of the track. A new sun shade was installed under warranty.
Sunroof leak into head console unit (auto wipers/headlights/drive assist)
Sunroof seal replaced
32000 mi
Sunroof leaked in heavy rain. Volvo knew about the issue and had a repair. I was pleased with their service.
7000 mi
Rattle in headliner/sunroof assembly Repair to sunroof to fix rattle was unsuccessful. Car began leaking into front passenger foot wells and ruined headliner. Volvo bought the car back the following month.
16830 mi
Interior Trim Panel came loose. Ordered fasteners to reattach. Interior Trim Panel came loose. Ordered fasteners to reattach.
17767 mi
Interior panel clips replaced from previous visit.
27876 mi
Rear View Mirror loose. Anti Rattle Tape applied
32874 mi
Seal around trunk falling off. Replaced seal
20000 mi
Sunroof would not operate. Had to have software updated.
68000 mi
US $450
replaced shark fin antenna seal
5000 mi
sunroof motor system was grinding, replaced with new.
12000 mi
Sunroof wasn't sealed correctly and water leaked in during a car-wash. Dealer pulled sunroof assembly and re-sealed.
15000 mi
During a routine car wash, water leaked in through the sunroof near the C-pillar
2800 mi
Water leaks behind the rear view mirror.
6500 mi
Rattle from back seat area.
9500 mi
When accelerating uphill at 30-45 mph, there are rattling noises coming from the dashboard. Dealership couldn't duplicate the noise though a technician did hear it when I drove the vehicle.
13640 mi
Water leaking oil from sunroof. Broken seal to be replaced. waiting for part.
13640 mi
Dealer lost the order for the part to fix the roof. Finally got it, took better part of a day to fix it but couldnt.. something went wrong. Ordered more parts and had the car for 4 days plus the weekend.
43000 mi
Minor leak near the rear view mirror in heavy rain only. Turned out being a clogged sunroof drain tube. Unfortunately, they broke the windshield during the repair, so it took 5 days (ordering new heated windshield). Otherwise, the leak would have been fixed during scheduled maintenance.
30000 mi
Sunroof gasket kept snagging on other sun roof parts and pulling off...big time leak into car. Volvo replaced retractable glass entirely. OK now
15500 mi
$500
Broken hood opening lever replaced.
39680 mi
Leaky sun roof
Leather on Dash split
49600 mi
Doors would freeze open when temp dipped below zero. Apparently there is a gasket or something inside of the door that deflects water from the mechanics, it needed to be adjusted/ replaced.
Driver's side rear reverse and signal lights enclosures started fogging/having water penetration. Dealer replaced enclosures and bulb (don't know which one) under warranty and I was told that the water penetration was caused by a crack.
Sunroof and sunshade both not working smoothly. Internal parts were replaced to correct issue under warranty.
52900 mi
US $100
Headlights have gotten dull and yellow. I bought kit to restore plastic lenses (polishing them) and a film to protect them. Did work myself.
26660 mi
rear window was rattling. Dealership fixed it at no cost to owner rattling from drivers side rear window. Dealership corrected it with some felt tape.
68000 mi
US $900
Plastic frame around driver's seat cracked
51000 mi
Cracks in finish of Sapeli wood steering wheel (cosmetic defect). Cup holder cover (between front seats) was sticking, which is a common XC90 problem. Both replaced under warranty. LOF ahead of schedule to find any problems before warranty end (50k).
74360 mi
C $1100
Moonroof exploded while driving at highway speed.
34000 mi
Console cupholder was not opening and closing smoothly. Dealer replaced assembly. Exterior left rear window trim piece was loose. Dealer ordered replacement parts.
23000 mi
water leak in rear tail light, housing replaced
24000 mi
replaced wiring harness for tail light, which was real cause of the leak in the tail light (housing was previously replaced)
Creaking sound when slowly accelerating from stop.
89000 mi
Driver door interior trim came unglued in heat and fell off.
33000 mi
speaker came ajar from driver door panel Cup holder sticks Door handle paint coming off
36000 mi
Front lights became cloudy. (Door handles lost paint - previously noted.) Loose interior panels, third row seat leather torn by reclining them--bad design. Not fixed because denied warranty coverage on them.
headlight replaced after two years of complaining about hazing. ripped off by dealer when they said car was CPO and had CPO warranty. Dealer didnt submit papers and says my fault!! next car not a Volvo.
55180 mi
squeaking from driver's door. Rattle when using radio. Diagnosis indetermanent because unable to replicate problem.
145000 mi
US $250
windshield replaced
148000 mi
US $30
Use a lens repair kit on the headlights and got them almost perfectly clear!
150000 mi
Used gorilla glue gel to reattach lose moldings on left doors.
Both headlights replaced due to plastic housing hazing.
60000 mi
Clanking noise
62620 mi
€75
The headlight washer on passenger side was replaced. Old cover that extends out of the front bumber fell off during a recent use onto the highway. New part was ordered, painted, and intalled.
Tweeter speaker cover fell off [again]. One of the few design flaws in this Volvo. Instead of replacing, they just put a few drops of glue on it to hold it on. Sounds kluge-ee but it works and much cheaper than whole new speaker.
Car has high pressure headlight washer nozzles imbedded inside bumper with a color matched cover with a built in gimble for the nozzle to swivel up to the headlight. Covers cost $300. for two (2) including paint, new nozzles and install.
62000 mi
US $35
"Soft Touch" plastic panel surround on drivers seat controls cracked and slowly disintegrated. Part replaced by owner as the shop was backed up. 30 dollar part, about an hour to R&R Parts came in a while ago, owner finally replaced. Ultimately a simple repair but w/o shop knowing process ( 1st time occurence for them) it took about an hour and a half to disassemble and "noodle out" the fix
Rebuilt the sunroof drains at base of A pillar to eliminate the flow restrictions (remove original drain connection at bottom of A-pillar, replaced with open tubing). Needed because the original drains self-destroyed & plugged.
65000 mi
US $1100
Car smells like mildew after washes, rain, being parked outside. Dealer wanted to change the sunroof drains at a cost of $700. I refused to pay that much to correct a design flaw and will look to replace the drains elsewhere.
58484 mi
US $1997
Cleared clogged sunroof drains, cut elbow opening larger to prevent further clogging. Cleaned up standing water on front passenger side and removed carpets to be dried.
72000 mi
US $65
Replaced 3rd row seat release cable
11000 mi
Trunk latch failed, both outside and the safety latch inside; so no trunk access at all (and was out of town with my whole family). Dealer replaced at no charge, along with rear cupholder which had broken.
Discovered water on carpet and beneath floor. Diagnosed as sunroof drain. Fixed plugged drain and dried carpets and foam beneath.
109000 mi
US $153
Headlights were beginning to get foggy glaze on them. Took to Walmart and had "headlight restoration" service completed for $30 complete with lifetime guarantee. The service and result was EXCELLENT. I highly recommend this service!!
210300 mi
US $6
Clogged sunroof drains on both sides. 2 inches of water under carpet. Replaced vinyl drain line with hose from hardware store to drain directly, not using the 90 degree fitting that causes clog. Removed floor carpets to airdry for four days.
104160 mi
Headlight lenses foggy
101880 mi
C $1200
Unplugged sunroof drains.
115940 mi
C $685
Seal near cowl was cracked which allowed water into interior. Also has to remove seats and carpets to remove accumlated water that was sloshing around under the floor of the vehicle
After heavy rain passenger floor mat was wet. Cleaned front sunroof drain tubes and cut rubber elbow ends to allow for debris to flow freely. Also removed and air dried the passenger floor panel. Leak is fixed. 45 minutes total time.
44406 mi
C $56
Cupholder Lid inbetween 2 front seats got stuck, had to be partially dismantled, rear underlid latch mechanism in wrong position, was repaired but is still sticky. Must be very careful when utilizing
As result of heavy rain, huge leakage through the draining openings in the cowl in front of the windscreen. High level of water in both the front floor sections of the body, under the front chairs. As result of heavy rain, huge leakage through the draining openings in the cowl in front of the windscreen. High level of water in both the front floor sections of the body, under the front chairs.