

turbocharged 400hp 3.0L V6 10-speed shiftable automatic AWD
Ford Explorer in Northwest Territory, Canada Dec 2021 - Jun 2022 | |||
May 2022 3720 mi |
Affected Explorers will be sent to dealerships for inspection and repair. Based on the Explorer model, dealers will either replace the bushing and axle cover or update the electronic parking brake software. |
Ford Explorer in British Columbia, Canada Dec 2021 - Jul 2022 | |||
Jul 2022 6820 mi |
Accident avoidance sensor failed |
Engine not specified
Ford Explorer in Michigan, United States May 2021 - Apr 2022 | |||
Jun 2021 1000 mi |
Shakes at 40 MPH. Gear hunting and jerky operation. | ||
Jul 2021 1000 mi |
Same as the first trip Still experiencing the same problems There’s been over 7 trips. It’s been in the shop for about half of my ownership experience. Maybe 65%. | ||
Sep 2021 2000 mi |
It’s been like Ground Hog Day. Lemon law lawsuit filed. | ||
Dec 2021 4000 mi |
This problem continued into January and February |
turbocharged 400hp 3.0L V6 10-speed shiftable automatic AWD
Ford Explorer in Alberta, Canada Jan 2021 - Jun 2022 | |||
Sep 2021 11780 mi |
Inside plastic trim on driver side door was sagging |
Ford Explorer in Virginia, United States Oct 2020 - Jun 2022 | |||
May 2021 2000 mi |
Reprogrammed transmission due to rough shifting and missed gears |
285-horsepower 3.3L V6 Hybrid 10-speed shiftable automatic AWD
Ford Explorer in Rhode Island, United States Jul 2021 - Jun 2022 | |||
Feb 2022 1850 mi |
Check engine light on at 1800 miles. Code indicated.misfire condition. Diagnosis of coolant leaking into cylinders. Engine (long block) replaced by dealer. Delay in work being completed due to lack of engines, and Covid. Low Battery Voltage warning came on, battery replaced with new. | ||
Apr 2022 3000 mi |
Drivetrain vibration detected at 40 mph when vehicle is cold (ambient temp approx 40 F). Isolated to rear driveshaft. Driveshaft replaced. |
turbocharged 400hp 3.0L V6 10-speed shiftable automatic AWD
Ford Explorer in New Jersey, United States Jan 2021 - Apr 2022 | |||
Nov 2021 21000 mi |
Malfunction Indicator Lamp - Regulatory |
Ford Explorer in Georgia, United States Dec 2020 - Jun 2022 | |||
Mar 2021 10000 mi |
4 wheel drive fault Replaced drive shaft sensor |
Ford Explorer in North Carolina, United States Jun 2021 - Jun 2022 | |||
Apr 2022 14000 mi |
Sync 3 system would blue screen and backup camera would not work. Dealer installed Sync 4 software update. Ford will need to replace compchip to correct. |
Ford Explorer in North Carolina, United States Oct 2020 - Jun 2022 | |||
Jun 2022 33000 mi |
Camera, updated firmware on first visit, still got random blue screen on backup camera. Replaced control module on second visit, same issue. Updated module and camera firmware on third visit, same issue. Replaced camera on fourth visit, appears to have fixed issue. |
turbocharged 300hp 2.3L I4 10-speed shiftable automatic RWD
Ford Explorer in Florida, United States Jun 2021 - Jun 2022 | |||
May 2022 14800 mi |
Hard down-shifts. Transmission “hunting”. Transmission over-hauled. | ||
Jun 2022 14800 mi |
The audio system quit responding to "instructions" during the pre-delivery prep. The car thought it was at the Ford plant in Dearborn. The dealer disconnected the battery for 15 minutes or so and connected the car to their wi-fi. That restored the audio and GPS function (for about a week). The audio would quit responding altogether or it would not change stations or volume. The manual says that the computer shuts some systems down when the battery gets thin and that seemed to bear out (short trips and commute). I put it on a charger overnight and that restored for a while. Then after the transmission failed and needed to be overhauled, the audio quit again. They tested and found a failed Audio Control Module. I think it's still at the dealership unsaleable due to the rear axle bolt recall and failed module. |
Ford Explorer in New Mexico, United States Jun 2020 - Jul 2022 | |||
Oct 2020 8000 mi |
New transmission cooler installed under warranty |
Ford Explorer in Ontario, Canada May 2020 - Jun 2022 | |||
Jan 2021 5 mi |
Drivers door lock failed, unable to unlock drivers door. Vehicle was in the dealer for over a month waiting for new door locks. Apparently parts are backordered as this has been as issue with the new Explorers. | ||
Jan 2022 19840 mi |
Drivers door lock failed, would not unlock or lock, set alarm off when attempting to gain entry Front collision warning inoperative. | ||
Jun 2022 24800 mi |
Windshield replaced due to faulty collision sensor. |
turbocharged 300hp 2.3L I4 10-speed shiftable automatic AWD
Ford Explorer in Illinois, United States Jan 2021 - Jan 2022 | |||
Oct 2021 14000 mi |
Transmission slipped into 2nd gear upon taking off from stop- dealer had to flash control module LED front turn signal stopped working- had to have entire headlight assembly replaced |
turbocharged 365hp 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Delaware, United States Jan 2018 - Jun 2018 | |||
May 2018 4000 mi |
Check charging system now warning....Battery wss replaced |
Ford Explorer in Indiana, United States Dec 2017 - Jun 2022 | |||
Feb 2018 1000 mi |
Inverter for 120v outlet was making a very high pitched noise. Inverter replaced. |
290-horsepower 3.5L V6 6-speed shiftable automatic FWD
Ford Explorer in British Columbia, Canada May 2018 - Jun 2022 | |||
Jul 2021 17980 mi |
Roof rack rail mount was loose | ||
Dec 2021 20460 mi C $290 |
Replace and re-set keyless door fob | ||
Jun 2022 21080 mi |
Nick in electrical wire harness under driver seat caused battery drain and vehicle would not start. Most likely happened during factory assembly. Technician replaced wiring and harness. |
Ford Explorer in Texas, United States Dec 2020 - Jun 2022 | |||
Jan 2021 25000 mi |
One horn quit working. This was the second time since purchase. Quite an involved process to fix. The front grill and fender must be removed to access and replace. |
290-horsepower 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Illinois, United States Feb 2018 - Jan 2022 | |||
Sep 2021 60000 mi US $700 |
Replace rotors and discs |
Engine not specified
Ford Explorer in Virginia, United States Dec 2021 - Apr 2023 | |||
Sep 2022 61000 mi US $250 |
Replaced whining alternator. Replaced upper left and right rear control arms. |
turbocharged 365hp 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in New Jersey, United States Jan 2017 - Dec 2017 | |||
Aug 2017 6000 mi |
transmission had to be replaced. |
Ford Explorer in Virginia, United States Aug 2016 - Jun 2017 | |||
May 2017 7500 mi |
rear seat belt jammed |
Ford Explorer in Georgia, United States May 2017 - Aug 2019 | |||
Jul 2017 500 mi |
Re-balance of all 4 wheels | ||
Nov 2017 5000 mi |
Replaced Driver Side Roof Rack Rail and related hardware. Replaced torn Driver Door Seal | ||
Jun 2018 11000 mi |
Brake light switch at the brake peddle was replaced because it would stick in the "on" position leaving the brake lights on when the brake peddle was not depressed. | ||
Sep 2018 13000 mi |
Driver's seat not cooling properly |
Ford Explorer in California, United States Nov 2016 - Dec 2020 | |||
Sep 2017 5000 mi |
Paint drip was repaired |
Ford Explorer in Ontario, Canada Sep 2016 - Oct 2019 | |||
Apr 2017 1860 mi |
The OEM wheels were installed in place of the Winter wheels on April 12th. First time I had a chance to drive on the OEM Hankooks and there was a slight vibration which gradually got worse over the following days. Took the vehicle back to the dealer and they rebalanced all wheels. Vibration now 95% gone. No Charge. Will continue to drive the vehicle some more to see what happens and report back to dealer service department as requested. | ||
Oct 2018 5181 mi C $138 |
Winter wheels installed |
Ford Explorer in Texas, United States Oct 2016 - Jun 2022 | |||
Jul 2018 13000 mi |
Paint bubbling up on leading edge of hood | ||
May 2022 53000 mi US $275 |
BOTH a pillar trim lose - I replaced both with new parts | ||
Jun 2022 53365 mi US $204 |
replace rear pads - they wanted to replace rotors - thats crazy with only 53k miles |
Ford Explorer in Connecticut, United States Aug 2016 - Oct 2018 | |||
Jul 2018 18000 mi |
Oil leak developed after 16,000 miles. The Ford is garaged every day and in the Spring when I had it out of the garage to give it a good cleaning, I noticed oil spots on the garage floor that had been building up. I took it to Brewster Ford, the dealership from which I purchased it, and so far, I've had to bring it back 4 times for the same issue - oil leak. The first time, they said they had to keep it overnight because they needed more time to find the source and I was not able to leave it without a loaner. I brought it back a week later at 7:30am and by 3:30pm that afternoon, they said they had repaired the leak by replacing the rear engine seal. I picked up the vehicle and found it leaking within a few days. I brought the Ford back a 3rd time. This time they kept it over night and said they had replaced the oil pan gasket sealant as well as the turbo seal. The vehicle started leaking again within a few days. Last week, I brought it back for the 4th time and now they're telling me that they've had to open a case with Ford to request technical assistance from the engineering group. They said they located the leak and it's not horrible, but that it shouldn't be happening [no kidding]. I don't know what the problem is and neither does the dealership apparently. Still waiting to hear what's going to happen with my new vehicle. I'll never buy another Ford again based on this experience. I think it's a combination of having to deal with a dealership that should have located the source early - why has it taken them this long to finally open a case with Ford? In speaking with the Regional Customer Service Manager, there could be a crack in the block causing the leak and they'll have to replace the engine, but I don't want the vehicle anymore because there may be more issues down the road. I paid $50k for this vehicle, brand new in July, 2016 and shouldn't be having an issue like this so early on. Very disappointed. | ||
Oct 2018 18000 mi |
After multiple trips to the dealer in an attempt to repair a slow oil leak, Ford agreed to buy the vehicle back from me. I drove the lemon back to the dealer I bought it from only 2 years earlier and they gave me a check and cancelled the balance of my car loan. It was very frustrating lasting months going back and forth to the dealer, but Ford did the right thing and took the vehicle back. |
Ford Explorer in Florida, United States Mar 2017 - Apr 2020 | |||
May 2018 17000 mi US $800 |
Rear tires replaced after going bald due to towing. Alignment checked but very close to correct. Assume pulling a 2 axle car trailer on 2 trips of 1600 mi caused the issue as the front tires look new. |
Ford Explorer in Quebec, Canada Feb 2017 - Dec 2019 | |||
Sep 2019 32240 mi |
Hood replaced for rust. Under warranty | ||
Oct 2019 32240 mi |
SYNC multimedia system replaced. |
Ford Explorer in Texas, United States Jun 2021 - Jun 2022 | |||
Sep 2021 74000 mi |
Fuel cap assembly had to be replaced. Spring and lock closing the door malfunctioned |
Ford Explorer in Arizona, United States Aug 2017 - Jan 2022 | |||
Dec 2017 3000 mi |
Roof rack rails, clips broke. |
turbocharged 280hp 2.3L I4 6-speed shiftable automatic AWD
Ford Explorer in New York, United States Apr 2017 - Jun 2018 | |||
Jun 2017 25000 mi |
sunroof rattle repaired underbody shield rattle repaired |
290-horsepower 3.5L V6 6-speed shiftable automatic FWD
Ford Explorer in Texas, United States May 2017 - Jan 2022 | |||
Jan 2022 43000 mi |
Rough shifting in low gear and burning odor. Transmission fluid low; leak from loose tap. Tap secured and fluid added. |
Ford Explorer in Michigan, United States Oct 2017 - Oct 2019 | |||
Feb 2018 9000 mi |
Power window motor driver rear passenger window |
290-horsepower 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Ontario, Canada Jul 2017 - Jun 2018 | |||
May 2018 17360 mi |
Recall for potential CO leak |
Engine not specified
Ford Explorer in Texas, United States Dec 2015 - Dec 2017 | |||
Oct 2016 10700 mi |
Replaced throttle body |
turbocharged 365hp 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Colorado, United States Jun 2016 - Oct 2020 | |||
Mar 2017 9000 mi |
One of the key fobs stopped working. Had to be reprogrammed. | ||
Aug 2020 69000 mi US $1100 |
Back breaks were completely worn out including rotors and the fronts are only 1/2 done? Seem odd to me. Tie rod and axle had play in them. Mechanic replaced some bushings and added a shim? There is a TSB out for this but I do not know what the number is. |
Ford Explorer in California, United States Mar 2016 - Mar 2017 | |||
Nov 2016 20000 mi |
Dealer replaced cowling to alleviate noise in windshield area. |
Ford Explorer in Wisconsin, United States May 2016 - Jan 2017 | |||
Jul 2016 4500 mi |
SD card fault for Navigation |
Ford Explorer in Maryland, United States Sep 2016 - Dec 2017 | |||
Oct 2016 16000 mi |
Complete Transmission rebuild. Dealer reported blown overdrive drum which was replaced. Also reprogrammed and replaced main drive valve to fix hard shifting after repair. | ||
Nov 2016 17500 mi |
airbag light came on indicating there was an issue with the system. Dealer indicated it was something to do with the rear inflatable seat belts. They replaced a sensor and it fixed the issue. | ||
Apr 2017 28000 mi |
Had a loud popping noise in the front end when going over bumps. Dealer said it was the transmission mount. That didn't fix the issue so they went over the front suspension and tightened everything up and it fixed the issue. They had no clue what specific part was loose. |
Ford Explorer in Ohio, United States Jan 2018 - Sep 2021 | |||
Mar 2018 39000 mi US $1000 |
Replace front and rear brakes were pulsing. |
Ford Explorer in California, United States Oct 2015 - Jun 2022 | |||
Sep 2017 32000 mi |
Noise in front suspension due to loose subframe bolt | ||
Jan 2019 60000 mi US $2000 |
PTU replaced | ||
Mar 2020 60000 mi US $200 |
Second PTU repair, previously replaced unit lasted exactly 13 months. Dealer initially wanted me to pay OOP ($2k), eventually Ford stepped in to cover this. |
Ford Explorer in Ohio, United States Apr 2016 - Feb 2019 | |||
Sep 2017 23000 mi |
Steering wheel was peeling |
Ford Explorer in British Columbia, Canada May 2016 - May 2017 | |||
Sep 2016 12710 mi |
parking brake lever failed, covered by warranty | ||
May 2017 | fuel economy in the city was 2x worse than advertised, almost 26L/100KM |
turbocharged 280hp 2.3L I4 6-speed shiftable automatic AWD
Ford Explorer in Alberta, Canada Feb 2017 - Jun 2022 | |||
Jun 2022 77500 mi C $55 |
Water pump leaking at shaft seal RR wheel bearing assembly Reverse shift solenoid. Problem was [repaired] under warranty at 95k, replaced and was fine up until now. Having issues again at 140k approx. Looking for part number and going to replace as it is very jarring when placed in reverse and requires increase in rpm to shift in reverse. My understanding the solenoid has a screen on it which plugs with transmission particals and need to increase pressure to flow fluid to shift. |
Ford Explorer in Ohio, United States Dec 2016 - Jun 2022 | |||
Mar 2017 14000 mi |
Gasket in sunroof loose. | ||
Aug 2017 31000 mi |
Trans Axle Seal Leaking | ||
Jul 2018 65000 mi |
Popping noise in front end and steering wheel occasionally freezes when making sharp turns. Problem NOT found and we will continue to drive until conditions worsens so they can find it. | ||
Sep 2018 72000 mi US $100 |
Replace Water Pump - beginning to leak. | ||
Aug 2020 70000 mi |
Transmission was grinding and shifting erractically. A complete rebuild was done. Complete transmission rebuild | ||
Jun 2022 138000 mi US $2000 |
AC compressor failed. |
290-horsepower 3.5L V6 6-speed shiftable automatic FWD
Ford Explorer in Oklahoma, United States Jun 2016 - Jun 2022 | |||
Sep 2017 29000 mi |
Driver's side front door molding was separating and and cracked. | ||
Dec 2017 34245 mi |
Rubber train on drivers door split | ||
Jun 2018 44000 mi |
All shocks replaced |
290-horsepower 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Minnesota, United States Nov 2015 - Jun 2022 | |||
Apr 2017 20000 mi |
Throttle control module. Dealership indicated 2016 Explorers have this problem frequently. Coincidentally a recall notice for the problem was received just a few days later. |
Ford Explorer in New York, United States Oct 2020 - Jan 2022 | |||
Jan 2021 72000 mi US $150 |
Moonroof drain was clogged, causing water leak into passenger footwell. Clog cleared by dealer. |
Ford Explorer in Iowa, United States Sep 2015 - Jul 2017 | |||
Mar 2016 15000 mi |
Heat stopped working. They found no coolant so added coolant. | ||
Apr 2016 16200 mi |
Coolant was low again. Found heater core was leaking so they replaced the heater core. | ||
Sep 2016 31000 mi |
Radiator fluid smell coming through vents. Air filter replaced. |
Ford Explorer in Michigan, United States May 2016 - Jun 2018 | |||
Oct 2016 9000 mi |
Leaky drain plug from factory. |
Ford Explorer in Pennsylvania, United States Mar 2017 - Jan 2022 | |||
Feb 2018 32000 mi |
Sunroof leaking slightly. Dealer cleaned out drainage tube |
Ford Explorer in California, United States Jan 2017 - Jul 2022 | |||
Jul 2018 49000 mi US $150 |
Battery to alternator wire had a high resistance so it was swapped out |
Engine not specified
Ford Explorer in Florida, United States Dec 2015 - Jun 2018 | |||
Jan 2017 11200 mi |
warning transmission not in park message when car was in park. Seatbelt light stayed on but not all the time Drops of oil noticed once in awhile. Started to be more frequent. Found nothing. When driving transmission seems like it needs to shift . When step on gas Rpm goes up but no response from vehicle. Tripometer not registering mpg or car using tooo much gas . 3 gallons for less than 30 miles hwy in shop now don't know. Oil still leaking previous repair they could find anything . | ||
Feb 2017 22000 mi |
Something I should wrong w thing vehicle but shop is unable to determine what . Not driving right . I attempt to accelerate the vehicle either seems to lose power or doesn’t shift to next gear . | ||
Mar 2017 22000 mi |
I reported same issue as feb . Plus other Exterior door handle driver side broke . I was attempting to make a turn from a stop I pressed gas and the vehicle didn’t hardly move . Full system check mechanic manager told me it was miss firing 2 of the 6 cylinders running on 4 cyclinders . Contacted Manufacturers ford said it was within specs . | ||
Nov 2017 30000 mi |
Acceleration problem again. Nothing was done could note replicate . | ||
Dec 2017 30000 mi |
Driver door panel warped . The panel was repaired in. November get but not correctly . They reset the panel .the panel is still warped . Service has to get approval from ford to replace full panel . Been a month haven’t heard anything . The door panel issue is a recall and will be fixed if owner reports it . Same issue as reported all year . The vehicle doesn’t excellerate properly . When attempting to pass another car I press the gas and I do not go faster . I took car in when it was happening they hooked the computer t9 it and said it did throw some codes . I asked they said it was a sub computer not talking* to main computer . Was told it was running at 16000 Rpms . Didn’t do anything to corr3ct just said the report said it had at one time through the code nothing was happening now couldn’t duplicate . Car has been in shop total of 8 times with 6 being for same issue that nothing is wrong . | ||
Jun 2018 36000 mi US $50 |
Rear seat heater wasn’t working took it in for repair in dec. Part was on back order they never called when it was in 6 months long enough to resolve back order issue . They replaced part. Work fine now I don’t need in summer . I had two tires replaced and then after I noticed a noise when backup and turning at same time . Took to service they repaired the cv I will have t9 find exact repair all under extended warranty |
turbocharged 365hp 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Ontario, Canada Oct 2014 - Apr 2019 | |||
Nov 2014 1240 mi |
wires for moon roof switch to close moon roof were crimped and not connected properly. Moon roof would not close with close switch for either tilt or slide. Dealer removed switch, uncrimped the wire, reinsytalled switch and all was fine. | ||
Jun 2016 41540 mi C $750 |
The driver's side interior door panel arm rest vinyl was splitting at the seam, The vehicle was at 70,000 kms and just out of warranty. Ford refused to cover the panel under warranty although it had clearly started to split before expiry | ||
Jun 2017 65100 mi C $1250 |
Complete front and rear brakes. | ||
Sep 2017 71300 mi C $250 |
Replace belt tensioner / pulley and belt. | ||
Feb 2018 84320 mi C $1500 |
Replace cracked oiling feed tube to inboard turbocharger. Had to drop engine cradle from vehicle. | ||
Jun 2018 85250 mi C $153 |
Repaired passenger side door panel under TSB notification for free. Paid for driver door panel seam at armreast which split to be repaired at the same time. | ||
Jul 2018 85560 mi C $535 |
Left rear wheel bearing replaced | ||
Oct 2018 94601 mi C $585 |
Right rear wheel bearing replaced |
Ford Explorer in Georgia, United States Jul 2015 - Jun 2017 | |||
Jul 2016 22800 mi |
replaced separated drivers door panal |
Ford Explorer in California, United States Aug 2014 - Jan 2018 | |||
Jan 2015 12700 mi |
There were 2 areas on roof (not seen at time of purchase) that had one large and several small dark gray spots / blobs underneath the clear coat...on a White Platinum car! | ||
Sep 2017 27000 mi |
Both Driver and Front Passenger door trim (entire inside panels) were replaced for FREE due to defect...the top "skin" was pulling away from the door interior where the window slides up / down...known defect (supposedly). Car model was < 3 years old at the time with <36,000 miles on it. |
Ford Explorer in Kentucky, United States Nov 2014 - Apr 2017 | |||
Feb 2015 4000 mi |
Plastic around fender had very minor gap. |
290-horsepower 3.5L V6 6-speed shiftable automatic FWD
Ford Explorer in Texas, United States Aug 2014 - Jan 2018 | |||
Jun 2016 22000 mi |
Passenger a-pillar trim was loose. Replaced under warranty. | ||
Apr 2017 36000 mi |
Experiencing buzzing vibration intermittently with crosswind at freeway speeds. Had loose trim piece replaced in roof above wind screen. Noise issue unresolved. Vehicle exhaust and gasoline scent present in vehicle on occasion following Ford TSB. Modifications made to venting at rear of vehicle. | ||
Jun 2017 38000 mi |
Windscreen trim parts and bracket underneath wipers | ||
Jan 2018 43000 mi US $300 |
Purge valve in fuel system was stuck ope causing check engine light. |
Ford Explorer in Texas, United States Apr 2017 - Jun 2019 | |||
Aug 2017 32000 mi |
Windows jump when opening. Know issue, motors were replaced. Drivers side is better, passenger is exactly the same. Taking it to a different dealer | ||
Nov 2017 34700 mi |
When hitting a bump on right rear wheel the car would shift to the right when hitting a bump on right rear wheel, car would shift to the right. leaking strut replaced. Loose driver A pillar trim and driver side passenger window trim replaced. Exhaust smell in cabin. TSB performed sealing the rear of the vehicle and replacing the rear air vents and reprogramming the climate control module. | ||
Mar 2018 39500 mi US $15 |
Found water in the spare tire well. the seam sealer cracked by the top of the hatch and the roof. It looks like they put bondo on er the seam sealer and painted it. the bondo dried up and cracked. the insulation under the spare and the spare tire cover both had mold so they will have to be replaced. |
Ford Explorer in Michigan, United States Mar 2015 - Feb 2016 | |||
Jun 2015 5000 mi |
Drivers Door Window Wind Noise at Highway Speeds. Still having the issue. | ||
Dec 2015 13000 mi |
Drives side window still has wind noise at highway speeds. | ||
Feb 2016 13000 mi |
Driver side window wind noise never fully fixed. |
Ford Explorer in Oklahoma, United States Nov 2014 - Jul 2018 | |||
Aug 2015 12000 mi |
Rattle noise from passenger A pillar on highway in windy conditions. Minor rattle noise from driver's side rear door. |
Ford Explorer in South Carolina, United States Mar 2016 - Jun 2018 | |||
Jun 2018 58000 mi US $220 |
OEM battery defective, leaked and corroded battery clamp |
290-horsepower 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in California, United States Dec 2014 - Jul 2018 | |||
Jan 2015 1300 mi |
Rear hatch was not aligned correctly at time of manufacture therefore there was a large gap on the left side whereas the right side sat flush when closed. Repair was completed by the body shop to re-align the hatch correctly | ||
Sep 2017 53000 mi US $300 |
New front rotors and pads | ||
Jul 2018 68000 mi US $240 |
Noisy belt tensioner replaced |
Ford Explorer in Florida, United States Oct 2015 - Oct 2015 | |||
Oct 2015 10000 mi |
Exhaust entering cabin under hard acceleration. |
Ford Explorer in United Arab Emirates Feb 2015 - Jan 2017 | |||
Apr 2015 | There was a consistent rattle in drivers side of the trunk, behind the penal. I pushed some foam behind the panel and the sound stopped The plastic cover at the bottom of the passenger and driver front doors was misaligned with the covers on the back-doors. I pushed a plastic thing under it to move it more outside. Its OK now | ||
May 2015 | Both A-Pilar covers on the outside were loose. Both covers were replaced AC stopped working while in traffic jam. The AC control system was reset | ||
Jan 2017 | Ac was not cooling. Charged gas. |
Ford Explorer in North Carolina, United States Mar 2015 - Sep 2019 | |||
May 2015 | Install missing bumper clip. |
Ford Explorer in North Carolina, United States Oct 2014 - Oct 2016 | |||
Apr 2016 23700 mi |
The coat hanger on the driver side snapped off. Ford refuses to repair under warranty. They say it's due to misuse of the hook??? This is why, even though my wife love the Explorer, I will purchase a Mercedes, BMW or Cadillac when I buy. | ||
Oct 2016 30000 mi |
Coat hanger never fixed. |
Ford Explorer in California, United States Feb 2015 - Mar 2018 | |||
Jan 2016 21700 mi |
moon roof cover would make a lot of noise when opened or closed. It took two trips to get cover repaired. Now, wind noise has become a lot worse. | ||
May 2016 15000 mi |
Excessive wind noise coming from moon roof, worse at highway speeds. |
Ford Explorer in Ohio, United States Nov 2014 - Jun 2017 | |||
Jun 2015 7000 mi |
Shifts hard thru the gears at times | ||
Apr 2017 28000 mi |
Airbag light was on. Took it in one day for diagnosis another for repair as parts needed to be ordered. It was an issue with the wiring for the inflatable rear seat belts. Replaced the wiring. No charge |
Ford Explorer in Indiana, United States Oct 2017 - Jun 2018 | |||
Jun 2018 60000 mi |
Internal window seals were bad and caused significant drag on the vertical operation of the power windows. Dealer replaced the seals and the windows operate appropriately. |
Ford Explorer in Indiana, United States Nov 2016 - Jun 2018 | |||
Mar 2017 38000 mi US $85 |
Audio System and screen went out, They did a reset and it is OK for now, but the estimate to replace the audio component is $800. |
Ford Explorer in Illinois, United States Jun 2015 - Jan 2022 | |||
Jun 2017 27000 mi |
Key fob not detected so car wont start. Problem continues. |
Ford Explorer in Ohio, United States Mar 2016 - Jun 2022 | |||
Jun 2017 34000 mi |
driver's door arm rest is splitting. Interior door panel part on order. | ||
May 2022 85000 mi US $800 |
function doors did not operate correctly. Only function available was defrost |
turbocharged 365hp 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Texas, United States Mar 2017 - Mar 2018 | |||
Jul 2017 41000 mi |
Pinion seal leak on transfer case. | ||
Feb 2018 52000 mi US $40 |
Blend door actuator on passenger side failed |
Ford Explorer in Michigan, United States Sep 2015 - Feb 2022 | |||
Apr 2018 51000 mi US $106 |
Replace right strut. |
Ford Explorer in Washington, United States Oct 2013 - Jun 2018 | |||
Jun 2015 15000 mi |
Replaced Evaporator Core due to bad switch | ||
Sep 2016 27000 mi |
Leaking Fuel Injector in #2. Replacement of Injector requires replacement of fuel line which took 8 weeks to get. | ||
Apr 2017 28600 mi |
TSB for "Transmission not in Park" warning |
Ford Explorer in Louisiana, United States Jul 2014 - Mar 2018 | |||
Jun 2016 14000 mi US $360 |
To eliminate clonking noises when the steering is turned to the right at low speed Two safety belts replaced under warranty. One was stuck and the other has to be cut off when a child got entangled in it. |
turbocharged 240hp 2.0L I4 6-speed automatic FWD
Ford Explorer in Illinois, United States Aug 2014 - Jun 2016 | |||
Dec 2015 25000 mi |
Backup camera wasn't working correctly |
Ford Explorer in Florida, United States Mar 2015 - Apr 2017 | |||
Jun 2015 35000 mi |
After extended time maintaining constant throttle at 70 mph and approaching a steep grade to go over a bridge experienced very harsh downshift. Experienced same issue when driving in mountains on vacation two weeks earlier. 2nd trip for this. | ||
Apr 2017 77000 mi |
Clicking sound in front end. Ford Dealership unable to determine cause. Told car was safe to drive. Sold car. Rubber molding on one side of sunroof fell out. Dealer repaired for free. |
290-horsepower 3.5L V6 6-speed shiftable automatic FWD
Ford Explorer in Ohio, United States Oct 2013 - Jan 2022 | |||
Nov 2014 15000 mi |
Second row passenger side bucket seat would not fold down/away using the automatic fold button. You could do it manually, but only with a lot of effort and tugging/pulling. |
Ford Explorer in California, United States Nov 2013 - Dec 2016 | |||
Jun 2015 15000 mi |
rear window trim was not seating correctly |
Ford Explorer in Virginia, United States Jun 2014 - Jan 2017 | |||
Dec 2016 38000 mi |
Water leaking from passenger side window |
Ford Explorer in California, United States Apr 2018 - Mar 2019 | |||
Jun 2018 54000 mi US $351 |
Emmisions Issue |
Ford Explorer in Indiana, United States Nov 2017 - Sep 2018 | |||
Aug 2018 74000 mi US $250 |
rear camera rear lift motor steering wheel switches |
Ford Explorer in Texas, United States Dec 2014 - Sep 2019 | |||
Mar 2015 4000 mi |
Metal support bar that holds up the front of the load floor when the power 3rd row is stowed came loose and was pointed into the passenger area. Was able to snap it back into place. | ||
Mar 2017 42000 mi |
Front passenger interior door panel started to peel and separate along the top where it meets the glass. Removed door panel and attempted to re-glue. Repair only partially successful as only the center is adhering. Airbag warning light comes on intermittently. Read code B141C which indicated issue with 2nd row inflatable seatbelts. Should be covered by TSB 16-0001. Dealer visit to be scheduled later. | ||
Aug 2017 51000 mi US $131 |
Had interior door panel that was separating professionally repaired (glued & stapled) since previous home repair attempt was not successful. | ||
Jun 2018 66227 mi US $802 |
Poor cooling especially on passenger side. Replaced low side Schrader valve, rear evaporator O-rings, and passenger side blend door actuator. System evacuated and recharged. Oil pressure sending unit found to be leaking and replaced. Left front door latch would intermittently not open fully resulting in the inability to close the door. Latch mechanism was replaced. |
Ford Explorer in Michigan, United States Aug 2013 - Sep 2015 | |||
Sep 2015 22000 mi US $600 |
Integrated Key/Key FOB physicaly broke while trying to turn in ignition. Car was still under warranty but Dealer said that Key's are not covered. Also I needed to replace a second key(lost) $600 total. |
Ford Explorer in Georgia, United States Apr 2014 - Apr 2017 | |||
Apr 2016 21000 mi |
Ba valve. Would not shift into 6th |
290-horsepower 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Delaware, United States Feb 2014 - Mar 2016 | |||
May 2014 3000 mi |
While idling in a parking lot, got "high coolant temp, low oil pressure, 4wd system failure, stability system failure" and other errors. After shutting off, vehicle would not start. After resting for 15 minutes, vehicle finally restarted. | ||
Jul 2014 4300 mi |
Problem reoccurred, drove car straight to dealer with warning lights on, did not turn it off. They found 3 pages of codes and a lack of BCM communication. Involved Ford engineering. Found and replaced a damaged pin in a harness connector. | ||
Oct 2014 6300 mi |
Got charging system error, noted bad battery by the "eye" on the battery being black. | ||
Dec 2014 8000 mi |
Belt noise was getting loud. I showed the dealer the noise when I pulled in. 2 days later, it mysteriously wasn't making the noise any more and the dealer "did nothing." It still makes the noise on really rainy days. Charging system error again. It seems if it sits for a week with no use, the parasitic drain on the battery is high and it gives this error until it has been driven to full charge. The Explorer on the show room floor had the same problem. |
Ford Explorer in New Jersey, United States Mar 2014 - Apr 2017 | |||
Oct 2014 9500 mi |
Replaced Steering rack Replaced seat rack, seat motor and cross bar support. | ||
Jul 2015 18700 mi |
paint was wearing on bottom edge of door. Repainted door. | ||
Mar 2016 30000 mi |
Replace door seal | ||
Dec 2016 41000 mi |
Paint on hood bubbling due to corrosion of the alum. | ||
Apr 2017 46000 mi |
Drive shaft seal leaking. Took 2 days because the part was not in stock. Drive shaft seal leaking. Dealer replaced seal |
Ford Explorer in Minnesota, United States Apr 2014 - Apr 2018 | |||
May 2017 46000 mi US $400 |
servo motor in heater/ac failed. Unit was replaced under extended warranty with $100 deductible. Door panel covering is curling up where door panel meets window on drivers side. Door panel was replaced. Dealer done at no charge under "customer satisfaction" |
Ford Explorer in New York, United States Aug 2013 - Apr 2018 | |||
Dec 2015 28000 mi |
Oil leak from timing chain cover. | ||
Mar 2016 31000 mi |
Rear differential was leaking fluid. Dealer replaced the vent with an updated part per a TSB. | ||
Jun 2016 35000 mi |
Transmission fluid cap is covered in fluid. Dealer reports levels are good and this is normal. | ||
Aug 2016 40000 mi |
Paint was bubbling on both rear door edges and on the rear hatch under some trim. The dealer repainted those portions of the vehicle under warranty. | ||
Jan 2017 47903 mi |
Left rear wheel bearing was making noise. Replaced under powertrain warranty. | ||
Apr 2017 52413 mi |
Airbag light was on. Dealer diagnosed and replaced both rear seatbelt wire harnesses per TSB 16-0001 | ||
Oct 2017 60456 mi US $8 |
Rear calipers we’re sticking due to corrosion pinching pad slides. Replaced slides, cleaned rust. Front calipers have no signs of corrosion at all. |
Ford Explorer in Alberta, Canada Dec 2013 - Jan 2017 | |||
Jun 2014 10540 mi |
Vibration coming through the floor |
Ford Explorer in Delaware, United States Oct 2013 - Feb 2018 | |||
Jun 2014 8000 mi |
Internal battery failure. Dealer replaced battery. | ||
Dec 2015 32000 mi |
Battery bad on service. Replaced under warranty. | ||
Nov 2016 49000 mi US $100 |
Lift gate not working. Replaced hinges, control module, lift gate motor. | ||
Jun 2017 59000 mi US $250 |
Rear brake pads replaced. | ||
Sep 2017 63201 mi US $100 |
Transfer case PTU Assembly leaking. Replaced. |
Ford Explorer in Ohio, United States Jan 2014 - Dec 2016 | |||
May 2016 32000 mi |
A-pillar trim panels replaced after becoming loose and making noise at highway speeds | ||
Dec 2016 43000 mi |
Ambient temperature sensor would sporadically read wrong replaced under extended warranty |
Ford Explorer in California, United States Jul 2014 - Aug 2014 | |||
Aug 2014 235000 mi |
Stalling at stop signs. |
Ford Explorer in Quebec, Canada Mar 2017 - Dec 2017 | |||
Aug 2017 35340 mi C $300 |
Rust in both rear doors inside.. like orange peel.. was not covered by warranty after 3 days past the end of the 3 years 60k warranty |
Ford Explorer in Pennsylvania, United States Nov 2017 - Jun 2022 | |||
May 2019 45999 mi US $49 |
Replaced purge valve (emissions system) to correct check engine light. | ||
Jun 2022 63000 mi US $330 |
Front left wheel bearing was worn (identified during state inspection in May) and had to be replaced. |
Ford Explorer in Delaware, United States Jun 2014 - Dec 2016 | |||
Mar 2015 14000 mi |
Windshield trim broke off while driving. Dealer replaced both sides even though only one side broke off. | ||
Nov 2015 22700 mi |
Bad rear wheel bearing - dealer replaced under warranty. | ||
Dec 2016 36000 mi |
Exhaust fumes were leaking into the cabin of the car. Ford proposed a $600 fix, but when I googled the problem, I found it to be widespread and apparently the $600 fix does not work. Therefore, we traded the car. |
Ford Explorer in Ontario, Canada Jun 2014 - Aug 2017 | |||
Jun 2017 44640 mi C $800 |
Rear brake pads and rotors replaced Driver's door handle replaced. Tab broken holding handle and had to continually push back into place |
Ford Explorer in Ohio, United States Oct 2016 - Jan 2022 | |||
Nov 2016 55000 mi |
Paint was chipped and bubbled at front edge of hood. Dealer sanded and repainted hood. | ||
Mar 2021 77000 mi US $300 |
Coolant hose in rear heater core leaking. Dealer wanted to replace entire rear lines from front to back for $2200. Another shop replaced leaking rubber hoses only and fixed problem. |
Ford Explorer in Texas, United States Feb 2016 - Jun 2022 | |||
Aug 2016 29000 mi |
Battery died |
Ford Explorer in Florida, United States Feb 2014 - Jun 2022 | |||
Dec 2014 8000 mi |
electronic display system glitch | ||
Nov 2016 19600 mi |
Exhaust fumes entering vehicle on hard acceleration. Fumes are now better but problem not eliminated | ||
Dec 2021 51000 mi US $1350 |
sensor malfunction engine mounts replaced. Transmission still slams into gears. Repairs shop says transmission is "fine" |
turbocharged 365hp 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Oregon, United States Apr 2013 - Dec 2013 | |||
May 2013 1000 mi |
Engine began misfiring. Dealer determined one fuel rail was defective due to manufacturing defect. | ||
Dec 2013 8000 mi |
Transmission shifting erratically. |
Ford Explorer in Virginia, United States Nov 2012 - May 2017 | |||
Dec 2015 59000 mi US $100 |
Updated APIM firmware and replaced shifter and linkage for parking shift position issue | ||
Jun 2016 66000 mi US $100 |
Experienced driveline jolts when accelerating. Dealer said the jolts were due to driveline slack at the hub. Added a shim kit due to a TSB about the problem. |
Ford Explorer in Arizona, United States Nov 2012 - Sep 2018 | |||
Aug 2016 62700 mi US $100 |
The electrical button on the shifter goes bad and will not register being in park. The shifter was replaced under my extended warranty. | ||
Sep 2018 91000 mi US $130 |
Rear air was [not] blowing cold. It was found that the A/C Compressor was leaking. Evacuated system, flushed system, replaced A/C compressor, replaced A/C condenser, refilled system. Shifter button acting up again. When putting in park, would not always read in park, causing other issues. Shifter was replaced. |
Ford Explorer in Texas, United States Feb 2013 - Jun 2018 | |||
Dec 2017 103000 mi US $2300 |
Electric steering needed steering column replaced. | ||
Mar 2018 103997 mi US $2198 |
Timing chain |
turbocharged 240hp 2.0L I4 6-speed automatic FWD
Ford Explorer in Ontario, Canada Apr 2013 - Jun 2018 | |||
Jun 2017 71300 mi C $550 |
Exhaust | ||
Jul 2017 71300 mi C $600 |
Wheel bearing |
Ford Explorer in Florida, United States May 2014 - Mar 2018 | |||
Aug 2014 19900 mi |
Dead cell battery, battery replaced |
Ford Explorer in Ontario, Canada Apr 2013 - Jul 2015 | |||
Oct 2013 14560 mi |
Air conditioning compressor failed. To be replaced, part on back order. Compressor Clutch and pulley worn out causing clutch to smoke when AC on. Evac recharge AC system. Replaced AC compressor and AC lines O-rings at the compressor. | ||
Jul 2015 22940 mi |
Gear selector sensor not reporting that the vehicle was placed in park. |
290-horsepower 3.5L V6 6-speed shiftable automatic FWD
Ford Explorer in Texas, United States Nov 2012 - Nov 2014 | |||
Feb 2014 22000 mi |
This was a recall that we had addressed - a coupler on a fuel line at the fuel tank had to be replaced due to leakage. |
Ford Explorer in Minnesota, United States Jun 2012 - Sep 2012 | |||
Sep 2012 3655 mi |
Traction Contrel System engaged while on dry pavement. I was unable to disengage TCS. Engine reving high as a result of TCR. Brought to dealer to see RCA. Results inconclusive. Dealer updated ECU and Antilock firware to latest rev. Traction Contrel System engaged while on dry pavement. I was unable to disengage TCS. Engine reving high as a result of TCR. Brought to dealer to see RCA. Results inconclusive. Dealer updated ECU and Antilock firware to latest rev. |
Ford Explorer in Florida, United States Feb 2013 - Sep 2018 | |||
Oct 2013 5200 mi |
Door ajar light on | ||
Apr 2016 22500 mi US $665 |
Moon roof stopped working 1 month after warranty expired.Replaced 1 of the motors and switch. The shade had still worked. Labor was $430. Job took less than 3 hours. | ||
Apr 2017 30000 mi |
Moonroof again stopped working, but dealer fixed at no cost because previous repair on moonroof had 2 year warranty. |
Ford Explorer in California, United States Jan 2014 - Feb 2014 | |||
Jan 2014 20000 mi |
Defect in arm, replaced Headliner rattle Seat belt not locking Clip loose in passenger door - removed and replaced Rubber door seals worn through. Noise while steering - Clock spring ordered but not yet replaced Rattle above the third row rear speaker. |
Ford Explorer in Wisconsin, United States Mar 2017 - Mar 2017 | |||
Mar 2017 33000 mi US $350 |
Tires replaced under warranty. Standard Equipment Michelin's dry rotted over the past 3 years in storage. |
Ford Explorer in California, United States Aug 2014 - Nov 2016 | |||
May 2015 59000 mi US $100 |
Rear deck did not open fully | ||
Aug 2016 69000 mi US $245 |
Replaced EVAP Purge valve |
Ford Explorer in Texas, United States Dec 2016 - Dec 2017 | |||
Sep 2017 66000 mi |
dealer broke bug deflecter-replaced |
Ford Explorer in Texas, United States Aug 2015 - Jun 2016 | |||
Sep 2015 48000 mi |
Stabilizer bar became lose and had to be replaced. Faint burning smell in car if engine exceeds 4000 RPM. Dealer are unable to find the cause. Replaced cabin filters. Problem ongoing. |
Ford Explorer in Oklahoma, United States Jun 2013 - Oct 2013 | |||
Oct 2013 38000 mi |
Vehicle was sucking exhaust into the cabin. Some places were sealed up but did not work. |
Ford Explorer in Florida, United States Aug 2015 - May 2017 | |||
Mar 2016 75000 mi US $570 |
Car wouldn't recognize when it was in Park, so it wouldn't fully shut off. Dealer replaced shifter assembly, 100% out of pocket expense. Well known problem among ford auto shifters. Really should be a recall issue, honestly. |
290-horsepower 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Rhode Island, United States Apr 2013 - Jun 2018 | |||
Jul 2013 1500 mi |
Brand new vehicle and air conditioner was't cooling the vehicle appropriately. Dealer evaluated and determined below standard. Evacuated and recharged coolant. | ||
Jun 2017 48000 mi US $160 |
Replaced rear brake rotors and pads. | ||
Jun 2018 57000 mi US $350 |
Replaced front and rear brake rotors and pads. |
Ford Explorer in Minnesota, United States Jun 2014 - Jul 2018 | |||
Aug 2015 84100 mi US $800 |
The AC compressor failed and needed to be replaced. | ||
Jun 2018 116000 mi US $1200 |
Passenger side CV and axle assembly including inner bearing. |
Ford Explorer in Arizona, United States Sep 2012 - Sep 2014 | |||
Jun 2014 30000 mi |
Buzzing behind the dash |
Ford Explorer in Ontario, Canada May 2014 - Jun 2018 | |||
Jun 2014 32240 mi |
Front and rear brakes serviced. Vehicle was making high pitched whining noise when releasing brakes. Pads determined to be sticking in 2 of 4 wheels. All brakes serviced and lubed under warranty. | ||
Sep 2014 36580 mi |
Third row seatback cracked right through. Leather separated from one third row headrest. Driver's side door panel replaced (2cm crack on leather). All covered under warranty. | ||
Jun 2015 47740 mi C $100 |
AC compressor clutch disintegrated and was nowhere to be found in engine bay. AC compressor replaced using Ford Extended Warranty. $100 is for deductible. Car had less than 75000km when this occurred. Ford not sure why part failed. | ||
Jul 2015 48360 mi |
Transfer case seal started leaking less than 2 weeks after car had its AC compressor replaced by the dealer. Covered by vehicle powertrain warranty. Cabin was filling with smoke as fluid dripped on the hot cat below the transfer case!!!!! | ||
Dec 2016 66340 mi C $150 |
Vehicle started overheating out of nowhere. After a short drive (30 minutes), even in cold December weather the temperature gauge climbed to the red zone. Had to be towed to Ford, who ended up replacing the water pump. Covered under extended Ford ESP with only deductible paid. | ||
Jun 2017 71920 mi C $40 |
P1450 code. Manually tested EVAP purge valve and noticed it was stuck open. Replaced EVAP purge valve at home. |
Ford Explorer in Alberta, Canada Mar 2013 - Jun 2014 | |||
Nov 2013 6820 mi |
HEADLIGHTS OUT OF ADJUSTMENT |
Ford Explorer in Texas, United States Sep 2012 - Jan 2013 | |||
Jan 2013 5000 mi |
replaced clip in glove box. did not fix. then said plastic on fender well rubbing. claimed to fix it. still rattles |
Ford Explorer in Arizona, United States Feb 2016 - Feb 2018 | |||
Jul 2016 53238 mi US $83 |
Replaced tensioner. 99$ Belt 33.88$ Found SERP belt tensioner making noise | ||
Jan 2017 58011 mi US $1666 |
Check engine light Code p1450 Defective purge valve Diagnosis of check engine light Labor fee for check engine light 3 part complete fuel system service |
Ford Explorer in New Jersey, United States Jun 2015 - Jun 2018 | |||
Aug 2015 42900 mi US $1800 |
Air conditioning compressor clutch seized | ||
Oct 2016 58300 mi US $160 |
Dead battery | ||
Jun 2017 72000 mi US $490 |
Wiring harness failure, caused an erroneous battery warning light. | ||
May 2018 77000 mi US $1800 |
2nd air conditioner compressor replacement required ugh!!!!’ Also required a new condenser |
Ford Explorer in New Jersey, United States Sep 2013 - Sep 2014 | |||
Sep 2014 31000 mi |
Windows wouldn't go down smooth on driver or passenger side, they would jump down |
Ford Explorer in Iowa, United States Jul 2014 - Mar 2018 | |||
Oct 2014 36500 mi |
Mirror door wasn't closing completely | ||
May 2017 80000 mi US $500 |
Shocks were making a squeaking noise when turning. |
Ford Explorer in United Arab Emirates Dec 2016 - Jun 2018 | |||
Dec 2016 41540 mi |
LH A-pillar outer trim came loose | ||
Jun 2018 55180 mi |
Battery died under warranty. Shop I bought the battery from agreed to replace free of charge. Battery was 11 months old. But after jump starting the car just to get home and had the new battery delivered and installed. Upon starting there were multiple warning related to brake and traction control system. Shop does not want to claim responsibility. I was forced to buy an OBD2 cable and FORscan in an attempt to clear the faults but as of today 15/07/2018, fault lights are still on. |
Ford Explorer in Wisconsin, United States Jan 2018 - Jun 2018 | |||
Jun 2018 97000 mi US $61 |
Replaced hub assembly with a new one because the original was grinding. Replaced spark plugs due to misfire. Also replaced intake gasket and pcv valve. Had to remove the upper intake to get to rear plugs so decided to replace the gasket and pcv valve as a preventative measure. |
Engine not specified
Ford Explorer in North Carolina, United States May 2012 - Oct 2012 | |||
Jul 2012 17700 mi |
Defective pillar mouldings Driver's power seat not sliding smoothly when going backward. |
turbocharged 240hp 2.0L I4 6-speed automatic FWD
Ford Explorer in Oklahoma, United States Mar 2014 - Apr 2014 | |||
Apr 2014 65000 mi US $300 |
Carriage bearing failed on passenger drive shaft. Replace drive shaft, seal and carriage bearing bracket. |
Ford Explorer in Alaska, United States May 2012 - Oct 2012 | |||
May 2012 7000 mi |
Check engine |
Ford Explorer in Illinois, United States May 2017 - Jun 2022 | |||
Apr 2017 53000 mi US $2200 |
Waste gate failed on the turbo. Had to replace the entire turbo assembly. Primary fuel pump failed. Had to replace the fuel pump. | ||
Jul 2021 101000 mi US $1200 |
Rear AC evaporator coil developed a leak, lost all cooling in car. Replacement cost was more labor than cost of parts. | ||
Mar 2022 104000 mi US $3000 |
Multiple issues came up. Control Arm Bushings on both sides, strut mounts on both sides. Tie rod ends. Alignment. |
290-horsepower 3.5L V6 6-speed shiftable automatic FWD
Ford Explorer in Quebec, Canada Nov 2011 - Jan 2022 | |||
Mar 2013 26040 mi C $120 |
Lost a piece of outside windshield trim. Changed windshield earlier, and pins get broken when this is done. Need to replace trim when replace windshield. | ||
Apr 2013 27240 mi C $120 |
Lost the other side windshield trim after a windshield change... Dealer said when you change your windshield, its better to change for new trim... | ||
Jun 2013 33480 mi |
driver door, stich of leather elbow support opened and you could see the foam | ||
Sep 2013 43400 mi |
Rust at bottom of driver door (inside). Dealer told us than sometime sand and dirt are stuck between inside bottom door and plastic trim... With vibration the paint his remove....So wash the inside door regularly | ||
Jun 2015 80600 mi C $50 |
They change both front shock head support Rear wheel bearing passenger side scrap | ||
Aug 2015 81840 mi C $100 |
Change front shocks passenger side ac was out of control.... fan was always changing to full speed and touch button was not working... They change all computer and Sony Radio...1200$$$ | ||
Sep 2015 84940 mi C $50 |
Lood noise, change rear wheel bearing All 4 doors where squeaking...Dealer said sand was in the rockers...We did just one trip in a sand area with the truck!! | ||
Sep 2016 99200 mi C $300 |
Park sensor not working, they change shifter | ||
Jan 2018 111600 mi C $400 |
Wheel bearing | ||
Dec 2019 124000 mi C $1000 |
Both gaz pump Cracks on top cover gaz smell | ||
Apr 2020 127100 mi C $1100 |
Alternative dead charge to Much 16 v | ||
Aug 2021 148800 mi C $700 |
Rear caliper stuck |
Ford Explorer in California, United States Nov 2011 - Dec 2011 | |||
Dec 2011 137000 mi |
I get a high and low simultanious whistle or whining sound from either the engine or transmission when I first start car. Once car warms, I still get the sounds but intermittently. Hoping its not the valve assembly on the transmission?? |
Ford Explorer in Oklahoma, United States Jul 2013 - Jun 2018 | |||
Sep 2013 34000 mi |
Leaking left rear shock was replaced |
Ford Explorer in North Carolina, United States Aug 2017 - Feb 2022 | |||
Apr 2018 86000 mi US $700 |
A.C. Compressor seized up, burned up the serpentine belt. Compressor blew a quarter sized hole in underside. Replaced compressor and recharged system. |
Ford Explorer in Louisiana, United States Jan 2012 - Aug 2018 | |||
Oct 2012 7300 mi |
Rear wiper inoperable Ford Sync System shut down. Dealer installed SOP module and replaced APIM module and program. |
Ford Explorer in Kentucky, United States Oct 2011 - Jun 2014 | |||
Dec 2011 1600 mi |
Side mirror condensation in LED Driver's - side mirror LED panel window has water/condensation inside. |
Ford Explorer in California, United States Dec 2020 - Jun 2022 | |||
Jul 2021 163116 mi US $2643 |
Replace upper & lower coolant hoses, thermostat replace right & left front strut assemblies | ||
Dec 2021 167429 mi US $1373 |
central processing unit (APIM) for central touchscreen replaced | ||
Jun 2022 171694 mi US $490 |
Driver's side seat belt buckle/pretensioner replaced |
Ford Explorer in Michigan, United States Jan 2012 - Mar 2015 | |||
May 2014 51000 mi US $350 |
Drivers side rear brake caliper froze up causing it to smoke and make noise. |
Ford Explorer in Wisconsin, United States Mar 2015 - Jul 2022 | |||
Mar 2015 76000 mi US $725 |
Needed to replace both rear calipers | ||
Mar 2016 99000 mi US $320 |
Both top front strut brackets had to be replaced. | ||
Jun 2017 150000 mi US $300 |
Rear high pressure AC corrosion & failure. Did not replace due to cost, capped real lines and run AC front only. Hard to reduce amount of refrigerant is system to compensate. | ||
Sep 2021 194000 mi |
Routine brake service |
Ford Explorer in New Jersey, United States Dec 2014 - May 2015 | |||
Mar 2015 30000 mi |
this is my 2nd replaced battery, 3 in total. |
Ford Explorer in South Carolina, United States Sep 2016 - Jan 2018 | |||
Oct 2016 86000 mi US $50 |
Caliper stuck |
Ford Explorer in North Carolina, United States Sep 2012 - Dec 2013 | |||
Sep 2013 33000 mi |
windshield wiper random wipe. Oil being sucked from valve cover to intake tube |
Ford Explorer in Dominican Republic Sep 2011 - Sep 2013 | |||
Nov 2011 1020 mi |
At 140 km/h a vibrating noise was generated by the windshield. after consulting with the dealer, he indicated that was a not frequent but known outside side frame issue. What they do is detach and reattach for a firmer fit. Took 4 hours. | ||
May 2012 3800 mi |
Back led running lights were not working. Burnt. |
290-horsepower 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Maryland, United States Sep 2014 - Dec 2016 | |||
Jun 2015 25000 mi |
This is the second time that the seat belt buckles have broken. The buckle does not break but the plastic casing around the buckle falls off making it hard for the kids to buckle themselves. Ordered a part. | ||
Dec 2015 32000 mi |
Battery died. Dealer replaced the battery under warranty. |
Ford Explorer in Texas, United States Aug 2011 - Nov 2017 | |||
May 2012 9700 mi |
Third row seat covering came loose | ||
Apr 2013 22300 mi |
Warnings displayed regarding "service advancetrac." Nothing was done as dealer could not reproduce and said there was no sign of error stored in computer. | ||
Apr 2014 35500 mi |
Replaced A pillar trim due to wind noise Fuel gauge was reading incorrect levels | ||
Jun 2017 71000 mi US $390 |
Clunking noise at slow speeds; dealer replaced failed strut bearings. |
Ford Explorer in New York, United States Aug 2011 - Jun 2015 | |||
Nov 2011 7000 mi |
Door panel keypad shorted out, causing door locks to constantly lock / unlock until battery died. | ||
Jan 2012 11000 mi |
Car would not start, error code "Ignition System Fault" on the console. Dealer said the security code in the key was throwing errors. Also said battery was throwing errors. Replaced key and battery. | ||
Mar 2012 15000 mi |
SYNC system black screen on update. Couldn't reboot. | ||
Nov 2013 50700 mi |
Battery stopped charging, had to be replaced. |
Ford Explorer in California, United States Oct 2011 - Jun 2018 | |||
Dec 2011 2000 mi |
Buzz sound in Right A pillar | ||
Feb 2012 4000 mi |
Plastic A pillars and gaskets replaced per Ford TSB | ||
Mar 2012 5000 mi |
Plastic A pillar on passenger side blew off going down the Freeway. Dealer replaced both plastic A pillars | ||
Oct 2012 12300 mi |
MyFordTouch screen quit working. Dealer ordered and replaced the APIM an loaded the latest version 3.2.2 of MFT |
Ford Explorer in Colorado, United States Dec 2012 - Jan 2017 | |||
Jan 2017 11000 mi US $700 |
Cv boot cracked Pcv valve starting to fail |
Ford Explorer in New York, United States Dec 2011 - Apr 2012 | |||
Apr 2012 4000 mi |
The A-pillar trim piece was slightly faded when I took delivery of the car, so this service was scheduled to replace it at no charge. |
Ford Explorer in Massachusetts, United States May 2022 - Jul 2022 | |||
Jul 2022 141121 mi |
Leaking passenger-side fuel pump. |
Ford Explorer in Wisconsin, United States Apr 2015 - Mar 2016 | |||
Dec 2015 50000 mi US $150 |
Touch pad for electrical locks did not function properly and was replaced. |
Ford Explorer in Ontario, Canada Feb 2012 - Jun 2022 | |||
Sep 2013 9920 mi |
replaced leaking PTU seal for driveshaft | ||
Sep 2014 17360 mi |
Replaced battery | ||
Feb 2018 49600 mi |
replace both rear upper arm bushings | ||
Jun 2022 72540 mi C $2500 |
spark plugs, pcv valve Brakes all around pads and rotors |
Ford Explorer in Indiana, United States Apr 2014 - Dec 2016 | |||
Dec 2015 67000 mi US $350 |
Rear view camera became inoperable and had to be replaced. |
Ford Explorer in British Columbia, Canada Mar 2017 - Jun 2022 | |||
May 2017 109740 mi C $2300 |
rear brakes, pads, rotors etc. Front struts and shocks. |
Ford Explorer in California, United States Mar 2013 - Jan 2016 | |||
Jul 2014 37000 mi |
Not shifting it to park occasionally. |
Ford Explorer in Michigan, United States Apr 2016 - Mar 2018 | |||
Oct 2016 76000 mi US $135 |
Right-front Wheel bearing replaced. Dealer also had to replace the front axle since there was a new part from the manufacturer that couldn't be used with the original axle. | ||
Jul 2017 92000 mi US $100 |
Two wheel bearings failing |
Ford Explorer in Massachusetts, United States Dec 2011 - Aug 2021 | |||
Jun 2017 45000 mi US $44600 |
Cracked Windshield Washer Bottle | ||
Sep 2017 46000 mi US $300 |
warped rotor |
Engine not specified
Ford Explorer in Missouri, United States Mar 2011 - Jul 2011 | |||
Apr 2011 1000 mi |
software update |
Ford Explorer in Michigan, United States Apr 2011 - May 2011 | |||
May 2011 13000 mi |
Electronic cooling fans stopped working cuasing the car to overheat when stopped. Additionally, the air conditioning stopped working directly related to the cooling system. The MYFORD SYNC system completely crashed. NAVI stopped working, phone would not stay paired, HVAC controlls would not work during system crash. System would indicate several USB connection when on 1 was plugged in. Loud wind noise in the upper right hand side of the windsheild. Wind noise is more noticalbe during windy conditions. |
Ford Explorer in Missouri, United States Aug 2012 - Sep 2012 | |||
Sep 2012 26000 mi |
car lurches upon acceleration. dealer doesn't know what causes it. |
290-horsepower 3.5L V6 6-speed shiftable automatic FWD
Ford Explorer in Florida, United States Feb 2011 - May 2018 | |||
Mar 2011 3000 mi |
Repaired trim Radio intermittently receiving signals. | ||
Dec 2011 20000 mi |
microsoft sync system has many issues and needs update that is very time consuming and not user friendly | ||
Jan 2012 22000 mi |
leak from cooling system/heater core. Had to remove dash to replace part! | ||
Oct 2012 31300 mi |
loose rear-view mirror Replaced rear view mirror | ||
Dec 2012 33000 mi US $150 |
Dead battery | ||
Aug 2013 52300 mi US $100 |
blend door actuator stripped and had to be replaced | ||
Feb 2014 60000 mi US $100 |
shifter not going into park always. needed adjustments. | ||
Feb 2015 90000 mi US $300 |
120 volt outlet repaired Backup camera replaced | ||
May 2016 111000 mi US $500 |
Replace pads and rotors | ||
Nov 2017 145000 mi US $200 |
Oil pressure sensor failed and was replaced. |
Ford Explorer in Ohio, United States Mar 2011 - May 2011 | |||
May 2011 2000 mi |
Car made screeching noise from engine right after ignition. Dealer could not replicate. |
Ford Explorer in Georgia, United States Mar 2014 - Jun 2018 | |||
Jul 2015 125500 mi US $285 |
Strut plates were replaced due to an issue where the suspension felt loose while coming to a stop and was causing the brakes to become warped. | ||
Dec 2017 190000 mi US $150 |
Exterior keypad entry was working very intermittently. Replaced the keypad panel. |
Ford Explorer in Texas, United States May 2011 - Feb 2015 | |||
Apr 2013 20000 mi |
Power folding 3rd row seat stuck. Dealer found that sound insulation was interfering with seat operation. Said it is a known problem Wind noise around a-pillar areas MyFord Touch update. | ||
Aug 2013 25000 mi |
Battery died. Replaced under warranty. MFT update passenger side power third row seat jammed. Seat is stuck halfway between folded flat and upright. Cannot move manually either. Dealer says new tracks must be installed. Parts ordered. Still waiting after 2 weeks. | ||
Sep 2013 26000 mi |
waited 4 weeks for parts. dealer finally called and said parts had arrived. installed new tracks and a latch on the power folding 3rd row seats. | ||
Jun 2014 34000 mi |
Reprogram MFT due to hanging nav system and overall poor response and performance. 3rd row power seats stuck during unfolding process. This is the 3rd time this has happened to this vehicle in 3 years. |
Ford Explorer in North Carolina, United States Apr 2012 - Sep 2012 | |||
Jun 2012 18000 mi |
Roaring noise was corrected by replacing plastic piece at bottom of windshield The computer software has an issue; when hang up from phone call using Sync system the radio comes on - even when the radio WAS NOT on prior to the phone ringing. At that point, can't turn the radio off except by voice command. |
Ford Explorer in Ohio, United States Apr 2011 - Dec 2020 | |||
Jan 2013 31000 mi |
Back hatch does not open all the way. Problem with gas shocks. | ||
Mar 2013 32000 mi |
Back hatch does not open all the way. Problem with gas shocks. Upgrade/fixes to Ford sync (dashboard controlling bluetooth phone connections, directions, climate, etc) | ||
Jun 2013 35000 mi |
2nd time to dealer to resolve this issue. Upgrade/fixes to Ford sync (dashboard controlling bluetooth phone connections, directions, climate, etc) | ||
Oct 2013 40200 mi |
Under engine air deflector failed and became detached. Appears to have been improperly reattached during oil changes. | ||
Jun 2014 53000 mi US $45 |
Ignition was stuck on Saturday; resolved by Ford Roadside assistance. Took to dealer on Monday, 7/14; unable to duplicate or find any issues. Charged for 1/2 hour labor. | ||
Dec 2017 109500 mi US $45 |
Replaced both front head lights - one was burned out. |
Ford Explorer in California, United States Oct 2011 - Mar 2012 | |||
Dec 2011 8000 mi |
Nav system fault, Ford says they should have an update by Janaury, no solution currently. Screen goes black, no access to AC/Fan/Radio/Phone/Nav | ||
Mar 2012 12000 mi |
Sync upgraded Wind noise repaired for 3rd time. |
Ford Explorer in Massachusetts, United States Feb 2015 - Sep 2020 | |||
Apr 2017 29000 mi US $1144 |
two plates in transmission were change out shifter assembly replaced |
Ford Explorer in Georgia, United States May 2017 - Jun 2017 | |||
Jun 2017 48000 mi US $310 |
Positive battery terminal (aka circuit breaker assembly) corroded. Dealer quoted battery harness cable replacement at 701.42. I refused the service and found the needed part number in an on-line Ford user forum-Ford OEM part number DA8Z-14526-A (Circuit Breaker Assembly). I ordered the part myself at a cost of 40.93. It took less than 15 minutes to replace. I informed the dealer and they were ambivalent about it. Left blower motor door clicking noise - had to have motor replaced $229.00 |
Ford Explorer in Florida, United States Aug 2011 - May 2019 | |||
Mar 2016 77000 mi US $472 |
Rear shocks | ||
Sep 2017 101000 mi US $170 |
Needed new battery |
Ford Explorer in Colorado, United States Oct 2011 - Feb 2016 | |||
Mar 2012 6000 mi |
Brakes had been squealing off and on since purchase. Finally had an opportunity to take it in to have it looked at - not sure what they did; said there were no problems or issues with brakes. Still squeals... | ||
Oct 2015 52300 mi |
Fuel gauge isn't working - I've taken it in for repairs but have had to reschedule due to heavy volume of vehicles needing work, ahead of mine. I am still waiting to get it looked at to see how much it will cost and if covered under warranty | ||
Feb 2016 54000 mi |
We did not have the fuel gauge repaired before trade-in as it was an easy fix for them (we were told), and could be an expensive one for us. |
Ford Explorer in Colorado, United States Jul 2011 - Aug 2011 | |||
Aug 2011 5000 mi |
audio for the DVD system on rear headrests does not work through thru the vehicle radio as indicated in the user guide, transmitted over a "unused" frequency which apparently is not really unused depending on the locale you are in. static. |
Ford Explorer in North Carolina, United States Jan 2015 - Feb 2017 | |||
Nov 2015 45700 mi US $300 |
Bad ignition coil replaced |
Ford Explorer in Ontario, Canada Jul 2011 - Jul 2014 | |||
Nov 2012 25940 mi |
window post applique on passenger side - rattle noise on highway | ||
Dec 2013 50220 mi |
right side A pillar molding had spider cracks, probably because installed incorrectly during earlier repair. Replaced under policy warranty with partial relief | ||
May 2014 56380 mi C $125 |
Overheated. Engine cooling fan stopped working. Replaced under extended warranty. |
Ford Explorer in New Jersey, United States Jul 2011 - Jun 2022 | |||
Oct 2011 6000 mi |
keyless entry pad replaced | ||
Jun 2013 43000 mi |
MYFordTouch | ||
Mar 2015 81000 mi US $100 |
Oil leaking - updated gasket | ||
Aug 2016 119000 mi US $219 |
Rear brakes.... Pin slide rusts and freezes.... One side worn down down....not a caliper issue and is a know explorer issue... Ford has replaced brake pad/slide design.... However refuse to accept responsibility | ||
Dec 2016 126000 mi US $100 |
Replaced actuator |
290-horsepower 3.5L V6 6-speed shiftable automatic AWD
Ford Explorer in Alabama, United States Feb 2011 - Apr 2011 | |||
Apr 2011 176000 mi |
Small coolant leak when sold. |
Ford Explorer in Michigan, United States Sep 2014 - Nov 2016 | |||
Oct 2014 108200 mi US $50 |
Replaced backup camera | ||
Dec 2014 109000 mi US $40 |
Replace auto park assist sensor that had failed in front right bumper position |
Ford Explorer in Indiana, United States Feb 2011 - Apr 2011 | |||
Apr 2011 1000 mi |
MyFordTouch had some issues. Dealer said that they needed to update the software. Problems were, cell phone would not sync, clock not keeping time. |
Ford Explorer in Pennsylvania, United States Jan 2018 - Sep 2018 | |||
Jul 2018 101000 mi US $420 |
Steering link frozen tried removing tie rods to isolate dealer replaced rack no charge then found the link frozen |
Ford Explorer in Oregon, United States Jul 2015 - Sep 2015 | |||
Sep 2015 85000 mi US $50 |
Vibration hum coming from front end, dealer could not find a problem. |
Ford Explorer in Michigan, United States Sep 2016 - Oct 2017 | |||
Oct 2016 71000 mi US $10 |
The small splash guard/wind deflector in front of the rear wheel repeatedly loosens and rattles. The piece is held in place by one screw and 2 plastic expansion plugs. The expansion plugs do not have sufficient material to remain locked in. | ||
Jun 2017 79000 mi US $40 |
Blower Door Actuator Motor replaced. Cheap plastic gear in the unit had one tooth break off of the gear. Tried super-gluing it back but that did not last. | ||
Jul 2017 79000 mi US $55 |
Vapor Canister Purge Valve was clogged/dirty. Removed and cleaned to solve the problem, at least for the short term. | ||
Aug 2017 81000 mi US $150 |
Transmission cooler bypass valve hose connection failed at the valve body. The actual threaded fitting sheared off, not a failure of the hose. Replaced bypass valve and sold the vehicle! |
Ford Explorer in Ohio, United States Mar 2011 - Jun 2011 | |||
May 2011 | ABS activated causing sudden slowdowns when taking 3-4 degree turn at 38-42 miles/hr. Replaced part BB5Z*3F818*A Sensor - Steering Rotation | ||
Jun 2011 8000 mi |
replaced passenger seat airbag wiring assembly... wires broke from moving the seat full forward |
Ford Explorer in Ontario, Canada Feb 2011 - Mar 2014 | |||
Jun 2011 2480 mi |
Active Park Assist not working. Diagnosed right front sensor faulty. Replacement part ordered. Replaced right front sensor to correct fault in Active Park Assist. | ||
Jan 2012 | Rain sensing wipers would sometimes do a random wipe when there was no reason for it. Dealer replaced the processor. | ||
Mar 2012 5580 mi |
A performance upgrade was installed for MyFord Touch (MFT). Many owners experienced various problems with MFT and Ford redesigned and worked on the software package. New navigation card was also installed. | ||
Nov 2012 7020 mi |
MyFord Touch software update and installation of a new A4 SD card for the navigation. | ||
Mar 2013 8060 mi |
Over the past few months I had to trickle charge the battery several times since it was low. Never failed to start the car. Battery was tested when I went for season tire change and the result was that the battery was replaced. | ||
Apr 2013 8160 mi |
Rain sensing wipers would periodically wipe for no reason. Dealer replaced control module. This was the second time it was replaced. |
Ford Explorer in Rhode Island, United States Jan 2012 - Jan 2017 | |||
Jan 2014 27300 mi |
Rear liftgate would not go all the way up | ||
Jan 2016 46486 mi |
There are times when the heat on the driver's side does not work, usually after the HVAC controls have been adjusted. Could not duplicate the problem so not fixed. Had car in in May for the same issue and they could not find a problem. Could not duplicate the problem so not fixed. Had car in in May for the same issue and they could not find a problem. | ||
Dec 2016 52000 mi US $100 |
Replaced both blend door actuators. Had taken vehicle in 3X before for heat issues but "could not replicate" so no repair. Found TSB this time. Only $100 because under extended warranty. Oil leak in front cover. Replaced gasket. |
Ford Explorer in Utah, United States Dec 2013 - Apr 2014 | |||
Dec 2013 25000 mi |
Axle replacement and CV joints replaced Cooling fan replaced |
Ford Explorer in Pennsylvania, United States Jun 2014 - Jun 2014 | |||
Jun 2014 115000 mi US $100 |
After a heavy rain, My roof will leak in several spots on the inside. |
Ford Explorer in Texas, United States Jun 2015 - Oct 2017 | |||
Sep 2015 69000 mi |
Power Steering went out and all terain light came on. They did "adjustments". Got car back next day & it happened again! Returned car & they replaced steering geer unit. | ||
Aug 2016 91000 mi US $450 |
Drive arm wore out causing strut to break into pieces. Replaced drive arm and one strut (front end) | ||
Feb 2017 116000 mi US $40 |
Severe water leak from all 6 main posts and also coming out of overhead console lights. We sealed all main seals on roof as well as sealed all around the roof rack rails with silicone. That fixed SOME of it but 2 weeks later we had to completely seal the sunroof shut! But now we havent had a single leak since. | ||
Oct 2017 121000 mi US $250 |
Low oil pressure light kept coming on in an Erratic manner. The throttle body was replaced because it was clogged with metal dust build up. |
Ford Explorer in Maryland, United States Dec 2011 - Aug 2019 | |||
Jan 2013 54000 mi |
Clunk when accelerating from a partial stop. Hesitation when shifting. Dealer rebuilt valve body. Navigation System randomly shuts down | ||
Feb 2013 55500 mi |
1-2 shift clunked when accelerating from around 20mph (like leaving a toll booth). Dealer re-flashed ECM, said it didn't take the first time. | ||
Jul 2015 120800 mi US $300 |
Rear calipers frozen. Replaced both rear calipers. | ||
Jan 2017 115000 mi |
Found that the body seam cracked. Carpet is soaked, temporarily sealed with RTV. Will facilitate a more permanent repair as soon as time permits. The crack is in the top corner near the hatch..not easy to spot for those looking. | ||
May 2017 170000 mi |
The water leak returned, and the seam sealer in the rear was still closed up from my previous repair. This time, I was actually able to catch the leak while it was happening, which made identifying the cause much easier. The behavior of this leak was a little different than last time, and the fix was easier. The latest leak was due to a clogged valve on the driver front sunroof drain. Some sand/dirt had gotten up above the wheel liner, and plugged the check valve, preventing the trey around the sunroof from draining completely. Unlike the previous leak, this one manifested by flowing down the drivers side A-pillar and onto the floor. The fix was very simple. Just cut the wheel hard to the right (for a drivers side repair), remove the fender liner push pins, pull the liner back about 6", reach up and run your finger across the check valve to clear it of debris. Ours was undoubtedly due to years of driving on the 4x4 beach at the Outer Banks N.C, and will now be something I check as part of my routine maintenance when we get back from that trip. | ||
Aug 2017 177000 mi US $500 |
Replaced the shocks/struts and mounts. They were worn out. They weren't wearing the tires or anything, but it didn't ride like it used too. | ||
May 2018 194000 mi US $400 |
Replaced both front Lower Control arms, as the rear bushings were shot. | ||
Jun 2018 196000 mi US $300 |
Primary O2 sensors failed. Replaced both upstream O2's and spark plugs while it was apart. |
Ford Explorer in Oregon, United States Mar 2013 - Jun 2017 | |||
Apr 2014 14200 mi |
TSB recall | ||
Oct 2014 17300 mi |
front wiper stops working. | ||
Sep 2015 25000 mi US $130 |
high water temp warning light on. | ||
May 2016 32000 mi US $700 |
cooling fan not working |
Ford Explorer in Ontario, Canada Apr 2013 - Mar 2014 | |||
Apr 2013 8060 mi |
Windshield wipers would wipe on occasion by themselves. Replaced the processor as per TSB. This was done for the second time and still did not completely address the issue. Suspect intermittent problem in the wiper control stalk. | ||
Mar 2014 10540 mi |
As reported earlier, a TSB for the Randon/Uncommanded windshield wipe was done but the issue reappeared shortly thereafter. Suspect a problem with the windshield wiper control stalk since other Explorers have had them replaced as well. |
Ford Explorer in Ohio, United States May 2014 - Oct 2015 | |||
Dec 2014 70000 mi US $100 |
Shifter assembly repaired to fix occasional false reports where the vehicle did not realize it was in park. |
Ford Explorer in North Carolina, United States Jan 2015 - Mar 2018 | |||
May 2017 101000 mi US $100 |
Replaced trim panels on either side of windshield when the driver's side trim piece blew off. New panels snapped into place after pulling off old pieces. | ||
Sep 2017 102000 mi US $170 |
Driver's side exterior a-pillar cover came off on a road trip. Second time this has been replaced. This time I replaced the upper and lower pieces together. Feels more solid this time. Common problem with this model from what I read. Got parts off ebay for $170 total. |
Ford Explorer in Colorado, United States Mar 2013 - Jun 2013 | |||
Apr 2013 29800 mi |
The BLIS system reports frequently that it isn't working and I need to take to the dealer. The dealer won't look at it unless it happens while in their possession and its not a daily occur. Turn car off then on and it resets. Ugh!! |
Ford Explorer in Maryland, United States Apr 2011 - Jun 2013 | |||
Aug 2011 3000 mi |
Water present in the right mirror turn signal indicator light. The exterior trim piece on the A-Pillar was buzzing at high speed. Attempted to pickup vehicle three times in 4 days but immediately returned with the problem. A rental was provided. | ||
Mar 2012 15000 mi |
A trim piece on the outside of the A-pillar was buzzing at speed. A new redesigned trim piece has been made available to fix the problem. | ||
Jun 2012 20000 mi |
TSB with electrical connector on fan. This repair was during a routine oil change. |
Ford Explorer in Minnesota, United States Apr 2011 - Jul 2011 | |||
May 2011 | MFT (My ford Touch) multiple reflashs. Still very buggy but getting better. Reflashs done in May and in July. Windshield noise, dealer unable to verify. |
Ford Explorer in Indiana, United States May 2011 - Jan 2018 | |||
Aug 2011 2000 mi |
both LED's on side view mirrors replaced due to condensation build up in them | ||
Sep 2011 2000 mi |
replaced a module in the sync system preventing pretty much everything from working, also replaced the side mirrors again for condensation in the led lights | ||
Nov 2011 3000 mi |
both side mirror replaced again due to moisture in the side indicator led's built into the mirrors. Performed tsb on the a-pillars for the rattling noise. tsb resolved the noise. | ||
Jan 2012 | A-pillars making whistling noise since last repair. A-pillars removed and more sealant added. Seems to have fixed it. I found out Ford has redesigned the windshield trim but no one can get it since its on national back order. | ||
Apr 2012 5200 mi |
Side mirror led on passenger side filled with water again. Mirror replaced again, for the third time. | ||
Dec 2012 10000 mi |
A-pillar trim making noise again. Replaced with revised parts--Ford TSB. New designed parts are supposed to fix the problem--so far so good. | ||
Jan 2013 10000 mi |
Exterior black trim piece on the inside top edge of the tailgate came loose at one end. Piece was double sticky taped back in place (that is how it was originally installed--no fasteners). | ||
Jun 2013 12000 mi |
A-pillar trim fastening tab broken somehow. Trim replaced. | ||
May 2014 21000 mi |
Front sway bar link bushings making noise--clunking over bumps at slow speed. Dealer replaced both sway arm links. | ||
Jun 2015 33000 mi US $100 |
Right rear wheel bearing replaced--making noise Left rear caliper seized--pads wearing quickly, rotor overheating. Caliper replaced. Right caliper inspected and was fine. Pads replaced on both rear wheels. Left rotor replaced, right machined. | ||
Jun 2017 45000 mi US $150 |
Seals on rear AC lines failed. Lines had to be replaced. In order to do so dealer had to remove rear subframe. Extended warranty paid for repair--just had to pay deductible. | ||
Aug 2017 48000 mi US $100 |
Clutch on AC compressor failed, compressor replaced under extended warranty | ||
Nov 2017 48000 mi US $150 |
Serpentine belt replaced, was squealing and slipping in wet conditions |
Ford Explorer in Florida, United States Nov 2011 - Dec 2017 | |||
Feb 2012 13000 mi |
Condensation on mirror indicator lights. | ||
Apr 2012 15800 mi |
Performance Update for Sync required visit to Dealer for most 2011 Explorers. Left turn signal lamp condensation. | ||
Feb 2013 27100 mi |
Master headrest DVD player (driver side) was resetting randomly and having issues with "Surround Around" (FM Modulation). Wiring Harness under the driver seat was loose causing intermittent failure. Repaired by dealer. | ||
Dec 2013 36000 mi |
Driver side in-headrest DVD player failed to play DVD or sync with second screen. Sunroof has leaked twice; water dripping from map lights in front of sunroof. | ||
Nov 2015 58300 mi |
Sirius XM module needed to be replaced - audio would work, but data would not load (ie, traffic data, weather, etc). | ||
Mar 2016 59000 mi |
Exhaust fumes present in vehicle after aggressive acceleration. Smell especially noticeable after highway merging. Told even though this was a TSB that this item was related to body panels. $900 quote for repair (Extended wrnty not covered) | ||
May 2016 60100 mi |
Exhaust fumes present in vehicle after aggressive acceleration. Smell especially noticeable after highway merging. Ford covered all but $100 with OoW assistance. | ||
Sep 2016 63000 mi |
Exhaust in cabin (second trip). |
290-horsepower 3.5L V6 6-speed automatic FWD
Ford Explorer in Texas, United States May 2011 - Dec 2014 | |||
Sep 2014 49000 mi US $250 |
Shifter will not always go into park |
290-horsepower 3.5L V6 6-speed automatic AWD
Ford Explorer in Colorado, United States Feb 2011 - Jan 2012 | |||
Jul 2011 7800 mi |
sync system voice recognition does not work very well |
292-horsepower 4.6L V8 6-speed automatic RWD
Ford Explorer in Texas, United States - Jul 2013 | |||
Jul 2013 60000 mi |
Another typical Ford 4.xL-Series Engine failure - "a blown cylinder" -- Dealership in McKinney/Allen, TX said it was fine less than a year ago. Died today. Dealership saying "it's not a warrantied item. Filing complaints with Ford, BBB, et |
292-horsepower 4.6L V8 6-speed automatic 4WD w/low range
Ford Explorer in Connecticut, United States Aug 2015 - Dec 2016 | |||
Sep 2015 72000 mi |
Wheel bearing replacement...second one. Other done before picking up vehicle from dealer | ||
Oct 2015 72300 mi |
Front differential replaced...pinion bearings went. | ||
Nov 2016 83600 mi US $275 |
Passenger front drive axle seal leak |
Ford Explorer in Ohio, United States Mar 2018 - Jun 2018 | |||
Apr 2018 102420 mi |
Instrument panel light bulbs replaced. | ||
May 2018 103000 mi US $52 |
Drivers side master power window switch auto down feature inoperable. Replaced drivers side master window control switches |
Ford Explorer in Connecticut, United States Mar 2015 - Jun 2018 | |||
Sep 2015 77000 mi US $600 |
Driver side strut and wheel bearing assembly | ||
May 2018 128000 mi US $250 |
Oil seal replaced |
210-horsepower 4.0L V6 5-speed automatic RWD
Ford Explorer in Tennessee, United States - Mar 2011 | |||
Mar 2011 30 mi |
Rollover Stability Control activates and makes annoying noises announcing it needs immediate service. Dealer checked system and pinged the module and said they found no problem. this did not stop the RSC from continuing to go off. |
Ford Explorer in South Carolina, United States Sep 2017 - Sep 2017 | |||
Sep 2017 97000 mi US $1000 |
One front wheel bearing was replaced Thermostat housing cracked, coolant was leaking. Thermostat housing and thermostat were replaced. |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in Illinois, United States Mar 2015 - Jun 2016 | |||
Jul 2015 68500 mi US $250 |
Leaking front left caliper. Part replaced and required brake fluid exchange. Worn serpentine belt | ||
Apr 2016 77300 mi |
Fuel Filler neck replacement |
Ford Explorer in Massachusetts, United States - Jul 2013 | |||
Jul 2013 112211 mi US $340 |
Right front wheel bearing failed and seized with little warning. Just a slight vibration for about 50 miles prior to it failing. |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in Utah, United States Dec 2016 - Jan 2022 | |||
Jan 2016 80000 mi US $1300 |
computer failed completely left stranded | ||
Jan 2017 100000 mi US $400 |
radiator blew up | ||
Feb 2018 119000 mi |
computer had to replaced again 4wd didnt work | ||
Jun 2018 122000 mi US $250 |
front cv axle replaced |
292-horsepower 4.6L V8 6-speed automatic AWD
Ford Explorer in Pennsylvania, United States Jul 2010 - Sep 2015 | |||
Dec 2010 32000 mi |
broken hinge on drivers side vanity mirror. | ||
Aug 2011 36700 mi US $150 |
Ignition Switch was bad causing the interior lights to stay on/come on. | ||
Nov 2011 39000 mi |
drivers side exhaust manifold studs broken (2). loud ticking/putt putt sound during cold start | ||
Jun 2012 43000 mi US $495 |
replaced right front wheel bearings/hub right front wheel bearings/hub replaced |
Ford Explorer in Ontario, Canada May 2009 - Mar 2010 | |||
Jun 2009 64480 mi C $230 |
Air conditioning was recharged. |
Ford Explorer in Michigan, United States Jul 2011 - Jun 2018 | |||
Sep 2011 28000 mi US $227 |
Vanity mirror hinged covers on both sun visors broke which caused the vanity mirror lights to stay on. | ||
Oct 2013 45300 mi US $397 |
Dealer notified us during maintenance visit that tie rod ends needed to be repaired. They replaced both but only one was worn because the boot was torn. | ||
Mar 2014 49000 mi US $509 |
Excessive noise coming from front of engine. 2 idler pulleys were replaced. Bearings worn. Ignition key cylinder replaced. Key was very loose and memory seat did not always move into position when key was put in. | ||
Apr 2014 49200 mi US $462 |
Rear windshield wiper stopped working. | ||
Jul 2017 70700 mi US $320 |
Rear wheel bearing making a loud noise at highway speeds. |
Ford Explorer in Ohio, United States Mar 2014 - Dec 2015 | |||
Feb 2015 115700 mi US $250 |
Map light and interior lights did not work, Repair was not completed - not economical to fix | ||
Dec 2015 122000 mi |
Interior lights never fixed. |
292-horsepower 4.6L V8 6-speed automatic 4WD w/low range
Ford Explorer in Wisconsin, United States Jul 2010 - Nov 2012 | |||
Dec 2010 34000 mi |
The rims on the car were corroding. 4 new rims and sensor bands were ordered and installed on the next visit. | ||
Dec 2011 45000 mi US $150 |
Moaning from front end, both front wheel bearings needed to be replaced. | ||
Jun 2012 48000 mi |
Front Driver axle seal was leaking. The dealer replaced the seal. | ||
Jul 2012 48300 mi |
Ticking sound from right side of engine. The Exhaust manifold was replaced and 3 broken exhaust manifold studs had to be extracted and replaced. |
Ford Explorer in Illinois, United States Sep 2013 - Mar 2018 | |||
Dec 2013 97000 mi US $120 |
Passenger was blowing cold air instead of heat. Blender actuator on that side was replaced in 30 minutes. | ||
Apr 2017 124000 mi US $670 |
Car would lurch/buck at highway speed. Analysis scope revealed problem with #1&7 spark plugs. They installed all new plugs and problem got worse. Replaced all the coils and problem was fixed. |
210-horsepower 4.0L V6 5-speed automatic RWD
Ford Explorer in Florida, United States Aug 2011 - Sep 2011 | |||
Sep 2011 35000 mi |
Ignition switch had to be replaced. Vehicle has automatic seat reverse when key turned off. This started happening when going over a bump in the road. very dangerous. Ignition switch had to be replaced. Vehicle has automatic seat reverse when key turned off. This started happening when going over a bump in the road. very dangerous. |
Ford Explorer in Oklahoma, United States May 2013 - Apr 2017 | |||
Jun 2013 80000 mi US $1844 |
Transmission started to get a pronounced bang when shifting into reverse. It had a hesitation also when shifting into reverse. Total rebuild job. All parts that were worn out replaced. Found out it was due to design flaws from factory. | ||
Jul 2013 80700 mi US $600 |
Front left bearing wore out, replaced brake pads, rotors resurfaced. Replaced both front bearings. Also, thermostat housing O ring wore out, replaced entire assembly. I will not buy another American brand of vehicle! | ||
Dec 2015 107000 mi US $358 |
Had to have solenoid pack replaced (again), after rebuild job 2 years ago. Water from ac condensation dripping down on wire terminal caused corrosion to short wires thus sending wrong signal to tranny telling it to shift when not suppose to. |
Ford Explorer in South Carolina, United States Aug 2011 - Sep 2011 | |||
Sep 2011 48000 mi US $582 |
Replaced ignition cylinder 3 times in 1 year because key would not turn. Repair shop (Ford dealer) was advised that if this is a recurring problem the lock housing should be replaced. They replaced the lock housing. |
210-horsepower 4.0L V6 5-speed automatic AWD
Ford Explorer in Michigan, United States Jun 2011 - Aug 2014 | |||
Aug 2012 41200 mi US $159 |
Leaking front axle seal. Replaced seal at local transmission shop. Topped off fluid. | ||
Jan 2013 39800 mi US $99 |
found front cover leaking, remove cover, reseal with RTV and re-check for leak and refill differential. |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in New Jersey, United States - Nov 2009 | |||
Jun 2009 8000 mi |
TSB for rear brake rattle, dealer replaced rear brakes | ||
Nov 2009 13000 mi |
Water leak in rear of truck, repair crack in body seam. Water leak behind third brake light, replace third brake light. |
Ford Explorer in Virginia, United States Jun 2017 - Jan 2022 | |||
Oct 2017 50000 mi US $300 |
Transmission Flush, filter replacement, and oil change. | ||
Jan 2022 70000 mi US $950 |
Both wheel bearings needed replacement. |
Ford Explorer in Iraq Nov 2010 - Jun 2011 | |||
Jan 2010 8990 mi $25 |
The (Service RSC Now)warning came back again, the dealership checked it and this time they said its the YAW sensor, they ordered it; they told me this is covered by the warranty. i supposed to get it in 2 weeks(2 weeks ago) | ||
Dec 2010 15500 mi $105 |
The vehicle was losing power, transmission was changing was rough. transmission was reprogrammed, fuel filter and spark plugs were replaced. |
Ford Explorer in Wisconsin, United States Dec 2014 - Jan 2015 | |||
Jan 2015 US $1200 |
wheel hubs with sensors brakes pads and calipers |
Ford Explorer in Ontario, Canada Jul 2009 - Jun 2018 | |||
Mar 2009 17050 mi |
Driver side power running board faulty, would not retract. Error message on display saying "Driver door ajar". Door switch replaced under warranty. | ||
Nov 2010 32240 mi |
Power Runnung board stopped working when door opened and closed. | ||
Nov 2013 58560 mi |
Front wheel bearing noise, due to premature wear. | ||
Sep 2015 86800 mi C $1000 |
Not sure of exact part. | ||
Feb 2016 94060 mi C $800 |
Heater core malfunction | ||
Jun 2017 118420 mi C $300 |
Replaced defective auto running boards with universal steps |
Ford Explorer in Maryland, United States Sep 2012 - Sep 2013 | |||
Sep 2013 65000 mi |
Issue with Sirius working within steering wheel (had been checked 2x previously; finally ordered a new part and repaired the problem. No further issues. |
Ford Explorer in New Jersey, United States Jul 2014 - Oct 2016 | |||
Aug 2014 109500 mi US $1500 |
The pcm was bad and needed to be replaced. It a few month to get this part. | ||
Sep 2014 111000 mi US $685 |
Noise in driver front wheel bearing. Dealer said that it could driven for anther month or so. Had the repair done that day anyway. |
Ford Explorer in Kentucky, United States Aug 2010 - Nov 2011 | |||
Aug 2011 88300 mi US $620 |
Both Front Wheel Bearing Hubs replaced. |
Ford Explorer in Pennsylvania, United States Oct 2012 - Jan 2015 | |||
Sep 2013 55000 mi |
Gas filler replacement! | ||
Oct 2014 72000 mi US $245 |
replaced left front wheel bearing |
Ford Explorer in New York, United States Sep 2013 - Dec 2015 | |||
Oct 2013 44000 mi US $108 |
Front Passenger Wheel Bearing | ||
Dec 2015 89000 mi US $50 |
Blend damper modulator on heating and cooling system |
Ford Explorer in Massachusetts, United States Jan 2013 - Dec 2014 | |||
Mar 2013 60000 mi |
Left front bearing was noisy. Replaced by dealer under 30 day guarantee. U Joint was noisy as well. Rear park assist sensors were intermittent. Dealer replaced wiring harness. Parts ordered during earlier repair trip. |
Ford Explorer in Pennsylvania, United States Jan 2013 - Feb 2018 | |||
Dec 2014 54000 mi US $100 |
The front differential began to make noise. A bad bearing from the factory that just showed up. There was grease in the pumpkin. Grease changed, additives added, noise the same. Ultimately will have to change out the bearing or swap out end. | ||
Jan 2015 US $75 |
Replace trans filter, change oil transfer case and trans.Repair made difficult by Fords none transmission filler on this model. it is very heard to get the fluid in correctly, the special adapter costs $20 at Advanced Auto. What a pain!!!!!! | ||
Mar 2015 55000 mi US $450 |
A factory bearing in the front pumpkin whining/growling. Inspection revealed bearing wear, however the pumpkin was full of grease. Replaced pumpkin with one front the junk yard, changed grease etc. not at all happy with Ford..cheap bearings | ||
Aug 2016 63100 mi US $180 |
Replace four rotors, all brakes, and two calipers. | ||
Aug 2017 72000 mi US $40 |
Replaced the selection motor for interior heating, cooling , fan | ||
Sep 2017 72000 mi US $59 |
Blend door repair. would have been nice if Advanced Auto sold me the right part. The right part number even though I have heat and air to the 3rd row is Dorman 604-209. Don't let then sell you Dorman 604-213 it won't work...there is only one blend door which at the base of the drivers side dash. |
Ford Explorer in Tennessee, United States Dec 2020 - Jul 2022 | |||
Jul 2022 130000 mi US $100 |
Replaced plastic thermostat housing with metal one. |
Ford Explorer in Connecticut, United States Jan 2012 - Feb 2012 | |||
Feb 2012 59000 mi |
Was told the head gasket is blown. They are currently replacing it. |
Ford Explorer in California, United States Sep 2013 - Jan 2014 | |||
Sep 2013 74000 mi US $500 |
had to replace the transmission |
Ford Explorer in Ohio, United States Jun 2013 - Jul 2014 | |||
Feb 2013 97000 mi US $125 |
Front Wheel Bearing | ||
Jun 2014 109000 mi |
Had Tires rotated and oil change then 10 days later wheel fell off due to shop error. |
Ford Explorer in North Carolina, United States Oct 2013 - Mar 2015 | |||
Aug 2014 137900 mi US $550 |
Radio did not switch off when keys were removed from the ignition thus discharging the battery. |
Engine not specified
Ford Explorer in United Arab Emirates Apr 2013 - Apr 2014 | |||
Dec 2013 34100 mi |
Break pads, gear shifter assembly. Engine wiring harness replaced. Suspension bushings/links/arms bars and wheel alignment done. 65k service done. Cost around 7000 AED (UAE dhirams). |
Ford Explorer in Vermont, United States Sep 2010 - Jun 2011 | |||
Oct 2010 50000 mi |
lug nuts loose, studs broken off. dealer caused issue |
292-horsepower 4.6L V8 6-speed automatic RWD
Ford Explorer in California, United States Feb 2012 - Feb 2013 | |||
Mar 2012 85000 mi US $2900 |
Catalytic converter went bad because the Air Sensor went bad. They have had my car for 2 weeks, now they tell me the part is back ordered and will not be shipped for another week. |
Ford Explorer in Missouri, United States Sep 2015 - Sep 2016 | |||
Sep 2016 142000 mi US $184 |
Bad plug |
Ford Explorer in Oregon, United States Feb 2008 - Mar 2010 | |||
Mar 2008 70000 mi US $3000 |
Third gear clusters out on 5-speed automatic transmission. Common occurance on 2002 Explorers with this particulr transmission. |
Ford Explorer in Tennessee, United States Jun 2014 - Jul 2015 | |||
Jun 2014 125000 mi US $2500 |
transmission not going into overdrive | ||
Jun 2015 150000 mi US $60 |
power running board not working | ||
Jul 2015 150000 mi US $330 |
seats worn and cracked. |
292-horsepower 4.6L V8 6-speed automatic 4WD w/low range
Ford Explorer in Maryland, United States Jan 2012 - Oct 2012 | |||
Feb 2012 73700 mi US $15 |
computer said door ajar when no door was ajar | ||
Mar 2012 74000 mi |
high speed miss that comes and goes. repair shop said coil on plug issue but cannot tell which one because no warning light said to wait until part fails completely which should turn on warning light. |
Ford Explorer in New York, United States Aug 2014 - Dec 2015 | |||
Oct 2014 111700 mi US $1139 |
Transmission lines rusted out and needed to be replaced. At the same time, replaced rear radiator, which had been damaged for years. | ||
Sep 2015 118000 mi US $675 |
Electronics failure led to car unable to shift (stuck in 3rd). Dealer quoted $3,700 to replace transmission. Took car to transmission repair shop where they replaced solenoid assembly for $675. | ||
Dec 2015 118000 mi |
Head gasket failed, causing coolant to leak into engine |
Ford Explorer in Ontario, Canada Jun 2011 - May 2013 | |||
Jun 2012 63860 mi C $206 |
Rear wiper motor | ||
Dec 2012 68820 mi C $560 |
Full tune up |
Ford Explorer in Minnesota, United States Sep 2012 - Oct 2021 | |||
Apr 2014 94700 mi US $400 |
Drivers front wheel bearing was growling. Replaced and the problem was fixed. | ||
Aug 2014 98300 mi US $300 |
Radiator leaking at seam between plastic tank and aluminum, top drivers side. Replaced radiator and refilled with G-05 coolant. | ||
Jan 2015 93000 mi US $500 |
Bulkhead connector sleeve started leaking. To replace required dropping the transmission pan, so while in the transmission a filter replacement and fluid exchange was also done. | ||
Mar 2015 103000 mi US $500 |
Drivers wheel bearing had play in it and was making a roaring sound and was replaced. | ||
Aug 2015 108000 mi |
Y-Pipe on heater hose split to rear heating unit has a slow leak. Coolant was not visible on ground, but could be smelled and left residue. Replaced with part from Ford that cost $240 from the dealership due to hose deterioration. Multiple Roaring sounds. Replaced both Front Wheel Bearings. Drivers Rear Wheel Bearing failed. Replaced for free under parts and labor warranty. | ||
Oct 2015 109300 mi US $75 |
Drivers rear ABS Sensor electrical connector broke causing intermittent issues with ABS/Traction Control. Replaced Sensor. Likely broken with Rear Wheel Bearing Replacement, but cannot prove. | ||
Dec 2015 111000 mi US $360 |
Drivers Rear Strut leaking oil badly. Replaced both sides with Quick Strut replacements plus an alignment. | ||
Mar 2016 113000 mi US $45 |
Coil Pack Cylinder #1 Failing causing misfires. Replaced. | ||
Jul 2016 115500 mi US $2000 |
2 broken studs on both exhaust manifolds and warped manifolds. Studs, manifolds, and gaskets replaced. lower slide pins on both front calipers frozen. Was able to remove one, but the other was stuck and resulted in replacing drivers front caliper bracket. Also replaced pads and rotors at same time. | ||
Sep 2016 118000 mi US $20 |
Dash bulbs burned out and needed replacement. Bulbs are Ford parts only... | ||
Mar 2017 124000 mi US $32 |
Drivers Sway Bar Link broke. Replaced both sides. | ||
Oct 2017 128000 mi US $42 |
HVAC Solenoid replaced at drivers feet side. Got rid of annoying clicking sound. |
Ford Explorer in Ohio, United States Apr 2009 - Jun 2014 | |||
May 2009 37000 mi US $50 |
power running board frozen and motor burned up | ||
Apr 2010 46000 mi US $200 |
rear wiper motor replaced | ||
Jul 2012 64200 mi US $50 |
Bad alternator, producing intermittent charging problem. Have to wait till Aug 1 to receive a replacement alternator..apparent shortage of cores | ||
Sep 2012 65000 mi |
Replace sway bar link and set of tires. | ||
Dec 2012 70000 mi US $53 |
Ac hose | ||
Mar 2013 76000 mi |
Replace alternator that was replaced 9 mths ago, still under warranty |
Ford Explorer in Ohio, United States Dec 2013 - Oct 2017 | |||
Mar 2014 117000 mi US $700 |
Original right front wheel bearing worn out at 115,000 miles, replaced both front wheel bearings as other could go at anytime. This 2007 Explorer has been virtually trouble free and just a great reliable vehicle. | ||
Dec 2015 134000 mi US $800 |
replaced front differential |
Ford Explorer in Virginia, United States Jun 2013 - Jun 2014 | |||
Jul 2013 36000 mi US $5000 |
transmission grenaded, needed to be fully reworked |
Ford Explorer in Florida, United States Nov 2010 - May 2011 | |||
Jan 2011 140300 mi US $750 |
lower and upper intakes needed replacing | ||
Apr 2011 141000 mi US $150 |
belt tensioner and belt needed replacement |
Ford Explorer in Ohio, United States Dec 2011 - Jun 2018 | |||
Jan 2012 77000 mi US $358 |
5 bad ignition coils out of 8. I replaced all 8. | ||
May 2012 83200 mi US $200 |
Both front wheel hub bearings were bad. I purchased the parts online and installed them myself. | ||
Jul 2012 85700 mi US $81 |
Both lower front ball joints were worn, loose and needed replaced. | ||
Sep 2012 89000 mi US $30 |
Sway bar link on the front drivers side broke. Bought ford replacement part online for $30 & replaced it myself. | ||
Dec 2012 94000 mi US $109 |
Plastic multi line connector in the heating cooling line, was cracked and not replaceable. If repaired at the dealer, the part cost $186 + labor to install. Took it to a repair shop and they cut the hoses, removed the cracked part, replace | ||
Dec 2013 115000 mi US $98 |
Passenger lighted mirror broke. Had to replace the entire visor. Purchased part from fordparts.com and saved 40.00. | ||
Aug 2014 131000 mi US $100 |
Driverside rear door lock actuator and rear hatch lock actuator were bad and needed replaced. Bought parts at fordparts.com for half the cost at the dealer for the same part. Delivered to my ford dealer at no cost. Easy repairs to do. | ||
Jun 2015 142000 mi US $225 |
Passenger side power running board not working. Replaced entire running board assembly with one from a junkyard for $225, instead of paying $1700+tax for a new one at the dealer. | ||
Aug 2015 145200 mi US $10 |
Power running board on drivers side did not work. I removed it, had a broken bracket. I repaired the bracket and reinstalled the running board. Works great now! | ||
Nov 2015 151000 mi US $16 |
Both rear axle nuts were loose. Bought the socket to fit the axle nut and torqued to specs. Must have been an issue when I bought the car as I have not worked on the rear brakes or rear wheel bearings until now. | ||
Mar 2016 159000 mi US $450 |
Water pump worn out, leaking. Pin holes in the radiator, part worn out. | ||
Feb 2017 178000 mi US $36 |
All 7 Instrument panel light bulbs were replaced since one was burnt out. I ordered bulbs at fordparts.com and installed them myself. | ||
Apr 2017 1835000 mi US $600 |
Engine was running rough due to worn out spark plugs. They were the original spark plugs and needed to be replaced. The plugs were replaced and my car runs great! | ||
Nov 2017 194000 mi US $240 |
Both front wheel hubs were replaced, they were making loud noises Replaced worn out rotors and pads brakes, parts worn out | ||
Dec 2017 196000 mi US $65 |
Lights on the rear heat/ac control were burnt out but controls were still working. Replaced the heat/ac and fan speed switches with one from a junkyard part from another Explorer. | ||
Feb 2018 199000 mi US $36 |
Hood struts no longer held up the hood. Both struts were replaced with OEM hood struts that I found online for $18 each. Cost at Ford Dealer is $56 each |
Ford Explorer in Michigan, United States Sep 2012 - Jan 2013 | |||
Jan 2012 75000 mi |
Folding running boards were seizing up do to corrosion of extension linkage. Boards were lowered to extended position and motors disconnected. | ||
Apr 2012 65000 mi |
Updated firmware controlling transmission to eliminate jerking experienced when shifting under load. Update was successful in eliminating problem. |
Ford Explorer in Michigan, United States Jun 2009 - Apr 2013 | |||
Nov 2009 55000 mi US $400 |
RR Left Front Wheel Bearing assembly |
Ford Explorer in Oregon, United States Mar 2009 - Apr 2013 | |||
Sep 2012 121000 mi US $100 |
Center rear seat belt bolt fell off and released the seat belt. The bolt appears to have been too short. |
Ford Explorer in Massachusetts, United States Jun 2012 - Jun 2013 | |||
May 2013 74900 mi US $150 |
Sway bars only lasted 6 months. they needed to be be replaced. Moderate driving done no 4 wheel off road or rugged terrian. |
Ford Explorer in Mississippi, United States Dec 2013 - Oct 2019 | |||
Jan 2016 | coil-on-plug (COP) condensate produces misfire of sparkplug. change cop, inspect plug, and replace if necessary. | ||
Mar 2018 135000 mi |
radiator hose leaking . replaced line going to heater core. htr core itself not affected. bought nearly identical after market part on line for $200 less than OEM dealer replacement. put it in myself. will take a couple hours if you are not tool handy. also need to take off front wheel and cowling to get best access. after that easy install. | ||
Jul 2019 162000 mi US $150 |
The memory seats would move while driving and the interior lights would come on. This was caused by a faulty ignition switch. | ||
Sep 2019 165000 mi US $40 |
this vehicle v8 engine has a history of frequent failure of the coil on plug. i just replace the coil. easy fix but annoying as it occurs often. buy the cop with a lifetime warranty then replacing each time is free. bring bad coil in get free replacement. initial cost of a cop was $45 |
Ford Explorer in Pennsylvania, United States May 2008 - Jun 2011 | |||
Jun 2008 112000 mi US $2500 |
transmission failed all sensors and torque converter | ||
Sep 2008 120000 mi US $145 |
Short in wire caused engine failures. Idler pulley snapped off, tension pulley broke and serpentine belt broke. | ||
Oct 2008 120000 mi US $100 |
Bearing on driver side went bad-- replaced bearing and hub |
210-horsepower 4.0L V6 5-speed automatic RWD
Ford Explorer in Texas, United States Feb 2011 - Mar 2014 | |||
Jun 2011 29000 mi US $50 |
Low on antifreeze. Checked for leaks and found none. Flushed cooling system and put in new antifreeze. | ||
Feb 2012 35000 mi |
engine dampner fell off - covered under warranty. Radiator is bad - not covered under warranty. | ||
Sep 2013 54000 mi US $150 |
Thermostat housing gasket failed. The part failed close to home and was able to repair in my garage. Would not have been able to drive for another week. |
Ford Explorer in Massachusetts, United States Dec 2010 - Feb 2011 | |||
Feb 2011 86000 mi |
CD changer no longer worked when sold. |
Ford Explorer in Texas, United States Jul 2021 - Mar 2023 | |||
Jun 2022 147000 mi US $150 |
Thermostat replacement after fan clutch replacement did not correct my problem. The thermostat reacted in the boil test, but after fan clutch replacement did not fully take care of the issue I contacted a friend who is a does mechanic and he said to replace the thermostat with an oem replacement as these engines go through thermostats. No more roaring engine fan or random overheating engine. | ||
Mar 2023 154000 mi US $100 |
replaced thermostat, added k-seal for coolant leak (mixed into engine oil) misfires due to valve gasket leak. Replaced plugs, wires and coil pack. Attempted to tighted valve cover but already tight. I will be adding a leak stop to mitigate. |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in Illinois, United States Mar 2009 - Nov 2013 | |||
Jun 2009 22000 mi US $56 |
Front tire was loosing air. Dealer found the tire valve was leaking and replaced valve. | ||
Nov 2011 56000 mi US $125 |
Coolant leak at the thermostat. Replaced gasket and fixed the coolant leak. | ||
Nov 2013 85000 mi US $720 |
Front driver side wheel bearing noisy. replaced as a wheel hub assembly. |
Ford Explorer in Ontario, Canada Mar 2009 - Dec 2016 | |||
Nov 2009 37200 mi |
Rear wiper motor stopped working | ||
Jan 2011 80580 mi C $2700 |
3rd row electric "stow" seats would not raise/lower. Some form of latch needed to be replaced on both seats. | ||
Apr 2014 91200 mi C $200 |
Right rear stabilizer had disconnected | ||
Aug 2016 119120 mi C $500 |
Replaced warn suspension component |
Ford Explorer in Kuwait Mar 2011 - Apr 2012 | |||
Nov 2011 55180 mi |
coolant temperature sensor O ring leaking, O ring replaced |
Ford Explorer in Oregon, United States Nov 2010 - Mar 2014 | |||
Mar 2011 52000 mi US $240 |
Replaced both struts due to one going bad. Not covered under warranty. |
Ford Explorer in Illinois, United States Nov 2014 - Jun 2015 | |||
Dec 2014 111000 mi US $3585 |
Transmission starting slipping when going into reverse. Had to replace the transmission with factory rebuilt unit. Rarely under any load in reverse due to downhill driveway, so not really noticeable until I had to back up with a small load. | ||
Feb 2015 111600 mi |
The factory rebuilt transmission failed with less than 3000 miles on it. A transmission fluid cooling line wasn't properly torqued, allowing fluid to leak out. It was replaced under warranty at no charge. |
Ford Explorer in New York, United States Aug 2010 - Nov 2012 | |||
Jan 2011 33000 mi US $700 |
Driver side front wheel bearing replaced | ||
Mar 2012 51000 mi US $630 |
wheel Hub Assembly / Wheel Bearing Right Upper Control Arm Replaced Replaced Both Lower Ball Joints |
Ford Explorer in Maryland, United States Jan 2011 - Nov 2011 | |||
Jun 2011 87000 mi US $500 |
replace right tie rod replace front right wheel bearing | ||
Nov 2011 98000 mi US $375 |
housing over thermostat cracked allowing slow leak of coolant housing over thermostat cracked allowing slow leak of coolant |
Ford Explorer in New York, United States Nov 2017 - Sep 2018 | |||
Feb 2018 131980 mi US $125 |
Thermostat housing leaking, replaced housing, thermostat and temperature sensor |
Ford Explorer in United Arab Emirates - Sep 2008 | |||
Sep 2008 46500 mi ¤4000 |
AUTOBOX Overhaul, clonking and whinning. Just outside warranty and no goodwill!! Typical Ford |
Ford Explorer in New York, United States Apr 2009 - Jan 2014 | |||
Feb 2012 53300 mi US $250 |
thermostat replaced | ||
Jan 2014 67000 mi US $2200 |
Brackets rusted on converter |
Ford Explorer in Michigan, United States Aug 2010 - Dec 2014 | |||
Dec 2010 97000 mi US $40 |
Horn not working - fuse replaced. | ||
Mar 2011 100000 mi US $250 |
Rear wiper motor stopped working, slowing stroke first, until it gradually stopped moving. Wiper motor replaced for rear window. | ||
Nov 2011 105000 mi US $800 |
Front wheel bearing hubs getting noisy, need replacement. Rears also need replacing, but will wait until next summer. | ||
Jan 2012 107000 mi US $550 |
Rear wheel bearings needed replacing. The bearings on these vehicles usually go about 75K. Mine went to a little over 100K. Replaced in January earlier than I was originally planning. | ||
May 2013 124500 mi US $900 |
Rear window wiper motor stopped working. The arm froze in position. Dealer replaced the ignition switch and tumbler. When vehicle was turned off but key left in the accessory position - touching the key resulted in the drivers seat moving out of position as if the key had been removed. Dealer replaced the ignition switch and tumbler. When vehicle was turned off but key left in the accessory position - touching the key resulted in the drivers seat moving out of position as if the key had been removed. Rear window wiper motor stopped working. The arm froze in position. | ||
Jan 2014 111000 mi US $300 |
Thermostat housing developed a slow leak. OEM part is made of PLASTIC! Repair takes about an hour. Replacement part I bought is made of metal - replacing the lower portion now and will reuse the plastic upper for now. | ||
Oct 2014 141000 mi US $120 |
Replaced another driver side front bearing (hub unit). This unit lasted just 40k miles and was supposed to be an OEM part. This time I replaced with a Timken hub from Amazon. Cheaper and looks like a good quality part. |
Ford Explorer in Alabama, United States Jul 2013 - Mar 2014 | |||
Oct 2013 81700 mi US $2354 |
Electronically flawed, alternator, battery, ecu unit, body damage repair, engine good, severe electrical issues! All wheel bearings in vehicle have to be replaced. |
Ford Explorer in British Columbia, Canada Apr 2008 - Sep 2012 | |||
May 2008 103540 mi C $1000 |
Broken belt for power steering. When towed discovered no coolant and cause was due to leak in heating coil that also need to be replaced. Leaking coolant from heating coil. | ||
Jun 2008 103540 mi C $550 |
No airconditioning because of leaking coolant. | ||
Aug 2008 104780 mi C $250 |
Unable to start car from park position in transmission. Intermittent problem. Somewhat improvement after repair. | ||
Jan 2011 116740 mi C $450 |
Power chair did not move back or forth. Repaired power seat switch. | ||
Jul 2011 119860 mi C $450 |
rust on tire rims leading to flat tires. dead rear lightbulb. |
Ford Explorer in Massachusetts, United States Feb 2011 - Jan 2013 | |||
Aug 2012 51700 mi US $100 |
Worn sero bores on the 5r55s. Trans fluid leak with burned fluid and burned bands. Replaced whole trans. | ||
Jan 2013 47000 mi US $100 |
Transfer case issue plus u-joints Transfer case noise. Replaced transfer case. |
Engine not specified
Ford Explorer in California, United States Oct 2014 - Jan 2015 | |||
Jan 2015 US $450 |
Front differential leak repair |
Ford Explorer in Colorado, United States Jul 2014 - Dec 2014 | |||
Nov 2014 102100 mi US $200 |
transmission very rapidly jerked. Mike Naughton Ford, Aurora, Colo had car for 3 days and couldn't find problem but charged me $800. 3 weeks later took it to local repair. Found 3 bad plugs on left side. Fixed. Runs great now. |
292-horsepower 4.6L V8 6-speed automatic RWD
Ford Explorer in Texas, United States Sep 2007 - Jun 2011 | |||
Oct 2007 31000 mi |
Transmission would kick when shifting into first when comming to a stop. | ||
May 2009 50000 mi US $100 |
Performed TSB for known transmission issue when shifting from 2nd to 1st. |
Ford Explorer in Texas, United States Sep 2007 - Dec 2017 | |||
Nov 2007 12000 mi |
Common problem with Explorers with 6 speed transmission where transmission downshifts from 2 to 1 harsh when coming to a stop. Service bulleting was issued in November that reprogrammed the transmission and e-learned new shift strategy. | ||
Aug 2008 15000 mi |
Two problems fixed; 1. Occasionally difficult to shift from park. Gear selector lever was replaced. 2. Ping or Click noise when reversing and going back to forward. Problem was found in right rear driveshaft, which was replaced. | ||
Oct 2010 28000 mi |
Right 3rd row seat would not rise. Gear assembly with motor was stuck. Removed cover behind 3rd row seat to access the assembly. Applied grease to the gears and it started working, thought it is not as smooth as the left side seat. | ||
Mar 2012 35000 mi US $18 |
Found radiator having a slow leak. Inserted Bars Leak Stop tablets into radiator and filled overflow reservoir with new coolant. Leak is now stopped but most likely this is a temporary fix. | ||
Sep 2012 37000 mi US $244 |
Passenger side power 3rd row seat back not elevating. The motor gearbox was broken. Ordered replacement part and replaced it by myself. | ||
May 2014 47000 mi US $204 |
Driver side third row seat electric latch assembly gear broke. Replaced the complete latch assembly. | ||
Nov 2014 50000 mi US $4 |
Slow leak on radiator. Added Bars radiator stop leak and it stopped the leak. | ||
Jun 2015 53000 mi US $100 |
Coolant leak from radiator top left corner. (Previous fix by leak stop products were no longer able to fix it.) Radiator replaced. | ||
Sep 2015 55000 mi US $35 |
Sway bar link bushings were worn. Replaced with new sway bar links. |
Ford Explorer in Georgia, United States Dec 2009 - Jun 2018 | |||
Dec 2010 76000 mi US $50 |
The Heater Blend Door Actuator had a stripped gear, causing the A/C to make a clicking noise on startup, though A/C still worked fine. The new part was $50. If you have this problem, DO NOT buy the part made by Dorman, it does not work. | ||
Sep 2012 102000 mi US $6 |
Radiator was leaking. Flushed it and refilled, then added some Bar's Leaks Pelletized Stop Leak, and it fixed the leak. | ||
Dec 2012 108000 mi US $150 |
Torque converter felt like it was going out, replaced transmission fluid and so far so good. | ||
Sep 2015 140000 mi US $215 |
Fan clutch was slipping - replaced (easy). Radiator was leaking - replaced with an aftermarket radiator. | ||
Jul 2016 144200 mi US $9 |
Had to replace the thermostat. |
Ford Explorer in Georgia, United States Nov 2012 - Oct 2017 | |||
Sep 2013 161000 mi US $450 |
Engine overheating due to leaking tee coupler from radiator to heater core. Ford will no sell just the tee, you have to buy the complete hose assmebly. | ||
Feb 2015 171000 mi US $475 |
Bad Fuel Mileage and lack of power. Oiled Changed, Fuel Filter Changed and Spark Plugs Changed. (First time the plugs were changed) RUNS OK NOW. | ||
Aug 2016 178000 mi US $2300 |
Front and Rear Brakes Replaced Rear springs replaced torsion bar replaced. Front and Reat Wheel Bearings Sway Bar replaced as part of suspension system repairs / Maintenance Spark Plugs Replaced |
292-horsepower 4.6L V8 6-speed automatic 4WD w/low range
Ford Explorer in Wisconsin, United States Apr 2017 - Jun 2018 | |||
Mar 2017 72500 mi US $650 |
Cruise control button on steering wheel did not work and was swapped out with new motorcraft part. Radiator was leaking and needed replacement. | ||
Mar 2018 75000 mi US $450 |
Third row passenger motor did not work and required replacement. Ended up swapping out the powered seats for manual ones that matched. |
Ford Explorer in Ontario, Canada Oct 2009 - Sep 2014 | |||
Sep 2010 77500 mi C $2 |
Burned out left rear turn signal/running lamp. Simple fix, first problem with my vehicle in almost a year of owning it | ||
Apr 2011 83080 mi C $101 |
Bad misfire in Cyl 8, coil and plug removed, coil boot badly cracked and corroded, plug badly fouled. | ||
Jul 2011 84940 mi C $95 |
the Tire pressure monitor in the right rear wheel was defective, had to be replaced, solved problem | ||
Sep 2013 105400 mi C $95 |
Tire pressure monitor failed, replaced |
Ford Explorer in Nebraska, United States Feb 2015 - Mar 2018 | |||
Mar 2015 129000 mi US $250 |
Repaired broken sway bar link. Replaced both. Also some new bushings. | ||
Jun 2015 131000 mi US $475 |
Replaced Power Steering Pump. | ||
Mar 2018 151000 mi US $1362 |
New front pads. Both lower ball joints. Rear Sway bar connection |
Ford Explorer in Illinois, United States Nov 2009 - Feb 2013 | |||
Dec 2010 62000 mi US $100 |
Left Rear Axle Seal was leaking | ||
May 2012 76700 mi US $120 |
Right front sway bar snapped. Replaced both left and right sway bar. | ||
Jan 2013 85000 mi US $3800 |
The right 3rd row power folding seat motor failed. The Transmission Valve Body is failing Transmission was rebuilt, Transmission Valve Body was replaced. | ||
Feb 2013 85000 mi US $110 |
Blower fan control was stuck on high and would not respond. |
Ford Explorer in Washington, United States Oct 2008 - Nov 2013 | |||
Feb 2012 77400 mi US $980 |
Replaced spark plugs | ||
Aug 2013 92000 mi US $220 |
Thermostat was sticking |
Ford Explorer in Indiana, United States Apr 2015 - Jan 2016 | |||
Apr 2015 125000 mi US $400 |
Worn tie rod required replacement | ||
Jan 2016 US $120 |
Y pipe replacement due to leak |
Ford Explorer in California, United States Oct 2007 - Jun 2011 | |||
Dec 2008 29000 mi |
Transmission shifting hard into and out of 1st gear. Rear defroster not working, parts backordered. Shifter intermittently not moving out of Park. Shifter replaced. | ||
Feb 2009 30000 mi |
Rear defroster had in-op lines, rear glass ordered and replaced. Problem resolved. Rear passenger door lock was very sticky, especially when below freezing. Lock actuator replaced; problem resolved. |
Ford Explorer in Maryland, United States Feb 2010 - Jun 2018 | |||
Apr 2010 37000 mi US $185 |
Rear brake lights / turn signals failed. Turned out to be a wiring harness that was installed improperly at the factory. Wiring harness rubbed against metal and eventually wires wore through and shorted the tail lights. Wiring harness replaced. Axle gasket on 4WD system was leaking. Problem was fixed by replacing the gasket. | ||
May 2010 37800 mi US $50 |
Brake shift interlock working intermittently. You needed to jiggle the shifter, push the shift button in several times etc. to get the car to shift out of park. Turned out to be a sensor on the shifter. Shifter was replaced. | ||
Dec 2010 45000 mi US $50 |
Car was leaking (minor) in the driveway. Appeared to be radiator fluid. CarMax stated the radiator was leaking and new radiator needed. Replaced for $650, but with extended warranty I only paid $50. Not fixed satisfactorily. Car continued to leak radiator fluid. Took back to CarMax, and they tightened all fittings, stated they thought is was transmission fluid, as that circulates through the radiator also. Ran the car in the shop for 1/2 hour, but still leaks | ||
Feb 2011 46300 mi US $50 |
Coolant leak was finally tracked to a valve/fitting under the car (around the location of the front passenger seat), whereby coolant leaked onto my driveway. After having the car into CarMax twice before, it is now fixed. | ||
Jun 2012 61000 mi US $50 |
Third row electric seat backs (raise the back up and down for stowage in the floor) stopped working on the passenger seat (third row is split). Electric motor replaced using extended warranty insurance. | ||
Mar 2014 79000 mi US $350 |
Check engine light came on. Was a leaking gasket on the fuel system (around the gas tank), which was allowing gas vapor to escape. New gasket needed. | ||
Dec 2015 94000 mi US $900 |
Exhaust manifold cracked and needed replacement. Torque converter not properly locking into place. | ||
Jul 2016 98800 mi US $975 |
Compressor replaced in A/C |
Ford Explorer in Ontario, Canada Nov 2007 - Mar 2010 | |||
Jan 2007 744 mi |
Shifting problem from 2nd to 3rd and downshift from 3rd o 2nd, also 2nd to 1st downshift - was very harsh. | ||
Mar 2007 930 mi |
right transaxle seal leaking | ||
Apr 2007 1550 mi |
warning light on for tire pressure - took back three times before it got fixed -dealer tried to sell me nitrogen! Repair was fault connection under the hood! |
Ford Explorer in Ontario, Canada Apr 2012 - Mar 2015 | |||
Jul 2014 140200 mi |
The front right wheel bearing was starting to get noisey. I changed both front wheel bearings to be safe. Front brakes were found to need new pads and were done two weeks later, but that is a maintenance item and does not count as a repair. |
Ford Explorer in Maryland, United States Mar 2014 - Apr 2015 | |||
Apr 2015 124000 mi US $800 |
No cold air coming out of vents with A/C on. Passenger side vents would randomly blow hot air. Replaced driver and passenger side blend doors. |
Ford Explorer in Illinois, United States Nov 2007 - Mar 2011 | |||
Jan 2008 25000 mi |
Truck was at dealer for late engagement of shift into 1st gear from a stop and a bump feeling when coming to a stop. TSB 07-23-2 was performed. Truck still has same symptoms. Ford tech being contacted by dealer. Customer waits for answers. | ||
Feb 2008 26000 mi |
Continuation of existing problem. TSB has been superceeded by TSB08-3-8. When dealer tried to reflash they received message of latest software installed. Delayed engagement and bump stop still exist. Rear window defogger has burnt out line. Dealer needs to order a fresh repair kit. | ||
Apr 2008 28000 mi |
Reflash ECM and TCM and problem is solved for now. Rear window defroster line repaired with kit that needed to be ordered. | ||
Jan 2010 49600 mi |
Driver's side back seat (2nd row) seat belt jammed as it was being pulled out to be used. Will not release or rewind. Dealer ordered new seat belt. Repair covered under the 5 year 50,000 mile safety warranty. |
Ford Explorer in Ohio, United States Dec 2007 - Jan 2012 | |||
Dec 2008 36000 mi |
Hard shifts when cold - reflash of transmission cured it. | ||
Jun 2011 72200 mi US $1309 |
transmission fluid ran out due to a fitting coming loose (might have been caused by a car wash). Required R&R of radiator as well. |
Ford Explorer in Iowa, United States - Aug 2006 | |||
Aug 2006 210 mi |
lifter stuck in engine when bought new and not discovered by dealer until brought back in |
Ford Explorer in Maryland, United States Jan 2013 - Mar 2013 | |||
Feb 2013 91000 mi US $500 |
Traction Control and ABS failure lights kept illuminating. Fixed itself for now. Likely a sensor issue, seems to happen when slush on the ground and wheel wells get splashed. Drives me nuts that when you need it most and the entire system shuts down. |
Ford Explorer in Minnesota, United States Dec 2013 - Mar 2018 | |||
Jun 2014 123000 mi US $977 |
left exhaust manifold replaced. | ||
Sep 2015 144000 mi US $150 |
Replacement upper left ball joint. Front and rear alignment. | ||
Sep 2016 164000 mi US $600 |
replaced eng. cooling system thermostat | ||
Nov 2016 165200 mi |
Replaced heater hose assmby 6L2Z 18C553 C. $342 parts. plus labor. | ||
Oct 2017 172000 mi US $400 |
replaced water pump |
Ford Explorer in Kentucky, United States Oct 2007 - Apr 2012 | |||
Jun 2008 14000 mi |
Rough downshift into 1st, either while stopping, or while accelerating. | ||
Dec 2009 29000 mi |
Car was dificult to shift into gear from park |
Ford Explorer in New York, United States Mar 2008 - Mar 2010 | |||
Apr 2008 17000 mi |
Water in rear tail lights and in right front fog lamp. | ||
Aug 2008 21000 mi |
Rear (middle row) drivers side seat belt buckle would not function properly (latch). Item was repaired by replacing the assembly. Passenger leather seat base had "stress cracks" on the upper portion between legs. Dealership had it repaired. The repair failed 1 year later. The dealer then decided to replace the cover. Part still on back order (2 weeks). | ||
Sep 2008 21000 mi |
Seat base cover was replaced by the dealer who sold the vehicle. | ||
Mar 2009 25000 mi |
Hard shifting, mainly between 1st to 2nd, but noticeable though all gears. Engine would idle rough. Ford replaced throttle body and motor assembly. Slow leak from radiator. Service shop found leak from hose under radiator. Driver door creeks/pops when closing. Service department lubricated twice (first time with penitrating oil, second time with White lithium grease). Waiting to see if returns. Problem with lower hinge. |
Ford Explorer in New York, United States Jun 2009 - Apr 2017 | |||
Jul 2011 65000 mi US $100 |
Noticed coolant leak in parking lot after vehicle was parked about an hour. Took to dealer who diagnosed as bad radiator, replaced same plus trans cooler line broken in radiator removal process. | ||
Jan 2012 126800 mi US $1000 |
3rd row power seat folding motor stopped working and needed to be replaced. (motor & gearcase one sealed unit) | ||
Jul 2012 79700 mi US $85 |
Check Engine light on. Engine running rough. Code was P0303. Replaced #3 coil on plug assy. Problem solved. | ||
Aug 2012 81000 mi US $170 |
No cooling from Air Conditioner. Recharge System & Check for leaks. | ||
Sep 2012 83000 mi US $125 |
Windshield wipers would not stop wiping. Diagnose & replace wiper motor. | ||
Apr 2013 93700 mi US $150 |
Charge ind. would come on and would able to be cleared immediately. Dealer diagnosed bad alternator and replaced it. Rear wiper would not move. Dealer diagnosed bad motor and replaced it. Car would miss and buck during acceleration. Dealer diagnosed 2 bad coil on plugs and replaced them. | ||
May 2013 95300 mi |
Car died on side of road. Jumped battery, car started but would not stay running. Towed to dealer who replaced alternator. | ||
Jul 2014 110500 mi US $70 |
Check engine light on repl coil on plug assy | ||
Sep 2014 113000 mi US $65 |
Check engine light on. repl coil on plug for cyl. 7. | ||
Jun 2016 133000 mi US $100 |
Rear Sway bar end link found broken during annual State Inspection. Replaced same. Tailgate rear window hinges broken. Remove & Replace. | ||
Jan 2017 137000 mi US $1300 |
Transfer case motor stuck between 2WD & 4WD. Car would not move. RF Wheel bearing bad, threw ABS & Traction Control lights on inst panel 2 lug nuts sheared off. Shop replaced all 5, fixed slow leaking tire. |
210-horsepower 4.0L V6 5-speed automatic RWD
Ford Explorer in South Carolina, United States Aug 2009 - Dec 2018 | |||
Jan 2010 95800 mi US $550 |
Vehicle gave a loud "WHOOSHING" noise when gas pedal pressed and had no working heat. Noticed coolant tank was empty and radiator fluid low. When refilled, the radiator began leaking slowly then profusely. Radiator was replaced. | ||
Mar 2012 73000 mi US $600 |
Thermostat housing cracked causing leaks | ||
Feb 2013 92300 mi US $1500 |
Radiator failure, barely made it a mile to the garage. Radiator replaced. This is the 2nd radiator I have had to have replaced. | ||
Mar 2014 109000 mi US $1100 |
Leaking T Coil Factory battery bad, was replaced Thermostat housing cracked (2nd time) | ||
Aug 2014 116800 mi US $1900 |
Trans was slipping,acceleration, jerking problems. Finally threw wrench & check engine lights. Problem caused due to 3rd Gear Ratio Error causing Transmission to go into fail-safe mode, Transmission was rebuilt. | ||
Mar 2015 138000 mi US $650 |
Jet Engine Noise, coolant smell, losing coolant - Thermostat housing replaced |
Ford Explorer in Tennessee, United States May 2011 - Sep 2011 | |||
Sep 2011 96000 mi US $736 |
drivers side rear axle snapped, looked like there were previous problems not repaired correctly |
Ford Explorer in Texas, United States Sep 2006 - Dec 2011 | |||
Jan 2006 11 mi |
Factory Warranty repair: Rear right passenger door window will not work from the driver's controls. Had to have passenger use the door control to roll window up and down a few times before driver's control would work. Both switches replaced. | ||
Feb 2006 300 mi |
Factory Warranty repair: Rear left passenger door out of alignment and hitting the trim of the step rail. Door was removed and re-installed. Trim had to be buffed, painted, re-glazed where door was hitting it. | ||
Apr 2007 16000 mi |
Factory Warranty repair-issue not resolved. Gear shift lock will not release when brake depressed. 2 visits to same dealership; problem not yet resolved. Escalating issue through warranty company. | ||
Oct 2007 21000 mi |
Selected Transmission/Drivetrain - Difficulty in getting gear shift to engage. 3rd trip to a dealership for this problem. This dealership finally got it right. This time was told that the problem is a 'known problem' at Ford but no recall. Rear passenger, driver side, window would not roll down with either the switch on that door or with the master control. Both switch's replaced. 2nd time to a dealership for this problem, only this dealership replaced the master control as well as the ne | ||
Dec 2011 45000 mi US $700 |
Starter went out. Learned this is a known issue in model years through 2006. Ford never issued a recall. |
Ford Explorer in Texas, United States Aug 2013 - Oct 2013 | |||
Sep 2013 124000 mi US $150 |
wet spark plugs |
Ford Explorer in North Carolina, United States Feb 2011 - Aug 2014 | |||
May 2011 73000 mi US $283 |
rear drive axel needed to be replaced. | ||
Sep 2011 75000 mi |
connection parts on radiator needed to be replaced, they were leaking. brake squeaked when depressed. Fixed by lubing brake assembly (inside driver cabin). | ||
Jul 2012 94000 mi US $1000 |
Crack in piece where you put oil in the engine causing oil to leak. Thermostat needed to be replaced. | ||
Jul 2013 112500 mi |
TPMS system was not working | ||
Mar 2014 121000 mi |
leaking coolant. | ||
Jun 2014 124000 mi |
Leaking coolant |
Ford Explorer in Alabama, United States May 2011 - Jul 2011 | |||
Feb 2011 64000 mi |
Engine cooling system (radiator, water pump, thermostat, heater core, etc.), repair |
Ford Explorer in Florida, United States Nov 2010 - Jun 2018 | |||
Sep 2012 121000 mi US $2100 |
Transmission was not taking reverse and not shifting past second gear. The shop re-built the Transmission. | ||
Apr 2014 133500 mi US $400 |
Replaced, brake pads, rotors, front right wheel hub, both back wheel bearings and back right cv joint. | ||
Apr 2015 136000 mi US $350 |
Replaced Spark plugs, spark plug wires. | ||
Jan 2016 133200 mi US $90 |
The EGR valve went bad, car would turn off or sputter. I replaced the EGR valve. | ||
Feb 2016 137600 mi US $500 |
Oil leak, replaced seal and gasket. |
Ford Explorer in Louisiana, United States Jan 2013 - Oct 2013 | |||
Aug 2013 102100 mi US $1300 |
Stop changing gear |
Ford Explorer in New York, United States Dec 2017 - Dec 2017 | |||
Dec 2017 136000 mi US $800 |
OEM compressor and/or clutch need replacement. |
Ford Explorer in Arizona, United States Mar 2009 - Mar 2010 | |||
Apr 2009 205000 mi US $750 |
A rebuilt engine was put in in 2004 and now Timing Chain & Guides on front left have to be replaced. (Was a recall in 2001 I believe.) |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in Utah, United States Feb 2018 - Jul 2024 | |||
Jul 2018 103000 mi US $250 |
Replaced brake pads and rotors | ||
Apr 2021 115000 mi US $50 |
Engine thermostat housing was gushing out coolant. Was able to get the vehicle home and replace the thermostat housing myself in a couple of hours |
Ford Explorer in Florida, United States Mar 2013 - Apr 2013 | |||
Apr 2013 78000 mi US $550 |
right rear hub bearing started grinding needed it replaced, |
Ford Explorer in Texas, United States Sep 2007 - Aug 2019 | |||
Mar 2008 35000 mi |
Radiator was replaced due to small leak. Radiator was replaced under warranty due to a leak | ||
Sep 2009 54000 mi US $295 |
Battery went dead, low voltage burned out the 6 cd player so it had to be replaced | ||
May 2013 79000 mi US $245 |
Battery died, low voltage damaged the CD changer which had to be replaced. Second time this has happened! | ||
Oct 2014 84500 mi US $800 |
Radiator was leaking and had to be replaced, 2nd time this issue has occurred. | ||
Jan 2015 86500 mi US $150 |
Stabilizer bars replaced | ||
Sep 2015 93000 mi US $400 |
Thermostat housing cracked, needed to be replaced. | ||
Nov 2015 98000 mi US $270 |
Rear sway bar links replaced Reflashed ecu to make the engine run cooler | ||
Sep 2016 105000 mi US $4900 |
Engine had no compression in cylinder #4 due to broken time chain tensioner, replaced with remanufactured engine. | ||
Aug 2017 116000 mi US $1200 |
Transmission was slipping when accelerating from a stop. Torque converter needed to be removed and repaired. |
Ford Explorer in Ontario, Canada Dec 2010 - Apr 2017 | |||
Sep 2011 42160 mi C $300 |
Had the rear hatch repainted due to a rust bubble forming just above the center trim piece with the Ford emblem, another factory issue in my opinion. | ||
Oct 2011 42760 mi C $650 |
Had to repair a front differential seal leak. | ||
Mar 2012 48360 mi |
Rear wiper stuck in position. I removed the motor assembly and found wiper shaft binding in motor housing due to corrosion. I cleaned out corrosion, greased the housing and shaft and reassembled. Has been working fine since. | ||
Feb 2014 72980 mi C $750 |
Thermestat housing crack causing coolant to leak. Issue found before any other damage could occur to engine, no overheating occurred. | ||
Mar 2015 86800 mi C $1100 |
Had to replace two bad wheel bearings, LF and RR. Also have minor leak at front axle seals but will not change at this time. After repair, I can now hear the LF wheel bearing will need to be changed in the next few months. | ||
Jun 2015 89900 mi C $550 |
Replaced noisy RH wheel bearing. | ||
Jul 2015 90700 mi C $450 |
For a second time, lift gate needs to be refinished for rust located along the chrome trim piece above the license plate. Also noticed rocker panels rusting but are not visible due to running boards therefore will leave as is. | ||
Apr 2017 112840 mi C $150 |
Replaced egr valve |
Ford Explorer in New York, United States Aug 2011 - Dec 2012 | |||
Sep 2012 77000 mi US $140 |
The wheel sensor went bad, but it is internal, so you have to replace the whole wheel bearing assy. |
Ford Explorer in Maryland, United States May 2008 - Mar 2010 | |||
Nov 2008 52500 mi |
Rear defroster not working. 6 hour fix. | ||
Dec 2008 56000 mi |
BAd vibration. Dealer performed TSB, still have vibration. 4 visits to dealer and still no fix. Vacuum line issue under the dash. Dealer says its normal to only have air blow out your defrost vents. |
Ford Explorer in South Carolina, United States Oct 2007 - Apr 2009 | |||
Aug 2008 35000 mi |
I was having a difficult time moving the car out of park. There was a TSB for the problem and they replaced the shifter. |
Ford Explorer in Missouri, United States Dec 2009 - Apr 2010 | |||
Feb 2010 39000 mi |
Leak in sunroof. | ||
Mar 2010 40000 mi US $300 |
broken radiator | ||
Apr 2010 40000 mi US $100 |
ignition coil malfunction faulty EVAP solenoid and canister; car sold with this unrepaired Heater was blowing cold air when the engine is idling. Not repaired. |
Ford Explorer in Florida, United States Aug 2013 - Dec 2015 | |||
Aug 2013 107000 mi US $500 |
Slippage, noise in systems, diagnosed as loose pins that came undone inside unit. The same problems you would typically read reported from 30K mileage and later. Passenger rear hub and bearing assembly replaced, also had dealer do analysis of transmission slippage issues and pull diagnostic codes from computer. | ||
Dec 2014 135000 mi US $800 |
Wheel hub and bearing assembly. Drive side front. | ||
Dec 2015 148000 mi |
Front hub and bearing - replacement needed. Steering fluid leak - replacement needed. |
Ford Explorer in Virgin Islands, U.S. Apr 2011 - Sep 2011 | |||
Jun 2011 38440 mi US $300 |
A/C condenser drip shorted shift solenoid in tranny. replaced parts ($950) and labor came out to $1700. moved A/C drip elsewhere. Poor engineering on Ford's part airbag light on. was a fault in electrical. |
Ford Explorer in Ontario, Canada Nov 2014 - Dec 2014 | |||
Dec 2014 109120 mi C $600 |
Grinding while driving. Driver side rear wheel hub removed and replaced, including bearing. |
Ford Explorer in Arizona, United States Oct 2009 - Jun 2012 | |||
Jun 2012 80000 mi US $1000 |
Replaced Radiator Replaced brake master cylinder |
Ford Explorer in United Arab Emirates Feb 2008 - Mar 2010 | |||
Jan 2008 12400 mi ¤500 |
While going off road, broke the hose of the tranny cooler and thus leaking tranny fluid. Had to replace the whole of the radiator/tranny cooler. Disappointed with the positioning of the hoses of the tranny. Tranny cooler should have been a sep unit | ||
Mar 2009 35960 mi |
A drop in coolant level was noticed and duly informed to the service center. After troubleshooting, a leak in th radiator was found. There is a TSB regarding this and the radiator was replaced free of charge. Hand brake release lever was broken. The hand brake lever was replaced by the dealers. |
Ford Explorer in Maryland, United States Dec 2011 - Feb 2013 | |||
Oct 2012 110000 mi US $2900 |
New radiator, rear wheel bearings, and fuel line repair. | ||
Feb 2013 115000 mi |
Transmission took several seconds to engage when put into reverse. Dealer wanted to replace transmission solenoid for $1000. I declined the repair. |
Ford Explorer in Pennsylvania, United States Jul 2013 - Dec 2015 | |||
Aug 2013 108200 mi US $95 |
Thermostat housing split again... second one within 2 months | ||
Oct 2013 114000 mi US $75 |
Stupid design, sliders seized, could not free pin, had to replace caliper and bracket | ||
Nov 2013 114000 mi US $10 |
sway bar links were replaced, passenger side broke off completely and was missing | ||
Dec 2014 131000 mi US $3700 |
jumped timing, blew engine |
Ford Explorer in Oregon, United States Jan 2014 - Apr 2015 | |||
Mar 2014 152000 mi |
Quick disconnect for trans cooler lines at radiator leaking. Shop had to engineer parts for repair, so a new $1000 radiator would not have to be done. Milled the connector and added 3/8npt fitting with trans hose jumper. No mare leaks seen. |
Ford Explorer in Florida, United States May 2019 - Jul 2020 | |||
Jul 2019 279000 mi US $340 |
Front left hub was replaced. The ABS, tool, and traction lights were on. The braking became irregular and grinding |
Ford Explorer in Illinois, United States Jan 2016 - Mar 2016 | |||
Mar 2016 108000 mi |
Transmission was rebuilt with 75000 miles on it. In March the transmission started slipping again. I decided not to put alot of money into a ten year old car. That year of Explorer has major transmission problems , look on the internet. |
Ford Explorer in Illinois, United States Mar 2008 - Mar 2010 | |||
Apr 2008 40000 mi US $176 |
Radiator leak at 40000 miles. waited for radiator because Ford didn't have any and neither did radiator shop. Ford was out, this tells you they have a problem w/ radiators. there should be a recall. Power steering leak at 39000 miles. Tire air pressure sensor went out at 39000 miles. |
Engine not specified
Ford Explorer in Illinois, United States Aug 2011 - Oct 2011 | |||
Oct 2011 89000 mi US $5600 |
Engine timing chain broke. Not happy! |
Ford Explorer in Pennsylvania, United States Aug 2010 - Feb 2012 | |||
Dec 2011 196000 mi |
Wheel Inflation Sensors 2 ea, Front wheels. Low tire light was coming on all the time. |
239-horsepower 4.6L V8 5-speed automatic RWD
Ford Explorer in Michigan, United States Mar 2013 - Apr 2013 | |||
Apr 2013 125000 mi US $300 |
replace coil and injector and plug |
Ford Explorer in Tennessee, United States Feb 2011 - Mar 2012 | |||
Nov 2011 148500 mi US $50 |
tapped and re-thread sparkplug "socket" in #3 cylinder after sparkplug blew out while driving | ||
Mar 2012 160000 mi US $600 |
Catalytic converter disintegrated and clogged requiring replacement of y-pipe that includes 3 converters. Also replaced o2 sensors as insurance against future removal. |
239-horsepower 4.6L V8 5-speed automatic 4WD w/low range
Ford Explorer in New Mexico, United States Mar 2013 - Jan 2022 | |||
Sep 2017 210000 mi US $500 |
Replaced timing chains Replaced steering rack because of leak Replaced steering pump because I was replacing rack Replaced ignition coils | ||
Mar 2018 215000 mi US $350 |
Replaced all four struts. One was leaking. |
Ford Explorer in Virginia, United States Sep 2017 - Mar 2018 | |||
Nov 2017 109500 mi US $10 |
Replaced thermostat |
Ford Explorer in Michigan, United States Nov 2008 - Mar 2010 | |||
Dec 2008 44000 mi |
Had a reputable transmission shop check trans due to somewhat hard shifts at times. They checked the trans bands, solenoids, fluid, pressure test etc. and found everything was good. Owner said that 'hard shifts' at times is common with this vehicle. |
Ford Explorer in Ontario, Canada - May 2007 | |||
May 2007 12150 mi |
Small amount of oil leaking on garage floor under vehicle. Crack in housing of transfer case; replaced under warranty. |
210-horsepower 4.0L V6 5-speed automatic RWD
Ford Explorer in Massachusetts, United States Dec 2010 - Jul 2012 | |||
Dec 2011 82000 mi US $421 |
replace left front wheel bearing |
Ford Explorer in Florida, United States Apr 2009 - Dec 2012 | |||
Dec 2010 53000 mi US $1500 |
no air coming from dash air outlets. took out dash and replace vacuum assembly. problem solved replaced ball joints | ||
Jun 2012 60000 mi |
cruise control inoperative. Not used often and deemed too expensive to repair. | ||
Dec 2012 62000 mi |
cruise control never fixed |
Ford Explorer in Connecticut, United States Feb 2010 - Jul 2011 | |||
Mar 2011 116000 mi US $450 |
Died while on the road. Adv Trk light was on and others on the dash. Ended up being a bad alternator. The first attempt by one dealer was to reset ECU. The second dealer found the problem and replaced the bad alternator. |
Ford Explorer in Hawaii, United States Jun 2009 - Sep 2013 | |||
Mar 2010 41000 mi US $100 |
ABS module. | ||
Oct 2012 64300 mi US $100 |
worn out front wheel bearings |
Ford Explorer in Texas, United States Jul 2014 - Jul 2014 | |||
Jan 2014 135000 mi US $3500 |
transmission failed on trip 130 miles from home; OD dropped and by the time it was picked up for tow; 4th gear had dropped. When vehicle went into shop for transmission repair I was explaining a noise I had hear the previous Sunday. Per repair shop it was timing belt. After doing research decided not to repair as it was VERY labor intensive for $1500 quote |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in Florida, United States Sep 2010 - Aug 2011 | |||
Aug 2011 70000 mi |
Little things were broken which were not repaired. Central window switch would not lower or raise rear windows. Driver's seat adjustment handles broke off (2, each cheap plastic). |
Ford Explorer in Iowa, United States Jul 2009 - Apr 2016 | |||
Jul 2010 53000 mi US $138 |
leaking radiator | ||
Jan 2012 64000 mi US $475 |
Alternator and battery replaced | ||
Dec 2015 85000 mi US $120 |
Replaced both links on front sway bar. |
Ford Explorer in Maryland, United States Oct 2013 - Aug 2015 | |||
May 2014 96300 mi US $657 |
Problems with alignment. 1) Replace both front lower ball joints. 2) Alignment 3 Oil change | ||
Jun 2014 96000 mi US $483 |
Problems with alignment, Replace right rear bub bearing D.R Out tie rod | ||
Jan 2015 95700 mi US $3900 |
Alignment issues. Was told I needed upper and lower ball joints, tie rods and the rear differential needed to be replaced | ||
Feb 2015 98400 mi |
rear differncial leaking car pulled and vibrated in the front end. Upper and Lower ball joints were replaced. |
Ford Explorer in Indiana, United States Dec 2010 - Mar 2011 | |||
Mar 2011 78000 mi US $123 |
rt wheel cylinder was dripping bad |
Ford Explorer in Michigan, United States Jul 2015 - Nov 2015 | |||
Oct 2015 123000 mi US $3000 |
I could hear a loud grinding noise from he back of the Explorer. Differential failing. |
Ford Explorer in New York, United States Jun 2011 - Apr 2013 | |||
Jul 2011 60300 mi US $100 |
R/R RH hub bearing. Covered by extended warranty | ||
Apr 2013 75000 mi US $100 |
front hub bearing |
Ford Explorer in New Jersey, United States Mar 2011 - Jul 2022 | |||
Sep 2014 86000 mi US $300 |
Replaced leaking radiator | ||
Jun 2015 89000 mi US $400 |
Cv boot ball joints | ||
Mar 2016 96000 mi US $550 |
Coolant inlet fitting contains (or is made of)plastic which failed. | ||
May 2016 96300 mi US $500 |
ticking noise when rear a/c blower is on. Replaced blower assembly part. | ||
Jun 2017 98000 mi US $500 |
left rear wheel bearing replace | ||
Dec 2017 99000 mi US $450 |
replace right front wheel bearing |
Ford Explorer in California, United States Dec 2010 - Mar 2015 | |||
Jan 2011 60000 mi US $700 |
Vehicle went in for 60k maint. Discovered leaking water pump - warranty repair. Also had prob with cruise. Part ordered and prob. fixed. Battery failed - was nearly 6 yrs old. | ||
Sep 2011 66000 mi US $150 |
Cruise control again, would go off after being set. Left rear window will not operate. $250+ to repair. Will live with it for now. At least it is stuck in the up position. | ||
Mar 2012 71000 mi |
Left rear window would not operate from the driver's console or the left rear door control. Then the right rear window stopped working. In March, I tried the windows and both are now working. Not the motor as dealer had diagnosed. | ||
Sep 2013 88000 mi US $300 |
Wheel bearings for left front hub on 4-wheel drive needed replacing. |
Ford Explorer in Texas, United States Nov 2008 - Mar 2010 | |||
Dec 2008 24000 mi |
Rear door on passenger side would not open. Inside and outside handles had no effect. Door locks cycled (many times) would eventually get door open. | ||
Apr 2009 31000 mi |
Slow engagement into reverse. Intermediate band found to be burnt, valve body out of tolerance. Replace bad parts, rebuild transmission and flush system. Radiator also failed (side tank leak) and was replaced |
Ford Explorer in Panama Feb 2011 - Jan 2013 | |||
Sep 2011 53320 mi US $150 |
Front hub wheel bearings needed replacement. |
Ford Explorer in Alabama, United States Apr 2013 - May 2013 | |||
May 2013 90000 mi US $1800 |
Transmission needed to be rebuilt |
Ford Explorer in New Jersey, United States Sep 2009 - Dec 2011 | |||
Jul 2010 86000 mi US $400 |
fuel injection clog | ||
Aug 2010 87200 mi US $347 |
bearings in the wheel needed to be replaced |
Ford Explorer in Pennsylvania, United States Dec 2008 - Feb 2013 | |||
May 2009 52000 mi US $100 |
ball joints on drivers side | ||
Jun 2009 52000 mi US $200 |
EGR valve was replaced due to computer sensor problem. A previous design where there are two chips and the EGR valve would have worked just as well and been cheaper to repair by at least a $120.00. Ford does not have a better idea. | ||
Sep 2011 68000 mi US $500 |
new fuel pump and filter. shocks front, spring stiffeners all around, upper/lower ball joints left side. | ||
Nov 2011 69000 mi US $180 |
upper and lower ball joint drivers side. | ||
Jun 2012 75000 mi |
THE CAR HAS A BAD REAR BEARING...HOWEVER WHILE IT COULD BE EVEN BY THE TECH IT WAS DECIDED UNTIL IT BECAME WORSE TO LEAVE IT ALONE. IT IS BECOMING LOUDER SO I AM CERTAIN THIS WILL BE REPLACED AS I FIRST THOUGHT. THIS HAS BEEN A GOOD TRUCK | ||
Feb 2013 78000 mi |
Somehow the noise in the rear axle worked itself out. |
Ford Explorer in Connecticut, United States Oct 2010 - Apr 2012 | |||
Dec 2010 58000 mi US $150 |
Sunroof mounting bracket was improperly isolated. Caused loud rattle from metal hitting metal. Shop had to drop the headliner and put some foam rubber between the sunroof support bracket and the roof. 3 hour repair, $150 cost. | ||
Nov 2011 66800 mi |
Alternator replaced. Above 3500 RPM I was getting “check charging system” and the voltage would dropped. I had it load tested and it failed. Getting worse every week. | ||
Jan 2012 68000 mi US $40 |
Replaced belt tensioner and idler pulley | ||
Apr 2012 71000 mi |
Replacement alternator failed. Replaced under part warranty by self. |
Ford Explorer in Kentucky, United States Aug 2015 - Sep 2015 | |||
Aug 2015 64000 mi US $365 |
All interior electrical systems including dome lights, radio, tach, etc were all out. Despite this, the headlights and exterior lights worked. |
Ford Explorer in Oregon, United States Aug 2010 - Feb 2016 | |||
Oct 2010 55000 mi US $195 |
Transmission rebuilt, my cost $195 ("lubricated parts" covered under 6 month, 6k mile limited warranty). | ||
Jul 2011 61000 mi US $160 |
Thermostat housing cracked open at seam | ||
Jun 2012 70000 mi US $850 |
Split radiator | ||
May 2013 79000 mi US $530 |
Left rear wheel bearing replaced due to "growling" noise | ||
Jun 2013 82000 mi |
Battery went completely dead for no reason. After a full charge "check ADVTRAC" notice appears. Can't clear message | ||
Aug 2013 84600 mi US $55 |
ABS module needed to be reflashed to turn off Advance Track light | ||
Aug 2014 96400 mi US $560 |
Replaced radiator. Slow leak at the tank seam. | ||
Oct 2015 109700 mi |
Replaced leaking radiator |
Ford Explorer in Ontario, Canada May 2015 - Dec 2015 | |||
Oct 2015 170500 mi C $950 |
Parts replaced. (tie-rod) Parts replaced (wheel bearing) |
Ford Explorer in British Columbia, Canada Mar 2011 - Oct 2016 | |||
Apr 2011 59200 mi C $175 |
Fan belt squeeked. Needed to replace belt and tension adjuster | ||
Apr 2012 67780 mi C $3000 |
Transmission would not engage immediately when shifted into reverse OR drive from PARK. When it did engage it would jolt. |
Ford Explorer in Michigan, United States Nov 2008 - Sep 2013 | |||
Jul 2008 42000 mi |
replaced fuel pump and gauge assembly - repaired under extended warranty | ||
Feb 2012 73900 mi US $120 |
thermostat replaced | ||
Apr 2013 78200 mi US $2165 |
rear differential replaced two front ball joints replaced |
Ford Explorer in British Columbia, Canada May 2010 - Jan 2017 | |||
Mar 2013 122140 mi C $450 |
Cat Converter | ||
Feb 2015 153140 mi C $65 |
Blend Door Actuator needs to be replaced | ||
Mar 2015 153760 mi C $2500 |
Unsure of parts - but my Check Engine Light came on and "Check Transmission" displayed on console. Per Mechanic - I had lost 2nd and 5th gear, with my reverse gear almost at failue. | ||
Sep 2016 169260 mi C $100 |
Suspension issue |
Ford Explorer in New Hampshire, United States Nov 2008 - Mar 2010 | |||
Dec 2008 55000 mi |
Strut cartridge failure on back left wheel caused a loud thumping sound to enter the cabin when traveling over road irregularities. Fixed under extended warranty. |
Engine not specified
Ford Explorer in Indiana, United States Oct 2013 - Oct 2014 | |||
Aug 2014 82900 mi US $900 |
The front wheel bearings were replaced, but the vibration persists. The technician was unable to successfully find the problem. |
Ford Explorer in Michigan, United States Dec 2013 - Dec 2014 | |||
Dec 2014 192000 mi |
Loud rhythmic whirring sound coming from the rear end of the truck. |
Ford Explorer in Alabama, United States Dec 2010 - Jul 2013 | |||
Dec 2011 89000 mi |
The right rear main axle seal on the Ford explorer xls is leaking oil. Not yet fixed. | ||
Jul 2012 92000 mi US $25 |
From previous rear axel leak, I changed the rear axel oil with w-mart 85-140 synthetic, added 4 ounces tranny stop leak and the LS additive. Rear end has stopped leaking and is much quieter. 92,000 miles |
Ford Explorer in Indiana, United States Mar 2014 - Mar 2014 | |||
Mar 2014 106000 mi US $30 |
EGR value was bad and had to be replaced |
Ford Explorer in South Carolina, United States Apr 2014 - Apr 2014 | |||
Apr 2014 219000 mi US $40000 |
The transmission went out. The car will not shift in reverse or go out of first gear. |
239-horsepower 4.6L V8 5-speed automatic RWD
Ford Explorer in South Carolina, United States Jun 2016 - May 2018 | |||
Aug 2016 112000 mi US $300 |
Leak in cooling system | ||
Oct 2016 115300 mi US $450 |
Replaced both rear wheel bearings | ||
Apr 2017 120000 mi US $500 |
Diverter flaps broken. Removed broken diverters and replaced then. |
Ford Explorer in Arizona, United States Mar 2014 - Jan 2015 | |||
Jan 2015 118000 mi US $2200 |
Oil filter adapter gasket leaking. Manifold hose leak, and actuator door broken. |
Ford Explorer in Virginia, United States - Dec 2007 | |||
Dec 2007 30000 mi |
I had a problem with the limited slip differential package. The vehicle was still under warranty so it cost me nothing. |
Ford Explorer in Jalisco, Mexico Oct 2015 - Jun 2018 | |||
Jan 2017 48560 mi |
Replaced driveshaft and U-joint. Someone had tried to make an inexpensive repair in the past by installing a stainless steel clamp with built in screw for tightening around the u-joint boot. | ||
Jul 2017 49600 mi |
Drive shaft vibration at 100 k/h (60 MPH)---though not as bad as before replacement. Apparently this is a problem with this model Ford. Live with it and trade for another vehicle. |
239-horsepower 4.6L V8 5-speed automatic AWD
Ford Explorer in Michigan, United States Nov 2008 - Jun 2016 | |||
Jan 2008 14000 mi |
ABS sensor | ||
Aug 2014 109300 mi US $800 |
Defroster vent |
239-horsepower 4.6L V8 5-speed automatic 4WD w/low range
Ford Explorer in California, United States Sep 2012 - Mar 2014 | |||
Aug 2012 94600 mi US $3040 |
A belt in the transmission broke, which required a complete rebuild. | ||
Mar 2014 105000 mi US $1600 |
Starter failed, and the flywheel had to be replaced as well. |
Ford Explorer in Ontario, Canada - May 2009 | |||
May 2009 88040 mi C $718 |
Short in wire harness leading to fuel pump. Harness cost $28 CDN. Remaining cost, diagnoses and labour. |
Ford Explorer in North Carolina, United States Apr 2011 - Jun 2018 | |||
May 2011 35000 mi |
Pump seal on the transmission replaced under dealer warranty. |
Ford Explorer in Michigan, United States Sep 2008 - Jun 2015 | |||
Mar 2014 93000 mi US $500 |
Front sway bar links Cat back exhaust |
Ford Explorer in Missouri, United States Jan 2013 - Mar 2018 | |||
Jun 2013 184000 mi US $40 |
Recharge | ||
Dec 2014 184000 mi US $1500 |
Changed CV joint Repaired transmission | ||
Apr 2015 184200 mi US $600 |
Charged ac There was also a new front end tie rod and ball joint installed. | ||
Apr 2016 189300 mi US $175 |
New oil filter housing | ||
Apr 2017 198000 mi US $50 |
Replaced blend door actuator | ||
May 2017 198000 mi US $60 |
Replace blend actuator |
Ford Explorer in Wisconsin, United States May 2016 - Jun 2021 | |||
Jun 2018 124000 mi US $185 |
Replace 2 fan belt idler pulleys |
Ford Explorer in Pennsylvania, United States Jun 2017 - Jun 2018 | |||
Oct 2017 149000 mi US $90 |
Replaced left rear CV Axle | ||
Jan 2018 161 mi US $35 |
Replaced two failed idler pullies | ||
Jun 2018 176000 mi US $10 |
Oil filter housing gasket |
210-horsepower 4.0L V6 5-speed automatic RWD
Ford Explorer in Wisconsin, United States Aug 2010 - Jun 2011 | |||
Sep 2010 95000 mi US $5300 |
The car was shaking at idle. |
Ford Explorer in Georgia, United States Jan 2013 - Oct 2014 | |||
Aug 2013 77300 mi US $100 |
Alternator died. Replaced. | ||
Oct 2013 78200 mi US $270 |
Dirty Solenoids Remove clutch pieces from resevoir Replace Fluid | ||
Feb 2014 85100 mi US $150 |
Thermostat housing cracked. Replace housing. | ||
May 2014 88000 mi |
Battery died | ||
Oct 2014 93000 mi US $20 |
Fuel Pump Relay had to be replaced. |
Ford Explorer in Oklahoma, United States May 2014 - Sep 2015 | |||
Dec 2014 151000 mi US $287 |
Front drivers side wheel bearing went out. Seems to be a common failure. Also discovered the ball joints are bad. Will get them replaced next month. | ||
Feb 2015 153600 mi US $458 |
Passenger side wheel bearing | ||
Aug 2015 161100 mi US $100 |
Alternator went bad | ||
Sep 2015 164000 mi US $160 |
Overheating. Replaced water pump and thermostat. |
Ford Explorer in Florida, United States Aug 2010 - Sep 2016 | |||
Sep 2011 70000 mi US $200 |
THERMOSTAT HOUSING LEAKED | ||
Feb 2013 76300 mi |
radio volume broke | ||
Jul 2014 82000 mi US $230 |
tie ends for sway bars | ||
Oct 2014 82200 mi US $750 |
upper and lower ball joints |
Ford Explorer in Alabama, United States Dec 2010 - Jan 2011 | |||
Jan 2011 104000 mi US $400 |
replaced right rear wheel bearing |
210-horsepower 4.0L V6 5-speed automatic AWD
Ford Explorer in West Virginia, United States Dec 2009 - Jun 2011 | |||
Jan 2010 61400 mi US $200 |
replaced intake manifold twice under warranty with $100 per visit |
Ford Explorer in Maryland, United States Sep 2013 - Mar 2014 | |||
Nov 2013 127000 mi US $1200 |
Replaced the The ball joints. | ||
Feb 2014 128000 mi US $400 |
The backup warning system was not working. wiring and speaker replaced. |
Ford Explorer in Iowa, United States Oct 2008 - Jun 2014 | |||
May 2011 108000 mi |
All 4 wheel bearings were replaced along with back brake pads |
Ford Explorer in Connecticut, United States Jun 2009 - Jun 2011 | |||
Apr 2009 71000 mi US $800 |
Replaced rear axle (limited slip) for the second time under warranty. ALso replaced radio subwoofer, and front wheel bearing. | ||
Jul 2009 80000 mi US $4300 |
Replaced transmission. I had reported hard shifting and other transmission problemds to Ford since the vehicle was new but they did not fix it. After the factory extended warranty (75K miles) ran out, the transmission failed entirely. | ||
Aug 2010 106300 mi US $200 |
The rear limited-slip differential started chattering again on slight turns. It has done this repeatedly since delivery. The temporary "fix" is to replace the rear lube with new 140W synthetic lube and add the special XL3 friction modifier. | ||
Nov 2010 108000 mi US $50 |
Replaced bad tire pressure warning sensor inside the tire/wheel assy. They have a long life (5 yr) battery, but that wasn't the problem. Road Salt had corroded the metal cap that screws on to the metal stem to add air to the tire. Junk. Replaced bad tire pressure warning sensor inside the tire/wheel assy. They have a long life (5 yr) battery, but that wasn't the problem. Road Salt had corroded the metal cap that screws on to the metal stem to add air to the tire. Junk. |
Ford Explorer in Washington, United States Nov 2010 - Jun 2011 | |||
Jun 2011 64000 mi |
First, backup sensors stopped working. Then engine idle was very rough, diagnosed as failure of manifold gaskets, common for this year of truck. |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in Quebec, Canada Jun 2013 - Jun 2014 | |||
Jun 2014 172980 mi C $100 |
Leake from the rear axel oil seal i have change the oil seal |
Ford Explorer in North Carolina, United States May 2012 - Apr 2018 | |||
Jun 2014 80000 mi US $100 |
Oxygen sensor at the back of the catalytic converter had to be replaced | ||
Oct 2014 83700 mi US $514 |
Replaced alternator and battery | ||
Jun 2015 89000 mi US $900 |
Worn rear wheel bearings have been causing roaring noise for about 1 year. Shop assured me there was no rush to get this done. Decided it was time to fix. New wheel bearings and one new axle because heat generated seized hub to axle. | ||
Jan 2017 88700 mi US $290 |
Replace serpentine belt and pulley tensioner kit | ||
Jun 2017 98000 mi US $1300 |
Replaced thermostat body to correct coolant leak Front Struts Replaced due to wear |
Ford Explorer in New York, United States Jan 2014 - Feb 2015 | |||
Mar 2014 109000 mi US $20 |
front pinion seal was found leaking, removed and replaced seal and refilled with oil | ||
Aug 2014 121000 mi US $100 |
freeplay in right rear trailing arm removed and replaced |
Ford Explorer in Indiana, United States Dec 2008 - Dec 2010 | |||
Oct 2010 131000 mi US $1000 |
Gear (or sprocket?) at the head of the drive shaft was severely damaged requiring immediate replacement. |
Ford Explorer in North Carolina, United States Mar 2013 - Jun 2014 | |||
Apr 2013 86500 mi |
Emission system was causing rough transmission shifting. system cleaned and trouble went away. |
Ford Explorer in Maryland, United States Jan 2010 - May 2011 | |||
Oct 2010 138000 mi US $1500 |
Replace upper and lower ball joints. During same visit I had brakes replaced, all 4 and an alignment. Front left bearing replaced. The rear wheel bearings are making noise but not recommended to replace them until they get worse. Replaced left front wheel bearing. Also got new Fireston Destination Tires and new brakes. Car now makes a road whirring sound from 35 mph to 45 mph. Had differentials and transfer case drained and refilled including friction modifier. | ||
Dec 2010 138000 mi US $845 |
Replaced alternator and emergency brake shoes. | ||
Feb 2011 138000 mi US $2300 |
Replace rear differential |
Ford Explorer in Pennsylvania, United States Mar 2011 - Sep 2016 | |||
Oct 2013 58300 mi US $200 |
abs warning light on abs sensor bad.... | ||
Sep 2014 65000 mi US $15 |
A/C recharge previously taken to another garage who did not repair it. replace blend door replaced plugs replaced upper radiator hose...it was swelled in two places. | ||
Jan 2015 61500 mi US $25 |
Front differential seal leaking. Added grease will replace when warmer In line Heater valve not opening fully. Some heat but not much. Replace heater valve, flush out heater core, top off anti freeze. | ||
Sep 2016 83000 mi |
Air conditioner required repair. Total around $1,500 for this and brakes. |
Ford Explorer in California, United States Jun 2013 - Sep 2014 | |||
Sep 2014 140000 mi US $180 |
Radiator leaked and had to replace. |
Ford Explorer in Wisconsin, United States Nov 2010 - Jul 2019 | |||
Sep 2011 97000 mi US $178 |
Bad bearings Heater Blend motor broken, had to disassemble dash to access it | ||
Apr 2013 119700 mi US $105 |
Front axle seal and rear bearing rear hatch hinges replaced | ||
Apr 2014 136300 mi US $600 |
bearing with sensor built in replaced | ||
May 2015 156000 mi US $1050 |
Differential carrier bearing failed. Replaced all bearings and seals in differential | ||
Oct 2015 158800 mi US $68 |
Thermostat housing was leaking and ultimately was replaced | ||
Oct 2017 187000 mi |
Spring came loose in parking brake, causing squeak in brakes, removed it | ||
Dec 2017 191000 mi US $7 |
Tail light burnt out. just two screws, maybe five minutes. |
Ford Explorer in New York, United States Jul 2012 - Sep 2012 | |||
Aug 2012 80000 mi US $110 |
Rear U-Joint replacement. Only lessened shudder / chatter from rear end. Shop said probably also needed a new differential, though outright failure could be years away. | ||
Sep 2012 80000 mi |
Shudder / chatter from rear. Needed a new exhaust system (or at least some new pipes/clamps). |
Ford Explorer in Virginia, United States Dec 2015 - Jan 2017 | |||
Jan 2017 195000 mi US $1500 |
Computer died and needed to be replaced. |
Ford Explorer in Massachusetts, United States Dec 2015 - Jul 2020 | |||
May 2017 136000 mi US $79 |
replaced blower motor | ||
Feb 2018 144000 mi US $80 |
Drivers side front window motor Replaced window regulator and motor assembly |
Ford Explorer in Ecuador Jan 2014 - Jul 2015 | |||
Aug 2014 80600 mi US $324 |
Fuel sensor wasn't working, it had to be changed. |
Ford Explorer in North Carolina, United States Jan 2016 - Feb 2016 | |||
Feb 2016 133000 mi US $200 |
Had to replace starter |
Ford Explorer in Kentucky, United States Sep 2009 - May 2018 | |||
May 2010 80000 mi US $180 |
Front Pinion Seal Replaced (Leaking). Also had Rear differential oil replaced (Maintenance) | ||
Oct 2010 85500 mi US $700 |
Rear wheel bearings howling - New bearings installed, TSB. Rear Differential Seals Leaking - New Seals installed, TSB. | ||
Jun 2011 92000 mi US $20 |
"creaking" sound when going over speed bumps. Replaced front sway bar bushings with aftermarket ones that could be lubricated via grease gun | ||
Jul 2012 107000 mi US $250 |
Rt wheel bearing found loose during brake pad replacement Found upper ball joint boot cracked on RT side. Replaced Ball Joint | ||
Jan 2013 91700 mi US $150 |
Car would not turn over when attempting to start | ||
Jun 2013 114000 mi US $60 |
Rough idle and hesitation. Replaced ignition wires | ||
Oct 2013 115000 mi US $50 |
Replaced left upper ball joint | ||
Dec 2013 120000 mi US $115 |
Replaced serpentine belt, idler pulley and belt tensioner. | ||
Feb 2014 122900 mi US $250 |
Left front wheel bearing making noise. Replaced wheel bearing assembly. Left upper ball joint boot split. Replaced left upper control arm (with ball joint) Clicking noise from underneath dash when temp control moved out of Cold position. Replaced blend door actuator | ||
Jul 2014 131200 mi |
Noise coming from left front brake when backing up and applying the brakes. Found caliper mounting bolts loose. | ||
Aug 2014 133000 mi US $50 |
Power steering pump leaking. Replaced Power steering pump with aftermarket refurbished unit. | ||
Oct 2014 135800 mi US $200 |
Replaced upper control arm and lower ball joint and had four wheel alignment | ||
Aug 2015 151400 mi US $200 |
RT front brake caliper siezed. Replaced both calipers, disks and pads | ||
Sep 2016 174000 mi US $200 |
Battery light and ABS light on. Alternator died and drained battery. Based on age of battery (4 Yrs) elected to replace battery as well as replaced alternator | ||
Aug 2017 192000 mi US $350 |
Exhaust resonator had a hole making noises when engine was run. Due to vehicle age complete exhaust system replaced aft of catalytic converter | ||
Nov 2017 196000 mi US $200 |
Check engine light with P2106 and P2135. Reset and issue came back with stalling and other codes related to Throttle Body Actuator and Throttle position sensor. Replaced Throttle Body with aftermarket part. P2106 and P2135 codes came back. Replaced Throttle Position Sensor with Motorcraft part. Issue resolved. | ||
Dec 2017 196000 mi US $35 |
Headlight burned out. Replaced both bulbs with Silverstar Ultra Halogen bulbs (9006) | ||
May 2018 200000 mi US $95 |
P0401 code. EGR insufficient flow. Replaced EGR valve |
Ford Explorer in Wisconsin, United States Jun 2011 - Jun 2012 | |||
Nov 2011 98900 mi US $3200 |
Transmission completely inoperable. Sway bar connecting links broken, repaired by owner |
6-cylinder automatic 2WD
Ford Explorer in Florida, United States Feb 2012 - Oct 2013 | |||
Oct 2012 82000 mi US $870 |
Brake repair, specifics not known. | ||
Jul 2013 93700 mi US $1255 |
Replace front wheel bearings and ball joints |
Engine not specified
Ford Explorer in New Jersey, United States Sep 2014 - Oct 2014 | |||
Oct 2014 92000 mi |
after reversing out of driveway would not shift into gear |
239-horsepower 4.6L V8 5-speed automatic AWD
Ford Explorer in Missouri, United States Aug 2010 - Jun 2011 | |||
Sep 2010 94000 mi US $302 |
air sensor |
239-horsepower 4.6L V8 5-speed automatic 4WD w/low range
Ford Explorer in Ohio, United States Aug 2008 - Jul 2013 | |||
Jan 2008 54111 mi US $38 |
Blew out blocked moonroof drains, replaced parking sensors, lubricated driver's "door ajar" switch | ||
Sep 2008 54111 mi |
Replace rear parking sensors. Lubricate door latch switches. Replace glovebox light assembly. Cleared sunroof drain lines Blew out blocked moonroof drains | ||
Oct 2008 56000 mi US $340 |
Left front wheel bearing hub assembly failing, replaced both front wheel bearing hub assemblies | ||
Jun 2009 67000 mi US $60 |
Multi-function (turn signal) switch failed, replaced with OEM part. | ||
Jan 2010 77000 mi US $80 |
Idle air control valve replaced to correct rough idle | ||
Sep 2010 88000 mi US $170 |
#3 fuel injector failed and was replaced. Spark plugs also replaced. | ||
Apr 2011 94000 mi US $750 |
Failed drive axle seal | ||
May 2011 95000 mi US $350 |
Replace upper and lower front ball joints, upper control arms due to failed ball joints and rusted control arms | ||
Jun 2012 104000 mi US $150 |
AC refrigerant loss - system sealed and recharged Driver's side blend door actuator failed | ||
Dec 2012 109000 mi US $190 |
Failed tensioner pulley bearings | ||
Feb 2013 112300 mi US $80 |
#3 spark plug shot out of head after threads in head failed. Destroyed #3 coil pack when it happened. Apparently a common problem in 4.6L Triton engine. Driver's seat heat switch failed, replaced switch | ||
May 2013 114000 mi US $180 |
Both front wheel bearing hubs failed, replaced both hubs |
Ford Explorer in Pennsylvania, United States Sep 2007 - Nov 2020 | |||
Oct 2007 44000 mi US $160 |
Broken heat shield on front transfer case. Broken duct vent in dash. | ||
May 2008 52000 mi |
Broken duct vent in dash. Rear window motor replaced. | ||
Apr 2009 62000 mi US $750 |
Left and right front wheel bearings replaced under extended warranty. Transmission problem fixed with computer flash at owner's expense. Pinion seal and rear axle seals replaced under extended warranty. | ||
Feb 2010 74000 mi US $1000 |
Replaced front & rear shocks/springs, replaced upper & lower ball joints. | ||
Dec 2010 83000 mi US $1500 |
Paint on hood was bubbling due to iron contamination in aluminum hood (see TSB 06-25-15 ALUMINUM BODY PANELS - CORROSION). Aluminum hood replaced with steel hood & repainted. Vehicle was beyond paint warranty time frame. | ||
Aug 2011 93000 mi US $200 |
Replaced all 8 ignition coils and spark plugs. | ||
Jun 2012 104000 mi US $400 |
Replaced all seals and fluid in rear differential. | ||
May 2013 116700 mi US $200 |
Replaced rear wheel bearings(Timken). Very difficult to remove old wheel bearings from assemblies; burned them out with a torch. | ||
Feb 2014 124900 mi US $2500 |
Transmission developed major leak while driving. Transmission rebuilt by local transmission specialist. | ||
Sep 2018 151467 mi US $25 |
Replaced rear stabilizer/sway bar links. |
Ford Explorer in Michigan, United States May 2009 - Jun 2011 | |||
Jun 2009 92000 mi US $500 |
Failed wheel bearing w/ damage to hub bearing race. | ||
May 2010 93000 mi |
Heated seats stopped working; turning on rr defrost turned on all interior lights & gave "door ajar" warning. Dealer claimed bad harness to liftgate. $600+ (seriously!) repair was refused. Vehicle returned--issues had disappeared! | ||
Oct 2010 99000 mi US $600 |
Corroded ground: rear defrost, automatic light timeout and heated seats no-op. Heated seats still not functional. |
Ford Explorer in California, United States Feb 2009 - Jul 2010 | |||
Sep 2009 96000 mi |
Air conditioning compressor was in need of replacement- dealership replaced at no charge because I had just purchased it used. | ||
Oct 2009 97200 mi |
Driver's side rear window motor stopped working. Dealership replaced at no charge because it was missed in inspection before I purchased the vehicle. | ||
Jan 2010 101300 mi US $424 |
Paint on roof directly above driver began to peel. Top coat of white paint only, primer underneath was still intact. Ford refused to even consider a repair based on poor paint quality. |
Ford Explorer in Michigan, United States Nov 2004 - Mar 2010 | |||
Apr 2004 5000 mi |
April 2004 A/C no-op. Warranty repair. | ||
Aug 2005 27000 mi |
The following was covered under the Extended Warranty (and was told only because of Ext Warr!): New transmission & cooler. Timing chain rattle. Hood rust (since re-appeared). ECM reprogrammed. | ||
Nov 2006 68000 mi |
Ext'd Warranty: A/C operation intermittent. New control head installed. |
Ford Explorer in Idaho, United States Dec 2008 - Dec 2012 | |||
Jun 2008 42000 mi US $210 |
DPFE - EGR Pressure Sensor IAC - Idle Air Control Sensor both replaced at same time |
Ford Explorer in Colorado, United States Jun 2013 - May 2016 | |||
Dec 2014 175000 mi US $3500 |
Transmission fluid pump died and caused tranny to run dry. | ||
May 2016 188000 mi US $4500 |
One of the bearings disintegrated while towing. Engine is a complete loss. |
Ford Explorer in New South Wales, Australia Nov 2012 - May 2017 | |||
Apr 2017 137020 mi A $275 |
Slow leak in radiator plug. Can wait. Ball joints required to be replaced at next service. |
Ford Explorer in Ontario, Canada Sep 2005 - Jun 2008 | |||
Jan 2005 49600 mi C $2000 |
Don't remember all the dates but the transmission was rebuilt 2x out of warranty and then replaced completely and paid for by Ford Canada & the dealership. Also antilock & reverse sensors repaired 3x in warranty. Heater blower, cruise control and computer | ||
Dec 2007 143840 mi C $465 |
Heater Blower Fan | ||
Apr 2008 154380 mi C $90 |
Wiring harness for windows loose. | ||
Jun 2008 154380 mi C $200 |
New ignition on the steering column since the old one came out with the key |
Ford Explorer in Michigan, United States Jul 2008 - Apr 2010 | |||
Mar 2010 110000 mi US $70 |
Changed alternator |
Ford Explorer in Wisconsin, United States May 2008 - Mar 2010 | |||
Feb 2008 65000 mi US $80 |
Driver's seat heater went out. | ||
Aug 2008 75000 mi US $40 |
Shudders occasionally at about 40mph, since towing with overdrive still on. Think I messed up the transmission a little bit. Mechanic couldn't find anything wrong, advised always locking out overdrive when towing. |
210-horsepower 4.0L V6 5-speed automatic RWD
Ford Explorer in Wisconsin, United States Feb 2017 - Jun 2018 | |||
Oct 2017 135000 mi US $200 |
Transmission servo wore out the case. Replaced with aftermarket o-ringed version. |
Ford Explorer in Puerto Rico Jun 2021 - Jun 2022 | |||
Jun 2022 87000 mi US $1700 |
The whole front suspension was replaced; shocks, springs, control arms, links, ball joints, bushings Rear Knuckle's replaced |
Ford Explorer in Alabama, United States Feb 2015 - Jun 2022 | |||
Jun 2016 181000 mi US $1200 |
Damaged Tie rod end was replaced. Front upper a-frames on both left and right sides were also damaged. | ||
Nov 2016 184000 mi US $100 |
Transmission wouldn't move immediately when put in gear. If you gave it a good amount of throttle, it would jerk into gear, then drove fine. It did this in forward and reverse gears. Got two different opinions and both agreed. Drivers side window power actuator broke. Replaced with aftermarket part. Rear hatch window actuator cable failed. Replaced with OEM part. Rear stabilizer bar linkages were broken. Replaced with OEM. | ||
Jul 2017 192000 mi US $250 |
Alternator was bad. Replaced with new one. | ||
Mar 2018 199000 mi US $250 |
There was an engine code that the temperature was not getting to optimal conditions. It ran fine, in fact it's been like that for over a year, but the problem turned out to be the thermostat. While I had a day off, I replaced the spark plugs and wires, air filter and the cruise control switch. | ||
Nov 2021 229000 mi US $300 |
Timing chain cassettes broke. Didn't appear to cause any timing issues at the time we repaired it, it was just very noisy, but was running great. Replaced cassettes, put it all back together, then a few days later it got loud again. Suspect that it jumped time on the drivers side. Have not had time to pull engine again to repair. Besides, it's been cold. |
Ford Explorer in Arizona, United States Nov 2011 - Jun 2016 | |||
Dec 2011 148000 mi US $100 |
leaking water pump |
Ford Explorer in California, United States Jan 2012 - Feb 2012 | |||
Feb 2012 151000 mi US $70 |
Rear A/C blend door not working and constant clicking noise. Plastic part connecting radiator hose to engine failed. |
Ford Explorer in Texas, United States Mar 2010 - Nov 2010 | |||
Apr 2010 107000 mi |
blender door not allowing air conditioner to work properly. due to cost, will fix myself with help of friend. | ||
Jul 2010 111000 mi US $536 |
issue had been previously reported as blender door. was actually fresh air intake assmbly. i believe was damaged by previous dealer work/maintenance. new dealer repaired without issue. |
Ford Explorer in Texas, United States Mar 2013 - Dec 2014 | |||
Dec 2013 178000 mi US $150 |
Thermostat housing cracked leaked coolant. | ||
Mar 2014 180000 mi US $200 |
Upper control Arms/ball joints. |
Ford Explorer in Illinois, United States Jun 2014 - Sep 2016 | |||
Jun 2014 71000 mi US $1 |
Replace Upper Ball Joint | ||
Dec 2015 89000 mi US $775 |
Right and left front wheel bearings with ABS sensors |
210-horsepower 4.0L V6 5-speed automatic AWD
Ford Explorer in New Jersey, United States Sep 2012 - May 2014 | |||
Feb 2012 115000 mi US $2600 |
replaced w/ rebuilt w/ 1 year warranty. work done by trans specialist shop. | ||
Sep 2013 135000 mi US $2000 |
oil pump broke, engine seized. replaced with used engine. 90 day warranty. | ||
Nov 2013 145000 mi US $120 |
both front struts were replaced after the spring on the right front strut cracked. bolt attaching strut to tie arm was rusted and seized. needed to grind bolt out. | ||
Dec 2013 147000 mi US $485 |
wheel bearing worn down and had to be replaced |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in New York, United States Nov 2010 - Sep 2016 | |||
Mar 2011 181000 mi US $90 |
Rear calipers... $90 and did them myself. They were frozen but still working. | ||
Aug 2011 189000 mi US $300 |
Hit a bump in road and front right spring collapsed. Parked for a week while drove Lincoln (waiting for parts) and had replaced at shop. Fairly inexpensive and quick fix | ||
Jul 2012 192000 mi US $360 |
Ford dealer told me eventually would need to repair about 20k ago but not to worry. Last oil change they said it was bad- and it was! They said 450 for repair- told me I could save almost 100 if went to small mechanic shop! thanks! | ||
Mar 2013 199000 mi US $125 |
Door ajar light wont shut off. Drivers door wire severed- common problem and a quick fix once the problem was found. Exhaust replaced | ||
Jul 2013 205800 mi US $160 |
Rear wiper motor burned out. Bought part on ebay for $80, and dealer charged $80 to replace |
Ford Explorer in British Columbia, Canada Sep 2007 - Jul 2010 | |||
Oct 2007 86800 mi C $90 |
Suspension started sqeaking at bumps. Opened and lubricated. | ||
Apr 2009 99200 mi C $701 |
Bearing made noise | ||
Jun 2010 118420 mi C $450 |
Check Engine Light came on. Driver side Oxygen sensor needed to be replace. |
Ford Explorer in Pennsylvania, United States Aug 2009 - Jul 2011 | |||
Sep 2010 86000 mi US $300 |
Replaced rear springs because right side broken. | ||
Apr 2011 89300 mi US $200 |
Cracked rear hatch trim below the lift up glass. Plastic body color trim piece cracking vertically. Mine cracked in 2 places over the period of 2 years, upon second crack, I replaced. bought part online, had painted professionally, I applied. |
Ford Explorer in Wisconsin, United States Apr 2018 - May 2021 | |||
May 2018 137412 mi US $200 |
Both upper ball joints loose, replaced both upper control arms |
Ford Explorer in California, United States Dec 2007 - Sep 2010 | |||
Sep 2007 63000 mi US $110 |
Re-flash computer to resolve surging on deceleration/coast. | ||
Jan 2008 65000 mi US $585 |
Front wheel bearing failed. Had fuel filter and trans filter replaced at same time. Unable to duplicate poor mpg issue. |
Ford Explorer in Indiana, United States Nov 2014 - Jun 2016 | |||
Jun 2016 186000 mi US $750 |
Failed water pump |
Ford Explorer in Indiana, United States Jan 2016 - Feb 2016 | |||
Feb 2016 149000 mi |
Timing chain is going out and rattling - engine needs to be replaced |
Ford Explorer in Minnesota, United States Jan 2016 - Dec 2017 | |||
Mar 2016 146000 mi US $10 |
PCV valve |
Ford Explorer in Ohio, United States Sep 2013 - Oct 2013 | |||
Oct 2013 118000 mi US $450 |
Had Ford kit installed to reduce differential noise Left front wheel hub bearing went bad |
Ford Explorer in Minnesota, United States Dec 2014 - Jul 2016 | |||
Feb 2015 157400 mi US $650 |
Thermostat housing was leaking. Flush coolant, replaced thermostat housing and refilled. | ||
Feb 2016 171000 mi |
Thermostat stuck open. Vehicle wouldn't reach operating temperature. |
Ford Explorer in Washington, United States - Jun 2006 | |||
Jun 2004 32000 mi |
Transmission failed, repaired under warranty | ||
Jun 2006 65000 mi US $100 |
Transmission shift solenoid pack failed. Repaired under certified warranty. |
Ford Explorer in Ontario, Canada Jan 2013 - Feb 2013 | |||
Feb 2013 85560 mi |
upper and lower ball joint replacment for certification right pass window inoperable |
Ford Explorer in Michigan, United States Feb 2009 - Jun 2011 | |||
Apr 2009 72000 mi US $5 |
Upper Control Arm, two new rear coil springs |
Ford Explorer in Michigan, United States Jun 2016 - Jul 2016 | |||
Jul 2016 92000 mi US $400 |
The truck overheated while pulling a trailer. Replaced water pump and thermostat housing (that melted from the heat) |
Ford Explorer in North Carolina, United States Jun 2015 - Nov 2021 | |||
Apr 2017 114000 mi US $281 |
Left wheel bearing making noise. Had it replaced. | ||
Mar 2018 132000 mi US $422 |
Right front bearing replaced | ||
Apr 2018 130000 mi US $770 |
Replaced both rear wheel bearings | ||
May 2018 132000 mi US $40 |
Alignment | ||
Mar 2020 155000 mi US $200 |
Noise from front of truck. I replaced driver side CV axle and bushings. |
Ford Explorer in Connecticut, United States Sep 2006 - Oct 2015 | |||
Mar 2006 43623 mi US $660 |
Front pinion seal leak; Power window (rear) drive/switch replacement. Covered by ESP. | ||
Aug 2007 66900 mi US $2000 |
Rear differential bearings; front sway bar bushings; both front lower ball joints; solenoid pack for the transmission. Covered under ESP plan, $2k was quoted cost w/o plan. | ||
Nov 2007 72000 mi US $100 |
Shifter was difficult to place in park after driving; TSB addressed the problem, part repaired. | ||
Aug 2009 100000 mi US $50 |
Rear spring on the passenger side was broken. | ||
Feb 2011 127000 mi US $600 |
Driver's front wheel bearing, sway bar links. | ||
Nov 2012 154600 mi US $250 |
P0301 CODE REGULARLY SENT, NO RESOLUTION | ||
Jul 2013 165800 mi US $150 |
Thermostat housing cracked | ||
Sep 2013 170000 mi US $630 |
Exhaust noise, needed new muffler Sway bar link broken P0301 code still active Front bushings worn | ||
Dec 2013 173000 mi US $200 |
P0301 code still active, replaced intake gasket and bolts. | ||
Sep 2015 187000 mi US $499 |
Timing chain issue diagnosed with rear chain. $3500 to repair. No repair made. |
Ford Explorer in Oregon, United States Feb 2008 - Mar 2011 | |||
Aug 2009 89000 mi US $400 |
ABS - speed sensor bad. | ||
Mar 2010 94000 mi US $125 |
Blend motor assy replaced. 'click of death' | ||
Jun 2010 96300 mi US $3600 |
Transmission rebuilt with newer 07 -08 parts |
Ford Explorer in British Columbia, Canada Jun 2015 - Jun 2017 | |||
Jun 2016 155000 mi C $150 |
I intermediate band replacement |
8-cylinder automatic 4WD
Ford Explorer in Illinois, United States Oct 2007 - Mar 2010 | |||
Nov 2007 39000 mi |
took 03 explorer to ford dealer for a number of repairs covered under extended warranty with 50.00 deductable.window motor front end boot replaced factory radio door ajar sensor | ||
Dec 2007 40000 mi US $50 |
replaced front rocker arms |
6-cylinder automatic 2WD
Ford Explorer in Illinois, United States Sep 2007 - Dec 2007 | |||
Dec 2007 49000 mi US $100 |
power steering pump leak |
4-cylinder automatic AWD
Ford Explorer in New York, United States May 2009 - Dec 2013 | |||
Jun 2009 89000 mi US $40 |
We hear a rattling noise but dealer could not hear it. | ||
Dec 2013 102000 mi US $225 |
Rear end broke and was leaking fluid. |
Engine not specified
Ford Explorer in Ohio, United States Feb 2010 - Sep 2010 | |||
Mar 2010 83000 mi US $323 |
Replaced worn front struts. | ||
Aug 2010 88000 mi US $2600 |
Bad torque converter. Replaced transmission at transmission shop. |
Ford Explorer in Kentucky, United States Nov 2013 - Jan 2014 | |||
Jan 2014 US $1000 |
Head Gasket leaking oil. Transmission had to be removed to repair. Made it far more costly. |
Ford Explorer in Vermont, United States Oct 2008 - Mar 2010 | |||
Nov 2008 109000 mi US $650 |
Front left wheel bearing replaced. Rear springs and shocks replaced. |
Ford Explorer in Pennsylvania, United States Sep 2011 - Sep 2012 | |||
Nov 2011 131000 mi US $1900 |
Transmission was going for the last three years and finally had to get it rebuilt. Chose this because the trans had lasted this long and worried about an unknown transmission. Still bangs slightly when I back up. |
Ford Explorer in Virginia, United States Sep 2014 - Sep 2014 | |||
Sep 2014 145000 mi US $2500 |
Transmission went out completely at 145,000 miles. Terrible transmission in this car. I am replacing to sell it. |
Ford Explorer in Florida, United States May 2013 - Jun 2013 | |||
Jun 2013 169000 mi US $150 |
There was a crack in the radiator. Was sealed with epoxy material. |
239-horsepower 4.6L V8 5-speed automatic RWD
Ford Explorer in Texas, United States Mar 2011 - Dec 2013 | |||
May 2011 107000 mi US $2200 |
Replaced transmission | ||
Nov 2011 109000 mi US $250 |
Transmission shifting very roughly, had to be rebuilt A/C compressor developed two cracks, entire a/c system had to be replaced Vehicle would not idle when cold, Idle Air Control (IAC) valve replaced. | ||
Jan 2013 122000 mi US $800 |
Intake manifold was leaking coolant at the thermostat housing, needed to be replaced CEL was on, gas cap needed to be replaced | ||
Jun 2013 126000 mi US $110 |
CEL light on, shop indicated gas cap was bad after testing emissions system. 2nd time gas cap had to be replaced in 6 months! | ||
Nov 2013 129000 mi US $150 |
Bypass hose in the back of the engine split, had to be replaced | ||
Dec 2013 129000 mi |
Rear end of the vehicle making loud whining noise above 30 mph, research says might be differential or wheel bearings but had not had it diagnosed at time of sale. |
Ford Explorer in New York, United States Jul 2010 - Jan 2011 | |||
Dec 2010 76000 mi US $1200 |
4x4 not working. discovered in middle of blizzard. after hours of troubleshooting, determined needs new part that may or may not completely fix problem. decided not to throw more money away in this car leaking differential. not worth fixing terrible noise in back wheels every time went over bumps. was shown both rear wheel springs cracked. not worth sinking more money into this car |
239-horsepower 4.6L V8 5-speed automatic 4WD w/low range
Ford Explorer in Illinois, United States Nov 2007 - Apr 2012 | |||
May 2008 102000 mi US $800 |
Air compresser failure. |
Ford Explorer in North Carolina, United States Jan 2013 - Jun 2018 | |||
Jun 2013 107000 mi US $211 |
line from resevoir to brakes rudted thru (live by ocean - everything rusts) | ||
Jan 2015 108500 mi US $641 |
Replace RF hub assembly | ||
Jun 2015 112000 mi US $330 |
Insufficient cooling; recharged system Ambient temp sensor failed. Temp incorrect on display. Replaced sensor. | ||
Sep 2015 113000 mi US $787 |
Front hub assembly | ||
Nov 2015 115000 mi US $20 |
Re-adhere rear view mirror | ||
Jul 2016 113200 mi US $140 |
Dead battery | ||
Jun 2017 121825 mi US $1402 |
Brake shoe replacement 2 Wheel bearing replacements - RR & LR Serpentine belt replaced Differential fluid replaced - Front Warning light - Mass AirFlow Sensor |
Ford Explorer in Michigan, United States Jan 2016 - Jan 2017 | |||
Feb 2016 152500 mi US $20 |
Replaced both front sway bar end links that had broken. | ||
Mar 2016 153000 mi US $120 |
Replaced dead battery. | ||
Nov 2016 158200 mi US $50 |
Rear windshield wiper stopped working. Replaced motor. |
Ford Explorer in Pennsylvania, United States Apr 2010 - Jun 2010 | |||
Jun 2010 175000 mi US $2500 |
Rear differential has made noise since new. Was repaired under warranty few years ago. At 178,000 rear finally went - car barely drivable. Drove to dealer and traded in for new Honda. |
Ford Explorer in Connecticut, United States Sep 2008 - Mar 2010 | |||
Oct 2008 97000 mi |
Replacement of emergency brake light switch. |
Ford Explorer in United Arab Emirates Jan 2009 - Mar 2010 | |||
Mar 2009 34720 mi |
Rear right hand door hinge replaced as found door noisy while opening. |
Ford Explorer in Colorado, United States Aug 2008 - Jul 2011 | |||
Sep 2009 64000 mi US $500 |
Bad left wheel bearing discoverd during mechanic test drive. Noise also noticed by driver, but not confirmed to be wheel bearing. | ||
Oct 2009 65000 mi US $330 |
It was finally determined that the reason my steering wheel wouldn't stay centered was due to a faulty intermediate steering shaft. Now that this has been replaced, the steering feels perfect. Intermediate steering shaft removed and replaced based on diagnosis of loose, off-center steering wheel. This finally resolved the "alignment" issue. | ||
Jan 2010 67000 mi US $965 |
Owner detected tapping noise under left side valve cover cylinder # 6. Dealer diagnosed and replaced lash adjusters, follower and installed new valve cover. The problem is back within less than 1 week so the vehicle is going back in. | ||
Mar 2010 68000 mi |
After multiple trips back to the dealership, the noise persists on the left side and now on the right side. Ford Motor Company representative has recommended new cylinder heads be installed which I'm declining to do at this time given the costs. | ||
Apr 2011 75700 mi US $280 |
Fixed tapping sound in engine myself by replacing lifters on right side. Took far too much of my time, but couldn't have traded the vehicle otherwise. |
Ford Explorer in Massachusetts, United States Jun 2008 - Mar 2010 | |||
Feb 2008 45179 mi US $500 |
Rear Spring fracture. Both rear springs replaced, parts and labor | ||
Jul 2009 53000 mi |
A/C stopped working, tried to charge with kit. Wouldn't hold charge |
Ford Explorer in Pennsylvania, United States Dec 2009 - May 2010 | |||
Mar 2010 106000 mi US $603 |
replaced EGR valve |
Ford Explorer in Ontario, Canada May 2008 - Dec 2010 | |||
Jun 2008 83700 mi C $450 |
Front wheel bearing | ||
Sep 2008 102920 mi C $1000 |
1 front and 1 rear wheel bearing replaced. | ||
Apr 2009 135160 mi C $100 |
Replace broken front sway bar link. | ||
May 2009 140740 mi C $300 |
Replace right front shock absorber. | ||
Nov 2009 169260 mi C $3400 |
Crankshaft bearing spun - engine seized. Engine replaced with used engine from wreckers. | ||
Feb 2010 179180 mi C $3200 |
Transmission failed at 288,000 km. Bores worn, overdrive planetary gear destroyed. Rebuilt. | ||
Mar 2010 185 mi C $450 |
Broken sway bar link on front right suspension Engine misfiring. Replaced all spark plugs. Misfire continued, returned and replaced a coil. Misfire continued, returned a week later and replaced another coil. | ||
Aug 2010 210800 mi C $350 |
Replaced #8 ignition coil. | ||
Dec 2010 220100 mi |
Replaced U-Joints Rear differential failed. Has been howling for 250,000 km and finally died. |
Ford Explorer in Ohio, United States Apr 2011 - Jan 2013 | |||
Jan 2011 105000 mi US $1600 |
4x4 Light flashing. Replaced 4x4 computer module behind glovebox. SRS light on. Dealer replaced seatbelt pretensioner. All wheel bearings replaced. | ||
Jul 2012 115700 mi US $200 |
Replaced two idler pulleys. Replaced belt tensioner. | ||
Oct 2012 117500 mi |
The parking brake had seized. Took it to a mechanic who replaced the parking brake assembly and pads. Brake did not work until I replaced the rear discs. |
Ford Explorer in Indiana, United States Jun 2014 - Jul 2015 | |||
Jul 2015 93000 mi US $24 |
Replaced steel cross brake line between rear wheels and bled system. Old clips were somewhat difficult to reach and they were also rusted so zip ties were used with insulation around lines as a substitute. |
Ford Explorer in Texas, United States Mar 2008 - Jun 2011 | |||
Jun 2009 60000 mi US $25 |
upper and lower front ball joints replaced valve cover seal replaced, leaking oil. |
Ford Explorer in Ontario, Canada Feb 2010 - Mar 2011 | |||
Dec 2010 113460 mi C $2500 |
- Replace four struts - Replace two control arms - Replace two ball joints - Replace sway bars | ||
Mar 2011 116560 mi C $250 |
Replace belt tensioner Replace belt tensioner |
Ford Explorer in Nebraska, United States Dec 2013 - Jan 2015 | |||
Dec 2014 147000 mi US $1500 |
These 5R55S transmissions are junk. It keeps grinding lots of shavings into the pan and the o/d comes on flashing on & off. Then it doesn't want to stay in o/d. It's a sealed trans w/ no dipstick. Wish I could find a rplcmnt unit that came w a dipstick. | ||
Jan 2015 US $800 |
5R55S sealed-up transmissions are a bunch of junk! |
Ford Explorer in New Jersey, United States Jul 2009 - Feb 2010 | |||
Dec 2009 101000 mi US $186 |
replace brake light switch plus rewire |
Ford Explorer in Botswana Oct 2012 - Jun 2018 | |||
Jan 2013 69340 mi $40 |
One rear window hinge broke. Replaced hinge. | ||
Feb 2014 58440 mi $50 |
4X4 selector malfunctioned |
210-horsepower 4.0L V6 5-speed manual 4WD w/low range
Ford Explorer in Massachusetts, United States Feb 2011 - Jun 2012 | |||
Apr 2011 158700 mi US $120 |
Hood latch and cable replaced. Hood would pop up driving on highway or if lifted by hand as though the release had been pulled. Hood didn't completely open. | ||
Aug 2011 164300 mi US $175 |
Rear diff. Pinion seal. |
Ford Explorer in New Mexico, United States Jul 2008 - Jun 2015 | |||
Aug 2010 85000 mi US $600 |
gear failed in transfer case - rear wheels could not drive engine in engine braking mode - also very noisy clutch engagement - so replaced a gear and 2 other small parts in transfer case. | ||
Oct 2012 92000 mi US $1124 |
4wd module in dash failed needed to be replaced power door lock on passenger front door would stick and not unlock | ||
Jul 2014 106700 mi US $700 |
front left wheel bearing froze, broke off end of half-shaft, wheel was held on only by brake caliper |
Ford Explorer in Massachusetts, United States Dec 2008 - Mar 2010 | |||
May 2008 59000 mi US $1200 |
transmission rebuild was told transmission case servo bore worn and needed to be bored an sleeved,bad pressure valve, planitary and input shaft worn and torque converter needed to be replaced | ||
Jan 2009 67000 mi US $2800 |
full transmission rebuild on privious repair they did not bore and sleeve transmission case servo bore or replace pressure valve wich I was told was cause of original failure and the reason for second failure |
Ford Explorer in New Jersey, United States Dec 2012 - Sep 2014 | |||
May 2014 126000 mi US $85 |
Cooling system. Thermostat Housing / Water Outlet cracked, coolant leaking. Replaced unit plus thermostat and temperature sensor. |
210-horsepower 4.0L V6 5-speed automatic RWD
Ford Explorer in South Carolina, United States Dec 2009 - Oct 2011 | |||
Jan 2010 105000 mi US $260 |
went to dealer for speed control recall, discovered power steering pump leak & replaced pump. Car stalled out on left turn, shop cleaned throttle bore and plate, IAC motor. Also replaced serpentine belt, lubed lower control arm bushings in the front. Am really afraid this stupid Explorer will stall out again. | ||
Apr 2010 107000 mi US $125 |
Explorer made loud squeaking noise from front end when driven over speed bumps, problem was bad front stabilizer bar frame bushings - replaced. | ||
Sep 2011 124000 mi US $2100 |
4 oil leaks in the car |
Ford Explorer in California, United States Feb 2011 - Oct 2014 | |||
Mar 2011 154000 mi US $7000 |
car started slipping, jerking and lurching. brake band was discovered broken in half along with most of the gears and plates worn out.Repair shop repaired the transmission by replacing the worn out and broken components. | ||
Dec 2011 162000 mi US $336 |
Coolant leak, hoses and valves needed replacement | ||
May 2012 163000 mi US $700 |
fuel pump died | ||
Dec 2012 173000 mi US $206 |
Heater control valve was leaking. Valve was replaced. | ||
Oct 2014 189000 mi US $1000 |
Replaced leaking radiator and radiator hoses. Replaced valve cover gaskets. |
Ford Explorer in California, United States Sep 2007 - Sep 2012 | |||
Sep 2008 91000 mi US $400 |
Brake master cylinder out. Front driver brakes rattling/noise. | ||
Mar 2009 103000 mi US $2400 |
1st, 2nd and reverse gears were all damaged by a failed pin-bearing in the transmission. A complete overhaul was required. | ||
May 2009 106000 mi |
Rear passenger window regulator broken. I disassembled it myself, the cable was broken and tore up the pulley system. I wedged in a block to hold the window up, will repair it when I want to spend $250 on a new regulator. | ||
Sep 2010 140000 mi |
Past transmission overhaul failed at 40,000 miles. Shop covered the second overhaul for free. | ||
Oct 2011 159800 mi US $60 |
Engine ran fine, dropped off kids at school, then it would not start. AAA came an hour later and it started right up. Mechanic could find nothing wrong. This was one year ago. Same situation again today. I will start with the fuel filter. | ||
Dec 2011 164000 mi |
Keyfob no longer locks or unlocks doors. Factory programmed keypad no longer unlocks doors; however my personal programmed code and the 'lock all' function still work ... ?!! | ||
Aug 2012 176400 mi US $85 |
Rear passenger power window stopped working. Replaced window regulator. |
Ford Explorer in California, United States Nov 2007 - May 2012 | |||
Feb 2008 74000 mi US $264 |
Emission sensor needed replacing. |
Ford Explorer in Indiana, United States Oct 2007 - Sep 2010 | |||
Apr 2008 114000 mi US $500 |
Problem with rear wheel bearings, worn out. | ||
Aug 2008 119000 mi US $900 |
Replace rear end, later fix seal leaks on new rear end. | ||
Oct 2008 122000 mi US $1250 |
Transmission failure, replaced with rebuilt transmission. | ||
Feb 2009 126000 mi US $700 |
The rear wheel bearings were replaced due to completely being worn out (they were smoking and creaking). This was formerly misreported on Truedelta, last year the rear end was replaced. | ||
Jul 2010 142000 mi |
Driver's power window. | ||
Sep 2010 142000 mi |
When sold had some noise coming from the rear end, a high pitched whining sound when accelerating, but we didn't do anything about it. Also some squeaking when driving over bumps at low speeds from the front suspension, but it has done that forever. |
Ford Explorer in Minnesota, United States Apr 2003 - Mar 2010 | |||
Jan 2003 22000 mi |
Back molding on door broke when closing in the cold, was told it's very common for the 02 model | ||
Jan 2004 32000 mi |
rear seal on rear differential | ||
Apr 2004 2400 mi |
rear seal on transfer case leak | ||
Jan 2005 35000 mi |
Rear seal on differential leak | ||
Jan 2006 52000 mi US $250 |
rear seal on differential leak | ||
Jan 2008 20000 mi |
ignition sensor went bad and brought up the check engine light. Sorry not sure which one it was but it was fixed under warranty | ||
Mar 2008 72000 mi US $1250 |
Rear seal on differential leak, noise in rear end. Replaced the bearings in the rear, brakes also and the seal AGAIN!!! Drove home much quieter. Have had a grinding noise in the engine when cold for about 40000 miles, according to forums it's a timi | ||
May 2008 76000 mi US $1200 |
Replaced clutch in rear differential. complained about cruise control, everything checked out and dealer said he couldn't repair it. Still doesn't work | ||
Apr 2009 89000 mi US $350 |
Rear end howling. Was told by dealer couldn't be fixed. It's a factory defect problem and I ended up shimming the pinion in the rear end myself. Rear panel on back tail gate broke for the 4th time since we purchased this vehicle new. I ordered the part and replaced it myself. I am sure It will break again. These things have more problems than I care to mention. | ||
Nov 2009 92000 mi US $100 |
Blew out the water pump. Replaced plugs attempting to stop the grinding noise, do this every 10K miles. Replaced the rear differential oil in an attempt to shut up the rear end which failed. Replaced spark plugs to reduce grinding noise caused by timing chain tensioner, every 10K miles. Also add Sea Foam to oil about 100 miles before changing oil. Real fix would replace tensioner. Replaced the rear differential oil in an attempt to shut up the rear end which failed. |
Ford Explorer in Georgia, United States Dec 2015 - Sep 2016 | |||
Aug 2016 182900 mi US $350 |
Radiator blew |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in New York, United States May 2009 - Aug 2009 | |||
Apr 2009 122000 mi US $5000 |
wheel bearings | ||
Aug 2009 124000 mi |
Needed new wheel bearings. |
Ford Explorer in Alberta, Canada Jun 2015 - May 2016 | |||
May 2016 106020 mi |
Transfer case I'm told was toasted. I think it was/is a culmination of electrical and transfer case and electronics. |
Ford Explorer in Maryland, United States Apr 2014 - Jul 2018 | |||
Jul 2014 121300 mi US $72 |
parking brake cable stuck. | ||
Mar 2016 127000 mi US $569 |
The rear rotors needed replacing and the emergency brake cable and mechanism needed replacing too. | ||
Jun 2016 127000 mi |
system needed 14oz of R134a | ||
Jan 2017 US $50 |
antifreeze leaking from seal under thermostat. Bolts tightened, leak stopped. | ||
Jul 2018 129300 mi US $175 |
dead battery |
Ford Explorer in Vermont, United States Dec 2008 - Oct 2012 | |||
Apr 2010 129500 mi US $1700 |
replaced wheel bearing on right rear | ||
Jun 2010 132000 mi US $800 |
replaced left rear bearing replaced trailer wiring plug transmission shift lever does not always engage drive, or may pop out while driving, but this was not repaired successfully | ||
Feb 2011 138000 mi US $100 |
gauge cluster overheats and needles flail about with reckless abandon after approximately five minutes of run time | ||
Jun 2011 140000 mi US $1450 |
gauge cluster was overheating, sent out for repair, was unable to repair so had to replace with new cluster power windows completely inoperative, door was taken apart and rewired to replace worn wires that were causing a short door ajar light was staying on, as was dome light, regardless of whether the door was open or closed. new door sensor was installed rear wheel bearing was shot, had to be replaced, again. | ||
Jul 2012 151000 mi US $500 |
rear hatch window exploded from going over train tracks | ||
Oct 2012 156000 mi |
bad ball joints broken rear springs rusted floorboards to the point vehicle would not pass state inspection and liquids or gasses could enter pasenger compartment |
Ford Explorer in Virginia, United States Feb 2010 - Mar 2012 | |||
Jun 2010 127000 mi US $687 |
Ford Explorer in Washington, United States Feb 2011 - Oct 2011 | |||
Oct 2011 111000 mi |
Driver side airbag light was on when traded. |
Ford Explorer in Missouri, United States Jan 2003 - Mar 2015 | |||
Mar 2003 5000 mi |
defective tailgate panel replaced under warranty. | ||
May 2007 50000 mi US $50 |
seat belt sensor and air bag sensor. Covered under warranty $50 deductible applies. | ||
Jul 2008 67000 mi US $1000 |
Rear wheel bearings failed due to too much preload. This seems to be a common failure for this vehicle. Ford would not cover it under warranty. | ||
Jun 2010 88000 mi US $380 |
door switch and handle replaced | ||
Feb 2013 110800 mi US $300 |
New coil pack, plugs and wire. | ||
Jul 2013 115500 mi US $780 |
Front wheel bearings making noise when turning. Both wheel hub assemblies replaced. | ||
Dec 2014 125000 mi US $200 |
Window regulator failure. Replaced by new one. | ||
Mar 2015 125000 mi |
transmission started slipping, for sale as-is. |
Ford Explorer in Michigan, United States Jun 2010 - Jul 2015 | |||
Mar 2015 161000 mi US $15 |
starter relay in junction box failed. car would not start | ||
Jul 2015 163000 mi |
starter failed. needed to be replaced. |
Ford Explorer in Virginia, United States Mar 2010 - Jun 2011 | |||
May 2010 102300 mi |
Air Bag Warning light flashes, intermittently comes on and goes off. Problem is in the wiring of the seat belt buckle which cost over $320 not including labor. Also Door Ajar warning light works intermittenly and problem can not be located. |
Ford Explorer in Illinois, United States Mar 2014 - Sep 2015 | |||
May 2014 172000 mi |
Odometer display out. Selling dealer had to send to Ford affiliate, who contracted outside facility to repair PCB. Took 30 days to get car back | ||
Jun 2014 174000 mi US $35 |
Replaced door ajar sensor to get rid of warning lamp; this repair also re-enabled external courtesy lamp timer, autolock, retained accessory power, door chime; eliminated constant 'key in ignition' chime. Replaced outside temperature sensor Replaced DPFE sensor; per SES diagnostic code. | ||
Jul 2014 174300 mi US $300 |
Replaced front axle seal; after looking to see what kind of effort repair would entail, decided to let mechanic fix. | ||
Aug 2014 175100 mi US $365 |
Replaced rear axle seal; had replaced rear differential fluid which leaked out; decided to let mechanic replace the seal. Noted fluid still leaking after seal replacement; would need to take vehicle back to repair again. | ||
Sep 2014 176000 mi |
2nd attempt to R&R rear axle seal; this time, dealer procured revised 1pc assembly and repair seems to be successful - no further leakage noted. |
Ford Explorer in Ohio, United States Apr 2009 - Mar 2011 | |||
Apr 2010 78000 mi US $39 |
EGR sensor failed | ||
Jul 2010 79500 mi US $180 |
Failure of front left Hub. | ||
Mar 2011 84000 mi |
transmission was stuttering and surging nearing failure when traded. another hub was failing when traded. |
Ford Explorer in Michigan, United States Jul 2009 - Jun 2011 | |||
Nov 2009 60000 mi US $272 |
front pinion seal replaced | ||
Dec 2010 61000 mi US $177 |
alternator and battery had to be replaced |
Ford Explorer in Maine, United States Oct 2012 - Oct 2012 | |||
Oct 2012 | All the doorhandles broke off |
Ford Explorer in North Carolina, United States Aug 2009 - Apr 2016 | |||
Mar 2016 166000 mi US $1400 |
Timing chains | ||
Apr 2016 167000 mi US $1875 |
Lost transmission |
Ford Explorer in New York, United States Dec 2012 - Dec 2016 | |||
Jan 2013 139300 mi US $900 |
Transmission failure Failure of fuel control module |
Ford Explorer in Utah, United States May 2016 - Jul 2016 | |||
Jun 2016 174000 mi US $150 |
The pistons had a delay in firing and my husband kept having to fix them one after the other. It is better now |
Ford Explorer in Queensland, Australia Jun 2011 - Sep 2011 | |||
Jul 2011 171740 mi A $2600 |
Vehicle missing replaced 3 x coils still missing, it is a known fault replaced upper bearings & other parts |
Ford Explorer in Kentucky, United States - Aug 2011 | |||
Apr 2011 114000 mi US $400 |
Both rear bearings and seals worn out. Replaced Emergency brake broke damaging rotors. Replaced and repair. |
Ford Explorer in Washington, United States Aug 2011 - Jun 2018 | |||
Oct 2011 92000 mi US $50 |
Windows quit, broken connector. | ||
Jan 2013 100200 mi US $200 |
Door sensor/ Alarm goes off intermittently. | ||
Apr 2014 103000 mi US $1800 |
Broken band, drives but won't shift properly. |
Ford Explorer in New York, United States Nov 2010 - Mar 2012 | |||
Dec 2010 144000 mi US $175 |
Front wheel hubs replaced. | ||
Mar 2011 152000 mi US $210 |
Front driver side control arm replaced. | ||
Jan 2012 163000 mi US $75 |
Replace thermostat. |
Ford Explorer in New York, United States Jun 2009 - Feb 2014 | |||
Aug 2009 72000 mi US $250 |
Replace both rear hub/bearing assemblies. |
Ford Explorer in Alabama, United States Aug 2012 - Mar 2013 | |||
Oct 2012 109000 mi US $300 |
Replace alternator |
Ford Explorer in Pennsylvania, United States Mar 2013 - Jun 2015 | |||
Apr 2013 163000 mi US $1875 |
Rear-end noise checked for excessive noise. Turned out bearings were shot. Rear-end needed complete rebuild. | ||
Jun 2015 173000 mi US $250 |
Explorer developed an accelerated rust-out rate. Last year there were no bodywork holes discovered during safety inspection. Now there is so much rust, car will not pass inspection. |
Ford Explorer in Illinois, United States Jul 2009 - Jun 2017 | |||
Jan 2009 107000 mi |
Over the last 3 years I have paid around $6,500 to repair this truck. Replaced transmission, front and rear wheel bearings, rear seals, differential including gears and bearings and more that I can't remember. Never hit & garage kept. | ||
Aug 2009 65000 mi US $1800 |
Had the differential rebuilt. The 8.8" rearend is notorious for failing, just like the transmission which I had replaced 2 years ago. | ||
Oct 2010 78200 mi US $600 |
I was sitting at a stop light and heard a loud boom from the back of my car. Got out to inspect; my right rear coil spring had snapped in half. Known defect from Ford but they won't pay. This truck is full of defects! | ||
Mar 2017 125000 mi |
I'm on my 3rd transmission now. Dealer had fixed the trans 10 years ago, and it, all of a sudden, started slipping. The transmission has NO dipstick to check the fluid level by the writer fluid level was low and had burned up trans, $5k. So I had the transmission repaired, and within 1k miles the engine timing twnsioner broke and killed the engine. I've owned this car since new. I've personally changed the oil and filter every 3k miles. Now I'm stuck with an Explorer with new tires, trans, brakes, the weird part is that there was no notice that car's engine just died. Oil level full and still clean. |
Ford Explorer in Washington, United States Jun 2009 - Jul 2017 | |||
Mar 2013 176000 mi US $140 |
I replaced the alternator myself at the site it failed so I did not have to have it towed. | ||
Aug 2015 207700 mi US $4000 |
Had to have the transmission completely rebuilt Had to replace radiator. Likely cause by repair shop replacing Heater Control Valve and dropped broken parts into cooling system | ||
Dec 2015 212000 mi US $2100 |
rebuilt rear end replaced wheel beering |
Ford Explorer in Ohio, United States May 2010 - Jun 2011 | |||
Jun 2010 145000 mi US $440 |
Bad valve in transmission at 146K miles OD light flashing |
Ford Explorer in Washington, United States Oct 2014 - Jun 2015 | |||
Jun 2015 126000 mi US $450 |
Valve cover cracked and was leaking oil |
Ford Explorer in Texas, United States May 2010 - Aug 2011 | |||
Oct 2010 158000 mi US $500 |
Leaking thermostat |
6-cylinder automatic 4WD
Ford Explorer in Ontario, Canada Oct 2007 - Sep 2017 | |||
Mar 2008 113460 mi C $290 |
Left rear wheel bearing replaced. |
4-cylinder automatic AWD
Ford Explorer in Texas, United States Jun 2013 - Jul 2013 | |||
Jul 2013 95000 mi US $2200 |
Motor froze. Cause undetermined. Recommended by mechanic to find specialist and replace motor |
210-horsepower 4.0L V6 5-speed automatic RWD
Ford Explorer in California, United States Dec 2015 - Sep 2017 | |||
Apr 2016 150000 mi US $250 |
Plastic thermostat and temp sensor housing leaking on SOHC 4.0 liter German engine wirh two timing belt front and back. New thermostat, housing, sensors and fluid replaced. Radiator was one gallon low due to leak. Leak was slow but constant. Rear hatch handle and lock release broke and required new handle be installed, requirin drilling out rivets on original handle and removal of rear hatch plastic panel to get inside rear hatch to connect to lock release. | ||
Jul 2016 155200 mi |
Shocks were shot including the axle shock = 5 shocks. Tires in front showed wear on outer edges and checked ball joints, they are also shot so that is next! Exploxer would not start on a hill facing wirh front pointing down hill and wirh less than 1 / 4 tank of gas. this is a generic problem as the fuel pump is located in the center of a long fuel tank mounted length wise front to back. | ||
Sep 2016 156000 mi US $35 |
Driver door handle broke on one side, plastic connector broke on back side of door handle which opens door and so made entry not possible. Used Superglue epoxy broken hinge together. |
Ford Explorer in Puerto Rico Jun 2013 - Jun 2014 | |||
Jul 2013 212700 mi US $900 |
Problem with rear suspension. |
Ford Explorer in California, United States Dec 2013 - Apr 2014 | |||
Apr 2014 183000 mi |
Column transmission shifter would not settle into "1". Would also not always settle into "P", resulting in the car being able to roll. If the shifter did not catch into Park, the truck would not start. |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in Missouri, United States Oct 2009 - Dec 2013 | |||
Nov 2009 156000 mi US $500 |
Replaced Valve body in transmission myself. Using knowledge from Explorer forum.com and have driven 1500 miles since and problem hasn't came back. A lot of Explorers see problems as early as 80,000 with regular maint. Mine was an exception. |
Ford Explorer in Ohio, United States Dec 2010 - Aug 2011 | |||
Jul 2011 144000 mi US $200 |
Replaced upper and lower intake manifold gaskets for 2 codes. Right and Left banks running lean. |
Ford Explorer in New Jersey, United States Sep 2012 - Oct 2012 | |||
Oct 2012 116000 mi |
intermittent juttering low rmps .. dealer said it was number two plug was bad said it would cost 670 to repalce plugs wire and coil.. i declined and replaced myself problems still happening. same problem intermittent jutter took to three other shops all said differnt thing had first tech tested fuel pump pressure ok said torque converter. one tech had it for two still no resolution. ready to trade the car in never buying a ford |
Engine not specified
Ford Explorer in New York, United States Aug 2008 - Oct 2008 | |||
Sep 2008 80000 mi |
Leaking head gasket, burning coolant. Quoted $1500, not worth cost of repair. At least one if not more fuel injectors bad, not cost effective coupled with leaking head gasket. |
Ford Explorer in California, United States Mar 2013 - Jun 2014 | |||
Apr 2014 110000 mi US $100 |
Tensioner, idler pully, serp belt radiator |
215-horsepower 5.0L V8 4-speed automatic AWD
Ford Explorer in North Carolina, United States - Feb 2016 | |||
Feb 2016 135000 mi US $250 |
Replaced OEM fuel pump |
Ford Explorer in Indiana, United States Oct 2013 - Jun 2022 | |||
Dec 2014 165000 mi US $250 |
Clock spring in steering is defective. No horn, No drivers airbag, no cruise control. | ||
May 2015 187000 mi US $1000 |
no horn, no cruise control, no washer fluid, no airbag, replaced entire steering column with used. repaired AC with a new condenser. Replaced upper control arm and then had alignment. | ||
Jul 2015 188000 mi US $150 |
Alternator gauge showing discharge, battery light came on. Truck would not start. Used Jump Box to drive to repair shop. | ||
Apr 2018 189000 mi US $300 |
brake line replaced. Had hole in line. | ||
Feb 2022 193000 mi US $800 |
tune up and was running ruff |
Ford Explorer in Michigan, United States Jun 2012 - Sep 2012 | |||
Jul 2012 191700 mi US $75 |
the Universal joint went bad after moving a heavy load. Easy Fix. Quick repair. |
Ford Explorer in Minnesota, United States Oct 2013 - Jan 2015 | |||
Dec 2013 201000 mi US $470 |
Replace Fuel Pump in tank, and fuel filter. Pump failed. | ||
Aug 2014 207600 mi US $30 |
serv engien light, running rought, just put set of new plugs in it and ran ok. also the front left wheel bearing may be failing, makes a growling noise. | ||
Jan 2015 201000 mi |
Growling wheel bearing. |
210-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in Ontario, Canada Dec 2009 - Apr 2012 | |||
Oct 2010 109120 mi C $150 |
Leaking exhaust | ||
Oct 2011 114700 mi C $700 |
Broken tie rod - replaced ball joints and sway bar | ||
Nov 2011 115200 mi C $350 |
Front Bearing |
Ford Explorer in Ontario, Canada Jul 2012 - Aug 2012 | |||
Aug 2012 148800 mi |
Transmission was slipping, especially driving in the city. |
Ford Explorer in Yukon Territory, Canada Jan 2009 - May 2011 | |||
Apr 2009 56420 mi C $450 |
Front driver's side lower ball joint replaced. | ||
Sep 2009 56420 mi C $650 |
Installed both upgraded timing chain tensioners and replaced gaskets | ||
Mar 2010 58280 mi C $700 |
Passenger tie rod replaced Drivers side CV joint broken. Replaced entire axle |
Ford Explorer in Florida, United States Dec 2013 - Nov 2014 | |||
Jan 2014 170000 mi US $120 |
Low voltage light went on, faulty alternator. Repair was easy with three easily accessible bolts. | ||
Apr 2014 172500 mi |
Radiator leaked from transmission cooler, replaced radiator. | ||
May 2014 173000 mi US $360 |
Right front wheel bearing needed to be replaced | ||
Nov 2014 180000 mi US $560 |
Replaced fuel pump. |
Ford Explorer in California, United States Aug 2009 - Jan 2022 | |||
Dec 2010 115000 mi US $500 |
Coolant leakage around the thermostat housing. Housing replaced. Front wheel bearing worn and replaced. Major engine belt replaced due to wear, original belt. Hood shocks would not hold up hood. Shocks replaced. | ||
Dec 2012 127000 mi US $550 |
Back wiper would not work. Indicated it was the motor but it works. | ||
Dec 2013 135000 mi US $600 |
Radiator cracked, was leaking coolant and had to be replaced | ||
Jul 2014 140300 mi US $360 |
Control Arm | ||
Jun 2018 150000 mi |
Replaced electrical motors for electric windows on the left side of the car as both had stopped working. Replaced electric mirror on left side of car which quit functioning when the motor stopped. Whole mirror assembly replaced. |
Ford Explorer in Virginia, United States Aug 2008 - Jan 2015 | |||
Jan 2015 214000 mi US $100 |
Fuel pump failed. |
160-horsepower 4.0L V6 5-speed automatic 4WD w/low range
Ford Explorer in Pennsylvania, United States Feb 2011 - Jul 2013 | |||
Mar 2011 104000 mi US $790 |
DPFE valve shorted out and melted. Used code finder to find problem. Replaced valve and reset code. Good to go. | ||
Apr 2011 104700 mi US $190 |
Engine missing on 2 cylinders. Had vehicle towed. Dealer warranty would not cover cost of new coil pack. It took the dealers garage 4days to repair after originally saying it would be one day. | ||
Jul 2011 108500 mi US $190 |
Engine came on one more time. Replaced another sensor on emission system. Garage mechanic stated the wrong part had previously installed. | ||
Jun 2013 131000 mi |
Heater core leaking. Added stop leak to stop leak and traded vehicle | ||
Jul 2013 131000 mi |
Rear wheels rusted through, rears doors also rusted badly. |
Ford Explorer in Washington, United States Jun 2017 - Jun 2018 | |||
Jan 2017 185000 mi US $2500 |
Transmission rebuild |
Ford Explorer in Pennsylvania, United States Nov 2009 - May 2015 | |||
Jul 2010 193000 mi US $30 |
The engine was overheating. Coolant was running out of the block from behind the alternator mount. Used a chemical block sealer to seal the leak. Car is now running after 30 hours of coolant system flush and repair work. The chemical sealant did not seal the engine block leak successfully. Had to remove the alternator and alternator mount. Found a hole in the head. Used a metal epoxy to repair. Working so far. | ||
Aug 2010 194000 mi US $140 |
Noticed that the battery was losing charge. Tests showed it to be a failed alternator. Bought a new alternator and installed it. Problem solved. | ||
Apr 2012 216000 mi US $2500 |
Hole in the end of the right head opened again and leaked out coolant. Scraped out old epoxy and replaced with new. A new leak in the radiator was repaired with stop leak until a new radiator is put in. Lost 2nd and 4th gear. Took to Earlington transmission who diagnosed a broken 2nd gear band plus other worn parts in the transmission. They rebuilt the transmission. | ||
Aug 2012 220700 mi US $200 |
Replaced the radiator due to a continuing leak. Fixed now. | ||
Sep 2012 223000 mi US $275 |
Had to have driver side lower ball joint replaced. Had to replace sway bar links and shocks on front and rear. Also had to replace the shackles on the rear suspension. | ||
Aug 2014 250000 mi US $20 |
Engine was leaking from the lower intake manifold to header connection on the driver side front. Patched over the leak with epoxy as repairs would cost ten times more than the vehicle is worth. |
8-cylinder automatic AWD
Ford Explorer in Virginia, United States Aug 2008 - Nov 2009 | |||
Dec 2008 97000 mi US $1066 |
Car made roaring sound at speed. Both right and left bearings were bad. Car drives fine now. | ||
May 2009 101000 mi US $1800 |
Replaced upper/lower ball joints. Car is AWD. |
8-cylinder automatic 4WD
Ford Explorer in North Carolina, United States Aug 2008 - Jun 2012 | |||
Sep 2008 107000 mi US $940 |
Both front wheel bearing pack noisy--replaced | ||
Jun 2012 125000 mi US $1100 |
Ball joints |
6-cylinder automatic 4WD
Ford Explorer in Virginia, United States Oct 2009 - Jan 2011 | |||
Nov 2009 146000 mi US $350 |
Had to replace both front wheel bearings. Horrible noise coming from it. Much quieter ride after the replacement. |
6-cylinder automatic 2WD
Ford Explorer in Mississippi, United States Jun 2009 - Mar 2010 | |||
Jul 2009 170000 mi US $411 |
the vehicle lost power and would only accelerate to a speed no greater than 40 MPH. mechanic replaced the intake set and an upper plenum. |
Engine not specified
Ford Explorer in Oregon, United States Jan 2013 - Jul 2013 | |||
Jul 2013 249000 mi |
Engine hot sensor on continually..engine not hot. Overdrive lite on...indicating transmission problem. Too expensive to diagnose. |
Ford Explorer in North Carolina, United States Jun 2012 - Apr 2015 | |||
Jan 2014 136000 mi US $124 |
Battery died due to cold weather. |
Ford Explorer in California, United States Mar 2011 - Apr 2011 | |||
Apr 2011 151000 mi US $500 |
car just sounded wrong-at first planned to drive it till it fell apart- maybe a week later learned it probably needs rear differential rebuilt-parked it. |
8-cylinder automatic 2WD
Ford Explorer in Texas, United States Jun 2018 - Jul 2022 | |||
Mar 2022 101000650 mi US $130 |
neither hood support would hold the hood up |
Ford Explorer in California, United States Nov 2009 - Mar 2014 | |||
Dec 2009 98000 mi US $550 |
warning light on for brakes warning light on for oil pressure | ||
Jun 2012 112000 mi US $41 |
Interior passenger hand grip | ||
May 2013 115900 mi US $800 |
Water pump failed | ||
Mar 2014 119000 mi |
front and back shocks |
Ford Explorer in Wisconsin, United States Oct 2010 - Jun 2011 | |||
Dec 2010 165000 mi US $340 |
Fuel neck had a crack in it. Service engine light on. Would not pass WI emissions |
6-cylinder automatic AWD
Ford Explorer in North Carolina, United States Mar 2011 - Jul 2018 | |||
Mar 2012 168000 mi US $985 |
Needed three complete ball joints replaced. |
6-cylinder automatic 4WD
Ford Explorer in Colorado, United States Aug 2017 - Jan 2019 | |||
Mar 2018 182000 mi US $86 |
Check engine for rich O2 sensor and heater malfunction |
Engine not specified
Ford Explorer in North Carolina, United States Mar 2011 - Jun 2012 | |||
May 2011 195900 mi |
Driver's Window shattered at Bottom. Might have been installed incorrectly by previous owner. Replaced with Window from similar vehicle. | ||
Jan 2012 US $300 |
Old Wheel Bearing caused Vehicle Instability, was replace and Problem Reduced. |
Ford Explorer in North Carolina, United States Dec 2011 - Jun 2013 | |||
Jun 2013 212000 mi US $500 |
Recently rebuilt transfer case failed. Case was removed from vehicle and repaired, and reinstalled. |
8-cylinder automatic AWD
Ford Explorer in Oregon, United States Mar 2011 - Oct 2011 | |||
Apr 2011 148000 mi US $500 |
Ball joints, control arms, tie rod ends, camber cams, shocks all needed replacing. They were original ford OE Stock from when it rolled off show room. Replaced all with aftermarket brands, raybestos, monroe. Parts are superior to OE parts | ||
Oct 2011 154000 mi US $3200 |
Transmission blew 7 bearings, a servo and a band. Oil Can Henries put wrong transmission fluid in. They are refusing to honor damage, so paying out of pocket to repair. |
8-cylinder automatic 2WD
Ford Explorer in Florida, United States Jun 2010 - Jun 2013 | |||
Sep 2010 94000 mi US $600 |
A/C variable motor control module was replaced. Lock function was not working; replaced lock control parts so that lock function would work. Unlock function was always working - it was only the lock function that was broken. Radio Antenna would not power up/down although radio itself was working. Powered radio antenna was replaced. Rear trunk/door latch brushings were replaced and door alignment was done to insure proper closing so that "door open" light wouldn't stay on. | ||
Oct 2010 95000 mi |
Radio lights did not work although radio/Cd/Cassette worked fine. I replaced the entire radio so that you could see the station ID as well as clock time. | ||
Nov 2010 96000 mi US $100 |
AC needed re-charging. O-ring replaced. Work done by Firestone for $100. | ||
Feb 2011 97000 mi US $397 |
A/C was not repaired with o-ring replacement. After additional check, the evaporator was replaced. Oil change/tire rotation and alignment done at same time. All 3 wipers replaced. | ||
Jun 2011 100000 mi US $500 |
Car was taken in for engine light. Diagnosed and repaired two O2 sensors. Oil changed. And wiper connectors were replaced. Tires were replaced at Firestone at separate cost. |
6-cylinder manual 4WD
Ford Explorer in California, United States May 2008 - May 2010 | |||
Dec 2008 158000 mi US $130 |
Radiator and tank leaking. Replaced radiator. | ||
Feb 2009 170000 mi US $200 |
OBDII indicated bad O2 sensor. I replaced all three sensors, and reset the check engine light. | ||
Jun 2009 178000 mi US $224 |
Front wheel bearings noisy. Replaced hub, bearings, seals, ABS sensor as a unit, both sides. Took about 3 hours. |
6-cylinder automatic AWD
Ford Explorer in Minnesota, United States Apr 2009 - Jul 2011 | |||
May 2009 108000 mi US $800 |
Car lost ability to accelerate while I was driving on the highway. I coasted up an exit and called a tow truck. Repair shop couldn't find a smoking gun but replaced a few different things. | ||
Aug 2009 109000 mi US $200 |
AC blowing hot air - had lost all coolant - still don't know if there is a leak or not but I have some cool air now. |
6-cylinder automatic 4WD
Ford Explorer in District of Columbia, United States May 2011 - Jun 2013 | |||
Jun 2011 146000 mi |
Replacement of one catalytic converter. Passed the DC emissions test. | ||
Jul 2011 146700 mi US $400 |
The Exploder was running rough at low idle and the problem became worse as it became harder to maintain speed on the road without frequent accelerator modulation. The 02 sensor had gone back and there was a misfire in cylinders 4,5 and 6. |
Ford Explorer in Ohio, United States Jan 2009 - Jul 2015 | |||
Feb 2009 127000 mi |
Repaired the dim LED issue on radio. Purchased rebuilt powersupply from online vendor. Very satisfied. The first time this happened the radio was repaired under extended warranty. This time I repaired myself for 25% of the cost of a dealership repair. | ||
Aug 2012 127000 mi US $75 |
Speedo and Odometer intermittently stop working. Problem was a bad instrument cluster printed circuit membrance. Replaced cluster with used unit and it works fine. |
6-cylinder automatic 2WD
Ford Explorer in Florida, United States May 2008 - Feb 2010 | |||
Mar 2009 153000 mi US $145 |
Sway bar replaced. |
Engine not specified
Ford Explorer in Alaska, United States Dec 2011 - Jan 2012 | |||
Jan 2012 US $14 |
Drive pulley bearings seized. |
Ford Explorer in California, United States May 2009 - Dec 2009 | |||
Dec 2009 143000 mi |
Rear driver side door lock stuck. |
Ford Explorer in New Hampshire, United States Mar 2012 - Jun 2012 | |||
Apr 2012 158300 mi US $120 |
first bought it and notice it was starting funny like not turning over right away. then it finally just stop working so had to replace it fix it with a new starter started right up again |
8-cylinder automatic AWD
Ford Explorer in New York, United States Apr 2008 - Dec 2008 | |||
May 2008 169000 mi US $1100 |
Front wheel bearings were damaged and causing severe vibration. Valve cover oil leak. Gaskets replaced. 3 sensors replaced. | ||
Jul 2008 175000 mi |
Transmission is begining to slip badly. Not worth repairing. Purchased a new vehicle. |
Ford Explorer in New Jersey, United States Apr 2008 - Mar 2010 | |||
Sep 2009 67000 mi US $600 |
Broken brake line to driver side rear. "Rotted away." Leak also took out brake pads, so they had to be replace even though not fully worn. | ||
Mar 2010 67000 mi US $125 |
broken brake line |
Ford Explorer in Florida, United States Jun 2009 - Nov 2009 | |||
Jul 2009 162000 mi US $280 |
Starter failed, no warning. Attempted to start car with remote start, forgot to turn the key so when I pressed brake to put car in gear, it stalled (safety feature). Upon restart, car wouldn't start. Had to tow to mechanic. |
8-cylinder automatic 2WD
Ford Explorer in New Mexico, United States Apr 2008 - Aug 2009 | |||
Jul 2008 131000 mi US $300 |
Door latch broken, door would not open | ||
Sep 2008 131000 mi US $400 |
Ball joint replacement. | ||
Jul 2009 144000 mi |
Leaking coolant hose Split radiator seam | ||
Aug 2009 144000 mi |
Sold because needed many repairs, including a new ball joint, new suspension (all four wheels)... also needed new A/C seals (had degraded to the point of adding a can of freon every month)... door latch failure... an overhead dome light that would not shut off unless you removed the fuse... and the check engine light was dancing on and off (indicative of the need for a new oxygen sensor ....again). |
6-cylinder manual 4WD
Ford Explorer in Pennsylvania, United States Apr 2008 - Jun 2012 | |||
Jun 2008 248000 mi US $200 |
Electrical cable at starter shorted out, requiring vehicle to be towed to shop. | ||
Aug 2008 251000 mi US $20 |
Leaking power steering fluid. Found leak at steering rack, but decided not to replace, adding "Stop Leak" and replacing fluid, instead. Leak has been greatly reduced or eliminated since then. | ||
Aug 2009 261000 mi US $785 |
Replaced 1st gear synchronizer with used unit. Replaced transfer case (slipping in coast mode) with used unit. | ||
Sep 2009 261000 mi US $320 |
Replaced steering rack with rebuilt unit. Old unit was leaking power steering fluid. | ||
Jan 2010 257000 mi US $350 |
Replaced right front ball joints and muffler clamp. Car was also in for annual inspection, oil service, and TSB on brake switch. | ||
Jan 2011 277000 mi US $292 |
No heat, replaced thermostat Rear spring shackles too rusty to pass inspection, replaced. Also replaced loose front ball joints. Vehicle passed inspection after repairs. | ||
Mar 2011 278000 mi US $40 |
Alternator failed. Replaced with used part. | ||
Feb 2012 285000 mi US $794 |
Replaced left front lower ball joint to pass inspection Replaced cat-back exhaust pipe and muffler to pass inspection |
6-cylinder automatic 4WD
Ford Explorer in California, United States Oct 2010 - Jun 2018 | |||
Mar 2011 88000 mi US $130 |
Engine serpentine belt idler pulley bearing froze, mounting bolt unthreaded itself and it and inner race were lost. New owner-provided belt and new parts installed by dealer in about 2 hrs. Very good, swift repair. | ||
Apr 2012 100500 mi US $125 |
Blender door oh heater/AC unit inop, resulting in no temperature control. | ||
Aug 2017 106000 mi US $100 |
crank speed sensor? |
Ford Explorer in Washington, United States Apr 2010 - Jun 2011 | |||
May 2010 133000 mi US $2100 |
Engine blew a head gasket due to a clogged radiator. I bought a 96K replacement engine and a new radiator. Had my shop install. | ||
Jul 2010 135000 mi US $140 |
Lights,Dash,dimmed and trouble lights came on. Air bag began to beep and engine began to run terrible. Tested Battery,voltage regulator and alternator. Replaced alternator which included a new voltage regulator. Work was done by me. |
Ford Explorer in Maine, United States Apr 2008 - Nov 2009 | |||
May 2008 146000 mi US $750 |
Intake manifold blew and dumped all coolant all over the place. | ||
Jun 2008 150000 mi US $150 |
battery cable clamp corroded through to the point it could no longer hold the battery post and drained the battery to it's doom at the same time |
6-cylinder automatic 2WD
Ford Explorer in California, United States May 2009 - Aug 2009 | |||
Aug 2009 218000 mi |
Check Engine Light on, so failed emissions test. No driveability issues and emissions normal. Diagnois: computer failing to detect position of solenoid in evaporative emissions system. Recommended replace computer, a $1200 part. Decided not to. |
Ford Explorer in California, United States Sep 2008 - Jun 2018 | |||
Jul 2010 140000 mi US $400 |
broken sway bar link | ||
Jun 2011 153000 mi US $800 |
thermostat, serpentine belt, idler pulley | ||
Oct 2011 156700 mi US $10 |
rear hatch not closing, removed hatch, did body work on hinge attachment points re-installed door and replaced tail light bulb (broken by slamming mis-aligned hatch) | ||
Jan 2012 160500 mi US $200 |
Replaced steering rack boot |
Engine not specified
Ford Explorer in Missouri, United States Feb 2011 - Jul 2012 | |||
Sep 2011 177000 mi US $200 |
replaced gaskets |
Ford Explorer in Georgia, United States Oct 2015 - Nov 2016 | |||
Nov 2016 167000 mi US $80 |
Serpentine belt broke after AC clutch seized. Ran hot and triggered fail-safe thermostat to stay open. Replaced belt, thermostat and disconnected power to AC compressor. AC compressor must be emptied and replaced. |
Ford Explorer in Georgia, United States Nov 2010 - Dec 2011 | |||
Dec 2010 143000 mi US $450 |
Replaced driver side front door lock mechanism. Was not working at all. |
8-cylinder automatic AWD
Ford Explorer in Arizona, United States Sep 2011 - Nov 2011 | |||
Nov 2011 161000 mi US $140 |
r&r rt front hub assembly |
Ford Explorer in Florida, United States Nov 2010 - Jun 2012 | |||
Mar 2011 208000 mi US $120 |
Headlight out lamp indicated driver's side headlight not functioning. Replaced bulbs, but light not repaired. Investigated other areas and determined lamp out module failed and switch corroded. Ordered replacement parts, but not installed. | ||
Oct 2011 208000 mi US $100 |
Replaced Lampout module and headlight switch. Discovered old headlight switch corroded and dashboard mount broken. Installed new switch and taped in place. New lampout module did not fix headlight issue. Wiring is the next item to fix. |
6-cylinder automatic 4WD
Ford Explorer in California, United States Jan 2011 - Feb 2016 | |||
Apr 2011 186800 mi US $530 |
Lower ball joints and outer tie rods replaced | ||
Aug 2011 193300 mi US $240 |
Battery dripped acid on fuel regulator beneath battery and created vaccuum leak. easy fix, getting better gas mileage than before problem occured. | ||
Dec 2011 199000 mi US $384 |
Master Cylinder failure - leaking |
Ford Explorer in Pennsylvania, United States Dec 2010 - Sep 2012 | |||
Apr 2011 185000 mi US $30 |
Timing chain cover was leaking coolant. Replaced all gaskets involved. | ||
Sep 2012 191000 mi US $160 |
Replaced fuel pump. The Explorer would not start in my parents driveway. I replaced the fuel pump myself and sold it two weeks later. |