| 1 | 0 | 3 | 4 | 3 | 4 |
2002 Ford F-150 repairs by problem area
Engine (38%)
Transmission and Drivetrain (15%)
Brakes and Traction Control (4%)
Suspension and Steering (13%)
Electrical and Air Conditioning (22%)
Paint, Rust, Leaks, Rattles, and Trim (2%)
Other (5%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 144 repairs.
2002 Ford F-150 electrical repair cost distribution
$2500+ (0%)
$1000 - $2499 (13%)
$500 - $999 (10%)
$100 - $499 (50%)
< $100 (27%)
Chart based on 30 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2002 Ford F-150 4dr Extended Cab 8ft bed
220-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range
| 265000 mi | Alternator had never been replaced. It finally gave up the ghost. Alternator replaced. |
| 285000 mi US $178 |
Motor on driver's side which controls the windows went out. It was replaced. |
2002 Ford F-150 4dr Extended Cab 6.5ft bed
260-horsepower 5.4L V8 4-speed automatic RWD
| 159000 mi US $530 |
Replaced major hose which sprung a leak, and recharged the system. |
| 176600 mi US $155 |
Simple replacement of alternator. Purchased part at Autozone, took an hour to swap out. |
| 53000 mi US $1600 |
New condenser, drier, hoses, seals, and recharge |
| 251000 mi US $24 |
Right door lock actuator quit working. Replaced actuator. |
| 150000 mi US $800 |
Replaced alternator Number 4 Electronic coil going out P0304 and P0316 |
2002 Ford F-150 4dr Extended Cab 6.5ft bed
260-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range
| 129000 mi US $1000 |
Starter died. |
| 172000 mi US $113 |
A/C system is leaking - service tech installed some dye to help to find the leak. |
| 182000 mi US $1308 |
Replaced leaking compressor |
| 187200 mi US $194 |
replaced alternator ( it was the original) and tensioner and belt |
2002 Ford F-150 4dr Extended Cab 6.5ft bed
220-horsepower 4.6L V8 4-speed automatic RWD
| 58280 mi C $210 |
R&R Daytime Running Light module #113z-14a601-ab |
| 65800 mi C $90 |
driver door lock actuator - replacement |
| 74400 mi C $478 |
replaced A/C clutch,idler pulley, tensioner due to noises from engine |
| 83080 mi C $190 |
replace low heat setting resistor |
| 89900 mi C $338 |
replace starter |
| 98580 mi C $300 |
R&R alternator |
2002 Ford F-150 4dr Extended Cab 6.5ft bed
202-horsepower 4.2L V6 5-speed manual RWD
| 85000 mi US $110 |
Replaced Alternator |
| 183000 mi US $568 |
alternator, battery, leak in tire and oil change. |
2002 Ford F-150 4dr Crew Cab 5.5ft bed
260-horsepower 5.4L V8 4-speed automatic RWD
| 166000 mi US $300 |
Right rear door electric window and power lock stopped working. Not repaired. Left front door speaker stopped working. Not repaired. |
2002 Ford F-150 4dr Crew Cab 5.5ft bed
260-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range
| 131000 mi US $420 |
replace alternator and battery |
| 145000 mi US $77 |
Blower motor resistor failed & was replaced |
| 167200 mi US $650 |
Previous owner installed own aftermarket trailer hitch wiring & for some reason avoided factory supplied harness, connectors used were poor quality & they eventually allowed corrosion causing turn & stop light fuse to blow. |
| 104200 mi US $20 |
Replaced open master cylinder mounted cruise control deactivation switch. |
2002 Ford F-150 4dr Crew Cab 5.5ft bed
220-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range
| 127040 mi C $2100 |
my truck wouldnt start and add none of the gages was working so the dealer put it on the computers and it was my cluster that was burnt so had to replace the cluster and the alternator was charging to much that why my cluster burnt |
2002 Ford F-150 2dr Regular Cab 8ft bed
supercharged 340hp 5.4L V8 4-speed automatic RWD
| 117000 mi US $200 |
Cruise control broken sensor |
2002 Ford F-150 2dr Regular Cab 6.5ft bed
260-horsepower 5.4L V8 4-speed automatic RWD
| 148000 mi | Starter failure, unable to remove starter, will need to go to professional shop |
| 148000 mi US $150 |
Replaced starter |
2002 Ford F-150 2dr Regular Cab 6.5ft bed
202-horsepower 4.2L V6 5-speed manual RWD
| 170200 mi US $360 |
alternator failed due to seized tensioner spring. |
2002 Ford F-150 2dr Regular Cab 6.5ft bed
202-horsepower 4.2L V6 4-speed automatic RWD
| 102000 mi US $50 |
speed control small part |
See TrueDelta's information for all Pickups
See TrueDelta's information for all Ford models.
