| 1 | 0 | 3 | 4 | 3 | 4 |
2011 Ford F-150 repairs by problem area
Engine (27%)
Transmission and Drivetrain (17%)
Brakes and Traction Control (7%)
Suspension and Steering (8%)
Electrical and Air Conditioning (28%)
Paint, Rust, Leaks, Rattles, and Trim (10%)
Other (4%)
Chart based on 354 repairs.
2011 Ford F-150 repair cost distribution
$2500+ (1%)
$1000 - $2499 (9%)
$500 - $999 (12%)
$100 - $499 (29%)
< $100 (50%)
Chart based on 208 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2011 Ford F-150 4dr Extended Cab 6.5ft bed
turbocharged 365hp 3.5L V6 6-speed shiftable automatic RWD
| Ford F-150 in Ontario, Canada Sep 2016 - Mar 2018 | |||
| Oct 201693000 miC $2200 | Timing chain, cam phasers | ||
| Ford F-150 in Alabama, United States Nov 2011 - Jan 2013 | |||
| Aug 20129000 mi | The wrench symbol came on indicating the truck needed repairs. No problems found at dealer. Sensor reset and has since come on again briefly. Also, truck has too many interior squeaks for a 1 year old vehicle costing 36K. | ||
| Jan 2013 | Still too many interior squeaks for a 1 year old vehicle costing 36K. | ||
| Ford F-150 in Ontario, Canada Aug 2013 - Jun 2022 | |||
| Mar 201312400 miC $1200 | After replacing 2 sensors which were not faulty, the dealer replaced the ECM, solving our problem | ||
| Sep 201440300 miC $35 | Alternator was replaced but did not fix charging problem Charging problem reappeared. After 2 days in the shop, the truck was returned. After another 3 weeks, the problem reappeared. heater/ac blower resistor failed. It was easier to fix it myself than to take it to a shop. Its failure may have been caused by the over-voltage charging problem (up to 17 volts) | ||
| Oct 201441500 miC $300 | A broken wire was discovered. This caused the alternator to overcharge. As a result of overcharging, the entire instrument panel including signal lights, speedometer etc, would intermittently shut down | ||
| Jul 201560760 miC $40 | Replaced blower motor resistor, again | ||
| Mar 201793000 miC $1000 | Replaced both front wheel bearings (hubs). | ||
| Jun 20221450800 miC $1100 | Leadframe replacement including transmission oil and filter replacement | ||
2011 Ford F-150 4dr Extended Cab 6.5ft bed
turbocharged 365hp 3.5L V6 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in New York, United States Dec 2011 - Apr 2014 | |||
| Mar 201214000 mi | Rear defogger required switch replacement- took 3 days. | ||
| Jan 201332000 mi | Rear defogger fuse, apparently, had blown. Replaced, "Ohmed out" and said all was well. Fuse blew again on the way home. | ||
| Apr 201446000 mi | Entire rear window was replaced. | ||
| Ford F-150 in Colorado, United States May 2011 - May 2016 | |||
| Dec 201215000 mi | Replaced battery Faulty tow module | ||
| Sep 201426000 miUS $300 | unable to lower spare tire check electrical because battery dies after 3 or 4 days of no use. not sure what they did, I know they reprogramed the system. backup camera would not keep settings | ||
| Oct 201426000 miUS $300 | unable to align until parts were replaced | ||
| May 201636000 mi | Rear end limited slip locked both wheels causing noise when turning. It was as if rear wheels were locked in 4x4. | ||
| Ford F-150 in Ontario, Canada May 2011 - Feb 2018 | |||
| Jul 20129920 mi | Hard 1-2 up shift. Third break light leaking. | ||
| Apr 201316000 mi | Heat control knob became sticky. Had to order part and replace HVAC control assembly. Information display on instrument cluster occasionally having "blue screen" | ||
| Jul 201428600 miC $75 | Service advancetrac light came on. TSB performed for software flash. Two weeks out of warranty | ||
| Jun 201649600 mi | Vacuum pump failed. Replaced as per ford program. | ||
| Ford F-150 in Ohio, United States Sep 2012 - Oct 2012 | |||
| Oct 20128000 mi | Seemed to be shutting off.Motor stopped.Dash board lights turned off then came back on.Happened 5 times had vehicle towed.Mechanic stated no codes showing and could not get vehicle to duplicate problem. | ||
| Ford F-150 in Ontario, Canada Jul 2011 - Sep 2016 | |||
| Mar 201213020 mi | very hard shifts up and down as well as lack of power on hard acceleration | ||
| May 201333960 mi | Rear camera guidelines had to be reset regularly. Both camera (parts) and software update were needed. It is a common problem on the 2011 model but many people don't use the rear guidelines so don't know that they disappear from time to time. | ||
| Nov 201450840 mi | Rough shift at very slow speeds occasionally Rough idle when cold | ||
| Dec 201576880 miC $240 | Coil packs for cyl 5 and 6, also put new spark plugs in | ||
| Ford F-150 in Alberta, Canada Aug 2011 - Dec 2014 | |||
| Oct 20117100 mi | Preventive TSB for transmission pump. | ||
| Sep 201462620 miC $750 | Repaired 2 wires that rubbed through the drive by wire system behind the dash, disabling it, $750. | ||
| Dec 201462620 mi | Blown turbo lead to terminal failure and last straw regarding trade in for SRT Jeep Grand Cherokee. Would have cost about $3,000 to repair. | ||
| Ford F-150 in Pennsylvania, United States Nov 2011 - Mar 2017 | |||
| Jan 201324200 mi | Right door speaker buzzing | ||
| Dec 201322000 mi | TPMS Sensor in Front Right wheel failed. | ||
| Jan 201513000 mi | Engine loss of power / shuddering under load. | ||
| Ford F-150 in New York, United States May 2014 - Mar 2016 | |||
| Mar 201581000 miUS $50 | Running ruff, replaced spark plugs. | ||
| Apr 201583000 miUS $75 | Caliper frozen | ||
| Feb 2016104000 miUS $3651 | Stretched timing chain | ||
| Ford F-150 in Kansas, United States Jul 2011 - Oct 2012 | |||
| Apr 20124000 mi | Rough idle, lost 5mpg, shudder @ about 55mph in high gear on a slight uphill grade or into strong headwind, and truck will fall flat on its face - complete misfire after cruising low rpm and then going full throttle like to pass someone. | ||
| May 20124000 mi | Rough idle, lost 5mpg, shudder @ about 55mph in high gear on a slight uphill grade or into strong headwind, and truck will fall flat on its face - complete misfire after cruising low rpm and then going full throttle like to pass someone. Because of previous problems, and Ford's unwillingness to correct problems that are SERIOUS safety problems under the right or wrong circumstances I am forced to lemon law this truck. That's a shame because, working, it's a great truck. | ||
| Oct 20124000 mi | Sold because of continuing problem with misfiring. Ford F150 Ecoboost are fine if they work. There are way too many like mine that do not. | ||
| Ford F-150 in Pennsylvania, United States Feb 2015 - Mar 2016 | |||
| Sep 2015114000 miUS $333 | New Battery Lug nuts were bad - the outer shell broke off of two of them while rotating tires. | ||
| Ford F-150 in Washington, United States Nov 2011 - Dec 2016 | |||
| Dec 201530000 mi | Air bag warning light on Replaced drivers side seat belt retracter | ||
| Ford F-150 in Delaware, United States Feb 2011 - Jan 2012 | |||
| Mar 20112000 mi | Replaced driver-side rear shock because it was leaking fluid. | ||
| Ford F-150 in Wisconsin, United States Mar 2011 - Mar 2013 | |||
| Aug 201236000 mi | Driver side speaker blow out | ||
| Feb 201349000 mi | Engine was unable to find a consistant RPM, TC appeared to unlock and relock constantly on downhill grades with T/H or Cruise engaged. PCM was reflashed, issue appears to be resolved | ||
2011 Ford F-150 4dr Extended Cab 6.5ft bed
360-horsepower 5.0L V8 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in Iowa, United States Jan 2021 - Jun 2022 | |||
| Feb 2021260700 miUS $20 | Oil leaking from oil pan gasket. Replaced gasket. Coolant leaking from upper coolant Y connection. Replaced o-rings on Y connection. Leaks resolved. | ||
| Jun 2021263900 miUS $96 | Front left brake sticking. Replaced caliper, hard line and soft line. Found soft line was collapsed and clogged, holding pressure in the caliper. | ||
| Jul 2021265770 miUS $352 | Squeaky wheel bearing and grinding Integrated Wheel End (4x4 hub actuator). Replaced both. | ||
| May 2022275400 miUS $250 | Recharge AC after replacing evap core Coolant reservoir was leaking coolant. Nipple for hose was cracked. Replaced entire reservoir. | ||
| Ford F-150 in Newfoundland / Lab., Canada Sep 2013 - Oct 2016 | |||
| Mar 201326040 mi | LSD clutch pack replaced | ||
| Jun 201441540 mi | LSD clutch pack replaced (2nd time) | ||
| Feb 201650840 miC $68 | Replace heater fan resistor (fan wouldn't work on low speed) | ||
| Oct 201657660 miC $15 | Vacuum check valve failed in 4x4 system, causing partial engagement of left side IWE (vacuum hub. Replaced vacuum check valve (Motorcraft YG-429) | ||
| Ford F-150 in Delaware, United States Oct 2015 - Mar 2017 | |||
| Aug 201670100 miUS $20 | Burned out passenger headlight bulb. Easy fix. | ||
| Ford F-150 in Kansas, United States Jan 2017 - Jan 2018 | |||
| Oct 201778000 miUS $200 | A water leak developed in the rear cargo light housing. | ||
2011 Ford F-150 4dr Extended Cab 6.5ft bed
360-horsepower 5.0L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Arizona, United States Feb 2017 - Jun 2018 | |||
| Jun 2017123000 mi | Brake warning light and message center "check brake system" only on open road driving > 20 miles. Does not happen in town driving. Dealer could not duplicate problem on 2 mile test run. NOTHING DONE! Trans temp reached between Yellow & Red when climbing long steep winding highway grade. No load in truck. Happens on the same section of highway every time. Mechanic could not duplicate in a 2 mile drive in town. NOTHING DONE! Once when passing another car stepped hard on gas to downshift and pass, trans when to a "neutral" position, rpms when to about 5000 before I backed out, once rpms dropped trans when back to high gear. Mechanic could not duplicate it on 2 mile drive. NOTHING DONE! | ||
| Aug 2017125000 mi | Fuel gauge and "Miles to Empty' would drop very rapidly. Fuel pump/sending unit were replaced in Dec '16. They were replaced again this time. This DID NOT cure the problem. Returning in Oct '17 for Instrument Cluster replacement. | ||
| Nov 2017129000 miUS $100 | Replaced gauge cluster. Replaced vacuum sensor on power brake booster. | ||
| Ford F-150 in Minnesota, United States Oct 2020 - Jun 2022 | |||
| May 2022150386 miUS $150 | Mouse Attack! Mouse had eaten through some wires resulting in a no start situation. Repaired wires | ||
| Ford F-150 in Kentucky, United States Jan 2012 - Jun 2018 | |||
| Jan 201764000 miUS $580 | Cooling system expansion tank and hose replaced | ||
2011 Ford F-150 4dr Extended Cab 6.5ft bed
302-horsepower 3.7L V6 6-speed shiftable automatic RWD
| Ford F-150 in Georgia, United States Feb 2012 - Mar 2014 | |||
| Apr 201214500 mi | Check Engine Light was on with a P2610 code. Turned out to be a known service bulletin regarding esrly 2011 models of this truck. Reprogrammed computer. | ||
| Ford F-150 in Texas, United States Jun 2011 - Mar 2014 | |||
| Nov 201231600 mi | SYNC system required an update. | ||
2011 Ford F-150 4dr Extended Cab 6.5ft bed
302-horsepower 3.7L V6 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in New York, United States Dec 2012 - Jan 2017 | |||
| Nov 201322700 mi | Improper shifting since day one. Hard slamming shift in all gears eventually before they finally replaced the whole thing. | ||
2011 Ford F-150 4dr Extended Cab 6.5ft bed
302-horsepower 3.7L V6 6-speed automatic RWD
| Ford F-150 in Idaho, United States Oct 2018 - Jan 2019 | |||
| Jan 201970000 mi | Replaced Driveline $650 | ||
| Ford F-150 in Florida, United States Aug 2011 - Jun 2019 | |||
| Feb 201316500 mi | On accel from a stop, clunk felt in drive train. Cleaned and lubed splines of drive shaft slip yolk per TSB 12-7-13. Repair drive shaft boot. When slowing to a stop at about 2 or 3 mph feels like transmission will not disengage. Vehicle jerks then slows normally to a stop. Advise 110812A Reprogram PCM and TCM, perform adaptive strategy learn. Drivers door lower seal is loose. Reattach seal. | ||
| Jul 201435500 mi | Radio cutting in and out using radio, sirus, or CD player. Dealership replaced both front speakers. | ||
| Jun 201662000 miUS $1181 | R&R Dash. Remove and replace 3 mode door actuators | ||
| Apr 201877000 miUS $164 | Vehicle exhibited drive shaft slip/bump on light to moderate acceleration. Vehicle repaired per Ford TSB 12-7-13. Note this repair was also performed when vehicle had 16,000 miles on it. Parts Required - Drive shaft boot and grease | ||
| Ford F-150 in Massachusetts, United States Jul 2015 - Jul 2021 | |||
| Feb 201874000 miUS $25 | Dealer diagnosed vapor purge valve needed replacement, quoted $200, drove it home, bought the part for $25 on Amazon and replaced it in under 15 minutes. | ||
| May 201876000 miUS $400 | Replaced strust assemblies, brake pads, and rotors | ||
2011 Ford F-150 4dr Extended Cab 5.5ft bed
turbocharged 365hp 3.5L V6 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in New Brunswick, Canada May 2011 - Jul 2013 | |||
| Jun 201212048 mi | Rust on the driver side bottom rear door latch under plate. While repainting the rocker sill the painter accidently put clear coat ont eh outer top door panel in closing the door. This panel was replaced as well. driver side main weather strip coming off in small pieces on the driver side. aslo had rust starting under the driver side rear door latch anchor point | ||
| Jan 201319840 mi | Sys off to save battery warning on dash. Contacted the dealer and was told they've NEVER heard of the error warning before. This went on for a week, during deep freeze in temps. 2007 Car started coldest am but truck almost didn't. | ||
| Jun 201325420 miC $500 | Vacuum booster has been failing and because its electronic believed to be the cause of a second heavy duty battery dying in less than 18 months. Part needed to be ordered - part was back ordered - 2 weeks to 3 months due date. Common problem. | ||
2011 Ford F-150 4dr Crew Cab 6.5ft bed
turbocharged 365hp 3.5L V6 6-speed shiftable automatic RWD
| Ford F-150 in Texas, United States Apr 2013 - Feb 2017 | |||
| Mar 201468000 miUS $100 | Ignition coil pack failed, causing truck to go into limp mode and CEL flashing. | ||
| Apr 201470000 miUS $100 | Had a slow coolant weep from the expansion tank where the heater hose connects. Replaced heater hose first and problem remained. Dealer ended up replacing the expansion tank, which has resolved the issue. | ||
2011 Ford F-150 4dr Crew Cab 6.5ft bed
turbocharged 365hp 3.5L V6 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in Minnesota, United States Oct 2011 - Jun 2013 | |||
| Jan 2013 | engine misfire on light acceleration after in 6th gear | ||
| Jun 201334000 mi | Engine misfire | ||
| Ford F-150 in California, United States Jun 2011 - Mar 2017 | |||
| Feb 201320800 mi | Harsh shift. Fixed by lubing slip joint and reprogramming transmission. | ||
| May 201324000 mi | Transmission not shifting. Transmission pump replaced. | ||
| Dec 201334000 mi | Vibration from rear end. TSB, insert a shim into the rear axle spring seat. | ||
| Mar 201436000 mi | Vibration reduced considerably, but still there under load: when bed is loaded, going up hill, or towing. Ford Customer Service contacted me and is going to work with the dealer to find the cause. | ||
| Ford F-150 in Connecticut, United States Dec 2011 - Dec 2013 | |||
| Jan 201218500 mi | Transmission leak. Deformed oil pan | ||
| Ford F-150 in Minnesota, United States Oct 2011 - Jan 2014 | |||
| Oct 20117500 mi | Bad batch of transmissions from 4/11/11 to 6/8/11 caused transmission pump leaks. Fixed under TSB. | ||
| Nov 201110000 mi | Long wheelbase F150s with Ecoboost engine shudder on take-off and at 55-60 mph. | ||
| Aug 201334400 mi | CAC replaced. This stupid typing is why I don't participate. | ||
| Jan 201445000 miUS $100 | Rear window heating element contacts became dirty and could not be cleaned. Entire power-sliding rear window with heating element was replaced under premium care extended warrantee. $100 deductible was paid for by customer. | ||
| Ford F-150 in Michigan, United States Apr 2011 - Jun 2022 | |||
| May 20111000 mi | Dealer replace a defective windshield wiper relay. Factory defect. | ||
| Jan 201211000 mi | Vehicle was bucking severely upon hard acceleration while entering freeway and CEL was flashing. The next day CEL was on steady. Error code was "catalyst efficiency below threshold bank 2". Dealer replaced the catalytic converter. | ||
| Feb 201213000 mi | Vehicle would buck when climbing a moderate grade at 45mph. You could hear the turbo's wastegate opening and closing rapidly and feel the truck surge. Dealer re-flashed the PCM with a new firmware version. | ||
| Nov 201222800 mi | Oil leak @ bell housing. Dealer investigated and found a TSB for the front pump on the tranny. Bad batch of pumps around the time my truck was built. Dealer replaced pump and tranny pan gasket. | ||
| Dec 201224000 mi | After the pump replacement, there is a loud resonanting vibration/noise when the engine/transmission is cold and the RPM's about 850. This is especially noticeable when backing out of the garage first thing in the morning. Bolts tightened. | ||
| May 201330000 mi | Ecoboost badges on both doors are corroding and look awful. Also the rubber cups on the door checks have rotted again. | ||
| Jul 201332700 mi | Oil leak @ bell housing. Front pump leaking again. Replaced pump assembly and main transmission housing, seals, filter, etc. | ||
| Oct 201682000 miUS $5 | 3 broken wires and 2 wires with exposed conductors in both rear door wiring bundles at door hinge area. Soldered new wires and coated damaged insulation on the other wires. Removed a hard plastic rod taped up in the bundle. | ||
| Sep 201795000 miUS $30 | The gearset in the HVAC blend door motor failed and would make a rapid clicking sound when the temperature dial was at the coldest setting. | ||
| Feb 201898899 miUS $150 | Loud pop came from the speakers while listening to the radio and then no sound. Removed radio and sent to United Radio for repairs. UR reported that there were cold solder joints on the main circuit board and that it was a common problem with this OEM radio AM/FM single CD. | ||
| Jun 2018104000 mi | Several wires in the bundle that goes from the body to the drivers side rear door broke AGAIN due to flexing when the door is opened and closed. I soldered in a new piece of wire to make them a little longer. | ||
| Ford F-150 in Maryland, United States Mar 2011 - May 2019 | |||
| Jun 201242000 miUS $100 | Steering position sensor faulty; replacement required replacement of entire rack-and-pinion steering system. Covered by Ford ESP PremiumCare warranty (less $100 deductible). | ||
| Aug 201246900 mi | Rough 1-2 and 2-1 shifts at lower throttle. | ||
| Ford F-150 in New Jersey, United States Aug 2011 - Sep 2014 | |||
| Oct 2011 | catalytic converter went bad at roughly 800 miles | ||
| Sep 201320000 mi | Poor design - Rear brakes have to come apart to adjust the parking brake | ||
| Apr 201424500 mi | Outlets & 12v adapters are over charging/heating my personal electronics (phone, tablet, etc). I need to make the time to get to the dealer. | ||
| Sep 201427000 mi | Never bothered with the repair of the interior charging system. | ||
| Ford F-150 in Georgia, United States Dec 2015 - Feb 2022 | |||
| Feb 201695700 mi | Back up sensor was inoperable upon purchase and repair trip was to replace one of the sensors and get the system working correctly. Under body coating applied due to evidence of rust beginning to form. Mod agreed upon purchase of vehicle less than 1 month prior. | ||
| Oct 2016113000 miUS $470 | Check Engine light came on and lost acceleration response significantly. Dealer diagnosed as faulty cam phaser and stretched timing chain. Extended warranty I purchased covered about $2,800 in addition to the 470 I had to pay. Back up camera was also replaced during same visit, it had quit sending signal to screen when in reverse. The tailgate Ford logo also had to be changed since it breaks in removal of the camera. | ||
| Apr 2017126000 miUS $10 | Fouled spark plug caused check engine light to come on | ||
| Jun 2018149000 miUS $200 | O2 sensor replacement | ||
| Jul 2018151000 miUS $56 | Replaced spark plugs after CEL came on indicating misfire | ||
| Oct 2021208000 miUS $1000 | Replaced brake pads, which turned into replacing blown wheel seals in the rear along with all 4 new calipers. | ||
| Ford F-150 in Minnesota, United States Feb 2011 - Dec 2017 | |||
| Mar 20111000 mi | Sync system malfunctions: 1 would not download phone address book although the phone is listed as compatible. Sync locking up/not responding. | ||
| Jun 20112000 mi | AdvanceTrac was failing while pulling trailer. Replaced computer and checked all connections and sensors | ||
| Ford F-150 in Alberta, Canada Mar 2011 - Mar 2017 | |||
| Sep 201432860 miC $250 | Advancetrac service light came on. The entire steering assemble needed to be replaced. | ||
| Aug 201652120 miC $1200 | Timing chain was stretched. Back up camera required replacement. | ||
| Ford F-150 in Ontario, Canada Mar 2012 - Jan 2013 | |||
| Apr 201213520 mi | After updating the PCM with TSB 12-02-10, still having turbo pop-off issues and misfire at 50-60 mph. Lacks turbo power altogether. Dealer kept truck for 20 days, wanted to tow a heavy trailer in order to duplicate turbo issue. Ford came out with a new TSB and dealer replaced Turbocharger vacuum regulator selenoid. Working better since, more power. | ||
| Nov 201218880 mi | Started to do turbo pop off again. Dealer said that Ford found the problem so they ordered parts. They changed an air deflector in theturbo plus a pin. January: Worked until now... pop off again plus hard on gas and idles really low. | ||
2011 Ford F-150 4dr Crew Cab 6.5ft bed
360-horsepower 5.0L V8 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in Yukon Territory, Canada Feb 2012 - Sep 2015 | |||
| Sep 20129920 mi | Console lid latch (plastic) broke, so entire lid was replaced. part was ordered ahead of time, then repair scheduled when part arrived. Truck returned in 1.5 hours | ||
| Jan 201312400 mi | Driver's side window intermittantly not working, so new switch installed. Still intermittently not working. | ||
| Aug 201426660 mi | recurrence of a faulty front driver's window switch. diagnosis made and part ordered | ||
| Sep 201427280 mi | new window switches installed in driver and passenger doors | ||
| Mar 201529140 mi | Warning the battery save mode was entered when ignition. turned to off position. Transfer case or front hubs grinding when 4x4 engaged while driving. Only happens at Temps below -20C | ||
| Ford F-150 in Alberta, Canada Sep 2011 - Oct 2013 | |||
| Sep 201214260 mi | Loud wind noise whistle from 80km/hr and up. Very loud door rattle when driving on rough or bumpy roads. The dealership said it was normal on all F-150's of that year. | ||
2011 Ford F-150 4dr Crew Cab 6.5ft bed
302-horsepower 3.7L V6 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in Wisconsin, United States Sep 2012 - Jun 2014 | |||
| Oct 201219500 mi | Truck began smoking. Transmission leak repaired under tsb 11-8-4. Pump and seal in bell housing area. Happened towing travel trailer in hilly area. | ||
| Mar 201330000 mi | Recall on turbo intercooler. | ||
| Jun 201436000 miUS $450 | Coolant leak in turbo hose was what i was told. quoted 1000 dollars and I balked, so they said 400...out of warranty by 500 miles. | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
turbocharged 365hp 3.5L V6 6-speed shiftable automatic RWD
| Ford F-150 in Texas, United States Oct 2012 - Jun 2018 | |||
| Apr 201319000 mi | Had to change out the actuator on AC that controls going from cold to warm air Right Rear shock leaking | ||
| Sep 201324000 mi | Had to grease the spline and replace the boot. Also did a update to transmission program | ||
| Jun 201550000 miUS $100 | Temp actuator had to be replaced. have done this before when it was 100% warranty, this time had to use extended and pay deductable | ||
| Dec 201782000 miUS $200 | Muffler replacement | ||
| May 201888000 miUS $750 | Replaced plugs and wires retuned to factory settings. Drained and flushed cooling system | ||
| Ford F-150 in Texas, United States Nov 2011 - Feb 2014 | |||
| Feb 201322300 mi | CV joint dry causing rough shifts and shuddering while braking. Dealer used a Ford kit to repack joint. | ||
| Feb 201439000 mi | Rough shifting problem returned. Dealer removed and greased the U-joint. | ||
| Ford F-150 in Georgia, United States Feb 2016 - Apr 2017 | |||
| Feb 201783000 miUS $261 | Engine light diagnosis was camshaft positing sensor on bank 1 and major oil leak on turbo bank 1. Patch fix for now will require major surgery to fix. repair not successful. | ||
| Apr 201785000 mi | Camshaft positing sensor on bank 1. Major oil leak on turbo bank 1. Would have been $2-3k to repair turbos. | ||
| Ford F-150 in Texas, United States Mar 2011 - Apr 2011 | |||
| Apr 20112000 mi | Vibration at any speed | ||
| Ford F-150 in Texas, United States May 2011 - Dec 2014 | |||
| Feb 201212300 mi | Drive would slip and bump when starting from a stop. Dashboard vent was broken | ||
| May 201330400 mi | Slippage and jerk from a stop and sometimes when accelerating from a cruise speed. Plastic vents broken while adjusting angle. | ||
| Ford F-150 in Florida, United States Apr 2011 - Apr 2017 | |||
| Mar 201336000 mi | Replaced termastatic control switch and relaxed front suspect | ||
| Jun 201341000 miUS $1500 | Replaced EPAS Tweaked transmission computer software adjustment | ||
| Dec 201472000 miUS $800 | Turn signal switch broken | ||
| Mar 201575000 miUS $500 | Miss firing engine in humid damp conditions. Replace plugs and wits and coils. Awful expensive tune up!!!!! Understand the Ecoboost may have issues with misfiring in humid damp conditions. Service bulletin is out. | ||
| Jul 201690800 miUS $800 | Coolant overflow tank broken and replaced | ||
| Sep 201695000 miUS $1600 | Rear bearings needed to be replaced | ||
| Apr 2017101000 miUS $350 | Rear end seal leaks again and had to repaired | ||
| Ford F-150 in Texas, United States Sep 2013 - Sep 2016 | |||
| Aug 201443000 miUS $100 | Sunroof would not close | ||
| Dec 201448000 mi | Wheel bearing on front drivers side wheel | ||
| Ford F-150 in North Carolina, United States Jan 2017 - Mar 2022 | |||
| Nov 2017108000 miUS $30 | Replaced fog lights | ||
| Mar 2022166000 miUS $760 | I turned on the defrost and the rear window shattered | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
turbocharged 365hp 3.5L V6 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in Massachusetts, United States Jun 2012 - Jun 2022 | |||
| Jun 201336000 mi | Transmission bangs when shifting from 1st to 2nd about 5% of the time. | ||
| Feb 201673600 miUS $1800 | Steering gear rack was replaced. | ||
| Dec 201687000 miUS $50 | Replace passenger heater blend door motor. | ||
| Ford F-150 in Massachusetts, United States Oct 2012 - Nov 2012 | |||
| Oct 201233000 mi | transmission replacement | ||
| Nov 201233000 mi | no sound from passenger speakers | ||
| Ford F-150 in Maryland, United States Jul 2012 - Sep 2013 | |||
| Nov 201210700 mi | WARNING "SERVICE ADVANCEDTRAC"-REPLACED STEERING RACK | ||
| Jan 201313000 mi | cover plate under engine came loose and hung down. fasteners failed. | ||
| Mar 201314000 mi | tire pressure sensor failed | ||
| Ford F-150 in Alabama, United States Dec 2012 - Mar 2015 | |||
| Mar 201315000 mi | Rear end was clunking when going into gear. They replaced the left axle, shimmed the driveshaft, adjusted back lash, replaced ring and pinion. | ||
| Sep 201427000 miUS $210 | the drive train still clunks, pop, bangs and rattles HVAC system is acting up. changes temp and fan speed on its own. both front seat heaters went out drivers side mirror heater not working | ||
| Mar 201530000 mi | Seat heated and driver side mirror heater never fixed. | ||
| Ford F-150 in Texas, United States Sep 2014 - Sep 2017 | |||
| Oct 201451000 miUS $26 | Bad plugs. Dealership wanted $400 to change them | ||
| Ford F-150 in Vermont, United States Jan 2012 - Feb 2018 | |||
| Jul 201722000 miUS $200 | Brakes were vibrating when applied at greater than 30mph. Rotors we're also quite rusty. The truck is not driven often. Rotors and pads replaced. Pads were not moving easily on caliper brackets. Caliper slides moved just fine. | ||
| Ford F-150 in North Carolina, United States Jun 2015 - Jun 2018 | |||
| Jan 201896000 miUS $54 | Check engine light. #2 cylinder misfire. Spark plugs due change at 100000 miles. Replaced plugs and ignition coil boots. Took care of problem. | ||
| Mar 201897000 miUS $250 | R2 worn brake pads and rotors front and rear | ||
| Ford F-150 in Massachusetts, United States May 2016 - Mar 2018 | |||
| Mar 201868000 miUS $900 | Wire harness failed requiring replacement. | ||
| Ford F-150 in Oklahoma, United States Apr 2016 - Jun 2022 | |||
| Jan 2022127000 miUS $450 | replace starter | ||
| Mar 2022129000 miUS $1600 | replace starter ring that was missing teeth and would not mesh with starter | ||
| Ford F-150 in California, United States Jan 2012 - Feb 2014 | |||
| Feb 2012 | Right Front tire had sensor data error. | ||
| Jun 201315000 mi | Abs control unit and sensor failure | ||
| Ford F-150 in Nevada, United States Sep 2014 - Aug 2017 | |||
| Sep 201643000 mi | Cold start rattle, TSB indicates a timing chain issue. Dealer could not replicate. | ||
| Aug 201758000 mi | None issue with TSB published of timing chain noise on cold starts. Repair is approx. 4K TSB has been updated 3 times to find a reliable fix. | ||
| Ford F-150 in Ontario, Canada Dec 2012 - Feb 2020 | |||
| May 201442440 miC $165 | Spark plugs needed to be replaced as cylinders weren't firing | ||
| Aug 201445920 miC $250 | Heated Seat Broke | ||
| Jul 201560320 miC $785 | Top of bed rusted. Confusing how this area rusted. No paint chips. | ||
| Jun 201675020 miC $2000 | timing chain went | ||
| Mar 201889900 miC $250 | Drivers side rear-door automatic lock no longer working. Needed new wiring brake switch broken - would leave the brake lights on & drain battery | ||
| Ford F-150 in Utah, United States Mar 2014 - Feb 2016 | |||
| Oct 201434500 miUS $300 | Heater blend door and gears replaced. | ||
| Ford F-150 in Texas, United States Jul 2014 - Dec 2017 | |||
| Sep 201437000 mi | Truck would lurch forward after a full stop. 1-2 SHIFT VALVE STICKING IN BORE CLEANED AND RECONDITIONED MAIN CONTROL. REINSTALLED REFILLED AND ROAD TEST VEHICLE RESET KAM AND REFLASHED TO LATEST CALIBRATION. | ||
| Ford F-150 in Ontario, Canada Jun 2013 - Jan 2015 | |||
| Jul 201335320 mi | This problem was never repaired. It bogs out when you try and floor the vehicle. The struts needed repairing as well. The rear seal bearing needed repairing as water had entered it. | ||
| Apr 201445760 miC $150 | We had issues with the struts again and we had issues with water getting into the rear axle again. We also had issues with the calipers sticking causing issues with the rotors, they replaced all the broken parts. | ||
| Oct 201457600 miC $800 | The electric motors would not work and back door remains on child safety lock , when door is open making it impossible to close sensor not working for doors Motor shakes violently upon acceleration to 100km/hr | ||
| Ford F-150 in Ontario, Canada Feb 2012 - Jun 2015 | |||
| May 201229800 mi | TSB was performed to update turbo software and reset transmission shift point. Much improved turbo response. | ||
| Dec 201370680 miC $25 | Air deflector on underside of transmission continues to come loose on the driver's side front corner. I have had this repaired 2x at the dealer and once myself. I expect the hardware will break again. | ||
| May 201481000 miC $650 | Vacuum boost pump failure required replacement. Pump would squeal loudly at startup. | ||
| Dec 201493000 miC $1700 | Timing chain and idler replacement at 145,000 km. Truck also suffers from intermittent misfire, associated with the buildup of moisture in the inter cooler. | ||
| Jun 201599200 miC $450 | Truck missfires on acceleration and while under load. Spark Plugs replaced - tests ok | ||
| Ford F-150 in Texas, United States May 2011 - Mar 2014 | |||
| May 201333600 mi | vent motor worn out | ||
| Jul 201336700 mi | electronic steering reduction gear wore out, steering would lock 5deg from center while moving for a second or so causing oversteer to correct | ||
| Ford F-150 in Virginia, United States May 2011 - Dec 2014 | |||
| Sep 201236000 miUS $80 | TSB for Intercooler condensation. Installed Intercooler deflector and flashed newest updates | ||
| Nov 201356000 miUS $66 | Intercooler TSB for condensation issue | ||
| Jun 201470000 miUS $135 | Pcv hose clamp failure. Limp home mode. | ||
| Ford F-150 in Minnesota, United States Jul 2011 - Jun 2015 | |||
| Mar 201320000 mi | Sync voice commands unavailable when USB drives are attached. | ||
| Jul 201437300 mi | Engine noise on startup. Dealer replaced high pressure fuel pump. | ||
| Jun 201548000 mi | Loud mechanical noise on engine start. same symptoms as last summer. | ||
| Ford F-150 in Texas, United States Jan 2013 - Mar 2014 | |||
| Aug 201342000 mi | Rear differential TSB for clicking | ||
| Ford F-150 in North Carolina, United States Sep 2011 - Mar 2013 | |||
| Jul 201232200 mi | Water was leaking from the passenger grab handle top bolt. The dealer had to pull the windshield and repair a "pinhole" body seam leak. | ||
| Ford F-150 in Kansas, United States Jun 2011 - Aug 2015 | |||
| Jun 201469000 miUS $200 | Leaking radiator overflow tank. | ||
| Jan 201520800 mi | Fixed leaking radiator overflow tank. The truck was out of warranty and the Ford repair estimate was absurdly high for a leaking radiator hose. My repair held until the truck was traded in last week. | ||
| Ford F-150 in Kentucky, United States May 2011 - Jun 2018 | |||
| Dec 201426000 mi | Rear defrost stopped working. Not a fuse. | ||
| Ford F-150 in Kansas, United States May 2011 - Feb 2012 | |||
| Nov 201113000 mi | Sync erratic, forgetful & unreliable. Reflash TSB 11-10-22 & 11-10-15 MPG better by 3.5 | ||
| Feb 201215000 mi | Mileage went from 20-25mpg to 12-13mpg and continued to drop. Engine cut out on acceleration, no CEL. TSB 12-2-10 should have fixed it, but dealer service would not do it. Great truck, but was broken. Traded it. | ||
| Ford F-150 in Michigan, United States Mar 2011 - Sep 2018 | |||
| Aug 201215800 mi | Check engine light, required catalytic converter replacement. | ||
| Mar 201437000 mi | Catalytic converter replaced | ||
| May 201765000 miUS $150 | Rear power lock actuator failed. Power lock actuator failed on the other rear door about 1 month later, soon after I replaced the first one. | ||
| Ford F-150 in Texas, United States Feb 2011 - Dec 2012 | |||
| Aug 201242800 miUS $72 | The spring that keeps the fuel door closed quit working. Had to remove the defective "fuel door housing" and replace with a new one. Cost: $72 plus 30 minutes of time. | ||
| Ford F-150 in Minnesota, United States Feb 2011 - Mar 2014 | |||
| Aug 20113000 mi | Transmission was experiencing a rough 2-1 downshift. Service repair bulletin existed for known problem with limited number of 6R80 transmissions - friction plate replacement done. | ||
| Ford F-150 in Texas, United States Mar 2011 - Aug 2013 | |||
| Dec 201220000 mi | Dealer discovered vct solenoid valve seal was leaking oil. Replaced solenoid valve and seal. | ||
| Aug 201328000 mi | Sending unit in gas tank not reading correctly. Would not show a full tank of gas on gauge, Dealer had to replace both sending unit and gas pump. | ||
| Ford F-150 in Texas, United States Mar 2011 - Apr 2019 | |||
| Jan 201451000 miUS $2 | Fuel door started making noise when opened. This is due to the hinge assy coming apart. Pulled fuel door assy from car and re secured the hinge pin and then made a locking pin to prevent from happening again. Fuel door would not stay closed. Pulled the fuel door assembly out of body and reassembled it where it had fallen apart. Fabricated a pin and washer to keep it from happening again. Common problem. To replace the part would have been $60. | ||
| Jul 201470200 mi | The antennae for my sat radio went out and I have decided not to repair it - I simply don't feel like tearing the car apart to fix it! I cancelled the service for this car and now listen to terrestrial radio on the HD dial, its better! | ||
| Dec 201591000 miUS $170 | Replaced 5 yr old battery that was cranking slow on cold mornings. Replaced with Motorcraft battery of same CCA. Problem fixed. | ||
| Jun 2017106000 miUS $450 | My 2011 Ecoboost FX4 has an auxiliary vacuum pump to keep the power brakes and 4WD working. It is electrically driven and prone to failure - Ford even has TSB on it where the dealer will replace it free under warranty. Problem is the dealer I'd wind up going to is terrible. Bought the part from Tasca parts online and did the repairs myself. Ford extended the warranty on the pumps for up to 10 years or 150k miles. Was worth the $400+ to keep my truck out of harms way (dealer screw ups). Truck is fine now. | ||
| Jan 2018111000 miUS $100 | Replaced sway bar end links, had gotten loose and noisy over bumps. Problem solved. | ||
| Ford F-150 in Alberta, Canada May 2011 - Apr 2015 | |||
| Apr 201211100 mi | replaced a coil pack #5 | ||
| Apr 201579360 mi | catalytic converter was clogged. | ||
| Ford F-150 in Alberta, Canada Aug 2011 - Jan 2014 | |||
| Dec 201111160 mi | Driver side power seat making squealing noise when adjust forward or backward. Seat track broken, replaced Driver door weatherstripping coming detached | ||
| Apr 201219840 mi | Rust spots and paint bubbles on tailgate. Ford Canada refused warranty repair because vehicle over 20K km | ||
| Jun 201226660 mi | Tailgate had rust spots showing through after less than 8 months ownership. Ford Canada denied warranty claim, but dealership had several similar complaints and petitioned Ford on behalf of several customers. Ford repainted tailgate. | ||
| Oct 201361740 miC $500 | Rear defrost not working, problem diagnosed as defective electronics in rear window. Estimated cost to repair $2000.00 Owner will try and source a more cost effective repair option before proceeding with repair. Engine would stutter and loose power under hard acceleration. First trip dealer installed a deflector in front of turbo inter-cooler as per TSB. Second trip, all spark plugs and coils replaced. Second action successful. | ||
| Ford F-150 in Georgia, United States Feb 2012 - Sep 2014 | |||
| Mar 201435000 miUS $100 | The engine light came on and started skipping when I floored it to accelerate into interstate traffic. Weather was cool and rainy and thought I had the intercooler problem which is prominently discussed on internet. Heavier duty plugs id | ||
| Ford F-150 in Texas, United States Feb 2012 - Dec 2016 | |||
| Mar 20138000 mi | Defective rear speaker | ||
| Sep 201415000 mi | Defective Speaker replaced by the dealer at no charge. | ||
| Mar 201517000 mi | Tire Pressure Monitoring System. One tire had failed sensor which was replaced under warranty. | ||
| Ford F-150 in New Jersey, United States Dec 2011 - Oct 2017 | |||
| Sep 20128000 mi | Driver side door speaker would go in and out. Dealer replace speaker. | ||
| Feb 201539300 mi | Rear window shattered due to cold and electric heating element. I found many cases reported on Internet of a similar incident. In the end it was covered under my extended warranty. | ||
| Ford F-150 in Ohio, United States Sep 2011 - Jan 2015 | |||
| Oct 201221000 mi | Engine would go to limp mode and run rough after trying to briskly accelerate after driving at cruising speed for 2 hours or so. Required a restart. Ford installed an air diverter to the turbo air intake. | ||
| Jun 201333000 mi | Engine would stumble and then go into limp mode. IE rpm would be limited to 45-50 mph. Engine light did not come on this time. New air intake prevents moisture build up (which reduces air flow). Still happens after driving the truck for over 3-5 hours. | ||
| Sep 201338000 mi | Engine would stumble and limit power when attempting to accelerate rapidly. Another intake diverter was added to the engine. This appears to have solved this issue. I have not been able to repeat this issue since the truck went in for repa. | ||
| Ford F-150 in Wisconsin, United States Oct 2011 - Sep 2012 | |||
| Jun 201210000 mi | A VERY slight ticking/squeaking sound coming from the driver's door. Just enough to be anoying. | ||
| Sep 201214000 mi | drivers side door trim rattle, again. | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
411-horsepower 6.2L V8 6-speed shiftable automatic RWD
| Ford F-150 in Georgia, United States Nov 2011 - Sep 2019 | |||
| Sep 201324000 mi | Perform TSB 12-7-13 for Rear Driveshaft Slip/Bump. | ||
| May 201433000 mi | Speaker crackling noise. | ||
| Dec 201445000 miUS $400 | High pressure line on power steering system was leaking. Replaced with revised high pressure line and new fluid. | ||
| Jan 201620700 miUS $443 | Humming (propeller) noise from right front corner (speed-dependent and would disappear when turning to the right). Dealer diagnosed bad right front wheel bearing and replaced entire hub assembly. | ||
| Jun 201667000 miUS $211 | Fuel door spring broke. Required new fuel door housing assembly because spring is not available separately. | ||
| Feb 2019107 mi | Perform Ford Recall #19S07 for 6R80 Sudden Transmission Downshift Powertrain Control Module Programming | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
411-horsepower 6.2L V8 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in Mississippi, United States Sep 2014 - Jun 2018 | |||
| Jan 201575300 miUS $750 | Front brakes became stuck, with the pads continually scrubbing the rotors. Had to replace front rotors and pads on both sides, and replace the passenger side caliper. | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
411-horsepower 6.2L V8 6-speed shiftable automatic 4WD
| Ford F-150 in Saskatchewan, Canada Jan 2013 - Feb 2022 | |||
| Mar 201325420 miC $60 | leaky power steering pressure hose (barely weeping) | ||
| May 201444640 miC $1000 | Foxx shocks leaked and needed to be replaced. | ||
| Nov 201450840 miC $205 | No start. Towed. Fuse 27. Fuel relay system. | ||
| Jan 201554000 miC $100 | broken cable | ||
| Mar 201560760 miC $800 | cracked boot on front driveshaft leading to worn ujoint and vibration at slow speed | ||
| Oct 201683080 miC $1700 | both front and rear pinion seal seat heater on driver side repaired | ||
| Jun 201788660 miC $1300 | Upper ball joint and cv boot | ||
| Jan 2022145700 miC $2200 | New shocks | ||
| Ford F-150 in Washington, United States Feb 2016 - Jun 2019 | |||
| Mar 201683000 miUS $2200 | Defrost and floor vents didn't blow, only from dash. Climate control module replaced. | ||
| Jul 201685500 miUS $75 | Blend air door motor teeth stripped and would click loudly upon start up or use of climate controls. | ||
| Feb 201793000 miUS $520 | Grinding noise from front end when turning at low speed. 4WD system inspected. All diff & PTU fluids replaced. | ||
| Nov 2017100000 miUS $300 | Driver front inside pad had worn away and backing plate was scoring the disc. Replaced front rotors & pads. | ||
| Jul 2018105000 mi | Truck died 10 min into trip one day. Towed to repair shop. Nothing major found. Trouble code for faulty knock sensor. Knock sensors & 100k maintenance performed DIY. | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
360-horsepower 5.0L V8 6-speed shiftable automatic RWD
| Ford F-150 in Louisiana, United States May 2011 - Sep 2015 | |||
| Oct 20116000 mi | Electric power steering malfunctioning Driver seat cover started to unravel. | ||
| Dec 20118000 mi | Replaced rack and electric power assist | ||
| Aug 201218000 mi | leak at bell housing pump and seal replaced | ||
| Mar 201327000 mi | drive line pop on hard acceleration | ||
| Ford F-150 in South Carolina, United States May 2014 - Apr 2018 | |||
| Apr 2016147800 miUS $600 | Replaced ac clutch and compressor. Then changed blend door behind the nav screen. | ||
| Jan 2017146300 miUS $500 | Oil pan gasket. | ||
| Feb 2018185000 miUS $60 | Main coolant T connector and o-ring for upper radiator hose replaced. | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
360-horsepower 5.0L V8 6-speed shiftable automatic 4WD, part-time w/low range
| Ford F-150 in Mississippi, United States Dec 2015 - Jun 2022 | |||
| Oct 2017114000 miUS $75 | Starting the engine became sluggish so I replaced the battery | ||
| Ford F-150 in Arizona, United States Oct 2017 - Dec 2018 | |||
| Aug 2017116000 miUS $300 | engine replaced | ||
| Sep 2017116000 miUS $100 | oil pressure failure engine replaced | ||
| Ford F-150 in Alabama, United States Oct 2012 - Oct 2013 | |||
| Nov 201218200 mi | rear glass defrost was not working | ||
| Ford F-150 in Wisconsin, United States Feb 2011 - Sep 2015 | |||
| Oct 201235500 mi | Plastic latch on seat storage compartment fell apart. Sloppy fix. Fell apart again after two weeks. | ||
| Dec 201238000 mi | Plastic latch on seat storage compartment fell apart. Better fix, replaced entire $300 seat piece. | ||
| Apr 201343300 miUS $100 | Plastic latch on seat storage compartment fell apart again. Now out of warranty. Ford picking up 80 percent. | ||
| Ford F-150 in Virginia, United States Mar 2012 - Jun 2014 | |||
| Jan 201326000 mi | airbag readiness sensor malfunction | ||
| Ford F-150 in Washington, United States Nov 2017 - Jun 2018 | |||
| Mar 2018118000 miUS $350 | A plug was loose that goes into the engine and it made the truck go into safe mode and would not work | ||
| Ford F-150 in Washington, United States Aug 2011 - Nov 2017 | |||
| Sep 201758000 miUS $1150 | Electric fuel pump in fuel tank was not providing sufficient pressure at higher rpms | ||
| Ford F-150 in North Carolina, United States Feb 2011 - Nov 2011 | |||
| Aug 201110000 mi | Transmission leak and shuttering while driving. Dealer replaced pump and seal as per TSB 11-8-4. | ||
| Nov 201114000 mi | Hard shifting and shuddering. 4 tranny solenoids need to be replaced per TSB 11-11-11, parts on national back order. Truck still at dealer going on 3 weeks. Hard shifting and shuddering. 4 tranny solenoids need to be replaced per TSB 11-11-11, parts on national back order. Truck still at dealer going on 3 weeks. | ||
| Ford F-150 in Massachusetts, United States Jun 2011 - Nov 2018 | |||
| May 201316000 mi | Truck stalled and would not run. Initially diagnosed a MAF failure, the truck again stalled and ultimately it was found that there was a bad check valve. Two visits, now seem fixed fingers crossed. | ||
| Aug 201316000 mi | Truck stalled and failed a third time! This time diagnosed as an evaporative system failure. Was examine by Ford, computer reflash as well. | ||
| Jul 201420300 mi | Weather stripping around the drivers side rear door came loose and fell off. Replaced under warranty. | ||
| Ford F-150 in Pennsylvania, United States Aug 2011 - Jun 2018 | |||
| Dec 20113000 mi | Driver headlight fogging up inside. Dealer replaced entire headlight assembly under warranty. | ||
| Feb 201421500 miUS $30 | Battery terminal corroding Passenger seat squeaks when unoccupied Passenger power mirror randomly moves/readjusts itself. | ||
| Feb 201528000 miUS $100 | fan control module went bad. would only blow on high through defrosters. replaced bad module | ||
| Oct 201531300 mi | Ring and pinion seal leaking. Repaired under drive train warranty. | ||
| Apr 201746670 miUS $116 | Check Fuel Inlet message. Dealer cleaned capless fuel fill system and reset computer. | ||
| Sep 201753000 miUS $119 | New Battery | ||
| Apr 201859000 miUS $300 | one of the control motors in the hvac distribution box stopped working and needed replaced | ||
| Jun 201863000 miUS $1750 | Replaced front brakes/rotors, new tires. Both front struts. | ||
| Ford F-150 in Alberta, Canada May 2011 - Mar 2012 | |||
| Jan 2012 | Transmission Leak - Pump, seals and tranny bolts replaced | ||
| Ford F-150 in Texas, United States Aug 2014 - Jan 2022 | |||
| Sep 201569000 mi | I've noticed significant rust on the bed cross member visible from the right rear wheel well. I took it to the local Ford dealer. They took pics and sent it into Ford. The claim was denied since it wasn't sheet metal. | ||
| Oct 2021178000 miUS $600 | Ignition coil packs and spark plugs replacement | ||
| Jan 2022185000 miUS $100 | leaking coolant hose connection | ||
| Ford F-150 in Minnesota, United States Jul 2011 - Sep 2014 | |||
| Sep 20128000 mi | Power Steering column adjusting motor replaced | ||
| Ford F-150 in Texas, United States Sep 2011 - Mar 2015 | |||
| Oct 20115000 mi | Passenger Front Door Window Intermittant from Driver's Door Switch. R2 Switch. | ||
| Mar 201443000 miUS $50 | Temperature blend door actuator ratcheting in lower 4 cool temperatures. Found this is a common problem not only with Fords, but General Motors and Chyrsler. | ||
| Jan 20157000 miUS $60 | Fuel door hinge broke. Replaced fuel filler assembly. Hard to disengage assembly catches. | ||
| Ford F-150 in Georgia, United States Jul 2011 - Oct 2014 | |||
| Sep 201221000 mi | automatic air condition, blower quit working | ||
| Sep 201436000 mi | Key switch would not go into off position, key would not come out of key slot | ||
| Ford F-150 in Georgia, United States Jul 2011 - Mar 2018 | |||
| Feb 201638600 miUS $10 | Water leak in cab thru brake light above rear window. Seal was bad and can't be replaced without buying a new light. Removed seal under light and replaced with some weather stripping. | ||
| Dec 201748000 miUS $23 | Driver's side heated seat element burnt out. Replaced the heating element under the seat cover. | ||
| Ford F-150 in Illinois, United States Jun 2014 - Sep 2016 | |||
| Mar 201643000 miUS $450 | Door rattle | ||
| Ford F-150 in Florida, United States Jul 2011 - Jun 2022 | |||
| Aug 20113000 mi | Moonroof had an issue where when it closed it dragged sticky insulation material from inside the roof area. Cosmetic but messy. Dealer had it totally disassembled, cleaned and adjusted. Repair was Satisfactory. | ||
| Jul 201669700 miUS $1500 | Brake master cylinder seal failed where all brake fluid leaked into the power brake booster. Replacement parts were defective so that it took three master cylinders and two power brake boosters before it was fixed. The front rotors were turned and pads replaced. The second time in less than a year. Both front calipers and hoses were replaced. The rear pads were replaced and rotors turned. | ||
| Aug 201670000 miUS $50 | The battery died. It was the original battery, 5 1/2 years old. An expected repair. | ||
| May 201892000 mi | Diagnosed that the A/C blower motor resistor had failed (likely caused by low battery voltage on the drive home). This was evidenced by the blower only working in off or full speed. Ordered a Ford replacement part on amazon for $64 and it took 5 minutes to replace. Took the truck to my mechanic to check the charging system, which is working normally. Was pleased that the truck got me home and blame the cheap battery, not the truck for this problem. Battery shorted out at less than 2 years old. Got a jump start and was able to drive home. Got a free replacement battery and installed it. | ||
| Nov 2020139000 miUS $631 | Backup camera failed and required replacement. | ||
| Sep 2021149000 miUS $38 | Broken exhaust manifold clamp. | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
360-horsepower 5.0L V8 6-speed automatic RWD
| Ford F-150 in Oklahoma, United States Jun 2013 - Jun 2022 | |||
| Dec 201737000 miUS $237 | Replaced HVAC blend door actuator. | ||
| Ford F-150 in Texas, United States Aug 2011 - Oct 2016 | |||
| May 201341100 mi | Gas Tank door stopped stay close. Dealer wanted $200 to repair. It took me about 45 minutes to take care of it. No parts required. I have to mention that a person who came up with this design is an idiot. | ||
| Feb 201457000 mi | drive shaft needed to be lubricated | ||
| Ford F-150 in Texas, United States Oct 2011 - Oct 2016 | |||
| Nov 201218900 mi | Driver seat had a squeak | ||
| Mar 201326000 mi | Driveshaft slip joint needed to be lubed | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
360-horsepower 5.0L V8 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in New York, United States Feb 2016 - Jul 2016 | |||
| Mar 201679000 miUS $563 | Transmission fluid flush and reprogramming; kept slipping going into third gear | ||
| Jul 201686000 miUS $1 | A/C drainage leak into passenger compartment; fixed by repairing seals | ||
2011 Ford F-150 4dr Crew Cab 5.5ft bed
302-horsepower 3.7L V6 6-speed automatic 4WD, part-time w/low range
| Ford F-150 in Missouri, United States Oct 2012 - Feb 2014 | |||
| May 201222000 miUS $780 | Transmission seals repaired | ||
| Aug 201342000 miUS $6000 | Engine replaced under warranty. | ||
2011 Ford F-150 4-door
6-cylinder automatic 2WD
| Ford F-150 in North Carolina, United States Feb 2013 - Mar 2013 | |||
| Mar 201345000 mi | right side rear door needed to be readjusted | ||
See TrueDelta's information for all Pickups
See TrueDelta's information for all Ford models.
