turbocharged 227hp 2.5L I5 5-speed shiftable automatic FWD
Volvo S40 in California, United States Jun 2017 - Jun 2018 | |||
May 201855000 miUS $120 | Had to replace the original car battery. |
Volvo S40 in Connecticut, United States Jul 2017 - Jan 2022 | |||
May 201850000 miUS $100 | One headlight failed; replaced both. |
Volvo S40 in Alberta, Canada - Sep 2015 | |||
Jun 201318600 miC $300 | Wheel bearing issue | ||
Aug 201427900 miC $840 | Replaced turbo fan | ||
Sep 201537820 miC $460 | Battery and fuses replaced |
turbocharged 113hp 1.6L I4 Diesel 6-speed manual FWD
Volvo S40 in Norway - Mar 2011 | |||
Nov 2010806 mi | Reprogramming of engine control, fitting new rear window lift | ||
Feb 20112170 mi | Reprogramming again | ||
Mar 20113100 mi | Rattle in door fixed, A/C cleaned (bad smell), 2 CPU replaced, new program uploaded, wiper washer replaced |
turbocharged 227hp 2.5L I5 6-speed manual AWD
Volvo S40 in Ohio, United States Jun 2017 - Jun 2019 | |||
May 201887000 miUS $750 | A/C Compressor leaked | ||
Oct 201889000 miUS $200 | Replaced [wheel bearing] | ||
Jun 201993000 miUS $200 | Replaced both fronts |
168-horsepower 2.4L I5 5-speed shiftable automatic FWD
Volvo S40 in Georgia, United States Jun 2014 - Jun 2022 | |||
Jan 201442000 miUS $700 | Replaced weatherstrip seal on both rear doors. Replaced front rotors |
Volvo S40 in Pennsylvania, United States - Feb 2014 | |||
Feb 201462500 miUS $400 | Vacuum pump sensor shorted out |
turbocharged 227hp 2.5L I5 5-speed shiftable automatic AWD
Volvo S40 in Massachusetts, United States Jun 2009 - Jun 2022 | |||
Oct 20094000 mi | Replaced seals on angle gear, covered under warranty | ||
Jun 201016000 miUS $70 | 15000 maintenance, checked climate control system (OK), adjusted window for slight noise when opening, no other repairs | ||
Nov 201022500 mi | Replaced driver's side LED brake lamp under warranty | ||
Apr 201247000 mi | Replaced AM receiver under warranty Car would not start after being parked in garage for 9 days. Dealer replaced battery under warranty. | ||
Dec 201256500 mi | Replaced two TPMS sensors under warranty Reported battery drain, found that Satellite radio was causing discharge, updated Satellite radio software per Volvo and replaced battery. All done under warranty. | ||
Jun 201363500 miUS $110 | Replaced TPMS Sensor | ||
May 2017120044 miUS $167 | Replaced coolant reservoir | ||
Jul 2017122606 miUS $1106 | Replaced AC compressor, compressor clutch worn | ||
Aug 2017123018 miUS $945 | Replaced alternator | ||
Jun 2018136217 miUS $900 | Replace front struts and springs |
143-horsepower 2.0L I4 5-speed manual FWD
Volvo S40 in Great Britain Jun 2017 - Jun 2022 | |||
Mar 2021148000 mi£900 | 2x wheel bearings replaced | ||
Jul 2021149000 mi£600 | All shock absorbers and springs replaced. | ||
Nov 2021151000 mi£350 | Steering Wheel Module software install. Genuine steering wheel module replaced. |
Engine not specified
Volvo S40 in Great Britain Feb 2011 - Mar 2011 | |||
Mar 201140000 mi£500 | No aircon and headlights kept blowing. |
turbocharged 227hp 2.5L I5 5-speed shiftable automatic FWD
Volvo S40 in South Carolina, United States Jun 2011 - Jan 2012 | |||
Sep 201175000 miUS $310 | Tech noticed the front drivers strut leaking while the car was in for 75k oil service. Had to have strut replaced, which seemed reasonable for the miles. |
turbocharged 227hp 2.5L I5 5-speed shiftable automatic AWD
Volvo S40 in West Virginia, United States Mar 2011 - Jul 2018 | |||
Apr 201263000 miUS $130 | Rattle in front dash and windshield washer | ||
Aug 201270100 miUS $675 | Cracked Head light lense, Insurence paid for lense replacment. But bulb went out the next week and that was not covered and cost $425.00 | ||
May 201386100 miUS $255 | ABS sensor needed cleaned | ||
Jul 2014101500 miUS $650 | xenon headlight out + replaced broken side marker light | ||
Mar 2015109000 miUS $875 | Replaced Passenger front drive axle & Hub | ||
Oct 2015123300 miUS $650 | Replaced original alternator | ||
Apr 2017156000 miUS $695 | Rear break calapier went bad | ||
May 2017156000 miUS $1050 | AC compressor replacment | ||
Sep 2017159000 miUS $1150 | Head light lens cracked. I do not believe it was hit with anythink looked like a vertical stress crack. Middle stop light in the window out. Required special ordering of part and a full day in the shop, they had never changed one before. | ||
Jul 2018149000 miUS $549 | Starter went out, Volvo shipped incorrect replacement had to wait and additional week for second replacement |
Volvo S40 in Florida, United States Apr 2011 - Feb 2015 | |||
Apr 201239000 mi | The screen readout said I had a problem with an immobilizer and needed to go to shop. Shop said it was only a battery problem and they replaced the battery under warranty. | ||
Jan 201554100 miUS $700 | Car was stalling and a/c kept shutting off |
turbocharged 109hp 1.6L I4 Diesel 5-speed manual FWD
Volvo S40 in Portugal Jul 2011 - Mar 2016 | |||
Aug 201148360 mi | Windows working badly, glass was diconnected from one side. | ||
Oct 201266320 mi€40 | No cold air. | ||
Apr 201374400 mi€300 | A/C condenser ruptured, a replacement was needed. Volvo payed for a part of the service. |
168-horsepower 2.4L I5 5-speed shiftable automatic FWD
Volvo S40 in Florida, United States Apr 2011 - Jun 2018 | |||
Aug 201634300 miUS $1100 | Condensor |
Volvo S40 in Great Britain Feb 2011 - Mar 2011 | |||
Mar 201170000 mi | Intermittent non-starting. Had to insist the RAC towed to garage eventually so that fault was present on investigation. Fault recurred 4 times over 6 months. Garage said it was throttle valve assembly, which was replaced. |
Volvo S40 in Colorado, United States Apr 2013 - Jan 2014 | |||
Jun 201381000 mi | Tires wearing quickly and unevenly on inside of all tires, front struts completely gone, front-end alignment needed. | ||
Aug 201384000 miUS $185 | Windscreen fluid hose came unbolted to inside, broke washer on top. |
Volvo S40 in Minnesota, United States Dec 2013 - Sep 2018 | |||
Feb 2017145000 miUS $40 | Was having trouble shifting from Park to Drive, etc.. The shifter blind was cracked, and the pieces were causing the trouble. Took a lot of digging to figure out how to get to all the Torx screws to disassemble the center console, "wave" and so forth, but aside from that, pretty easy. | ||
Feb 2018165 miUS $800 | Bad suspension |
Volvo S40 in Hawaii, United States Dec 2012 - Jun 2018 | |||
Jan 2013 | Repeatable rubbing noise when turning steering wheel in either direction. | ||
Jun 201353000 miUS $1100 | Strut bearing was making rubbing noise at low speed including parking. Required removal of strut/spring assembly. Replaced struts since everything was apart. Dealer had no clue. | ||
Oct 201358200 miUS $600 | Check Engine Light was going on/off. CAN-OBD2 scanner indicated P00089 - Fuel Pressure Regulator Performance. Expected cause was faulty fuel injection pressure sensor - common problem on S40s. Shop updated software with Volvo download. | ||
May 201460300 miUS $900 | Check engine light on with trouble codes. AC also stopped working at same time. Difficult for shop to troubleshoot. Suspected leak detection pump or ECM. Problem was a shorted sensor in oil pan. | ||
Jul 201570000 miUS $750 | Replaced alarm/siren module and main car battery, due to failure in our 2011 Volvo S40, which irreparably damaged the main battery. Main car battery was less than 2 years old and replacement cost was $225. | ||
Apr 201775000 miUS $1100 | Typical problem with Volvo S40 AC compressors. Clutch on AC compressor was not engaging during warm weather due to inability of electromagnet to close the gap. Problem has been solved by others by removing the clutch (using special or self-made tools) and closing the gap by changing or removing shims. Others have used used "bread clips" or thin metal sheets on the outside of the clutch. Decided to ask the Volvo expert mechanic just replace the entire compressor on the 2008 (and identical problem on the 2011 S40). Compressor part was $740. Only charged couple hours of labor and had him change the serpentine belt while he was working on it. Solved the problem so hopefully another 75000 miles of AC. | ||
May 201880000 miUS $700 | Replaced non-adjustable rear upper control links with adjustable versions. Allowed camber adjustment as the left rear wheel camber was out of specification. Rubber bushing on the sway bar end links was gone - shop tech noticed this when I brought the car in for annual wheel alignment. |
168-horsepower 2.4L I5 5-speed manual FWD
Volvo S40 in Estonia - Jul 2010 | |||
Nov 200921080 mi€2500 | new ABS pump + ECU |
turbocharged 218hp 2.5L I5 6-speed manual AWD
Volvo S40 in Tennessee, United States Jan 2016 - Jun 2022 | |||
Sep 201780000 miUS $1000 | Shaking on acceleration. This should not happen at only 80K miles. Replaced an axle and lower control arms. Repair took care of the problem. | ||
Oct 201780000 miUS $5 | Air intake (vacuum line) after the throttle body to the intake manifold had split causing an engine code. I got a code reader, looked it up myself, went on line and quarried the forums and found the problem. Replaced a flexible line with one from Autozone with new clamps and this solved the problem. Gas mileage increased 2 mpg. | ||
Jan 2022110000 miUS $350 | XYB adjustable shocks replaced the Heico shocks on the lowered rear that were completely worn out. | ||
May 2022114000 miUS $500 | Rear shocks went out & replaced with 3rd party adjustable shocks |
Volvo S40 in Alberta, Canada Dec 2012 - Jul 2018 | |||
Jan 201365880 mi | Bumper skin was blocking headlight washer nozzle | ||
Feb 201356920 miC $70 | Compressor Bypass Valve (CBV) had torn diaphragm. Replaced. | ||
Nov 201360300 mi | Parking brake was stuck. Cable was siezed. Greased cable and worked it back and forth several times, resolved. | ||
Dec 201360140 miC $550 | Front passenger axle replacement due to grinding noise in axle | ||
Feb 201462000 miC $100 | Failed passenger side engine mount. Mount replaced. | ||
Oct 201573360 mi | PCV failure. Replaced under extended PCV warranty. | ||
Jul 201883700 mi | Plugged sunroof drains caused water leak Leaking crank seal/valve seals |
turbocharged 218hp 2.5L I5 5-speed shiftable automatic FWD
Volvo S40 in New Jersey, United States Apr 2016 - Jun 2017 | |||
Apr 201662000 miUS $200 | Replaced front lower control arms and front sway bar end links due to clunking noises over bumps. |
Volvo S40 in California, United States Mar 2011 - Jun 2022 | |||
Aug 201573100 miUS $600 | Replaced PCV box Replace driver side trans axle and boot | ||
Jun 201780000 miUS $285 | Replace front motor mount | ||
Nov 201780000 miUS $612 | engine service urgent light on. Dealer changed fuel pressure switch and spark plugs. | ||
Dec 201780000 miUS $899 | Engine light on, replaced leak detection pump | ||
May 202195000 miUS $428 | Replace brake caliper |
turbocharged 218hp 2.5L I5 5-speed shiftable automatic AWD
Volvo S40 in New Hampshire, United States May 2013 - Jun 2022 | |||
Aug 2014104000 miUS $20 | Sunroof front driver's drain detached and wetted deep carpet pad left side front and back. A/C drain fitting leak wetted right side front and back. Removed all seats and carpeting to dry. Remedied leak causes. | ||
Jan 2015106300 miUS $500 | Previous owner's exhaust repairs without proper pipe alignment contributed to premature flex pipe failure at the manifold. Replaced flex pipe, repaired hangers, and realigned exhaust. Allowed mechanic flexible lift time between smaller jobs to save cost. | ||
May 2015109100 miUS $560 | Replaced both (lower) control arms, as one exhibited excessive play. | ||
Oct 2016123000 miUS $40 | Fuel rail pressure sensor erratic. Replaced. | ||
Dec 2016125000 miUS $200 | Normal wear. Rear struts replaced, as they were failing. | ||
Apr 2017126000 miUS $1900 | Replace failed PCV system. Replace right front wheel bearing. (Singularly expensive job) Install both provided front struts and strut bearings. Replace leaking camshaft seals. | ||
Jul 2017129000 miUS $900 | Replaced rusted/patched factory cat-back exhaust with SS system. | ||
Nov 2017135000 miUS $560 | Replaced front brake rotors and pads after snow tire swap shop overtighted lugnuts and warped rotors. Also full alignment. |
Volvo S40 in New Jersey, United States Jul 2014 - Aug 2014 | |||
Aug 2014117000 miUS $615 | replaced upper and lower radiator hoses as well as coolant reservoir. |
Volvo S40 in Rhode Island, United States Sep 2013 - Oct 2017 | |||
Sep 2013149000 miUS $50 | Sunroof leak of rainwater into front driver wheelwell. Required simple fix with shop vac to remove water and absorbant material after repair, as well as cleaning of rain gutter. | ||
Oct 2014152000 miUS $500 | PCV system required replacement. Of note, this had been completed by prior owner at ~60,000 miles and occurred again during my ownership. May have been associated with switch from regular to synthetic oil. | ||
Apr 2015158000 miUS $300 | Replaced 2 front and single rear engine mounts. At replacement, old parts had clear wasting of rubber components. |
Volvo S40 in New York, United States - Sep 2008 | |||
Sep 200815000 mi | Sirius unit kept freezing (locking onto a station and wouldn't change) Repaired under warranty. |
turbocharged 177hp 2.4L I5 Diesel 5-speed shiftable automatic FWD
Volvo S40 in Great Britain May 2010 - Jan 2011 | |||
Jun 201044000 mi | dash warning - engine system service required. Told that oil pressure sensor needed replacing and replaced. One week later same dash warning appeared. Now ongoing | ||
Sep 201050000 mi | 'Engine system service required' message display. Solved by replacing oil level sensor and reduction in oil level - dpf regeneration issue, though dealer did not admit. Dealer did put sticker on engine cover denoting new, lower oil level! |
turbocharged 134hp 2.0L I4 Diesel 6-speed manual FWD
Volvo S40 in Great Britain Sep 2015 - Jul 2017 | |||
Oct 2015135500 mi£200 | Lower control arms | ||
May 2016143300 mi£110 | Noisy wheel bearing | ||
Aug 2016146300 mi£150 | Loose bolt on wishbones causing vibration. Loose bolt possibly due to incorrect wishbone fitting | ||
Apr 2017157000 mi£80 | Bad front pads |
168-horsepower 2.4L I5 5-speed shiftable automatic FWD
Volvo S40 in Indiana, United States Apr 2011 - Jun 2012 | |||
May 201163000 miUS $166 | Replaced right front wheel hub bearing assembly. | ||
Jun 201165000 miUS $232 | Warning light. One item was under a recall / warranty. The second, an update that was due, cost $231.70. Needs upper strut mounts and plates. Dealer wanted $871. Declined at this time. | ||
Jul 201165500 miUS $320 | Purchased strut parts online, under $100 and had them replaced at a local shop with alignment for $220. |
Volvo S40 in Virginia, United States Mar 2012 - Apr 2012 | |||
Apr 201275000 mi | Engine making a loud noise when accelerating, almost sounded like an exhaust leak, but also noticed that the engine power was reduced when making this noise |
Volvo S40 in Texas, United States Mar 2010 - Dec 2011 | |||
Jun 201038000 mi | Driver's door seal not sealing well, resulting in excessive wind noise at highway speeds. | ||
May 201147500 miUS $100 | Air conditioner compressor failed. Replaced under Volvo extended warranty with $100 deductible. Cost would have been $893 without extended warranty. Fuel pressure sensor failing. Replaced under extended warranty. | ||
Aug 201149000 mi | Breather box replaced at no charge. Volvo has issued an extended warranty for this piece due to numerous problems. Our S40 had the same problem at the same mileage. | ||
Dec 201152000 miUS $100 | HVAC control panel working intermittently. Replaced under Volvo extended warranty with $100 deductible. Would have cost $1083 without warranty. |
Volvo S40 in New Jersey, United States Jun 2009 - Sep 2009 | |||
Aug 200927000 mi | Washer fluid did not squirt. Dealer replaced nozzles. |
Volvo S40 in Pennsylvania, United States Feb 2011 - Mar 2012 | |||
Mar 2012110000 miUS $80 | Driver side bearing went bad. Replaced myself. Bearing is not bolted in is pressed in and out. If you do not have an arbor press do not attempt this. |
Volvo S40 in Washington, United States Jun 2011 - Nov 2015 | |||
Dec 201273000 miUS $120 | Brake pedal hard to press when cold. Brake Booster pump replaced. Shop diagnosed torn CV boot. |
Volvo S40 in Alabama, United States Jun 2017 - Apr 2018 | |||
Aug 2017129000 miUS $700 | AC Compressor/Clutch/ recharge |
Volvo S40 in Georgia, United States Apr 2016 - Apr 2016 | |||
Apr 2016213000 miUS $125 | Transmission flushed for first time in cars' history. |
Volvo S40 in California, United States Apr 2007 - Jan 2011 | |||
Oct 200715698 mi | Rattle, found sun roof shade clips broke, tighten rear view mirror screws, all under warranty. | ||
May 200942000 miUS $100 | Sun Roof Rails clog, interior leaking on passenger side. | ||
Dec 201059000 miUS $1400 | alarm module failure, battery replaced. software flash done. full 60,000 service completed. left front strut replaced, control arms replaced, right front shock leaking, both upper shock mounts replaced, alignment performed. coolant water bottle replaced. |
Volvo S40 in Korea, South Jul 2014 - Jun 2018 | |||
Oct 201463240 mi$140 | Rear Wheel hub started to make noise. Changed it by myself. Wheel bearing can not be replaced by itself, it needs the whole hub. | ||
Mar 201885560 mi$250 | Front two shocks have been completed dead (for a year though.) changed bearing and shocks. |
Volvo S40 in Virginia, United States Apr 2014 - Jul 2014 | |||
Jul 2014105000 miUS $300 | Leak at bottom side of condenser (passenger side) |
Volvo S40 in California, United States Apr 2013 - Feb 2017 | |||
Jun 201385000 miUS $100 | I had a broken left axel repaired under warranty and 82000 service completed (another $583). | ||
Jul 201385300 miUS $100 | passenger side axel replaced and both left and right boots replaced. | ||
Aug 201495500 miUS $1100 | replace air box assembly. I was unable to remove the size 6 torq bolts the were striped and the inlet hose was deteriorated, it was unrepairable. replaced motor mount due to vibration at idle. replaced rubber door striping. | ||
Nov 201498000 mi | I replaced both left and right brake bulb and Tail light bulbs (about 20 minutes), and wind shield wiper blades, preventive maintenance. | ||
May 2016113000 miUS $1400 | 112000 service, repaired replaced drivers side seat electrical panel, recovered drivers seat, installed new r model steering wheel. |
Volvo S40 in British Columbia, Canada Jan 2013 - Jul 2020 | |||
Apr 201454240 miC $1250 | front wheel bearings had to be replaced. Front struts were replaced at same time as one was defective. | ||
Dec 201463240 miC $207 | micro switch on to open the trunk died and needed to be replaced | ||
May 201569380 miC $330 | PCV valve stuck open and a split hose | ||
Apr 201793000 miC $600 | replace starter |
168-horsepower 2.4L I5 5-speed manual FWD
Volvo S40 in Norway Nov 2010 - Feb 2011 | |||
Feb 201150840 mi | The generator was defective. An ugrade from 120 to 150A was installed. 85% of the cost was covered by the dealer. I paid around 150 dollar for the repair. |
Volvo S40 in Arizona, United States Feb 2007 - Jun 2011 | |||
Sep 20074000 mi | Software update to fix start shudder stall issue. |
Volvo S40 in New York, United States Sep 2010 - Sep 2018 | |||
Feb 201356700 miUS $8 | Windshield washer check valve was clogged, replaced it with new part. | ||
Jul 201362000 miUS $130 | Drivers side front wheel bearing was noisy. Replaced by owner Passenger side inner cv boot was torn, owner replaced both inner and outer boots. | ||
Jan 201458500 miUS $900 | Both front wheel bearings replaced 5 hrs labor | ||
Jun 201478000 miUS $630 | AC Condenser Replacement and System Recharge. | ||
Jul 201592500 miUS $300 | Upper radiator hose leaking. Labor rate high for accessing hose. Many parts needed removal. | ||
Dec 201599000 miUS $200 | Another radiator hose replacement | ||
May 2016104000 miUS $30 | Replaced PCV hose to engine filter. | ||
Nov 2016110700 miUS $200 | Replaced worn/leaking front struts | ||
Aug 2017118000 miUS $30 | Fuel pressure sensor on intake manifold failed, causing CEL. Sensor replaced. | ||
Sep 2017120000 miUS $170 | Replaced parking brake cable Driver's side axle boot torn and leaking, replaced the axle assembly. | ||
Dec 2017122300 miUS $650 | Replace both front control arms | ||
Jun 2018128000 miUS $200 | PCV system /oil filter housing failed, causing CEL. Part replaced | ||
Jul 2018129000 miUS $300 | Poor acceleration. Engine knock sensor replaced |
turbocharged 218hp 2.5L I5 6-speed manual FWD
Volvo S40 in Virginia, United States May 2006 - Feb 2007 | |||
Dec 20064000 mi | Climate Control System was blowing cold air out of the driver's side vents and warm air out of the passenger's side vents even though both sides were set to the same temperature. Climate Control System was still blowing cold air out of the driver's side vents and cold air out of the passenger's side vents upon pickup from the dealer after the original unsuccessful repair. Repair was successful this time via a dealer installed sof |
Volvo S40 in Florida, United States Mar 2006 - Oct 2014 | |||
Apr 200816000 mi | Erratic operation of power door locks and windows, from both the remote and the interior switches. Diagnosis: on previous dealer visit, new wire harnesses were installed into doors, however the required software flash had not been performed. Faulty driver side headlight washer jet replaced. | ||
Nov 200822000 mi | Failure of all dashboard gauges (speedometer, tach, temp, oil pressure). Diagnosis: faulty DIMM. Service tech successfully re-flashed the DIMM but a new DIMM was ordered because testing revealed errors. The car was driveable after this shop visit. New DIMM controlling dashboard installed. Successful repair. Erratic operation of power door locks and windows, from both the remote and the interior switches. On this service visit, the wire harnesses to driver and passenger front doors were replaced, and new gold contacts installed to replace the tin contacts. | ||
Dec 200924000 mi | Driver side windshield washer jet was replaced due to blown valve. | ||
Dec 201130000 miUS $285 | Sunroof drain clog, with 1" water in entire right side of interior (front & back). Carpets removed/dried, drain mechanisms replaced with updated parts, interior damage check, carpets replaced. | ||
Aug 201231200 miUS $300 | Electro-mechanical trunk lock shorted out and replaced. Long process to also diagnose wiring problem to the unit. Wire harness to trunk replaced. | ||
Feb 201332500 mi | Sunroof drain clog, water in entire interior (front & back). Drains cleared, carpets removed, dried and re-installed, interior damage checked. This is a repeat of the problem repaired in December 2011. No charge for this repair. | ||
Jul 201335200 miUS $100 | A/C drains clogged. Condensation blowing out dashboard vents. Water in passenger compartment, carpets soaked. Repeat of sunroof drain clogs, water in passenger compartment. Dealer states repairs made to drain system. Seats, carpets removed, cleaned, dried, reinstalled. Electronic trunk latch activator handle replaced. This is the second time this problem has been addressed. In the first repair every part except the activator handle was replaced, but the problem reoccurred. | ||
Apr 201438200 mi | Another failure of the sunroof drain system with substantial leakage into the interior. Cost covered by dealer 1-year warranty on previous repair. | ||
Aug 201439300 miUS $1300 | Clogging and corrosion of A/C condenser to the point of failure with extensive water leakage into passenger compartment. Condenser removed, cleaned (extensive presence of mold) and re-installed. Carpets removed, cleaned, treated for mold. |
turbocharged 218hp 2.5L I5 6-speed manual AWD
Volvo S40 in Pennsylvania, United States May 2007 - Mar 2013 | |||
Sep 200732000 mi | Nav screen wouldn't pop up and would retract when accelerating. New screen put in. | ||
Dec 200738000 mi | Creaky driver's seat...not able to be duplicated by a different dealer at an earlier date. Possibly caused by Volvo's WHIPS system. | ||
Sep 2011105000 miUS $250 | One engine mount was completely ruptured. | ||
Oct 2012121200 miUS $1000 | New front shocks & struts |
Volvo S40 in Utah, United States Mar 2013 - Dec 2014 | |||
May 2013123000 miUS $508 | I noticed coolant leaking from the front of the car and the A/C would stop working after 20 minutes. Replaced upper radiator hose and recharged A/C. Leak is fixed but may need new A/C compressor. I will wait to replace compressor ($1,100) I noticed a rattle from driver's door area when traveling at speeds excess of 73 mph. I narrowed source to loose trim piece adjacent to door hinge. I used a small hammer to push plastic fastener back in place which resolved the issue. | ||
Jun 2013128000 miUS $185 | A very common issue with Volvo's of this vintage is failure of the Fuel Pressure Sensor. My symptoms were a noticeable drop in engine power while cruising. Sensor replaced with updated Volvo part by indy mechanic. Power loss issue solved. | ||
Nov 2013136000 mi | Reversing lights would not turn on when transmission was in reverse. Diagnostics determined there is no fault with reverse switch or bulbs. Tech will need more time to find wiring issue. | ||
Sep 2014154000 miUS $150 | Brief update on past and current problems: Reverse lights fixed by re-securing wiring from fuse box. The latest problem is bad valve guide seals which require a new engine head. ($2,900) at independent mechanic shop. Still love Volvo cars. | ||
Dec 2014157000 mi | Since the valve guide seal replacement was half the value of the car, I decided to sell. It didn't make sense to spend so much money on a car with 157k miles. Volvo makes great car but needs better resale value. I bought a 2012 Passat. |
turbocharged 218hp 2.5L I5 5-speed shiftable automatic FWD
Volvo S40 in Pennsylvania, United States Jun 2014 - Oct 2017 | |||
Sep 2014100000 miUS $100 | driveshaft bent, this had been replaced by previous repair with an cheap replacement part and not a volvo part. | ||
Jun 2015103000 mi | air coinditioning would work for 10 minutes, then blow warm air. | ||
Aug 2015104200 miUS $915 | Needed compressor replaced | ||
Sep 2015104000 miUS $900 | replaced front struts and bushings, etc | ||
Jun 2017119000 miUS $300 | routine rear brake pad replacement to pass state inspection |
Volvo S40 in Washington, United States Jun 2007 - Apr 2009 | |||
Apr 200835000 mi | Passenger airbag sensor. | ||
Oct 200843000 mi | Bad electrical connection in door caused malfunction of external temperature gauge |
Volvo S40 in Mexico, Mexico May 2008 - Nov 2010 | |||
Jan 200925420 mi | Emission system noise. A valve was replaced. | ||
Mar 200926660 mi$200 | Emission system noise. A valve was replaced (this is the 2nd time this happens). | ||
Mar 201033480 mi$5000 | Transmission |
Volvo S40 in Maryland, United States Jul 2009 - Jan 2011 | |||
Aug 200951500 mi | Warranty repair, sunroof drain leak. |
turbocharged 218hp 2.5L I5 5-speed shiftable automatic AWD
Volvo S40 in North Carolina, United States Jan 2009 - Jun 2011 | |||
Nov 200955000 miUS $300 | Starter switch irregularly refused to move to start position Ignition switch became eratically inoperable | ||
Mar 201166000 miUS $38 | PCV oil trap vaccuum leak triggered check engine light and made noise, issue was repaired under manufacturer extended warranty PCV oil trap defective...discovered from a check engine light. Volvo extended 100,000 warranty covered |
Volvo S40 in Pennsylvania, United States Dec 2007 - Apr 2011 | |||
Jul 200932000 mi | Car would not start. Had to be towed to the dealer. Computer had a code in it. Dealer cleared code. Car started. | ||
Sep 200937000 mi | ABS light came on, and the auto down function stopped working on the drivers window. Car went in to "crash mode", and shut off the fuel pump! The steering wheel sensor erroneously sensed the car was in a crash with air bag deployment. Volvo dead lined the car and a new wiring harness was ordered and installed. | ||
Jan 201045000 mi | Car was brought in and worked on three times. Problem couldn't be found. Computer had no code defaults. Last time in computer had a code. Volvo held the car 'til 2 modules could be replaced. Starter Control and ignition control modules were replaced. | ||
Dec 201063000 miUS $300 | Siren(alarm) module failed, which also killed the battery. |
turbocharged 134hp 2.0L I4 Diesel 6-speed manual FWD
Volvo S40 in Great Britain Oct 2010 - Oct 2011 | |||
Dec 201058000 mi£98 | Dpf pressure sensor failed. After much reluctance, selling dealer paid half of costs | ||
Jan 201159000 mi | Front wheel bearing re-replaced. | ||
Jun 201163000 mi£110 | Alternator failed - replaced under warranty. Replacement battery also required. |
Volvo S40 in Great Britain Jun 2009 - Dec 2012 | |||
Oct 200996000 mi | Headlight bulb. | ||
Jan 2010102000 mi | Other headlight bulb. | ||
Sep 2011126000 mi£292 | battery completely flat tryed to start with power pack not enough power then immobiliser see manual warning came on car then made no attempt to start had to take to volvo for reset of the whole ECM system. i did replace the battery first. | ||
Jul 2012141800 mi£130 | Front wishbones near/s/r also off/s/rear had to be replaced failed MOT | ||
Sep 2012146000 mi£600 | dual mass flywheel out of balance replaced clutch and dual mass repair successful |
99-horsepower 1.6L I4 5-speed manual FWD
Volvo S40 in Great Britain Nov 2009 - Mar 2010 | |||
Dec 200985000 mi£1200 | Failed wishbone bushes. Wishbones replaced. |
168-horsepower 2.4L I5 5-speed shiftable automatic FWD
Volvo S40 in Hawaii, United States Nov 2009 - Jun 2011 | |||
Dec 200924000 mi | Sun roof switch failed to work in certain settings, Dealer Replaced Switch and Motor Control Unit for Sun Roof | ||
Jan 201025000 mi | Right Rear wheel had brake fluid puddle on rim after vehicle sat for several days, Dealer Replaced Right Rear Brake Caliper | ||
Mar 201027000 mi | Brake pedal would continue to depress when vehicle was stopped and pedal pressure maintained, brakes were bled afterward dealer determined faulty Brake Master Cylinder and replaced. | ||
Jul 201029000 mi | Drivers side door window switches intermittently failed to operate windows. Dealer replaced door harness. | ||
Nov 201033000 mi | Head Liner Rattled due to poor installation by repair tech during sun roof motor replacement. | ||
Dec 201034000 mi | Fault light appeared on dash for Passenger Airbag. Dealer found Passenger Airbag Sensor fault, sensor replaced and computer reflashed. Fault light appeared on dash for Passenger Airbag. Dealer found Passenger Airbag Sensor fault, sensor replaced and computer reflashed. |
Volvo S40 in Missouri, United States Dec 2009 - Apr 2012 | |||
Mar 201033000 mi | Check engine light came on; TSB had been issued to repair. window and door lock switches on driver's side would intermittently not work, although the rest of the car would. |
Volvo S40 in Ontario, Canada Oct 2009 - Dec 2015 | |||
Feb 201163240 miC $272 | front sway bar link kits | ||
Oct 201170040 miC $248 | trunk lid kept unlocking. trunk switch was replaced. | ||
Jul 201278000 miC $425 | A/C seals were leaking & replaced. A/C re-charged | ||
Sep 201280600 miC $1478 | Passenger side rear brake squealing on breaking. Rear 80% pad left on drivers side, O% on passenger side - master cylinder issue. Rear pads, rotors and master cylinder replaced. | ||
Feb 201491840 miC $275 | Accelerator pedal sensor failure. Pedal & sensor kit was ordered and installed | ||
Jan 201592140 miC $500 | lack of cabin heat. Replaced thermostat, coolant recovery tank. battery would not charge - replaced battery | ||
Jul 2015102300 mi | accelerator pedal sensor failure |
Volvo S40 in Florida, United States Jan 2012 - Dec 2012 | |||
Apr 201291800 miUS $1000 | AC clutch was not working properly and needed to be replaced. Cost for this alone was $860. Replaced fuse for the power outlets (ie. cigarette lighters). Cost was $50 bucks for a fuse!! | ||
Nov 2012100000 miUS $120 | rear brake caliper replaced due to poor seal and leaking brake fluid. |
Volvo S40 in Pennsylvania, United States Mar 2016 - Jan 2017 | |||
Jan 2017 | Water in cabin under rear left passenger footwell |
Volvo S40 in Pennsylvania, United States Nov 2010 - Dec 2011 | |||
Aug 201054600 mi | Right rear lock and window operated erratically several months. In and out of the shop. They repaced a sensor in the rear door, but did not fix the problem. A month later they repalced a sensor in the drivers door, fixed. | ||
Dec 201161000 mi | Windows and locks inconsistent. This was second time in about 15 months. |
Volvo S40 in Georgia, United States Dec 2014 - Apr 2015 | |||
Apr 2015155000 miUS $150 | Blown head gasket |
Volvo S40 in Hawaii, United States Jul 2009 - Dec 2012 | |||
Aug 20099000 miUS $13000 | Trunk prop plastic tip cracked & needed to be replaced--was under warranty & dealer replaced the plastic tip & prop as an entire unit. Wrote about this in initial entry when I signed on. Acquired car. In first few weeks of use, needed to replace left trunk prop at dealer; good service & no cost. Considering purchasing extended warranty having read reviews from other owners. My mechanic also recommends warranty due to expensive parts. | ||
Apr 201012000 miUS $200 | Check Engine light illuminated. Gas cap needed to be replaced & then mechanic did analysis of car for other maintenance. | ||
Dec 201013000 miUS $1200 | Check engine light came on & then it stopped coming on after a few days. Mechanic originally forgot to read the code. Brought car back for code to be read & nothing was found wrong. Mechanic sprayed special chemical into intake vent to eliminate moldy smell in air conditioner. Was NOT charged extra for this, as we paid for everything else. Was also not charged for diagnosis code for check engine light. | ||
Mar 201113000 miUS $1000 | Oxygen sensor needed to be replaced per check engine light & diagnostics by mechanic. | ||
Apr 201223300 mi | originally told needed to have master cylinder worked on, including replacing leaking valves & likely replacing master cylinder. turned out nothing was wrong, liquid got spilled on it from something else. |
168-horsepower 2.4L I5 5-speed manual FWD
Volvo S40 in Texas, United States Jan 2009 - Jun 2011 | |||
Sep 200943000 miUS $250 | Clutch return spring snapped. Replaced by self after learning that dealership charges approx. $250. |
Volvo S40 in Utah, United States Dec 2010 - Jun 2022 | |||
Apr 201184700 mi | The flame trap needed to be repaired/replaced. It was covered under a warranty extended specifically for that problem. | ||
Dec 201195000 miUS $500 | Shifter cables needed to be replaced. The coupling broke while shifting from first to second gear. | ||
Mar 2015147000 miUS $248 | Battery was slowly failing after ten years (it was the original battery) | ||
Nov 2015157000 miUS $610 | Check Engine light on, had state-required emission test done, had to replace the catalytic converter. | ||
Jan 201691200 miUS $1074 | CV boots were torn on both sides - replaced all four. | ||
Aug 2016170000 miUS $1490 | Ignition coil #2 failed, needed to be replaced. $270. During repair service for ignition coil, they noticed my fuel pressure sensor was bad. Oil trap was clogged - technician noticed it while car was in for another repair. $700. | ||
Apr 2018189000 miUS $120 | Broken engine mount, top, passenger side. Easy. |
Engine not specified
Volvo S40 in Great Britain Apr 2011 - Sep 2012 | |||
May 2012114700 mi£2000 | 4 new shock absorbers |
turbocharged 218hp 2.5L I5 6-speed manual FWD
Volvo S40 in Ohio, United States Apr 2008 - Apr 2013 | |||
Jul 200859000 miUS $110 | 6 CD changer center spindle broke, subsequently would not eject CD's, replaced entire CD changer with used unit. | ||
Jun 200969000 miUS $130 | Replace front sway bar end links. Front right went bad. | ||
Aug 200970000 miUS $12 | Check valve on window washer came apart and needed replaced. | ||
Jun 201077000 mi | Cracked PCV Box | ||
Aug 201077600 mi | Parking brake stuck in the on position. Corrosion built up at the end of the cable housing on the left rear wheel. Extensive lubrication and cleaning of the cable corrected the problem at this time. | ||
Dec 201079000 miUS $742 | Replaced right side wheel bearings both front and back, both were bad, the front with excessive noise and flat spot and back had significant play. |
Volvo S40 in Alabama, United States Apr 2010 - Aug 2011 | |||
May 201049000 miUS $398 | Fuel pressure sensor replaced | ||
Sep 201054000 miUS $125 | Software patch installed to fix AC sometimes blowing hot and cold at same time. Problem has happened twice. | ||
Aug 201160000 miUS $1214 | Air conditioner compressor replaced. Also leak onto carpet caused by AC drain hosed fixed. |
Volvo S40 in Texas, United States Jun 2010 - Jan 2011 | |||
Jul 201075000 miUS $1100 | A/C was shorting out according to Dealer. A/C would intermittantly not blow cold. Dealer told me the whole unit needed to be repaired. $1100 repair at only 75,000 miles. | ||
Dec 201081000 miUS $2350 | 2 problems. Seats started cracking with 82k miles. this is a manufacturer defect. deal paid half. Owner paid $650. $880 to repair CD Deck error. I did not replace. alternator needed to be replaced. $880. did not repalce. traded car for a new Nissan |
Volvo S40 in Texas, United States Jan 2011 - Oct 2011 | |||
Feb 201198000 miUS $700 | Cracked diapragm in the breather box. Breather box replaced. | ||
Jun 2011105000 miUS $200 | AC would work fine for about 15-20 minutes of driving, then start to pull in hot air from outside. Compressor clutch was repaired. |
turbocharged 218hp 2.5L I5 6-speed manual AWD
Volvo S40 in British Columbia, Canada Jun 2013 - Jun 2013 | |||
Jun 2013 | anti skid warning needing service. Goes on and off randomly. alarm would go off in the middle of the night, over and over! 2 wheel bearings failing at the same time. ac belt and drive belt because of a chirp coming from the engine. |
Volvo S40 in Florida, United States Feb 2007 - Dec 2016 | |||
Apr 200958000 miUS $219 | Intermittent Check Engine Light | ||
Jun 201189000 mi | AC Compressor Clutch replaced. | ||
Mar 2013103000 miUS $700 | Battery was leaking, corroded battery and battery cables were replaced. | ||
Aug 2014111000 miUS $1400 | Alternator failed, replaced Alternator failed, killed battery Cam seal oil leak | ||
May 2015117400 miUS $400 | Brake sensor replaced, reverse lights were intermittent. Engine mount damaged | ||
Jun 2016127000 miUS $350 | Cracked Coolant Reservoir | ||
Nov 2016128000 miUS $300 | InnerCV boot leaking |
Volvo S40 in Virginia, United States Jul 2009 - Nov 2014 | |||
Sep 200938000 mi | TSB 205 - PCV Vent box. Dealer did not reconnect dipstick tube to engine in Sep service #1. Dipstick tube fell out of oil pan. When I brought it in, they pop-riveted it back on! This time they replaced the PCV assembly and used a bolt to secure the dipstick tube. After 3 visits! | ||
Sep 201047000 miUS $950 | O2 sensor check engine light, dealer replaced battery harness and O2 sensor. | ||
Nov 201489000 miUS $6700 | Timing belt tensioner failed |
Volvo S40 in Kansas, United States Oct 2013 - Nov 2013 | |||
Oct 2013116000 miUS $987 | Alternator went out. Replaced with battery. Afterwards received deck error from CD player. | ||
Nov 2013116000 miUS $51 | Harmonic Balance nut worked loose, caused belts to be thrown, quick fix but could of blown my engine. |
Volvo S40 in Wisconsin, United States Jun 2015 - Jun 2018 | |||
Jul 2015149500 miUS $80 | Replace engine torque mount. Shim AC compressor. | ||
Jun 2016160000 miUS $100 | Replace: both rear differential seals, driver rear axle (torn boot), rear wheel bearing. Replace failed alternator. Replace passenger front wheel bearing. | ||
Sep 2016164000 miUS $220 | Replace PCV oil trap. Replace AWD controller and pressure sensor. | ||
Jan 2018169000 miUS $1200 | Replace clutch, flywheel, slave and angle gear collar. Replace fuel pump |
turbocharged 218hp 2.5L I5 5-speed shiftable automatic FWD
Volvo S40 in Switzerland Jun 2006 - Mar 2010 | |||
Jun 200621700 mi | cd charger | ||
Jan 200724800 mi | climate control reset |
Volvo S40 in Texas, United States Feb 2005 - Mar 2010 | |||
Jul 20056000 mi | Radio random lockups were repaired under warranty | ||
Aug 200624000 mi | Some vibrations at low and high speeds were repaired under warranty with software update for the transmission and replacement of an axle. Axle could have been damaged from pot hole from hell. All fixed under warranty. | ||
Dec 200867000 miUS $90 | Clogged PCV caused a squealing noise. I replaced the oil filter housing. | ||
Mar 200971000 mi | Airbag sensor was not working on the passenger seat. Dealer reset it and is working fine. |
Volvo S40 in New York, United States Oct 2009 - Jun 2015 | |||
May 201141000 miUS $160 | Trunk lock would not disengage, replaced trunk lock assembly. | ||
Aug 201242000 miUS $400 | fuel pressure sensor failure |
Volvo S40 in Texas, United States Apr 2010 - Dec 2012 | |||
May 201045500 mi | Replaced windshield wiper washers Replaced windshield wiper washers | ||
Aug 201159000 miUS $125 | Coolant reservoir developed a crack and all coolant leaked out | ||
Sep 201160000 miUS $86 | When driving, the car gave bucking sensation so severe, it felt like I had been rear-ended by another car. After this, I received the message "Transmission Service Urgent" and odd transmission behavior. Dealer performed TCM software upgrade | ||
Aug 201271900 miUS $45 | The auto transmission felt like it slipped a gear and message appeared in Trip Computer saying 'Transmission Service Urgent'. Dealer said they were not able to replicate, but performed a software update. This seemed to fix issue. |
turbocharged 218hp 2.5L I5 5-speed shiftable automatic AWD
Volvo S40 in Quebec, Canada Nov 2017 - Jan 2018 | |||
Dec 201788660 miC $75 | Hole in flex pipe, flex pipe was replaced with a new OEM grade unit Rear sway bar end links replaced with new OEM grade links |
Volvo S40 in Ontario, Canada Apr 2007 - Mar 2010 | |||
Jan 200713026 mi | CD Player Replaced under Warranty | ||
May 200718207 mi | L Front Wheel Bearing Replaced (Warranty) | ||
May 200937200 mi | Front Right Wheel Bearing Worn - Front Wheel Hub Assembly replaced. | ||
Sep 200945880 mi | Oil trap box (housing oil filter is attached to) - plugged |
168-horsepower 2.4L I5 5-speed shiftable automatic FWD
Volvo S40 in Virginia, United States May 2007 - Jan 2009 | |||
Aug 200728000 mi | Check engine light came on and air conditioner started blowing HOT air on driver's side only |
Volvo S40 in Ohio, United States Feb 2007 - Apr 2010 | |||
Apr 200940000 mi | I needed a software upgrade (ECM Gasoline Up) and the PCV hose from the oil trap to the head failed. | ||
Apr 201053000 miUS $100 | Failed brake sensor. Parts ordered and car repaired in 2 business days. Happy with process. Total cost (including $100 deductible) was $270. |
Volvo S40 in New Hampshire, United States Jul 2012 - Jul 2022 | |||
Feb 201396300 mi | sunroof drain was disconnected which caused the floors to fill with water. I have reconnected the drain and removed the standing water though the carpets and insulation under are still quite wet. I see from my internet search this common |
Volvo S40 in Illinois, United States Jul 2010 - May 2011 | |||
Mar 201161000 miUS $125 | Wipers could not be turned off, gas gauge went to zero (after just filling the tank), SRS airbag light on, trunk lid open light on. Found loose/faulty electrical wire. |
Volvo S40 in Texas, United States Dec 2012 - Jan 2013 | |||
Jan 2013 | Software update |
Volvo S40 in Alabama, United States Sep 2015 - Jun 2016 | |||
Sep 2015138000 miUS $1200 | transmission needed to be replaced | ||
Jun 2016136000 miUS $3500 | some belt broke and tore my air conditioner lines up. if i kept driving it it would have totaled the car |
Volvo S40 in Indiana, United States Feb 2014 - Aug 2014 | |||
Jun 2014124000 mi | Right wheel bearing needed replaced. Had to grind off the existing one as it was rusted throughout. | ||
Aug 2014124000 miUS $750 | Alternator had to be replaced. |
Volvo S40 in Pennsylvania, United States Apr 2015 - Mar 2016 | |||
Jun 201587000 miUS $2000 | Air conditioning cycles off after 10-15minutes Growling noise from rear of car while driving. Both rear wheel bearings worn. Both rear hubs replaced. | ||
Mar 201689000 mi | Multiple warning lights illuminated, wipers switched on uncommanded, transmission reverted to "limp" mode. No parts replaced...got rid of car instead. |
168-horsepower 2.4L I5 5-speed manual FWD
Volvo S40 in Pennsylvania, United States Sep 2006 - Jan 2017 | |||
Jan 200625000 mi | Engine light came on - needed to have carbon deposits removed from intake manifold. | ||
Nov 200941000 miUS $50 | The windshield wiper check valve had failed | ||
Mar 201043000 miUS $660 | Water was found behind the passenger seat. It was diagnosed to be a plugged sunroof drain pipe backflowing into the car. | ||
Nov 201151000 mi | The dealer removed the interior carpets and insulation, dried the vehicle, and cleared the sunroof drainage tubes that were blocked causing a leak | ||
Apr 201255000 miUS $550 | one motor mount was degraded and required replacement. This was detected during a normal service interval. | ||
Nov 201259400 miUS $960 | Replaced worn lower control arm | ||
May 201364100 miUS $175 | I experience periodic blockage of the sunroof drainage tubes. Part of this service interval addressed this issue. | ||
Aug 201582600 miUS $732 | Headlining delaminating - replaced entire headlining. | ||
Jan 201677800 miUS $140 | Symptom was power steering pump stopped working. Diagnostic codes and battery load test indicated failing battery. | ||
Nov 201692900 miUS $4200 | CV boots replace engine mount strut shocks |
Volvo S40 in Ontario, Canada May 2011 - Dec 2016 | |||
Jun 2012104160 miC $300 | Battery died and had to be replaced. | ||
Jun 2014121520 miC $300 | CV boot front strut |
Volvo S40 in Pennsylvania, United States Dec 2016 - Mar 2017 | |||
Jan 2017128200 mi | Clutch spring failure. Mechanic could not physically replace the spring. | ||
Feb 2017129000 miUS $500 | Emissions system check engine light. Throttle cleaned to fix problem in short term. Diagnosis is catalytic converter and will likely need replacing at a cost of $500-$700. |
Volvo S40 in Ontario, Canada Mar 2013 - Jan 2014 | |||
Sep 201381220 miC $248 | Squeaky clutch pedal with slow return. clutch spring was replaced. | ||
Jan 201481220 miC $350 | Right rear wheel bearing was noisy and had to be replaced. Right lower arm clunky and the left rear shock absorber was shot Manual transmission hard to use in winter. Noisy clutch release bearing, AC compressor clutch burnt. Squeaky accessory drive belt possibly due to missing engine splash guard. Engine splash guard came out. Decided not to replace as I was selling the car. |
Volvo S40 in Spain Nov 2007 - Jun 2011 | |||
Nov 200839358 mi | Loose cable on fuel pump. Loose cable on fuel pump | ||
Jun 200946500 mi | Alternator. |
Volvo S40 in Alberta, Canada Feb 2010 - Aug 2014 | |||
Aug 201448980 miC $1200 | Front shocks need replacing |
Volvo S40 in Illinois, United States Nov 2010 - Jun 2018 | |||
Mar 201179000 miUS $350 | Check engine light on. When tested, had error code ECM-2600. Replaced faulty fuel pressure sensor. | ||
Jun 201180000 miUS $3500 | No AC. Replaced condenser. $1700. Replaced shocks, discovered problem at tire shop, $1800. | ||
Aug 201290900 miUS $3095 | Clutch was slipping. Diagnosed as failed clutch. Replaced the clutch, flywheel, and throw out bearings. Cracked breather hose. Replaced hose and the intake seals. | ||
Aug 2014101000 miUS $3072 | Parking brake doesn't hold intermittently. Parking brake cables were binding. Replaced cables and wire box. Excessive vibration, rough ride, appears to be coming from front end. Left front axle was vibrating and inner boot torn. Replaced left front axle shaft. Left front spring broken, struts leaking and strut bearings binding on turns, bump rubber damaged. Replaced springs and struts with related bearings and bump rubbers. | ||
Oct 2016113500 miUS $900 | Front end noise, worse on left side, caused by worn wheel bearings. Replaced front left & right wheel bearings. Right motor mount leaking fluid. Replaced. Rear passenger taillight out. Replaced. | ||
Apr 2017120000 miUS $42 | Replaced right headlight. | ||
Nov 2017127000 miUS $1971 | Intake manifold gasket, oil separator and gasket, spark plugs, air flow sensor. Camshaft and crankshaft seals. Right front axle. |
143-horsepower 2.0L I4 5-speed manual FWD
Volvo S40 in Alberta, Canada Aug 2015 - Jan 2022 | |||
Mar 201664480 mi | Replaced front shocks. One was leaking and the other was soft. Also timing belt change. |
123-horsepower 1.8L I4 5-speed manual FWD
Volvo S40 in Ireland Jun 2009 - May 2010 | |||
Mar 201055800 mi€600 | Replaced alternator. When sold the 'brake failure, engine stop' message still came up from time to time. Shop couldn't diagnose even with code. When it happened indicators and wipers wouldn't work or wouldn't turn off. Or the car wouldn't start for up to three days. |
turbocharged 5-cylinder automatic 2WD
Volvo S40 in Virginia, United States Feb 2007 - Apr 2016 |
5-cylinder automatic 2WD
Volvo S40 in Florida, United States Dec 2007 - Jul 2008 | |||
Jan 200831000 mi | There is a rattle noise coming from the engine bay at idle. Originally thought to be a loose hose, dealer tightened hose and the noise still persists. Replaced faulty passenger airbag sensor. | ||
Mar 200832000 mi | I was driving when a "Warning, low brake level fluid, stop immediately" light came on. I pulled over and had Volvo come tow me to the dealer. I just had my 30,000 mile service done 3 months ago, so dealer inspected the brake fluid container and ... | ||
May 200836000 mi | Splash guard underneath engine disconnected from all 5 front clips falling to the ground. Was still connected at the back. Couldn't drive car because any bump or object in the road would rip off splash guard. Towed to dealer by roadside asst. and fixed. |
Engine not specified
Volvo S40 in Georgia, United States Mar 2012 - Apr 2012 | |||
Apr 201283000 miUS $4300 | Vechicle overheated and they originally thought it needed the head gasket replaced but it turned out that it could not be repaired and needed a whole new engine. Mechanic said that the engine was rare but i don't really believe that. |
Volvo S40 in Ontario, Canada Nov 2014 - Apr 2015 | |||
Mar 2015133920 mi | Car would start, then shut off. Car would not start and run without immediately revving the car almost to max after ignition. | ||
Apr 2015133920 miC $350 | Had to replace both drive shafts. |
turbocharged 218hp 2.5L I5 6-speed manual FWD
Volvo S40 in Michigan, United States Aug 2010 - Jun 2013 | |||
Sep 2010117000 miUS $650 | Vehicle would not recognize key. Had to have new switch installed. Check engine light has come on. Again. Some times it goes away, but returns later. Probably a sensor is going. Just going to live with it. Just another repair cost to this vehicle. |
turbocharged 218hp 2.5L I5 5-speed shiftable automatic FWD
Volvo S40 in New Jersey, United States Oct 2008 - Dec 2015 | |||
Nov 200891000 mi | Dealer cleaned out drain tubes because they were clogged and was allowing water into floor of back seat floor. | ||
Apr 2009105000 miUS $100 | ABS light came on; problem traced to faulty ABS wheel speed sensor. Dealer did not have in stock so customer ordered it elsewhere and installed it on their own. Installed wheel speed sensor. | ||
Dec 2009132000 miUS $175 | Car went in to replace timing belt. Successfully changed, no problems. Water pump replaced at the same time that the timing belt was changed as preventative maintenance. Replaced a torn engine mount....fixed successfully the first time. | ||
Jul 2010150000 miUS $600 | Replaced front struts and bearings | ||
Sep 2010156000 miUS $528 | A wheel hub was noisy and replaced successfully. | ||
Mar 2011177000 miUS $600 | Another wheel hub replaced Starter replaced | ||
Apr 2011178000 miUS $800 | Replaced starter. Replaced both lower control arms and passenger side axle. | ||
Dec 2011201000 miUS $284 | replaced driver's door module that controls door locks and window operation | ||
Apr 2012216500 miUS $330 | Turbo Control Valve replaced | ||
Jun 2012224000 miUS $350 | Replaced fuel pressure sensor | ||
Jul 2012225200 miUS $420 | replace compressor and clutch | ||
Jan 2013242000 miUS $400 | Replaced heater core | ||
May 2013246000 miUS $159 | Replaced rear shocks. | ||
Jan 2014210500 miUS $75 | Engine coil on cylinder 1 failed and caused check engine light to come on. | ||
Jun 2015272000 miUS $700 | Coolant hoses split and thermostat housing was leaking |
Volvo S40 in Georgia, United States Feb 2010 - Jun 2011 | |||
Mar 201066000 miUS $230 | AC compressor not turning on, no cold air. |
Volvo S40 in North Carolina, United States - Aug 2006 | |||
Aug 200626000 mi | Car was rattling over bumps. They said the cage that protects the gas tank was hanging down. It was replaced. |
168-horsepower 2.4L I5 5-speed shiftable automatic FWD
Volvo S40 in California, United States Aug 2007 - May 2015 | |||
Oct 200738000 mi | Rolling noise from front of car, springing noise from seats and suspension | ||
Mar 200848000 mi | Clicking noise from front part of car, suspension ticking, electrical sounds from front right of car, scratched panel, dealer dented car had to get touched up. | ||
Oct 200865000 miUS $140 | Mod went wrong. | ||
Jan 200968000 mi | AC didnt blow cold after a recharge; new compressor. | ||
Mar 201096000 mi | cd player doesn't eject. ignition went out. | ||
Jun 2012140000 miUS $1800 | replaced CEM (central electronic module) | ||
Aug 2013161000 miUS $150 | Known problem Pcv | ||
Feb 2014165000 miUS $600 | Head Gasket | ||
Jan 2015166000 mi | Head gasket failure. |
Volvo S40 in Oregon, United States Jan 2016 - Sep 2016 | |||
Jun 201670000 miUS $775 | Headliner had pretty much all fallen down. On the front door panels, some areas of the fabric cover had come unglued. |
Volvo S40 in Texas, United States Oct 2009 - Mar 2013 | |||
Mar 2013 | Torn CV axle boot. |
123-horsepower 1.8L I4 5-speed manual FWD
Volvo S40 in Great Britain Apr 2010 - Oct 2011 | |||
Jun 201062000 mi£700 | Check engine light illuminated. Fault located to throttle module. Throttle module replaced, fault still present. Next stage is replace wiring harness. Alternator also packed up whilst in the garage. | ||
Oct 201176000 mi£300 | Probably coil packs Throttle body communication. Same fault as last year. Minimum £500 repair so car was sold as faulty. |
turbocharged 5-cylinder automatic 2WD
Volvo S40 in Puerto Rico Feb 2007 - Jul 2009 | |||
Mar 200735000 mi | Vacuum pump defect | ||
May 200736000 mi | Same vacuum pump | ||
Jun 200738000 mi | The vacuum pump of the brake system was changed. Driver side vent visor is damaged. And also driver door seal is broken. | ||
Mar 200843000 mi | New weather strip placed. Xenon lights needed leveling. | ||
May 200846000 miUS $400 | Need to replace bad struts...... | ||
Jul 200847000 mi | Fuel pump module needed to be replaced. One oxygen sensor replaced. | ||
Oct 200850000 mi | An hydraulic engine mount was defective | ||
Jan 200952000 mi | Engine mount replaced. |
turbocharged 170hp 1.9L I4 5-speed automatic FWD
Volvo S40 in Texas, United States Jun 2017 - Jun 2018 | |||
Apr 2018165000 miUS $528 | Left rear caliper frozen, requiring replacement, along with both rear rotors and pads. |
turbocharged 170hp 1.9L I4 5-speed automatic FWD
Volvo S40 in California, United States - Aug 2007 | |||
Aug 200760325 miUS $190 | replace boost pressure sensor |
turbocharged 160hp 1.9L I4 5-speed automatic FWD
Volvo S40 in Washington, United States Jun 2017 - Jun 2018 | |||
Aug 2017149000 miUS $1700 | Replaced all 4 Brake pads, Rotors, and Brake Lines | ||
Jun 2018153000 miUS $30 | Front Driver & Passenger-side door panels; center portions came unglued over time and rattled during idle. |
Volvo S40 in Michigan, United States Jun 2017 - Jul 2018 | |||
Sep 2017188600 miUS $60 | HVAC resistor replaced. | ||
Mar 2018194400 miUS $180 | Both front springs broke and were replaced. | ||
Apr 2018199000 miUS $70 | Radiator started leaking from corrosion at the endcap/core interface and needed to be replaced. |
Volvo S40 in California, United States Jan 2020 - Mar 2021 | |||
Sep 2020117000 miUS $225 | Upon visual inspection, noticed that coolant colored leak line from top radiator hose that has molded small hose connection for overflow (special hose from Gates or Volvo). Replaced hose, hose clamps and coolant. Also checked plastic overflow container for leaks, cracks and brittle fitting tubes but was ok (known weakness at over 100k miles and can cause overheat, blown head gasket). Checked condition of lower radiator hose and radiator cap and both were fine. | ||
Dec 2020118000 miUS $125 | Car began to make knock noise at full lock in parking lot maneuvers, inspection revealed sway bar stabilizers rubber bushings were shot, replaced with factory OEM links from FCP-Groton, and steering improved as it was notchy before but clunk remaining, suspected strut tower top assemblies wirh rubber cushion and shaft bearing are worn as a known issue at this mileage. [brake job] | ||
Jan 2021119000 miUS $170 | [brake job] |
Engine not specified
Volvo S40 in Ontario, Canada Apr 2012 - May 2012 | |||
May 2012124000 miC $45 | The wire sending signal to one of the spark plugs was corroded. Mechanic figured out the loosed connection and managed to fix it without ordering a new (and expensive) replacement. |
turbocharged 165hp 1.9L I4 5-speed automatic FWD
Volvo S40 in Michigan, United States Oct 2009 - Jun 2011 | |||
Nov 2009135000 miUS $275 | Trunk would not open |
Volvo S40 in Quebec, Canada Dec 2009 - May 2011 | |||
Jan 201083080 miC $185 | Fuel gauge not giving correct reading - sending unit replace over 12 months ago at the dealer and problem recurred last year. Was actually harness to sending unit - replaced = all ok now. | ||
Apr 201083080 miC $10 | Handbrake seemed high - rear right caliper was stuck - lubricated and ok now | ||
Mar 201191760 miC $125 | Caliper changed on driver's side rear |
Volvo S40 in New York, United States Aug 2010 - Dec 2012 | |||
Sep 2012126000 miUS $800 | Alignment of wheels could not be performed because adjustment bolts on rear were frozen. Parts were ordered from Volvo and replaced. Work done at Sears automotive | ||
Oct 2012126000 mi | Smell of gasoline in cabin. Sears automotive could not find a leak. No repairs attempted. Continuing problem for months led us to trade the car in on a new car purchase. |
Volvo S40 in Quebec, Canada Nov 2009 - Aug 2011 | |||
Mar 2010105400 miC $250 | problem with flex pipe(?)/catalytic converter had been around a while but car sounded terrible and was reluctant to drive anywhere -- I had parts fixed rather than replaced since I hope to trade the car in during the next month or so... | ||
Mar 2011109740 miC $1200 | brakes did not work... brake lines replaced... also ball bearings replaced... |
Volvo S40 in Virginia, United States Dec 2009 - Jan 2012 | |||
Sep 2010145000 miUS $650 | Alternator worn out and replaced | ||
Jan 2012160000 miUS $125 | needed new battery |
Volvo S40 in California, United States Sep 2009 - Jun 2011 | |||
Oct 200972000 miUS $1200 | long crank time when trying to start, intermittent idle stumble. replaced fuel pressure regulator. | ||
Nov 200972000 miUS $165 | BOTH REAR TAIL LIGHTS NOT WORKING, ELECTRICAL SHORT FOUND AND REPAIRED |
Volvo S40 in Maryland, United States May 2010 - Sep 2012 | |||
Jul 2010150300 miUS $500 | My 2001 S40 would only overheat when I would run the AC. The dealer replaced 3 relays but the problem continued, particularly in traffic. The low speed was not working. The failure was in the fan resistor (P/N 30644121) not the fan itself. | ||
Mar 2011157000 mi | Rear brakes replaced (rotors and pads) and the dust shields needed to be replaced due to rust and rot. |
Volvo S40 in Pennsylvania, United States Oct 2009 - Jan 2013 | |||
Dec 2009116000 miUS $120 | replaced stabilizer bars. |
Volvo S40 in Pennsylvania, United States Mar 2013 - Apr 2013 | |||
Apr 2013103000 mi | Acceleration lag and check engine light came on. |
Volvo S40 in North Carolina, United States Jun 2010 - Jun 2011 | |||
Aug 2010108000 miUS $140 | bad antenna shaft........repaired, but still makes awful noise raising and lowering.... I'll never own a volvo again man..... |
Volvo S40 in California, United States Jan 2017 - Jan 2017 | |||
Jan 201780000 miUS $160 | Regulator needed to be fixed. |
Volvo S40 in British Columbia, Canada Aug 2011 - Aug 2014 | |||
Nov 2011121700 miC $35 | Front Hood single hydraulic arm on right side failed to maintain pressure, resulting in hood not being able to stay up on own accord without physically holding it up by person or object. | ||
Apr 2012126360 miC $27 | right front passenger side light bulb was replaced. | ||
Jun 2012128960 miC $100 | Engine light came on. I went for regular maintenance, technician discovered other problems. Requires two sensors, $1,000. Flushed fuel and transmission fluids, replaced air filter that might have caused error. | ||
Sep 2012132060 miC $23 | replaced left front headlight. | ||
Oct 2012132560 miC $23 | replaced right front headlight | ||
Dec 2012135160 mi | replaced coil and all spark plugs, changed oil, troubleshooted engine light error but not charged for problem not resolved. going back again on dec 21, 2012 Diagnose engine light error codes(3 of them) and left car overnight. Mechanic was able to troubleshoot two of the codes by replacing an ignition component in the engine. 1 code still remained. Will fix when have more money. Brake work caused noise in front left wheel. Shop fixed under warranty by tightening something. | ||
Aug 2013142540 mi | Dealer replaced oil and indicated the following problems: Front Crank, radiator hose leak, gasket leak in transmission, fuel mix problem causing starting issues. | ||
Aug 2014153760 mi | Oil, coolant, and transmission fluid leaks never fixed. Fuel mix problem causing starting issues. |
Volvo S40 in Virginia, United States Feb 2012 - Mar 2012 | |||
Mar 2012156000 mi | Transmission is starting to slip |
Volvo S40 in Great Britain Sep 2011 - May 2014 | |||
Dec 201285000 mi£148 | Right rear coil spring had broken, was replaced. |
turbocharged 4-cylinder manual 2WD
Volvo S40 in Great Britain Oct 2010 - Sep 2012 | |||
Aug 2011113000 mi£300 | Broken front offside coil spring. Both front springs were replaced by the garage. | ||
Dec 2011117000 mi£300 | both front flexi brake pipes and driver side front to rear brake pipe were perished or overly corroded. |
4-cylinder automatic 2WD
Volvo S40 in Great Britain May 2013 - Dec 2013 | |||
Jun 201356000 mi£200 | Harsh gear changes. Drop links needed replacement. | ||
Nov 201363000 mi | Central locking system. | ||
Dec 201363000 mi | The locking system was fixed (second attempt) by fitting a new part and now all works well again. |
turbocharged 160hp 1.9L I4 4-speed automatic FWD
Volvo S40 in Massachusetts, United States Jun 2014 - Dec 2014 | |||
Jun 201490000 miUS $270 | Entire front suspension had to be re-done; 2000 model had faulty strut mounts, needed to be updated to later 2001+ style; struts needed replacing; right spring broke and was replaced Wheel bearings both needed to be replaced; caused massive vibration Other wheel bearing replaced and seal Both CV joint boots torn; both CV axles replaced other cv axle replaced |
Volvo S40 in New Jersey, United States Aug 2013 - Jun 2015 | |||
Oct 201396000 miUS $600 | Fuel Pump failure (leak) | ||
Aug 201497000 mi | Fuel pump got stuck. | ||
Jun 201598000 miUS $900 | Brake hose leak Replace front (required) and back brakes |
Volvo S40 in Ohio, United States - May 2008 | |||
May 200819000 miUS $100 | Replace fuel pressure regulator (FPR) due to prolonger crank times. |