◆

Volvo XC90 repairs by problem area

Engine (26%)

Transmission and Drivetrain (11%)

Brakes and Traction Control (8%)

Suspension and Steering (19%)

Electrical and Air Conditioning (24%)

Paint, Rust, Leaks, Rattles, and Trim (8%)

Other (5%)

Select a problem area

Need advice about a specific Volvo XC90 problem?

Chart based on 1442 repairs.

See TSBs and recalls for the Volvo XC90.

Volvo XC90 repair cost distribution

$2500+ (6%)

$1000 - $2499 (16%)

$500 - $999 (18%)

$100 - $499 (31%)

< $100 (29%)

See most expensive repairs

Worried about potential repair costs? An extended warranty can provide peace of mind.

Chart based on 931 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

See repairs for all Volvo XC90 model years.

Volvo XC90 in Texas, United States Aug 2021 - Feb 2022
Dec 2021 2000 mi	4 wheel alignment [out at delivery]

Return to top

Volvo XC90 in Alberta, Canada Feb 2021 - Jun 2022
Apr 2021 1054 mi	A/C system not charged from factory and missed on delivery inspection of new vehicle 2 months prior.

Return to top

Volvo XC90 in Georgia, United States Jun 2021 - Oct 2024
Jul 2024 32000 mi	Software issue. Will not "see" lanes on lane keep assist. Audio from radio/carplay/other inputs at times stops. Software restarts periodically, for no reason

Return to top

Volvo XC90 in Maryland, United States Jun 2021 - Jun 2022
Sep 2021 2000 mi	Front passenger rotor was warped. Replaced under warranty.

Volvo XC90 in Indiana, United States Jun 2021 - Jun 2022
Nov 2021 3748 mi	Hybrid power system failure. Replaced high voltage traction power inverter.

Return to top

Volvo XC90 in North Carolina, United States Oct 2020 - Dec 2023
Aug 2022 21000 mi	rear brake pads replaced; they were wearing abnormally quick; replaced under warranty;

Return to top

Volvo XC90 in Alabama, United States Oct 2020 - Jun 2022
Jun 2022 13000 mi	Charging System Issue Message Displayed. Dealer updated software.

Return to top

Volvo XC90 in Virginia, United States Oct 2020 - Nov 2021
Oct 2021 21 mi	Recall fuel pump fuse

Volvo XC90 in Nebraska, United States Jun 2022 - Mar 2023
Mar 2023 31000 mi	Chrome delaminating on two exterior door handles and on shift bezel

Return to top

Volvo XC90 in Virginia, United States Dec 2022 - Nov 2023
Apr 2023 39240 mi	The vehicle would start and then immediately stall. Also experienced a long crank. Check engine light would illuminate after the vehicle would stall.

Return to top

Volvo XC90 in Delaware, United States Nov 2017 - Jun 2018
Jun 2018 5000 mi	Heat shield around drive shaft was rubbing the drive shaft and creating a scraping noise under low acceleration. It was a quick fix by the dealer to bend the shield back in place.

Volvo XC90 in North Carolina, United States Aug 2017 - Jun 2018
Feb 2018 12000 mi	Fuel filler neck had to be replaced due to vapor escape.
Jun 2018 19000 mi	Full suspension replacement

Volvo XC90 in Wisconsin, United States Jun 2017 - Jun 2022
Dec 2017 4000 mi	Emissions repair - Fuel filler neck replacement.

Volvo XC90 in New Jersey, United States Jul 2018 - Aug 2019
Sep 2018 2000 mi	SiriusXM showed "Antenna Error" Entire ICU was replaced, fixed the issue.

Volvo XC90 in Indiana, United States Dec 2020 - Jul 2022
Jul 2021 65000 mi US $100	Replaced steering wheel button assembly due to inop audio controls
Apr 2022 87000 mi	Cam phaser check engine light, dealer reset CEL. CEL reappeared 1-200 miles after attempted "repair".
May 2022 80000 mi	Cam phaser check engine light, dealer changed oil because they said it was "dirty". However, they did not test the oil, and the check engine light came on 2-300 miles later.
Jul 2022 93000 mi	Check Engine light for cam phaser failure.

Volvo XC90 in Colorado, United States Feb 2021 - Jun 2022
Jan 2022 42000 mi	Trunk floor storage handle was lose and lower passenger side of the windshield trim was lose. Both were replaced under warranty. 2nd battery (for the engine stop start function) failed and resulted in the stop start feature no longer working properly. battery replaced and system works fine again.

Volvo XC90 in Colorado, United States Nov 2017 - Jun 2022
Apr 2022 49000 mi US $350	Fuel system sensor failed

Return to top

Volvo XC90 in Ontario, Canada Oct 2020 - Jun 2022
Dec 2021 86180 mi C $1100	Brake pads were changed on the rear tires
Apr 2022 93620 mi C $900	Water was leaking through the headlights into the car. Stuff has to be removed, cleaned, changed and put back The problem reoccurred after a few weeks and on the second time the repair was successful. Or it’s been a few weeks and so far so good.
May 2022 96720 mi C $1100	There was a leak from the AC condenser into the car and affecting the acceleration and the actual paddle. All had to be replaced with some stuff under warranty.
Jun 2022 100440 mi C $1100	Door could not open

Return to top

Volvo XC90 in California, United States Jul 2017 - Feb 2022
Dec 2017 4000 mi	Nav system failed to access internet which affected traffic, in car apps etc. Dealer first attempted to reload sensus FW which only briefly resolved the issue. Later they needed to replace the whole control unit which took a few weeks to get from Sweden
Jun 2020 30000 mi US $390	front and rear pads needed replacement A/C lost charge and needed to be recharged. Dealer looked for a leak but could not find one. They left dye in and its now wait and see. Start stop was not working. They attempted fix the problem with sw in previous trips but was not resolved in the longer term. This service trip they found the battery had a internal problem and would not take a full charge. They replaced the charge and did a SW update. Problem seems fixed finally. o2 sensor problem

Volvo XC90 in Texas, United States Jan 2017 - Jun 2022
Mar 2017 3000 mi	problem in Software related to the optional Tow Package - draining Battery
Dec 2021 49048 mi US $1370	Hear Evaporator replace & Freon recharge

Volvo XC90 in California, United States Sep 2017 - Mar 2018
Dec 2017 10000 mi	Car has a dead spot in the throttle at tip-in. Transmission shifts clunky. Installing Polestar did not fix the problem. Uninstalling Polestar and resetting the computers fixed the problem for 3 days until the car began adapting back to the original state. Problem still exists. Regional Engineer has been brought in to capture more data for analysis in Sweden. No abnormality found in the sensors. Attempted to replace throttle body. No difference.
Jan 2018 10000 mi	Dead spot in the throttle tip-in followed by a burst of acceleration. Dealer could not fix. Sold back as a lemon.

Volvo XC90 in Quebec, Canada Jul 2017 - Jul 2020
Aug 2017 186 mi	roof trim replaced because it was a little bit torn upon delivery. It was torn during a recall for side curtain made before arrival to the dealer. they noticed it on pre-delivery inspection.
Aug 2018 9300 mi	While driving in a mountain region, low coolant warning pops on the dashboard when terrain is not level. Added about 1 L of coolant to the expansion tank. No visible leak. Brought it back to the dealer for a checkup of coolant system. They replaced a coolant hose on warranty.
Feb 2020 21700 mi	Direction lights lever started to work intermittently. The dealer changed all the lever behind the steering wheel.

Volvo XC90 in Texas, United States Feb 2017 - Dec 2021
May 2017 10000 mi	Software glitch in navigation system. Download fixed it completely. No other issues at all.

Volvo XC90 in Michigan, United States Mar 2017 - Jan 2021
Jul 2017 7421 mi	Replaced Vehicle connectivity module
Sep 2017 10280 mi	Front pads and rotors replaced - warped rotors
May 2018 25000 mi	Air suspension failed. Replaced compressor.
Sep 2019 42000 mi	Air suspension compressor replaced for second time Front Rotors warped. Replaced
Oct 2019 42000 mi	Auto start stop failed. Replaced auto start battery
Jul 2020 50000 mi US $850	Rear Rotors and pads replaced

Volvo XC90 in Rhode Island, United States Apr 2017 - Jun 2018
Aug 2017 5000 mi	Defective battery, replaced under warranty

Volvo XC90 in New York, United States Nov 2016 - Dec 2020
Dec 2016 1000 mi	Windshield was warped / distorted - noticed it on drive home. Replaced under warranty.
May 2018 13000 mi	Passenger seatbelt squeaked when passenger was using it. Required dis-assembly and re-assembly by dealer to fix.

Volvo XC90 in Alabama, United States Nov 2017 - May 2022
May 2022 58000 mi US $500	Replace one of the motorized tailgate arms

Volvo XC90 in Quebec, Canada Oct 2021 - Jun 2022
Jun 2022 41540 mi C $3500	Headlight

Volvo XC90 in Connecticut, United States Oct 2020 - Jun 2022
Jan 2021 42000 mi	vibration in driveline center screen freezes
Apr 2021 46000 mi US $120	battery tested and failed
May 2021 48466 mi US $250	replaced AGM battery
Oct 2021 52204 mi US $450	Replaced rear rotors and pads
Nov 2021 53500 mi US $400	Replaced front pads and rotors due to vibration
Jan 2022 56000 mi US $450	Infotainment system reflashed due to freezing issues Air suspension compressor pump replaced. Original pump failed.

Volvo XC90 in Illinois, United States Jan 2021 - Jan 2022
Mar 2021 44300 mi	Moonroof sun shade fell down out of the track. A new sun shade was installed under warranty.

Volvo XC90 in Nova Scotia, Canada May 2021 - Jun 2022
May 2022 72540 mi C $500	Sunroof cracked in left front corner for no reason, replaced thru insurance @$1450. With $500 deductible.

Volvo XC90 in Massachusetts, United States Aug 2016 - Jun 2022
Feb 2017 8000 mi	Water leaks and AC hose recall. They performed AC hose recall. Water leaks along the passenger footwell still occur. Not fixed and awaiting for leaks to re-occur before being able to diagnose per dealer.
Apr 2018 19000 mi	Rotors warped, steering wheel shake
Jun 2021 54000 mi US $400	Replaced passenger side tailgate motorized strut #31690604
Jan 2022 68000 mi US $70	Cooling line leading into the coolant reservoir broke - emptying all the coolant into the ground. The cooling line was $40 from the dealer. It took about 3 hours to replace as I had not done it before. Now that I do, it would take less than an hour.

Volvo XC90 in California, United States Jun 2017 - Jun 2020
Mar 2018 4000 mi	Driver door had rattling when driving on any kind of road surface.

Volvo XC90 in Nebraska, United States Dec 2016 - Mar 2020
Sep 2018 34000 mi US $1100	Rear pads replaced. Front and rear rotors replaced. Fronts were done under factory warranty
Dec 2019 49000 mi US $650	Brake pads both front and rear are gone. And the rear rotors were warped

Volvo XC90 in Pennsylvania, United States May 2016 - Nov 2017
Dec 2016 6000 mi	Low battery warnings. Took 3 trips to resolve. Software updates plus new battery.
Jan 2017	Software issue caused battery drain. Known issue for all 2017 XC90 due to bad update in November.

Volvo XC90 in Illinois, United States May 2018 - Jun 2018
Feb 2018 7400 mi US $250	Rear parking sensor stopped working.

Volvo XC90 in California, United States Jul 2017 - Jul 2018
Nov 2017 6000 mi	Fuel Filler tube cracked: caused check engine light : replaced

Return to top

Volvo XC90 in Colorado, United States Jun 2016 - Dec 2017
Jul 2016	Replaced plug-in vehicle charger.
Sep 2016 4000 mi	Check engine light was on. Software update supposedly resolved (turned out to be incorrect; see next repair trip).
Nov 2016 6000 mi	Check engine light came on again. Diagnosed as faulty fuel sensor.
Dec 2016 8000 mi	Brake service required warning had come on. Checked out brake system and updated software in the vehicle. During this visit the tech installed the fuel sensor ordered during prior visit.
Jan 2017 8000 mi	Battery had died. Applied software update and reversion to resolve. Parking brake switch replaced. Climate system not putting out appropriate temperatures.
May 2017 12000 mi	Brake service required investigation. They thought that a software update resolved the issue, but it persists. It's going in for another service visit. Squeaking noise during low-level AC use. Replaced heat exchanger per Volvo technical bulletin.
Jul 2017 14000 mi	Charge port replacement.
Sep 2017 16999 mi	Hybrid system failure. Replaced battery control unit.

Volvo XC90 in Washington, United States Sep 2016 - Oct 2017
Mar 2017 6000 mi	An electrical problem caused the hybrid system to stop working, which resulted in a stalled vehicle. It died in the middle of downtown Seattle during rush hour. The best part it that it engages the electronic emergency brake (for safety), so I couldn't even push it out of the way. Dealer replaced a module and performed a software update.

Volvo XC90 in Virginia, United States Feb 2017 - Jun 2022
Mar 2018 21000 mi	Auto requires service warning light persisted. Vehicle software replaced. Problem persisted. Dealer replaced backup battery for diagnostic system. Problem has recurred since then. Car scheduled for service on Monday, 9 April. Warning indicator came on and persisted. Message said to take car to the dealer for repair. Dealer replaced battery for backup warning system. Message disappeared for about a week. Has since returned.

Volvo XC90 in California, United States Sep 2016 - Jun 2022
Jun 2017 9500 mi	10,000 mile check-up, but it also had a software problem.
May 2018 24000 mi	The navigation system map had the car in the Pacific Ocean off the coast of California. The dealer said this was due to a problem with the computer operating system. Brought the car in for a new download. This fixed the navigation system problem, and it also caused the car to run much better and extended the length on the battery charge from 18 to 20 miles, like when it was new.
Dec 2019 45500 mi	The two electrical motors in the rear were not operating properly due to a problem with the rear drive train, which had to be replaced under warranty to its failure. Car ran shitty after previously reported repairs. Returned for download of all specification. Runs better but still not as well as before rear drive replacement. Dealer has placed a help ticket with Volvo in Norway.
Jul 2020 48500 mi	Yearly/10,000 mile service - engine tune, update software, oil change.

Volvo XC90 in New Jersey, United States Aug 2017 - Jul 2022
Sep 2017 1000 mi	Parking sensor was behaving inconsistently. Minor interior trim issues - loose speaker on driver door and loose lining in the trunk area.
Sep 2018 8000 mi	The radio did not have an AM Station on it. The dealer reset the software, then reinstalled the software but the AM station did not show up. The dealer then reported that the T8 Hybrid variant does not have a AM station on its radio. Apparently all other models do.
May 2019 15000 mi	Check Engine Light came on. Was fixed because of a gas fill recall.
Sep 2020 19000 mi	The WiFi module was not working, and the car would not connect to WiFi

Volvo XC90 in Ontario, Canada Nov 2016 - Mar 2018
Mar 2017 3720 mi	Hybrid system module failure causing vehicle to shut down completely in the middle of a busy street.
Jul 2017 7320 mi	navigation system module failure
Sep 2017 9920 mi	air suspension failure (three repairs related to this issue)
Feb 2018 11780 mi	rear door seals failed in cold weather

Return to top

Volvo XC90 in Sweden Jun 2016 - Jun 2022
Nov 2017 16740 mi	Oil leakages.
Jun 2020 36580 mi $1400	Oil leak, replacement of some sealing parts. Replacement of a hose.

Return to top

Volvo XC90 in North Carolina, United States Jul 2016 - Aug 2017
Jul 2016 2000 mi US $2	The outside temperature sensor was not working properly. But the dealership only updated the software. Faulty outside temperature sensor.
Aug 2016 2800 mi	Water leaks behind the rear view mirror.
Sep 2016 4000 mi	Central control unit was replaced.
Nov 2016 6500 mi	A warning light came on and dealer upgraded the software. Mildew smell. Rattle from back seat area.
Apr 2017 9000 mi	The BLIS system stopped working and cameras were out of order though all the cameras were clean. Brakes are squeaking again after several thousand miles.
May 2017 9500 mi	Popping sound still could be heard. Driver side lower and upper control arms were replaced. Shock absorber was replaced. Popping up noise could still be heard. Bolts were tightened and front brake calipers were replaced. The steering wheel makes a pop-up noise when I brake and make a right turn. When accelerating uphill at 30-45 mph, there are rattling noises coming from the dashboard. Dealership couldn't duplicate the noise though a technician did hear it when I drove the vehicle.
Jun 2017 11000 mi	Steering box was leaking. Whole steering box was replaced. This fixed the popping noise.

Volvo XC90 in North Carolina, United States Jun 2016 - Jan 2021
Sep 2016 4000 mi	Outside thermometer bad; replaced for the 2nd time in less than a month
Apr 2017 12000 mi	Had to change the IHU (Internal Head Unit) for the Center dash display. It had a continuous boot issue and a software update did not fix the problem. Appears corrected now.
May 2017 15000 mi	Cruise control and wiper sensor bad. Dealership replaced sensor for cruise control and reprogrammed software.
Sep 2017 20000 mi	Sunroof would not operate. Had to have software updated.
May 2018 29000 mi US $880	Rear brakes pads and rotors replacement
Sep 2018 36000 mi	Brakes vibrating even after rear pads and rotors changed at 30,000 miles
Dec 2018 40000 mi	This was the 3rd trip for a integral display going blank issue. Software 1st time, Wiring 2nd time then IHU (Integrated Head Unit) replaced 3rd time. All under warranty but would have been over a $5000 repair.
Nov 2019 51000 mi	Fuel Door latch replaced, broken
Nov 2020 68000 mi US $400	Coil #1 and all spark plugs replaced
Jan 2021 68000 mi US $450	replaced shark fin antenna seal

Volvo XC90 in New Jersey, United States Jan 2016 - Sep 2016
Aug 2016 7000 mi	Rattle in headliner/sunroof assembly Senses voice control was unreliable Repair to sunroof to fix rattle was unsuccessful. Car began leaking into front passenger foot wells and ruined headliner. Volvo bought the car back the following month.

Volvo XC90 in Massachusetts, United States Jul 2016 - Jun 2022
Feb 2017 10000 mi	Car battery was dead. Jumped but continued to drain battery only charging at 60%

Volvo XC90 in Ontario, Canada Feb 2016 - Jan 2019
Apr 2017 9796 mi	Sunroof leak into head console unit (auto wipers/headlights/drive assist) Sunroof seal replaced
Dec 2017 13020 mi	Crankshaft bearing seal failed. Losing oil, and oil on serpentine belt. Dealr had issues getting the tools to replace the bearing.
Dec 2018 27280 mi C $1700	Brakes all around to fix major shimmy (didn't fix it) and dashboard computer to fix tailgate that wouldn't open

Volvo XC90 in Alaska, United States Feb 2016 - Apr 2017
Jun 2016 3000 mi	This is difficult to categorize. The fix was a software update as that was the official problem. The reporting error was insufficient battery charge. Volvo had a software update.

Volvo XC90 in Oregon, United States Feb 2016 - Jun 2018
Nov 2016 5000 mi	Radio would stay on causing battery drain.
Dec 2016 6000 mi	Oil leak after recent service Low battery warning
May 2017 9000 mi	Auto stop feature not working. Battery recharged.
Apr 2018 18000 mi	Auto stop not working. Battery cell not holding charge. Battery replaced.

Volvo XC90 in Texas, United States Oct 2015 - Dec 2017
Aug 2016 5000 mi	sunroof motor system was grinding, replaced with new.
Oct 2017 12000 mi	Sunroof wasn't sealed correctly and water leaked in during a car-wash. Dealer pulled sunroof assembly and re-sealed.
Dec 2017 15000 mi	During a routine car wash, water leaked in through the sunroof near the C-pillar

Volvo XC90 in Virginia, United States Aug 2015 - Mar 2018
Sep 2016 12000 mi	Drive unit replaced on tailgate. Auto open/close of tailgate was not working properly.
Dec 2016 13000 mi	Navigation system was stuck in one location. Needed to be reset and could not be done by me.

Volvo XC90 in Louisiana, United States Sep 2015 - Feb 2020
May 2017 32000 mi	Sunroof leaked in heavy rain. Volvo knew about the issue and had a repair. I was pleased with their service. It also had a blind spot indicator problem. They're fixing that but had to order a new steering wheel angle sensor. Should be done next week. Installed new steering angle sensor.

Volvo XC90 in Arizona, United States Aug 2015 - Jul 2022
Dec 2015 2000 mi	Software Refresh.
Mar 2017 16830 mi	Interior Trim Panel came loose. Ordered fasteners to reattach. Interior Trim Panel came loose. Ordered fasteners to reattach.
Apr 2017 17767 mi	Interior panel clips replaced from previous visit.
Sep 2017 23000 mi	Navigation system stopped working properly. Hardware was replaced to fix it.
Feb 2018 27876 mi	Rear View Mirror loose. Anti Rattle Tape applied Replaced Spark Plugs - RECALL
Jun 2018 34000 mi	Navigation module replaced
Jul 2018 32874 mi	Seal around trunk falling off. Replaced seal Replaced Secondary and Primary Battery due to code B129F96.
Jul 2020 49160 mi US $859	O2 Sensor and Oil Trap replaced
Nov 2020 52000 mi US $202	Dashboard showing Low Voltage fault saying Power Steering not powered. They recommended upgrading software to expand the voltage sensing parameters. The software upgrade was performed. They also recommended putting car on battery tender at home. I have done this and it hasn't helped with the warning message.
Feb 2021 52818 mi US $279	Replaced Control Arm bushing and Engine Mount

Volvo XC90 in Pennsylvania, United States Jul 2015 - Jan 2016
Dec 2015 3000 mi	Car engine computer "froze" and automatically set electronic parking brake. Ignition failed to start engine and car needed to be towed to dealer for analysis. Computer software was upgraded and problem seems to have been resolved.

Volvo XC90 in California, United States Sep 2015 - Jan 2022
Oct 2015	The Volvo On Call remote control module doesn't work properly.
Jul 2016 3300 mi	Battery low charging message popped out if the car is not driven for a few days. The start/stop function doesn't work because of low battery.

Volvo XC90 in Virginia, United States Oct 2015 - Mar 2019
Nov 2016 7300 mi	Low battery, power saving mode comes on frequently
Jan 2019 26000 mi	Left rear outside door handle does not fully retract.

Volvo XC90 in South Carolina, United States Jan 2016 - Jun 2022
Jun 2016 4000 mi	Outside air temperature sensor required replacing.
Aug 2016 6000 mi	Outside air temperature indication. Sensor was determined bad but could not be replaced due to dealer not having spare part stock. Also, dealer performed sunroof switch recall software update.
Sep 2016 7000 mi	Outside air sensor failed again. Sensor was replaced.
Apr 2020 37000 mi US $150	2016 and later Volvo XC90s have a separate auxiliary battery that carries electrical load when the Auto Stop/Start system has stopped the engine at street lights, stop signs, etc.... That auxiliary battery failed and caused the Auto Stop/Start system to stop disabling the engine when the car stops, again stop lights, stop signs, etc... Dealer/Volvo declared the auxiliary battery a wear part and would not replace under warranty.

Volvo XC90 in Ontario, Canada Dec 2015 - Mar 2019
Jan 2017 19200 mi	Power was lost to all wheel drive. Only you had front wheel drive. Was a lose connection. Service All wheel drive light turned on. No physical issues were felt. It was an issue with the electrical connection to the AWD.
Apr 2017 37820 mi	Car thought that there was a trailer attached, turned off blind spot notification
Jan 2018 34100 mi	Fuse on rear passenger seat heat
Jul 2018 39680 mi	Leaky sun roof Leather on Dash split
Nov 2018 49600 mi	Doors would freeze open when temp dipped below zero. Apparently there is a gasket or something inside of the door that deflects water from the mechanics, it needed to be adjusted/ replaced.

Volvo XC90 in Ontario, Canada Dec 2016 - Sep 2020
Dec 2017 13640 mi	Water leaking oil from sunroof. Broken seal to be replaced. waiting for part.
Feb 2018 13640 mi	Dealer lost the order for the part to fix the roof. Finally got it, took better part of a day to fix it but couldnt.. something went wrong. Ordered more parts and had the car for 4 days plus the weekend.

Volvo XC90 in Texas, United States Aug 2016 - Oct 2018
Jun 2018 43000 mi	Minor leak near the rear view mirror in heavy rain only. Turned out being a clogged sunroof drain tube. Unfortunately, they broke the windshield during the repair, so it took 5 days (ordering new heated windshield). Otherwise, the leak would have been fixed during scheduled maintenance.

Volvo XC90 in New Jersey, United States Nov 2015 - Aug 2018
Oct 2015 4405 mi	Center console screen, not starting up. updated software
Dec 2015 7966 mi	Horn muted, replaced horns
Apr 2016 14446 mi	brakes still squealing, checked again okay
Mar 2017 32595 mi	brakes are squealing all the time - replace rear rotors & pads Rear tire loosing air - small leak fixed
Sep 2017 42890 mi	High pitch sound from engine compartment Checked codes and confirmed found noise and replaced Oil Trap box.
Oct 2017 42970 mi	Car towed to dealer - Spark plugs & Pistons replaced and outlet charger hose replaced All gaskets replaced

Volvo XC90 in Virginia, United States Jul 2017 - Jun 2018
Oct 2017 30000 mi	Sunroof gasket kept snagging on other sun roof parts and pulling off...big time leak into car. Volvo replaced retractable glass entirely. OK now

Volvo XC90 in Texas, United States Oct 2016 - Dec 2019
Feb 2017 16000 mi	A/C stopped working, was due to software problems in the Sensus vehicle management system. Software reflash fixed the issue. Vehicle was vibrating when braking, due to warped rotors. Rotors were replaced at no charge. Minor body trim adjustments were made.
Sep 2017 21000 mi	A/C cut out again, dealer replaced A/C pressure valve to try to remedy the situation, along with another software update to remedy system rebooting.

Volvo XC90 in Germany Mar 2016 - Jul 2022
Aug 2017 16120 mi €140	Replaced rotors (warranty) but paid to upgrade pads (above warranty replacement). Seems like driving Autobahn speeds puts a bit too much heat on pads intended for US market so I asked for the Euro-spec pads. Software upgrade.
Dec 2018 30347 mi €200	Replaced worn rear brake pads.

Volvo XC90 in Bulgaria Nov 2015 - Jun 2022
Jun 2017 6200 mi	Replaced suspension parts under warranty.
Jun 2019 15500 mi $500	Broken hood opening lever replaced.
Jun 2021 18600 mi $500	Noise from dampers

Volvo XC90 in Utah, United States Aug 2017 - Sep 2017
Sep 2017 30000 mi	Supercharger seals failed. 2nd time it's been in for this problem.

Volvo XC90 in Maryland, United States Sep 2015 - Jun 2022
Jan 2022 85000 mi US $650	Replaced start/stop battery and main battery

Volvo XC90 in Delaware, United States Jun 2016 - Jun 2022
Apr 2021 48000 mi US $800	Replaced defective windshield wiper stalk assembly. Continuous warning message displayed on console for wiper failure

Return to top

Volvo XC90 in California, United States Apr 2016 - Oct 2020
Oct 2019 27000 mi	Dealer left cap on coolant reservoir untightened. Check engine light came on for low coolant.
Oct 2020 31000 mi	Electric rear axle motor failed. Replacement unit was recalled before repair could take place. Nearly three weeks to get car back.

Volvo XC90 in Vermont, United States Apr 2016 - Jun 2022
Dec 2016 6000 mi	Check engine light came on. Code for high voltage battery cooling problem. Volvo consulted and it was a software glitch with nothing actually wrong with car.
Sep 2017 10000 mi	Software update, driver's seat making clunking sound and seat back wobbled. They replaced a part. The seat back wobbles far less now. The clunk is a bit better. I think that there is still something not quite right. There is still a clunk coming from the thigh extension. I will ask next time the car is in for service.
Jul 2018 15000 mi	AC Drain line kinked. Backed up onto floor. Corroded some computer connections and fried the vision module. All replaced and fixed under warranty

Volvo XC90 in California, United States Apr 2016 - Jun 2018
Jun 2016 2000 mi	Volvo OnCall was not working. It took some time to upgrade the software to get it to work. Since this car does not have a spare tire, it's quite crucial to have OnCall work. Surprisingly it did not work off the door.
Jan 2017 7000 mi	"Brake Paddle Characteristic Changed. Service Required" message popped up while in normal driving condition. It turned out to be faulty booster & terminals. Repaired under original warranty. This type of repair could be expensive w/o warant.
Jul 2017 11000 mi	Foot motion sensor drew too much current when car was parking. It drained the battery in 2-3 weeks.
Apr 2018 18000 mi	Fix water leak through the seal of moon roof.

Volvo XC90 in New Jersey, United States Aug 2016 - Aug 2018
Aug 2017 8000 mi	Outdoor thermometer was inaccurate. Temperature sensor was replaced.
Feb 2018 10000 mi	Water leaked down from rear view mirror area. Appeared to be common problem, so was resolved quickly.

Volvo XC90 in California, United States Sep 2016 - Jun 2020
Jun 2017 10000 mi	The vehicle had a software update @ 10,000 miles to fixed some glitches in the infotainment system.

Return to top

Volvo XC90 in Alaska, United States Nov 2016 - Sep 2020
Dec 2018 6000 mi	The CEL had been lit up and I took the vehicle into the dealership, who performed an upgrade and cleared the codes.

Volvo XC90 in Virginia, United States Feb 2017 - Jul 2018
Apr 2017 14000 mi	Sunroof leaks, gasket came loose from glass
Jul 2018 35000 mi US $400	Squeal from right front. Dealer replaced front pads/rotors warranty TSB. Rear pads over half worn on one side, I paid to replace as tech said they wouldn't make next PM. I inspected used parts, really didn't like the wear pattern. I usually get far better wear; tech said hill hold and brake programming out of my control results in reduced friction material life. Now front squealing again; IR temp gun showed 40 degree delta between right and left rotors after commute. Car now back at dealer.

Return to top

Volvo XC90 in Washington, United States Nov 2017 - Feb 2022
Feb 2018 50 mi	Leaking Windshield washer fluid. Was repaired under Volvo Certified Pre-Owned warranty.
Feb 2022 112000 mi US $320	Replaced the front brake pads and front rotors.

Return to top

Volvo XC90 in Texas, United States Sep 2017 - Sep 2018
Mar 2018 157000 mi US $750	Vehicle had slight vibration, had all worn engine mounts replaced
Jun 2018 159000 mi US $600	Low coolant message...discovered a leaking gasket on the rear engine water pipe. Replaced pipe and gaskets. Also replaced one oxygen sensor that was damaged during the repair.
Sep 2018 163000 mi US $800	Check engine light since previous repair...consistent P0420 code for bank one catalytic converter and an intermittent P0430 for bank two. Replaced both cats with aftermarket units.

Return to top

Volvo XC90 in Virginia, United States - Jul 2014
Jul 2014 13000 mi US $360	Inside right rear door handle would not open the door from the inside. This was fixed in one day, at no cost. Covered under warrenty.

Volvo XC90 in Illinois, United States Apr 2021 - Jan 2022
Jan 2022 136000 mi US $900	Both front stablizer links

Volvo XC90 in Colorado, United States Jun 2018 - Jul 2019
Sep 2018 97054 mi US $20	Coolant expansion tank was leaking - replaced with aftermarket part

Return to top

Volvo XC90 in North Carolina, United States - Nov 2011
Jul 2011 17500 mi	Front brake asemblies feel loose. Front brakes make a lot of groaning noises just as the vehicle comes to a full stop. Dealership Service Associate stated that this is normal for all XC-90s. I think it's very weird and abnormal.
Nov 2011 22500 mi	Removed front brake assemblies and applied silicon grease to required areas. This corrected the noisy popping sounds thta occurred while braking during left and right turns

Return to top

Volvo XC90 in Kentucky, United States Jun 2017 - Jun 2018
Aug 2017 134000 mi US $200	AC intermittent failure. Took weeks to diagnose as failing battery.

Volvo XC90 in Quebec, Canada Jun 2017 - Jul 2018
Jul 2017 86800 mi C $1000	Altenator changed
Sep 2017 87420 mi C $500	Fan works from time to time. Fan replaced.

Volvo XC90 in Pennsylvania, United States - Jul 2017
Jul 2017 60000 mi US $550	Rotors

Return to top

Volvo XC90 in Great Britain Apr 2012 - Sep 2013
Nov 2012 33100 mi	Sensor on engine management in exhaust system
Apr 2013 37000 mi	Gear lever front button cracked in half. Lever completely replaced.
Jun 2013 40000 mi	Passenger door mirror loose, replaced under warranty Alarm kept going off movement sensor replaced
Aug 2013 42000 mi £5	Swirl arm replaced common fault alarm sensors replaced under warranty
Sep 2013 44000 mi £360	Haldex unit motor failed replaced 60% paid by Volvo

Return to top

Volvo XC90 in Great Britain Mar 2010 - Dec 2013
Sep 2013 54000 mi	Replacement turbo pipe

Return to top

Volvo XC90 in Great Britain Jun 2013 - Jun 2022
Feb 2018 44000 mi £350	Both front wheel bearings replaced as had become noisy
Jun 2018 46000 mi £125	Split in the hose to the turbo. Car went into 'Limp Mode'.

Return to top

Volvo XC90 in Great Britain Mar 2010 - Mar 2020
Apr 2012 17200 mi	Loose bolt
Mar 2013 28000 mi	Clutch occasionally slipping due to electrical fault. Update: clutch fine.
Dec 2013 36000 mi	DPF blocked
Dec 2014 49000 mi £180	Front wheel bearing
Sep 2016 96000 mi £450	Turbo lower housing cracked
Dec 2017 148000 mi £170	Battery failed and replaced

Volvo XC90 in Great Britain Dec 2009 - Jun 2011
Dec 2010 10000 mi £400	Issue with the radio and RDS - flashed the IC to resolve

Return to top

Volvo XC90 in California, United States Sep 2015 - Jan 2022
Jun 2018 108692 mi US $465	Replace two front tires as one had unrepairable screw in the sidewall.

Volvo XC90 in Washington, United States Oct 2021 - Jun 2022
Jan 2022 74000 mi US $140	Fuel pressure sensor replacement.

Volvo XC90 in Arizona, United States May 2010 - Aug 2011
Jun 2010 1000 mi	compass/mirror replaced - compass not functioning
Jul 2010 1700 mi	oxygen sensor wiring rubbing against fan needed to be replaced, was sheared
Jun 2011 19000 mi	front seat massagers, air conditioned seats not functioning. re-routed wires and replaced fuse.
Aug 2011 24000 mi	Power side mirrors non-functioning, mirrors loose. When dealer closed mirrors after maintenance service to wash car, they did not re-engage upon opening. Have to close, re-open, close, re-open to have it re-engage and lock in place.

Return to top

Volvo XC90 in Texas, United States Jul 2013 - Sep 2015
Apr 2015 130700 mi US $350	Replace engine mount

Volvo XC90 in California, United States Sep 2011 - Sep 2013
Jan 2012 16200 mi	Climate control module replaced.

Volvo XC90 in Oklahoma, United States Apr 2016 - Mar 2021
Apr 2018 122000 mi US $1300	Compressor failed and had to be replaced.
Mar 2021 180000 mi US $2000	Throttle sensor failed

Volvo XC90 in Florida, United States Dec 2009 - Jan 2018
Jan 2011 12000 mi	leather issue
Apr 2012 23300 mi	Sun roof mechanical problem
Jul 2013 32800 mi	Front door speakers replaced. Not working as designed originally.
Oct 2013 37000 mi	Door was making noise. They changed the connecting piece. Door was making noise. They changed the connecting piece.
Aug 2014 45000 mi	Bulb Tail Lamp Replace Pump Break Oil Leak
Sep 2014 46000 mi	Module Steering Angle Sensor replaced Moldings discolored. Replaced. Right rear door handle loose. Replaced.
Jan 2015 47000 mi	Rear wiper motor replaced due to screeching noise.
Jul 2015 50200 mi US $180	Control Valve replaced
Feb 2017 70000 mi US $190	New Battery

Volvo XC90 in Connecticut, United States Oct 2015 - Apr 2017
Nov 2015 80700 mi	Dashboard interior lights not working. Also drivers electric window not operating correctly and incorrect warning light on dashboard. Required replacement of ECN Board. Paid by Dealer as withing 3 month warrenty (~1000 GBP)
Jan 2016 82300 mi	Parking brake issues. Failed MOT twice as dealer unable to correct until 3rd attempt.

Volvo XC90 in Alabama, United States Feb 2010 - Nov 2020
Mar 2018 80000 mi US $600	Replace one wheel bearing.
May 2018 81000 mi US $1200	Replace front brake pads and rotors.

Return to top

Volvo XC90 in Georgia, United States Dec 2009 - Apr 2012
Feb 2010 7700 mi	Rear door not closing properly. Door removed and reset but still not correct. Carpet lifting Rear door not closing properly
Jun 2011 23000 mi	Car Stalled on acceleration. Could not duplicate. Stability control warning light. Replaced sensors and computer module
Aug 2011 25800 mi	Tilt steering wheel would not lock
Dec 2011 30000 mi	doors not unlocking with key fob

Volvo XC90 in New York, United States Dec 2009 - Jan 2013
Apr 2010 6700 mi	Blind spot indicator on passenger side does not work all of the time.
Jan 2011 20000 mi	Rear passenger seat did not fold down, mechanism in the seat was defective from delivery.
Mar 2011 21000 mi	Rear windshield washer nozzle did not work.
May 2012 44400 mi	Engine vibration while in drive. Most noticeable at a stop.

Volvo XC90 in Illinois, United States Dec 2009 - Feb 2013
Apr 2010 6000 mi	Car still pulls to the right. Mechanic says he has fixed it. Now after the TSB, the front end is popping when car is turned to the right.
May 2010 8000 mi	car pulls to right. After dealer tried to fix the problem , which he never did to my satisfaction, the front end started to pop when turned to the right.
Jun 2010 8000 mi	Car pulls to the right and the has an intermittent popping sound when slowing and turning to the right. Volvo regional rep drove car and said it did not pull and the car did not make any popping sounds when he drove it.
Jul 2010 9000 mi	Popping sound in the front end when turning and braking
Sep 2011 29000 mi	Right suspension piece had to be order and then replaced on the car
Nov 2011 35000 mi	Car has always pulled to the right and the brakes have started popping again when applied during a turn
Dec 2011 37000 mi	Popping sound from the front suspension when making slow turns while braking.
Apr 2012 42000 mi	Right rear wheel bearing had to be replaced
Sep 2012 51000 mi	popping sounds in the shocks popping sounds in half drive shafts
Dec 2012 55000 mi	Front end popping. This has been a continuous issue with the car. Popping happens with you slow down and turn and hit the brakes.

Volvo XC90 in Pennsylvania, United States Jul 2010 - Sep 2017
Jan 2011 8000 mi	WHEN TURN SIGNAL SHUTS OFF THE STALK BOUNCES UP AND CHANGES MESSAGE BOX TO NEXT MESSAGE. TECH NOTED INTERNAL FAILURE WITH TURN SIGNAL SWITCH. TECH REPLACED TURN SIGNAL SWITCH.
Apr 2013 29300 mi	Left rear shock replaced.
Oct 2014 41000 mi	Replaced clockspring Replaced clockspring
Aug 2016 57700 mi US $170	A/C recharged

Volvo XC90 in New York, United States Jun 2021 - Jun 2022
Mar 2022 84000 mi US $300	1. the hydraulic struts for the rear gate were replaced 2. the interior sunroof cover guides had to be replaced 3. passenger side headlight had to be replaced

Volvo XC90 in New York, United States Jun 2010 - May 2018
Feb 2013 16500 mi	I've got traction control warning in dashboard and took it to service to be fixed.
Oct 2017 69000 mi US $5000	[brakes?]

Volvo XC90 in Minnesota, United States Jul 2016 - Oct 2017
Sep 2017 112000 mi US $315	Collapsed Dog Bone Engine Mount
Oct 2017 112593 mi US $850	Replaced steering angle sensor.

Volvo XC90 in Massachusetts, United States Apr 2017 - May 2018
Jan 2017 96888 mi US $500	replaced rear shocks
Jan 2018 106000 mi US $200	replaced sticking seatbelt and latch for driver

Volvo XC90 in British Columbia, Canada Aug 2013 - Mar 2017
Jun 2014 58280 mi C $3000	Read - Reed(?) bearing failure.

Volvo XC90 in New Jersey, United States May 2013 - Apr 2016
Apr 2016 64000 mi	water under floor mats

Return to top

Volvo XC90 in Taiwan Apr 2010 - Jun 2011
May 2010 3720 mi	oil leakage from engine oil filter base

Return to top

Volvo XC90 in Georgia, United States Jun 2015 - Mar 2020
Sep 2015 114000 mi US $225	Engine mounts

Volvo XC90 in California, United States Jun 2015 - Jun 2018
Sep 2015 67350 mi US $210	Power steering fluid very low,replaced with dye added, no leaks found.

Return to top

Volvo XC90 in Illinois, United States Jun 2017 - Jul 2022
Aug 2017 120000 mi US $1000	AC Fan/Blower motor finally died, 350part+650labor (10h).
Dec 2017 124000 mi US $250	Replaced 2 front stabilizer links on each side.
Jun 2018 127000 mi US $1470	Replace AC compressor and recharge AC system with freon. 2 front struts and strut mounts

Volvo XC90 in Ontario, Canada - May 2013
May 2013 47740 mi C $770	control pump leaking - replaced under extended warranty

Volvo XC90 in Virginia, United States Jul 2018 - Jul 2018
Mar 2018 46000 mi US $150	Blower motor bearing went bad, replaced blower motor.

Volvo XC90 in Maryland, United States Jun 2018 - Jun 2022
Sep 2021 174000 mi US $500	I had them change out the switch for the compressor and they also fully charged the system as well as regular oil change. https://youtu.be/qX2sFkpmYZs
Mar 2022 176367 mi US $1300	drive belt, idler, tensioner replaced due to cracks and out of spec spark plugs replaced (carbon build up) power steering flushed oil change and tire rotation

Return to top

Volvo XC90 in Hawaii, United States Sep 2011 - May 2014
May 2014 67000 mi	Dealer identified rotted/worn engine mounts and worn front tires. Sold vehicle to buyer who knew and accepted outstanding maintenance needs.

Volvo XC90 in Iceland Aug 2010 - Jun 2012
May 2011 23560 mi $200	Brake sensor stopped working
Jan 2012 29760 mi	cruise control

Return to top

Volvo XC90 in Texas, United States Jul 2010 - Apr 2017
Aug 2010 50000 mi US $270	Passenger airbag light came up. Dealer re-attached power connector under seat that got unplug.
Apr 2012 65500 mi US $200	Camshaft Position Sensor bank 2 not working. Replaced sensor with a new one. $66 for a new sensor and $120 + tax for labor.
Jun 2013 80000 mi US $620	Radiator cooling fan stopped working. Replaced with a new fan (genuine Volvo part).
Oct 2014 98500 mi US $1302	Replaced failed alternator with BOSCH Remanufactured unit, $908. Replaced broken right front engine mount (spring seat), $394.
Jan 2015 101500 mi US $1177	Power steering pump failed at 101,000 miles. Replaced pump with Volvo remanufactured unit. Parts: $627 Labor: $550 Replaced broken left front engine mount (spring seat) Parts: $48 Labor: $150
Sep 2015 110000 mi US $270	Install failing headlight switch. Parts: $220. Labor: $50.
Sep 2016 121000 mi US $120	Replace failed right front XENON Headlight bulb

Volvo XC90 in Wyoming, United States Mar 2010 - Dec 2014
Jan 2014 57400 mi US $285	AM quit working. Head unit contains AM/FM/NAV and connected by fiber optic. Repair required unit be sent to special facility with proper knowledge/equpt. Also over holidays so repair delayed. Vehicle back to me during repair.

Volvo XC90 in Washington, United States Jan 2012 - Feb 2012
Feb 2012 40000 mi	Backup sensors not working

Volvo XC90 in Virginia, United States Feb 2013 - Jan 2014
Mar 2013 52000 mi	Angle gear went bad. There was a lound clunking sound when turning during slow speeds.

Volvo XC90 in California, United States Mar 2011 - Sep 2016
Nov 2011 65300 mi US $2000	water pump Air conditioner
Jan 2014 70200 mi US $2900	compressor steering rack

Volvo XC90 in Pennsylvania, United States Jun 2011 - Aug 2017
Mar 2012 44000 mi	Clock spring in Steering wheel associated with the anti-skid braking system.
Sep 2013 66000 mi	Anti-Skid warning was displayed and dealer checked and replaced the clockspring and reprogrammed system.
Nov 2014 76000 mi US $700	Cooling fan failed to always come on when needed and needed to be replaced
Jan 2015 69700 mi US $600	Key ignition lock failed

Volvo XC90 in New Jersey, United States Jun 2010 - Jul 2011
Jul 2011 45000 mi	Multiple repairs over the past 2 months related to the tire pressure monitoring system. All unsuccessful, so terminated lease early.

Volvo XC90 in Washington, United States May 2016 - Dec 2016
Oct 2016 148000 mi US $30	Replaced headlight bulb

Volvo XC90 in California, United States Sep 2011 - Jul 2016
Jul 2014 110000 mi US $1500	Air conditioning needs to be fixed. Opted to wait.
Jul 2015 126800 mi US $1250	I had the ac blower replaced
Jun 2016 146000 mi US $300	Replaced shocks
Jul 2016 146000 mi US $60	Leaking AC coolant. Just added more for now.

Volvo XC90 in Washington, United States Mar 2009 - Jun 2018
Jul 2009 18000 mi	Front end clunking noise. Noise was coming from rear bushing front lower control arm. Replaced bolt/nut set both sides per TNN 61-10. Warranty repair
Jan 2010 25600 mi	Replace steering angle sensor module. Warranty repair.
Jan 2011 38000 mi	Front end creaking and clunking at low speed turns.
Oct 2013 71500 mi US $400	Front drive line spline at hub needed to be tightened and epoxied/locktited.
Jan 2014 74000 mi US $200	Passenger airbag system fault. Reset and tested, fault did not return.
Jun 2016 104000 mi US $1500	Leaking power steering line. Warning light. Required alternator replacement.
Sep 2016 106000 mi US $900	Ball joints
Jun 2017 116000 mi US $200	Drive shaft spline needed to be tightened.
May 2018 128000 mi US $300	Would not shift into Park. Worn interlock part in shift knob.

Volvo XC90 in Ohio, United States Sep 2011 - Jun 2014
Nov 2013 62000 mi US $1500	A/C delay in turning on passenger spring perch failed
Jan 2014 64500 mi	Grinding on start up and smoke from right front of engine
Mar 2014 67000 mi US $200	Starter needed to be replaced as it was hanging up on the flywheel Replaced A/C compressor again under warranty. Also replaced idler pulleys at the same time

Return to top

Volvo XC90 in California, United States Jan 2014 - Feb 2015
Jan 2014 88000 mi US $376	Replace Fuel Pressure Rail sensor
Mar 2014 91000 mi US $3040	3 Engine mounts replaced. Front right, and 2 hydraulic mounts.
Sep 2014 98000 mi US $493	AC out, broken connection. New wiring harness installed. Front left and right fog lamp bulbs replaced.
Jan 2015 US $1200	Replaced right rear signal housing and lower bulb.

Volvo XC90 in Florida, United States Nov 2011 - Jan 2012
Dec 2011 57000 mi US $100	Vibration during acceleration; Front right axle needed to be replaced

Volvo XC90 in Texas, United States - Feb 2008
Feb 2008 2000 mi	Ashtray in back seat replaced after falling out several times. Thumping noise after cold start at 18mph. Dealer said they repaired but it still occurs.

Volvo XC90 in Texas, United States Nov 2014 - Aug 2021
Dec 2015 114000 mi US $800	Both rear wheel bearings replaced.
Jan 2017 138000 mi US $88	I replaced the spark plugs. When I started the car, the check engine light came on and the car ran rough. I had a local mechanic look at it. It seems that I crossed the coil wires for the number 1 and 2 cylinders.
Jul 2017 148000 mi US $1600	The a/c compressor was replaced

Volvo XC90 in Florida, United States May 2009 - Mar 2015
Feb 2009 7300 mi	Driver's side rear reverse and signal lights enclosures started fogging/having water penetration. Dealer replaced enclosures and bulb (don't know which one) under warranty and I was told that the water penetration was caused by a crack.

Volvo XC90 in Georgia, United States Jun 2015 - Jan 2022
Jun 2016 145000 mi US $400	New AC compressor, dryer and recharge
Aug 2016 148100 mi US $140	PCV system was clogged and needed replaced
Dec 2016 156000 mi US $130	Replaced battery
Sep 2017 163000 mi US $55	Cracked coolant reservoir and hose

Return to top

Volvo XC90 in Wisconsin, United States Mar 2010 - Apr 2017
Nov 2013 57000 mi US $650	replace water pump

Volvo XC90 in California, United States Mar 2010 - Jun 2022
Nov 2014 65000 mi US $600	Ignition key lock did not turn anymore and was replaced. First temporarily repaired by AAA, had to use a screwdriver as a key for a couple of days.
Nov 2017 86000 mi US $400	door handle side cover lose

Volvo XC90 in Michigan, United States Jun 2010 - Jan 2014
Sep 2012 58000 mi US $700	Bearing malfunction on the rear wheel.
Jan 2014 58000 mi US $450	Powerlock on driver's side won't work. Powerlock motor was replaced.

Volvo XC90 in California, United States Jan 2010 - Oct 2011
Jan 2010 15000 mi	warranty repair to lower front control bushings
Nov 2010 29800 mi	Creaking of front suspension at slow speed turn. Replaced left front upper strut bushing.
Oct 2011 42000 mi	Left rear shock failed, leaking and noisy

Volvo XC90 in Connecticut, United States Nov 2011 - Mar 2015
Jan 2012 30000 mi US $120	lof hard starting

Volvo XC90 in Washington, United States May 2010 - Jul 2018
Jun 2011 35000 mi	Driver side plastic power seat side panel switch housing cracked on top and was replaced under original warranty
Jul 2018 79060 mi US $6	Replaced broken plastic strap that connects gas cap to vehicle

Volvo XC90 in Connecticut, United States Jun 2010 - Sep 2012
Sep 2010 13000 mi US $145	Broken LCD for DVD's, broken vent fins, stuck center console storage door. Stuck CD changer.

Volvo XC90 in Connecticut, United States May 2014 - Sep 2015
Apr 2015 79700 mi US $500	needed a gas cap. $34 part, but I was charged $120 by dealer for computer diagnosis of "check engine" light Belt tension pulley very slight oil leak. bad seal on vacuum

Volvo XC90 in Ohio, United States May 2015 - Feb 2018
Jun 2015 119000 mi US $1000	Steering angle sensor replaced
Oct 2017 151000 mi US $100	I completed the repair myself. Alternator Decoupler Pulley Loud noise that dealer was unable to diagnose.

Volvo XC90 in Connecticut, United States Oct 2011 - Jan 2014
Aug 2012 67700 mi US $60	Seldom message " Anti-skid service required" diagnostics during regular oil change
Aug 2013 77000 mi US $468	check engine light Steering sensor replacment Driver door rubber trim loose message Anti-skid service required is gone now Drivers door rubber needed to be glued-in
Dec 2013 81000 mi US $16	Could be a corrosive contact, but greased and replaced low beam lightbolb anyway

Volvo XC90 in Oregon, United States Mar 2008 - May 2010
Nov 2008 13900 mi	Faulty CEM

Volvo XC90 in Iowa, United States Oct 2014 - Jun 2018
Oct 2017 159000 mi US $350	Oil box needed rebuilt
May 2018 165000 mi US $150	Replaced bushings in front and rear of SUV

Volvo XC90 in Minnesota, United States Nov 2017 - Feb 2022
Feb 2018 118000 mi US $2800	Replace fuel pump rebuild main computer.
Jun 2018 122000 mi	Fuel pump went bad again. Replaced with a better one.
Jan 2022 160000 mi US $500	A coil burnt out because of bad spark plug. Replaced 1 coil and all 6 spark plugs.

Volvo XC90 in New York, United States Dec 2014 - Jan 2016
Jul 2015 119700 mi	Headlight out. (MK estimate)
Jan 2016 128000 mi US $35	The right headlight burnt out twice. The left headlight burnt out once.

Volvo XC90 in Washington, United States Jan 2014 - Sep 2017
Feb 2014 67700 mi	DVD player behind front passenger seat head rest stopped working. Since it was still under warranty, Volvo paid for it.
Mar 2014 69000 mi	Heating fan stopped working which caused Volvo to overheat. Since it was still under warranty, Volvo replaced it.
Jun 2015 84000 mi	Passenger front window glass would not close properly, going up and down. Not fixed. I still need to bring it back to the dealership to have it done (again). Update: problem later went away on its own.

Volvo XC90 in Ontario, Canada Jan 2012 - Jun 2022
Jan 2012 65999 mi C $425	Lock cylinder would not go past position 1. Cylinder replaced by dealer under used car warranty
Dec 2014 98580 mi C $389	Defective accessory belt tensioner replace tensioner, belt and idler pully
Jun 2016 114080 mi C $10	Alternator light, loud grinding/rubbing noise. Loose bolt on cupler pulley. Cleaned, tightened with locktite.
Dec 2016 120900 mi C $214	defective MAP sensor replaced
Jan 2017 95080 mi C $46	Passenger side mirror glass fell out.
Mar 2018 134540 mi C $1650	Water pump seized. Replaced water pump, thermostat, idler pulley, tensioner, serpentine bely
May 2018 136400 mi C $3200	No charging, Replaced Alternator, Alternator coupling, Rear accessory coupling. serpentine belt.
Aug 2021 149420 mi C $450	Rear calipers seized, replaced calipers, rotors and pads. Warning light ABS would periodically light up and clear a trip or two later

Volvo XC90 in Missouri, United States Dec 2012 - Nov 2015
Jun 2015 100000 mi US $200	Solenoid in valve body. Had to remove valve body and repair solenoid.

Volvo XC90 in Connecticut, United States Jul 2013 - Jun 2015
Apr 2014 71700 mi US $207	Very good service at Secor

Volvo XC90 in Hawaii, United States May 2014 - Aug 2017
Jan 2015 US $1890	Failed alternatator replaced. New battery installed.
Apr 2016 76300 mi US $350	replaced leaking gasket that was causing slow oil leak.
Dec 2016 86000 mi US $14	Broken windshield wiper hose coupling. Replaced myself. Cost of coupling was $14 at dealership.
Aug 2017 94400 mi US $1000	All new rotors and pads. Fuel rail pressure sensor replaced. Loose bolt in Alternator drive shaft caused coupling to related parts to be destroyed, resulting in total failure of vehicle's electrical systems, as well as bad battery. Alternator itself was fine. Bolt, coupling gear, related belt, and vehicle's battery all replaced. Damage could have potentially been avoided when alternator was replaced in 2015 by different dealership technicians.

Volvo XC90 in New Jersey, United States Aug 2017 - Aug 2018
Nov 2017 131000 mi US $650	one way clutch at bottom of engine managed serpentine belt

Return to top

Volvo XC90 in Saudi Arabia Sep 2013 - Oct 2013
Oct 2013 59520 mi ﷼6000	I didn't complain about anything else than hearing a noise coming from the break area. When dealer checked the car they asked me to replace the suspension, breaks, parts of the engine, gear box as if I had destroyed the car! AC leakage

Volvo XC90 in Quebec, Canada Dec 2012 - Dec 2013
Dec 2013 69440 mi C $1100	Muffler had to be replaced

Return to top

Volvo XC90 in Netherlands Mar 2009 - Jan 2010
Jul 2009 28520 mi €30	Turbo hose showed signs of deterioration, replaced.

Volvo XC90 in United Arab Emirates Jan 2009 - May 2012
Aug 2011 58060 mi ¤1200	It has been a knocking when going over rough road at low speeds. It sounds like the knocking comes from the front right side of the car. Front LH & RH bushings have been replaced.
Dec 2011 66960 mi ¤700	Troubleshooting has been carried out to find out the knocking sound coming from the front wheel at low speed, finally they found the Insulator of the LH front wheel spring was damaged and causing this sound, same replaced, test drive done,OK

Return to top

Volvo XC90 in Great Britain Jun 2009 - Aug 2012
Jul 2009 18000 mi	Cracking suspension noise when going round corners
Sep 2009 21000 mi	recurring problem cracking suspension on cornering
Sep 2010 31000 mi	Cracking suspension noise when turning and braking

Return to top

Volvo XC90 in Alberta, Canada Sep 2009 - Jun 2011
Oct 2009 19840 mi	tire pressure sensor lost contact with computer. Warning reset, no other service performed.
Jul 2010 26660 mi	rear window was rattling. Dealership fixed it at no cost to owner rattling from drivers side rear window. Dealership corrected it with some felt tape.

Volvo XC90 in Texas, United States Sep 2009 - Apr 2012
Dec 2011 47000 mi	Steering electronic control module needed to be replaced.

Volvo XC90 in Virginia, United States Sep 2011 - Jun 2014
Oct 2011 31000 mi	Active headlights were not working well. Brought back to Carmax within 30 days. They brought it to Volvo dealer who re-calibrated them. They work great now.
Sep 2013 55000 mi US $767	Ignition Lock Cylinder lockup. Read about lots of other Volvo's with this problem, yet no recall.

Volvo XC90 in New York, United States Nov 2009 - Dec 2016
Oct 2010 53000 mi	Noise from wheel - Replace R/F wheel bearings
Nov 2012 81300 mi US $200	stabilizer link replaced
Jul 2014 99300 mi US $500	Rear backup sensor module replacement
Feb 2015 107000 mi US $35	replace TPMS valve
Jun 2015 112000 mi US $500	bad bearing
Jul 2016 122500 mi US $400	replace tie-rod end

Volvo XC90 in California, United States Mar 2010 - Apr 2016
May 2011 28000 mi	Sunroof and sunshade both not working smoothly. Internal parts were replaced to correct issue under warranty.
Jun 2011 28000 mi	Ignition lock, where one inserts key to start car, broke internally. This prevented key from turning. Unable to start car. Towed free to dealer through Manuf. roadside assistance. Repair took one day. Covered under warranty.
Jul 2013 45300 mi US $2400	Alternator went bad after only 7 years and 46k miles. They replaced several unrelated but required parts with it. I think a design flaw allowed it to burn out prematurely.
Aug 2014 52900 mi US $100	Headlights have gotten dull and yellow. I bought kit to restore plastic lenses (polishing them) and a film to protect them. Did work myself.
Mar 2015 58000 mi US $1100	Cooling fan and fan clutch needed replacing. Car overheated due to issue and needed towing to repair shop.
Jul 2015 59200 mi US $4500	Transmission failed. Apparently inherent in the design of transmission such that no one will repair, only replace with reconditioned unit from Volvo. $3500 for the unit itself. Seems ridiculous to me a transmission fails in 59k miles.
Nov 2015 60000 mi US $800	One of the main high pressure power steering hoses sprang a pinhole leak. Needed replacing and is in a difficult location so labor cost was high. Water pump belt drive loosened from previous repair (transmission).
Apr 2016 63000 mi US $20	Windshield washer fluid motor went bad.

Volvo XC90 in Colorado, United States Apr 2011 - Sep 2013
Sep 2013 66000 mi US $500	Vehicle started to hesitate when shifting gears. Normally between the lower gears. Volvo said that it is a known issue with this model and the only definite fix would be to replace the transmission at a cost of over $5,000.

Volvo XC90 in Colorado, United States Jul 2011 - Jan 2018
Sep 2011 48000 mi	new gas cap
Jan 2012 93300 mi	trans solenoid/valve
Mar 2012 55000 mi	window motor was sporadic
Feb 2016 103000 mi US $800	front suspension/strut mounts were making noise (torn rubber) were replaced and noise stopped
Dec 2016 112000 mi US $1600	starter/alternator died, replacing it required dropping suspension components and "updated" ducting
Sep 2017 118000 mi US $3400	replaced front struts and control arms

Volvo XC90 in Pennsylvania, United States Jul 2010 - Jul 2018
Sep 2011 38000 mi	Gas cap leak caused emission light. Tech damaged spring that pops gas cap. Scheduled return for repair.
Oct 2011 39300 mi	Repaired damage dealer did when replaceing gas cap. Repaired damage dealer did when replaceing gas cap
Feb 2015 60000 mi US $725	Door control module for locks, mirrors, windows, etc left door
Jul 2015 60300 mi US $305	emission from fuel tank recirulating blower

Volvo XC90 in Maryland, United States Apr 2010 - Mar 2016
Dec 2014 68000 mi US $900	Muffler replaced Plastic frame around driver's seat cracked
Sep 2015 74000 mi	Got warning light: Antiskid service required. Determined that the Differential electronic module failed and got it rebuilt by a company in Canada

Volvo XC90 in Michigan, United States Jul 2011 - Aug 2011
Aug 2011 48000 mi US $1300	FEAD belt broke due to degraded tensioner pulley. Replaced tensioner pulley and accessory pulley. Replace passenger side front ball joint that was loose. FEAD belt broke due to degraded tensioner pulley. Replaced tensioner pulley and accessory pulley. Replace passenger side front ball joint that was loose.

Volvo XC90 in New Jersey, United States Feb 2008 - Jun 2017
Feb 2010 47000 mi	Insert key into ignition, was able to turn key to position 1 but could not turn it any further. Ignition lock had to be replaced.
Dec 2010 55000 mi US $500	noise & vibration with steering....resevoir replaced due to some kind of debris in it.
Sep 2012 76000 mi US $1000	Electric engine cooling fan failed causing the car to overheat.
Jun 2013 85000 mi US $1000	temp sensor a/c recharge
Jul 2014 97300 mi US $400	The shift lever button fell out and the shifter locked in place
Mar 2016 118000 mi US $200	4wd transfer case shot

Volvo XC90 in Texas, United States Dec 2007 - Sep 2015
Jul 2009 18000 mi	vibration during acceleration; right front axle replaced, problem corrected.
May 2010 26900 mi US $400	Vibration during acceleration; left front axle replaced. Right axle replaced previously for the same issue. Volvo looks down on doing both at the same time for some reason.
Jan 2012 27200 mi US $1500	Replaced angle gear for AWD system and left front axle. Also replaced oil temp sensor for rear diff.
Oct 2013 54000 mi US $1100	Slow cranking, starter replaced.
Sep 2015 72000 mi US $7712	The trans cooler failed and coolant contaminated the trans fluid and cooked my transmission to the tune of $7700 for a new transmission and radiator.

Volvo XC90 in Alabama, United States Nov 2009 - Mar 2015
Dec 2009 36000 mi US $200	Noticed washer fluid leaking out. turns out is was the pump for the fluid. Warranty replacement.
Aug 2014 78400 mi US $275	Replaced shifter lever because car wouldn't shift into park

Volvo XC90 in Georgia, United States Dec 2008 - Mar 2013
Mar 2009 27000 mi	Suspension bushings replaced in front.
Sep 2009 37000 mi	fuse blew to 12V power source
Feb 2010 40300 mi	Both front struts replaced. Making noise
Apr 2012 81000 mi US $300	Mp3 player connection went out on radio
Mar 2013 91000 mi US $350	Ball joints needed to be replaced

Volvo XC90 in Connecticut, United States Jan 2009 - Aug 2012
Jan 2010 22200 mi	Heat shield became loose and was hitting the drive shaft. Remote key fobs intermittently would not unlock doors. Other remote functions worked correctly but the unlock button on both remotes would not function. Dealer replaced one remote and re-synced remotes with car.

Volvo XC90 in California, United States Nov 2011 - Mar 2015
Jun 2012 66000 mi	Front end developed a popping sound when steering in reverse.
May 2014 90400 mi	Alternator failed, replaced under Volvo CPO programme

Volvo XC90 in Wisconsin, United States Jan 2008 - May 2008
Mar 2008 8000 mi	Defective compass in rear view mirror.
Apr 2008 8000 mi	Power seat moves on its own. Lockup of climate controls and radio. Ongoing compass issue. Still not resolved.

Volvo XC90 in Minnesota, United States Feb 2009 - Mar 2010
May 2009 34000 mi	Rear differential control unit malfunctioned, which disabled the AWD system. The control unit needed to be replaced, and the software reflashed. Console cupholder was not opening and closing smoothly. Dealer replaced assembly. Driver side door speaker was making a loud humming noise. Dealer replaced speaker. Exterior left rear window trim piece was loose. Dealer ordered replacement parts.

Volvo XC90 in Alberta, Canada Feb 2009 - Jun 2022
May 2010 38440 mi	AWD had not been functional for some time. Problem diagnosed and new part replaced in 45 minutes.
Aug 2013 74360 mi C $1100	Moonroof exploded while driving at highway speed. The shield that protects the fuel lines under the chassis fell off and required replacement. Anti-skid service warning light came on and remained on for several days. The dealership diagnosed the issue as a faulty DEM but before it was replaced, another shop determined that the issue was a poor electrical connection.
Mar 2014 77500 mi C $1150	Rear shock replacement
Nov 2014 85560 mi C $1800	The "anti-skid service required" message was a defective DEM related back to the water damage that triggered the earlier DEM diagnosis that was never repaired and thought to only be an electrical connection issue! Used Xemodex rebuilt DEM.
Jun 2016 107260 mi C $15	Replace low beam headlamp
Mar 2017 117800 mi C $450	The idler bearing and serpentine belt required replacement.
Feb 2019 142600 mi C $2700	What was originally suspected to be a battery issue was actually a faulty alternator.
Apr 2022 161200 mi C $4400	Rear end noise. Suspected rear wheel bearings, AWD or differential. Had a local garage remove/replace the differential. The actual bearing and seal replacement done by a specialty shop.

Volvo XC90 in California, United States Apr 2008 - Apr 2011
May 2008 31000 mi	Software reflash for active xenon lights and 30k mile service. I think this is a TSB and not a recall since I did not know about it until I got to the dealer and have not seen any info on swedespeed about this either.
Apr 2009 51000 mi	Cracks in finish of Sapeli wood steering wheel (cosmetic defect). Cup holder cover (between front seats) was sticking, which is a common XC90 problem. Both replaced under warranty. LOF ahead of schedule to find any problems before warranty end (50k).
Jul 2010 83000 mi US $100	Rear door (driver's side) lock module replaced. The door could not longer be opened from inside the car. Could only be opened from the outside. What a P.I.T.A. Can't remember exact part. Tech found worn steering system bushings as part of the multi point inspection as part of the LOF. Replaced under Volvo's VIP warranty fixed at the same time as the lock module replacement (problem 1 of Trip 1).
Apr 2011 97000 mi US $100	Bushings in steering / suspension for the front wheels. This would have been a $1200 if I didn't have the extended warranty (only had a $100 copay).

Volvo XC90 in New York, United States Sep 2009 - Jan 2022
Oct 2009 23000 mi	noisy rear wiper motor. water leak in rear tail light, housing replaced
Dec 2009 24000 mi	Anti-skid fault - replaced steering wheel angle sensor Rear parking sensors sometimes malfunction causing a constant beep like something is right against car, but nothing is there. Problem present since early in life this time replaced wiring harness, everything has been replaced except computer control replaced wiring harness for tail light, which was real cause of the leak in the tail light (housing was previously replaced)
Nov 2010 31000 mi	Rear parking sensors sometimes malfunction causing a constant beep like something is right against car, but nothing is there. Problem present since early in life this time replaced computer, everything in system has been replaced. Rear parking sensors sometimes malfunction causing a constant beep like something is right against car, but nothing is there. Problem present since early in life this time replaced computer, everything in system has been replaced
Jul 2012 48700 mi US $100	Brake light switch failed
Mar 2013 55000 mi US $150	replace drive belt idler pulley (and drive belt as preventive maintenance)
Mar 2014 64000 mi US $1400	Power steering pump failure oil leak
Feb 2015 73400 mi US $280	Broken engine mount
Mar 2015 74000 mi US $890	Alternator was replaced
Feb 2016 83600 mi US $500	Replace clock spring in steering wheel
Apr 2016 84200 mi US $600	Replace valve cover seals
Sep 2016 86000 mi US $500	replace leak detection pump
Sep 2017 92000 mi US $799	Repaired haldex AWD pump and computer (pump sized causing too much current in computer control circuit)
Mar 2018 94000 mi US $150	Fuel leak - fuel filter seam had opened, replaced fuel filter
May 2019 99000 mi US $700	Idler pulleys and belts
Jun 2020 105000 mi US $500	Replace both front bearings
Feb 2021 109000 mi US $500	Replace rear bearing

Volvo XC90 in California, United States Oct 2010 - Jun 2014
Jul 2011 43000 mi US $100	Bulb failed.

Volvo XC90 in Florida, United States Jan 2015 - Jan 2015
Jan 2015 80000 mi US $1800	Oil Leak and steering problems

Volvo XC90 in Alberta, Canada Jan 2014 - Jun 2022
Dec 2014 73780 mi C $1400	"ANTI-SKID SERVICE REQUIRED" in diagnostic window, resulting in only front-wheel drive. Active-on-demand (AOD) coupler (Haldex) oil pump, temperature and pressure sender, filter, coupler oil replaced.
Mar 2018 96100 mi C $4150	Idler pulley for the accessory belt seized and ended up tearing up the timing chain cover on which it was attached. Replaced items include timing cover, idler pulleys, belt tensioner assembly, accessory drive belt, an engine mount, and numerous gaskets.
Sep 2021 117180 mi C $500	"ANTI-SKID SERVICE REQUIRED" in diagnostic window, resulting in only front-wheel drive. Active-on-demand (AOD) coupler (Haldex) oil pump replaced. Same issue as was fixed 8 yrs previous.

Volvo XC90 in Ohio, United States Dec 2012 - Dec 2013
May 2013 77400 mi US $100	Key would not turn in ignition

Volvo XC90 in Quebec, Canada Jun 2013 - Dec 2014
Feb 2014 90520 mi C $4000	Faulty valve body, replaced transmission, 6 speed Aisin transmission
Mar 2014 92380 mi C $225	Top plates

Volvo XC90 in Texas, United States Oct 2008 - Jun 2015
Jan 2010 44264 mi US $461	broken switchblade ignition key replaced under warranty ECM software upgrade & mass air flow meter replaced under warranty after engine stalled.
Mar 2010 46000 mi	ECM software upgrade & mass air flow meter replaced under warranty after engine stalled. broken switchblade ignition key replaced under warranty
Sep 2012 65000 mi US $200	intermittent short caused misfires (chk enigne light) and vehicle hesitation. Repair was easy, once problem was identified, but that took a while. Intermittent issues are frusrating to track down.
Jun 2013 79000 mi	Car died in traffic. The fuel pressure sensor had been intermittently throwing faults for a couple of weeks before the breakdown. Also replaced alternator. And power steering pump.
Jul 2013 79800 mi	The A/C was feeling more anemic than usual. Last week, during the heat wave here, I had the coolant topped up, changed the in-cabin filter, and cleared debris from the condenser. So far the AC feels OK.
Jun 2015 108000 mi US $5800	Tranmission was acting wonky and failed completely a few days later. Dealer replaced Transmission. It failed. They replaced it again and it now seems to be OK. Hope so. Will be doing a long cross country drive soon. Axle replacement

Return to top

Volvo XC90 in Victoria, Australia Mar 2011 - Dec 2013
Apr 2011 50840 mi A $2116	replacment of faulty CEM Module
Oct 2011 54760 mi A $1052	The ignition system locked up without warning, meaning car could not be moved.
Mar 2013 64480 mi A $500	emission systems problem. Car lost all power and shut down. Towed to mechanic and part replaced.

Volvo XC90 in Louisiana, United States Sep 2010 - Jun 2018
Dec 2012 98000 mi US $250	Replaced right rear wheel bearing hub asm.
Feb 2014 122000 mi US $13	Replaced burned out low beam head light, $13 air wal-matr
Jun 2014 126000 mi US $950	Air takes a long time to get cool. A Volvo mechanic said this is a typical problem when AC compressor starts to fail. Replaced AC compressor and works like new. This is an expensive compressor.
Nov 2016 143500 mi US $400	Replaced flame trap box (engine making a loud squeal). Replaced upper torque engine mount (engine making a vibrating noise when accelerating).
Feb 2017 180000 mi US $450	Engine idler pulley broke and took out two other pulleys and drive belt.
Nov 2017 155000 mi US $120	Could not move shifter out of park. Replaced coil on shifter that would not allow shifter to move out of park (safety feature)

Volvo XC90 in Georgia, United States - Dec 2008
Dec 2008 22000 mi	SUV was shaking when put in overdrive, found out the front axle was broken, being fixed under warranty.

Volvo XC90 in North Carolina, United States Oct 2009 - Sep 2011
Jan 2010 US $240	Left rear HUB / axle boot making a grinding noise
Dec 2010 50000 mi	Problem with power locks on front passenger door

Volvo XC90 in Michigan, United States Jan 2008 - Sep 2015
Jul 2015 68200 mi	Ran Diagnostic ($100) and replaced battery ($250). Symptoms were "Check Engine, Reduced Engine Performace message". Clock was resetting. Car was running rough intermittently.

Volvo XC90 in South Carolina, United States Sep 2008 - Jul 2010
Oct 2008 26000 mi	Adjusted power steering belt/pulley to cure noise. Replaced cupholder door (would not stay shut).
Apr 2009 31000 mi	Slight oil leak due to faulty seal on drain plug. Problem appears to be fixed.

Volvo XC90 in Alberta, Canada Jan 2021 - Jun 2022
Aug 2021 127720 mi C $1800	Traction control system
Mar 2022 133920 mi C $450	Signal light switch was having problems

Volvo XC90 in Sweden Apr 2011 - Mar 2014
Mar 2012 34100 mi	diaphragm with oil/air breather, under warranty

Return to top

Volvo XC90 in Oregon, United States May 2018 - Feb 2019
Jun 2018 123000 mi US $195	Torque converter began to shudder, so transmission specialist decided to first replace very dirty transmission fluid.

Volvo XC90 in California, United States Mar 2009 - Aug 2015
May 2011 38000 mi US $400	"Anti skid service required" message. Problem caused by faulty steering angle sensor giving false error message. Can only be repaired by Volvo dealer due to proprietary software. Est. dealer quote to repair = $600. Opted not to repair.
Aug 2012 51900 mi US $309	Brought vehicle to dealer to diagnose "Anti-skid service required" alert indicator. Bad sensor would be $500, decided not to replace it.
Feb 2014 69000 mi US $60	Significant wheel alignment needed.
Aug 2015 83000 mi	ABS warning light remained on until sold, though never any other symptoms of a problem.

Volvo XC90 in Ontario, Canada Jan 2010 - Mar 2018
Sep 2012 68200 mi C $580	Left side bearing; needed the whole hub to be replaced
Jan 2013 71920 mi C $1500	Fuel pump suddenly dead on the road
Mar 2015 90520 mi C $600	Car broke in the street with steering becoming tough. Towed the car. Belt Tensioner Pulley & Poly Rib Belt replaced.

Volvo XC90 in Quebec, Canada Jan 2011 - Apr 2015
Nov 2011 C $1729	all wheel drive not engaging repld transmission pump winshield wipers ceased repld mechanism cost $260.00 xeon bulb and ballast burnt repld bulb and ballsast. cost $800.00
Oct 2012 81100 mi	gas gauge reporting completely empty, even though i know for a fact that it was half full.it did this maybe at least 4 times in a 2-3 week period. works after restart the car. check engine light came on and never came back after car restartd
Apr 2013 87300 mi C $323	check engine light came on solid..did a diagnostic volvo specialist determined it was the EVAC
Jun 2013 89900 mi C $1250	replaced both front wheel bearings and ball joint
Oct 2013 94020 mi	mechanic noticed oil leaking from engine. does not know from exactly where. hw recomends leaving car there overnight
Nov 2014 105760 mi	windsheild fluid not comming out
Apr 2015 109740 mi C $675	wipers ceased oil leak...repld main gasket. losing 1 liter of oil per 5 months

Volvo XC90 in Kentucky, United States Jan 2014 - Jun 2018
May 2014 81000 mi US $80	Replaced fuel rail sensor
Mar 2015 88000 mi US $395	brake vaccume assist leaking oil - needed rebuild kit
Dec 2015 101000 mi	required new front light - High Intensity - cost $175
Sep 2016 112000 mi US $35	DRIVERS SIDE PLASTIC BELOW SEAT BROKE AND PINCHING LEG UPON EXIT. REPLACED THE PLASTIC COVER. VERY QUICK AND LOW COST REPAIR
Sep 2017 118000 mi US $40	Plastic coolant tank broke where one of the hoses attach. Replaced with a new tank.

Volvo XC90 in Florida, United States Oct 2013 - Feb 2015
Sep 2014 98000 mi US $1400	replace left front wheel bearing

Volvo XC90 in Illinois, United States Aug 2010 - Jan 2021
May 2015 147300 mi US $1300	Replaced water pump, power steering pump and belt
Dec 2015 155000 mi US $795	Anti skid service requested light on. Replaced AWD pump
Jun 2017 185000 mi US $1500	Spark plugs and one coil

Volvo XC90 in California, United States Mar 2009 - Jan 2018
May 2015 91000 mi US $1000	Replaced a servo for the brakes had a light on sometimes.

Volvo XC90 in Massachusetts, United States Jun 2016 - Sep 2018
Aug 2016 75000 mi	Felt clunk from front suspension, dealer diagnosed worn front sway bar links. Links replaced, suspension now tight.
Sep 2016 77000 mi US $225	Car threw a CEL. Ran the code, and it indicated a faulty fuel pressure sensor. Replaced sensor.
Jun 2017 86000 mi US $450	Car exhibited clunking over bumps, shop diagnosed as worn front struts. Front struts and strut mounts replaced.
Aug 2018 102000 mi US $30	The hinge on the gas lid broke, leaving it prone to flopping open when unlocked. I purchased a replacement hinge and installed it.

Volvo XC90 in Arizona, United States - Oct 2007
Apr 2007 100 mi	purchase, warranty repair - a/c malfunction, constant clicking under booster seat addressed but not properly repaired.
May 2007 300 mi	warranty repair - unusual wear on paint finish around windshield- repaired, clicking sound still present.
Aug 2007 1400 mi	warranty - a/c portion of console freezing up, clicking under booster seat still present. Unable to duplicate either, no repair.
Oct 2007 3200 mi	warranty - upgraded a/c software, replaced parts on middle seat. Finally eliminated clicking.

Volvo XC90 in California, United States Dec 2007 - Jun 2014
Aug 2013 43000 mi US $750	Key would not turn past position 1. Could not start vehicle. Had to have it towed to dealership.
Jun 2014 46000 mi	TPMS light would periodically come on even though the pressures were fine. On when last had the car.

Volvo XC90 in Indiana, United States Jun 2012 - Jun 2014
Aug 2012 60600 mi US $959	vibration in front end, improper acceleration. Replaced FP PT.#30783079-4 oil pump, FP PT# 31325136. Parts $546.43,Labor $519.80. This included DV-10 vo srv coupon And DV-20 vo srv coupon.
Jun 2014 78000 mi US $1300	Exhaust pipe and muffler,cabin air changed and oil and oil filter changed

Volvo XC90 in Minnesota, United States Sep 2016 - Jun 2022
Jul 2020 199800 mi US $600	RF axle replace
May 2021 204000 mi US $2000	Replaced front control arms

Volvo XC90 in Virginia, United States Sep 2017 - Dec 2017
Oct 2017 132000 mi US $2900	2nd steering rack, rebuilt because new was 4 weeks out; leaking bad 1 cup per day expensive fluid. 1st rack lasted 8 months, original failed 2016. Replace Halidex (XEMODEX) DEM, pump, filter failed 1 yr ago, rear brakes (shoes & pads) rotors- all worn last replaced 4 years ago.
Dec 2017 135000 mi US $300	Replace bushings on tie rods

Volvo XC90 in Ontario, Canada Dec 2013 - Apr 2016
Jan 2016 C $150	Door needed adjustment.
Apr 2016 79360 mi C $300	Exhaust issue, nothing done, car sold to mechanic. The fix was estimated at $2500 if using volvo parts, or $900 if using aftermarket parts.

Volvo XC90 in Illinois, United States Dec 2007 - Dec 2009
May 2007 3420 mi	Main computer went out which cause all instrument reading to go out and then the car would not start. Covered under warranty- dealer kept car for 6 days
Mar 2008 10000 mi	Cigarette lighter not working.
Jan 2009 23000 mi	Popping sound in suspension when turning especially when applying brakes.
Feb 2009 24000 mi	Return to dealer for popping sound in front suspension. They retorque some system bushing and solved the problem.

Volvo XC90 in Ontario, Canada Nov 2012 - Sep 2015
Mar 2015 86800 mi C $900	Front and rear shock absorber

Volvo XC90 in Louisiana, United States Mar 2011 - Sep 2015
Mar 2013 95000 mi US $215	AC compressor replaced

Volvo XC90 in Illinois, United States Sep 2010 - Jun 2021
Oct 2010 30000 mi	car was brought in for 30k service and during last month of factory warranty. mechanic discovered vibrations during acceleration. they ended up replacing drive/axle shafts all under warranty.
Aug 2014 52800 mi US $1465	brought in for anti skid message. tech replaced steering angle sensor. different error codes appeared after test drive. tech now replaced dem pump, oil pump kit. replaced free under easy care extended warranty. during 52500 service, tech found brake vacuum pump leaking oil. replaced free under easy care extended warranty. during 52500 service, tech found brake vacuum pump leaking oil. replaced free under easy care extended warranty. brought in for anti skid message. tech replaced steering angle sensor. replaced free under easy care extended warranty. brought in for anti skid message. tech replaced steering angle sensor. different error codes appeared after test drive. tech now replaced dem pump, oil pump kit. replaced free under easy care extended warranty.
Jan 2018 79503 mi US $650	replaced variable valve timing solenoids OEM Part
Jun 2018 83438 mi	replaced all 4 position lights on rear.

Volvo XC90 in Virginia, United States Feb 2012 - Nov 2015
Mar 2012 88000 mi US $400	several electrical quirks with radio
Apr 2012 88300 mi	Climate control issues
Jun 2013 102000 mi US $500	Air pump leaking oil
Jun 2015 131000 mi US $850	Immoblizer problems

Volvo XC90 in New Jersey, United States Mar 2011 - Oct 2018
Jun 2013 57000 mi US $180	Vehicle burned 3 qts of oil since last svc. Low Oil warning message appeared. Eng leaking oil into cyl #6 between upper & lower sections of cylinder head. Eng needs to be opened up & anaerobic sealant needs replacement
Mar 2015 67000 mi US $100	Sway bar link failed and was replaced
Feb 2016 70100 mi US $370	Issue with low oil level
Oct 2016 76200 mi	Engine replacement Completion of engine replacement due to oil consumption
May 2018 86000 mi US $6400	Replace front struts and control arms

Volvo XC90 in Indiana, United States May 2012 - Feb 2017
Jun 2013 137000 mi US $200	Lower control arm bushings were replaced.
Jan 2015 162700 mi US $75	Front end vibration. Found "play" in outer tie rod ends. Replaced both sides.
Sep 2015 158000 mi US $500	Failure of electric cooling fan and high pressure A/C hose
Jan 2017 154200 mi	Short circuit in wiring harness causing battery drain. Repaired wire insulation.

Volvo XC90 in Massachusetts, United States Oct 2010 - Apr 2012
Apr 2011 39000 mi US $150	Driver's window not closing properly. It would close and then immediately open, again. Dealer took the door apart and fixed a bent part. Bill was for hourly work done.

Volvo XC90 in Ohio, United States May 2010 - Mar 2013
Oct 2010 50000 mi US $320	Tightened some suspension bushings that were causing noises below the front end of the vehicle.

Return to top

Volvo XC90 in New York, United States Dec 2007 - Mar 2010

Return to top

Volvo XC90 in Slovenia Nov 2009 - Mar 2010

Return to top

Volvo XC90 in Virginia, United States Apr 2014 - May 2015
Oct 2014 63300 mi US $2000	Big noise at the bottom. A part controling 4 wheel drive was broken and replaced.
Mar 2015 67000 mi US $400	Battery die. Alarm self alert without reason.

Volvo XC90 in Georgia, United States Mar 2009 - Mar 2010
Apr 2009 36000 mi	02 sensor
Dec 2009 50000 mi US $250	Front wheel bearing went out, was replaced. Corrected the problem

Return to top

Volvo XC90 in North Carolina, United States Jul 2010 - Feb 2014
Aug 2010 73000 mi	Driver door handle failed to open door.
Apr 2011 86000 mi US $50	Window switch auto-up function had to be reset. Low cost and low time.
Jul 2011 89000 mi	Driver door interior trim came unglued in heat and fell off.
Nov 2013 121000 mi US $1100	Control arm bushing failure. Remove and replace.
Dec 2013 123000 mi US $400	PCV system failure (clogged breather box) caused rough starting and poor idle.

Volvo XC90 in Virginia, United States Jun 2017 - Jun 2018
Jan 2018 130000 mi US $2200	Spark Plugs were replaced, battery and charging system were checked, CVVT Hubs and CVVT Solenoid replaced

Volvo XC90 in Georgia, United States Feb 2010 - Oct 2021
Mar 2010 43000 mi US $45	Creaking sound when slowly accelerating from stop.
Apr 2013 77700 mi US $480	Right and left engine mounts
Jan 2015 73700 mi US $400	Engine mounts
May 2018 152000 mi US $1550	AC Condenser was replaced and air box replaced.

Volvo XC90 in California, United States Jun 2008 - Dec 2012
Jul 2009 33000 mi	door lock malfunction speaker came ajar from driver door panel rear defroster window, some lines do not defrost Cup holder sticks Door handle paint coming off
Feb 2010 36000 mi	Front lights became cloudy. (Door handles lost paint - previously noted.) Loose interior panels, third row seat leather torn by reclining them--bad design. Not fixed because denied warranty coverage on them. Broken and misaligned air filter box not fixed because denied warranty coverage on it. Again, poor design.

Volvo XC90 in Georgia, United States Jan 2010 - Mar 2014
Jul 2010 55800 mi US $1500	Replaced gas fill door hinge.
Nov 2010 60000 mi US $850	60K service, plus replaced lift cylinders for tailgate.
Dec 2011 69000 mi	Windshield washer motor and nozzles replaced.
Jun 2012 72000 mi US $100	Replaced center console lid.

Volvo XC90 in California, United States Feb 2012 - Oct 2016
Oct 2016 56000 mi US $500	Replace parking brake components and up grade system

Return to top

Volvo XC90 in New Brunswick, Canada Feb 2010 - Jun 2015
Apr 2015 82140 mi C $500	Angle gear resealed and rear driveshaft coupler

Volvo XC90 in Quebec, Canada Mar 2011 - Dec 2012
Dec 2012 62620 mi C $823	low oil pressure

Volvo XC90 in Virginia, United States Sep 2017 - Sep 2018
Sep 2018 160000 mi US $18	Driver's side headlight was not working consistently

Volvo XC90 in Virginia, United States Feb 2010 - May 2015
Apr 2010 41000 mi US $452	Passenger's side door lock would not work (sounded as if there were a broken chain or linkage when the auto lock feature was engaged). Parts installed (or at least that was the description) and the issue has disappeared.
Dec 2011 69000 mi US $350	LR hub bearing replacement
Jul 2012 75700 mi US $600	Ball joint rubber, front left wheel, excessive wear required replacement or (told) wheel might off.

Volvo XC90 in New Jersey, United States Jun 2008 - Feb 2013
May 2010 46000 mi US $900	Front Wheel bearings replaced
Mar 2012 55000 mi	Intermittent start issues - thought it was starter - dealer removed it and found loose wire from fuse box to starter, cleaned and reattached wire - no more issues. Took less than 1 hour to fix.

Volvo XC90 in Illinois, United States Dec 2007 - May 2013
Feb 2012 72000 mi	Key stuck in the ignition. Ignition cylinder was replaced.

Volvo XC90 in Colorado, United States Jun 2008 - Jun 2017
Mar 2010 52000 mi US $360	Passenger door actuator died the day after the bumper to bumper warranty expired. Volvo agreed to $400 fix if I paid $100.
Dec 2010 63000 mi US $60	headlight replaced after two years of complaining about hazing. ripped off by dealer when they said car was CPO and had CPO warranty. Dealer didnt submit papers and says my fault!! next car not a Volvo.
Oct 2011 72500 mi US $500	Replaced sway bar end links and control arms because bushings were cracking. These items are known and common to this model. Had new tires installed and then got car alighted. Replaced coolant and spark plugs too.
Jul 2012 82500 mi US $2000	rear wheel bearings. front subframe bushings. rear rotors and pads.
Feb 2013 90700 mi US $550	ball joints - front
Nov 2015 122700 mi US $260	Replaced leaking front shocks with Sachs shocks
Jan 2016 123700 mi US $151	Drivers door open alarm goes off when signaling left, actuator and drivers window didnt work. it was not the actuator. was a broken wire in loom going to the drivers door. i replaced the actuator which was good. it is a wire going to door
Jun 2016 129000 mi US $615	Replaced control arm bushings
Feb 2017 134000 mi US $325	Drivers door actuator. Second time. Part under warranty from FCP. I will get credit for the part. Didnt believe it went after one year. Part was replaced last year when old one was still good. it was negative ground in B pilar.
Jun 2017 137000 mi US $265	CEL came on. Repaired something with the PCV. Sold the car the next day. Replaced it with a lower mileage XC90. New owner should have a lot of trouble free miles with the car.

Volvo XC90 in New York, United States May 2009 - May 2019
Oct 2009 44300 mi	Spring on fuel door broke and was replaced. Pinch sensor on window of driver's door malfunctioned and was re-programmed by dealer.
Jun 2011 62000 mi US $30	Faulty electrical connector on left low beam requires replacement. Left front sidemarker bulb also required replacement.
Jun 2012 75000 mi US $500	AC Condenser replaced due to leak.
Sep 2013 86000 mi US $90	AC compressor clutch retaining bolt fell out and clutch fell off AC compressor. Parts were reattached by mechanic and AC is operational. Repair took approximately 1 hour.
May 2014 94000 mi	Replaced worn rear shock absorbers
Sep 2014 95000 mi US $180	Faulty AC refrigerant temperature sensor replaced.
Jul 2017 110000 mi US $800	Torn intercooler hose caused hesitation and stumbling. Replaced intercooler hose, spark plugs and air filter.
Sep 2017 112000 mi US $1000	Oil leak. Replaced multiple gaskets. Problem was not fixed. I am living with it for now. My mechanic cannot find the source of the leak.
Jul 2018 120000 mi US $180	Engine was missing under acceleration. Coil packs and spark plugs were replaced.
May 2019	Leaking head gasket causing oil leak.

Volvo XC90 in Wisconsin, United States May 2009 - Mar 2010
Nov 2009 41000 mi	loose right front tie-rod

Volvo XC90 in Alberta, Canada Sep 2013 - Aug 2016
Dec 2013 119660 mi C $300	Suspected ETM fault traced to battery. Check engine light combined with reduced engine performance and service engine components messages. Independent garage cleared error codes which is causing problems.

Volvo XC90 in British Columbia, Canada Dec 2007 - Jun 2011
Jun 2008 19840 mi C $200	Original brake controller installation was done improperly by the dealership. Did not want to go back to the dealership since they treated me poorly the first time.

Volvo XC90 in Minnesota, United States Jun 2015 - Aug 2019
Feb 2016 130000 mi US $750	Mass airflow sensor and misfire code. Shop was unable to resolve. Replaced one wheel bearing.
Jun 2017 155000 mi US $300	Replaced electronic throttle body.
Sep 2018 169000 mi US $2000	previously, the banjo bolt had failed sending the BB into intake manifold (128,000 miles). Unable to properly diagnose, I drove for 40k miles with it idling like a diesel but running well at speed. Repair involved swapping engine with a known good from Volvo salvage yard while completing water pump/timing belt and PCV service on replacement engine.
Apr 2019 174000 mi US $600	alternator failed, replaced

Volvo XC90 in Pennsylvania, United States Jan 2015 - Jul 2022
Jul 2015 112700 mi US $1500	Loss of engine oil pressure-this was caused by a defective worn o-ring in pick-up tube from oil sump. Result was aeration of oil causing oil pump cavitation which resulted in oil pressure loss, low oil pressure. New Oil Pick-up reseal, clean
Mar 2017 136000 mi US $300	Replaced Front Brake pads and rotors
Jun 2017 141000 mi US $1200	Replaced front Angle Gear. AWD stopped functioning
Jul 2021 161000 mi US $60	Replaced stuck VVT valve and gaskets

Volvo XC90 in Virginia, United States Jan 2015 - Apr 2021
Aug 2015 102700 mi US $300	Sudden misfiring. Replaced coil pack.
Nov 2016 117000 mi US $800	Intermittent code for mass air flow sensor. No change in drivability. MAF replaced. Code returned one month later. Sudden loss of power, misfiring. Two coil packs broken. Replaced all 4 that hadn't yet been replaced. Also changed all spark plugs at this time, as was scheduled to be done at 120k anyway.
Mar 2017 122000 mi US $150	Interior driver door handle mechanism broken. Replaced door handle.
Jan 2018 132783 mi US $615	Replaced rear shocks, which had failed

Volvo XC90 in California, United States Sep 2011 - Jun 2022
Nov 2011 100000 mi US $350	left passenger window would not open, replace the regulator
Oct 2012 115000 mi US $270	Replaced both hatch gas springs Rear fog light Driver side, plastic seat control cover
Dec 2012 118000 mi US $600	Cracked air hose from crankshaft case tripped a sensor that sent a 042 "Engine System service required" message. Subsequent to fixing that the airflow sensor went off and the air intake + sensor were replaced.
Nov 2014 138000 mi US $200	Front passenger window won't close all the way
Sep 2016 163000 mi US $500	Wheel bearing, rear, driver side
Mar 2019 192300 mi US $4650	Total loss of engine power due to 1 cylinder going bad. Had to replace the engine block
Dec 2019 204700 mi US $688	Ignition coils replaced

Volvo XC90 in Kansas, United States Nov 2014 - Sep 2016
Dec 2014 61000 mi US $100	changed spark plugs, added power steering fluid, replaced deteriorated crankcase to oil trap hose, replaced cabin air filter
Jun 2016 82000 mi	Steering noise was found to be from incorrectly placed drive belt following timing belt replacement

Volvo XC90 in Pennsylvania, United States Mar 2014 - Apr 2017
May 2014 87200 mi	Replaced leaking transmission cooler.
Apr 2017 156000 mi US $85	Muffler bracket welded

Volvo XC90 in Michigan, United States Jan 2016 - Jun 2018
Jan 2016 207000 mi	Intermittent knocking sound from front suspension. Found brake dust shield was bent out of alignment. Straightened shield.
Jun 2018 244000 mi US $230	Replaced front brake rotors and pads Replaced passenger outer tie-rod end

Volvo XC90 in Massachusetts, United States Feb 2014 - Dec 2016
Apr 2015 111200 mi US $1100	No Oil Pressure due to sludge in oil pickup tube. Installed newly designed oil pickup tube and oil pump.
Sep 2015 116000 mi US $100	Right Rear HUB replaced ABS Sensor Replaced right rear
Feb 2016 118600 mi US $512	Left Wheel Beering replaced Emergency Brake Shoes replaced
May 2016 121000 mi US $350	Removed and repaired Rear Electronic Module and replaced. ABS and park assist warning lights came on. Also think it disabled AWD.
Dec 2016 229000 mi US $400	replaced front shocks, struts and tie rods

Volvo XC90 in New South Wales, Australia Dec 2012 - Jun 2018
May 2015 114040 mi A $4600	Engine oil leaks due to failing seals, due to clogged PCV system. Had PCV replaced and all engine oil seals. Failed engine mount.
Apr 2016 121820 mi A $1550	Engine mount need replacing, again
Sep 2017 136400 mi A $600	Control arms
Oct 2017 137020 mi A $1000	Starter motor failed

Volvo XC90 in Wyoming, United States - May 2010
Oct 2006	Dealer tried to trace faulty start issue with security system. Dealer could not replicate issue but reset computer and software. Problem never occurred again and the issue showed up in Vadis updates in 2010 as an issue.
May 2010 62000 mi US $585	Replaced vacuum pump and valve.

Volvo XC90 in Maryland, United States Dec 2016 - Jul 2018
Sep 2017 139000 mi US $110	Replaced the left rear wheel bearing again. First time was at 80k. Right side has been through two also. Bad design.
Oct 2017 142000 mi US $100	wheel bearing
Apr 2018 145000 mi US $250	windshield replaced
Jun 2018 148000 mi US $30	Use a lens repair kit on the headlights and got them almost perfectly clear!
Jul 2018 150000 mi	LF window would not stay up with the one-touch auto-up feature. Pulled fuse while operating the window down to reset the auto stop settings. Replaced fuse and ran window up and down several times while holding switch one way and then the other. The window now goes up with one-touch and stays up. Used gorilla glue gel to reattach lose moldings on left doors.

Volvo XC90 in Virginia, United States Feb 2014 - Jul 2018
Dec 2016 148000 mi US $840	cam gear seals leaking causing timing belt replacement. timing belt oil soaked.
Oct 2017 149000 mi US $200	replaced struts and stabilizer bar end links
Jul 2018 151000 mi	Replaced variable cam timing solenoid. 1st repair attempted with aftermarket part, replaced with oem part. Issue resolved.

Volvo XC90 in Nevada, United States May 2011 - Jan 2014
Jan 2013 49000 mi US $700	Heating system on driver's side INOP. Had to to replace heater. The heater was rarely ever used, so I'm disappointed this equipment failed!

Volvo XC90 in Ontario, Canada Jun 2010 - Aug 2011
Oct 2010 55180 mi	squeaking from driver's door. Rattle when using radio. Diagnosis indetermanent because unable to replicate problem.
May 2011 62000 mi C $400	Road noise proportional to road speed. Dealer diagnosed problem to transfer case. Stripped spline shaft; replace transfer case. Problem remains. Rediagnose at local mechanic. Identified bad wheel bearing; replaced. Problem resolved.

Return to top

Volvo XC90 in Great Britain Nov 2009 - Aug 2010
Apr 2010 74000 mi £320	Track rod end failure. Engine still has constant stutter at 70mph. No issue found by dealer. Going back in for cold start at dealership as exhaust manifold/turbo is leaking fumes when engine is cold...
Jun 2010 76000 mi	Rear wiper motor replaced.
Jul 2010 76000 mi	Rear prop shaft and transfer box replaced because of leaking seals.
Aug 2010 76000 mi	Prop shaft whining when traded car in. Started doing this after the repair.

Return to top

Volvo XC90 in Massachusetts, United States - Sep 2006
Sep 2006 100 mi	The power steering unit was leaking fluid. The Rack was replaced.

Volvo XC90 in Massachusetts, United States Jan 2009 - Mar 2012
Dec 2009 62000 mi US $175	GPS and Radio lost power and would reset.

Volvo XC90 in Pennsylvania, United States Feb 2010 - Jan 2017
Sep 2010 73200 mi US $400	transmission kicks occasionally, was suggested to update TCM software, kicks are still there...
Jan 2011 79000 mi	transmission would kick and get stuck in neutral, transmission service urgent light came on; transmission valve body was replaced; cost of $2400 was covered by the extended warranty
Nov 2011 99000 mi	rear bushings
Jul 2013 139700 mi US $100	Had oil warning light come on although oil level was good. Dealer fixed the warning. Check engine light is also occasionally on, but dealer couldn't identify the problem, no repairs were done.
May 2014 158000 mi	Replaced both front wheel bearings
Jun 2014 160000 mi	Replaced front struts and lower control arms
Feb 2015 172900 mi	Drive belt broke, replaced belt and pulley tensioner
Apr 2015 176700 mi	Replaced power steering pump replaced worn out bolt joins
Jun 2015 180000 mi	Replaced contact reel because anti-skid was not working

Volvo XC90 in California, United States Feb 2009 - Jan 2011
Mar 2009 48000 mi US $350	Fender liner deteriorated. Dealer, Volvo of Orange County CLAIMS owner ran over something to cause issue. Owner states he did not, in fact there would be scratches under the car if this happened. Dealership told customer "We don't owe him anything."
Jan 2011 78000 mi US $250	abs system lights on

Volvo XC90 in California, United States Dec 2009 - Sep 2016
Mar 2014 113000 mi US $165	Power steering fluid needed to be flushed.
Jul 2016 137000 mi US $700	check engine light. Fuel pressure sensor needed replacement.

Volvo XC90 in District of Columbia, United States Feb 2010 - Mar 2014
Jul 2010 63000 mi US $500	60,000 mile service and replace tie rod end.
Dec 2011 87000 mi	replace idler pully. $1300 with maintenance.
May 2013 108700 mi US $3000	replace tire, control arms, and align

Volvo XC90 in New Jersey, United States Dec 2011 - Apr 2014
Apr 2014 129000 mi US $1800	Needed a new alternator, Also needed new front brakes- pads and rotors

Volvo XC90 in Argentina Dec 2010 - Apr 2011
Jan 2011 47740 mi $100	One of the suspension support stuts broke whilst on holiday and took car to garage where they mended the part. I'm now awaiting a new suspension strut.

Volvo XC90 in Ontario, Canada Feb 2009 - Mar 2010
Mar 2009 17980 mi	Steering column replaced.

Volvo XC90 in British Columbia, Canada Jan 2009 - Jan 2013
Feb 2009 24800 mi	Bi Xenon headlights continue to readjust high and very low while driving. Seems to happen within the first 10 mins. of driving and when the headlight switch is not in auto position. Noisy lifters for 30-60 secs. when first started. Grumbling/whistling noise when A/C button is in auto and blower motor is on. Rear speakers would cut in and out. It was because Dolby Pro Logic was turned on while radio signal was not strong enough. Electrical acc. will turn on long before ignition switch is in 1st position.
Jul 2009 29140 mi	Spoke to mechanic directly with test drive and discovered the whistling/grumbling noise was the A/C compressor. clunking noise when backing out of driveway. replaced A/C compressor. replaced steering rack.
Sep 2009 29760 mi	torn door weather strip high pressure washers for headlights
Nov 2009 31000 mi	Squeaky rear window wiper motor. The squeak went away if used constantly for a couple of minutes. Dealer was very helpful about getting it fixed and ordered a new motor. Replaced wiper motor and washed car.
Dec 2010 41540 mi C $130	Bad bearing in Idler pulley for Serpentine belt. Replaced with new dealer pulley. Took one day for part to be ordered in.
May 2012 50320 mi	Drivers window would not stay up when the switch was used in auto. Reset the window by pulling the fuse while in operation, turned off key, then reinstalled fuse and rolled window up in manual and held it in closed for 10 sec.

Volvo XC90 in California, United States Jan 2008 - Jun 2015
Jul 2014 103500 mi US $300	Sensor in AC system replaced; AC recharged
Mar 2015 112000 mi US $400	Tailgate lock broken

Volvo XC90 in New Jersey, United States Dec 2007 - Jun 2013
Apr 2009 55000 mi US $600	new wheel bearings
Jan 2011 90600 mi US $50	replaced fuse for wipers
Mar 2011 95000 mi US $1500	wheel bearing, tire rods replaced rear axle replaced new bearings, rear axle, tie rods
Jul 2011 98000 mi US $200	A/c blower would turn off
Aug 2011 99000 mi US $4000	Replaced transmission

Volvo XC90 in Indiana, United States Dec 2006 - Mar 2010
Oct 2006 4500 mi	Power steering pump making loud noises. Radio speakers still cut out. Rear tire loses 20lbs. of pressure every other day. Blue tooth continues to hang up.
Nov 2006 5500 mi	Power steering pump making racket-see metal filings in fluid. Told it is a pulley, not pump. Wait two weeks for part. Rear tire continues losing pressure. Radio speakers continue to cut out
Dec 2006 7500 mi	Rear speakers continue to be problem-reported to Volvo Cust Service (car has been in 5 Times now for problem-including before I leased). Rear tire continues to lose pressure.
Dec 2007 7500 mi	Rear speakers cut out still. Been in 5 times for this (once before leased) Rear tire continues to lose pressure.
Jan 2008 21000 mi US $100	Second axle replacement-bearings.

Volvo XC90 in Saudi Arabia Aug 2008 - Jan 2014
Nov 2008 33480 mi	- Steering wheels tiking noise when turining - Damaged Rear Window Rubber Trim
Feb 2013 104940 mi ﷼1333	Change Steering Wheel Pump because of leakage...
Sep 2013 114700 mi	Gear Box Repair

Volvo XC90 in California, United States Jan 2009 - Apr 2014
Jun 2009 52000 mi US $250	Front passenger door lock does not work electronically, motor replaced at an independent Volvo repair shop.
Mar 2010 61000 mi US $400	Front control arm bushings cracked.
Feb 2014 78300 mi US $900	Drive/Serpentine Belt Tensioner made loud noise. Dealer replaced Pulley, Tensioner and the belt. Transmission stay in first gear too long then jump directly to 3rd and skip the 2nd gear. Dealer update the software then problem is gone.

Volvo XC90 in Michigan, United States Nov 2008 - Mar 2010
Oct 2009 37000 mi	Rear hub bearing.

Volvo XC90 in California, United States Oct 2011 - Apr 2012
Jan 2012 99000 mi	abs and brake assist service light and text came on but has recently disappeared.
Mar 2012 102000 mi US $1200	noisy belts or pulley

Volvo XC90 in Sweden Jul 2009 - Feb 2011
Sep 2009 29140 mi	Steering column replaced due to unusual gap and movement up and down
Apr 2010 30380 mi	Windshield wiper arm broken, rear door, not easy to replace the blade without damaging the arm.

Volvo XC90 in Indiana, United States Aug 2016 - Jul 2018
Aug 2016 153000 mi US $150	Loose steering, repaired by replacing both front lower control arms and ball-joints.
Oct 2016 153000 mi	Lower than expected fuel economy, replaced worn OEM spark plugs.
May 2018 178000 mi US $400	Replaced leaking valve cover gaskets, also required replacement of intake manifold gaskets.

Volvo XC90 in Tennessee, United States May 2015 - Jun 2018
May 2015 76000 mi US $190	Replaced worn right front spring cap Replaced lower control arm bushings on both sides.
Dec 2015 88000 mi US $2700	Main engine seal leaking/fixed. Both valve covers leaking/repaired
Jan 2016 103000 mi US $2400	Oil leak from main bearing seal and valve cover gaskets.
Dec 2016 105000 mi US $180	Front passenger door lock mechanism gears stripped, replaced unit.
Mar 2017 109000 mi US $300	Worn ball joint replaced. Replaced drain lines and traps from sunroof.
Jan 2018 124000 mi US $190	Replaced o-ring on power steering line where pressure line enters rack assembly.

Volvo XC90 in Washington, United States Apr 2015 - Jun 2018
May 2015 135500 mi US $800	Alternator died and was replaced.
Jun 2016 153000 mi US $1028	Front Control Arms and ball joints replaced.
Nov 2016 156700 mi US $2400	Shock, strut, and spring replacement for worn items.
Jun 2017 174500 mi US $120	Accessory drive belt and one pulley replacement. Pulley had a scratch which was wearing the belt very quickly. Third belt replacement in six months, but should be fully repaired with the pulley.

Volvo XC90 in Great Britain Dec 2015 - Jun 2022
Dec 2016 101000 mi £700	Replace tension pulleys and serpentine belt ( maintenance interval by Volvo too long should be 75,000 miles. replace track rod end (probably caused by pot hole in road); carried out replacement transmission fluid shortly after car purchase.
Feb 2018 108000 mi £680	Replace Transmission Shift Lever Cables Replace suspension bushes front and rear ( 4 in all) Fit Parking Brake Adjusters ( parking brake factory fitted is known to be inefficient and frequent MOT Fail fitting after market adjusters said to improve performance) Replace fuel filler flap hinge

Volvo XC90 in Colorado, United States Oct 2016 - Mar 2018
Apr 2017 132000 mi US $950	Power Steering pump replacement
Nov 2017 139500 mi US $250	Overflow reservoir cracked it’s nozzle.

Volvo XC90 in British Columbia, Canada Aug 2009 - Mar 2010
Feb 2009 33790 mi	Clunking sound from steering when parking etc. Dealer replaced both steering follower arms and joints at no charge. Problem fixed.

Volvo XC90 in Colorado, United States - Aug 2009
Aug 2009 30800 mi US $1500	Vehicle climate control module replaced under warranty.

Volvo XC90 in California, United States Jan 2012 - Jan 2016
Mar 2012 77000 mi US $80	Pressure sensor in haldex failed, AWD would not engage Lower control arm bushings failed.
Apr 2012 77000 mi	Knocking noise in front end when backing and turning quickly. Mechanic diagnosed steering rack and replaced under warranty.
May 2012 78200 mi	New steering rack failed within 300 miles. Knocking noise during parking. Replaced.
Jul 2012 80000 mi	Knocking noise in steering, disconnected variable speed steering sensor, noise went away, reconnected sensor, noise did not return, dealer cannot explain, proposed corrosion issues, under warranty on this item still
Sep 2012 84000 mi	rebuilt steering rack knocking during parking maneuvers. R/R rack and align.
Dec 2012 87000 mi	Volvo Cars NA replace steering rack again due to internal knocking noise, experienced during low speed parking maneuvers. Reman'ed rack installed again. Corporate involved.
Jul 2013 96000 mi US $15	Fuel door hinge failed. Will no longer stay shut due to plastic holding spring breaking. $15 part at dealer.
May 2014 108700 mi US $150	Fuel Pressure Sensor caused check engine light, owner replaced.
Dec 2015 134000 mi US $1500	Power steering pump leaking

Volvo XC90 in Vermont, United States Dec 2014 - Dec 2016
Mar 2015 110000 mi US $750	Pulley boss broke off of pulley resulting in the need for all pulleys and associated parts to be replaced. Cost could have been much worse (timing chain cover replacement) if not for a creative fix by the mechanic. ( he machined a part)
Sep 2015 121000 mi US $200	Replaced various front end components that were worn out. Swaybar links and tie rod ends.
Jan 2016 US $283	Replaced alternator, took around 8 hours and the part was $283.00.
Mar 2016 136000 mi US $78	Replaced control arms
Jun 2016 139000 mi US $30	Heater/Cooling Blower fan died. Culprit was the blower motor resistor. $30 part on eBay and a few hours to install.

Volvo XC90 in California, United States - Mar 2008
Apr 2007 21968 mi	PMS Upgrade for seat issue
Mar 2008 37016 mi	Replace Brake Booster

Volvo XC90 in Utah, United States Mar 2013 - Dec 2014
Jun 2014 111000 mi US $570	Check engine light came on, the Fuel Rail Pressure sensor had to be replaced. Dealer could only get volvo oem parts it would of been about $100-$150 cheaper if I could of purchased a 3rd party part.

Volvo XC90 in Colorado, United States Jun 2014 - Dec 2014
Dec 2014 104000 mi US $2900	Full front end suspension refresh including front shocks, bushings, sway bar

Volvo XC90 in Colorado, United States May 2013 - Jul 2014
Jul 2013 83000 mi	Passenger side wheel bearing going out. Just bought the XC90 less than a month ago. Dealer did not want to fix because the warranty hadn't started. Dealer stated that I could bring the car back in a month. Going back today.

Volvo XC90 in California, United States Nov 2012 - Jun 2014
Dec 2012 98000 mi US $800	radiator failed, allowing trans fluid in cooling system
Feb 2014 105900 mi US $350	a/c compressor control solenoid failed

Volvo XC90 in Missouri, United States Mar 2014 - Nov 2014
Sep 2014 73000 mi US $700	Replace unknown fluid with Volvo spec fluid
Nov 2014 73000 mi	Dealer said the transmission had to be replaced after a previous 2500 was spent on transmission repairs.

Return to top

Volvo XC90 in Great Britain Jul 2010 - Sep 2013
Jun 2012 71000 mi £350	Nav unit failed - DVD required replacement parts and RSE remote repaired at same time

Volvo XC90 in South Africa Jun 2010 - Dec 2014
Jul 2010 60760 mi	Transmission service urgent warning came on. Transmission flushed and warning reset. Gearbox broke down completely one week later.
Aug 2010 60760 mi	After transmission flush less than two weeks passed. Suddenly lost reverse gear and on way to shop lost first gear. Transmission extensively rebuilt
Jun 2012 74400 mi	Tapping sound from drivetrain diagnosed as worn propshaft replaced at cost of US$2000 but covered by extended warranty
Jul 2013 82460 mi	Ignition switch broke

Return to top

Volvo XC90 in Colorado, United States May 2010 - Jul 2014
Jun 2011 90000 mi US $650	Alternator failure. Replaced alternator brushes. Replaced front strut spring seats.
Nov 2012 107700 mi US $270	Idler bearings replaced
Jun 2013 115000 mi US $1200	Fuel pump failure. Fuel pump replaced.
Oct 2013 119500 mi US $700	Check engine light, codes indicated O2 sensors failed.
Jan 2014 122000 mi US $600	The ignition broke and had to be replaced. The Key couldn't turn because of the failure and the car could not be started.
Jul 2014 127000 mi	Catalytic converter is failing. Will cost $800-1200. Oil leak in rear and front mail seals. Oil leak in the oil pan. Transmission stutters between 2nd and 3rd and 3rd and 4th gears. Probably a valve body at a minimum looking at another $2000k in repairs or if the whole trans need to be replaced $6000-8000. Power steering pump leaking.

Return to top

Volvo XC90 in Mississippi, United States Jan 2013 - Feb 2013
Feb 2013 147000 mi	car taken to volvo mechanic for power steering leak. am told that it needs a new power steering rack $1300

Volvo XC90 in Minnesota, United States Feb 2015 - Apr 2015
Mar 2015 162000 mi US $200	Fuel smell. Cracked tube.

Volvo XC90 in Massachusetts, United States Sep 2011 - Nov 2011
Nov 2011 135000 mi US $3050	The GM transmission that volvo put in the XC models don't last much longer after the vehicle hits the 133000 mile marker. Don't fall for a $600-1000 software update. Volvo knows dam well about the problems with the GM transmissions

Return to top

Volvo XC90 in Florida, United States Mar 2010 - Sep 2010
Apr 2010 58000 mi US $550	AC hose leaking - greenish dye showing
May 2010 60000 mi US $225	Upper engine motor mount replacement

Volvo XC90 in New Zealand Dec 2012 - Jan 2013
Jan 2013	Retaining lugs on the bracket holding Fuel Door Spring broke - repaired with cable tie and self tapping screw to keep tension on the spring. Repair working well so far.

Volvo XC90 in Pennsylvania, United States Sep 2009 - Apr 2011
Dec 2010 98000 mi US $2700	Had to replace driveshaft.
Apr 2011 99000 mi	Transmission began slipping, putting car into limp mode. Mechanic advised getting rid of car. Replacement transmission would have been $7500 with no guarantee it would last. Mechanic noted the T6 transmission has a bad history.

Volvo XC90 in California, United States Mar 2012 - Apr 2012
Apr 2012 65000 mi US $8000	At just 65,000 I am told I need a new transmission and drive shaft.... I've had one problem after another. This is the worst car I've ever owned. Do not buy this car. You will be sorry.

Volvo XC90 in California, United States Jan 2008 - Dec 2012
Feb 2008 40000 mi	Trans shift vibration.
Aug 2008 45000 mi	T6 transmission and transmission oil cooler replaced. Both headlights replaced due to plastic housing hazing.
Dec 2009 60000 mi	Clanking noise
Jan 2010 61000 mi US $675	Front axle u joint replaced.
Jan 2011 85000 mi	Steering column adjustment loose

Volvo XC90 in New Zealand Dec 2007 - Sep 2011
Oct 2008 34100 mi $1200	Same clunking noise when vehicle turns, they replaced and tightened some screws underneath, okay now but am sure problem will be back again after a couple of months.

Volvo XC90 in Oklahoma, United States Jan 2013 - Feb 2014
Feb 2013 95700 mi US $100	The transmission had been replaced just before we acquired it. Found a large leak of Transmission Fluid. Car was returned for repair. Seal was replaced. software updated. Replaced the central control unit. no temp control was happening and it was diagnosed as a failed unit.
Dec 2013 106000 mi	Fuel pump was replaced as per factory recall. Flange was leaking fuel creating strong odor in car and possible fire hazard due to leaking fuel near exhaust. Car was part of a pool of cars recalled earlier but the work had never been done.

Volvo XC90 in Georgia, United States Jan 2008 - Jun 2011
May 2008 75000 mi US $320	Told needed a new Transmission. Took to independent shop for second opinion. Independent shop reset Transmission light and changed fluid. No problems found.
May 2009 94000 mi	Urgent Transmission Service light. Told needs a new transmission by dealer. Flushed fluid at home and still driving.
Nov 2009 99500 mi US $1680	Transmission failure. Replaced transmission. Manufacturer paid for parts, customer paid labor. Replaced radiator.

Volvo XC90 in California, United States Jul 2008 - Mar 2012
Mar 2009 52000 mi US $150	Worn suspension bushings.
May 2009 52000 mi	replace additional bushings

Volvo XC90 in Ohio, United States Nov 2008 - Sep 2010
Dec 2008 57000 mi	No emergency brake.
Oct 2009 74000 mi	window malfunction broken tie rod broken motor mount bad seat belt retractor triggering airbag light installed seat belt retractor
Dec 2009 79000 mi US $89	key wouldn't easily remove from ignition
Jun 2010 88000 mi US $210	Airbag warning light
Aug 2010 92000 mi	airbag warning light again on (3rd time) Airbag warning light on

Volvo XC90 in Ontario, Canada May 2009 - Nov 2013
Dec 2011 82460 mi C $180	Wiper Motor replaced

Volvo XC90 in Germany Dec 2008 - Mar 2010
Jun 2009 62620 mi €75	The headlight washer on passenger side was replaced. Old cover that extends out of the front bumber fell off during a recent use onto the highway. New part was ordered, painted, and intalled. Rear windshield wiper arm and blade fell off onto highway during recent use. New one was ordered and repaired.

Volvo XC90 in Alabama, United States May 2014 - Jun 2015
Aug 2014 183000 mi US $400	Passenger side CV axle going bad, had it replaced.
Apr 2015 198000 mi US $495	Lower control arm and bushings

Volvo XC90 in Ohio, United States Feb 2015 - Jul 2015
Mar 2015 138000 mi US $700	Had to put a new engine in it.

Volvo XC90 in Washington, United States - Jan 2009
Jan 2009 42022 mi	new transmission - still in shop

Volvo XC90 in Pennsylvania, United States Feb 2015 - Jun 2015
May 2015 111600 mi	Fuel pump failing - gas leaking
Jun 2015 113000 mi US $600	Parking break self destructed while driving. Felt like tranny dropped out. Replaced parking brake, rotors, pads Coolant level sensor had to be replaced

Return to top

Volvo XC90 in Maryland, United States Jun 2010 - Mar 2012
Aug 2010 85000 mi US $360	Alarm sensor malfunction - replaced under VIP warranty with $50 deductible
Sep 2011 98000 mi US $900	it went in for non-functioning windshield washers - washer pump was bad and was replaced

Volvo XC90 in Texas, United States Dec 2014 - Jun 2016
Feb 2015 126100 mi US $350	Cleaned electronic throttle body due to surging at idle. Replaced rubber strut seats due to age wear-clanking over bumps.
Jun 2015 129000 mi US $550	Worn inner tie-rod ends, replaced and alignment completed. Loose sway bar end links with cracked bushings-replaced. Replaced worn lower ball joints, loose with about .5 inch of play.

Volvo XC90 in Florida, United States Sep 2017 - Jun 2019
Jul 2018 133000 mi US $80	Vent temps were weak at 60 degrees. Took in and it was only 50% charged. Took 1.25 lbs of 2.5lbs system capacity.

Volvo XC90 in California, United States Aug 2010 - Jul 2013
Sep 2010 86000 mi US $320	AC condensor leak had to replace with new one at cost of $250 plus recharge system at shop, but the pressure switch maybe the root of the problem that caused the leak to occur.
Jul 2012 100300 mi US $200	Replaced a leaking motor mount.

Volvo XC90 in Texas, United States Jan 2008 - Jul 2018
Jun 2011 68000 mi US $700	Right rear wheel bearing replacement.
Apr 2012 78500 mi US $1300	Fuel pump and fuel sender failure.
Sep 2013 103000 mi US $900	Motor mount replacement--3
Mar 2016 133000 mi US $1100	Power steering pump and hose failure
Jul 2018 144000 mi US $2500	Camshaft seal and bearing Rear rotors and pad

Volvo XC90 in California, United States Feb 2013 - Mar 2015
Mar 2014 111000 mi US $1600	Leaking boot
Jan 2015 US $450	Gas pressure sensor replaced

Return to top

Volvo XC90 in California, United States Dec 2007 - Mar 2008
Jan 2008 22000 mi	Brought in for routine maintenance, asked for an alignment and they found worn control arm bushings and a broken motor mount. Replaced control bushings. Replaced motor mount.

Volvo XC90 in Pennsylvania, United States Aug 2014 - Jun 2017
Jun 2017 182000 mi US $590	Muffler

Volvo XC90 in Minnesota, United States Mar 2009 - Mar 2010
Jun 2009 59000 mi US $1300	XC90 needed new front strut plates.

Volvo XC90 in New Jersey, United States Oct 2008 - Oct 2009
Sep 2008 32000 mi	Both rear wheel bearings
Oct 2008 35000 mi	Both front wheel bearings
Nov 2008 36000 mi	Grinding noise. Replaced both front wheel bearings. Anti-slip error light. Replaced steering input sensor. Steering input sensor
Oct 2009 51000 mi	All-too-common transfer case rear seal leak. Volvo dealer quoted $1800 to repair. Sold car to dealer.

Volvo XC90 in Illinois, United States Oct 2009 - Dec 2012
Nov 2009 28000 mi US $300	Wheel bearing worn out
Dec 2009 30000 mi US $100	Hatch/ liftgate lock replaced
Jan 2012 48000 mi US $2000	Engine mounts cracked
Oct 2012 54300 mi US $1600	tie-rod end

Volvo XC90 in Illinois, United States Dec 2007 - Jun 2018
Nov 2008 21000 mi	Got "brake assist service required" message. Dealer replaced defective brake position sensor. Time taken: about 90 minutes.
Mar 2011 40000 mi US $330	Struts, bushings worn out; replaced. Angle gear leak; sealed.
Jul 2011 43500 mi	Replaced worn sway bar links and engine mounts.

Volvo XC90 in Iceland Jun 2011 - Jul 2011
Jul 2011 39060 mi $1050	wheel bearings were replaced on both rear wheels.

Volvo XC90 in Minnesota, United States Aug 2013 - Sep 2014
Dec 2013 114000 mi US $1000	replaced some electrical thing in the steering column
Sep 2014 128000 mi US $1100	oil filter thing(not oil filter) muffler bracket broken

Volvo XC90 in Minnesota, United States Dec 2007 - Dec 2017
Aug 2010 31000 mi US $150	Replaced rear wheel bearing. Replaced ball joint.
Feb 2011 35000 mi US $325	Remove and Replaced vent hose to oil trap
Jun 2011 37000 mi US $100	DS spline in front axle loose and was glued (loctite). Made loud knock before repair. OK after repair.
Dec 2012 47000 mi US $900	Replace rear wheel bearings
May 2013 49600 mi US $300	Broken seal (O Ring) required replacement of seal and recharge of coolant.
Jun 2015 73000 mi US $725	Replace Front strut
Sep 2015 75000 mi US $1600	Replace rear shocks.

Volvo XC90 in New York, United States Aug 2008 - Dec 2009
Sep 2008 67000 mi US $1000	Both rear wheel bearings were replaced.
Jun 2009 80000 mi US $15000	Engine Mounts were bad

Volvo XC90 in Texas, United States Dec 2007 - Mar 2014
Dec 2010 55000 mi US $120	Shift leaver release button cracked
Dec 2012 70000 mi US $32	Seat side panel - drivers side
Jan 2014 71500 mi US $25	Window washer lines

Volvo XC90 in Maryland, United States Oct 2009 - Aug 2013
Jul 2010 75000 mi US $150	Rear driver's side wheel bearing replaced due to noise.

Volvo XC90 in Utah, United States Aug 2011 - Oct 2012
Sep 2011 70000 mi US $850	anti skid and lock brake electrical system failed and had to be replaced
Oct 2011 70000 mi US $950	manifold failure; caused at rattling sound when cold started which went away as car warmed up replaced electrical system as antiskid, antilock brakes melted down and were inactivated manifold failure; caused at rattling sound when cold started which went away as car warmed up
Oct 2012 84000 mi	window would go up but not stay up

Volvo XC90 in New Hampshire, United States Nov 2009 - Jun 2011
Jan 2010 95000 mi US $2300	AWD stopped working. Angle gear worn out some time since last year. AWD stopped working for no reason. Dealer states this is an angle gear and want to replace the whole unit.

Volvo XC90 in Michigan, United States Jan 2010 - Jun 2013
Jun 2010 52000 mi US $650	Both rear wheel bearings began to fail following the winter -- cab bacame more and more noisy
Jul 2010 52000 mi US $450	Siren module needed to be replaced, alarm ramdomly activated.

Volvo XC90 in Kansas, United States Mar 2011 - Dec 2013
Jul 2012 110300 mi US $250	Replaced sensor in passenger window that protects from child getting pinched. Defective sensor made window just go right back down when it got to full up position. Tweeter speaker cover fell off [again]. One of the few design flaws in this Volvo. Instead of replacing, they just put a few drops of glue on it to hold it on. Sounds kluge-ee but it works and much cheaper than whole new speaker.

Volvo XC90 in South Africa Jun 2010 - Dec 2016
Dec 2016 96100 mi	Engine mounts top and bottom replaced. Brake discs and pads replacement on all four wheels.

Return to top

Volvo XC90 in Great Britain Sep 2012 - Feb 2014
Aug 2013 47400 mi £500	Fuel sensor defective required a replacement and software update - as car out of warranty although just had to pay Â£500
Feb 2014 53000 mi	Faulty ABS sensor on both real wheels with splice ring worn had to replace -took a long time to diagnose with independent

Volvo XC90 in Great Britain Jun 2016 - Apr 2018
Jul 2016 115200 mi	Replace new parking brake

Volvo XC90 in Great Britain Dec 2008 - Dec 2012
Feb 2009 62000 mi	Left rear wheel bearing replaced. Noisy Windscreen wiper bearing in drive mechanism required plenum cover removed and lubrication
Jun 2009 67000 mi £1000	Replaced left hand front lower wishbone (control arm). Bushes worn out and broken causing clunking noise. Right hand rear wheel bearing making rumbling noise. Replaced.
Feb 2010 77000 mi £100	Noisy bearing on alternator. Heater kept blowing cold then hot then cold etc etc Engine torque mountings bottom worn/ top broken. Replaced both units. Can now much quieter. Left hand suspension top spring shock mount replaced to stop nasty creaking and knocking noise on braking/corners. Rear parking brake sticking due to rusty mechanism on both sides plus broken pad. Replaced both levers and 1 set pads behind rear disks.
Mar 2010 79000 mi	Radio works intermittently plus high pitched crackling noise. Possible connection problem on fibre optic plug in amplifier under right hand seat. Removed amplifer, unplugged and replugged fibre connector. Seems to work OK now.
Apr 2010 80000 mi £400	Radio continued to fail intermittently. Gave up and fitted an aftermarket radio/DVD player and volvo parts prices were ridiculous. Now much improved with better sound and linked screen for movies.
Nov 2012 97000 mi £750	Bevel gear oil leak plus wear on drive shaft seals. replaced

Return to top

Volvo XC90 in California, United States Jun 2008 - Jun 2011

Volvo XC90 in Virginia, United States Nov 2007 - Dec 2012
May 2007 25000 mi	rear wheel bearing replaced
Jun 2008 34000 mi	Replace rear differential
Dec 2012 86000 mi US $500	Both front lower control arms, brakes, spring seats, shocks

Volvo XC90 in Colorado, United States Nov 2011 - Dec 2014
Jul 2012 99200 mi US $700	Alternator stopped working... bought new bosch unit and had friend (mechanic at another dealership) install
Feb 2014 110000 mi US $1100	needed new hub bearings and control arm bushings. still using the original shocks which are still OK (a little rusty but not leaking) After bearings and bushings, had an alignment service done.

Volvo XC90 in Wisconsin, United States Jan 2011 - Jun 2012
Feb 2011 106000 mi US $450	Transmission was failing. Transmission fluid was flushed and filled and the computer systems were reset.
Apr 2011 110200 mi US $625	Alternator died. Had to tow. Installed rebuilt alternator. Part $425 labor 3-4 hours.

Volvo XC90 in California, United States Feb 2010 - Jun 2015
Sep 2013 95000 mi US $3000	bearings in the tensioner pulleys going out making noise sensor i believe was a MAP sensor going bad
Feb 2014 102000 mi US $1800	Alternator went bad and was replaced. Due to the location of this part, many hours of labor was required.

Volvo XC90 in Iceland Dec 2007 - Nov 2008
Sep 2007 26040 mi $6500	OBC message said Anti-skid needed servicing, but no fault codes showed up. After a lot of hours spent on searching for the fault, the rear differential was found to be inoperative and needed replacement. Replaced under optional extended warranty.
Jun 2008 29760 mi $300	The message ANTI-SKID SERVICE REQUIRED came up in the OBD. Problem solved after sensor connections were checked and fastened.
Oct 2008 31000 mi	Right tie-rod end worn out and replaced.

Volvo XC90 in Idaho, United States Aug 2012 - Dec 2013
Dec 2013 122000 mi US $900	The alternator needed replaced. It was giving a Power System Service Urgent warning light.

Volvo XC90 in Washington, United States Jan 2010 - Oct 2015
Feb 2010 58000 mi	Vibrations coming from the transmission at certain speeds. Dealer replaced transmission on the third visit to their service department.
Dec 2010 65000 mi	Both middle seats would not fold to allow access to rear seats.
May 2011 67000 mi	Middle row of seats would not fold correctly so kids could not get to the third row.
Oct 2015 125000 mi	ABS light came on. Dealer wanted to charge $3k to repair it. We traded in the xc90 for an xc60.

Volvo XC90 in Minnesota, United States Nov 2009 - Sep 2016
Mar 2012 106000 mi US $600	Inner-tie rod end was loose and clicking/clunking when turning the steering. Tie rod end was replaced. Slight hesitation in shifting. Some minor shift flare.
Aug 2012 109400 mi US $600	Rear hub assembly worn. Required replacement of rear axle which was rusted to hub,
Feb 2015 136000 mi US $1000	Outer Tie-Rod End replacement. Both rear bearing (hub assemblies) replaced.

Volvo XC90 in Ohio, United States Dec 2008 - Sep 2012
May 2010 67000 mi US $600	Parking brake was replaced and rear brake pads were replaced. Left tie rod was fixed.
Jul 2010 68000 mi US $300	AC was not cold. Regfrigerant was really low and more was added. AC is now blowing cold air.
Oct 2011 85000 mi US $1000	All Wheel Drive stopped working. Problem noticed b/c front tires were bald. Front tires were just over a year old, so we knew the problem was beyond bald tires.

Volvo XC90 in Ohio, United States Jun 2015 - Mar 2016
Feb 2016 101300 mi	Squeaking sound from accessory belts. Replaced serpentine belt and tensioners for around $1000. Memory for front seat stopped working

Volvo XC90 in California, United States Mar 2016 - Sep 2016
Sep 2016 85000 mi	Alternator failed, thought it was battery...original battery still working after 11 Years. Repair shop wanted $1200 to replace alternator. Was going to do it myself ~300 but needed to remove wheel & axle...looked like a pain ita. Traded in!

Volvo XC90 in Hawaii, United States Nov 2008 - Mar 2013
Dec 2008 49000 mi	Transmission valve body replaced. Corrected funky shifting. Interior lights inop. Wiring harness damaged during repairs to rain sensor for wipers.
Feb 2009 55000 mi US $300	Car has high pressure headlight washer nozzles imbedded inside bumper with a color matched cover with a built in gimble for the nozzle to swivel up to the headlight. Covers cost $300. for two (2) including paint, new nozzles and install.
Aug 2009 62000 mi US $35	"Soft Touch" plastic panel surround on drivers seat controls cracked and slowly disintegrated. Part replaced by owner as the shop was backed up. 30 dollar part, about an hour to R&R Parts came in a while ago, owner finally replaced. Ultimately a simple repair but w/o shop knowing process ( 1st time occurence for them) it took about an hour and a half to disassemble and "noodle out" the fix
Mar 2012 104000 mi US $120	Hood gas strut supports fail to keep hood open. Most likely due to age (6.5 yrs) and tropical heat. Simple replacement. Parts only.
Jun 2012 108000 mi US $150	Some sensor that affected the check engine light failed
Mar 2013 119000 mi	Automatic window closure malfunction. "pinch guard" sensitivity too high and window would re-open by itself. Adjusted software.

Return to top

Volvo XC90 in Great Britain Mar 2012 - Jun 2012
Apr 2012 102700 mi £850	handbrake did not hold on hills and a new system had to be installed

Return to top

Volvo XC90 in Great Britain Dec 2012 - Mar 2014
Mar 2014 93000 mi £1000	Ignition barrel broke, locking the key so it wouldn't turn past position 1 Jerk going into gear 4 and 5. Replaced transmission fluid, reset adaptive setting, fluid counters and updated gearbox software

Volvo XC90 in Great Britain Sep 2011 - Sep 2012
Dec 2011 137000 mi £40	Excessive clutch wear warning and limp home mode engaged locking transmission into 4th gear.

Return to top

Volvo XC90 in Great Britain Jun 2010 - Oct 2011
Nov 2010 93100 mi £350	rear wheel bearing, replaced.
Mar 2011 96000 mi £1100	central electrical module failure which caused damage to rear electrical module
Jul 2011 98000 mi £500	split intercooler
Oct 2011 99000 mi £60	screen washer pump failure

Return to top

Volvo XC90 in Minnesota, United States Feb 2015 - Mar 2015
Mar 2015 150000 mi	ACV cracked

Volvo XC90 in Virginia, United States May 2008 - Mar 2010
Jun 2008 86000 mi US $1500	Transmission went, stuck in third gear.
Sep 2008 89000 mi US $425	suspension work

Volvo XC90 in Virginia, United States Mar 2015 - Dec 2016
Jun 2015 220000 mi US $900	Replace front bushings
Sep 2016 246000 mi US $300	Cracked top engine mount

Volvo XC90 in British Columbia, Canada Mar 2008 - Mar 2010
Apr 2008 51460 mi C $200	Broken motor mount.

Volvo XC90 in Chile Jan 2010 - Jun 2011
May 2010 71300 mi $2000	Replaced the solenoid and master kit of transmission. Fault codes: TCM-002B 4th gear. Incorrect gear ratio. TCM-000B Shift solenoid S1. Hydraulic fault. BCM-0115 Communication between control modules. BCM-0103 Pedal position sensor. Faulty signal.

Volvo XC90 in New York, United States Feb 2010 - Jun 2011
Mar 2010 72000 mi US $5900	Broken drain sun roof.

Volvo XC90 in Iceland Feb 2012 - Mar 2012

Volvo XC90 in Connecticut, United States Nov 2009 - Mar 2010
Dec 2009 86000 mi US $800	Had to replace front right axle.

Return to top

Volvo XC90 in Washington, United States Feb 2009 - Mar 2009
Mar 2009 64000 mi	awd didn’t work at all – probably electronic problem, costs ~ 2000$ to fix, dealer said whole rear differential needed changing ~ $4500

Volvo XC90 in Massachusetts, United States May 2008 - Mar 2010
Jun 2008 46000 mi	Replaced 2 wheel bearings. Seal on Fuel Tank was broken during wheel bearing repair. Terribly strong smell of leaking fuel. Car not driveable. Dealer repaired under factory warranty w/o admitting fault.
Aug 2008 49000 mi	Replaced a third wheel bearing.
Jun 2009 57000 mi	Radio & Nav system cutting out - replaced faulty Infotainment Center Control Module (ICM). Seal on Fuel Tank was broken during wheel bearing repair in May/June 2008. Terribly strong smell of leaking fuel. Car not driveable. Dealer repaired under factory warranty w/o admitting fault.

Volvo XC90 in Colorado, United States Dec 2010 - Apr 2011
Feb 2011 75200 mi	at 75K miles the 'transmission service urgent' warning light came on. The Volvo dealership diagnosed a faulty transmission that needed total replacement--evidently this is a known issue which is why Volvo paid for the replacement. there was a gear broken in the steering column during the transmission removal. Volvo says it wasn't their fault, but that they consistently see this problem when transmissions fail. Volvo says it's unrelated to the transmission failure.

Volvo XC90 in Colorado, United States Mar 2011 - Mar 2014
Apr 2011 67000 mi US $750	The alternator went out in this car less than 24 hrs. after purchasing it used from the dealer. They paid for the part. Mechanic was surprised at how long it took to replace it.
Oct 2011 70000 mi US $1200	Car has been veering slightly to left when braking. Problem got progressively worse. Rear left control arm bushing was shot, right was badly worn. Both were replaced. I think actual control arm was replaced too (?) Problem fixed but pricey.
Mar 2014 84000 mi	Transmission services light was on. Dealer installed software, which made light go off. Because of this, I did not have transmission further inspected.

Volvo XC90 in Virginia, United States Dec 2011 - Sep 2017
Jul 2012 118500 mi	Changed right rear brake light
Dec 2013 129000 mi US $2261	check engine light. Front and rear O2 sensors replaced. Front strut sprngs found brokn: both spring seats replaced. Right engine mount broken: replaced. Power steering hose leak. Needs lower control arms, rear sway bar links, tie rods, steering column u-joint.
Jul 2014 136200 mi US $50	Engine mount
Nov 2014 137900 mi US $4300	needed complete front end repair kit leaking steering hose oil on drive belt
Apr 2016 147300 mi US $435	Oil leak Loose stabilizer bar
Jul 2017 155000 mi US $400	Replaced radiator

Volvo XC90 in British Columbia, Canada Nov 2008 - Mar 2010
Dec 2008 56420 mi C $2000	Oil leak, timing belt.

Volvo XC90 in California, United States Nov 2008 - Jun 2012
Dec 2009 60000 mi	Moldy, rotten smell emanating from the air vents after car has been washed or it has rained. No leaks inside the car (i.e. no wet floor mats or interior panels). Smell goes away after 2-3 days with the a/c running continuously. 3rd trip and no repair
Mar 2010 61000 mi	Mildew smell coming out of vents after rain or car wash. 3rd visit to dealership for same problem. Dealer could not replicate problem (smell).
Sep 2010 65000 mi US $1100	Car made a clunking sound in the front driver's side while turning or backing up. Dealer replaced the control arm brushings and upper engine mount. Car smells like mildew after washes, rain, being parked outside. Dealer wanted to change the sunroof drains at a cost of $700. I refused to pay that much to correct a design flaw and will look to replace the drains elsewhere.
Jun 2012 88000 mi US $500	Dealer found a/c was leaking, gave us a quote of $600 to repair. Dealer found engine was leaking coolant, gave us a quote of $1500 to repair. Dealer found part of the suspension system needed to be replaced and gave a quote of $900 to repair.

Volvo XC90 in California, United States Mar 2009 - Jun 2013
Jul 2009 55000 mi US $32	Recharged the A/C
Dec 2012 80000 mi	The transmission was rebuild and fully paid for by Volvo under Goodwill agreement.

Volvo XC90 in Minnesota, United States Jan 2012 - Sep 2014
Apr 2012 133000 mi	steering fluid leak due to hose connection was aged.
Feb 2013 141700 mi US $539	Two of six ignition coils failed. Replaced two ignition coils and six spark plugs at the same time.
Oct 2013 149500 mi US $640	Ignition lock cylinder failed. Car was towed to dealership and its ignition lock cylinder was replaced. $640 includes $91 towing charges.

Volvo XC90 in Pennsylvania, United States May 2010 - Mar 2012
Jun 2010 58000 mi US $1	Motor mount was broken
Mar 2012 62000 mi US $358	The tie rod was replace also and oil change and have sun roof leak taken care of.

Volvo XC90 in Indiana, United States May 2010 - Jun 2011
Jun 2010 93000 mi US $480	wheel brearing replaced - rear driver's side
Jul 2010 93000 mi US $195	upper motor/torque mount replaced
Jun 2011 109000 mi US $287	front sway bars replaced

Volvo XC90 in Nevada, United States Apr 2010 - Feb 2011
Dec 2010 121000 mi US $3500	ABS braking system was malfunctioning and was replaced. The ABS system needed to be ordered

Volvo XC90 in Ohio, United States Oct 2012 - Jan 2013
Jan 2013 138000 mi US $160	Front bearing boot at driveshkaft connection to rear was completely worn and no grease inside; car made metal clicking sound on acceleration and deceleration; prop shaft may need replaced eventually

Volvo XC90 in South Carolina, United States Apr 2008 - Apr 2011
Oct 2008 39000 mi	Replaced entire drivetrain. Took 5 months for parts to be shipped and clear customs.
May 2010 70961 mi US $865	Replaced leaking power steering pump Replaced leaking power steering pump
Feb 2011 78000 mi US $940	Power steering pump replaced again due to leaking seals.

Volvo XC90 in California, United States May 2010 - Jun 2010
Jun 2010 85000 mi	Engine suddenly died while daughter was driving. She ended up in the oncoming lane. Lucky no one was in it at the time. Towed to the nearest Volvo dealer who could find nothing wrong with it (except $2500 list of unrelated repairs). Sold instead. Cracked and broken Front Lower Control Arms, front and rear bushings. Sold instead of repairing. New upper torque mount (broken). Sold instead of repairing. New coolant reservoir (leaking). Sold instead of repairing. New Air Hose (leaking). Fix ignition key (Key part wouldn't stay horizontal). Sold instead of repairing.

Volvo XC90 in New York, United States Aug 2010 - Jun 2011
Oct 2010 63000 mi US $2281	We lost power to the lights, dash, wipers, windows and directional signals unexpectedly. First a DIM was replaced and the problem re-surfaced within days. Back to the dealer for a CEM. It seems fine now.

Volvo XC90 in Massachusetts, United States Jan 2012 - Jan 2013
Feb 2012 140700 mi US $800	replaced rear drive shaft
Aug 2012 145400 mi US $850	replace ignition coil and all spark plugs driver window and ext. mirror does not work

Volvo XC90 in Connecticut, United States Nov 2009 - Jun 2011
Nov 2009 53985 mi US $2944	Replaced both Turbochargers
Mar 2010 58484 mi US $1997	Cleared clogged sunroof drains, cut elbow opening larger to prevent further clogging. Cleaned up standing water on front passenger side and removed carpets to be dried. Replaced security system siren module for an internal failure. Replaced fuel door lock system consisting of door hinge and lock motor.
Sep 2010 63802 mi US $90	Adjusted brake backing plates away from rotors due to noise when in reverse.
Dec 2010 65772 mi US $793	Replace Thermostat and temperature sensor housing. Replace engine torque mount Replaced engine torque mount. Check engine light eluminated: Replaced engine coolant temp sensor and thermostat.

Volvo XC90 in Great Britain Oct 2009 - Mar 2010
Nov 2009 70000 mi £800	Car goes into protection mode for no reason

Volvo XC90 in New South Wales, Australia Sep 2010 - Jan 2011
Oct 2010 44866 mi A $119	Replaced oil cooler hoses due to hose fail and resulting water/coolant leakout. Replaced oil cooler hoses due to hose fail and resulting water/coolant leakout.

Volvo XC90 in Ohio, United States May 2009 - Mar 2014
Jun 2009 47000 mi US $241	Transmission developed a significant bearing noise
Oct 2009 52000 mi US $899	Radio failed, had to replace the main control module. Volvo declined any assistance.
Aug 2010 60800 mi US $60	Transmission Output shaft seal was leaking, according to TSB and repair history was likely caused by the dealers replacement of the transmission. Roll bar links failed, replaced both sides with OEM new
Mar 2011 70000 mi US $125	Leaking seal replaced
May 2011 72000 mi US $65	Replaced 3rd row seat release cable Replaced 3rd row seat release cable

Volvo XC90 in Alabama, United States May 2010 - Jan 2013
Jan 2013 160000 mi US $5000	failed transmission again. This is the second time 80k miles apart.

Volvo XC90 in Iowa, United States May 2004 - Jun 2011
May 2004 11000 mi	Trunk latch failed, both outside and the safety latch inside; so no trunk access at all (and was out of town with my whole family). Dealer replaced at no charge, along with rear cupholder which had broken.
Jan 2007 93000 mi US $5200	"Service Transmission Urgent" light came on, had been having no problems but all of a sudden seemed to be starting in 2nd gear and not shifting into first. Dealer said I need a new transmission, total cost, $5200.00
Jun 2010 141000 mi US $874	Bad left front Axle. Bad tie rods

Volvo XC90 in California, United States Jan 2014 - Apr 2018
Sep 2015 162000 mi	Powersteering pump bleed-screw leak

Volvo XC90 in Tennessee, United States Nov 2007 - Jun 2016
Nov 2009 106000 mi US $1800	Car had been doing a light whistling noise under moderate acceleration usually between 5 and 20 MPH. Then transmission alert came on. After restart, transmission worked fine. Took to transmission specialist. Replaced all wearable for $1,800.
Dec 2009 108000 mi US $1080	Replaced broken top engine mount ($85).
Oct 2011 139700 mi	Rebuilt the sunroof drains at base of A pillar to eliminate the flow restrictions (remove original drain connection at bottom of A-pillar, replaced with open tubing). Needed because the original drains self-destroyed & plugged.
Jan 2012 143000 mi	fuel filler door does not lock anymore unless engaged by hand radio (AM/FM only) temporarily stopped working twice, operational at present.
Jun 2012 161000 mi	Alarm siren has been out for a few months. Not replaced to date. Problem reported with radio has not reappeared. Original battery still in good conditions after 8 years (a few Low Battery warnings ignored since 2008).
Sep 2013 180000 mi US $1300	Coolant is leaking. In searching for leaks, mechanic noted that a turbocompressor oil leak weakened two short cooling system hoses. Replaced those hoses. Tightens another cooling hose to stop leak. Leak slowed, not all the way gone yet Ventilation fan failed. Mechanic said the HVAC controller had failed, most likely from an overamped fan motor (known failure). Replaced fan motor and controller.
Dec 2013 183000 mi US $115	Coolant leak continues. Found leak at the upper radiator connection. Replaced upper hose. Still leaking under pressure, identified a likely crack at the radiator connection. Radiator needs to be replaced. Keeping pressure off to avoid leak
Jun 2014 189000 mi US $750	Master cylinder failed (slow repsonse to pedal). Replaced. All is back to normal.
Sep 2014 192000 mi US $250	Water pump started to leak badly--radiator okay. Having the level sensor of the coolant was extremely valuable to manage the leak while traveling. Since it was almost time for a new timing belt, that was done too, minimizing the actual cost of the repair.
Dec 2015 198000 mi	Just a note that an oil leak getting worse, possibly at a turbo.
Feb 2016 199000 mi US $130	This great yet aged car is giving some feedback when I brake, a little move in the steering wheel, with having to turn my steering wheel a bit to the right while stopping. Paid for diagnosis. Worn suspension rubbers and lower control arm bushings I have a leak of engine oil that has been getting worse. Got it looked at during diagnosis visit. Told the seal of the oil pan needs replacing. Expensive replacement! About $700. Lots of hours... Will wait a bit. Air bag light was on. I had unplugged connectors at front passenger seat and rear middle seat to clean the carpet. Dealer completed a reset. No more problems.
Mar 2016 201000 mi US $750	Front bushings badly worn out with impact during braking. Replace lower control arms on both sides, with new bushings of course. Then 4-wheel alignment. Pb fixed
Jun 2016 201000 mi	Oil leak never fixed.

Volvo XC90 in Wisconsin, United States Dec 2014 - Mar 2015
Dec 2014 128000 mi US $640	Motor mounts and torque mount replaced
Jan 2015	Main drive shaft was clicking, starting to fail

Volvo XC90 in Washington, United States Jun 2017 - Sep 2017
Jul 2017 197000 mi US $790	Stuck caliper. Ruined the pads and caliper assembly.
Sep 2017 197000 mi US $1200	Coolant leak traced to water pump. Oil leak.

Volvo XC90 in Indiana, United States Nov 2015 - Oct 2017
Jul 2016 142300 mi US $350	Inner and Outer Tie rods replaced Driver and passenger side ball joints replaced. Further reduced how often the suspension makes a loud popping clunk noise when turning to the lock either way at low speeds. Still makes it sometimes.
Jul 2017 152000 mi US $75	Front left wheel bearing was making noise new bearing didn’t solve issue

Volvo XC90 in Alberta, Canada May 2008 - Dec 2010
Jun 2008 47120 mi C $700	failed endlinks

Volvo XC90 in Zimbabwe Oct 2014 - Sep 2015
Sep 2015 130200 mi $5000	Gear Box Serviced Prop Shaft replaced Head Gasket Serviced Aircon Radiator Replaced Radiator Replaced

Volvo XC90 in Jamaica May 2013 - Jan 2014
Dec 2013 44020 mi $2536	replace ABS control unit

Volvo XC90 in Missouri, United States Jan 2013 - Mar 2013
Feb 2013 97200 mi US $1500	Volvo warrantied a complete new transmission and cooling lines and radiator

Volvo XC90 in Brunei Darussalam Oct 2008 - Mar 2010
Nov 2008 60140 mi	Transmission require urgent message incidator appeared.

Volvo XC90 in Virginia, United States Jul 2013 - Aug 2013
Aug 2013 127000 mi US $1400	CEM Failure due to water leak, 2 fuse relays

Return to top

Volvo XC90 in Ohio, United States Jan 2014 - Mar 2019
Feb 2014 138300 mi US $1370	Water intrusion due to failed moonroof drain system, causing various problems with the electronic modules.
Apr 2014 139300 mi US $165	Siren module malfunctioned due to leaking internal battery. Causing sunroof to be nonfunctional.
Aug 2014 141000 mi US $275	When replacing the struts of front wheels, it was found that the tie-rod was broken and required replacement
Dec 2016 174000 mi US $346	Lower ball joints of both front worn out.

Volvo XC90 in North Carolina, United States Jan 2015 - Jul 2017
Nov 2016 198700 mi US $120	motor mounts were replaced

Volvo XC90 in New Hampshire, United States Aug 2010 - Jun 2018
Oct 2010 60300 mi US $200	Water leaked in from passenger's side blocked drain tube from sun roof. Flooded Floor
Aug 2013 93000 mi US $100	Right rear bearing replaced under extended warranty
Apr 2017 121000 mi US $300	Hangers on exhaust system broke, repaired with aftermarket hanger kit. Check engine light was due to bad gas cap replaced with original equipment also due for state inspection.
May 2017 123000 mi US $600	Had left rear wheel bearing changed
Jan 2018 140000 mi US $853	Replaced antilock braking sensor left rear wheel Had right rear anti-lock wheel sensor replaced

Volvo XC90 in Connecticut, United States Jan 2013 - Jun 2014
Mar 2013 134000 mi US $1800	Replace sway bars, fix front suspension, replace fuel pump, water pump and timing belt.
Dec 2013 134000 mi US $1900	All wheel drive broke

Volvo XC90 in Georgia, United States - Feb 2008
Feb 2008 520000 mi US $4200	repair/replace transmission

Volvo XC90 in Illinois, United States Dec 2014 - Mar 2015
Dec 2014 182000 mi US $200	Replaced turbo. Replaced MAF. Replaced oxygen sensor

Volvo XC90 in Oregon, United States Dec 2020 - Jun 2022
Apr 2022 155000 mi US $685	Replaced spark plugs and defective ignition coil. Also fuel filter

Volvo XC90 in Florida, United States Mar 2010 - Sep 2011
Dec 2010 95000 mi US $370	found slight oil leak from turbo.
Jul 2011 99000 mi	Fuel pump recall. Gas smell in car. Fuel pump had a leak.

Volvo XC90 in North Carolina, United States Nov 2011 - Jun 2018
Jul 2012 220500 mi US $700	Replaced compressor Power seat control button broke off

Volvo XC90 in California, United States Mar 2013 - Jul 2016
Jan 2015 US $400	Radiator cracked.
Mar 2016 120000 mi US $600	Catalytic Converter was gone. Couldn't pass Calif emissions test. Indy Mech replaced with part from used XC. Cat's been gone for about 10 months now but I just had it fixed. no problems sensed but just couldn't pass emissions.

Volvo XC90 in Georgia, United States Mar 2012 - Apr 2012
Apr 2012 92000 mi US $1200	Reduced engine performance. Needed new electronic throttle module

Volvo XC90 in Hawaii, United States Nov 2007 - Feb 2011
Jan 2010 US $35	low beam wire connector failure. Needs replacement
Nov 2010 66000 mi US $1500	O2 sensors and MAF sensor replaced
Feb 2011 67000 mi	Headliner falling down when sold.

Volvo XC90 in Georgia, United States Jan 2011 - Jan 2013
Feb 2011 68000 mi US $50	Spare tire winch failed. Replaced with new from Volvo, at cost of $50. Also performed Synthetic Oil Change, coolant flush, and power steering flush in my home garage.

Volvo XC90 in California, United States Oct 2012 - Mar 2016
Jul 2014 103300 mi US $1100	Tune up and replaced cracking timing belt. Bearing behind timing belt, some rust.
Jul 2015 109500 mi US $659	Speed Sensor and Brkae sensor failed

Return to top

Volvo XC90 in Oregon, United States Nov 2007 - Aug 2014
Jun 2008 94000 mi US $100	Sway bar end link dampers replaced. Broken tail gate release cable replaced.
Jun 2010 121000 mi US $800	rear suspension bushings
Nov 2012 147700 mi US $1400	Rebuild differential control module and replace anti-skid module. Rear wiper motor serviced. Rear door would not open sometimes. Interior cable replaced.

Volvo XC90 in California, United States Mar 2010 - Mar 2011
Apr 2010 72000 mi US $380	According to the dealer, there is a design problem with the transmission in the 2004 Volvo XC90. They "commonly fail" somewhere around 70K miles. Took them a week to replace the non-working transmission with a "refurbished" one.
May 2010 73000 mi US $400	Error message: "Anti-skid system repair required" - not sure what they actually did, but it cost about $400 for "reprogramming computer"
Nov 2010 77000 mi US $150	In for routine maintenance, while testing, found the rack and pinion steering had to be replaced. We have the extended warrantee and were told that it would have cost about $7000 but was covered under the warrantee.
Mar 2011 87000 mi US $2200	Dashboard error code indicated brake module failure. Had it replaced and sold the car. Three major failures in the last year: Transmission, steering and brake system. Bought a Lexus to replace the Volvo

Volvo XC90 in New York, United States Nov 2007 - Mar 2010
Jul 2008 56000 mi US $506	Air conditioning not blowing cool air when idle.
Nov 2009 70000 mi US $220	Radio display did not display Reseal angle gear Replaced Lateral Link

Volvo XC90 in Kansas, United States Apr 2009 - Mar 2010
May 2009 72000 mi	In this trip our XC90 received a new transmission and angle/bevel gear. Also new radiator.
Jun 2009 73000 mi	Replacement of a bad Turbo Control Valve.
Jan 2010 US $25	Had code P0638 faulty throttle sensor come up. Code was reset and has not come back since.

Volvo XC90 in Ontario, Canada May 2009 - Aug 2013
Jun 2009 40300 mi	Rubber engine mounts needed replaced Rubber bushings for front sway bars replaced
May 2012 59380 mi C $3300	Part that comes off the transmission that runs the rear wheels was leaking oil and making noise. Was replaced due to being worn out.

Volvo XC90 in Sweden Sep 2009 - Sep 2011
Apr 2010 68200 mi $35	position light bulb broken
Jul 2011 72540 mi $2000	horn was malfunctioning and had to be replaced.

Volvo XC90 in New Hampshire, United States Nov 2009 - Jun 2011
Aug 2010 95000 mi US $100	Brake pedal sensor is bad, needs to be replaced, part ordered

Volvo XC90 in California, United States Jun 2012 - Sep 2015
Oct 2014 70500 mi US $300	Spark plug failure. Replaced all.
Dec 2014 73000 mi	Discovered water on carpet and beneath floor. Diagnosed as sunroof drain. Fixed plugged drain and dried carpets and foam beneath.

Volvo XC90 in Michigan, United States Sep 2010 - Oct 2012
Dec 2010 95000 mi US $1000	Replaced 3 wheel bearings and speed sensors. I did the front 2, the shop did the back right side. I could not get the sensor wire run myself.
Sep 2011 105000 mi US $100	Scanned the check engine code and replaced the brake light switch
Jun 2012 110000 mi US $35	Replaced shifter knob button with an upgraded part from ebay

Volvo XC90 in Alberta, Canada Jan 2013 - Jun 2017
Sep 2015 126480 mi C $1800	Repeatedly found car with flat battery in the morning. First visit (1 day): battery replaced. A week later, symptoms repeated. 2nd visit (2 days): shop discovered faulty diode on alternator. Alternator replaced with new unit.
Jan 2016 120900 mi C $550	Engine not running smoothly, power loss. Sounded like not all cylinders firing. Shop found #3 cylinder ignition coil not working. Unit replaced.

Volvo XC90 in Texas, United States Aug 2012 - Dec 2012
Dec 2012 130000 mi	Driveshaft making noise and needed replacement ($1900.00). Since tranny replaced twice (Volvo paid for total repair 1st time and 2nd time and I paid for labor at $2200.00) decided enough was enough and traded it.

Volvo XC90 in Texas, United States - Aug 2009
Aug 2008 90000 mi	under warranty, replace transmission
Aug 2009 106000 mi US $4000	replace front differential after major breakdown. Replaced under courtesy warranty chain box

Volvo XC90 in California, United States May 2012 - Mar 2013
Apr 2012 US $2000	MAS computer chip AGAIN
Jul 2012 152300 mi US $600	yet ANOTHER computer chip went out and needed replacing

Volvo XC90 in North Carolina, United States Aug 2013 - Mar 2014
Oct 2013 115300 mi US $1556	Cruise control stopped working. Software needed to be updated. One side of 3rd row seats would not go down when in the up position. Common problem with 3rd row seats; the clips broke and needed to be replaced. Heavy rubbing sound whenever making a turn. Had to replace steering shaft boot and adjust steering shaft.

Volvo XC90 in Minnesota, United States Dec 2013 - Sep 2015
Oct 2014 119200 mi US $120	Light on for intake camshaft timing. Previously purchased timing belt per service manual replacement @ 120k. Replaced timing belt, no issues. Immediately after replacement noticed lifter noise, checked timing, still OK. Lifter noise. Noise got louder. Low oil pressure light came on. Failed connecting rod bearing. Engine oil was full. Cause still unknown. Regular dealer maintained vehicle with records new up to 105k. Work still in progress.

Volvo XC90 in Colorado, United States Dec 2014 - Jan 2016
Mar 2015 157000 mi US $1600	Multiple front end repairs completed, tie rod ends, sway bar, bushings. The symptoms involved sharp veering to the left upon sudden braking. An unknown problem remains, the vehicle needs tires every 20,000 miles.

Volvo XC90 in Sweden Sep 2014 - Jan 2022
Oct 2014 99200 mi $300	Rear wheel bearing hub noise. Replaced hub.
Jun 2015 104160 mi	Headlight lenses foggy
Dec 2016 112840 mi	Haldex DEM PCB burned beyond repair due to water ingress (poor sealing)

Volvo XC90 in Wisconsin, United States May 2014 - Jun 2015
Jun 2014 109000 mi US $153	Battery required replacement. The battery was OEM and lasted 10 years, 109,000...time for a new one! Headlights were beginning to get foggy glaze on them. Took to Walmart and had "headlight restoration" service completed for $30 complete with lifetime guarantee. The service and result was EXCELLENT. I highly recommend this service!!
Sep 2014 116000 mi US $110	Replaced brake pedal switch in response to P2131 Throttle/Pedal Position Sensor/Switch "F" Circuit Range/Performance. The cruise control would not stay engaged so narrowed the issue to the brake switch rather than the throttle.

Volvo XC90 in Maryland, United States Mar 2010 - Dec 2011
Apr 2010 88000 mi US $980	Vibration upon acceleration. Replaced right front axle. Is an apparent problem with this vehicle. Replaced sway bar and bushings.
Aug 2010 90000 mi US $478	Replaced worn (noisy) right rear wheel bearing. It may not be common to all cars, but it apparently is a problem for Volvo XC90's and, though it may be coincidental, my 2003 Chrysler minivan too.
Dec 2011 106000 mi US $80	The "short" and "long rails" that anchor & protect the fuel line and evaporative return that run from the fuel tank to the engine compartment beneath the cabin floor fell off the car and had to be replaced. Not accident/incident-related.

Volvo XC90 in Alaska, United States Apr 2012 - May 2012
May 2012 82000 mi US $500	AWD not working (DEM and spline sleeve issue)

Volvo XC90 in Maryland, United States Jun 2011 - Mar 2013
Sep 2011 112000 mi US $2000	headlights not functional. Fuse replaced, fixing lights, but computer warning light still malfunctioning intermittently, irritating. replaced ball joint on driver side front suspension leak in exhaust system. No safety issue and would cost over $1K to replace. Only effect is slightly noisier exhaust system.
Aug 2012 127000 mi US $4000	replaced front axle replaced struts
Sep 2012 128000 mi US $25	intermittent thick smoke from exhaust. Possibly coolant leaking into combustion chamber.
Mar 2013 132000 mi US $150	Worn axle Oil pump system failure

Volvo XC90 in British Columbia, Canada May 2010 - Apr 2013
Apr 2013 102920 mi C $600	Due to blown gasket from overheating at the shop's fault, the engine was rebuilt at the shop's expense, except for parts costs of timing belt, water pump, spark plugs replaced with new items.

Volvo XC90 in Alberta, Canada Nov 2010 - Mar 2011
Dec 2010 96100 mi C $250	Oxygen sensor failed. Dealership wanted to replace both which would have cost me $1200. I friend replaced only the faulty one: part + his labor = $260. Everything works fine since then. The 6-CD changer failed. Could not play or even eject disks. Dealership quoted $1100 to replace it. Bought used one for $250 including shipping and replaced it myself. Many people report faulty CD changer.

Volvo XC90 in British Columbia, Canada Oct 2010 - Nov 2021
May 2012 82240 mi C $550	Module for sunroof and alarm system
Jul 2012 83800 mi	initial problem with alarm module was not completed properly
Nov 2012 85220 mi	faulty alarm module
Nov 2014 100720 mi C $400	engine mount broken
Jan 2015 101880 mi C $1200	Replaced water pump and timing belts. Unplugged sunroof drains.
Jun 2017 113460 mi	Reverse sensor replaced. There were intermittent problems (ie. warning light coming on that it wasn't working) with the sensor leading up to the accident. No warning light at the time of the accident. It didn't work at all after the accident. It was repaired as part of the insurance claim.
Jul 2018 115940 mi C $685	Seal near cowl was cracked which allowed water into interior. Also has to remove seats and carpets to remove accumlated water that was sloshing around under the floor of the vehicle

Volvo XC90 in Virginia, United States Nov 2010 - Dec 2015
Aug 2012 178200 mi US $15	Right side air conditioning not cooling. Left side ok. Added refrigerant, wanted to replace o rings for $500 but I opted not to. Fuel door hinged broke. Replaced hinge with part from internet and used rivet gun instead of the cheap push in plastic rivet on part.
Nov 2012 182000 mi US $125	Replaced right rear wheel hub due to noisy bearing.
Mar 2013 187000 mi	Replace left rear wheel hub. Replace worn engine mount
Jun 2013 190000 mi US $430	Replaced all 10 bulbs in sound system. eBay parts were1/10th of dealer cost@$10 v$100. Replaced all 10 bulbs in sound system. eBay parts were1/10th of dealer cost@$10 v$100.
Aug 2013 192000 mi US $6	Replaced fuel door hinge again. Lip that holds the spring snaps off. Design flaw.
Nov 2013 194900 mi	Turn signal (right) flashed fast, intermittently or not at all. Undid 3 T20 torx screws under steering column, then 2 Phillips screws. Removed turn signal switch. Remove last Phillips and cleaned contacts with alcohol and qtips.Replace all
Mar 2014 199305 mi US $474	HID left bulb out, replaced both sides, $350 End joints replaced, $300 HID headlight bulb burned out. Replaced the pair. Parts very expensive.
Mar 2015 210000 mi US $1370	Replace left front spring seat Replace PCV / flame trap system And cracked boost hose.
Apr 2015 210300 mi US $6	Clogged sunroof drains on both sides. 2 inches of water under carpet. Replaced vinyl drain line with hose from hardware store to drain directly, not using the 90 degree fitting that causes clog. Removed floor carpets to airdry for four days.
Aug 2015 212000 mi US $8	Replace fuel filler door hinge. Design flaw.

Volvo XC90 in British Columbia, Canada Nov 2010 - May 2012
Dec 2010 79360 mi C $1100	needed new key fob, hatch back release and windshield washer pump
Apr 2011 83700 mi C $45	rear exhaust bracket that holds muffler in place had rusted through and was causing a "rattle" i simply reinforced the bracket..it now seems to be working fine
Sep 2011 87420 mi C $400	needed new spring and parts for E brake as it was squeaking and not working very well
May 2012 93000 mi C $500	regular maintenance term plus replace clasps for fuel line

Volvo XC90 in Maryland, United States Jul 2011 - Oct 2011
Aug 2011 54000 mi US $1000	Front bushings about to fail. Noticed when tires were replaced at tire shop (not dealer) Steering control arms replaced Leak at transmission

Volvo XC90 in Virginia, United States Dec 2010 - Jul 2012
Jan 2011 148000 mi US $260	There was a trottle body code found. The car was running very rough the check engine light was on and the engine service required warning was on. The shop did an induction cleaning to see if it would help. Still running smooth so far.

Volvo XC90 in Michigan, United States Aug 2017 - Sep 2018
Sep 2017 202000 mi US $1100	Radiator leaking fluid.
Jan 2018 206000 mi	Interior air Fan motor

Volvo XC90 in Colorado, United States Jun 2017 - Jun 2018
Feb 2018 184000 mi US $180	xenon light bulb burned out, pricey to replace.

Return to top

Volvo XC90 in Great Britain Jul 2013 - Jul 2018
Oct 2013 52000 mi £175	DSM module replaced, with Â£1400 replacement cost covered by warranty thankfully but warranty did not cover labour or upload of the new software, hence out of pocket Â£175.
May 2016 87500 mi £1848	Brake failure message. Replaced brake control module. Replaced CEM. Reloaded software to both. Kindly gave us a discount because it took them a week to find the problem and it had to go back twice again after the first "repair."
Jul 2018 112000 mi £600	The car was misfiring, so they replaced some sensors and when we got the car back it was still misfiring, so we sent it back and they played with it a bit more and finally fixed the problem. We did not get a clear answer from them as to the problem, but the car is running well again.

Return to top

Volvo XC90 in Great Britain May 2010 - Jun 2012
Jul 2011 86500 mi £400	Replaced all four wheel bearings due to moaning noise when driving - some of this was preventative as just about to embark on 2,000 mile holiday drive.
Jan 2012 83200 mi £80	Fuel level sender failed
May 2012 94000 mi £75	ICM failed - audio was dying randomly. Fixed ICM at specialist car audio repair shop by replacing power transistor and resoldering dried out joints

Volvo XC90 in Norway Apr 2016 - Jun 2017
Feb 2017 101060 mi $300	Windows regulator

Volvo XC90 in Great Britain Jun 2010 - Oct 2015
Aug 2014 81900 mi £60	Abs sensor ring cracked. Drive shaft removed & new sensor ring fitted.
Dec 2014 84000 mi £200	PAS stopped working properly. Pump removed checked & cleaned. System flushed & fluid replaced. Off side Abs sensor ring cracked. Drive shaft removed & new sensor ring fitted.
Aug 2015 87600 mi £200	Near side Abs sensor ring cracked. Drive shaft removed & new sensor ring fitted.

Return to top

Volvo XC90 in California, United States Jan 2008 - Mar 2010
Feb 2008 53000 mi	Coolant tubing needed replacement. Small leak under pressure.

Return to top

Volvo XC90 in Great Britain Dec 2009 - May 2012
Feb 2010 73500 mi £1588	Rear wheel drive sleeve stripped common problem
Apr 2010 74000 mi £430	Geartronic gearbox oil change and reprogrammed.
Jun 2010 76000 mi £4088	Gearbox had problem again of Transmission service required on dashboard as this is now third time decided to go for complete gearbox replacement told by service staff they had done a lot of gearbox changes recently.
Sep 2011 92000 mi	Fuel pipe from fuel pump leaking

Return to top

Volvo XC90 in Michigan, United States Jan 2011 - Mar 2013
Feb 2011 162000 mi US $2500	console lights went out. told it was console- replaced for $1400. lights still out then dimmer replaced for additional $900. I was very angry because I asked if elect module would turn lights back on.
May 2011 169000 mi US $246	AC out; fan continued to blow after car was turned off. Dealer adds FREON. Next day fan continued to run after car is off result-dead battery. Recharge switch for fan would not accept dial down continued to blow. Heat turn on dial down off.
Jul 2011 176000 mi US $1100	Fixed AC.
Apr 2012 189700 mi	engine message "reduced engine performance". local auto part shop was unable to get a good reading on problem when plugging into their system. nothing done to date.
May 2012 192100 mi US $700	24May rearend, towbar re-welded; Car now drag & hik-up. Local shop paid 2 tuneup $520 still dragng;diagnostic $0,catlyt converter quote $1700, dealer diagnostic paid $121 quote $5000. Indep volvo Spec shake dust from filters quote $0 no code.
Sep 2012 200000 mi	The SR airbag light came on after my last oil change. I am not going to do anything about it. Im sick of this light that appears to mean nothing but cost.
Oct 2012 201500 mi	I picked the car up, and drove 10 miles, and the skid cover came off. $129.00- I had it removed.
Feb 2013 209300 mi US $16	Car hesitating as if to hickup; the engine light's on; I experienced this before autozone recommended adding an additive to fuel which worked. Last year dealer suggested $2300 for tune up, and a local shop $5000 for the same problem.

Return to top

Volvo XC90 in California, United States Mar 2015 - Mar 2016
Mar 2016 140000 mi US $2487	Replace 2 front axels, 2 front wheel hub assembly, Replace Turbo Large Hoses.

Return to top

Volvo XC90 in Georgia, United States Aug 2013 - Dec 2013
Nov 2013 118100 mi US $350	replaced two motor mounts
Dec 2013 121000 mi	replaced driveshaft control arms replaced (upper)

Return to top

Volvo XC90 in Virginia, United States Sep 2012 - Oct 2012
Oct 2012 67000 mi US $1200	Transmission cannot be flushed, only drained and refilled.Shop in Fl has done 2x on this vehicle. Volvo has a class action suit for 2003,4, &5 against these trans for this prob. trans doesn't malfun but fluid is burnt & metal shavings prest

Volvo XC90 in North Carolina, United States Sep 2013 - Oct 2013
Oct 2013 153000 mi US $4000	Final drive failed and shift valves failed. Second transmission repair, first at 105k. Partially fixed, found would require more work, so replaced the car. So much for Volvo being reliable.

Volvo XC90 in California, United States - Jan 2010
Jan 2010 105000 mi US $21000	TURBO REPLACED ENGINE REPLACED TRANSMISSION REPLACED TRANSFER CASE REPLACED LEFT AXLE REPLACED CUP HOLDERS REPLACED

Volvo XC90 in South Carolina, United States Apr 2010 - Apr 2016
Oct 2013 139000 mi US $2800	Infamous trans issue. Dead pressure control valve.
Oct 2014 150800 mi US $2100	The all familiar failed transmission. Not only did the pressure control solenoid fail but the torque converter clutch came apart as well.
Jan 2016 158000 mi US $500	Key would not turn past position 0, locked down.
Apr 2016 173000 mi	Still having problems with the ignition switch. Key will not rotate sometimes.

Volvo XC90 in Washington, United States Jan 2018 - Mar 2018
Mar 2018 120000 mi US $100	Not shifting properly.

Volvo XC90 in Florida, United States Sep 2007 - Jun 2011
Apr 2007 69000 mi US $1700	Shocks, struts, timing belt
Mar 2008 78000 mi US $750	Broken motor mount
Oct 2008 82000 mi US $1000	Siren replaced
Mar 2009 85000 mi US $1800	broken motor mount, fuel pump
Oct 2010 90000 mi US $2500	Something in the rod was leaking transmission fluid into the wheel area. Sounds like BS to me, but who knows.

Volvo XC90 in Maryland, United States Apr 2011 - Nov 2014
Jun 2011 118000 mi US $800	Replaced bushings and realigned.
Aug 2013 154000 mi US $4100	Rebuilt transmission (will be 3rd transmission) after roughly 75,000 miles (first transmission replaced at 75,000.
Sep 2013 154000 mi US $650	Axle installed incorrectly when transmission rebuilt. Axle failed and caused leakage of transmission.
Jan 2014 146800 mi	Software update
May 2014 163000 mi US $1973	Replaced strut assemblies rear and front brake pads and rotors
Jul 2014 163800 mi US $460	Recharged ac Replaced. Braking solenoid
Oct 2014 168000 mi	Leak determined. Waiting to see if under Aamco warranty.
Nov 2014 168000 mi	Oil leak not repaired.

Return to top

Volvo XC90 in California, United States Mar 2009 - Jul 2022
Oct 2009 57450 mi US $11500	Bought vehicle (TX), fixed cracked plastic on armrest hinge - glued together with epoxy and works like a charm. Front wiper washer fluid line had been cut/pinched. Replaced. Fuel door plastic locking latch broken, in search of replacement door.
Nov 2009 58000 mi US $800	Leaking fuel pump (Symptoms: lower gas mileage, difficulty starting, fuel smell, wet fuel tank) Replaced at ind. mechanic with OEM parts.
Dec 2009 58500 mi	Continuation of fuel pump repair: Volvo reimbursed for part, since pump was under manufacturer warranty.
Feb 2010 61000 mi US $160	Never found used fuel door. Ind. shop ordered a new door, paint and install. Also, pass. side low beam light socket had short and partially melted. Had just the socket replaced. This assembly was orig. a junk yard repl. by dealer in order to sell car.
Dec 2010 74000 mi US $66	Two rear brake lights not working, both bulbs burned out (third top bar was working). Replaced bulbs, lights did not work. Replaced brake relay switch and relay. Problem solved and lights work like new. Parts received from dealership.
Feb 2011 76000 mi US $450	CV boot busted for a while/was easier to replace axle. Also, there was a crack in the exhaust flange where it connects to engine, leaking exhaust, making engine noisy and smelly. This was welded closed and works like a charm now!
Sep 2011 84000 mi US $300	Rough idling - engine revving on its own at red light. Threw code, idle too rich, gas mileage was suffering. Replaced MAF and solved problem.
Feb 2012 87500 mi US $500	Replaced worn bushings
Mar 2012 88000 mi	After heavy rain passenger floor mat was wet. Cleaned front sunroof drain tubes and cut rubber elbow ends to allow for debris to flow freely. Also removed and air dried the passenger floor panel. Leak is fixed. 45 minutes total time.
Aug 2012 93000 mi US $300	Replaced front strut spring mounts (one was busted and the other cracked)
Sep 2012 94000 mi US $190	Worn out engine mount. Replaced.
Oct 2013 107500 mi US $1500	AWD angle gear failed damaging right front axle in the process. Replaced angle gear & axle.
Feb 2014 111400 mi US $1900	Real seal leak was getting worse - replaced all engine rubber seals
Oct 2016 144000 mi US $400	Replaced faulty alternator
Jul 2017 147000 mi US $700	Ignition coils cracked, replaced all 5 and spark plugs. Leaky Evap hose replaced. replaced noisy AC blower motor and shimmed AC compressor (was not engaging) with zip ties, per the "zip-tie AC compressor trick"

Volvo XC90 in Alberta, Canada Apr 2009 - Jun 2011
Feb 2009 42782 mi	Inner CV Boot Clamp - was loose had it repaired at same time of Angle Gear reseal
Mar 2009 42782 mi C $931	Angle Gear - Resealed (not replaced, replacement was estimated at $3500 and not necessary)
Apr 2009 44406 mi C $56	Cupholder Lid inbetween 2 front seats got stuck, had to be partially dismantled, rear underlid latch mechanism in wrong position, was repaired but is still sticky. Must be very careful when utilizing
Jul 2009 46648 mi C $67	"Reduced Engine Performance" warning - Clear warnings in system, recommended action if it comes back is to reload 2 ECMs (Code 9520 Accelerator Pedal Sensor and Throttle Unit Reload)
May 2010 47740 mi C $1600	Stereo stopped working, problem is not resolved. Solution is to put in new stereo into a 7 year old car (ridiculous!)

Volvo XC90 in Nigeria Jan 2015 - Apr 2016
Jun 2015 131440 mi $200	Ball joint, linkages and lower arm

Volvo XC90 in Queensland, Australia Jun 2011 - Mar 2012
Jul 2011 219480 mi A $140	transmission shift problem - requires overhaul

Return to top

Volvo XC90 in Great Britain Jun 2010 - Jun 2011
Apr 2010 128000 mi	Replaced NSR wheel-bearing cassette

Volvo XC90 in Great Britain Jun 2015 - May 2016
May 2016 135000 mi £100	Back up sensor failed

Volvo XC90 in France Jul 2007 - Jan 2012
Aug 2007 61959 mi €158	Recplacement of left/ball joint
Aug 2008 72788 mi €83	replacement top engine support (rubber in alu)
Jun 2009 82460 mi €2058	Intially diagnosed as problem with one injector of the engine, it later proved to be a problem with the flywheel and starter motor. Flywheel replaced. Intially diagnosed as problem with one injector of the engine, it later proved to be a problem with the flywheel and starter motor. Flywheel replaced.
Dec 2009 86943 mi €758	Complete revisions of handbrake system, cables and also handbrake pads
Aug 2010 94883 mi €16	Also replaced leaking crankcase seal. Also replaced leaking crankcase seal.
Sep 2010 95790 mi	Repair of rear window wiper motor. Text message "SRS Airbag repar urgente" appears in display of DIM. DTC error codes SRS-00D4 and DIM-0003 and DIM-0005
Mar 2011 100874 mi €81	Set of new antitheft wheelbolts (were damaged by workshop)
Jun 2011 104160 mi	As result of heavy rain, huge leakage through the draining openings in the cowl in front of the windscreen. High level of water in both the front floor sections of the body, under the front chairs. As result of water leakage Audio systeem has halted to work. DTC (Error) codes ICM-DC02, ICM-1A51 and ICM-DC01. Probably AUD control module defect. As result of heavy rain, huge leakage through the draining openings in the cowl in front of the windscreen. High level of water in both the front floor sections of the body, under the front chairs. As result of water leakage Audio systeem has halted to work. DTC (Error) codes ICM-DC02, ICM-1A51 and ICM-DC01. Probably AUD control module defect.
Jan 2012 €644	Replacing rear wheelbearing left

Return to top

See TrueDelta's information for all SUVs

See TrueDelta's information for all Volvo models.

Volvo XC90 repairs by problem area

Volvo XC90 repair cost distribution

2022 Volvo XC90 4dr SUV

2022 Volvo XC90 4-door

2021 Volvo XC90 4dr SUV

2021 Volvo XC90 4dr SUV

2020 Volvo XC90 4dr SUV

2020 Volvo XC90 4dr SUV

2019 Volvo XC90 4dr SUV

2019 Volvo XC90 4dr SUV

2018 Volvo XC90 4dr SUV

2018 Volvo XC90 4dr SUV

2017 Volvo XC90 4dr SUV

2017 Volvo XC90 4dr SUV

2017 Volvo XC90 4dr SUV

2016 Volvo XC90 4dr SUV

2016 Volvo XC90 4dr SUV

2016 Volvo XC90 4dr SUV

2014 Volvo XC90 4dr SUV

2013 Volvo XC90 4dr SUV

2013 Volvo XC90 4dr SUV

2011 Volvo XC90 4dr SUV

2011 Volvo XC90 4dr SUV

2010.5 Volvo XC90 4dr SUV

2010 Volvo XC90

2010 Volvo XC90 4dr SUV

2010 Volvo XC90 4dr SUV

2010 Volvo XC90 4dr SUV

2010 Volvo XC90 4dr SUV

2010 Volvo XC90 4dr SUV

2009.5 Volvo XC90 4dr SUV

2009 Volvo XC90 4dr SUV

2009 Volvo XC90 4dr SUV

2008 Volvo XC90 4dr SUV

2008 Volvo XC90 4dr SUV

2008 Volvo XC90 4dr SUV

2008 Volvo XC90 4dr SUV

2007 Volvo XC90

2007 Volvo XC90 4dr SUV

2007 Volvo XC90 4dr SUV

2007 Volvo XC90 4dr SUV

2007 Volvo XC90 4dr SUV

2007 Volvo XC90 4dr SUV

2007 Volvo XC90 4-door

2006.5 Volvo XC90 4dr SUV

2006 Volvo XC90

2006 Volvo XC90 4dr SUV

2006 Volvo XC90 4dr SUV

2006 Volvo XC90 4dr SUV

2006 Volvo XC90 4dr SUV

2006 Volvo XC90 4-door

2005.5 Volvo XC90 4dr SUV

2005 Volvo XC90

2005 Volvo XC90 4dr SUV

2005 Volvo XC90 4dr SUV

2005 Volvo XC90 4dr SUV

2005 Volvo XC90 4dr SUV

2005 Volvo XC90 4dr SUV

2005 Volvo XC90 4-door

2005 Volvo XC90 4-door

2004.5 Volvo XC90 4dr SUV

2004 Volvo XC90

2004 Volvo XC90 4dr SUV

2004 Volvo XC90 4dr SUV

2004 Volvo XC90 4dr SUV

2004 Volvo XC90 4dr SUV

2004 Volvo XC90 4dr SUV

2004 Volvo XC90 4-door

2004 Volvo XC90 4-door

2004 Volvo XC90 4-door

2004 Volvo XC90 4-door

2003 Volvo XC90

2003 Volvo XC90 4dr SUV

2003 Volvo XC90 4dr SUV

2003 Volvo XC90 4dr SUV

Volvo XC90 Repair Histories