| 1 | 0 | 3 | 4 | 3 | 4 |
2004 GMC Envoy repairs by problem area
Engine (33%)
Transmission and Drivetrain (1%)
Brakes and Traction Control (4%)
Suspension and Steering (30%)
Electrical and Air Conditioning (29%)
Paint, Rust, Leaks, Rattles, and Trim (3%)
Other (0%)
Chart based on 70 repairs.
2004 GMC Envoy engine repair cost distribution
$2500+ (0%)
$1000 - $2499 (20%)
$500 - $999 (20%)
$100 - $499 (35%)
< $100 (25%)
Chart based on 20 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2004 GMC Envoy 4dr SUV, ext.
290-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| 62000 mi US $700 |
Radiator leaking |
| 68200 mi C $1200 |
Replaced fuel pump and fuel filter Replaced water pump |
| 65000 mi US $100 |
cat converter needed to be replaced.took it to and indempendent shop and they diagnosed, told me that part is covered by gm for 8yrs and dealership should do for zero charge, they did. Cost $100 at first shop |
| 127000 mi US $2100 |
fuel pump belts squeaking |
2004 GMC Envoy 4dr SUV, ext.
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 160000 mi US $300 |
AN unauthorized tow driver, yanked our vehicle up onto a rollback while this RWD car was still in park! Next driver, moved car 100' over and proceeded to SHAKE it off his rollback and back down to the ground. PLUS, said driver damaged rear fascia where our trailer hookup is located....dumb driver damaged said fascia because they first attempted to tow our car WHILE still attached to our trailer! How do you spell dumb, and illegal?? |
| 85000 mi US $385 |
replaced drivers side wheel hub and ABS sensor |
| 135000 mi US $150 |
manifold cracked, purchased a new one and installed. |
| 146300 mi US $1600 |
Miss on cylinder 6, new plugs, replaced coil pack, found it had burned exhaust valve. |
2004 GMC Envoy 4dr SUV
290-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| 176300 mi US $60 |
Replace front oxygen sensor |
| 178000 mi US $150 |
Replace radiator |
| 178200 mi US $115 |
Replace thermostat, idler pulley, tensioner pulley, belt |
2004 GMC Envoy 4dr SUV
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 65920 mi C $750 |
Fuel sending unit had rusted out from salt exposure. Tank removed, unit, fuel filter, and hose ends replaced. |
| 78000 mi US $650 |
both forward and rear o2 sensors failed. they were replaced |
| 68000 mi | Envoy went in for Check engine light turned out to be a air pump sensor. While in shop they noticed the water pump was leaking. Replaced. Fan clutch was also replaced. They also noticed that the cam actuator solenoid was leaking. Replaced. |
| 147000 mi US $600 |
Throttle Body replaced. |
| 55800 mi | Air pump gate (valve) cleaned. Code P0410 |
| 57040 mi C $40 |
Relay for exhaust airpump sensor. |
| 78000 mi US $35 |
The AIR system comtinues to give multiple problems on this model year GM Vehicle. A drop of water can freeze in the pump and cause these un-desired effects. In my professional opinion it is caused by another GM Design flaw. I took the piping loose and ble |
2004 GMC Envoy 4-door
4-cylinder automatic 2WD
| 117000 mi US $187 |
misfire at cyl6 after changing plugs and fuel filter. Checked plugs for cracking and gap, no problems, compression test okay, fuel economy has declined by 25%. Coils okay. no stalling, hesitation, or overheating, idles roughly. |
See TrueDelta's information for all SUVs
See TrueDelta's information for all GMC models.
