We are 103,000+ car owners sharing real-world car information.

Join Us

2003 Toyota Tacoma Technical Service Bulletins (TSBs)

sort by date
TSB Date Problem Area TSB Text
04/23/18 NHTSA ID: 10134128
TSB ID: TSB-0012-13 Rev2

Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bull
04/23/18 NHTSA ID: 10134223
TSB ID: T-TT-0362-15

Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
04/02/18 NHTSA ID: 10132529
TSB ID: T-TT-0086-11

Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
03/28/17 NHTSA ID: 10096556
TSB ID: T-TT-0362-15

Tt: the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
03/21/17 NHTSA ID: 10096036
TSB ID: T-SB-0012-13 REV

Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bul
11/01/10 NHTSA ID: 10034284
TSB ID: TSB-0064-10

Toyota: techstream ecu flash reprogramming procedure. flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures de
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
07/26/05 NHTSA ID: 10015504
TSB ID: 05015

Special service campaign 50j - phase i - front suspension lower ball joint may experience excessive wear and looseness causing increased steering, effort, reduced vehicle self-centering, and noise in the front suspension.
11/03/04 NHTSA ID: 10010030
TSB ID: 04204

Intermittent extended or hard cranking.
11/03/04 NHTSA ID: 10010021
TSB ID: 03704

Engine bank 1 and bank 2 a/f and 02 identification. various toyota models.
06/26/03 NHTSA ID: 10001785
TSB ID: 03094

Fuel inlet protector installation - voluntary special service campaign.
04/23/18 Transmission and Drivetrain NHTSA ID: 10134454
TSB ID: T-TT-0086-11

Techtip: condition - the vehicle may be difficult to start or have an abnormally low or rough idle after the battery has been disconnected or power to the engine ecm has been interrupted.
04/23/18 Transmission and Drivetrain NHTSA ID: 10133836
TSB ID: T-SB-0391-08 Rev

This bulletin contains general vehicle pulling diagnosis and repair procedures along with specific information to help correct pulling complaints.
04/02/18 Transmission and Drivetrain NHTSA ID: 10132084
TSB ID: T-SB-0071-11 Rev

The purpose of this service bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil ?on,? shifting issues, and/or transmission damage. use the information in this bulletin when
08/01/17 Transmission and Drivetrain NHTSA ID: 10109404
TSB ID: T-SB-0014-11 Rev

Tsb: the purpose of this service bulletin is to provide information regarding the installation of the correct torque converter bolts during automatic transmission/transaxle assembly replacement. incorrect torque converter bolts or missing w
08/01/17 Transmission and Drivetrain NHTSA ID: 10109492
TSB ID: T-SB-0134-14

Tsb: the purpose of this bulletin is to provide precautions to follow when installing an automatic transmission/transaxle assembly to avoid mil "on" shifting issues and/or transmission damage. use the information in this bulletin when insta
07/25/05 Transmission and Drivetrain NHTSA ID: 10015475
TSB ID: 5098B

Differential locking system - suspension and axle. repair manual correction. 00400-rm100-2u2.
04/23/18 Electrical and Air Conditioning NHTSA ID: 10133654
TSB ID: T-SB-0229-12_Rev

Tsb: revision notice november 22, 2017 rev1: ? applicability has been updated to include 2014 ? 2018 model year vehicles. any previous printed versions of this bulletin should be discarded. in the event that a toyota vehicle becomes submerg
04/23/18 Electrical and Air Conditioning NHTSA ID: 10133915
TSB ID: T-TT-0213-13

Toyota vehicles are equipped with srs, including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the srs airbags or pretensioner devi
Looking for a warranty? Get a quote.
04/23/18 Electrical and Air Conditioning NHTSA ID: 10133878
TSB ID: T-SB-0064-10 Rev

Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
04/23/18 Electrical and Air Conditioning NHTSA ID: 10133897
TSB ID: T-SB-0012-13

Flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bulletin de
04/23/18 Electrical and Air Conditioning NHTSA ID: 10133860
TSB ID: T-TT-0226-13

The customer is having difficulty changing the multi-display screen from day mode. if the multi-display screen is set to day mode when the headlights are on, the setting we be memorized when the engine is turned off.
04/02/18 Electrical and Air Conditioning NHTSA ID: 10131961
TSB ID: T-TT-0213-13

Toyota vehicles are equipped with supplemental restraint systems (srs), including various airbags and in some models, seat belt pre-tensioners, to help reduce the risk of injury in a collision. if a customer expresses any concerns that the
04/02/18 Electrical and Air Conditioning NHTSA ID: 10132149
TSB ID: DR8 Reg Ltr

Toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed. please note the following information for regional and pd associates.
04/02/18 Electrical and Air Conditioning NHTSA ID: 10132930
TSB ID: T-SB-0012-13 Rev

Tsb: obsolete notice: september 14, 2016: this bulletin is now obsolete. please see t-sb-0134-16.
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
04/02/18 Electrical and Air Conditioning NHTSA ID: 10132812
TSB ID: T-TT-0010-10 Rev

Tech tip: low battery voltage can contribute to a mil "on" condition for p0335 (crankshaft position
04/02/18 Electrical and Air Conditioning NHTSA ID: 10132762
TSB ID: T-SB-0012-13 Rev

Tsb: flash reprogramming allows the ecu software to be updated without replacing the ecu. flash calibration updates for specific vehicle models/ecus are released as field-fix procedures described in individual service bulletins. this bullet
04/02/18 Electrical and Air Conditioning NHTSA ID: 10132715
TSB ID: T-SB-0043-14 Rev

Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
04/02/18 Electrical and Air Conditioning NHTSA ID: 10132708
TSB ID: T-SB-0043-14

Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased.
08/14/17 Electrical and Air Conditioning NHTSA ID: 10111179
TSB ID: T-SB-0083-13 Rev

Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
08/14/17 Electrical and Air Conditioning NHTSA ID: 10111197
TSB ID: T-SB-0101-11 Rev

Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
08/14/17 Electrical and Air Conditioning NHTSA ID: 10111416
TSB ID: T-SB-0043-14 Rev

Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
08/14/17 Electrical and Air Conditioning NHTSA ID: 10111562
TSB ID: T-SB-0083-13 Rev

Tsb: the procedure in this bulletin is a general guideline on how to properly diagnose the air conditioning system after a component failure. refer to the applicable repair manual for vehicle specific repair procedures and parts.
08/14/17 Electrical and Air Conditioning NHTSA ID: 10111126
TSB ID: T-SB-0043-14 Rev

Tsb: the immobilizer and smart key reset is a feature that allows the registration of new keys when all master keys are lost. once the system is reset, all previously registered keys will be erased. follow the procedures in this bulletin to
08/14/17 Electrical and Air Conditioning NHTSA ID: 10111390
TSB ID: T-SB-0101-11 Rev

Tsb: when servicing interior electrical switches and components, please note the precautions in this bulletin to avoid damaging electrical components and switches. many lubricants, cleaners, and automotive chemicals contain silicone or othe
08/01/17 Electrical and Air Conditioning NHTSA ID: 10109473
TSB ID: ER10_Remail_Regi

Region letter: toyota will be sending safety recall follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
08/01/17 Electrical and Air Conditioning NHTSA ID: 10109402
TSB ID: T-SB-0044-14 Rev

Tsb: some 2012 - 2014 model year tacoma vehicles equipped with 1gr-fe engines may exhibit spark knock (detonation) during light acceleration and/or uphill in hot weather (80?f or higher). the engine control module/ecm (sae term: powertrain
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
08/21/12 Electrical and Air Conditioning NHTSA ID: 10045140
TSB ID: TSB-0087-12

Toyota: accelerator pedal sensor assembly information regarding the inspection, removal, and installation, if lubrication or oil, is applied.
01/10/06 Electrical and Air Conditioning NHTSA ID: 10018661
TSB ID: 5269

Repair manual correction for the rear differential lock - electrical wiring diagram. 00400-ewd47-8u. '02 tacoma. '03 tacoma. 00400-ewd51-7u. '04 tacoma - 00400-ewd56-5u. '01 tacoma. 0040-ewd44-0u. '00 tacoma -
04/23/18 Other NHTSA ID: 10134107
TSB ID: Pol-08-04

Warranty policy bulletin (pol08-04): toyota received isolated reports regarding a small number of 2001 through 2004 model year tacoma vehicles operated in severe cold climate areas with high road salt use. they were reported to be exhibiti
04/23/18 Other NHTSA ID: 10133649
TSB ID: T-SB-0144-08_Obs

Tsb: obsolete notice november 21, 2017: this bulletin is now obsolete. please see t-sb-0304-17.
04/23/18 Other NHTSA ID: 10133901
TSB ID: T-SB-0064-10 Rev

This bulletin is now obsolete. please see t-sb-0012-13.
04/23/18 Other NHTSA ID: 10133867
TSB ID: SST Requirements

Ssts are key elements to provide your customers with swift and accurate repairs resulting in superior customer satisfaction.
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
04/02/18 Other NHTSA ID: 10131984
TSB ID: T-SB-0141-13

A new special service tool (sst 09709-00002) has been introduced to aid in the inspection procedure for certain vehicles equipped with a floor pedal-type parking brake system. this bulletin references the correct method for installing the b
04/02/18 Other NHTSA ID: 10132295
TSB ID: T-PG006-00 Obsol

This bulletin is now obsolete. please see t-sb-0054-13.
04/02/18 Other NHTSA ID: 10131928
TSB ID: T-TT-0132-11

A key part to maintain the proper function and safe operation of the vehicle's braking system is to perform a visual inspection when installing brake pads, calipers, and discs. the following recommendations are intended to provide general
04/02/18 Other NHTSA ID: 10132287
TSB ID: T-SB-0054-13

California (ca), federal (fed), and 50 state certified emission control underhood labels (emission labels) may be obtained through your dealership?s parts department utilizing standard replacement parts ordering procedures. follow the guide
04/02/18 Other NHTSA ID: 10132281
TSB ID: T-SB-0141-10 Rev

If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, or at the top of the rear glass, the source of the noise may be the two stoppers bonded to the top of the windshield/rear glass, or the windshield retainers
04/02/18 Other NHTSA ID: 10132410
TSB ID: T-SB-0218-17_Rev

Tsb: revision notice july 20, 2017 rev1: applicability has been updated to exclude 2007 ? 2017 model year avanza vehicles. some hazardous material treatment and handling regulations at the state and local level define the pre-disposal deplo
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
04/02/18 Other NHTSA ID: 10131993
TSB ID: TS-BO030-01 Obso

This bulletin is now obsolete. please see t-sb-0185-13.
04/02/18 Other NHTSA ID: 10131988
TSB ID: T-SB-0185-13

The following procedures are recommended during routine maintenance or in the event of a customer concern for wiper performance.
04/02/18 Other NHTSA ID: 10132136
TSB ID: T-TT-0269-13

The appearance of spots in tempered glass (when viewed at certain angles) is the result of the heat treating and quick quenching process during manufacturing.
04/02/18 Other NHTSA ID: 10132055
TSB ID: T-SB-0122-11 Rev

Beginning in 1998, toyota introduced side airbags as optional equipment. toyota does not recommend replacement of original seat covers with non-toyota leather or other seat cover materials on vehicles due to the following: seat covers not
08/14/17 Other NHTSA ID: 10111309
TSB ID: CSV_LSC_Region L

Rl: on 2001 - 2004 model year tacoma vehicles, prolonged exposure to road salts and other environmental factors could cause the spare tire carrier lift plate to corrode. in limited cases, the lift plate may excessively corrode and break res
08/14/17 Other NHTSA ID: 10111322
TSB ID: CSV_TI_REM_Publi

Ti: on 2001-2004 model year tacoma vehicles, prolonged exposure to road salts and other environmental factors could cause the spare tire carrier lift plate to corrode. in limited cases, the lift plate may excessively corrode and break resul
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
08/14/17 Other NHTSA ID: 10111478
TSB ID: E0D ESD_Region L

Rl: toyota will be sending limited service campaign follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
08/14/17 Other NHTSA ID: 10111313
TSB ID: CSV_LSC_Dealer L

Dl: on 2001 - 2004 model year tacoma vehicles, prolonged exposure to road salts and other environmental factors could cause the spare tire carrier lift plate to corrode. in limited cases, the lift plate may excessively corrode and break res
08/14/17 Other NHTSA ID: 10111159
TSB ID: CSV_LSC_Region L

Rl: on 2001 - 2004 model year tacoma vehicles, prolonged exposure to road salts and other environmental factors could cause the spare tire carrier lift plate to corrode. in limited cases, the lift plate may excessively corrode and break res
08/14/17 Other NHTSA ID: 10111172
TSB ID: CSV_TI_REM_Publi

Ti: on 2001 - 2004 model year tacoma vehicles, prolonged exposure to road salts and other environmental factors could cause the spare tire carrier lift plate to corrode. in limited cases, the lift plate may excessively corrode and break res
08/14/17 Other NHTSA ID: 10111163
TSB ID: CSV_LSC_Dealer L

Dl: on 2001 - 2004 model year tacoma vehicles, prolonged exposure to road salts and other environmental factors could cause the spare tire carrier lift plate to corrode. in limited cases, the lift plate may excessively corrode and break res
08/14/17 Other NHTSA ID: 10111479
TSB ID: E0D ESD_Dealer L

Dl: limited service campaign completion is important and is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending limited service campaign follow-up notices to remind owners whose vehicl
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
08/01/17 Other NHTSA ID: 10109477
TSB ID: ER10_Remail_Deal

Dealer letter: safety recall completion is important not only in satisfying government requirements but also is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending safety recall follow
02/16/17 Other NHTSA ID: 10092007
TSB ID: E0D ESD_D 11/30

Dl: limited service campaign completion is important and is an integral part of our commitment to meet customer expectations of toyota products. toyota will be sending limited service campaign follow-up notices to remind owners whose vehicl
02/16/17 Other NHTSA ID: 10091997
TSB ID: E0D ESD_R 11/30

Rl: toyota will be sending limited service campaign follow-up notices to remind owners whose vehicles have not yet had campaign repairs completed.
02/14/17 Other NHTSA ID: 10091609
TSB ID: POL08-04

Warranty policy bulletin (pol08-04): toyota received isolated reports regarding a small number of ?01 through ?04 model year tacoma vehicles operated in severe cold climate areas with high road salt use. they were reported to be exhibiting
04/11/16 Other NHTSA ID: 10062051
TSB ID: TC13-019

Summary to be provided on a future date.
09/18/15 Other NHTSA ID: 10058414
TSB ID: TC-15-016

Toyota: tsb has an owner notification letter. select document search button below. due to exposure and prolonged usage of road salts and other environmental factors, on certain trucks, the lift plate for spare tire carrier will corrode a
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
12/16/11 Other NHTSA ID: 10042555
TSB ID: TSB-0122-11

Toyota: information provided for replacing the seat covers for vehicles equipped with side airbags.
06/29/11 Other NHTSA ID: 10038974
TSB ID: TC-11-013

Toyota service campaign: see document search button for owner letter. a service campaign to apply anti-corrosion materials for vehicles in cold states. 1996-2004 tacomas.
06/01/11 Other NHTSA ID: 10037656
TSB ID: TC-10-056

Toyota service campaign: see document search button for owner letter. toyota is extending the date for corrosion resistance treatment.
04/12/11 Other NHTSA ID: 10036742
TSB ID: TC-10-049

Toyota: limited service campaign-90 d deadline extension and owner renotification. frame corrosion-resistant compound(crc).
04/12/11 Other NHTSA ID: 10036743
TSB ID: TC-10-050

Toyota: see document search button for owner letter. limited service campaign (lsc). 90d deadline extension and owner renotification. frame corrosion resistant compound (crc).
11/29/10 Other NHTSA ID: 10034525
TSB ID: TC-10-036

Toyota: frame corrosion preventative compound. owners whose vehicles have not yet had lsc 90d repairs completed will be notify. affects only certain states:vt, ma and me.
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
09/23/09 Other NHTSA ID: 10030357
TSB ID: LSC-90-D

Toyota service campaign: see document search button for owner letter. a number of vehicles operating in severe cold climate areas with high road salt used exhibited excessive rust corrosion to the frame, causing perforation of the metal.
02/24/09 Other NHTSA ID: 10027968
TSB ID: TCS-08-018

Toyota service campaign: see document search button for owner letter. warranty enhancement for frame rust perforation on model trucks in severe cold climate areas with high road salt use. csc letter was received.
08/17/05 Other NHTSA ID: 10015972
TSB ID: 0040010021

Repair manual correction. *sc
11/03/04 Other NHTSA ID: 10010039
TSB ID: 00604

Tonneau cover foam wedge kit. for vehicles with under-the-rail bedliner, the tonneau cover kit may interfere with the tailgate bedliner. a foam wedge fit kit has been created to resolve this issue.
07/07/04 Other NHTSA ID: 10007652
TSB ID: 00804

Front door window frame improvement.
05/26/04 Other NHTSA ID: 10007091
TSB ID: 04005

Owner renotification of non-completed special service campaigns and limited service campaigns. various modles including the toyota scion xb my2004.
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
05/05/04 Other NHTSA ID: 10006521
TSB ID: 3276

Repair manual correction. vol 1. diagnostics -sfi system.
03/08/04 Other NHTSA ID: 10005617
TSB ID: NV00602

Some customers may experience rattles from the dash area - repair tips. revised.
02/17/04 Other NHTSA ID: 10005258
TSB ID: 01203

Manual outer rear view mirrors may experience a slight wind noise from the left side of the vehicle. revised.
12/16/03 Other NHTSA ID: 10004495
TSB ID: 01203R

Slight wind noise from either side of the vehicle on certain models with manual outside mirrors.
12/16/03 Other NHTSA ID: 10004494
TSB ID: 01203

Manual outer rear view mirrors may experience a slight wind noise from the left side of the vehicle.
10/24/03 Other NHTSA ID: 10003565
TSB ID: BO02600

Information on water leak field-fix repair instructions - revised.
NHTSA's feed only includes summaries. For the full text of TSBs:

Get a 1 year subscription for only $19.95 from ALLDATAdiy! Use Code DIYDISCOUNT. Click here now!
10/23/03 Other NHTSA ID: 10003563
TSB ID: PG00503

Spare tire carrier operation. various modlels including the 2004 landcruiser and 4 runner.
08/12/98 Other NHTSA ID: 601600
TSB ID: 1698

Water leak field-fix repair instructions. *yc

Return to top

Toyota Tacoma TSBs (Technical Service Bulletins)

Some things are often misunderstood about recalls and technical service bulletins (TSBs). Plus a disclaimer.

  1. Recalls do not have to be issued only because something is prone to failure. NHTSA (a government agency) can only require a recall if a failure will affect safety, emissions, fuel economy, or compliance with some other regulation or law. Manufacturers can voluntarily recall cars for problems that do not affect these, though.
  2. Recalls often apply to only some cars of a specific model year, rather than all of them. You should receive a letter from the manufacturer if your car has been recalled. You can also check with the dealer, which will know which (if any) recalls pertain to your car.
  3. The primary purpose of TSBs is to inform dealers about known problems with a car and how to fix them. They are not the same as recalls. As with recalls, TSBs often only apply to some cars, not the entire model year.
  4. Dealers often will not provide a preventive repair just because a problem described in a TSB might happen to your car. They'll usually want to observe symptoms that the problem is already affecting your car.
  5. Even if there are symptoms, a manufacturer doesn't have to pick up the cost of a TSB repair if the car is out of warranty, though sometimes they do.

We provide the text of recalls and TSBs as provided by NHTSA. There can be errors in the text. If you sign up for notifications in My Garage, we will try to get these to do, but for various reasons (some beyond our control) cannot guarantee you will receive them. When in doubt about a recall or TSB, contact the dealer.