| 1 | 0 | 3 | 4 | 3 | 4 |
2006 Volvo XC90 repairs by problem area
Engine (23%)
Transmission and Drivetrain (10%)
Brakes and Traction Control (4%)
Suspension and Steering (29%)
Electrical and Air Conditioning (20%)
Paint, Rust, Leaks, Rattles, and Trim (7%)
Other (7%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 247 repairs.
2006 Volvo XC90 transmission repair cost distribution
$2500+ (14%)
$1000 - $2499 (18%)
$500 - $999 (23%)
$100 - $499 (9%)
< $100 (36%)
Chart based on 22 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2006 Volvo XC90
Engine not specified
| 63300 mi US $2000 |
Big noise at the bottom. A part controling 4 wheel drive was broken and replaced. |
2006 Volvo XC90 4dr SUV
turbocharged 208hp 2.5L I5 5-speed shiftable automatic AWD
| 87200 mi | Replaced leaking transmission cooler. |
| 82140 mi C $500 |
Angle gear resealed and rear driveshaft coupler |
| 141000 mi US $1200 |
Replaced front Angle Gear. AWD stopped functioning |
| 121000 mi US $350 |
Removed and repaired Rear Electronic Module and replaced. ABS and park assist warning lights came on. Also think it disabled AWD. |
| 62000 mi C $400 |
Road noise proportional to road speed. Dealer diagnosed problem to transfer case. Stripped spline shaft; replace transfer case. Problem remains. Rediagnose at local mechanic. Identified bad wheel bearing; replaced. Problem resolved. |
2006 Volvo XC90 4dr SUV
turbocharged 182hp 2.4L I5 Diesel 6-speed manual AWD
| 76000 mi | Rear prop shaft and transfer box replaced because of leaking seals. |
| 76000 mi | Prop shaft whining when traded car in. Started doing this after the repair. |
2006 Volvo XC90 4dr SUV
311-horsepower 4.4L V8 6-speed shiftable automatic AWD
| 108000 mi £680 |
Replace Transmission Shift Lever Cables |
| 73000 mi US $700 |
Replace unknown fluid with Volvo spec fluid |
| 73000 mi | Dealer said the transmission had to be replaced after a previous 2500 was spent on transmission repairs. |
| 84500 mi US $2400 |
Oil leak from main bearing seal and valve cover gaskets. |
| 77000 mi US $500 |
Pressure sensor in haldex failed, AWD would not engage |
| 79000 mi | transmission would kick and get stuck in neutral, transmission service urgent light came on; transmission valve body was replaced; cost of $2400 was covered by the extended warranty |
| 176700 mi | replaced worn out bolt joins |
| 114700 mi | Gear Box Repair |
| 93000 mi US $1500 |
rear axle replaced |
| 99000 mi US $4000 |
Replaced transmission |
| 78300 mi US $900 |
Transmission stay in first gear too long then jump directly to 3rd and skip the 2nd gear. Dealer update the software then problem is gone. |
2006 Volvo XC90 4-door
turbocharged 6-cylinder automatic AWD
| 60760 mi | Transmission service urgent warning came on. Transmission flushed and warning reset. Gearbox broke down completely one week later. |
| 60760 mi | After transmission flush less than two weeks passed. Suddenly lost reverse gear and on way to shop lost first gear. Transmission extensively rebuilt |
| 74400 mi | Tapping sound from drivetrain diagnosed as worn propshaft replaced at cost of US$2000 but covered by extended warranty |
See TrueDelta's information for all SUVs
See TrueDelta's information for all Volvo models.
