| 1 | 0 | 3 | 4 | 3 | 4 |
Plymouth Voyager / Grand Voyager repairs by problem area
Engine (28%)
Transmission and Drivetrain (15%)
Brakes and Traction Control (2%)
Suspension and Steering (17%)
Electrical and Air Conditioning (34%)
Paint, Rust, Leaks, Rattles, and Trim (4%)
Other (0%)
Chart based on 47 repairs.
Plymouth Voyager / Grand Voyager repair cost distribution
$2500+ (2%)
$1000 - $2499 (12%)
$500 - $999 (7%)
$100 - $499 (27%)
< $100 (51%)
Chart based on 41 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2000 Plymouth Voyager / Grand Voyager 4dr Minivan
150-horsepower 3.0L V6 4-speed automatic FWD
| Plymouth Voyager / Grand Voyager in Kansas, United States May 2010 - Oct 2010 | |||
| Aug 2010203000 miUS $250 | Front wheel bearing replaced. | ||
| Oct 2010204000 mi | Transmission died and due to accessive mileage, car was sold for scrap. 205 thou on engine. ALSO, Engine had a leak : Antifreeze/ water was entering the engine and was blowing out tailpipe.......... I Gave-up the fight. | ||
| Plymouth Voyager / Grand Voyager in Ontario, Canada Apr 2013 - Jun 2014 | |||
| Jun 2013122140 miC $1800 | Tie rod replaced. Wheel alignment. Back brakes rebuild. New tires | ||
2000 Plymouth Voyager / Grand Voyager 4dr Minivan
150-horsepower 2.4L I4 3-speed automatic FWD
| Plymouth Voyager / Grand Voyager in Illinois, United States May 2011 - Mar 2013 | |||
| Dec 2011109000 miUS $153 | oil pressure switch was broken and replaced | ||
| Mar 2012110000 miUS $80 | coolant leak | ||
| May 2012110900 miUS $164 | coolant leak, dye trace added | ||
| Mar 2013114000 mi | timing belt broken | ||
2000 Plymouth Voyager / Grand Voyager 4-door
6-cylinder automatic 2WD
| Plymouth in Ohio, United States Aug 2008 - Jan 2010 | |||
| Oct 2008117000 miUS $35 | Replaced leaking transmission side cover and gasket. Replaced worn rear shocks. | ||
| Feb 2009124000 miUS $550 | Replaced front strut assemblies, front tie rods, and front sway bar links. | ||
| Jun 2009130000 miUS $50 | Recharged air conditioning with freon-system working as normal now. | ||
| Oct 2009140000 miUS $30 | Repaired broken rear heater hoses | ||
| Plymouth in Alabama, United States Mar 2009 - Jun 2009 | |||
| Jun 2009167000 mi | Unrepaired problems when traded included a radiator leak, transmission cooling line leak (likely rubber line at radiator) , and difficulty steering at idle speed in hot weather after warming up. | ||
1999 Plymouth Voyager / Grand Voyager 4-door
6-cylinder automatic 2WD
| Plymouth in North Carolina, United States Apr 2015 - Jun 2018 | |||
| Jul 2015109000 mi | Calipers were not fully releasing causing a brake pad smell and slightly poorer mileage. Replace calipers, rotors, pads; problem fixed. Clicking driver CV joint. Replaced. All is well with the world now. | ||
1998 Plymouth Voyager / Grand Voyager
Engine not specified
| Plymouth in Alabama, United States Jun 2012 - Jul 2012 | |||
| Jul 2012208000 miUS $18 | Temperature Sending unit was not working properly. Did not allow PCM to turn on cooling fans, causing engine to overheat, but temp gauge showed normal temp. | ||
| Plymouth in New Jersey, United States Feb 2014 - Feb 2014 | |||
| Feb 201492000 miUS $1650 | Head gasket blew. Car did not overheat. Replaced water pump at time of repair too | ||
| Plymouth in Florida, United States Dec 2011 - Jul 2012 | |||
| Jan 201278300 mi | leak in the front seal was fixed. the belt tensioner pulley was replaced along with a new belt | ||
| Apr 201280000 miUS $100 | replaced A/C condenser | ||
| Plymouth in Alabama, United States Mar 2011 - Apr 2013 | |||
| Jul 2011189500 miUS $250 | went into limp mode | ||
| Apr 2013209000 miUS $3200 | Transmission would not shift | ||
1998 Plymouth Voyager / Grand Voyager 4-door
6-cylinder automatic 2WD
| Plymouth in Minnesota, United States Jun 2009 - Nov 2015 | |||
| Jul 2010187500 miUS $1300 | electrical parts (replaced the instrument cluster, air bag clock spring & turn signal switch) | ||
| Jun 2011196000 miUS $300 | Replaced two tires and aligned. Also had a repair cap placed on the strut tower as it was rusting out (engine compartment next to the battery) | ||
| Plymouth in Ontario, Canada Mar 2011 - Jul 2013 | |||
| Nov 2011159660 mi | Instrument panel was not working. No Speedo, Tach, fuel gauge, instruments did not light up at all. Mechanic gave engine a rev, then literally hit the panel with his hand, and the problem was solved within 3 seconds. | ||
| Jul 2013186620 mi | Gas pump was making a whining noise. Problem was solved when gas pump fuse was replaced | ||
1998 Plymouth Voyager / Grand Voyager
4-cylinder automatic 2WD
| Plymouth in Ohio, United States Jul 2008 - Apr 2015 | |||
| Aug 2008156000 miUS $550 | Drive shaft on drivers side snapped in half. Repair shop has seen this many time before. Rusted through one inch diameter shaft at rubber balancing anti vibration fitting which holds in the moisture. Road trip on vacation the air conditioning compressor locked-up solid burning off the serpentine belt. Both items replaced and van picked up after vacation. On trip home, air stopped working again. Our local repair shop added more freon and all is well. | ||
| Aug 2011164000 miUS $90 | Few years back, the ac froze up and burned the belt off. Shop repaired but did not find a leak in the heat exchanger. Second shop recharged freon and added dye, I found leak. I added $30/3oz leak repair + 3x$20/12oz freon. So far so good. | ||
| Oct 2011166000 miUS $5 | replaced ground lead going to battery | ||
| Nov 2011166300 miUS $300 | Loss of coolant, but no hole found. Suspect Head Gasket (repaired 2 times 80,000 miles ago). After coolant flush (and Head Gasket seal solution) found radiator hole. New radiator and hoses. Runs good for last month. (Belt is squeeking now.) | ||
| Jul 2013182500 miUS $40 | Alternator rebuilt. Dashboard electrical failure. While driving, dash seems to go dead. May come back and work again. Usually works when car is started. Replaced wires to battery. Did not repair problem. | ||
| Apr 2015199000 miUS $100 | First compression loss lead to thicker oils. Second double gasket on oil filter change lead to oil dump and over heat. Third seized engine freed, but then engine compression worse. Fourth thick oil leads to bent piston rod. Drove to dump. | ||
1997 Plymouth Voyager / Grand Voyager
Engine not specified
| Plymouth in New Jersey, United States Jun 2009 - Mar 2010 | |||
| Jul 2009167000 miUS $1400 | radiator fluid not staying in overflow tank. noticed leak when adding fluid. waterpump replaced and new tires. | ||
| Plymouth in California, United States Oct 2011 - Dec 2011 | |||
| Dec 201178000 mi | radiator leak, minor. mechanic recommended stop leak before replacing radiator | ||
| Plymouth in Florida, United States May 2012 - Aug 2013 | |||
| Jun 2012136000 mi | needed to replace the starter. | ||
1996 Plymouth Voyager / Grand Voyager 4-door
6-cylinder automatic 2WD
| Plymouth in South Carolina, United States May 2008 - Jun 2012 | |||
| Jun 2009116000 mi | Oxygen sensor replaced | ||
| Sep 2010123000 mi | The rear window was leaking, so I sealed it with silicone. | ||
| Apr 2012126000 miUS $200 | Passenger window regulator failed and had to be replaced. Also replaced power seat that was unable to go back and forth. | ||
| May 2012126000 miUS $150 | Replaced driver's seat due to failed seat position motor. | ||
| Plymouth in Ontario, Canada May 2008 - Jan 2009 | |||
| Jun 2008145080 miC $1000 | Strut towers were corroded, fixed with Chrysler repair kits. Problem with all Caravans and Voyagers, 1996 to 2000. Major Leak in Power Stering lines, corroded. Outer Ball Joint, driver side. | ||
| Sep 2008150040 miC $600 | Power steering pump. | ||
| Plymouth in Colorado, United States Feb 2011 - Aug 2011 | |||
| Aug 2011115000 mi | dash lights inoperative, power locks, cruise control not working when gave minivan away to friends. new owners had mechanic wire around the dimmer control for the dash lights - diagnosis and troubleshooting and repair was $350. | ||
See TrueDelta's information for all Plymouth models.
