| 1 | 0 | 3 | 4 | 3 | 4 |
2011 Ford Fusion repairs by problem area
Engine (25%)
Transmission and Drivetrain (14%)
Brakes and Traction Control (8%)
Suspension and Steering (14%)
Electrical and Air Conditioning (22%)
Paint, Rust, Leaks, Rattles, and Trim (6%)
Other (9%)
Chart based on 161 repairs.
2011 Ford Fusion engine repair cost distribution
$2500+ (0%)
$1000 - $2499 (5%)
$500 - $999 (3%)
$100 - $499 (28%)
< $100 (64%)
Chart based on 39 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2011 Ford Fusion 4dr Sedan
263-horsepower 3.5L V6 6-speed shiftable automatic FWD
| 78000 mi US $300 |
OBD sensor port went bad. Found out during emissions testing. |
2011 Ford Fusion 4dr Sedan
263-horsepower 3.5L V6 6-speed shiftable automatic AWD
| 16740 mi | car had a rattle at speeds over 100 kms,heat shield for the cat. conv. was to close to conv. and was moved slightly. this repair took test driving and 2 shop repairs to get satisfaction!! |
2011 Ford Fusion 4dr Sedan
240-horsepower 3.0L V6 6-speed shiftable automatic FWD
| 60500 mi US $360 |
Throttle linkage replaced |
| 55700 mi | Car was displaying check engine light related to evaporative emissions problems. Related to pending recall for defective evaporative purge valve. Mine was stuck open. |
| 57000 mi US $50 |
O2 Sensor triggering check engine light |
| 60000 mi US $50 |
Emissions sensor |
| 98000 mi US $50 |
Throttle body replaced |
| 109000 mi | Bad spark plug. Recently replaced at 100,000 service, so repair covered under warranty. Car stayed at dealer for 4 days because misfire happened after the initial repair on cold wet day, but could not be recreated during drier, warmer weather. |
| 12000 mi | Erratic shifting |
2011 Ford Fusion 4dr Sedan
240-horsepower 3.0L V6 6-speed shiftable automatic AWD
| 58600 mi | Throttle body sensor failure. Loss of engine throttle control. Engine went to idle at 70mph. The throttle body was replaced. |
| 34100 mi | Throttle defect, car died several time when it was running. Very dangerous especially when you were in the middle of an intersection. Many same problem reported. Warranty repaired. |
| 23500 mi US $178 |
Clogged injector. Carbon blow out and fuel cleaner maintenance. |
2011 Ford Fusion 4dr Sedan
175-horsepower 2.5L I4 6-speed shiftable automatic FWD
| 95200 mi US $1150 |
ECM required replacement due to complete failure |
2011 Ford Fusion 4dr Sedan
175-horsepower 2.5L I4 6-speed manual FWD
| 16000 mi | Fuel cap was not properly closing could smell gas. We had to have the gas cap replaced. |
| 21480 mi | wiring badly protected, fuse of the engine blown a few times. Had to redo a part of the wiring. |
2011 Ford Fusion 4dr Sedan
175-horsepower 2.5L I4 6-speed automatic FWD
| 139000 mi US $160 |
Replaced water pump, antifreeze. |
| 167000 mi US $170 |
Replaced fuel evap canister valve |
| 112000 mi US $200 |
Replace fuel pump. Replace valve cover gasket. |
| 117500 mi US $220 |
Water in valve sensor. Air in cooling line |
| 130000 mi | had to replace tensioner pulley and drive belt |
| 47120 mi | Recall for the fuel tank that caused an engine warning light to appear in the dash. |
| 58000 mi | Emission problem. Capless gas valve leaking. Seems to be fixed for now by cleaning and fiddling with the cap. |
| 1000 mi | Thermostat stopped working, car overheated and check engine light came on. |
| 63000 mi | "Check fuel fill inlet" warning comes and goes intermittently, due to faulty sensor in capless fuel fill system. Did not repair. |
| 78000 mi US $200 |
Replaced faulty fuel filler neck |
| 92100 mi US $1500 |
Faulty ignition wiring harness causing two cylinders to misfire, including an injector completely failing due to bad wires. Bad accessory belt tensioner needed replacement. |
| 6000 mi | MIL Light on (check engine) - Codes P052, P052 - TSB 11-2-10, cleared codes. |
| 120000 mi US $600 |
Investigated check engine light, thermostat and flush/fill completed |
| 86000 mi US $50 |
Wiring fault with check engine light. Ended up being a Bad O2 sensor even though code indicated wiring fault. |
| 67700 mi US $75 |
Striped engine oil drain plug repaired with heli-coil. |
| 1240 mi | TSB for intermittent delayed engagement into gear. |
| 42300 mi | Catalytic converter gone bad. Warranty replacement. |
| 44500 mi US $150 |
idler pulley replaced. |
2011 Ford Fusion 4dr Sedan
156-horsepower 2.5L I4 Hybrid CVT FWD
| 75000 mi US $85 |
Needed software update. |
| 86800 mi | Oxygen sensor (upper) problem |
| 53320 mi | check engine, sensor check engine, sensor broken |
| 30000 mi $300 |
The display showed "high motor temp". It was the motor wiring was shorting. The wiring was replaced. |
| 59882 mi US $50 |
Replaced upstream oxygen sensor. |
See TrueDelta's information for all Sedans
See TrueDelta's information for all Ford models.
