Toyota Sienna in Massachusetts, United States Jan 2009 - Mar 2010
Feb 2009 39000 mi US $2000	Driver side sliding door cable broke and pieces of the door came flying out at me. Repair was unsussessful and car is back at shop.  Also both seat heaters failed.
Mar 2009 41000 mi	Changed brake light bulb. After changing a brake light bulb, van went into shut down mode. Nothing would work and all repair lights came on. Sent to shop and told it was repaired. Brake lights still not working due to missing fuse. Fault of shop.

Toyota Sienna in New Jersey, United States Jul 2012 - Apr 2014
Feb 2013 94400 mi	driver side sliding door can not be remotely lock and unlock.
Apr 2014 95000 mi	the lock of diver side sliding door doesn't work anymore. cost is too much, so give up the attempt to repair.

Toyota Sienna in North Carolina, United States Sep 2012 - Mar 2017
Jan 2013 141500 mi US $350	The cable on the power sliding door unravelled and caused the door to get stuck open. Had to have the motor cable assembly rebuilt.
Sep 2014 165000 mi US $950	Front struts, sway bar ends left front wheel bearing
Jan 2017 191000 mi US $500	Right front wheel bearing Rear driver-side sliding door lock actuator malfunctioned, causing power door to not work with interior button. Took apart and replaced a very small, hard-to-access $10 actuator motor.

Toyota Sienna in Texas, United States Jun 2012 - Jun 2016
Aug 2012 108800 mi	Driver's door check strap weld broken. Repaired by drilling and using a bolt.
Dec 2015 145000 mi	Toyota replaced the dashboard due to cracks and stickyness, at no charge to the owner.

Toyota Sienna in Illinois, United States Oct 2012 - Jan 2013
Nov 2012 114200 mi US $2000	I replaced both struts and both rear shocks. When I purchased the vehicle the tires were showing shock wear.
Jan 2013 115000 mi US $40	The shocks on the rear tail gate would not fully lift the door up. I replaced them both and it works fine now.

Toyota Sienna in Pennsylvania, United States Jun 2012 - Jan 2013
Jan 2013 147000 mi US $160	coolant plug on engine block was leaking

Toyota Sienna in Mississippi, United States Jun 2011 - Jan 2018
Jun 2013 120000 mi US $75	Would not crank, replaced alternator
Jul 2013 120700 mi US $150	Part that controls clutch wouldn't engage
Apr 2014 128300 mi US $550	Shifter replacement
Aug 2017 158350 mi US $45	Freon leaked and leak fixed. Freon recharged

Toyota Sienna in Indiana, United States Feb 2012 - Feb 2014
Dec 2012 128000 mi	Replace crankshaft pulley. No charge, done as recall. The only other non-maintenance repair was the CV joints. They were covered under the extended warrantee that I bought when the van was new.
Feb 2013 130500 mi US $230	Leak in the air conditioner system was repaired and the ac system charged.

Toyota Sienna in New Jersey, United States Feb 2013 - Mar 2013
Mar 2013 108000 mi	have problem with right front tire heel toe wear for over a year dealer replaced bearings and shocks previously. still have abnormal tire wear.

Toyota Sienna in North Carolina, United States Mar 2013 - Jan 2016
Dec 2013 195000 mi US $351	Car was shuddering when turning right, almost like the alignment was off, but I knew it was good. Left front wheel bearing was replaced.
Jun 2014 208000 mi US $275	A/C not working, was recharged following dye test and two valves replaced. Drove ~500 miles and stopped working. Had to be recharged 2Xs more on cross country road trip. Will be taking in for big repair soon.
Jan 2016 249000 mi US $720	Replaced catalytic converter after multiple codes misfired

Toyota Sienna in California, United States Feb 2013 - Oct 2022
Mar 2015 90000 mi US $500	Steering rack developed a leak and had to be replaced.

Toyota Sienna in Wisconsin, United States Jan 2013 - Jun 2016
Jun 2013 130000 mi US $80	AC was working intermittently. AC was 3/4 lbs low.
Sep 2013 140000 mi US $100	Broken A/C Relay switch replacement
Dec 2013 145000 mi US $300	Rear of van made noise and shocks appeared worn. Rear shocks replaced.
Feb 2014 146700 mi	Rear shocks replaced under warranty. Monroe Sensatrack shocks failed twice in 3 months. Shop replaced with KYB shocks, and is now perfect. I paid $40 extra to get the KYB shocks. Well worth the upcharge.
Jan 2015 147500 mi US $50	leaks in exhaust system
Feb 2015 158000 mi US $400	Exhaust leaks. Bad flex pipe.
Nov 2015 171400 mi US $200	Leaking coolant from block heater plug

Toyota Sienna in New Jersey, United States Jan 2012 - Dec 2019
Apr 2014 177300 mi	Sparetire assembly jammed up. Chain would not retrack after replacing tire.
May 2014 177600 mi US $257	Flexible pipe between resonator and catalytic converter
Dec 2014 183000 mi US $700	Lower control arms replaced
Jul 2016 208700 mi	dashboard cracking and dealer replaced
May 2017 225000 mi US $500	Compressor needed to be replaced

Toyota Sienna in Arizona, United States Jan 2013 - Oct 2013
Oct 2013 127000 mi US $300	Front wheel bearing

Toyota Sienna in California, United States Feb 2012 - Apr 2017
Mar 2015 155000 mi US $160	Air-conditioner relay switch failed causing air conditioner to stop working.
Jan 2016 148000 mi US $2000	fluid leak in block
Apr 2017 185000 mi US $800	Wheels out of balance tires damaged and replaced with alignment

Toyota Sienna in Georgia, United States Dec 2011 - Sep 2013
Jan 2012 98100 mi US $2800	Heater would not heat on driver side and they have to replace the heater block. 1500 plus for parts and 1200 for labor. It will require 12 hours for repair. This has been a problem for a year and they have tested it before to find problem
Feb 2012 96000 mi US $890	It was a Heater box problem. The motor that opens and closes the door to the heater box burned out and therefore the foor would not operate. No warm air would go to the driver's side of the car.
Mar 2013 120000 mi	Right rear door was stuck in open position becasue of a piec of plastic that was dropped in the mechanism at last visit. Had to have car towed as could not drive with door wide open. They replaced the mechanism that operates door opening a.

Toyota Sienna in Michigan, United States May 2006 - Nov 2024
Oct 2011 137700 mi US $100	Driver's side door catch was replaced -- was very noisy. Sounded like it had partially failed or was about to fail.
Dec 2011 141000 mi	Steering became increasingly stiff. Lubed the steering gear.
Mar 2012 151000 mi	Steering became increasingly stiff. Lubed the steering universal joint
Apr 2012 154000 mi US $400	Mid steering shaft replaced
Nov 2012 166300 mi	Replace/re-attach door check strap. Was previously attached using rivots which did not hold. This time welded.
Jan 2014 173300 mi US $12	Replace rear shocks and front struts. (An alignment was performed, also) Replaced both headlight bulbs after one burnt out.
Mar 2014 195000 mi US $20	Replaced both turn signals after driver's side burnt out. Driver's side turn signal is very difficult to get to because of tight clearance with fuse box.
Dec 2014 216000 mi	Bolts securing driver's side sliding door rear latch pulled through sheet metal causing it to not latch shut. Replaced with longer bolts and washers, and door latched shut, but will no longer open.
May 2015 226400 mi US $126	Engine block off plate corroded and was leaking coolant. Replaced plate and replaced coolant
Nov 2015 238400 mi US $962	Replace leaky radiator Replace leaky rear shocks
Mar 2016 247000 mi	Cracked and oxidized dash replaced under warranty enhancement program
Jun 2016 250000 mi US $286	Replace exhaust system gasket to repair leak, $70 Diagnose lack of A/C and recharge, $216
Apr 2017 259000 mi US $225	Severed wheel speed sensor wire replaced and factory hitch wiring harness fixed/replaced
May 2019 277000 mi US $355	Replace section of exhaust downstream of catalytic converter Replace belts
Mar 2020 284000 mi US $255	Replace front driver's side wheel bearing
Nov 2020 288000 mi US $686	Replace two brake lines and abs sensor harness connector and flush brake fluid
Nov 2021 296000 mi US $797	Replace front brakes/rotors and rear drum brake shoes Cut and splice weld front flex exhaust
Dec 2021 298000 mi US $40	Replace rear lift gate supports
Aug 2022 304000 mi US $33	Sway bark link (both) replacement. Weld pipe for exhaust Replace front headlight low-beam bulbs after one burned out.
Oct 2023 316000 mi US $420	Replace heater blend door actuator Tighten squealing belt.
Mar 2024 321000 mi US $736	Replaced intermediate exhaust pipe and muffler parking brake adjustment

Toyota Sienna in Alabama, United States Feb 2011 - Dec 2013
Mar 2011 220000 mi US $58	Replaced relay for air conditioning. This was the *first* out of warranty non-maintenance repair for this vehicle!
Aug 2012 270000 mi US $260	Stuck front brake caliper. Replaced timing belt and tensioner under warranty.

Toyota Sienna in Maryland, United States Dec 2010 - Jan 2014
Aug 2013 172400 mi US $300	gasket leak
Nov 2013 173900 mi US $800	replaced catalytic converter

Toyota Sienna in Alberta, Canada Nov 2010 - Mar 2016
Mar 2013 82460 mi C $450	RADIATOR HAVE SMALL LEAKS. REPLACED RADIATOR AND COOLANT ANTIFREEZE BY OWNER.
Dec 2014 100440 mi C $250	Van wanders. Shop found Tie-rod end loose. Change both Tie-rod ends by owner. Brought Van to shop for alignment.

Toyota Sienna in California, United States Sep 2010 - Jun 2011
Oct 2010 46000 mi	Drivers door hinge, broken welds. Repair under factory warranty. TSB.

Toyota Sienna in Ontario, Canada Oct 2010 - Mar 2013
Jun 2011 106020 mi C $800	Power door failed - 2000 to repair, so forget it.  Also had lower control arms replaced.
Jan 2012 C $488	Passenger seatbelt jammed and would no longer retract. Replaced belt and mechanism.

Toyota Sienna in Ohio, United States Mar 2011 - Jun 2018
Feb 2012 123300 mi	Noticed steering problems, dealer said need new lower steering shaft assembly. TSB. My mechanic heated up the knuckles and lubricated them, good as new.
Jul 2015 183300 mi US $1300	Corroded radiator caused the trans fluid lines to mix with the anti-freeze lines. The transmission suffered, the engine overheated. New radiator was needed; new condensor needed as it could not be removed from radiator w/out damage to seal
Dec 2016 203000 mi	o2 sensors
Apr 2018 227000 mi US $8	Rear running light, had to remove inside back panel of door.
May 2018 229 mi US $20	Glove box latch broke
Jun 2018 229000 mi US $500	Both struts needed replacement.

Toyota Sienna in California, United States May 2011 - Dec 2017
Jun 2011 103000 mi US $972	Left and right lower front controls arms and ball joints replaced. The wear in them caused the tires to be out of alignment always, damaging tires.
Jan 2012 114000 mi US $944	Both oxygen and air fuel sensors replaced.

Toyota Sienna in Maryland, United States Sep 2011 - Sep 2015
Oct 2013 176200 mi US $900	rear AC system not working
Mar 2014 188000 mi US $800	Seatbelt retractors were jammed  Rear window not working Driver door hard to close. Other preventive maintenance.
Sep 2015 210000 mi US $280	Tie rod end worn out and replaced

Toyota Sienna in New Jersey, United States Apr 2013 - May 2016
May 2013 111300 mi US $400	AC Relay Replacement
Feb 2014 125000 mi US $2800	Had a leak of power steering rack leaking. Gear Assy, Power steering fluid replacement. 817.00 Parts, 480.00 Labor - New Jersey Pricing. Front Struts rusted / shocks fr/rr replaced - 800.00 parts, 360 labor.

Toyota Sienna in California, United States Jul 2011 - Jun 2018
Aug 2011 75000 mi	We had the front driver door fixed - under recall/warranty, so free. It made a loud popping sound every time you opened it.
Jun 2012 81000 mi US $200	We bought the car used, and the middle row right seat seatbelt was twisted several times. They had to open the case to straighten it. Not sure how it got so twisted in the first place.
Mar 2015 103000 mi US $1106	Replaced radiator assembly
Mar 2016 108000 mi	Passenger side sliding door would not respond to automatic open/close unless manually forced. Driver side sliding door did not respond to full car lock/unlock, had to be (un)locked manually. Cracked dash was replaced as per recall.
Jul 2016 108700 mi	AC has stopped working. This trip was diagnostic. Turns out it's the compressor. Repair trip scheduled.

Toyota Sienna in British Columbia, Canada Apr 2011 - Jun 2018
Mar 2012 59520 mi C $45	One of Two rear hatch hydraulic strut blew and needed replacing. 5 mins to fix and $45 for the part.
Feb 2014 92380 mi C $800	Replaced passenger front axle Replaced power steering

Toyota Sienna in Connecticut, United States Apr 2011 - Jun 2012
Dec 2011 131000 mi US $100	Front left caliper broken.

Toyota Sienna in Ontario, Canada Dec 2011 - Dec 2015
Nov 2012 102340 mi C $120	Exhaust flex hose had leak - new flex joint installed.
Dec 2012 104780 mi C $484	Replace Bank 2 Sensor 2
Mar 2014 115940 mi C $1300	Right hand sliding door fell off track, breaking back right window as well.
Dec 2014 136400 mi C $780	Right passenger door would not open, power or manual. A small piece of the handle actuator was broken off.
Dec 2015 161200 mi C $220	exhause flex pipe leaking - was replaced. THis was welded to repair about 4 years ago

Toyota Sienna in North Carolina, United States Aug 2013 - Apr 2014
Aug 2013 350000 mi US $650	rebuilt transmission failed after 20K miles

Toyota Sienna in California, United States Mar 2015 - Jun 2018
Apr 2017 158000 mi	Minor exhaust leak in a hose. Hose was replaced.

Toyota Sienna in California, United States Feb 2016 - Jul 2018
Jun 2017 152000 mi US $400	broken thermostat housing unit
Jul 2018 163000 mi US $60	Engine light came on. Error code P0430 came up on the scanner, but mechanic did not find any leaks. The car drives fine, no lack of power, no strange smell, no decrease in gas efficiency.

Toyota Sienna in California, United States Sep 2014 - Feb 2023
Apr 2017 147398 mi US $270	The parking brake had no tension at all due to a nut that had fallen off onto the floor mat. The technician had to partially disassemble the dashboard in order to replace the nut. 2 hours labor, no parts.

Toyota Sienna in Arizona, United States Jul 2014 - Jun 2022
Mar 2017 64000 mi US $42	Replaced front brake pads replacing original pads.

Toyota Sienna in Kansas, United States Dec 2007 - Feb 2008
Oct 2007 81172 mi US $1056	Replaced steering angle and YAW rate sensors.

Toyota Sienna in Wisconsin, United States Sep 2006 - Mar 2010
Aug 2006 23000 mi	Air conditioning performance was poor. Technician found some defective hose assemblies and replaced. Warranty Repair.

Toyota Sienna in Georgia, United States Jul 2017 - Mar 2018
Sep 2017 187000 mi US $200	Humming from driver side front hub- bad bearing. Replaced bearing & hub

Toyota Sienna in British Columbia, Canada Apr 2017 - Jul 2018
Sep 2017 220191 mi C $522	Wheel made noise while driving, progressively getting worse. Although left/right freeplay in wheel and there was sloppy handling. Wheel bearing was determined worn and wheel hub was also damaged due to driving on worn wheel bearing for a while and replaced. Problem was fixed.

Toyota Sienna in Idaho, United States Apr 2018 - Mar 2020
May 2018 161500 mi US $335	Radiator was leaking. Radiator & coolant were replaced. Steering rack boot torn. Steering rack has a slow seep. Oil weakens the boot and it eventually fails, allowing dust & debris to possibly contaminate the rack. Common issue on Siennas. Replaced boot

Toyota Sienna in New Brunswick, Canada Jun 2017 - Jul 2018
Jul 2018 143220 mi C $350	rear rotors plus caliper rebuild kits

Toyota Sienna in Maryland, United States Apr 2017 - Jun 2018
Sep 2017 85000 mi US $700	Needed to replace fuel oxygen sensor. Sensor seized and mechanic could not get it out (or at least he stopped trying). So we had to replace the exhaust manifold (to which the sensor is attached). I'm still angry about this one...
Jun 2018 90000 mi	There was a strange intermittent rubbing/wind noise coming from the front right of the car. I discovered that the wheel rock guard had torn and was rubbing on the tire. So, with the tire off, I cut out the part of the guard that was damaged and, using what felt like 50 zip ties (probably more like 10), I tied down the remainder of the rock guard to the body and frame.

Toyota Sienna in California, United States May 2017 - Feb 2022
Jan 2018 18500 mi US $2200	CAT Converter Replacement. Right Axle replacement.

Toyota Sienna in Utah, United States Oct 2017 - Jun 2022
Jan 2018 124000 mi US $10	New radiator cap to fix collapsing upper radiator hose.
Mar 2018 129000 mi US $1800	Leaking radiator replaced. Also did the thermostat for good measure.

Toyota Sienna in Wisconsin, United States Oct 2017 - Nov 2020
Mar 2018 122000 mi US $125	Rusted through exhaust pipe
Jun 2020 146000 mi US $600	Sliding door Electrical motor failure. Replaced entire electronic door module since individual servo not available. Web boards suggest common failure point

Toyota Sienna in California, United States - Jan 2005
Jan 2005	Transmission wouldn't stay in 2nd gear, skipped from 1st to 3rd Radio fell apart

Toyota Sienna in Oregon, United States May 2016 - May 2016
May 2016 170000 mi US $750	Radiator was leaking. Replaced.

Toyota Sienna in Washington, United States Oct 2014 - Apr 2018
Sep 2015 120000 mi US $3000	Power steering rack needed to be replaced. Transmission fluid leak
Oct 2017 139000 mi US $3500	Needed new radiator and a new coil. Coolant leak was cleaned up.

Toyota Sienna in Virginia, United States Dec 2014 - Mar 2018
Sep 2016 230000 mi US $20	Steering rack boot r&r

Toyota Sienna in New Jersey, United States Apr 2014 - Mar 2018
Jul 2015 121700 mi US $600	Wire short & compressor went bad.
Dec 2015 128000 mi US $130	replaced 6yr old battery
Jun 2016 137000 mi US $1100	replaced rack & pinion. boot ripped and leaking

Toyota Sienna in California, United States Mar 2014 - Mar 2017
Jun 2014 78000 mi US $500	Center hinge replacement on passenger sliding door
Sep 2015 90000 mi US $100	Passenger side power sliding door became non operational. Diagnosis was broken regulator. Original repair estimate was $1800. Cost to remove regulator and convert door to manual operation was $100. Less expensive option was chosen.

Toyota Sienna in Virginia, United States Aug 2013 - Nov 2021
Jun 2014 129000 mi US $2500	Cylinder sensor, timing belt
Jan 2017 136800 mi US $900	Fuel pump, first fuel pump was faulty, the second fixed the issue
Apr 2017 161000 mi	Replaced dash board due to cracks

Toyota Sienna in Delaware, United States Nov 2013 - Jun 2018
Jun 2016 143000 mi US $999	Front struts and rear shocks replaced including sway bar. Essentially got new suspension.
Jul 2017 163000 mi US $300	Steering rack issue
Nov 2017 175000 mi US $400	Flat tire

Toyota Sienna in North Carolina, United States Apr 2015 - Sep 2016
Dec 2015 226000 mi US $250	Hard 1-2 shift.

Toyota Sienna in Virginia, United States Jun 2015 - Jun 2015
Jun 2015 175000 mi US $80	Sliding door would not close

Toyota Sienna in California, United States Apr 2016 - Jun 2022
Jul 2016 108500 mi US $500	Door guide hinge broke. Replaced and welded.

Toyota Sienna in Washington, United States Jun 2015 - Jun 2017
May 2016 129300 mi US $750	Loud popping sound in right suspension. Shop replaced control arms and bushings on both sides. Right side was severely worn. Popping sound was improved but not completely resolved. Still suspect ball joint or brake pad issue.

Toyota Sienna in Georgia, United States Dec 2015 - Mar 2019
Jun 2016 177000 mi	While on a trip in 100 degree weather the car overheated and lost power. Feared engine failure. Turned out water pump had seized and chewed up the timing belt. Engine fine otherwise.

Toyota Sienna in New Brunswick, Canada Sep 2015 - Sep 2018
Apr 2016 169340 mi C $1	Driver door was making a bad clicking noise apparently a common issue . Fixed by drilling a hole where door stop is and put in rivet = noise is now gone .
Aug 2017 192200 mi C $500	rack and pinion replacement
Sep 2017 198400 mi C $25	Windshield washer nozzle replacement .
Feb 2018 211420 mi	Brought the car to shop to get a front end noise , Everything safe according to mechanic , no repairs needed but suspension is noisy .

Toyota Sienna in Tennessee, United States Aug 2015 - Aug 2015
Aug 2015 217000 mi US $1500	Had to replace both front and rear catalytic converters.

Toyota Sienna in Virginia, United States Jul 2010 - Mar 2016
Jul 2015 174000 mi US $500	FL bearing wore out, replaced it and half axle.
Mar 2016 183000 mi	Rear left sliding door would not close.

Toyota Sienna in Kentucky, United States Jan 2011 - Mar 2018
Mar 2012 168000 mi US $119	The magnetic clutch relay for the AC went out.
Jun 2015 230000 mi US $25	Stabilizers worn, replaced parts

Toyota Sienna in Massachusetts, United States Oct 2007 - Jul 2015
Sep 2009 51000 mi US $200	Front door would not open more than a few inches because door's interior trim panel came loose and caught on door opening
Dec 2010 56000 mi US $600	suspension bushing heavily worn and needed replacement, then alignment
Aug 2012 67500 mi US $200	Insert in lower front fascia fell out, causing fascia to separate from RF wheel well and vibrate at high speed. Replaced and reconnected parts.
Nov 2013 78300 mi US $100	Tire leaking because not sealing against wheel. Issue was corrosion of wheel. Fixed by cleaning wheel.
Jul 2014 81800 mi	Trim around middle-seat bottom had come loose and was flapping. Found appropriate-size screw and reattached Driver door panel and handle loose. Disassembled door, identified missing fastener, and replaced.

Toyota Sienna in Texas, United States Oct 2007 - Jan 2015
Apr 2012 108000 mi US $410	Rack and pinion boot tear, grease came out over time, had to replace whole r & p system. intake and exhaust valves bent b/c of faulty installation of timing bel
Aug 2012 115300 mi US $125	Clock spring failure. (airbag lighton, no horn, no steering wheel radio controls) Bolts rusted and broke holding down a clamp for stabilizer bar (front passenger side)
Sep 2012 119000 mi US $750	strut replacement up front (one had been damaged from earlier accident), lower control arm replaced a second time, unknown reason of why it went bad.
Jan 2013 106800 mi US $295	Axle issue, same one I had replaced in 2011, faulty due to improper installation by original mechanic.

Toyota Sienna in New York, United States Aug 2007 - Feb 2024
Jun 2008 116000 mi	Passenger Side Sliding Door Power Window stuck in down position. Broken switch tab on Driver Door Power Window Switch assembly. Driver Door switch assembly modified to prevent operation of of that window by driver, normal operation at PSSD/PW switch.
Jan 2009 133000 mi	3days after recall,>90% failure of new struts to hold hatch. Called dealer and told they need to"break in".Wrong answer!Return to dealer and was told "motor" was now problem(after 4+ yr's in service,failure free. Got vocal,struts replaced,lot#123-08.Fi
Jun 2009 142000 mi US $117	Ride becoming harsh, especially noticeable over road defects. Replaced rear shocks.
Oct 2009 150000 mi US $221	Driver Door Check, lower spot weld failed. Self repaired by installing hardware and epoxy bonding. Driver door lock motor intermittant. Replaced door lock assembly.
May 2010 165000 mi	Unequal AC cooling driver(warmer) vs passenger side. Removed panels to observe/test AC system. Control and dampers working properly, assume probable low refrigerant issue. To be checked/resolved at independent shop.
Nov 2010 174100 mi	DS Sliding Door cable failure. Has had cable sheath degraded >2 years, lube was applied to minimize rust. Door had operated >18,000 cycles. Not repaired at this time.
Jan 2011 176000 mi US $1018	R strut bearing seized breaking spring. Replaced springs/struts/bearings/sway links.
Feb 2011 176700 mi US $60	Exhaust leak at Crossover to Catalytic pipe joint, replace gasket and hardware.
Aug 2011 181000 mi US $97	Poor AC cooling on drivers side and dehumidification. Old issue addressed. Remaining system charge was 50% of minimum spec charge. Leak test passed, just general bleed out over 7 years in service. Recharged system to max charge.
Sep 2011 183000 mi US $388	Right Front Wheel Bearing noise, replaced bearing. Wheel alignment.
Feb 2012 188000 mi US $355	Left Front wheel bearing growl, replaced.
Mar 2012 188000 mi US $21	AC Clutch relay failure, replaced.
Apr 2012 189000 mi	Parking Brake inoperative prior to state safety inspection. Cleaned, lubricated, adjusted Rear Parking Brake components and adjusted main Parking Brake Cable.
Jul 2012 192500 mi US $112	Front passenger side window stuck down. Cracked switch on drivers door. Bypassed driver door switch. Window operational from passenger side. Slight radiator leak for several years, only several ounces of coolant lost per year. Major increase in leakage suddenly. Removed and epoxy repaired leak areas, reinstalled radiator, replaced upper and lower hoses.
Aug 2012 193700 mi US $12	Pipe to muffler flange leak. Replaced gasket.
Jan 2013 188500 mi US $429	Coolant leak, replaced Intake Manifold Gaskets.
May 2013 202700 mi US $160	Parking Brake Cables Seized. Replace L and R Rear Cables. Replace Parking Brake Shoes.
Apr 2014 211300 mi US $60	Right outside tailight capsule damaged during removal for bulb replacement, replaced assembly.
Sep 2014 215000 mi US $6	Patched leaking Front Bellows Joint on exhaust.
May 2015 220500 mi US $979	Front end shimmy, uneven F tire wear. Replace left outer tie rod end and stabilizer link. Flex joint and flange/gasket failures. Replace all gaskets, Y, resonator and tail pipe, muffler. Kept main CAT.
Jun 2015 222000 mi US $535	Stalling AC Compressor, replace compressor.
Aug 2015 223400 mi	Replaced AC Compressor noisy, replaced with another suppliers unit.
Oct 2015 223700 mi US $368	Replace both sway bar links, L link under part warranty. Check alignment, adjust toe-in, replace front tires.
Aug 2016 233000 mi	Power Seat jammed in one operators F/B driving position. Parts not available. Removed bad jackscrew, modified rails for power adjustment, manual lock in place. Sourcing junkyards for complete repair parts.
Feb 2017 237500 mi US $144	Alternator output intermittent. Replace alternator and serpentine belt.
Jun 2017 240000 mi US $477	Rear brake grinding noise, pad lining thrown. Replace Pads, Rotors. Misc Parking brake hardware, clean and adjust Parking Brake. Replace Left Outer Tie Rod end, adjust Tow-in. Replace rear springs for cracked ends. State Inspection.
Sep 2017 241865 mi	Passenger Side Power Sliding Door cable drive failed. Removed drive assy, operate door manually.
Dec 2017 242761 mi US $621	L Sway Bar Link failed, replace both links and sway bar bushings. Replace front tires, 4 wheel alignment.
Aug 2018 247000 mi US $450	Replace front rotors, front and rear pads. Clean, lube, adjust parking brakes. Replace all 4 caliper assy and exchange all fluid.  Replace rear shocks.
Oct 2018 248000 mi US $304	Failed AM middle (resonator) exhaust pipe at rear flange. Replaced.
Jan 2019 249000 mi US $45	Intermittent rubbing noise when in D. Engine pulleys rubbing when engine/trans-axel under load. Replaced upper torque strut for broken/worn shock mounting.
Aug 2019 253000 mi US $78	Replace Lower Control Arms for bushing failure, Ball Joints (originals), front Y pipe, 4 wheel alignment, state inspection. Moog components used. Rear hatch gas strut failed, replace struts.
Nov 2020 256007 mi US $300	Parking brake cables seized. Replaced both R cables, parking brake shoes, clean and adjust system.
Dec 2020 256169 mi US $680	RF upper strut bearing seized, wound up and broke spring. Replaced F strut assemblies (loaded) and stabilizer links.
Dec 2021 258000 mi US $1652	Rusted front subframe not passing inspection. Replace subframe,  noisy alternator and fusible link assembly.
Mar 2022 257980 mi US $1096	AC comp clutch coil failed. Replace comp, belt, recharge.

Toyota Sienna in Texas, United States Jun 2007 - Jun 2022
May 2009 79000 mi US $250	Replaced rear shocks and front struts.
Mar 2010 90000 mi	Replaced timing belt and water pump
Mar 2013 130000 mi US $150	Replaced both left and right rear wheel bearings .
May 2014 146000 mi	Replaced AC Compressor and condensor, evacuated system and recharged.
Jun 2015 159000 mi US $135	Replaced starter
Oct 2015 161300 mi US $550	Replaced front wheel bearings, rh axle shaft, and front shock absorbers
Jun 2018 182000 mi US $45	replaced MAF sensor and pcv valve

Toyota Sienna in Alberta, Canada Mar 2007 - Jun 2011
Jul 2008 52080 mi	Passenger power sliding door malfunction resulting in inability to open or close the door - including manually. I cut the drive cable which then allowed manual operation of the door. Parts unavailable at the time of the scheduled serviec trip to dealer. Dealer service tech identfied that radiator was leaking. Parts unavailable at the time. Dealer replaced drive motor & cable for passenger sliding door at no cost. Although original warranty had expired for this item dealer found a Toyota WAB (unsure of acronym or meaning) which covered 100% of costs (parts & labour). Would have been costl Dealer replaced radiator at no cost. Although original warranty had expired for this item dealer found a Toyota WAB (unsure of acronym or meaning) which covered 100% of costs (parts & labour). Would have been costly!
Aug 2009 60760 mi C $30	driving light - drivers side
Jun 2010 70060 mi	passenger side headlight exhibiting condensation witihin headlight assembly - off & on problem since new
Sep 2010 72540 mi C $50	Recurring problem with drivers side driving light (not the headlight). This about the 4th time the bulb has been replaced so I suspect it is getting wet somehow. The peculiar thing is that there is no visible condensation around the bulb
Dec 2010 76880 mi C $100	driver's side running light replaced - 5th time I believe since we purchased van new in 2004 Ongoing problem with condensation in passenger side headlight, this started shortly after we purchased the van new from dealer, they refuse to replace headlight unit as do I due to cost & what I believe is a Toyota issue, so we live with it.

Toyota Sienna in Virginia, United States Nov 2007 - Jun 2011
Oct 2009 81000 mi US $175	Steering bar (?) making knocking sound when brakes were applied. Took it to Merchant's Tire, they installed new one.  4 weeks later, same problem with noise. Took it to dealership who found the nuts holding part were loose and tightened them.
Jan 2010 US $175	Suspension bar loose - previous repair shop had either not tightened the bolts properly, or they had come loose.

Toyota Sienna in California, United States Feb 2008 - Mar 2010
Aug 2008 66000 mi	Right power sliding door went out. The dealer replaced the hinges, motor, etc. on the door. This is the third time this has happend over the life of the car. The service dept. said there is an updated part that is more reliable then the origional.

Toyota Sienna in New York, United States Jun 2008 - Mar 2010
Jul 2008 39000 mi	Motor for passenger side door is defective. There is a TSB for it, only if the part dies before 3yr/36k. It's about $2500 to repair the automatic sliding side door!
Sep 2008 41000 mi US $100	Right passenger sliding door jammed in close position because of defective motor. When door was opened, I saw the broken motor--a Toy-car-ota bulletin was made, but only covered the 3 yr/36000 mile period. My door broke about 4 yrs after purchase.

Toyota Sienna in Iowa, United States Jun 2010 - Jan 2019
Dec 2010 112000 mi US $180	Radiator was leaking - radiator was replaced - Toyota paid for 1/2 of new radiator & dealer paid for 1/4 so I was left with 1/4 of the bill...amazing
Jan 2011 112000 mi US $180	Radiator was leaking - radiator was replaced - Toyota paid for 1/2 of new radiator & dealer paid for 1/4 so I was left with 1/4 of the bill...amazing
Nov 2012 140700 mi US $80	Rear shocks seeping oil, rear suspension made a clunk sound going over larger bumps - so I replaced the rear shocks myself
Jun 2015 175000 mi US $450	Front drivers side CV joint began clicking on turns. Drove 1000 miles on it then replaced the entire axle. The boot was never cracked/broken. Seems the joint had little grease in it from the factory!

Toyota Sienna in Colorado, United States Apr 2008 - Oct 2015
Oct 2012 99300 mi US $1100	Failed door lock actuators. One on passenger front door, and one on driver's rear door.
Jan 2013 101500 mi US $2000	Coolant leak. Required a lot of work to fix it.
Sep 2014 128000 mi US $3000	Control arms were failing; steering column was leaking and needed to be replaced.

Toyota Sienna in Illinois, United States Mar 2008 - Jun 2011
Apr 2008 71000 mi	Radiator leak. Radiator replaced. (Covered under extended warranty)
Apr 2009 80000 mi	"Traction Control" sensor came on and car would not accelerate.

Toyota Sienna in Virginia, United States Jan 2008 - Aug 2013
Feb 2009 73000 mi	Rear hatch lifters could not hold rear hatch open.
Apr 2012 93500 mi US $860	The front wheel bearings were replaced on both sides

Toyota Sienna in Virginia, United States Feb 2007 - Jul 2022
Jun 2010 48000 mi US $670	Power sliding door had an accessory motor failure that affected remote operation. The power door would work if the exterior handle were manually tugged upon, but not if an interior button or key fob button was pressed.
Jun 2014 85000 mi US $1600	Water pump, timing benlt, drive belts, engine seals d/t wear
Jun 2015 98000 mi US $1700	Rear springs damaged due to multiple heavy loads, springs and shocks replaced coolant leak noticed at time of service
Aug 2015 99000 mi US $1000	Alternator broken and not able to charge a battery purchased earlier this year.

Toyota Sienna in Alberta, Canada Feb 2007 - Aug 2013
Aug 2007 37820 mi	Inspect and Report for Clunking Noise from Steering. Ordered Steering Shaft. Wait for 4-5 business days for part. Replaced Steering Intermediate Shaft and Greased as Required. Suggest alignment

Toyota Sienna in New York, United States May 2006 - Dec 2017
Mar 2007 36000 mi	Replaced the right front strut assembly (rattling sound on rough or uneven roads). - ordered part Right headlight assembly replaced due to fogging. - ordered part Radio/Headunit replaced due to inoperable cd player. - ordered part Replaced the right front strut assembly (rattling sound on rough or uneven roads). Radio/Headunit replaced due to inoperable cd player. Right headlight assembly replaced due to fogging.
Sep 2010 86000 mi US $130	Door striker on driver side has to be welded back onto the frame.

Toyota Sienna in Missouri, United States May 2006 - Mar 2010
Mar 2008 65000 mi US $280	Broken door guide covered under recall notice. O2 sensor failed.

Toyota Sienna in Michigan, United States May 2006 - Jun 2018
Jul 2013 105500 mi US $500	Timing belt, big end seal, cam seals, motor mount
Jun 2014 118000 mi	AC lost charge, clearly has a slow leak. Recharged and will monitor Slider door handle broke off.
Oct 2014 120200 mi US $200	Down pipe between the engine headers
Jul 2016 125200 mi US $550	Tie rods, Tie Rod Ends, Shocks and struts front and rear, lower front A arms and ball joints

Toyota Sienna in New York, United States Aug 2006 - Dec 2013
Jan 2007 60000 mi US $365	Worn idler arm control rods, both right & left. Rear View Camera Defective.
Apr 2007 63000 mi US $550	Right Front Brake Caliper frozen
Aug 2008 88000 mi US $450	Flexible exhaust pipe had a crack in the seam.
Jan 2009 99000 mi US $100	Emergency brake cable froze up- replaced.
Nov 2013 124000 mi US $600	The Transmission fluid cooling lines were corroded and leaking.

Toyota Sienna in Massachusetts, United States May 2006 - Apr 2018
Apr 2011 72000 mi US $450	vehicle failed mass. inspection due to exh leak in flex section between manifold and exh pipe to cat converter. not covered by emission warranty.
Sep 2012 82000 mi US $700	right front driveshaft/bearing. had to replace shaft also as brg was rusted to shaft.
Jul 2013 90000 mi US $1000	failed shaft between engine and transmission. Initially thought to be failed trans, hence long time in shop getting replacement whcih was wrong part.
May 2016 102600 mi US $1000	oxygen sensors, 2 within 2 days
Sep 2016 104000 mi US $600	coolant leak at a freeze plug on front of engine.
May 2017 106000 mi US $600	2 oxygen sensors out of 3 in system failed a few days apart
Jun 2017 106000 mi US $1300	replace rotors, pads, hoses. All badly worn or rusted

Toyota Sienna in New York, United States May 2006 - Nov 2013
Sep 2007 67000 mi US $30	rear folding seat latches do not release. it jams down, it jams up. requires "new cables", part not in stock, part not ordered. Grrrr. I HATE return trips.
Aug 2008 74000 mi US $180	Car was in for lube, oil and filter. Pointed out unrepaired jammed seat. They claim they "adjusted it, and its ok". It was stuck down when returned to me. It needs parts. They don't stock them.
Dec 2009 91000 mi US $420	Starter did not engage. Starter motor spun-up, but bendix failed to engage starter in flywheel. Starter replaced.
Jul 2010 96300 mi US $600	spare tire hanger cable rusts excessively in NY salty winters. Toyota issued recall notice, but has no solution for their dealers yet. Another trip will be required. Rear brake pads replaced upon inspection during LOF.
Oct 2010 98500 mi US $130	Driver's seat elevation mechanism. Bar that syncs left and right elevation detached causing right side of seat to drop down.
Jun 2013 117000 mi US $898	LF coil spring broken Found while repairing leaking Y-pipe in exhaust Y-pipe replaced ... leaking loudly.
Sep 2013 122000 mi US $150	Sway bar links were worn/loose. Replaced.

Toyota Sienna in Ohio, United States Oct 2006 - Mar 2010
Jan 2007 36000 mi	Replaced rear struts for rear door

Toyota Sienna in Florida, United States Jan 2007 - Oct 2007
Feb 2007 42000 mi	Rear Hatch sensor which controls the electric motor malfunctioned causing door to reverse and close automatically. Replace one struct, but problem remains. Replace second strut, still not fixed. Order motor. failed to fix the sensor on the rear hatch. had to replace entire electric motor

Toyota Sienna in California, United States Jan 2007 - Mar 2018
Aug 2009 78000 mi	Rear gate lifters would not lift gate
Oct 2010 93300 mi US $350	Right rear wheel bearings. Wheel hub replaced.
Apr 2011 100000 mi US $10	Cable on R slider door snapped. Motor, actuator and door bracket replaced. Water leaking into rear compartment. plugs replaced.
Sep 2013 145000 mi US $950	Thermostat and housing Intake manifold gasket
Nov 2013 148000 mi US $250	2 oxygen sensors
Feb 2014 152000 mi US $900	catalytic converter, check engine light on.
Oct 2014 164300 mi US $250	RF Wheel bearing. Noisy rumbling. Repaired.
Jul 2016 195500 mi US $85	Emissions system, gas cap.
May 2017 200000 mi US $1900	Rack and pinion leaking, replaced Motor Mount. Control arms and bushings
Aug 2017 202000 mi US $425	Starter failed, replaced.
Sep 2017 202000 mi US $300	R Rear wheel bearings replaced.

Toyota Sienna in California, United States Sep 2006 - May 2015
Nov 2006 18 mi	Replaced second row captain's chair seat belt receptacle.
Mar 2012 41000 mi	Replaced rear door struts under recall. They had begun to not open the door quite as high as before.
Jun 2013 54000 mi US $115	New battery

Toyota Sienna in New York, United States Jan 2007 - Jul 2015
Dec 2009 76000 mi US $50	automatic sliding door motor and cable poor heat therefore changed thermostat, problem fixed.
Sep 2011 103000 mi US $3000	Radiator leak while driving. Radiator could not be changed by itself so condensor had to be changed too. Hoses, belts and thermostat changed while it was in the shop.
Apr 2012 130000 mi US $1500	Oxygen sensor. catalytic converter
Jun 2012 139000 mi US $160	Flex Exhaust pipe off manifold pipe.
Mar 2013 163000 mi US $850	Catalytic converter , 1 of 3 on the car
Feb 2014 206000 mi US $400	Muffler pipes only not muffler
Mar 2014 209000 mi US $200	Front wheel bearings. Left was bad but replaced both while it was there.
Sep 2014 234000 mi US $40	Temperature sensor Catalytic converter code I used catalytic converter cleaner cost $25 a bottle but was on sale, but one get one free at advanced auto. Add cleaner to 1/4 tank of gas or 4 gallons drive 10-15 miles and fill up tank. Worked like a charm!
Apr 2015 256800 mi US $450	Rack replaced

Toyota Sienna in Alabama, United States Aug 2008 - Dec 2016
Mar 2009 67000 mi US $60	Glove box latch was broken and the glove box was not able to be opened.
Jun 2014 129000 mi US $25	Belt for alternator and compressor
Dec 2016 164000 mi US $65	Cleaned MAF

Toyota Sienna in California, United States Feb 2008 - Apr 2016
Feb 2010 120000 mi US $475	Lower control arm bushings and ball joints needed to be replaced.
May 2010 128000 mi US $90	Rear shock absorbers needed to be replaced as they were causing uneven tire wear.
Sep 2010 137000 mi US $500	Air conditioner wasn't working. Mechanic advised compressor was bad, needed to be replaced. He ordered the part and replaced it the following day.
Jun 2013 210000 mi US $365	Power steering pump leaking, replaced.
Jun 2014 235000 mi US $145	Worn motor mount needed to be replaced.
Nov 2014 246000 mi US $200	Replaced all four motor mounts.
Mar 2015 253000 mi US $325	Removed and replaced air conditioning compressor and condensor core.
Jun 2015 260000 mi US $593	Replaced radiator fan assembly.
Jul 2015 262000 mi US $400	replaced left and right drive axles
Aug 2015 262200 mi US $200	Radiator needed to be replaced as transmission fluid was being mixed with engine coolant due to internal leak.
Apr 2016 263000 mi	Failed smog check

Toyota Sienna in Ontario, Canada Sep 2009 - Apr 2010
Mar 2010 81220 mi C $150	rear window defroster.
Apr 2010 81220 mi C $770	Air conditioning failure. System was fully charged, but not blowing cold. Electrical wiring problem.

Toyota Sienna in Illinois, United States Nov 2009 - Jun 2011
May 2010 89000 mi US $450	Coolant leak repaired.

Toyota Sienna in California, United States Dec 2009 - Dec 2016
Oct 2010 124000 mi US $122	A/C stopped blowing cold air wwhich was fixed with a Freon recharge.
Aug 2011 135000 mi US $50	R134a Recharge-did it myself.
Aug 2013 163900 mi US $1500	Replace compressor, AC switch and refrigerant recharge.

Toyota Sienna in Texas, United States May 2009 - Oct 2010
Sep 2009 91000 mi US $700	Bad power lock motor on sliding door.

Toyota Sienna in New Jersey, United States Nov 2008 - Mar 2014
Feb 2013 116300 mi	The automated door track & motor for the passenger door was replaced as part of a recall.

Toyota Sienna in Illinois, United States Jan 2009 - Sep 2011
Jul 2011 131000 mi US $1050	Replaced A/C compressor

Toyota Sienna in British Columbia, Canada Jun 2009 - Mar 2020
May 2013 99820 mi C $300	Replaced air conditioning magnetic clutch relay.

Toyota Sienna in California, United States Feb 2009 - Nov 2014
Sep 2012 54000 mi US $604	The passenger window broke loose of its mount. The replacement was $600. Radiator hoses, wiper blades, air filter, cabin air filter, oil and filter was an additional $600.
Nov 2013 59000 mi US $1272	Steering Gear Ball Joints Power Steering Rack & Pinion Wheel Alignment Front Break Pads
Aug 2014 61000 mi	Parking Sonar Stopped Working - Alarm Sounds - All the Senors Positions Flash Red Not Repaired at this time Radio/Stereo Screen Shows Black Boxes Rear Driver Side Sun Screen will not Retract
Nov 2014 63000 mi	Passenger Side Rear Power Sliding Door: Motor works, but cable may have come off the pulley. The van is still at the Dealer Service Center

Toyota Sienna in Manitoba, Canada Feb 2005 - Jun 2011
Apr 2005	Replace one rear brake pad (on warranty)
Aug 2008 117800 mi	Replace driver-side door due to latch issues (done on warranty)
Jul 2009 85560 mi C $1900	Broken strut. Front shock and struts replaced.

Toyota Sienna in Arizona, United States Mar 2011 - Mar 2014
Mar 2014 115000 mi US $70	Whole vehicle inspection/diag indicates need for front strut & rear shock replacement, steering rack bushing replacement, tie rod end replacement

Toyota Sienna in Iowa, United States Oct 2008 - Jun 2012
Mar 2009 120000 mi US $870	Radiator replaced.
Jul 2009 124000 mi US $330	AC did not blow cool air.
Feb 2010 134900 mi US $140	Coolant leak. It was not the water pump nor a hose; I don't remember the term used by the mechanic. Apparently it is a common problem for Siennas.

Toyota Sienna in Maryland, United States Oct 2008 - Mar 2010
Dec 2008 94000 mi US $160	Transmission pan gasket was leaking -- not a major repair.

Toyota Sienna in Manitoba, Canada Mar 2009 - Sep 2019
Apr 2012 145360 mi C $200	Power sliding door jammed.
Mar 2015 173600 mi C $450	Had plugged power steering fluid lines causing the steering to be periodically very tight and difficult to manage. Fluid flush prevented a more costly repair. Exhaust pipe rusted through.
Jan 2018 202740 mi C $200	Tire leak; malfunctioning block heater cord.

Toyota Sienna in Florida, United States Sep 2007 - May 2010
Dec 2007 74000 mi US $572	DVD player screen.
Mar 2008 80000 mi US $254	Fluid leak block off plate.
Jul 2008 88000 mi US $155	Passenger side A/C temperature actuation door.
Aug 2008 90000 mi US $36	Driver side fog light.
Sep 2008 92000 mi US $356	Driver side electric door lock actuator.
Sep 2009 108000 mi US $600	water pump leaking. decided to replace instead of waiting for in use failure cracked engine mount, rear replaced
Dec 2009 108000 mi US $75	Front passenger shoulder belt twisted and fully extended
May 2010 114500 mi US $463	DVD Screen replace , second time in 3 yrs. Audiovox noted problem replace CV axle and boot due to broken boot (right side) and lubricant total leak out

Toyota Sienna in Florida, United States Nov 2008 - May 2013
May 2013 93000 mi	Transmission was operating in a problematic manner, without smooth shifting.

Toyota Sienna in Minnesota, United States Nov 2011 - Jan 2012
Jan 2012 152000 mi US $600	The cable on the automatic sliding door broke. The driver side windshield wiper arm stopped working.

Toyota Sienna in Maryland, United States Nov 2008 - Mar 2010
Apr 2009 53000 mi US $230	Replaced the two rear shocks.

Toyota Sienna in Virginia, United States Dec 2008 - Jun 2018
Feb 2014 67000 mi	Front engine motor mount replaced. Changed front engine mount. Flushed/filled transmission, brake, and power steering fluid.
Sep 2016 85000 mi US $200	Front SeatBelts replaced under TSB. Seatbelts bind when retracting. Parking brake no longer holding, even after adjustment. Shop dissected brakes and reinstalled shoes and springs and adjusted brake cable.
Jul 2017 88000 mi US $1000	Exhaust leak in original exhaust.
Oct 2017 90000 mi US $170	Both headlights replaced using aftermarket headlights. OEM headlights opaque/yellowing and unsafe.

Toyota Sienna in Ontario, Canada Nov 2008 - Feb 2015
Dec 2009 78740 mi	Power lock on passenger rear-sliding door will not work. Manual locking/unlocking still fine. Power actuation of the lock has failed. Part costs over $600 plus labour to open up door. Will not fix given this very steep price.
Apr 2011 91760 mi C $700	Exhaust pipe @ manifold had a hole in it.
Jul 2012 101680 mi C $800	Also unseized left front caliper slider and other maintenance items.
Jan 2013 104780 mi C $240	There was a cracked gasket that was causing a slow antifreeze leak in the cold weather.
Apr 2014 115620 mi C $1000	Replaced front struts

Toyota Sienna in New York, United States - Nov 2007
Nov 2007 53000 mi US $255	Replaced power steering hose because it started to leak fluid; dealer refuses to honor it under Toyota Platinum Extended Warranty.

Toyota Sienna in New Hampshire, United States Nov 2016 - Jul 2017
Jun 2017 136000 mi US $560	Rear brake froze, ebrakes haven't worked in 2 years, all the brakes needed to be replaced. Took the shop three tries to get the parking brake working again. Driver side sliding door will not open, cannot be opened by shop. They tried twice, no luck. Have an appointment with the dealer to see if it can be fixed.

Toyota Sienna in Colorado, United States May 2006 - Jun 2018
Nov 2011 62300 mi US $60	Left front brake caliper seized. After problem diagnosed, removed caliper and ordered rebuild kit. Problem was discovered during a 60 mile drive.
Aug 2013 77900 mi US $200	Did the long overdue valve adjustment. Replaced or moved 17 shims.
Mar 2016 102000 mi US $70	Replaced both inside tie rod ends due to wear
Sep 2017 123000 mi	Under Toyota enhanced warranty, entire dashboard was replaced, not to include electronics.
Dec 2017 125000 mi US $450	Outer tie rods and lower ball joints and control bushings
Feb 2018 125000 mi US $106	Battery died...replaced it with Toyota True Start

Toyota Sienna in British Columbia, Canada May 2010 - Dec 2015
Sep 2010 56420 mi	Checked code and ordered an O2 sensor
Oct 2010 58280 mi C $85	Installed o2 sensor and reset code, code has not returned at all.
Mar 2012 81220 mi C $10	No A/C, found puncture in condenser from small rock, patched with JB Weld. Seems to work holding 25 lbs pressure.

Toyota Sienna in Massachusetts, United States - Feb 2005
Sep 2004 410 mi	Tightened front bumper hardware that was not properly torqued at delivery resulting in a loud rattling after 300 miles.
Oct 2004 2420 mi	Replaced radiator due to anti-freeze smell. Covered under warranty.
Nov 2004 3390 mi	Lubricated door seals due to rattle/clicking of seals against windows over bumps. Covered Under warranty.
Dec 2004 4250 mi	Replaced radiator 2nd time due to antifreeze smell. Fixed center row seat belt that stopped retracting. Relubricated door seals due to rattle/clicking of seals against windows over bumps. Covered under warranty.
Jan 2005 5405 mi	Replaced center row seat belt assembly that stopped retracting again. Relubricated door seals due to rattle/clicking of seals against windows over bumps. Covered Under warranty.
Feb 2005 7180 mi	Replaced radiator for the 3rd time due to antifreeze smell. Attempted to fix rattling from front seat belt height adjusters - no fix, characteristic of vehicle. Relubricated door seals due to rattle/clicking against windows over bumps. Covered under warra

Toyota Sienna in Virginia, United States Dec 2015 - Jun 2018
Mar 2015 105000 mi US $200	Power sliding door cable. Power sliding door solenoid. Outer tie rods previously replaced but not tightened or greased. Caused shaky suspension and poor tire wear. Tie rod ends removed and replaced. Also caused premature failure of inner tie rod on driver side.
Aug 2016 124000 mi US $400	AC Compressor replacement.
Mar 2017 127000 mi US $5	Power sliding door solenoid.
Apr 2017 130000 mi US $100	Front exhaust flex pipe
Jun 2017 134000 mi US $600	Transfer case has been leaking for >30K miles, recently leak has increased, I had the case resealed by a private mechanic.
Sep 2017 136000 mi US $600	Leaking transfer case was finally resealed, three gaskets were leaking at the time of the repair: 1. Rear Output Shaft, Front Cover, and Transmission/T-Case.
Jan 2018 140000 mi US $45	The driver side sliding door cable broke. Both sliding doors often have trouble in cold weather. The door cable was replaced only 14 months ago. Part replaced free of charge. I performed the R&R in about 3 hours. Driver side ball joint. Failed state inspection for "play" in the joint. The part only had 20,000 miles on it. When I asked to have the "play" demonstrated the technician was unable to do so. The technician insisted it needed replaced. I replaced it at home in <30 min.
Mar 2018 142000 mi US $45	Alignment

Toyota Sienna in New York, United States Sep 2006 - Jul 2010
Apr 2010 117000 mi US $350	replaced wheels/bearings on sliding driver's side door due to difficulty opening and closing the door

Toyota Sienna in Nevada, United States Jun 2009 - Jul 2021
Mar 2011 55368 mi	Vibration in steering wheel Flushed mud from inside of rims
May 2011 60120 mi US $608	New KYB struts and shocks + alignment New KYB struts and shocks + alignment
May 2013 91700 mi	Automatic sliding door closing/opening cable snapped. Repaired under extended warranty by dealer. New cable mechanism installed.
May 2016 126000 mi US $784	Replace steering rack
Nov 2017 134735 mi US $526	Mice chewed ignition wires, 2 coils replaced Battery replaced - 75 mo
Dec 2017 136000 mi US $92	Replaced damaged tire

Toyota Sienna in Indiana, United States Mar 2007 - Jan 2011
Apr 2007 36000 mi	passenger sliding door failure - needed a whole new mechanism. tires wore down prematurely - need to put 3rd set of tires on at 37,000.
Oct 2008 61000 mi	Major fluids leaking - had to take apart and replace all engine seals. While they were doing this, they also noticed that the cooling system had an issue causing the engine to run hot and had to replace those seals.
Nov 2010 86900 mi US $100	Power sliding door broke and would cost 1200 to repair. Would not cover under extended warranty despite have replaced every other part of that same door over the years. Radiator leaking - 1100 to replace. Decided the car was not worth the investment and will be trading it in.

Toyota Sienna in North Carolina, United States Dec 2013 - Jul 2016
Aug 2015 131300 mi US $85	Driver side power window switch passenger side sliding door trim strip Drivers side sliding door automatic open/close failure - severe grind/scrape against paint when opening/closing.
Jun 2016 145000 mi US $150	headlight tarnish repair
Jul 2016 145000 mi US $60	Rear automatic door struts

Toyota Sienna in Wisconsin, United States Jan 2014 - Dec 2019
Apr 2015 129000 mi US $200	Power sliding doors not working with buttons
Aug 2015 134800 mi	Rear hatch support was covered under recall
Sep 2015 135000 mi US $60	Worn out swaybar links and bushings. Original parts since 2004 Inner and outer tierods finally warn out completely. Even thou they didn't look bad and weren't clunky. So lower control arms, lower ball joint and struts and mounts were all replaced. Weren't extremely bad but after 10+ years it was time to swap them all out
Apr 2016 144700 mi US $250	Left wheel bearing making lots of road noise. Roaring type of sound
Sep 2016 149000 mi US $15	Replaced little motor in actuator. Rear sliding Door wouldn't open with buttons only manually Dear ujoint completely worn out. Bought aftermarket and repaired.

Toyota Sienna in South Carolina, United States Apr 2012 - Oct 2012
Oct 2012 178000 mi US $158	A/C not cooling. System Recharged might be signif leak.

Toyota Sienna in Saskatchewan, Canada Nov 2013 - Jan 2022
Nov 2013 111600 mi C $2700	Vehicle hesitates when changing gear. Service personnel topped up transmission fluid & reset sensors. Noise on front right wheel. Changed wheel bearings.
Feb 2014 113620 mi C $164	New computer scavenged to deal with ongoing transmission issue. Engine warning light (& VSC) burning. Related to oxygen sensor(?) and problem with drivetrain. Computer replacement (#1) however did not fix it. Conclusion:faulty sensor. Needs replacing.
May 2014 116760 mi C $715	Check Engine Light stays on. Replaced Bank 1 Sensor 2 Oxygen sensor. Drive belt screeching. Drive belt coming apart.
Jan 2015 113820 mi C $828	Blower motor in ventilation system making a noise.
Nov 2015 126480 mi C $335	Traction control kicks in at a specific left-hand turn on highway. But only if brakes had been applied in the 60 seconds prior to reaching that spot! Technicians found no problems. Balanced and aligned wheels. It still happens at that spot.
May 2018 145700 mi C $1100	All brake pads replaced
Sep 2018 150660 mi C $200	Battery replaced. End of life. Sensor overlooked and car ran rough/ wouldn’t start. All fixed
Jun 2021 156860 mi C $1700	Front suspension repaired

Toyota Sienna in California, United States Feb 2005 - Jun 2011
Dec 2005	replaced rear hatch struts,
Jul 2006 20500 mi	repaired daytime running lights, alignment for the 3rd time
Sep 2006 23500 mi	repaired Daytime running lights and rattle under the dash
Dec 2006 28000 mi	replaced rear hatch struts for the 2nd time
Mar 2007 31000 mi	repaired passenger side sliding door
Apr 2007 32000 mi	repaired rattle under the dash, replaced tires under the Toyota recall
Jan 2008 36000 mi US $1500	repaired the laser cruise control- did not register other vehicles
Mar 2008 37000 mi	Replaced rear hatch support struts.
Feb 2009 45000 mi US $800	Spring inside the driver door broken so door hard to open and made a loud popping sound.  Laser cruise control does not work any longer. Cost $1200 to fix so we said "No thanks".

Toyota Sienna in Maryland, United States Jun 2010 - Oct 2015
Jul 2010 129000 mi US $1500	Found radiator leaking. Replaced that and A/C condensor which supposedly could not be removed from radiator without stripping threads of bolts connecting it to the radiator.
Aug 2011 148000 mi US $1771	AC failed. Replaced compressor.  excessive tire wear, poor ride. Replaced struts & shocks.
Oct 2015 210000 mi	Driver seat was stuck in the "short person" position.

Toyota Sienna in Washington, United States Oct 2008 - Nov 2010
Nov 2010 98000 mi US $25	Replaced overhead console light bulb for $5/each totaled $25 (all 5 light were out).

Toyota Sienna in Texas, United States Jun 2011 - Jun 2012
Jul 2011 122000 mi US $1400	A/C failure at least once per year for the past 3yrs on a row with cost from $800-$1400 for last repair. Engine check during annual inspection, problem with emissions. Parts & Labor >$4,500 by Toyota. Covered by extended warranty. Couple of months more and it would be on my dime.
Dec 2011 126000 mi US $2500	Had problem with sensors and needed $2500 to fix. Decided to get a new car due to bad history of repairs with this car. No more Toyotas from now on.

Toyota Sienna in Massachusetts, United States Jul 2011 - Dec 2021
Mar 2012 164000 mi US $210	door hinge needed repair - now works great
May 2013 174000 mi US $500	Muffler / Exhaust needed repair
Jun 2013 175000 mi US $300	exhaust flex pipe broke
May 2014 185100 mi US $800	steering rack assembly
Jul 2014 186300 mi US $400	o2 sensor bad
Sep 2015 203000 mi US $700	flex pipe
Sep 2016 215000 mi US $100	engine code due to bad thermostat in radiator - new thermostat and radiator fluid

Toyota Sienna in Minnesota, United States Feb 2007 - Mar 2016
Apr 2007 59000 mi	The heater in the driver seat did not work well and the cowling of the seat had come apart. Second unsuccessful attempt to fix seat heater. Successfully fixed heated seat on third try.
Apr 2008 96000 mi US $403	Check engine light turned on and so we had car checked. We had an oxygen sensor replaced as the outcome. We were told it was just wear and tear and not covered by warranty.
Mar 2009 125000 mi US $1143	The radiator leak (not hoses) was noticed in the shop. The radiator housing had cracked open.
Aug 2009 143000 mi US $100	Laser sensor for cruise control failed. Unable to calibrate. Was damaged apparently during previous body work to bumper. Body shop paid for labor. Not repairable. Plastic back of driver's seat fell off and pins holding it in place broke
Oct 2009 146000 mi US $5000	Transmission failed. Had to replace transmission.
Dec 2009 148000 mi US $400	Wheel bearing apparently wore out and had to be replaced. Check Engine light and VSC lights are on
Dec 2010 186000 mi US $330	Oil pan leaking and gasket had to be replaced.
Jun 2011 201000 mi US $1000	Front passenger seat warmer no longer works Since the shop tried to fix the passenger seat warmer, the front dash now clicks rhythmically off and on when car is on

Toyota Sienna in Texas, United States Oct 2011 - Sep 2012
Jun 2011 99000 mi US $790	Front struts/mounts needed repair for wear, one of them shot.
Jun 2012 100000 mi US $950	Front strut mounts and struts replaced. One broke, others replaced for age/symmetry.

Toyota Sienna in Pennsylvania, United States Dec 2012 - Jan 2013
Jan 2013 125000 mi US $100	repair to exhaust system

Toyota Sienna in North Dakota, United States Apr 2015 - Jun 2018
Jun 2015 125000 mi US $150	Bad washer on connection to condenser. Part replaced and recharged. Good since then
Dec 2016 146000 mi US $80	Wheel bearing was worn out, making humming noises. Bought new brewing and had mechanic press it into place, then I reinstalled it.
May 2017 155000 mi	Replacement of transmission pan filter and change of translating oil.
Sep 2017 157000 mi US $30	Replaced transmission oil pan drain plug gasket
Jun 2018 165000 mi US $250	Replaced Knock Sensors due to code showing sensor failure. Replaced both even though code was only for #1. Replaced coolant crossover line that was leaking while the engine was open. Also replaced spark plugs and O rings on fuel injectors

Toyota Sienna in Washington, United States May 2006 - Mar 2010
Nov 2006 19000 mi	The daytime running lights do not work. They have been unable to fix it three times. I need to take it back in again when they can talk to Toyota corporate.
Dec 2006 21000 mi	Daytime running lights did not work. This was the 4th visit to get them repaired, but the dealer was unable to figure out how to repair it.

Toyota Sienna in Georgia, United States May 2006 - Mar 2010
Mar 2007 32000 mi	Misc TSBs before warranty ends

Toyota Sienna in California, United States Jul 2006 - Jan 2018
Oct 2006 42000 mi US $445	Rear lift gate struts failed. Part price alone was an exorbitant $180 each!
Nov 2006 43000 mi US $450	Hatch struts failed

Toyota Sienna in Indiana, United States Oct 2007 - Mar 2010
Mar 2008 61000 mi US $585	Found radiator leak two days before leaving on 2000ml vacation. My shop r/r radiator within 24hr and we took off. No problem.

Toyota Sienna in New York, United States Nov 2007 - Jun 2011
Feb 2008 54000 mi US $900	CD player not working
Nov 2008 60000 mi US $150	Replaced 02 sensors due to check engine light on and several other sensors.