| 1 | 0 | 3 | 4 | 3 | 4 |
2004 Jeep Wrangler repairs by problem area
Chart based on 22 repairs.
Chart based on 21 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2004 Jeep Wrangler 2dr SUV
190-horsepower 4.0L I6 5-speed manual 4WD, part-time w/low range
| Jeep Wrangler in Wisconsin, United States - Apr 2008 | |||
| Jan 2008 45000 mi US $3000 |
full top end replacement. Camshaft lobe failue, caused valve train damage. Heads machined, camshaft & all valves replaced. FIXED UNDER WARRANTY (7 - 70,000), but definately would have been an expensive repair.. | ||
| Apr 2008 48000 mi US $300 |
sway bar linkage broke off. replaced linkage and bushing, stupid me went to dealership hoping for warranty work, wasn't covered - ended up paying labor, full charge parts, and their BS $70 'diagnostic' fee. This is a repair you should try to DIY | ||
| Jeep Wrangler in Georgia, United States - Jun 2011 | |||
| Jun 2011 44000 mi US $27 |
Replaced blower fan switch and heater resistor block. Replaced switch first only to find out that wasn't the problem. Heator Block resistor cost $27.99 at AutoZone with a lifetime warranty! Did the work myself. | ||
| Jeep Wrangler in Washington, United States Jun 2010 - Jun 2014 | |||
| Aug 2010 51000 mi US $2400 |
Damaged transfer case, due to improper maintenance. Replaced entire coil and springs due to premature failure from aftermarket winch | ||
| Jeep Wrangler in California, United States Jan 2015 - Sep 2017 | |||
| Sep 2017 152000 mi US $200 |
Clutch went out. Replaced clutch, flywheel and throw out bearing. | ||
| Jeep Wrangler in Alabama, United States Dec 2014 - Apr 2017 | |||
| Jul 2015 98300 mi US $2 |
Automatic / linkage broke underneath. Used to zip ties to re-join. | ||
| Aug 2015 99100 mi US $250 |
Water pump failure | ||
| Jeep Wrangler in Michigan, United States Jul 2015 - Jul 2018 | |||
| Aug 2016 148000 mi US $750 |
replaced ball joints | ||
| Jul 2018 156000 mi US $800 |
Hole in pipe, had to replace the entire exhaust. | ||
| Jeep Wrangler in Connecticut, United States Sep 2014 - Jun 2018 | |||
| Oct 2014 134500 mi US $500 |
oil pan rusted out and needed to be replaced. | ||
| Dec 2015 148000 mi US $400 |
Interior of windshield frame rotted out completely Seatbelt retractors broken. | ||
| Jun 2016 149000 mi US $140 |
Fuel pump broke. | ||
| Apr 2017 151000 mi US $100 |
Starter | ||
| Jeep Wrangler in New York, United States Mar 2015 - Mar 2016 | |||
| Mar 2016 62000 mi US $150 |
Front caliper froze - replaced both and pads/rotors. | ||
| Jeep Wrangler in Virginia, United States Oct 2014 - Oct 2019 | |||
| Nov 2015 37600 mi US $1000 |
The brakes were so bad (one caliper frozen) that we had to have a full brake job at a time i consider early. But it is not a car fault but rather due to lack of use, so you probabrbly want to not consider this as a reliability issue. | ||
| Jul 2016 39000 mi US $2600 |
Replaced worn tie rods and performed alignment. | ||
2004 Jeep Wrangler 2dr SUV
190-horsepower 4.0L I6 4-speed automatic 4WD, part-time w/low range
| Jeep Wrangler in Massachusetts, United States Sep 2016 - Dec 2016 | |||
| Dec 2016 122000 mi US $25 |
Oil pressure sending unit | ||
2004 Jeep Wrangler 2-door
4-cylinder automatic 4WD
| Jeep Wrangler in Virginia, United States Sep 2014 - Sep 2017 | |||
| Dec 2015 73000 mi US $177 |
o2 sensor | ||
| Aug 2016 74000 mi US $500 |
Ball joint | ||
| Mar 2017 81000 mi US $100 |
Replace power steering hose. | ||
See TrueDelta's information for all SUVs
See TrueDelta's information for all Jeep models.
