| 1 | 0 | 3 | 4 | 3 | 4 |
2004 GMC Yukon repairs by problem area
Engine (30%)
Transmission and Drivetrain (11%)
Brakes and Traction Control (11%)
Suspension and Steering (12%)
Electrical and Air Conditioning (36%)
Paint, Rust, Leaks, Rattles, and Trim (0%)
Other (1%)
Select a problem area
Chart based on 113 repairs.
2004 GMC Yukon engine repair cost distribution
$2500+ (0%)
$1000 - $2499 (12%)
$500 - $999 (18%)
$100 - $499 (44%)
< $100 (26%)
Chart based on 34 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2004 GMC Yukon
Engine not specified
| 67000 mi US $50 |
replaced thermostat |
2004 GMC Yukon 4dr SUV, ext.
335-horsepower 6.0L V8 4-speed automatic AWD
| 108000 mi | Spun crankshaft bearing |
2004 GMC Yukon 4dr SUV, ext.
295-horsepower 5.3L V8 4-speed automatic RWD
| 113100 mi | Replaced intake manifold gasket under the warranty from the dealer where we purchased the car. |
| 114300 mi US $15 |
Exhaust rattling noise. A heat shield was loose causing a rattle. The problem was fixed for $15 at Midas by tightening up the heat shield. |
| 141200 mi US $300 |
The water pump was leaking. I replaced the water pump, thermostat, hoses, and belts. The time would have been much less but I am very inexperienced. But I tackled it myself pretty easily. |
| 190000 mi US $2000 |
Rear Main Seal Replacement, as well as some other seals and gaskets. |
| 192000 mi US $50 |
The coolant reservoir was low so I added more coolant. I might have a leak but it has not shown up yet after a few months, so if it is a leak it is very minor. |
2004 GMC Yukon 4dr SUV, ext.
295-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| 135000 mi US $49 |
Check Engine Light Came on with Code P0466 - Purge Flow Sensor Circuit. I examined the valve on the manifold and found it to be dirty. Replaced with a new one and cleared the code. Has been fine for a week now. |
| 70000 mi US $200 |
Water pump failed and was replaced. |
| 176700 mi US $200 |
Replaced the engine knock sensors due to a P0327 DTC. |
| 181200 mi US $1180 |
Fuel pump failed. Module obsolete at dealer, aftermarket fuel sender erratic, second unit more erratic. |
| 185000 mi US $180 |
Bank 2 catalytic converter changed due to P0430 recurring code. |
| 187000 mi US $75 |
Replace leaking exhaust manifold gaskets and valve cover gaskets. 4 broken exhaust manifold bolts extracted from the cylinder heads. |
2004 GMC Yukon 4dr SUV, ext.
| 118000 mi US $370 |
Leaking fuel line. Took a long time for dealer to get correct part. |
| 128300 mi US $150 |
Fuel dampener was leaking. |
| 128900 mi US $110 |
Thermostat replacement. |
| 136000 mi US $275 |
CEL came on. TPS bad. I had the whole throttle body replaced. I bought the parts and garage did the repair. |
2004 GMC Yukon 4dr SUV
335-horsepower 6.0L V8 4-speed automatic AWD
| 177500 mi | Plugged in the code reader -- I need to replace catalytic converter. |
2004 GMC Yukon 4dr SUV
295-horsepower 5.3L V8 4-speed automatic RWD
| 105000 mi US $543 |
Replaced water pump, tstat, ac belt, coolant. All but water pump preventive. |
| 132300 mi US $574 |
Replaced A and B knock sensors Replaced coolant |
| 134000 mi US $1210 |
knock sensor harness, intake gasket |
2004 GMC Yukon 4dr SUV
295-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| 144800 mi US $956 |
Replaced fuel pump assembly on top of gasoline tank |
| 148300 mi US $265 |
Often could not remove key from ignition. Sometimes, car would remain running until key was jiggled and could be turned to "on" position and then removed again. Often process would have to be repeated until engine could be shut off. same problem with removing key but can turn engine off. First trip, ignition was replaced. |
| 193000 mi US $300 |
engine light would come on infrequently when in "all- wheel" drive. At this time car would be running only in 2nd and 3rd gear and no 4WD. Diagnosed as bad ignition switch, replaces. |
| 172000 mi US $240 |
leak in coolant hoses - replaced both |
| 173500 mi US $110 |
The rear heat was not blowing hot. The rear blend door actuator was locked in the default or cold position. The computer was bad also. Replaced both rear actuators and computer, parts from Amazon - simple plug in $110.00 |
| 176047 mi US $479 |
Water pump malfunctioned. Had to replace water pump. As a preventative maintenance item, the mechanic also replaced thermostat and upper/lower radiator hoses. water pump failed - replaced |
| 191300 mi US $380 |
Check engine light (OBD II codes p0171 and p0174) - replaced intake manifold gasket |
| 268789 mi | water pump leaking - repaired under warranty |
| 138000 mi US $1250 |
Replaced intake manifold. |
| 151000 mi US $980 |
Replaced both catalytic converters |
| 144600 mi US $565 |
I had the water pump and thermostat replaced |
See TrueDelta's information for all SUVs
See TrueDelta's information for all GMC models.
