| 1 | 0 | 3 | 4 | 3 | 4 |
2004 GMC Envoy repairs by problem area
Engine (33%)
Transmission and Drivetrain (1%)
Brakes and Traction Control (4%)
Suspension and Steering (30%)
Electrical and Air Conditioning (29%)
Paint, Rust, Leaks, Rattles, and Trim (3%)
Other (0%)
Chart based on 70 repairs.
2004 GMC Envoy repair cost distribution
$2500+ (0%)
$1000 - $2499 (10%)
$500 - $999 (24%)
$100 - $499 (41%)
< $100 (25%)
Chart based on 59 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2004 GMC Envoy
Engine not specified
| GMC Envoy in Indiana, United States Jul 2012 - Jul 2013 | |||
| Jun 2013162000 miUS $600 | Dash quit. Top rear window motor, chauffeur window motor, and drivers side window control were bad | ||
| GMC Envoy in Wisconsin, United States Oct 2010 - Dec 2011 | |||
| Nov 201069000 miUS $450 | speedometer worked intermittantly. Replaced entire dash cluster. | ||
| Nov 201178000 mi | Suspension linkage repairs both front and back | ||
2004 GMC Envoy 4dr SUV, ext.
290-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| GMC Envoy in Washington, United States Dec 2009 - Jan 2015 | |||
| Oct 200965000 miUS $100 | cat converter needed to be replaced.took it to and indempendent shop and they diagnosed, told me that part is covered by gm for 8yrs and dealership should do for zero charge, they did. Cost $100 at first shop | ||
| Jan 201565000 miUS $2100 | fuel pump belts squeaking | ||
| GMC Envoy in Ontario, Canada Jun 2009 - May 2011 | |||
| Aug 201068200 miC $1200 | Replaced fuel pump and fuel filter Replaced water pump | ||
| Oct 201068820 miC $600 | Replaced front wheel bearing and tie-rod end. | ||
| GMC Envoy in New York, United States Sep 2011 - Mar 2015 | |||
| Jan 201480300 miUS $200 | Replaced right front wheel bearing Replaced right tie rod | ||
| Apr 201469000 miUS $75 | Replace right front wheel bearing again, parts warranty | ||
| Jul 201473300 miUS $300 | Leaking power steering fluid | ||
| Jan 201566700 miUS $700 | Radiator leaking | ||
2004 GMC Envoy 4dr SUV, ext.
275-horsepower 4.2L I6 4-speed automatic RWD
| GMC Envoy in Oregon, United States Mar 2011 - Jun 2022 | |||
| Feb 201461000 miUS $33 | Blower Motor Resistor replaced. | ||
| Nov 201567900 mi | left rear door lock actuator replaced | ||
2004 GMC Envoy 4dr SUV, ext.
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| GMC Envoy in Kentucky, United States Jul 2022 - Jul 2022 | |||
| Jul 2022170000 mi | Brakes went out so we replaced all four sets of brake pads, all four rotors, all calipers, master cylinder, and brake booster. We still have no brakes. We don't know what's wrong. | ||
| GMC Envoy in Tennessee, United States Feb 2015 - Sep 2016 | |||
| Feb 2015135000 miUS $150 | manifold cracked, purchased a new one and installed. | ||
| Nov 2015146300 miUS $1600 | Miss on cylinder 6, new plugs, replaced coil pack, found it had burned exhaust valve. | ||
| GMC Envoy in Maine, United States Feb 2010 - Dec 2011 | |||
| Dec 201085000 miUS $385 | replaced drivers side wheel hub and ABS sensor | ||
| Mar 201199000 miUS $500 | Front left Strut had blown, Front right side tie rod end wornout, both rear shocks wornout | ||
| GMC Envoy in South Dakota, United States Feb 2012 - Jun 2012 | |||
| Apr 2012113000 miUS $265 | return a/c line repaired as previous repair was poorly done. | ||
| GMC Envoy in Idaho, United States May 2016 - Jun 2018 | |||
| May 2016136632 miUS $107 | AC recharge Axle seal Owner reported leak in AC system. Dealer tested and found pass side line needs replacing. Dealer estimated cost at $600 prts + $600 lbr. Owner chose not to repair at this time. | ||
| Nov 2016133451 miUS $250 | Dash gauges not working at all | ||
| GMC Envoy in Virginia, United States Jun 2016 - Apr 2018 | |||
| Sep 2017160000 miUS $300 | AN unauthorized tow driver, yanked our vehicle up onto a rollback while this RWD car was still in park! Next driver, moved car 100' over and proceeded to SHAKE it off his rollback and back down to the ground. PLUS, said driver damaged rear fascia where our trailer hookup is located....dumb driver damaged said fascia because they first attempted to tow our car WHILE still attached to our trailer! How do you spell dumb, and illegal?? | ||
| Mar 2018165000 miUS $800 | Power steering pump. this vehicle was recently sold. We put over $3000 into a $5000 car in less than 15,000 miles in less than 2 years. Good bye XUV, never again. | ||
| GMC Envoy in Pennsylvania, United States Oct 2013 - Mar 2018 | |||
| May 2013100000 miUS $250 | replace power steering cooler | ||
| Aug 2017133000 miUS $600 | Replace ball joint, tie rod, PA inspection | ||
2004 GMC Envoy 4dr SUV
290-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| GMC Envoy in Arizona, United States Jan 2013 - Dec 2015 | |||
| Dec 201575000 mi | Sunroof jammed open, had to have dealer close it. Estimate for repair was well over $1500 so we chose to just close it. | ||
| GMC Envoy in Pennsylvania, United States Dec 2014 - Nov 2016 | |||
| Feb 2015175900 miUS $2400 | Replace front carrier | ||
| Mar 2015176000 miUS $50 | Replace front crash sensors (2) Replace instrument panel gage motors | ||
| Apr 2015176300 miUS $60 | Replace front wheel hub (bearing) Replace front oxygen sensor | ||
| May 2015176900 miUS $95 | Replace tailgate window regulator | ||
| Jul 2015178000 miUS $150 | Replace radiator | ||
| Aug 2015178200 miUS $70 | Replace AC condenser, dryer, expansion valve, compressor, drive belt, evacuate system and recharge Replace thermostat, idler pulley, tensioner pulley, belt Replace steering pump cooler | ||
| Jan 2016175800 miUS $657 | Repair emergency brake and backing plates Replace both rear stabilizer bars | ||
| Nov 2016180000 mi | Rusted frame, will no longer pass inspection | ||
2004 GMC Envoy 4dr SUV
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| GMC Envoy in Pennsylvania, United States Dec 2011 - Jan 2012 | |||
| Jan 2012US $541 | Front sway bar was cracked and both sway bar liks were worn also. Rear axle backing plates were rusted and not holding e-brake. Rear axle bearings and axle seals also were replaced. | ||
| GMC Envoy in New Jersey, United States Jul 2011 - Aug 2011 | |||
| Aug 2011127000 miUS $479 | Wheel bearing right front side Ball bearings | ||
| GMC Envoy in Wisconsin, United States Jul 2010 - Jul 2012 | |||
| Aug 201050000 miUS $396 | right rear stabilizer link repaired. | ||
| May 201152300 miUS $130 | replace left rear back up lamp assembly: socket, lamp and bulb. | ||
| GMC Envoy in Michigan, United States Sep 2008 - Mar 2013 | |||
| Jul 200840030 mi | Had IP Cluster replaced because Speedo stoped working | ||
| Nov 200845240 miUS $1021 | Replaced Rack/Gear Assembly because of noise in steering | ||
| Jul 201068000 mi | Envoy went in for Check engine light turned out to be a air pump sensor. While in shop they noticed the water pump was leaking. Replaced. Fan clutch was also replaced. They also noticed that the cam actuator solenoid was leaking. Replaced. | ||
| GMC Envoy in Alabama, United States Nov 2008 - Mar 2010 | |||
| Dec 200878000 miUS $35 | The AIR system comtinues to give multiple problems on this model year GM Vehicle. A drop of water can freeze in the pump and cause these un-desired effects. In my professional opinion it is caused by another GM Design flaw. I took the piping loose and ble | ||
| GMC Envoy in Ontario, Canada Apr 2008 - Mar 2010 | |||
| Aug 200852080 miC $300 | Front wheel bearing. | ||
| Mar 200955800 mi | Left front wheel hub and bearing. Air pump gate (valve) cleaned. Code P0410 | ||
| Jun 200957040 miC $40 | Relay for exhaust airpump sensor. | ||
| GMC Envoy in Ontario, Canada Sep 2011 - Dec 2011 | |||
| Nov 201165920 miC $750 | Fuel sending unit had rusted out from salt exposure. Tank removed, unit, fuel filter, and hose ends replaced. | ||
| GMC Envoy in West Virginia, United States Jul 2011 - Jul 2012 | |||
| Aug 2011146000 miUS $150 | Both Front Calipers Replaced due to sticking problems. Also replaced rotors and pads. | ||
| Nov 2011147000 miUS $600 | Throttle Body replaced. Fan motor resistor replaced. | ||
| GMC Envoy in West Virginia, United States Jul 2008 - May 2009 | |||
| Aug 200868000 miUS $400 | Instrument cluster stopped working. GMC refused assistance for Envoy, although there is a current recall for the larger trucks. Vehicles must fall under 70K miles to be covered--too low considering the years involved. | ||
| Mar 200973000 miUS $85 | To dealer for mechanical diagnosis of faulty instrument panel cluster--required by GM in order to qualify for assistance. Assistance declined once again after official diagnosis. Will escalate problem from current status. | ||
| GMC Envoy in Missouri, United States Jun 2011 - Jun 2012 | |||
| Sep 201178000 miUS $650 | both forward and rear o2 sensors failed. they were replaced vent came off. water leaked onto floor. put back on. | ||
2004 GMC Envoy 4dr SUV
| GMC Envoy in California, United States Dec 2017 - Jul 2018 | |||
| Mar 2018121000 miUS $600 | this car is a lemon [alternator or starter?] electric is bad | ||
2004 GMC Envoy 4-door
4-cylinder automatic 2WD
| GMC Envoy in Texas, United States Nov 2010 - Jun 2011 | |||
| Dec 2010117000 miUS $187 | misfire at cyl6 after changing plugs and fuel filter. Checked plugs for cracking and gap, no problems, compression test okay, fuel economy has declined by 25%. Coils okay. no stalling, hesitation, or overheating, idles roughly. | ||
See TrueDelta's information for all SUVs
See TrueDelta's information for all GMC models.
