Worried about potential repair costs? An extended warranty can provide peace of mind.
Chart based on 47 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2009 Chevrolet HHR
Engine not specified
9300 mi
WINDSHIELD HAS SMALL POCK MARKS ALL OVER AND CONTINUE TO INCREASE EVERY DAY. DEALER SAYS ROAD DEBRIS BUT HAD A ROCK HIT IT AND NO DAMAGE. I BELIEVE GLASS IS FAULTY AND DISINGRATING. THEY WILL NOT REPLACE UNDER WARRANTY
My locks were freezing open and my keyfob's would not start the car because the doors never locked. They repositioned some foam around the lock actuators and it has appeared to fix the problem. The rear trunk struts have been weak since purchase. After being told it was "normal" from two dealerships, the third one I took it to replaced them and my hatch finally works as it should.
22000 mi
The passenger seat belt locked up. Dealer replaced under warranty.
Hydraulic lifters on rear door were weak, replaced under warranty.
3000 mi
Drivers right exterior rear view mirror glass fell out of housing while driving. A screw stuck to the back of the mirror at the factory prevented it from completely seating. Mirror glass was replaced.
30380 mi
Drivers door dropped a tiny bit when opened. Problem eliminated by adjusting top door hinge.
38000 mi
US $75
Replaced wiper transmission
118000 mi
US $80
Driver wiper not working, passenger side still working.
Replace wiper transmission (linkage)
143000 mi
US $75
Passenger wiper not working, replaced wiper transmission
turn signals had stopped turning off after turns were completed. Both left and right directions were affected. Both slight and sharp curves caused the problem. Problem happened at both slow and fast speeds.
61500 mi
US $24
TPMS needs to have new sensors. Dashboard "idiot" light displays SVC TIRE MONITOR in hot weather. Annoying. Shop just reset it and suggested I might want to replace the sensor (s). I didn't do it at this time.
Windshield wiper linkage joint on driver's side came apart due to worn plastic joint. I drilled the joint with a 3/16 bit and added a bolt with nut to secure the joint.
28000 mi
Intermittent wipers inconsistent and sometimes wont turn on. Outer weatherstripping no longer contacting lower part of doors. Dealer could not find problem with wipers and was told weatherstripping was not supposed to contact door bottom.
8000 mi
Sunroof front passenger-side drain-tube leaking water into passenger front floor. Tech attached drain-tube to drain exit. Same problem, sunroof front passenger-side drain-tube leaking water into passenger floor. Tech reattached drain-tube to drain exit and secured with zip-tie.
16000 mi
Sunroof jammed open.
35700 mi
US $258
Reinstalled regulator bolt that had fallen out inside rear driver's door window.
86300 mi
US $500
I put new wheels on the car in August, the stock wheels kept corroding and wouldn't let the tires hold air.
Key will not turn to lock position when car is parked after driving. Out of warranty, to expensive to repair. You have to restart car and move it back and forth to be able to get key out.
Wiper linkage replaced on passenger side wiper, stopped working. Driver side was still working properly.
14000 mi
Intermittent wipers not working properly or consistently. Dealer had previously told me it was "known" problem and ordered parts. This time I was told that there was no such known issue, no parts were ever ordered, and they could not duplicate problem so
20000 mi
Door restraint bar had cracked sheathing and was replaced.
Sunroof air deflector would not close. Clip attaching deflector to sunroof track broke.
3000 mi
Ignition would not release key.
39000 mi
Auxillary glovebox open button broke.
39000 mi
Auxillary glovebox open button broke.
10700 mi
Replaced running boards because pads wavy
22320 mi
Drivers seat belt did not retract properly. A replacement was ordered. No cost under warranty. New seatbelt retractor installed.
86680 mi
C $180
Wiper arm broke
40000 mi
US $450
"Failed inspection because of divet in windshield. Windshield had to be replaced.
25000 mi
sunroof deflector broke and jammed the window, had to replace unit.
83000 mi
US $339
Install new liftgate latch, parts & labor
10000 mi
Water on front floor. Another appointment for in depth water leak search. Printed up 4 pages of tsb's and 10 pages of customer comments on water leak results from "HHR Forum". Presented to service tech. They spent 1 1/2 days "repairing. Hopefully all is well.
13000 mi
Sunroof screen support broke. Compass located in rear view mirror sticking.
34720 mi
Door mechanism to control how much door open broken. Ordered part, still haven't fixed rattle in back of car suspension, maybe next visit.
65000 mi
Running light seemed to be missing.-----had fallen off and was in the "hole' Pulled forward and plugged in.
See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how
frequently Chevrolet HHR problems occur, check out our car reliability stats.