| 1 | 0 | 3 | 4 | 3 | 4 |
Expensive Mercury Milan repairs by problem area
Engine (13%)
Transmission and Drivetrain (20%)
Brakes and Traction Control (7%)
Suspension and Steering (33%)
Electrical and Air Conditioning (27%)
Paint, Rust, Leaks, Rattles, and Trim (0%)
Other (0%)
Chart based on 15 repairs.
Mercury Milan repair cost distribution
$2500+ (0%)
$1000 - $2499 (100%)
$500 - $999 (0%)
$100 - $499 (0%)
< $100 (0%)
Chart based on 13 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2011 Mercury Milan 4dr Sedan
240-horsepower 3.0L V6 6-speed shiftable automatic FWD
| 47100 mi US $106 |
Check engine light triggered due to gas tank spout valve showed ECU valve was not closing completely. |
| 84000 mi US $300 |
Flush Trans fluid very dark color |
| 45800 mi US $1250 |
Tie Rod bushings failed |
| 105550 mi US $1615 |
Replaced Blower Motor, Wiring Harness and Blower Resistor. Had burning smell while using AC, this problem occurred once in a while for a few years. Finally Blower Motor stopped working. Job was very easy other than having to solder wires. Replaced entire Electrical Power Steering Unit. Warning light came upon dashboard, car was extremely difficult to steer. Car ran perfectly earlier that day. This happened about 2 months previously, I disconnected a battery terminal and reinstalled. It then ran fine and I forgot about it. When it happened this time disconnecting the terminal did not help, as I tried it several times. There was a recall on this very item but.....my car had a "born on date" 10 days before official date. I feel as though my car should have been covered, since it had the same symptoms as the vehicles which were recalled. $1400. Dealer found 3 Exhaust System Gaskets which needed replacing while they were repairing Power Steering Unit. $215. |
2010 Mercury Milan 4dr Sedan
175-horsepower 2.5L I4 6-speed automatic FWD
| 82700 mi US $2000 |
Power steering control module needed replacement due to an actuator being stuck open. |
2010 Mercury Milan 4dr Sedan
156-horsepower 2.5L I4 Hybrid CVT FWD
| 39700 mi US $325 |
Started hearing grinding coming from wheel area. Eventually diagnosed as LF wheel bearing. Initially dealer thought it was a rotor issue and turned the rotor but it didn't fix problem and had to return for a second trip. |
| 52800 mi US $650 |
Replace rear breaks. Cost is estimated as I can't find the receipt. |
| 55553 mi US $1300 |
AC condenser |
2009 Mercury Milan 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic AWD
| 71000 mi US $200 |
Noise low frequency creaking coming from the passenger side front wheel well area when turning or going over bumps. No definitive diagnosis or fix but somehow dealer improved the situation but did not completely eliminate it. |
| 105000 mi US $1370 |
Rear passenger side bearing relaxed . Brake disks and pads replaced |
2008 Mercury Milan 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic FWD
| 136000 mi US $1664 |
Hydraulic booster failure |
2007 Mercury Milan
Engine not specified
| 78000 mi US $1040 |
AW Drive split in half.. |
2007 Mercury Milan 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic FWD
| 85000 mi US $2080 |
the blower fan would stop working without any noticable warning. The blower would start working again in as few as 5 minutes or as long as 1 hour. this happened 3 times the i took car to dealership. Blower and special order wiring harness installed |
| 86000 mi US $300 |
Starter failed |
| 32428 mi US $1652 |
AC compressor failed at 32,400 miles, was not covered under extended powertrain warranty. Total cost $1652. |
| 44540 mi US $155 |
front boot on cv joint was torn, leaking grease. |
| 86250 mi US $150 |
engine mount, transmission mount |
| 91684 mi US $130 |
slightly bent wheel which was repaired |
2007 Mercury Milan 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic AWD
| 45000 mi US $550 |
Coil pack to number 1 cylinder was failing. The coil was replaced and spark plugs were replaced, as they would have been due at 50,000 miles. |
| 81000 mi US $300 |
Bottom of the oil pan leak. Replace gasket and seal. |
| 84000 mi US $1695 |
Vibration of drive line due to failing bearings in the line |
2007 Mercury Milan 4dr Sedan
160-horsepower 2.3L I4 5-speed automatic FWD
| 67000 mi US $491 |
Engine light came on. Auto Zone determined it was a coolant system issue. Dealer replaced thermostat and housing. Also determined battery needed replacing as car would not restart. Total cost: $491 ($115 for new battery) |
| 122000 mi US $1250 |
Air conditioner did not effectively cool. Condenser actuator, interior "sniffer" sensor, and in-dash HVAC computer were replaced. $1,250 total cost, parts and labor. |
| 156000 mi US $1093 |
Loud loose squeaking noise from front end during city driving and turning. Lower front control arms replaced. Engine was loose in engine bay. Visibly moved when gears changed. Broken motor mount was discovered and replaced. |
| 157300 mi US $580 |
Rear brake calipers locked up after replacement of rear rotors and pads. Both rear calipers were replaced. |
| 164000 mi US $1972 |
Transmission rebuilt. |
| 171000 mi US $659 |
Blower motor and resistor failed and were replaced. Belt tensioner replaced. Valve cover gasket leaking and replaced. |
| 174000 mi US $285 |
Driver's interior door handle broken. Door would not open from inside. |
See TrueDelta's information for all Sedans
See TrueDelta's information for all Mercury models.
