| 1 | 0 | 3 | 4 | 3 | 4 |
1999 Chrysler Town & Country repairs by problem area
Engine (40%)
Transmission and Drivetrain (9%)
Brakes and Traction Control (13%)
Suspension and Steering (19%)
Electrical and Air Conditioning (16%)
Paint, Rust, Leaks, Rattles, and Trim (3%)
Other (0%)
Chart based on 77 repairs.
1999 Chrysler Town & Country repair cost distribution
$2500+ (0%)
$1000 - $2499 (7%)
$500 - $999 (17%)
$100 - $499 (32%)
< $100 (45%)
Chart based on 60 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
1999 Chrysler Town & Country
Engine not specified
| Chrysler in New Jersey, United States Jan 2012 - Apr 2014 | |||
| Apr 2012253300 miUS $75 | Brake lines from ABS unit to rear of vehicle rusted through and were leaking substantially. Obtained from dealer (have special fittings on them), installed, bled brakes all around. Requires dropping left side of gas tank about 6 in. Replaced power steering pump. Reservoir had rusted through and was leaking. Requires dropping from section of exhaust to access pump mounts and space to withdraw pump. | ||
| Oct 2012256700 miUS $384 | Replaced power steering pump. | ||
| Apr 2014275000 mi | Replaced the idler pulley on the drive belt. | ||
| Chrysler in Kentucky, United States Oct 2012 - Nov 2012 | |||
| Nov 2012240000 mi | Water leaked past the rubber trim at the base of the windshield. It then blew under the cowl fresh air vent and leaked into the floor of the van. | ||
| Chrysler in North Carolina, United States Aug 2012 - Aug 2013 | |||
| Sep 2012187000 miUS $250 | Customer continues to complain front brakes tighten up and won't release until vehicle sits awhile. Replaced master cylinder, booster and bled all brakes. | ||
| Mar 2013188000 miUS $25 | Brakes would tighten up while deiveing sometimes. All it needed was the rod running from brake booster to pedal needed to be adjusted a little shorter. After customer spent $ 2500.00 all it needed was a $25.00 fix. | ||
| Chrysler in New York, United States Oct 2012 - Dec 2013 | |||
| Nov 2012125700 miUS $585 | Installed metal reinforcing cap on the left strut tower because of rust threatening the structural integrity of vehicle. | ||
| May 2013130300 miUS $200 | Corroded radiator was replaced. | ||
1999 Chrysler Town & Country 4-door
6-cylinder automatic AWD
| Chrysler in New York, United States Mar 2010 - Jun 2011 | |||
| Apr 2010135000 miUS $400 | Tie rod ends. | ||
| Jul 2010138700 miUS $1100 | Replaced brake pads and calipers. Replaced gasket causing transmission fluid leak. | ||
| Sep 2010142000 miUS $420 | Wouldn't start. Starter and battery replaced. | ||
1999 Chrysler Town & Country 4-door
6-cylinder automatic 2WD
| Chrysler in Georgia, United States May 2010 - Sep 2013 | |||
| Jun 2010218000 miUS $1200 | Engine over heat due to shorted radiator fan relay and worn out fan assy. Service engine light came on. Found leak at rear heater wheel well connection due to rusted steel tubes to heater assy. Parts not available this trip. High speed wheel hop on level road. Vibration starts at 65 and gets worse at higher speeds. Replaced rear shocks, McPherson struts, rebuilt leaf springs, replaced tires, rebalanced 6 times, road force tested and aligned. Problem remains. | ||
| Sep 2010225000 miUS $90 | Low hum coming from left rear axle. Hub bearings are going bad and need replacement. Leak discovered at rear heater QD's under car by right rear wheel well. Tube Assy. to optional rear heater core corroded causing leak at QD's | ||
| Jun 2011235000 mi | Right rear window does not open. Possible damaged motor. Shop replaced fan control module ($230+ parts and labor). Owner had shop replace Thermostat, but engine ran hot still. Shop found fan module defective and under warranty - replaced for free. | ||
| Aug 2011237800 miUS $42 | Right Rear Vent window motor will not open all the time. Found website that walked me through the trouble shooting process and discovered motor was getting power. Remove and Replaced right rear vent motor sucessfull repair. | ||
| Jan 2012247000 miUS $65 | Master power window control replaced due to Driver window not returning to up position. Right rear window motor failed. Replace motor. | ||
| Apr 2012248300 miUS $832 | Fuel pump died on the road without any warning. Pump & Filter alone cost over $450 with 3-1/2 hours labor and towing. | ||
| Jun 2012250000 miUS $174 | Water pump leaking. This one only lasted 3 years. | ||
| Oct 2012254000 miUS $130 | Left rear hub siezed up after being noisy for some time. | ||
| Jan 2013257000 mi | Transmission pump slipping on start up. Noticed leak in that area also. Engine takes several tries to start. This is due to original spark plugs being used (277000 miles on them). Valve covers leaking severely too. | ||
| Feb 2013258300 miUS $530 | in line oil filter and hoses cracked and leaking due to old age. wornout tie rod end on driver side. Replaced original spark plugs, replaced leaking valve cover gaskets and plenum seals. | ||
| Mar 2013260000 miUS $350 | Found leak was transmission in-line filter and rubber hoses. Replaced filter and hoses, drained and refilled with fluid. Transmission does not slip at all. | ||
| Jul 2013265500 miUS $250 | Oil pan gasket leaking badly. Removed and replaced gasket. No leaks at all on this 14 year old mini-van. | ||
| Chrysler in Indiana, United States Mar 2010 - Sep 2011 | |||
| Apr 2010188000 miUS $600 | Failed power window motor and regulator, front right door Blower control module. Front blower was blowing on high speed only before repair. | ||
| Jun 2010192000 miUS $135 | Fresh air door actuator was not working, therefore recirc function for a/c not working. Self-diagnosed by owner, replaced a factory part for a successful repair. Old part had stripped plastic gear. | ||
| Jan 2011201000 miUS $1100 | Alternator failure. While car in shop, need for serpentine belt and tensioner diagnosed. | ||
| May 2011204900 miUS $950 | Failing inner CV joints. Repair involved replacement halfshafts with new inner and outer CV joints. Also discovered broken sway bar, replaced with bushings. | ||
| Aug 2011207000 miUS $800 | Leaking steering rack. Steering rack replaced with remanufactured unit. | ||
| Sep 2011207000 mi | Broken planetary gearset in original transmission at 209,000 miles. Uneconomical to repair. Car was replaced | ||
| Chrysler in Minnesota, United States Oct 2009 - Jun 2011 | |||
| Nov 2009137000 miUS $75 | Water pump bearing failure. No coolant leakage. Strut towers rusted through. Installed strut tower repair caps. | ||
| Chrysler in Switzerland May 2009 - Nov 2011 | |||
| Dec 2010122760 mi$1200 | Flex plate (part between the engine and the torque converter) was damaged, causing the crank shaft sensor sensing wrong signals which led to engine computer malfunctions. No other major parts were replaced, transmission works fine again. | ||
| Chrysler in Wisconsin, United States May 2008 - Jun 2018 | |||
| Nov 2008184000 miUS $185 | Serpentine belt tensioner broke. First time this van has ever had a tow! | ||
| Jan 2010197000 miUS $625 | Broken rear brake line. While in the shop had EGR replaced. While in the shop had water pump replaced. While in the shop had ABS sensor replaced. | ||
| Chrysler in Ontario, Canada Mar 2009 - Aug 2016 | |||
| Jun 200976880 miC $60 | Front sway bar links starting to make noise - replaced sway bar links. | ||
| Sep 201093000 miC $5 | Waterpump bearing making noise - replaced water pump. I had a pump in the garage that I bought at a swap meet few years ago for $5 | ||
| Mar 2011103540 miC $120 | Intermittent minor Brake fluid leak - replaced the rear brake proportioning valve | ||
| May 2011105400 miC $300 | Radiator showed signs of deterioration - corrosion, aging. Replaced Radiator. Noted leaking muffler noise - corrosion on the seam. Replaced muffler | ||
| Mar 2012124620 miC $120 | Replace Multi function switch - intermittent left signal | ||
| Oct 2012138020 miC $20 | Driver side Outer Tie Rod end worn - replaced tie rod end. | ||
| May 2013150660 miC $60 | Sway bar bushings worn - replaced sway bar bushings Accessory Serpentine belt idler pulley - bearing noise | ||
| Sep 2013159340 miC $10 | Front crankshaft oil seal replaced | ||
| Oct 2013160240 miC $75 | Outer tie Rod end worn - ran into a problem with thread on inner tie rod end ended up replacing inner too - that's why it took so long | ||
| Mar 2014168640 miC $60 | Muffler rusted out (previously replaced 3 years earlier Maremont non OE muffler)- Muffler replaced with Walker muffler | ||
| Apr 2014169840 miC $100 | Front right wheel bearing noisy after winter tires removed - replace wheel bearing - problem fixed Rear brake proportioning valve with a slight leak of brake fluid - brake warning light flashing on turns - replaced the proportioning valve - problem fixed | ||
| Jun 2014176080 miC $60 | Replaced upper and lower rad hose - partly preventative as they were still original - partly because I thought they were not sealing properly | ||
| Jul 2014176080 mi | Replaced the radiator - it had previously been replaced and was a lifetime warranty unit from Spectra so there was no cost for replacement. It turned out this was the source of the leak - leak on tank seam | ||
| Jul 2016210800 miC $200 | ABS sensor defective Minor radiator leak and radiator fan seized | ||
| Chrysler in Florida, United States Jun 2009 - Jun 2010 | |||
| Jul 2009121000 miUS $100 | Vehicle began overheating while on a trip. Overheats after an hour of driving. Coolant is usually about a qt low each time. No leaks found yet, engine tests ok - no internal leaks. System losing about 2psi every 5 minutes on pressure test. | ||
| Sep 2009121000 miUS $500 | Followup to overheating problem from July 2009. Leak finally became visible on rear heater tubes at coming from the firewall. Had shop bypass rear heat to address the problem. Outcome pending... | ||
| Oct 2009122000 miUS $70 | This is a recurrance of the previous overheating problem. Temp gauge spiked and set off warning light. Shop ran diagnostics and found no leaks. Suspect electrical issue at instrument panel. Vehicle still overheats after an hour of constant running. Coolant is down by about 1/2 gallon. All leak tests performed but no leaks found yet. | ||
| Feb 2010123200 miUS $530 | Coolant leak - present since July 09 finally became bad enough that it could be located. Turned out to be the water pump. Old pump was not correct for the vehicle - required additional labor to remove. Fingers crossed-I think we've got it this time! Oil pressure sending unit failed causing warning light to illuminate. Since the cause of the warning light could not be determined by driver, van was taken to shop immediately. | ||
| Chrysler in Texas, United States Jul 2009 - Mar 2010 | |||
| Sep 2009240000 miUS $70 | losing water from radiator with no oil in water and no water in oil. Also no puddles under car. | ||
| Chrysler in North Carolina, United States Aug 2008 - Mar 2013 | |||
| Jul 2009142000 mi | A/C stopped cooling, added freon and everything works. | ||
| May 2010149000 miUS $8 | A/C not cooling enough, needed to add refrigerant. | ||
| Jun 2012166000 miUS $50 | Rear metal brake lines rusted, one burst and I had no brakes. Replaced both metal lines from rear axle tube to just over the fuel tank. | ||
| Sep 2012166000 miUS $50 | Belt tensioner was chirping, replaced. | ||
See TrueDelta's information for all Minivans
See TrueDelta's information for all Chrysler models.
