| 1 | 0 | 3 | 4 | 3 | 4 |
2007 Ford Fusion repairs by problem area
Engine (34%)
Transmission and Drivetrain (10%)
Brakes and Traction Control (8%)
Suspension and Steering (16%)
Electrical and Air Conditioning (19%)
Paint, Rust, Leaks, Rattles, and Trim (7%)
Other (6%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 210 repairs.
2007 Ford Fusion body repair cost distribution
$2500+ (0%)
$1000 - $2499 (0%)
$500 - $999 (8%)
$100 - $499 (0%)
< $100 (92%)
Chart based on 12 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2007 Ford Fusion 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic FWD
| 293100 mi US $10 |
Headliner separated and began sagging in the rear of the car. Repaired with a hot glue gun. |
| 64000 mi US $45 |
Inside drivers door handle broken. |
| 28560 mi | Vibration or buzzing noise coming from the engine compartment or instrument. The symptom and repair was describe in TSB 07-17-5. |
| 42500 mi US $65 |
Broken interior door handle. |
| 111700 mi US $700 |
condensation drains for moon roof were clogged with dust and tree pollin. |
2007 Ford Fusion 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic AWD
| 104160 mi | Car had become a piece of rusty junk with a failed transfer box. It was on it's way to the junkyard anyway, and I was able to help by bringing a large tree on it. Finished up looking like an El Camino. |
2007 Ford Fusion 4dr Sedan
160-horsepower 2.3L I4 5-speed manual FWD
| 63860 mi C $2400 |
I was hoping to donate the car to a missionary returning on furlough. I took the car in to get safetied and both rocker panels are rusted out. It will cost about $1200 CDN per side to pass the safety. Passing the safety is a requirement for transferring ownership of a vehicle in Canada if the buyer intends to license the car for use on the road. |
| 3100 mi | trimming around the door was loose |
| 11160 mi | Rear doors are hard to close, I have to reopen it after a unsuccesful close a lot more often than any other car I ever used, they changed a part and tweaked the other door, it's still the same, they can't do anything more. The car in show room is the same |
2007 Ford Fusion 4dr Sedan
160-horsepower 2.3L I4 5-speed automatic FWD
| 34000 mi | Drivers seat cushion material developed crack in material. Dealership inpected and immediately ordered/replaced with new seat cover. Warranty repair. |
| 47000 mi | I had rust under the hood lip, trunk lip and drivers side rear door. |
| 34000 mi | Been to dealer once regarding rattling drivers door panel. They changed the speaker and put foam tape on the door panel edges, and noise hasn't returned. Took approximately 1-2 hours. |
| 33000 mi |
| 19000 mi | Door wind noise. Dealer adjusted door seal. |
2007 Ford Fusion 4-door
6-cylinder automatic 2WD
| 2000 mi | Squeaky pass. seat when someone is sitting in it and on left turns. |
See TrueDelta's information for all Sedans
See TrueDelta's information for all Ford models.
