Mazda MPV in Florida, United States Jul 2019 - Jul 2019
Feb 2019 140000 mi US $1000	Timing tensioner broke bent valves. Replaced timing chains and tensioners as well as head gasket and all valves

Mazda MPV in Florida, United States - Jun 2012
Jun 2012 75000 mi	Oil Leak from engine"O" rings. Cost to repair $900-$1,000 Oil Leak from engine"O" rings. Cost to repair $900-$1,000

Mazda MPV in Arkansas, United States Dec 2011 - Dec 2012
Jun 2012 116000 mi US $450	replaced all coils

Mazda MPV in Washington, United States Aug 2011 - Jul 2022
Feb 2013 45900 mi US $350	#3 coil and spark plug
Apr 2017 63000 mi US $911	replace #4,5,6, plugs and coils

Mazda MPV in Florida, United States Dec 2012 - May 2014
Apr 2013 78500 mi US $200	erratic idle, down on full throttle power. Replaced faulty PCV hose and valve. As a preventative maintenance I removed and replaced all spark plugs and COPs.
Sep 2013 89000 mi US $75	When I previously replaced all COP and spark plugs I used cheap parts off Amazon. Don't do it. I basically had to re-accomplish all work with genuine OEM parts to correct reoccurring drivability hiccups. This van is ignition sensitive.
Dec 2013 92000 mi	Front timing chain cover and oil pan develop leaks. It is a labor intensive repair. Estimates about $1,300. I first tried engine seal "stop leak" products with poor results. A telltale sign of burning oil accompanies this ford sourced duratech V6 defect.
Feb 2014 93400 mi	Water pump developed leaks around the housing. Replaced it along with the short elbow bypass hose that connects the water pump to the coolant passages in the valley under the lower intake.

Mazda MPV in Florida, United States Jan 2012 - Feb 2012
Feb 2012 137000 mi US $700	Radiator and thermometor replaces as the radiator had a leak

Mazda MPV in Ontario, Canada - Jul 2010
Jul 2009 46393 mi C $1318	Replace #4 ignition coil and spark plug Replace front brake pads, machine rotors + fluid Repair collapsed PVC hose Replace water pump + anti-freeze Replace rear brake light
Jul 2010 62000 mi C $650	Replace driver side window motor Replaced PCV hose

Mazda MPV in Oklahoma, United States - Dec 2007
Dec 2007 48000 mi US $500	front stabilizer bar and bushings. right hand window motor and regulator.

Mazda MPV in Texas, United States - Nov 2007
Nov 2007 45000 mi	Radiator Fan Control Module failure. Under warranty - no cost.

Mazda MPV in Minnesota, United States - Aug 2008
Aug 2008 75000 mi US $67	Consistent problem with door locks actuating themselves. Troubleshot to a bad door switch, replaced.

Mazda MPV in Ontario, Canada Aug 2011 - Dec 2017
Nov 2011 67360 mi C $18	Replaced Driver's side Stabilizer Link component
Apr 2012 69440 mi C $120	Replaced lower control arms (complete with BJ) on both sides.
Nov 2013 80460 mi C $450	New alternator
May 2016 94640 mi C $75	Replace Drivers side window regulator
Jun 2016 95480 mi C $125	Replace lower control arm due to failed ball joint

Mazda MPV in Georgia, United States Aug 2011 - Mar 2013
Dec 2011 128000 mi US $38	PCV tube collapsed and disintegrated. Issue caused prake issues as well as engine idle issues.

Mazda MPV in California, United States Nov 2011 - Mar 2016
Jan 2014 78700 mi US $40	Cooling system fan module failed and cooling fan kept coming on more and more when not needed. Seems this is a common failure. I bought a replacement module on eBay for $40. Dealer wanted $130 for the part. Took 15 minutes to replace it.
Jul 2014 63300 mi US $90	The $40 eBay fan module failed in about 30 days. I found a OEM version for $90, installed it in 15 minutes and it works as it should.
Dec 2014 69000 mi US $100	#3 ignition misfire. Replaced all 6 coils and spark plugs.

Mazda MPV in California, United States Jul 2017 - Jun 2022
Apr 2017 139049 mi US $150	Typical ignition coils which go bad, PCV, and spark plugs Control arm bushings, sway bar links and sway bar bushings.
Nov 2017 143247 mi US $243	Transmission and engine mounts
Apr 2018 151970 mi	Timing cover leak, given $1100 estimate. Added STP stop leak instead and park over plastic area because it drips 2 drops of oil after driving. Oil usage minimal--about 0.5 quarts per 3000 miles. An annoyance as it smells slightly of burning oil when parking.

Mazda MPV in Pennsylvania, United States - Jun 2009
Dec 2008 26000 mi	Radiator Fan Control module replaced. Under warranty. (fan cycled irregularly, summer and winter).
Jun 2009 31000 mi US $650	Replace three rear ignition coils.

Mazda MPV in Pennsylvania, United States Dec 2011 - Nov 2017
Mar 2014 102000 mi US $225	Loud front end noise. Replaced bearing.
Jun 2014 104000 mi US $1000	Major rust in wheel wells and bottom of doors.

Mazda MPV in Massachusetts, United States Aug 2011 - Sep 2018
Jun 2013 128000 mi US $650	Original alternator went out, the alternator would read normal without a load. The mechanic put a load on it and find out that the alternator would not produce enough to recharge the battery.
May 2014 142900 mi US $200	Outer tie rod, driver's side.
May 2015 165000 mi US $418	Both right and left lower control arm and ball joint assembly.
Dec 2015 180000 mi US $180	Coolant line
Jul 2018 210000 mi US $260	Tie rod and and bushing.
Aug 2018 221000 mi US $140	Coil pack.

Mazda MPV in Minnesota, United States Aug 2012 - Jun 2016
Jan 2013 88000 mi	The van was running roughly and Check Engine light was illuminated. Code was read and indicated a misfire in Cylinder 3. Ignition coil was replaced and solved the problem.
Dec 2013 96000 mi US $200	Vacuum leak caused by collapsed PCV hose.
Apr 2014 98700 mi US $560	Failed ignition coil in cylinder 1. Repair included replacing 2 coils and spark plugs.
Dec 2014 111000 mi US $60	Replaced ignition coil on cylinder 4.

Mazda MPV in Georgia, United States Aug 2011 - Mar 2018
Dec 2012 69000 mi US $256	the car was intermittently hesitating, not running smoothly. it was a post-ignition problem. Spark plugs and some sensors had to be replaced.
Feb 2013 71600 mi US $1200	electronic post ignition and air flow sensors malfunctioning. also replaced all ignition coils.
Jan 2017 118000 mi US $300	controller for engine fan was replaced
Feb 2017 120000 mi US $850	front ignition coils replaced CV joints replaced

Mazda MPV in North Carolina, United States Dec 2011 - Jun 2016
Aug 2013 76000 mi US $194	Engine missing - replaced coil module on one cylinder.

Mazda MPV in Alberta, Canada Dec 2013 - Feb 2016
Sep 2014 88660 mi C $1000	Drain plug stripped. required replacement. Replaced oil pan too.

Mazda MPV in Massachusetts, United States Sep 2013 - Sep 2017
Dec 2014 91000 mi US $2000	replacement of multiple exhause components including 2 catalytic converts

Mazda MPV in Ohio, United States Jan 2010 - Mar 2015
Feb 2010 56000 mi US $280	Ignition issue, code reading cylinder x misfire, all coils checked out ok as did vacuum system and fuel, engine is missing
Mar 2010 57000 mi US $750	Engine misses.. stumbles
Mar 2015 106000 mi	Coolant lines to rear heater failure. replace corroded lines

Mazda MPV in Utah, United States May 2008 - Jan 2014
Jan 2008 45000 mi	replaced rear shocks by Mazda

Mazda MPV in Virginia, United States Aug 2015 - Sep 2018
Mar 2017 265000 mi US $50	Power steer high pressure hose leak
Aug 2018 268000 mi US $50	Drivers power window motor replaced

Mazda MPV in Illinois, United States Mar 2009 - Nov 2015
Apr 2009 67000 mi US $80	Vehicle was running very roughly and CEL was flashing.
Apr 2011 91000 mi US $60	Replaced bad spark plug coil. Same cylinder as previously replaced.

Mazda MPV in Ohio, United States Jan 2004 - May 2011
Oct 2004 5893 mi	Performed minor interior warranty work-fixed screw, fixed floor mat holder. Also, warranty work on back bumper-replace plastic cover
Feb 2005 12853 mi	Check squeak in rear brakes when backing up. Mazda ordered and replaced part to repair brakes under warranty.
Aug 2008 81451 mi US $690	Replaced defective mass air flow sensor; replaced coolant temperature sensor
Oct 2008 84764 mi US $665	Replaced idle air control valve for stalling issue. Replace left turn signal-front bulb; To resolve oil leak-replaced oil pan gasket and front crank seal.
Sep 2009 100000 mi US $1215	After we arrived at our vacation destination, car began running roughly and after a short while, engine light came up. Drove about 1 hour to dealership. Required replacement of all 6 ignition coils. All-day repair job.
Mar 2010 109000 mi US $205	coolant temp sensor replaced Completed Induction service / induction cleaning to correct problem
Jan 2011 124000 mi US $220	Replaced 2 sway bar links($155) as advised by repair shop and dealer. Also, replaced waterpump belt ($65) at same time.

Mazda MPV in Washington, United States May 2009 - Mar 2010
Jun 2009 114000 mi US $100	Engine misfiring. Had previously replaced two coils. Replaced 4 remaining coils. Also replaced engine coolant, changed air filter.

Mazda MPV in Alabama, United States Apr 2005 - Jul 2018
Aug 2005 5000 mi	Left rear door motor went out. Replaced under warranty.
Jul 2009 32000 mi US $53	Misfire when accelerator pressed.
Aug 2009 32000 mi US $150	Coil bad in cylinder 4. No code on computer. Just started at cyl 4 and problem cleared. Went ahead and replaced coils/plugs for cylinders 5 & 6. MPV forum and all the good members saved me $$ and time. Thanks.
Jun 2010 37000 mi	Had replaced coil packs 4-6 last year or so and started noticing slight hesitation going up a hill.Had previously bought 6 coil packs and replaced the ones for cyl 1-3. Problem was solved but there still seems to be a slight problem.
Mar 2014 58000 mi US $25	PCV hose leak. Replaced rubber elbow.
Sep 2016 75000 mi US $250	Dealer replaced rear (1-3) coil packs and spark plugs. I supplied the parts. 3 coil packs cost ~ $35 each. Plugs were ~ $3 each.
Oct 2016 75000 mi US $105	I replaced coil packs for front 3 cylinders (4-6) and also replaced the 3 spark plugs. This repair is fairly easy as these cylinders are in front of engine. Slightly over 1 hour time to replace.
May 2017 81000 mi US $72	Sensor 1 bank 1 giving error codes. I replaced at cost of $25. Repair took 2 hours as I had to put van on jacks and replace from underneath. Cooling fans running erratic at times. Replaced fan control module. Had to remove battery to get the 3 plugs undone on old module. Other than replacing battery this was an easy fix.
Oct 2017 85000 mi US $175	Battery failed at 4 years. Replaced with new battery. Always get the battery with longest warranty. (IMO)
Nov 2017 85500 mi US $130	Oxygen sensor bank 2 sensor 2. I paid for part $35 and dealer installed $95.
Dec 2017 86000 mi US $250	Rotors were warped causing vibration when stopping. Replaced all 4 rotors and brake pads.

Mazda MPV in Ohio, United States Jan 2009 - Sep 2016
May 2011 51700 mi	currently in shop for check engine light. also auto trans. flush. 55,000 miles
Jun 2011 54000 mi US $250	Replaced one front ignition coil

Mazda MPV in Indiana, United States Feb 2016 - Aug 2019
Jul 2018 228000 mi	Evaporator condensation line clogged causing water to pool in the cabin. Placed on ramps and cleaned end of discharge hose with wire.

Mazda MPV in California, United States Sep 2013 - May 2018
Jun 2016 154000 mi US $200	worn steering arms prevented alignment
Dec 2017 178000 mi US $1000	Repl radiator

Mazda MPV in Utah, United States Jan 2014 - Jun 2018
Jul 2014 129462 mi US $145	Fan control module replaced
Sep 2014 132800 mi US $38	#6 ignition coil with spark plugs replaced Throttle body position sensor replaced
Oct 2014 136933 mi US $308	#1 ignition coil replaced with gasket $308
Jan 2015 144000 mi US $216	#5 cylinder ignition coil replaced
Jun 2015 153000 mi US $195	ignition coil #4 replaced
Jul 2016 177200 mi US $2100	running rough repaired ignition and computer problems
May 2017 201275 mi US $20	radiator cap replaced
Mar 2018 214000 mi US $90	replaced front pads bleed brakes

Mazda MPV in Colorado, United States Mar 2015 - Oct 2017
May 2015 145900 mi US $660	The intake manifold gaskets needed to be replaced and spark plugs with new spark plug connectors
Jun 2015 152000 mi US $68	Gasket repair was good from mechanic. But spark plug coil repacement was done by myself.
Sep 2015 153000 mi US $110	Overdrive light on and check engine light on.
Jan 2016 US $130	My car has been receiving several codes p0171,p0174, and p0301.I am still trying to figure the problem.
Feb 2016 153300 mi US $500	Steering was bad and control arms and front and rear suspension bad. Car needs to be reprogrammed
Jun 2016 154000 mi US $42	My control arm had to be replaced
Jan 2017 154500 mi US $40	Heat was not working well during cold weather. I had to change coolant.
Jun 2017 164000 mi US $30	I hit pot hole and had to repair clunk sound Stablizer bar was a little noisy. End link was changed.
Oct 2017 166000 mi US $160	Leaking passenger side cv axle

Mazda MPV in Massachusetts, United States Oct 2010 - Oct 2015
Jun 2011 162000 mi US $30	Knocking in front end. Lower ball joint bad. Replace lower control arm passenger side intake boot split at accordion area. Replaced with new Mazda intake boot
Apr 2012 175000 mi US $445	transmission cooler leaking needed to be replaced
Jul 2012 180800 mi US $160	Passenger inner tie rod bad...first noticed as a slight "thump" when turning the steering wheel. Tie rod replaced and front end aligned Exhaust leak for the "front" muffler/silencer.....heard exhaust louder than usual, looked underneath and noticed exhaust starting to rot away
Sep 2012 184000 mi US $250	excessive play passenger font wheel. Also "clunk" when turning wheel. Shop suggested replacing lower ball joint but wound up replacing control arm assembly. was the same repair as 13 monrhs prior.

Mazda MPV in Maryland, United States Aug 2011 - Mar 2012
Mar 2012 95000 mi US $15	Rear wiper spring wore out and failed to hold the wiper tightly against the rear window reducing visibility.

Mazda MPV in Texas, United States May 2010 - Sep 2014
Jun 2010 88000 mi US $650	Replaced water pump. Replace Water Pump
Dec 2010 95000 mi US $175	Replacement of parking lights which required taking off the front bumper
Mar 2011 99000 mi US $679	Replaced pcv hose that was cracked and had fuel injectors cleaned. Replaced pvc hose that was cracked and had fuel injectors cleaned.
May 2011 103000 mi US $398	Power steering and radiator flush
Jul 2011 104000 mi US $636	Tuneup due to misfires
Jan 2012 109000 mi US $950	Engine coils not firing
Aug 2013 126000 mi US $40	Fan control module went bad
Dec 2013 129000 mi US $100	Replace a dead battery
Aug 2014 134000 mi US $700	Replaced ac system Replaced sway bars

Mazda MPV in Massachusetts, United States May 2009 - Nov 2013
Dec 2009 74000 mi US $10	Replaced a headlight Replaced a broken interior trim clip
Feb 2010 75700 mi US $40	Replaced IAC valve
Nov 2010 84000 mi US $180	replaced the O2 sensor Sway bar link replaced
Feb 2011 89000 mi US $1100	Ball joint and control arm replaced Transmission oil cooler had a hole and needed to be replaced
Jun 2012 101000 mi	Replaced rear shock absorbers Replaced cooling fan control module
Aug 2012 102100 mi	One of the ignition coils replaced. Luckily - one of the front ones...
Feb 2013 106100 mi US $375	Ball joint and control arm were replaced

Mazda MPV in Alabama, United States Nov 2010 - Mar 2016
Mar 2011 75000 mi	Engine hesitates occasionally while driving, shop could not reproduce.
Nov 2011 81000 mi US $100	engine hesitates occasionally during acceleration. Private shop was previously unable to replicate, dealer now couldn't either. Problem still occurs, but intermittently. No codes in computer.
Mar 2012 83000 mi US $350	Engine was hesitating, ignition coil replaced on cylinder #5.
Dec 2012 94000 mi US $1000	water pump failed and was replaced
May 2013 98000 mi US $1300	Air conditioning system needed complete replacement.
Aug 2013 99000 mi US $500	Engine hesitating, ignition coil replaced.
Jul 2015 101200 mi US $40	A/C not cold, recharged refrigerant.
Dec 2015 102000 mi US $100	Oil pressure light intermittently flickers at idle. Mechanic could not reproduce. Battery drains if car sits idle for a few days. Mechanic could not detect any drain.

Mazda MPV in Netherlands Jun 2011 - Jul 2011
Jul 2011 47120 mi €2880	Turbocharger broke down Ignition pump broke down

Mazda MPV in Minnesota, United States Dec 2011 - Jul 2018
Mar 2014 155000 mi US $50	Vacuum hose was cracked caused check engine light to be on. Replaced and everything if fine.
Jul 2016 191300 mi US $350	Coil pack went out

Mazda MPV in Arizona, United States Oct 2009 - Dec 2012
Jan 2009 91000 mi US $246	Transmission reflash $200 91k miles Fan Control Module replacement **$46**
Apr 2009 94000 mi US $125	PCV hose replacement
Oct 2009 96900 mi US $215	window motor replacement
May 2011 115000 mi US $125	The left front wheel bearing went out, it was making a howling sound at speed(it was driving me crazy).
Jun 2012 127000 mi US $75	Window motor went out(again) luckily that part is under warranty

Mazda MPV in Oregon, United States Mar 2009 - Aug 2011
Jul 2009 86000 mi US $120	Ignition coil began to fail intermittently. This was the second time a coil had started to fail within the last 18 months. Replaced all six coils. Problem seems fairly prevalent among 2004 MPVs.

Mazda MPV in Washington, United States Jan 2011 - Mar 2015
Apr 2011 87200 mi US $150	Driver power window switch failure. 2 worn out engine coils
May 2012 95700 mi US $900	Brakes and Shocks Replaced
May 2013 106000 mi US $200	New spark plug wires added.
Oct 2013 108300 mi US $200	Vacuum seal repaired

Mazda MPV in Minnesota, United States Jul 2013 - Sep 2014
Aug 2013 47300 mi US $600	Replaced PCV breather hose and filter, all six sparkplugs and direct ignition coils, intake gasket set, basically a 50,000 mile tuneup but the PCV hose had failed as had one of the coils.
Sep 2014 54000 mi US $500	Tranny range sensor failed tripping check engine light, replaced.  Also put new hose clamp on leaking oil cooler lines near oil filter.

Mazda MPV in Ohio, United States Aug 2010 - Mar 2016
Sep 2010 76000 mi US $150	van started missing and CEL came on. Code reader indicated cylinder one misfire. Replaced all three coils and plugs behind/under intake manifold. Problem cleared. Note: 3 of the 6 coils have failed on Mazda van....definitely a problem.
Feb 2011 80000 mi US $305	Wheel bearing noisy. Decided to replace both

Mazda MPV in Arizona, United States Jun 2013 - Jun 2022
May 2014 96900 mi US $132	Electric Fan Control Unit was defective, causing A/C condenser and radiator fans to run erratically.
Dec 2015 105000 mi US $125	Temperature gauge reading low. CEL code for Engine Temp Too Low For Proper Emissions. Engine Coolant Temperature sensor was replaced. $60 for new sensor, $65 labor.
Nov 2016 117700 mi	Radiator plastic tank cracked at upper hose nipple. Replaced radiator. Also replaced thermostat, upper and lower hoses and fan assembly due to age of vehicle and area was open for access.
Nov 2021 131000 mi US $75	Valve cover gaskets were leaking, causing a burned oil smell. Both gaskets were replaced. PCV valve and hose were replaced as preventive maintenance.

Mazda MPV in British Columbia, Canada Mar 2013 - Apr 2013
Apr 2013 95480 mi C $140	ignition coils fail

Mazda MPV in Moscow Oblast, Russia Jan 2009 - Mar 2010
Feb 2009 85560 mi $250

Mazda MPV in California, United States Dec 2009 - Jun 2011
Jan 2010 56000 mi US $300	#3 coil which is a problem that Mazda will not recall!!!! we have now replaced 3 of the 6 coils #3 coil failed and the pcv hose failed, replaced at the dealer

Mazda MPV in British Columbia, Canada Feb 2009 - Jun 2018
Feb 2014 71240 mi C $220	Replace two coils
Dec 2014 79980 mi C $162	#4 coil replaced.

Mazda MPV in Poland Aug 2014 - Jun 2017
May 2016 122140 mi $100	Radiator leak

Mazda MPV in Ontario, Canada Jan 2005 - Jun 2016
Apr 2005 23560 mi	Brakes squealing when backing up in reverse. Replaced rear brake shims
May 2005 25119 mi	CEL flashing diagnosis code P0303 cylinder 3 misfire Replaced cyclinder 3 ignition coil (AJ51-18-100A) & spark plug (AJ09-18-110)
Nov 2005 41635 mi	1)Driver side power window does not function. Replaced driver's side window motor and window regulator 2) No heat at idle heat only when driving. Heater valve was closed. opened heater valve
Mar 2006 49125 mi	CEL flashing diagnostic code P0303 cylinder 3 misfire. Fuel system check and replaced cylinder 3 ignition coil (AJ51-18-100A)
Apr 2006 52702 mi	CEL flashing diagnostic code P0304 cylinder 4 misfire Replaced cylinder 4 ignition coil (AJ51-18-100A)
Jul 2006 58083 mi	CEL flashing diagnostic code P0306 cylinder 6 misfire Replaced cylinder 6 ignition coil (AJ51-18-100A)
Jan 2007 98028 mi C $142	Car stalling. idle would drop to zero when reving engine in park or when driving and taking foot of gas pedal. Replaced IAC. No charge for installation. IAC replaced by me
Oct 2007 91544 mi C $418	CEL flashing diagnostic code P0302 cylinder 2 misfire. Replaced all spark plugs (ZZC2-18-110A) and cylinder 2 ignition coil (AJ51-18-100A)
Jan 2008 98027 mi C $88	CEL flashing diagnostic code P0305 cylinder 5 misfire. Replaced cyclinder 5 ignition coil (AJ51-18-100A) myself
Dec 2008 119036 mi C $385	CEL flashing diagnostic code P0301 cylinder 1 misfire. Replaced all spark plugs (ZZC2-18-110A) and cylinder 1 ignition coil (AJ51-18-100A)
Apr 2009 124000 mi C $170	coolant dripping on driveway from water pump area. Soon after, squealing noise was coming from engine area. suspected water pump. removed belt temporarily and noise stopped. Ordered part, drained coolant, installed new pump & added coolant. coolant dripping on driveway from water pump area. Soon after, squealing noise was coming from engine area. suspected water pump. removed belt temporarily and noise stopped. Ordered part, drained coolant, installed new pump & added coolant. Drivers side power window stopped functionng. buzzing sound when button for front left window pushed. Replaced power window modulator myself
Jul 2009 128960 mi C $878	Rough idle, car would lag when gas pedal pressed down for quick acceleration. Engine codes showed lean bank 1. Car taken to dealer for diagnostics. paid for diagnostic. PCV hose collapsed, EGR Boost sensor & solenoid found to be the problem Replaced PCV hose, Idle Air Control Valve, EGR Boost Sensor & EGR Boost sensor solenoid Rough idle, car would lag when gas pedal pressed down for quick acceleration. Engine codes showed lean bank 1. Car taken to dealer for diagnostics. paid for diagnostic. PCV hose collapsed, EGR Boost sensor & solenoid found to be the problem Replaced PCV hose, Idle Air Control Valve, EGR Boost Sensor & EGR Boost sensor solenoid
Aug 2010 148040 mi C $300	Squeaking noise from drivers side believed to be suspension related. Driver side sway bar link had excessive play, and passenger side also had some. Replaced both links.
Nov 2010 151300 mi C $351	Driver side front lower ball joint out of spec. Ball Joint replaced.
Apr 2012 179060 mi C $199	Inspection found excessive play in right lower ball joint. Contributing to reported problem (clunking from front end suspension/sterring when driving).
Jun 2012 181660 mi C $100	Fan motor for air conditioner cycling on and off rapidly. Replaced fan control module
Jul 2012 182260 mi C $217	Right (passenger side) axle boot split. Found at oil change during 30 point inspection.
Oct 2012 185980 mi C $412	Re-Re right lower control arm
Jul 2013 195300 mi C $131	Water pump belt cracked. Belt replaced Clunking noise from front right. Front right lower ball joint replaced.
May 2014 204140 mi C $732	Exhaust leak Front sway bar link broke Driver side window modulator
Sep 2014 207700 mi C $435	Front exhaust Flex pipe Noise front driver side front wheel. Front wheel bearing replaced
Jan 2015 203100 mi C $404	temperature gauge drops to zero. No heat. fault code P0118. It ended up that it was the thermostat and not the engine coolant temperature sensor.
Feb 2015 210800 mi C $999	Car studdering (missing) fault code P0303. Bank 1 colis/plugs replaced. After air intake off to replace bank 1 coils/plugs, notice bad oil leak at rocker cover. Rocker cover gasket replaced.
Mar 2015 210800 mi C $212	Humming noise from front right wheel. Replaced front right wheel bearing winter tires removed and new all season radial tires installed. Humming from front driver side. Wheel bearing gone. Bearing was replaced under manufacturer warranty. Note: this bearing previously replaced Sept 2014. When replacing front driver side wheel bearing outer tie rod required replacing, $212.
Jun 2015 213900 mi	Oil leak from front valve cover. Re-re valve cover gaskets

Mazda MPV in Hawaii, United States Feb 2011 - Jun 2011
Jun 2011 87000 mi US $157	radiator become cardboard-ish flaky and was brittle. replaced radiator

Mazda MPV in Colorado, United States Jun 2013 - Jun 2015
Jan 2015 78000 mi	Small pan gasket leak. Didn't fix it.

Mazda MPV in Michigan, United States Dec 2013 - Apr 2014
Apr 2013 92000 mi US $900	Replaced ignition coil
Jan 2014 US $850	Minor Oil Leak, bad smell from engine compartment when heater was on. Rear gasket leaking, replaced. Also replaced front sway bar links.

Mazda MPV in Florida, United States Jan 2009 - Mar 2010
Feb 2009 85000 mi US $1100	Engine gasket replacement with oil pan.

Mazda MPV in Quebec, Canada Nov 2008 - Mar 2010
Dec 2008 68820 mi	No heat in mpv. Find heating hoses where they enter the firewall (around center). There is a plastic valve that was closed shut. Up is closed down is open. Was moved by mechanic when replacing pcv valve. Very easily moved. Heat nice and hot now.

Mazda MPV in West Virginia, United States Jan 2011 - Jul 2014
Jun 2011 117000 mi US $44	Coil failure cyl 5

Mazda MPV in Texas, United States Dec 2007 - Jan 2014
Mar 2008 67000 mi US $300	Replaced pre-cat O2 sensor on right bank (cowl side) of V6 engine. Done by independent mechanic.
Nov 2008 77000 mi US $80	Replaced pre-cat O2 sensor on left bank (radiator side) of V6 engine. Cost includes special socket to remove O2 sensor. Added Lubegard Red to address minor (but growing) problem with shift "flare". It worked surprisingly well. Replaced pre-cat O2 sensor on left bank (radiator side) of V6 engine. Cost includes special socket to remove O2 sensor. Added Lubegard Red to address modest shift flare problem (The duplicate entries for these repairs listed in Jun 2009 are erroneous.)
Dec 2008 78000 mi US $75	Replaced collapsed, split PCV hose (causing the CEL) and incidentally all six plugs (which requires removing the intake manifold!).
Dec 2009 89000 mi	I replaced the oil pan due to a very slow gasket leak.
May 2010 97200 mi US $5	OBD-II Code P0306: misfire in cyl 6 during a severe rain storm. Misfiring stopped after storm. I erased code and pulled plug wires and coils for cyls 4,5,6 and sprayed the coil, plug, and spring with wire dryer.
Jan 2012 95000 mi	Minor vacuum leak in IMRC; sealed with RTV
Dec 2012 135000 mi US $30	MIL came on with P0174 code (vacuum leak). Found crack in air intake hose between MAF sensor and throttle body. Replaced the hose
Jan 2014 120000 mi US $60	Replaced the PCV hose yet again.

Mazda MPV in Pennsylvania, United States May 2014 - Sep 2016
Jun 2015 114000 mi US $200	Severe vacuum vacuum leak and bad water pump

Mazda MPV in Idaho, United States Mar 2009 - Sep 2011
Apr 2009 79000 mi US $50	Oil pan gasket and crankshaft seal replaced to fix oil leaks.
Jul 2009 84000 mi US $40	Fan control module replaced. A/C condenser fan now works.
Jan 2010 93100 mi US $300	Coil on cyl #3 failed, incompetent mechanic refused to replace coil. Instead he replaced spark plugs for $300. Problem came back in less than 100 miles. Previous incompetent mechanic did not reconnect IMCC harness, did not properly torque intake manifold causing vacuum leaks. Mechanic also did not replace faulty coil. Replaced coil.
Feb 2010 91000 mi US $100	Replaced remaining coils, all showed signs of severe wear. Visible corrosion. PCV valve also replaced, it had been removed and was no longer able to stay in engine block. Crankcase vapors leaking into HVAC system due to this.
Jan 2011 90300 mi US $45	Replaced the ECT. The O-ring on the original broke down and coolant started seeping past it eventually corroding the sensor causing it to underreport the coolant temperature.
Aug 2011 99000 mi US $100	leaking oil pan, replaced oil pan with updated style.

Mazda MPV in Alabama, United States Oct 2007 - Jun 2012
Mar 2008 98000 mi US $160	Broken stabilizer bar in the front right.
Sep 2009 114000 mi US $491	Exhaust leak. Had to change the flex pipe.
Dec 2009 117000 mi US $220	Replaced spark plugs and ignition coil
Dec 2011 135000 mi US $140	The rear door automatic opener was broken. Could not open the rear hatch.

Mazda MPV in Arizona, United States Jan 2012 - Feb 2012
Feb 2012 94000 mi US $175	engine light came on. took to my mechanic and codes p2195 and p2197. replaced pcv hose, engine idle control, intake manifold gasket and a few other vacuum leaks, engine came back on, mechanic suggested taking it to dealer.

Mazda MPV in Texas, United States Sep 2012 - Sep 2014
Feb 2013 214900 mi US $350	Failed ignition coil on rear bank of cylinders which necessitated removing the intake plenum. This is the fifth or sixth time this has happened in the 11 years I have owned this vehicle.
Feb 2014 235700 mi US $250	Coolant leak from radiator system
Jul 2014 247000 mi US $300	The ignition coils went out again. The back three (under the intake manifold) were replaced even though only one was defective. I approved the additional work. The car began leaking coolant again. The leak was repaired.
Aug 2014 247200 mi US $70	One of the front ignition coils failed, causing hesitation and misfire on cylinder four. I replaced the coil myself.

Mazda MPV in New Jersey, United States Sep 2009 - Jan 2012
Oct 2009 48000 mi US $100	Temp sensor/t-stat/fan module
Jul 2011 63000 mi US $75	check engine light.(this is a yearly occurrence for something or other with this car @ about the same time frame). This time it was code p0031 ho2 sensor heater. Probably O2 sensor as heater is built into device.
Nov 2011 71000 mi US $75	O2 sensor bank1 sensor1.

Mazda MPV in Nevada, United States Mar 2011 - Jul 2017
Aug 2011 96000 mi US $1363	Shocks and Struts were bad. Replaced tires, shocks, struts, and alignment.
Feb 2012 105700 mi US $100	Oil pan gasket replaced
Dec 2013 115000 mi US $800	Motor Mounts had to be replaced Replaced front axels Replaced starter Rear Door Lock Actuator driver and passenger

Mazda MPV in New York, United States May 2008 - Jun 2011
Jun 2008 67000 mi US $350	Coil #5 broke down. To replace it it required all the upper part of the engine to be removed in order to gain access. Therefore although the part itself was about 70$ the cost of labor caused the price to be 350$.
Jul 2008 68000 mi US $450	vacuum hose
Feb 2010 85300 mi US $110	Another ignition coil had to be replaced due to a misfire. DIY to avoid paying labor, $75 for the part. Also replaced air control module, $35 for the part.
Jun 2010 87000 mi US $70	Leak in the vacuum hose.

Mazda MPV in Alberta, Canada Jan 2013 - Mar 2014
Feb 2013 108580 mi C $30	# 5 Coil Pack went bad (again)

Mazda MPV in Texas, United States Nov 2008 - Sep 2011
Mar 2008 30000 mi US $425	Replaced driver's window motor. This is the only repair we have made to the MPV. Great car!
Feb 2011 57000 mi US $200	The PCV hose assembly was replaced.

Mazda MPV in Texas, United States Apr 2009 - Mar 2010
May 2009 147000 mi US $250	Car was dragging no exhaust power also check engine flashing off and on. New coil pack putting in van.

Mazda MPV in Oregon, United States Mar 2013 - Apr 2013
Apr 2013 159000 mi US $50	Right sliding door handle broke again. Replaced again with aftermarket handle.

Mazda MPV in Virginia, United States Dec 2013 - Jun 2017
Feb 2014 112200 mi US $1122	Replace PCV Valve Engine Oil Pan gasket Timing Cover/Gasket + Outer cover gasket
Apr 2014 113800 mi US $1120	Replace valve cover gaskets
Jul 2014 118800 mi US $500	Replace L/F Door mirror. Exposure to ice and snow during a past trip to Wisconsin created a small crack in the mirror glass. Virginia state inspection required me to replace it. Replace front stabilizer bar control links.
Jan 2015 127364 mi US $264	Engine analysis. Replace cylinder #4 ignition coil. Engine analysis. Replace cylinder #4 ignition coil.
Apr 2017 167000 mi US $170	replace ignition coils Replace drive belt

Mazda MPV in Texas, United States Jun 2009 - Jan 2011
Jun 2010 87000 mi US $240	Wouldn't start temp sensor

Mazda MPV in Georgia, United States Jul 2010 - Jan 2011
Jul 2010 109000 mi US $2500	One of the spark plug poped out while the car was still running. Latter we learned that the ciramic of the plug had melted & fallen into the cylinder, damaging the engine. I had no options but replace the engine.
Aug 2010 110000 mi US $2500	one of the cylinders lost compression

Mazda MPV in Virginia, United States Dec 2008 - Jun 2011
Jul 2008 70000 mi US $380	Park select sensor in steering column had to be replaced. THis switch lets the main comuputer know that the car is in park. When it fails, you can't remove the key from the ignition.
Dec 2009 95000 mi	Replaced worn front suspension lower control arms.

Mazda MPV in Virginia, United States May 2013 - Dec 2014
Sep 2013 109000 mi US $550	Strong smell of burnt oil from engine compartment, but nothing obvious seen under hood (smoke or actual oil) and nothing on the ground.

Mazda MPV in California, United States Aug 2008 - Jul 2018
Dec 2009 63000 mi US $150	Needed to replace driver headlight. Very hard to access it, have to remove battery and airduct, so had a shop replace all of the front lights and also one brake light.
Jun 2010 67000 mi	Engine oil pan gasket leaking. Didn't repair because will have to replace entire oil pan.
Oct 2010 69300 mi US $61	Changing light bulbs on Mazda no longer a DIY for this 65 yr old guy
Nov 2010 70100 mi US $400	Engine quit running. Replaced ignition module and cleaned fuel injector.
Mar 2012 79000 mi US $400	replace oxygen sensor
Aug 2012 82600 mi	new front brakes, plugs, and coils along with bodywork due to a collision.
Mar 2014 91000 mi US $250	oxygen sensor replaced
May 2014 92000 mi US $122	Front end noise on going over large bumps for several years. Finally diagnosed. Replaced front stabilizer links.
Jul 2014 93000 mi US $82	Had to replace driver headlight again after having it replaced it perhaps 3 years ago. Labor: $34.50 bulb: $20.20 (also replaced air filter: part-$26.24; labor-$11.50)
Jan 2015 81200 mi US $110	Check engine light: code re cat converter. Dealer was able to get light off after some magic. Needs to be smog tested. Expensive repairs if it fails.
Mar 2018 112000 mi US $760	water pump and belt cooling fan module replaced replaced air intake breather hose

Mazda MPV in Alabama, United States - Jan 2009
Jan 2009 107700 mi US $28	Replace fan control module.

Mazda MPV in Texas, United States Jun 2013 - Dec 2013
Dec 2013 98000 mi US $350	problem with ignition coils

Mazda MPV in California, United States - Apr 2006
Apr 2006 28152 mi	Transmission reflash and power door adjustments.

Mazda MPV in Massachusetts, United States Jun 2010 - Nov 2014
Jul 2010 113500 mi US $95	Replaced pads and rotors. I would have replaced the calipers as well if I had them on-hand.
Apr 2011 123000 mi US $1200	Noisy - had to replace expensive front pipes (one had integrated cat). Had tranny oil changed while there.
Jul 2013 163000 mi US $25	New outer passenger side tie rod end.
Jul 2014 179200 mi US $60	Replaced hood and drivers side door with same color hood/door from junk yard due to both being badly rusted out. Did a sheet metal/bondo/paint/clearcoat job on both rear wheel wells. Looks pretty good.
Oct 2014 180000 mi	Exhaust leak at manifold. Snapped bolt. Estimaged repair cost $1000+. Will soon go to the junk yard.
Nov 2014 180000 mi	Check engine light - multiple O2 sensor problems. Loud, running poorly. Took in for evaluation and was told that a bolt snapped off exhaust manifold - a very expensive repair + whatever else was wrong.

Mazda MPV in Pennsylvania, United States Aug 2010 - Jun 2011
Sep 2010 155000 mi	Remote stopped working, program failed, had to reprogram it. Check engine light went off, test say "Bank 1 collector full"(Oxygen) erased comp memo, have to drive on high octane fuel.

Mazda MPV in South Carolina, United States Jul 2008 - Mar 2010
Aug 2008 85000 mi US $225	Broken PCV hose. Had originally been replaced under recall. Refused to replace again.
Nov 2008 90000 mi	Power sliding doors failed. This has happened several times - 3 times under warranty. Finally just dismantled the power door feature.

Mazda MPV in British Columbia, Canada May 2008 - Nov 2014
Jun 2008 31000 mi C $100	Replaced Idle Air control valve at 50040. Stalling after hard acceleration when releasing the gas. Found the solution here: http://mazdaforum.com/m_49352/tm.htm
Jul 2011 58280 mi C $120	PCV hose failed. In 2004 Mazda issued a recall which our van had applied. Hose failed again. Replaced and it's all good not. Part number AJ51-13-89YB.
Jan 2012 61720 mi C $300	Clunk sound when going over bumps. Sway bar's replaced.
Aug 2012 67660 mi	Battery died. Replaced.

Mazda MPV in Pennsylvania, United States Oct 2007 - Jul 2014
May 2009 73000 mi US $79	Replaced burned out side marker bulb
Sep 2011 100000 mi US $3300	Rusted heater assy for rear HVAC replaced. Headlight replaced (broken by rock). 100K major service
Jun 2012 108000 mi	One Catalytic converter & two O2 sensors failed, due to engine misfiring.
Nov 2012 110400 mi US $2500	coils failed & needed to be replaced with plugs
Aug 2013 117700 mi US $250	coil failed - again & CAT Convertor damaged. Will not pass inspection. Going to trade this thing in- I'm done sinking $$$ into it....
Jul 2014 126000 mi	Traded with toasted cats.

Mazda MPV in Ontario, Canada Mar 2010 - Jun 2011
May 2010 76260 mi C $1487	Noticed leak in oil pan – relaced oil pan gasket and crank seal. Engine runs rough on idle – replaced EGR valve, by-pass valve, gasket, A.c. sket, A.C. Hose, P.C.V SE, P.C.V. valve. Repair Vacuum hose near left strut tower. Replace leak detection pump. Replaced front stabilizer links. Replaced transmission range switch.
Dec 2010 79360 mi C $702	1 -Engine idles rough after warming up. Sometimes it is so rough that it is better to turn the car off and drive it later. Ignition Coils replaced and now the engine idles very well. 2 -Intermittent problem starting...replaced battery

Mazda MPV in Maryland, United States Jun 2010 - Dec 2016
Jan 2011 66000 mi	Oxygen sensor replaced.
Feb 2013 76000 mi US $400	Replace PCV vacuum lines and related parts; clean intake; reset cel
Oct 2013 78000 mi US $550	Replace water pump, disconnect rear heat (lines leaking)
Aug 2014 84000 mi US $120	Engine cooling fans running erratically. Replaced fan control module. (Note - common MPV repair; use the Mazda part and not the $50 aftermarket alternative. I went the cheap route first and ended up doing the job again a week later.)
Jan 2015 79300 mi US $250	Replace motor mount Replace front links Replace O2 sensor
Feb 2016 89200 mi US $500	Diagnose problem; replace rear wheel sensor

Mazda MPV in Illinois, United States Aug 2010 - Jul 2011
May 2011 86900 mi US $236	Could not remove key from ignition switch. I replaced the "change control lever assembly" myself following Bubba's procedure found on mpvclub.com.
Jul 2011 89000 mi	Rust at door edges and other areas when sold.

Mazda MPV in Ontario, Canada Jan 2008 - Jun 2011
Mar 2009 117800 mi C $60	The fan control module was going crazy. A twenty minute job lasted for hours. Had to take the battery and tray out to get access. Module replaced with new version. Now working normally.
Apr 2009 119660 mi C $600	Ignition coils, which cost CAN$90 each. Mechanic suggested replace the back three with new ones. Then take one of the three old good ones to replace the defective one in the front and save the two good ones in case the ones in the front misfired again.
Jul 2009 124000 mi	Check engine light came on. Garage pulled and cleared the code. Oxygen sensor malfunction.($200)Garage will replace sensor if it is on again. No charge.
Dec 2009 130200 mi C $1000	Eventually one of the front 3 coils gone. Back 3 coils replaced earlier. Replaced the 3 coils with new ones($100@). 2 codes for 1 chk eng. replaced the PCV hose, $110. Mechanic said the hose is new design and should not crack.
Jan 2010 136400 mi	P0421 Bank1 cat efficiency below threshold. Reset by disconnecting battery. Have to change cat.
Apr 2010 14260 mi C $224	check engine light on again. "fixed" by disconnecting battery. Plan to replace catalytic converter before next emission test. Part of the flex pipe on the exhaust had a hole in it.
May 2010 145700 mi C $70	In the shop to check suspension and brakes. Rear drum brake seized. Mechanic able to free it and lubed the drum and cable. Front struts leaking, not fixed.
Jul 2010 148800 mi	Check engine light on again. Cleared by disconnecting negative terminal. I think it is the same catalytic converter problem.

Mazda MPV in South Carolina, United States Oct 2004 - Mar 2016
Apr 2004	TSB for Temp Sensor
Nov 2008 47000 mi US $28	Fan control module was replaced. I noticed the fan running a couple of times after vehicle was shut down. This was replaced under warranty also in 2004. New upgraded part for the Mazda 6 was used.
Oct 2010 61300 mi US $340	Coolant crossover pipe cracked. Part was a Mazda only part and took a couple of days to get in. Not a bad leak and wanted it replaced before any major damage happened.
Aug 2011 70000 mi US $1000	New brakes, 5 coils and plugs. All original.

Mazda MPV in Qatar Nov 2013 - Jul 2022
Dec 2013 71300 mi ﷼22	partly burned-out high-mount brake lights Jerky downshifting, fuel thirsty
Jul 2014 74600 mi ﷼40	Heater hoses cracked. Coolant leaked.
Nov 2015 83580 mi ﷼99	The O2 sensor (aka B1S1 P0031) malfunctioned and had to replace.
Apr 2017 91032740 mi ﷼4	drive belt tensioner bearing noise. bearing replaced and repaired.
Nov 2017 94240 mi	fan control module is erratic. runs unnecessarily high most of the time.
Jul 2022 117800 mi ﷼200	strut top mount cracked FR, FL

Mazda MPV in Indiana, United States Oct 2005 - Jun 2008
Nov 2005 13500 mi	Re-programmed auto transmission for shift shock and engine control module (removed a false check engine indication).

Mazda MPV in Saskatchewan, Canada Jan 2015 - Apr 2018
Jun 2017 109740 mi C $300	Pads worn
Apr 2018 117180 mi C $385	Brake pads were worn causing noise when brakes were applied

Mazda MPV in New York, United States Oct 2007 - Jun 2022
Jun 2011 68000 mi US $248	Ignition Coil #4 failed causing a check engine light, loss of power, vibration in engine, misfire. Coil replaced and MPV runs like new. Not bad considering almost 68,000 miles and 8 years old.
Sep 2011 70000 mi US $1700	Engine had loss of power and increase exhaust noise. Mechanic discovered hairline crack in Orig front stainless steel Exhaust Manifold. Crack was in rusted out seam weld in the exhaust manifold. Driver LF top Orig Oxygen Sensor Bad.
Mar 2012 72000 mi US $245	Original Ignition Coil #5 failed and replaced. Also # 5 Original Spark Plug replaced.
Jul 2012 75500 mi US $340	Passenger Rear Shock had rusted and rotted away exposing piston rod. Both rear shocks were replaced. Original rear Oxygen Sensor went bad and was replaced.
Sep 2012 77000 mi US $395	ABS and Brake Light on. Replace Original Left Rear Wheel Sensor.
Nov 2013 86100 mi US $264	Engine misfire. Original Ignition coil #6 Along with Original Mazda Platinum spark plug replaced. Engine smooth and power restored.
Jun 2014 90000 mi US $605	Loss of power during acceleration and when A/C on. Replaced all original spark plugs and the original 3 ignition coils and spark plugs closest to the firewall even though coils were still good since the labor was the same without the coils.
Sep 2014 91000 mi US $327	Original Passenger Rear ABS Sensor Failed. Part replaced and warning light reset.
Jan 2015 88300 mi US $131	Original exhaust flex pipe on passenger side rusted and rotted causing a hole resulting in noise. New flex pipe was welded in.
Jun 2015 96000 mi US $48	Original Driver's Front Caliper had a frozen piston. A rebuilt caliper purhased at AutoZone for $47.99 and installed.
Dec 2015 99000 mi US $259	Both front original sway bar link bars wore out. Both were replaced $127.30 total plus $95.00 labor.
Nov 2017 104000 mi US $42	Front Brake pads wore out . Pads replaced for $42.03 for Bosch Premium Ceramic Pads..
Jan 2018 104871 mi US $130	Battery went dead. New MT-35 Interstate Megatron 75 month battery installed.
Nov 2018 107000 mi US $281	Front Oxygen Sensor failure. Part replaced.
May 2019 107813 mi US $100	Two OEM flex pipes replace along with OriginalOEM Catalytic pipe , Original OEM intermediate pipe and Original OEM exhaust tailpipe replaced due to rust and corrosion from salt.. Check engine light on. Computer code read both engine banks running lean. Removed Original OEM Mass Air Flow Sensor as recommend by parts store and sprayed with CRC Mass Air Flow cleaner at $8.99. Reinstalled cleaned Mass Air flow Sensor and check engine light cleared by parts store. Engine runs perfect. Driver front caliper seized. Replaced with rebuilt unit at $49.00. New front brake pads installed Bosch at $40.67. Brakes were bled and brakes back to normal.
Oct 2019 108553 mi US $250	Bank 1 Sensor 1 upstream Oxygen sensor by firewall replaced.
Jul 2021 110585 mi US $50	Recharge refrigerant R134a.

Mazda MPV in California, United States Oct 2007 - Sep 2017
Mar 2008 78000 mi US $550	Ignition module/interconnect (related to lockout of electric sliding doors except when transmission is in "park". Malfunction caused audible warning to remain on constantly even when doors were closed. Electric doors failed to operate (electrically) ...
Dec 2010 125000 mi US $650	Engine light - diagnossis bad ingition coil. Coil replaced. Additionally replaced plugs.
Aug 2012 155000 mi US $550	Cooling System - Crack in radiator at upper hose connection. Starter developed grinding and no start problem. Started as random occurence, gradually increased frequency
Jan 2014 181000 mi US $200	Bad coil on number 3 cylinder
May 2014 189100 mi US $900	"Front" Engine seal replaced due to oil leak that dripped on exhaust pipe creating a very bad smell
Oct 2014 198000 mi US $125	Driver's (master) Power window switch would not operate rear windows at all. Not fixed. Passenger side window would only go up from driver's control. New switch fixed.
Jun 2015 206000 mi US $45	EVAP related CEL. Replaced purge valve and gas cap.
Feb 2016 217000 mi US $45	Window regulator failed (Plastic block that cleats the cable to slider) After a jerry-rigged repair attempt failed, two weeks later the entire assembly was replaced.
Apr 2016 220300 mi US $12	Gasket for IIAC valve (actuator) replaced
Jul 2016 222700 mi US $75	Emissions: O2 Sensor Bank 2, Sensor 1
Mar 2017 232000 mi US $50	Replaced Purge Valve, IIAC valve. Seemed to be fixed for a while, but engine light returned Took it to repair $$$hop. Replaced intake gaskets, PCV valve, air hose. Also performed smog check. A week later, same engine light / codes returned. Returned to repair shop, replaced purge valve (again)
Sep 2017 235000 mi US $175	Cooling fan running loud and erratic

Mazda MPV in Minnesota, United States Feb 2008 - Sep 2011
Jun 2008 78000 mi US $50	Replaced Coil #6. Check engine light would come on during rainy weather. Did repair myself after research on mpvclub.com.
Nov 2008 82 mi US $10	Replaced Front headlight bulb.
Jun 2009 96000 mi US $225	Replace the back 3 ignition coils. One was bad but replace all since had it apart. Known issue for this model for the earlier coil version to get moisture inside.
May 2011 119000 mi US $60	P0126 - ECT not reporting correct temp. Poor gas mileage plus minor coolant leak around the o-ring. Known issue with this car.

Mazda MPV in Colorado, United States Feb 2009 - Aug 2016
Feb 2009 109000 mi US $140	replaced engine oil pan gasket and fixed leak, replaced leaking ECT sensor, replaced worn front sway bar links
Mar 2009 114000 mi US $20	Replacement of PCV boot at engine manifold.
Aug 2010 145000 mi US $80	Replaced fan control module
Jan 2011 149000 mi US $1400	timing cover oil leak
Mar 2011 150000 mi US $300	Repaired oxygen sensor
Jun 2013 183000 mi US $28	replaced induction hose due to crack
Jun 2014 198000 mi US $400	Replaced radiator due to leak
Aug 2014 200000 mi US $200	replaced air bypass valve due to erratic idle
Sep 2015 216000 mi US $75	Replaced bad ignition coil
Nov 2015 219000 mi US $90	Replaced rear engine mount
Dec 2015 222000 mi US $180	Replaced rear bank ignition coils

Mazda MPV in Minnesota, United States Nov 2007 - Apr 2017
Oct 2008 107000 mi US $552	Replaced water pump.
May 2009 117000 mi US $330	Vehicle jerked when at stoplight. A hose was replaced that was leaking air. $90 for a rubber hose? Successful repair.

Mazda MPV in California, United States - Jan 2008
Jan 2008 105000 mi	Past repairs include replaced spark plug coils, replaced EGR hose

Mazda MPV in California, United States - Oct 2007
May 2004 17000 mi	sliding door motor replaced.
Oct 2007 87000 mi US $300	PCV hose replacemnt

Mazda MPV in Hawaii, United States Nov 2004 - Mar 2010
Mar 2004 14727 mi	Reflash transmission
Nov 2005 38196 mi	Replaced ignition coil-cyl #3

Mazda MPV in Virginia, United States Oct 2007 - Oct 2017
Nov 2007 65000 mi US $340	Engine was idling rough. It turns out the PCV hose had a hole in it (again). This was repaired a couple of years ago under recall but failed again.
Jun 2011 100000 mi US $359	Car was losing lots of coolant while driving. No puddles. Noticed coolant residue around water pump. Pressure test performed - no leaking hoses. Water pump was shot and they replaced it and all the coolant. Works great.

Mazda MPV in New Hampshire, United States Dec 2011 - Mar 2013
Nov 2011 85000 mi US $1100	coolant leaked from the back of the car. no repair. too expensive
Jan 2013 US $300	flex pipes on exhaust system were rusted out and wide open

Mazda MPV in Delaware, United States Nov 2007 - Jun 2015
Mar 2007 53000 mi US $360	Ignition coil for one cylinder failed, causing rough running in wet weather and CEL to stay on. Required two trips to shop: two hours' diagnosis, which was unsuccessful, but shop swapped ignition wires around so that when problem reappeared, they were abl
Dec 2007 64000 mi US $310	Oil pan gasket leaked engine leaked oil. Necessary to remove part of exhaust to access oil pan, adding to cost of replacing gasket.
Dec 2008 78000 mi US $150	PCV tubing leaked, causing lean-burn fault code. Part not available due to holidays, but car was drivable in interim Parts received and installed to repair PCV tubing.
Jan 2009 80000 mi US $230	Rough running and stalling caused by faulty coolant temp sensor, causing CEL light to come on. Could not drive car except very short distance with cold engine.
Mar 2009 81000 mi US $600	Abrupt shifting, particulary 1 to 2 at low road speed, diagnosed as due to failed ring sensor in transmission. Sensor replaced.
Dec 2009 88000 mi US $500	For 3rd time, an ignition coil failed, causing short in wet weather; misfiring on 1 cylinder. Extensive labor to access rear cylinder bank. Replcd coil & rmng 3 originals. Also replcd plugs to avoid repeat of labor later (addl $ not included)
Mar 2010 90000 mi US $300	Coolant leaking. Replaced water pump. Rear heater not working; plugged line or valve possible, but will be evaluated at a later time.
Jun 2011 100000 mi US $600	Cooling system hose leaking; replaced
Oct 2011 107000 mi US $800	Piping to rear heater corroded and leaking coolant. Replaced with new parts - past extended warranty that Mazda has reportedly added for this problem.
Sep 2013 125000 mi US $300	Replaced CV joint on right side as inner and outer boots were both compromised
Mar 2014 136000 mi US $1400	Heater core leaking with odor of hot coolant inside vehicle. Very lengthy labor to access, thus high cost.
Oct 2014 138000 mi US $1600	Oil leak had been noted on a prior maintenance visit - burning oil smell now apparent. Timing chain cover gasket leaked oil onto exhaust manifold. Extensive labor expense. Timing chains, tensioners, guides found to be very clean.
Jan 2015 138200 mi	Replaced one catalytic converter.
Apr 2015 139000 mi US $410	Brake master cylinder leaking fluid; replaced.
Jun 2015 139000 mi	Exhaust system extremely rusty and near end of life. Replaced one catalytic converter earlier in year; three more in system remained with unknown reliability.

Mazda MPV in Ontario, Canada Feb 2011 - May 2011
May 2011 111600 mi	cv joint needed replacing when sold.

Mazda MPV in Botswana Oct 2012 - Jun 2013
Jan 2013	temperature sensor no way to be found and when taking long trip it finishes water in engine.

Mazda MPV in Virginia, United States Apr 2011 - Jul 2011
Jul 2011 173000 mi	Exhaust manifold leaking when sold.

Mazda MPV in Texas, United States Dec 2011 - Jun 2013
May 2013 219900 mi US $3900	Engine was replaced Transmission was replaced ECU Replaced

Mazda MPV in Quebec, Canada Nov 2009 - Jul 2011
Mar 2011 62620 mi C $500	Rear heater pipe rusted through; leaking coolant. Front heater piper was degraded, so replaced as a preventative measure. Flushed radiator as well.

Mazda MPV in Kansas, United States Apr 2012 - Mar 2015
Feb 2013 98600 mi US $300	drivers side power window motor replaced
Sep 2013 103000 mi US $300	Drivers power window controller replaced
Mar 2015 129000 mi US $900	Cylinder coil failure

Mazda MPV in Massachusetts, United States Aug 2009 - Jun 2011
Sep 2009 174000 mi US $300	Replaced Manifold Air Pressure Sensor with used parts. Replaced Liquid Purge Box with used parts.

Mazda MPV in Washington, United States Aug 2009 - Mar 2010
Sep 2009 61000 mi US $300	PCV line assembly replaced due to PCV fail. Mechanic says this is a known problem on Ford engines

Mazda MPV in Michigan, United States Dec 2009 - Jun 2011
Jan 2010 80000 mi US $550	Replace gaskets to stop tranny leak and replace cv boots
Apr 2010 83000 mi US $650	replace hoses to repair air conditioning system

Mazda MPV in Ohio, United States Jun 2010 - Jun 2011
Jul 2010 103000 mi US $750	front suspension noisy. replaced parts of suspension

Mazda MPV in Minnesota, United States Aug 2009 - Aug 2016
Oct 2010 171500 mi US $40	Thought it was leaking oil, was slow leak in cooling system. Ship repaired gratis since they had done maintenance on cooling system earlier in the year.
Jun 2012 195000 mi US $1600	Radiator core failed. Hoses replaced.
Feb 2013 203500 mi US $1200	Vacuum leak, coil replacement, sensor cleaning.
Aug 2013 207000 mi US $350	PCV Valve replaced, hose rotting and air leaking giving a whistle sound.
Apr 2015 210200 mi US $450	Exhaust - left flex pipe came out, needed replacing.

Mazda MPV in Ontario, Canada - Feb 2009
Feb 2009 68200 mi	2 front wheel bearing is gone. Water pump leaking. Coolant pipe to the rear heater rust out about 700 labour & parts

Mazda MPV in New York, United States Jan 2011 - Feb 2012
Feb 2012 68000 mi	The exhaust manifold was cracked. Too expensive to repair on a 10 year old car.

Mazda MPV in North Carolina, United States Jan 2010 - Sep 2010
Mar 2010 102500 mi US $200	Oxygen sensor, sway bar links, spark plugs Lower Control Arms - ball joints had failed
Apr 2010 104000 mi US $200	Replaced both lower control arms as the ball joints were worn. Royal pain to do it, but saved a ton of money. Front suspension is still squeaking - suspect manufacturer did not sufficiently lube ball joints on new control arms.
May 2010 104200 mi US $40	Front engine mount replacement

Mazda MPV in New Jersey, United States - Dec 2007
Jan 2004 35000 mi	two coil replaced under warranty fan control module replaced under warranty AT reflash to cure rough shifting
Oct 2005 54000 mi US $100	Tranny dead, replaced under extended warranty
Jul 2006 60000 mi US $200	Two more coil replaced under extended warranty on two occasions
Oct 2006 65000 mi US $80	replaced 1 more coil (do-it-yourself)
Jan 2007 83000 mi US $100	oil pan leak fixed under extended warranty
Jul 2007 90000 mi US $80	last coil replaced (DIY)
Aug 2007 92000 mi US $25	fan control module replaced (DIY)
Dec 2007 95000 mi US $200	flexpipe leak, to be fixed for $200 (muffler shop estimate)

Mazda MPV in Pennsylvania, United States - Jul 2007
Jun 2002 2500 mi	OD light flashed, towed to dealer as recommended, replaced sensor covered under warranty
Jul 2007 70030 mi US $2800	Without warning, transmission has failed. Seems to be common problem when checking other sites like Edmunds. 1st gear and internal pump have caused total failure. Mazada will do nothing to admit they may have a problem here.

Mazda MPV in Ontario, Canada Dec 2011 - Dec 2012
Dec 2012 155000 mi	O2 sensor. Will cost about $310, will probably replace it in February.

Mazda MPV in South Carolina, United States Jun 2010 - Jan 2017
Aug 2013 95000 mi US $1500	Engine missing. Coils replaced.
Dec 2013 101000 mi US $200	Oxygen sensor replaced
Apr 2014 104200 mi US $980	Exhaust manifold cracked. Had to be replaced.
Jun 2016 129000 mi US $85	Left Rear wheel bearing became noisy. I replaced it
Aug 2016 133000 mi US $850	I replaced the rear shocks, front struts, ball joints and tie rod ends to correct slightly loose steering and road wander that had developed from many years of use. This was entirely optional, but made for better driving on trips.
Jan 2017 101000 mi	The rack has a slight fluid leak

Mazda MPV in Georgia, United States Sep 2016 - Apr 2022
Oct 2017 124000 mi US $2500	Complete failure of transmission, which was replaced with low mileage used one (2 yr warranty)
Nov 2019 144000 mi US $200	MAF, MAP, EGR, PCV, ICV all replaced
Dec 2021 164000 mi US $300	New radiator and water pump

Mazda MPV in Ontario, Canada Jun 2013 - Dec 2014
Jul 2014 125540 mi	driver door not opening, this is the second time this car is having this issue
Dec 2014 127100 mi	Shifter sticks while moving to Park.

Mazda MPV in New York, United States Aug 2009 - Feb 2014
Feb 2010 104900 mi US $700	replace water pump and all 4 tires
Jul 2012 129500 mi US $1400	New catalytic converter + New oxygen sensor (part of exhaust system). AC recharge + New air filter (routine maint item) + New tires (routine maint item)
Jul 2013 139000 mi US $150	Broken so replace
Feb 2014 140000 mi	Cylinder misfire

Mazda MPV in Oregon, United States Aug 2009 - Jun 2011
Sep 2009 85000 mi	Leaking water pump was replaced. Engine was rinsed to reduce the residual coolant on the outside of the engine.

Mazda MPV in California, United States Sep 2011 - Jun 2017
Jun 2013 114000 mi US $50	Throttle body cleaning
Jul 2013 114200 mi US $350	Both front bearings replaced.
Mar 2015 125000 mi US $250	Check engine light. O2 sensor.
Sep 2016 135000 mi US $100	Leaky radiator. Had to replace. The radiator I order from Amazon, did not fit. So, we put some glue and put it back. I have to refill it once a month now instead of every 2 weeks :)

Mazda MPV in Virginia, United States Mar 2011 - Sep 2012
May 2011 135500 mi US $250	Replaced faulty ignition coil bank.
Sep 2012 145000 mi US $140	Transmission failed

Mazda MPV in Ohio, United States Aug 2010 - Jan 2012
Mar 2011 139000 mi US $900	OBD II Check Engine revealed Misfire Codes
Nov 2011 157000 mi US $100	Check

Mazda MPV in Florida, United States Jun 2014 - Jun 2014
Jun 2014 US $240	Catalytic converters ... not worth fixing. Car no longer runs, selling it for scrap.

Mazda MPV in New South Wales, Australia May 2010 - Apr 2016
May 2010 102300 mi	Misfire noticeable going uphills or when accelerating.Had Mazda check but no engine codes present.Suggested replace ignition leads. Installed Top Gun brand and appears ok.
Mar 2014 129580 mi A $500	brake master cylinder replaced

Mazda MPV in Quebec, Canada Mar 2014 - Sep 2014
Apr 2014 106640 mi C $300	Belt tensioner needed replacing (w/ new belt)
Sep 2014 110980 mi	Some sort of short circuit in the ignition system.

Mazda MPV in British Columbia, Canada Apr 2015 - Jun 2016
Apr 2015 138880 mi C $280	The driver's power window got stuck 2/3's of the way up. It would not go up or down. The shop had to swap the mechanism out for a new one. It is cable driven and the cable had become so frayed that it had bound up on itself.
Dec 2015 157480 mi C $750	The rear drums and wheel cylinders needed to be replaced. The shoes only had 2 mil wear on them since they were replaced and so they were fine.

Mazda MPV in Massachusetts, United States Aug 2014 - Feb 2015
Dec 2014 153000 mi	Engine has begun to leak small amounts of oil.
Feb 2015 153000 mi	Engine started burning oil at a rate of one quart every 50 miles. Sold it for salvage.

Mazda MPV in Arizona, United States Dec 2014 - Apr 2015
Feb 2015 210700 mi US $250	rough driving

Mazda MPV in Rhode Island, United States May 2009 - Aug 2009
Jun 2009 89000 mi US $250	Water pump not working properly.
Aug 2009 89000 mi	Traded in under C4C with minor electrical problems (the interior door lights would not turn off when the car was running).

Mazda MPV in Ontario, Canada Aug 2009 - Feb 2010
Sep 2009 93000 mi C $350	oil pan replaced due to damaged thread
Dec 2009 95480 mi C $350	leaking engine oil. gaskets need replacement

Mazda MPV in New Jersey, United States Jun 2009 - Jun 2015
Sep 2009 133000 mi US $200	Found a hair line crack on the right side of the radiator after filling antifreeze to the recovery tank almost everyday. Replaced the defective radiator.
Jan 2010 136000 mi US $453	rough idle and spewing nauscious exhaust fumes. replaced ignition wire set and all six spark plugs.
Feb 2010 137000 mi US $56	Erratic Idle speed problem recurred after spark plug/ignition wire set replacement. Replaced ignition coil module, idle speed back to normal. Replaced ignition coil pack in an attempt to improve spark intensity. Intermittent rough idle problem was cleared and returned.
Mar 2010 138000 mi US $2	DTC's P0171 and P0174 occur once every four to five days. Replaced broken Idle Air Control Valve gasket. No DTC's noted. Lesson learned: Do Not re-use any gaskets.
Jul 2010 142000 mi US $6	Loss of air conditioning. Repair shop replaced defective compressor and recharged with new refrigerant. Check Engine Light DTG P0455. Replaced gas tank cap. No CEL.
Oct 2010 145000 mi US $80	Replaced worn out rear shocks because they make noise over bumps.
Dec 2010 147000 mi US $15	REPLACED PCV VALVE DUE TO P0171 DTC AND CONDENSATION (MILKY OIL FILM ON OLD PCV VALVE). ADDED CLAMPS TO PCV VACUUM HOSE CONNECTIONS.
Feb 2011 148000 mi US $407	Heard loud whining noise and the Battery warning light was lit. Replaced alternator to clear both.
May 2011 150883 mi	constant random misfire dtc P0300, found crack in a rubber air hose connects air filter to IAC. constant random misfire dtc P0300, found crack in a rubber air hose connects air filter to IAC.
Jan 2012 160000 mi US $185	Engine crank but won't start. Replaced all (6) fouled platinum +4 spark plugs that only ran 24,000 miles. No check engine light.

Mazda MPV in Georgia, United States Jul 2008 - May 2011
Mar 2009 108000 mi	CEL came on, van running fine. I took it to autozone and was told that an O2 sensor needs replaced. I'm going to wait a bit until I can afford to replace it.
Oct 2010 108000 mi	Water pump failed, replaced. Negative battery terminal rusted away from the wire. Replaced, van now starts. O2 sensor on order O2 sensor installed.

Mazda MPV in Delaware, United States May 2009 - May 2014
Sep 2010 116000 mi US $140	Replace leaky flex pipe.
Oct 2010 118000 mi US $300	Driver side power lock actuator gear failed. New one installed.
Jun 2011 125000 mi US $62	Right Lift support rusted out and broke. Replace both Left and Right lift support.
Aug 2011 128000 mi US $150	replaced the rear ac/heat pipe as it is leaking antifreeze.
Dec 2011 129000 mi US $500	Alternator not charging. Battery light came on. Replace alternator and battery.
Apr 2012 131800 mi US $150	the remanufactured alternator had only 1 yr warranty. Failed during a long trip (8 hrs) and luckily replaced with a remanufactured alternator (CHAMPION) that has 3 yr warranty with no charge for labor. Paid extra 150 for it though.
Jun 2013 144000 mi US $200	Replace passenger side lock actuator. Rear right door lock actuator not working too. But skip that repair to save money.
May 2014 148000 mi	Rear right door lock actuator not working.

Mazda MPV in Queensland, Australia Jun 2008 - Dec 2017
Oct 2008 111600 mi A $100	Cooling system overflow bottle leaking.
May 2009 119660 mi A $250	Engine ignition coil failing have replaced HT leads, waiting for coil.
Jun 2009 120280 mi	Replaced ignition leads with OEM brand from Top gun and turned out didnt require the coil at all.
Aug 2009 122760 mi A $50	Coolant leak from top radiator hose. System pressurised to find leak. Hose clamps replaced.
Nov 2009 123380 mi A $450	Connecting hose to thermostat/engine/water pump failed. Water pump required replacement (original waterpump lasted almost 200,000km).
Feb 2010 126260 mi A $450	Axle Bump Stops needed replacement.
Nov 2010 132260 mi A $900	Radiator was repaired just over three years ago, but has consistently been failing as the car has been overheating up major hills etc.
Dec 2010 132680 mi A $885	Replaced Shock absorbers all round. Orignal equipment has lasted 11 years and >200,000km.
Dec 2012 157480 mi A $200	High tension leads
Oct 2013 166240 mi A $285	Rubber Coupling needed replacing
Nov 2013 167400 mi A $200	Replacement of rear view mirror after it fell off in my hand (probably sun damage over the years).
Mar 2014 172360 mi A $900	Starter Motor failure and replacement

Mazda MPV in California, United States May 2011 - Jan 2012
Jul 2011 110000 mi US $1000	Knocking sound on front struts/suspension.
Jan 2012	Rear door passenger side sliding door lock actuator failed.

Mazda MPV in Ontario, Canada Aug 2010 - Sep 2015
Oct 2011 148800 mi C $360	Replaced alternator.

Mazda MPV in California, United States Nov 2012 - Mar 2015
Nov 2013 111000 mi US $20	Was told in Mar my check engine light code was replace catalytic converter. Waited til registration due because of high cost. Went to another mechanic - code was for vacuum leak but he found none and reset chk eng light

Mazda MPV in Pennsylvania, United States Jun 2010 - Mar 2011
Dec 2010 45000 mi US $300	New brake drums, belts and  motor mount.

Mazda MPV in Florida, United States Feb 2009 - Jun 2013
Sep 2012 234000 mi US $170	Replaced leaking Radiator
Jan 2013 242000 mi US $193	Coolant hose failure.

Mazda MPV in New Jersey, United States Mar 2013 - Apr 2014
Apr 2014 168000 mi US $600	Inherent overheating , which anyone with knowledge of the Canadian engine swap "fiasco" is well aware of. These vehicles should have all been recalled for engine replacements!!

Mazda MPV in Wisconsin, United States May 2008 - Nov 2012
Jun 2009 112000 mi US $150	Water pump failed at 112,000 miles. Replaced with OEM replacement part.
Aug 2009 113000 mi US $400	Bad ball joint on driver's side. Replaced both lower control arms as a preventative measure.
Nov 2009 115000 mi US $900	Windings in alternator failed, alternator seized.
Aug 2010 122000 mi US $350	Replaced 2 front struts.
Mar 2011 137000 mi US $550	Front brakes replaced (pads, rotors, and 1 caliper), coolant leak in rear heater fixed.
Oct 2012 173000 mi US $20	Replaced right side tie rod end

Mazda MPV in Nigeria Sep 2011 - Jun 2018
Oct 2011 68820 mi $250	Faulty right tire hub gave way, Speedometer & odometer stopped working after. Speedometer sensor fixed. When trying to fix speedometer previously,the trans got bad and wouldn't change gear, O/D light on.
Apr 2014 132740 mi $400	transmission shot, had to be either repaired or replaced opted to replace
Jul 2014 139500 mi	fixed holes in the exhaust with the use of steel wool, steel cans and clamps to improve fuel economy cracks in rear suspension welded, I mean this component http://www.mazdapartsunlimited.com/auto-parts/2000/mazda/mpv/lx-trim/2-5l-v6-gas-engine/suspension-cat/suspension-springs-and-related-components-scat/54224505-assy
Aug 2014 139500 mi $150	The ignition coil failed, was replaced with used.

Mazda MPV in Mozambique Mar 2012 - Mar 2013
Mar 2013 79360 mi	Exhaust Manifold Gasket need to be replaced the acelerator sensor was not working and the car wasnt developing the speeds. Was just running in the first gear spark plugs

Mazda MPV in California, United States Mar 2011 - Aug 2014
Nov 2012 119400 mi US $500	Oxygen sensor replaced, periodic maintenance nag reset

Mazda MPV in North Dakota, United States May 2008 - Jul 2014
Mar 2009 84000 mi US $220	Alternator failed.
May 2010 90600 mi US $545	Front seal was leaking oil. Replaced.
Aug 2011 107000 mi US $556	The alternator stopped charging and it was replaced.
Mar 2012 111000 mi US $350	Battery drained. Fusable link was blown during jump start. Blown fuses were replaced and cause of battery drain was determined to be radio, which was diconnected.
Apr 2013 123200 mi US $458	intake manifold gasket was leaking. Replaced.
Sep 2013 131000 mi US $283	Window regulator for drivers door went out
Mar 2014 132000 mi US $145	Replaced rear shocks

Mazda MPV in California, United States May 2008 - Mar 2010
Jun 2008 80000 mi	replace catalytic converter

Mazda MPV in Minnesota, United States Jun 2009 - Dec 2009
Jul 2009 139000 mi US $380	o2 sensor was replaced, first replacement at 139k. pretty good for an o2, usually see them go a lot sooner.
Nov 2009 139000 mi US $1100	Radiator leaking, replaced radiator, thermostat and hoses. CEL came on, replaced intake and exhaust gaskets.
Dec 2009 139000 mi US $275	Oil cooler transmission line failed, reattached line with a clamp and then traded-in vehicle.