2004 Chrysler Pacifica Chrysler Pacifica 2004

We are 103,000+ car owners sharing real-world car information.

Join Us

2004 Chrysler Pacifica repairs by problem area

Engine (38%)

Transmission and Drivetrain (6%)

Brakes and Traction Control (2%)

Suspension and Steering (21%)

Electrical and Air Conditioning (29%)

Paint, Rust, Leaks, Rattles, and Trim (2%)

Other (2%)

Select a problem area

Show all problems

Need advice about a specific Chrysler Pacifica problem?

Chart based on 169 repairs.
See TSBs and recalls for the 2004 Chrysler Pacifica.

2004 Chrysler Pacifica electrical repair cost distribution

$2500+ (7%)

$1000 - $2499 (4%)

$500 - $999 (9%)

$100 - $499 (33%)

< $100 (47%)

Worried about potential repair costs? An extended warranty can provide peace of mind.

Chart based on 45 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

2004 Chrysler Pacifica

Engine not specified

58900 mi

C $2700
Problem with relay being loose. Was incorrectly diagnosed and starter, wires, etc were replaced and diagnostics were done that did not fix the problem. 
151400 mi

US $40
horn inop - run wire around pcm 
157000 mi As the car sat from May to July the right side windows became inop and the air bag lamp lit. 

Return to top

2004 Chrysler Pacifica 4dr SUV

250-horsepower 3.5L V6 4-speed shiftable automatic FWD

60000 mi

US $57
Oil change & headlight replaced 
171000 mi

US $25
Replaced a wire that activated the cruise control. 
205800 mi

US $610
The bearing in the air condenser seized up and stopped it from working. In addition, the hoses of the air conditioning system were also seized to the condenser. All were replaced. 
35998 mi Replace DVDx6 player unit in dash, changer failed. 
66000 mi

US $550
Replaced heater core. 
87000 mi

US $120
Replaced passenger-side headlight 
139000 mi

US $2600
Would not start. 
164000 mi

US $900
Stalling, 
53000 mi No further repairs: Not repairs but since purchase we have replaced both head light bulbs once & replaced the battery twice. Battery discharges if car sits unused for weeks, unless I remember to hook up a trickle charger. 
79000 mi

US $1300
Alternator bearing had become noisy at idle. Decided to replace the alternator as it was time to replace the accessory belt (wear item).... 
150000 mi

US $100
Right Side Low Beam Headlight failed. 45 min to replace bulb. New bulb Tested good. Light still not functioning. Failed circuit in Elect Cntrl box . Cost to repair $1400. Built new Circuit with 2 relays and 2 fuses Now Working. 
43000 mi

US $64
The high-intensity headlight bulb burned out again. This was the third bulb to be replaced. It is the only complaint we have had about the vehicle during ownership. The high-intensity bulbs are not long-lasting. 
54000 mi

US $50
Tire pressure sensor indicated low pressure via warning light. Dealer could not reproduce - reset warning light. 
55000 mi

US $50
Tire pressure sensor again. Again told the dealer service department could not replicate the issue. Reset warning light. 
55000 mi

US $360
The long-standing prior issue with the tire pressure sensor was finally resolved. The SPARE TIRE was low! The other dealership in New Jersey never checked the spare! The dealership in Downingtown, PA was on top of it and problem solved! VERY HAPPY! 

Return to top

2004 Chrysler Pacifica 4dr SUV

250-horsepower 3.5L V6 4-speed shiftable automatic AWD

139000 mi

US $400
A/C blower fan stop working 
178200 mi

US $80
Front driver window regulator was relpaced 
89900 mi

US $250
fan blew only on high, no cold ac, no fan blowing at feet. 
111000 mi

US $215
Also fixed Air conditioner 
98000 mi

US $100
Starter replaced by owner. 
77000 mi

US $58
Heater not blowing hot air - paid $58 to diagnose -they said they fixed it but it stopped working a few days later. 
78000 mi

US $180
Heater not blowing hot air. Mechanic again flushed system and found junk in fluid - needed several flush cycles to remove majority of junk. Heater works OK now. 
68000 mi

US $320
Car would not start. Could not be jumped. Ground cable was bad. Replaced cable and battery. 
57000 mi

US $700
Heater control went bad $500 for unit $200 to have put in.  Also tire sensors reading needs service, did not have done. 
122000 mi Air bag system warning light came on. Ended up being the right front sensor. Dealer replaced it zero charge due to my father-in-law owns a dealship. 
72000 mi

US $50
Auto opening/closing lift gate not operating. Mechanic found loose connection. 
87000 mi

US $75
Cruise control not working. Dealer mechanic found a cracked vacuum hose and replaced it. Total $75. 
81000 mi

US $75
Fan blower motor module(resistor) replaced(easy repair- behind glove box). fan speed uncontrolable and increased if turned off heater.  
124000 mi

US $15
GROUNDING ISSUE wouldnt start.Wire located near transmission on drvrside. Didnt have lift or floor jack, but local mechanic(had same issue)had quickfix(ground from frt of mtr to battery).Car starts a few options not working(cruise/seat). 
146300 mi

US $400
rear brakes and repaired groundwire behind left frt tire. continuing issue. since initial ground wire repairs haven't been able to get cruise, Autostick, and power seat to work. 
168000 mi Ground issue when turned on wipers. Repaired and have wipers. See this post with pics https://www.chryslerforum.com/forum/chrysler-pacifica-15/2004-pacifica-wiper-electrical-issue-24701/ 
48360 mi

C $1200
DVD screen had a burned out pixel. mad a red dot on dvd screen. DVD screen replaced 
58900 mi Faulty tire sensor. Caused service tire system soon on the dash computer. 
86180 mi

C $260
Tire sensor 
112000 mi

US $3500
AC no longer keeping car cool. 
67000 mi

US $200
Cruise control not activating 
69500 mi Cruise control activates on console but does nothing 
83000 mi

US $200
condensor failure defrost vent switch, would not switch to defrost 
154000 mi

US $40
Driver headlight burnt out 
155000 mi

US $75
Power seats stopped working. Suspected control module, found control module on-line. Replaced module and checked power distribution module for loose connections. Seats now working. 
155000 mi

US $10
heater would stop working on long trips. Had prev. problem with power dist. module. Removed module cleaned with contact cleaner and applied di-electric grease to all connections on module. problem appears to be solved 
189000 mi

US $150
Front passenger power window fell while vehicle being driven. Disassembled door panel and found window regulator failed. Ordered new regulator and replaced. Now working fine 
130500 mi

US $330
Nem starter installed. 

Return to top

See TrueDelta's information for all Minivans
See TrueDelta's information for all Chrysler models.

2004 Chrysler Pacifica Electrical Problems

See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how frequently 2004 Chrysler Pacifica problems occur, check out our car reliability stats.