Engine not specified
Ford F-150 in North Carolina, United States Feb 2011 - Apr 2012 | |||
Mar 201127000 mi | Tranny shifted hard 1-2 gear.common problem improved by updated program but not erased. | ||
Jun 201136000 mi | Also drivers window was lubricated to eliminate squeaking noise when putting down window. |
Ford F-150 in Minnesota, United States Jul 2014 - Mar 2016 | |||
Jul 201492000 miUS $100 | Door sensor stopped working, wouldn't autolock doors. | ||
Mar 2016128000 miUS $10500 | Rocker arm broke and shot the piston through the engine block. Repair cost was higher than value so decided to not repair the truck. Very disappointing. |
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
Ford F-150 in Ohio, United States Jun 2015 - Jun 2018 | |||
Oct 2015189500 miUS $200 | Replace front Brake calipers | ||
Jun 2016196000 miUS $200 | Replaced brake pads, rotors, and front left caliper. Caliper was locking up. | ||
Jan 2017194500 miUS $75 | Replace blower motor and blower motor resistor | ||
Mar 2017205000 miUS $50 | Loose Tie Rod. Part replaced. | ||
May 2017207000 miUS $100 | Replaced both stabilzer bars. Ball joints were broke. | ||
Sep 2017210000 miUS $398 | Replaced both front hubs and passenger hub actuator. | ||
Nov 2017213600 miUS $200 | Rear end failure. Entire rear axle assembly was replaced. Replaced rear shocks. Replaced rear pads and rotors. |
Ford F-150 in Ontario, Canada Sep 2012 - Dec 2013 | |||
Dec 201376880 miC $390 | Steering shaft required replacement due to the universal seizing and locking |
310-horsepower 5.4L V8 6-speed automatic RWD
Ford F-150 in California, United States Jun 2010 - Jun 2022 | |||
Dec 201124000 mi | hard downshifting water leaking from back sliding window | ||
Aug 201236000 mi | 2 broken dash vents replaced under warranty | ||
Feb 201456400 mi | leaking transmission fluid from rear sensor, repair at no cost due to TSB from Ford regarding this issue. | ||
Oct 201467200 miUS $100 | motor for blending door in HVAC system rear view camera not working correctly. camera replaced | ||
Aug 201795000 mi | Surface rust has appeared on passenger side A pillar at rooftop transition. Sub surface rust has appeared at 3rd brake light location on cab roofline. No repairs undertaken at this time. | ||
Jan 2022125000 miUS $1800 | Had to have the roof rust (2 spots, each a 6x6 inch patch) repaired and roof and hood repainted due to clear coat issues. |
Ford F-150 in Texas, United States Jan 2015 - Dec 2015 | |||
Mar 201552000 mi | Slip joint clunking. Repaired under warranty per Ford bulletin. | ||
Dec 201570000 miUS $600 | Vapor canister failure followed shortly after by fuel gauge sender failure. Researched problem on the net and traded the garbage in on a new vehicle before it cost me any more money. |
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
Ford F-150 in New Mexico, United States Mar 2010 - Dec 2015 | |||
Feb 201112500 mi | SYNC system microphone relocated per TSB | ||
Jan 201213000 miUS $200 | Sync problem regulating volume between phone and music modes. After much fumbling the truck was scheduled for a follow-on software upgrade - the problem is still there. non-working bracket for d/s visor. fixed | ||
Jul 201335500 miUS $150 | solenoid for engaging/disengaging 4wd failed | ||
Feb 201443400 miUS $700 | leaking gasket | ||
Dec 201453000 miUS $120 | fluid leak-2nd repair in 3 months. not successful. will return to shop | ||
Jan 201544300 miUS $300 | Bulkhead connector o-ring failure. This was the source of the trans leak that the repair shop misdiagnosed. I looked-up the symptoms on the web and this seemed the most likely problem. It has fixed the problem. |
Ford F-150 in Pennsylvania, United States Jan 2015 - Jun 2018 | |||
Sep 201589000 mi | Passenger side rearmost exhaust hanger broke. Was replaced free of charge by the shop who did the exhaust work. | ||
Mar 201696000 mi | Passenger side rearmost exhaust hanger broke....AGAIN. Was replaced free of charge by the shop who did the exhaust work...shop relocated the hanger and installed a new one. |
Ford F-150 in Minnesota, United States May 2010 - Sep 2017 | |||
Jan 201371000 miUS $170 | Power steering hose exploded. Replaced hose and flushed power steering fluid. Required 2 trips because they did not flush the fluid the first time. | ||
Dec 201396000 miUS $760 | Power steering hose was blowing open when starting up in very cold weather. The AC condenser was replaced, as the fluid could not move through it. | ||
Sep 2014120000 mi | Replaced Tie rod | ||
Nov 2014123400 miUS $600 | Need to flush transmission fluid. But the plug had dipstick broken off, and the connection was leaking. |
Ford F-150 in Pennsylvania, United States Aug 2014 - Aug 2015 | |||
Aug 201443000 mi | Torsion bar in tail gate failed again. Replaced second time under warranty. | ||
Nov 201445100 miUS $5 | Gas lid hinge worn. Drilled a hole in the bottom of the hinge pin and inserted a cotter pin to prevent hinge pin from falling out. Symptom was gas lid that wouldn't close. | ||
Aug 201552000 miUS $40 | A/C Compressor clutch rubber damper melted. Replaced part with identical new part. |
Ford F-150 in New York, United States Nov 2009 - Dec 2016 | |||
Jun 201220000 mi | Replaced leaking A/C condensor |
Ford F-150 in Nuevo Leon, Mexico Mar 2011 - Jan 2022 | |||
Apr 2017136400 mi$4200 | Suddenly a valve has been broken and as we did't know how much damage it make's I prefer to change all the engine for a newer. I found a 38,000 miles Expedition motor and the mechanic make the installation. | ||
Mar 2018142600 mi$200 | Overheat while idle more than 1 hour at 100F or above. One of the radiator (right side) fan doesn't work properly changed by afternarket motor and recharge gas at 245,000kms |
Ford F-150 in Michigan, United States Sep 2011 - Sep 2014 | |||
Sep 201214000 mi | Window track was loose within passenger door. Dealer tightened things up, rattle was repaired. |
Ford F-150 in Pennsylvania, United States Dec 2009 - Dec 2011 | |||
Nov 20107100 mi | Transmission vibration between gear shifts (automatic trans) Wanted TSB For SNYC microphone taken care of. They refused to repair |
Ford F-150 in Iowa, United States Nov 2010 - Dec 2011 | |||
Apr 20117800 mi | A dirty sensor in the transmission made the truck go into fail safe mode took it to the dealer it was a quick easy fix and under the warranty. Had dirty sensor in the transmission made it go into fail safe mode dealer fixed it under warranty it was quick and easy |
Ford F-150 in Massachusetts, United States Jun 2012 - Jun 2022 | |||
Oct 201241300 mi | After a heavy rain, I noticed the headliner in the cab was wet the whole width of the cab for about 2 inches forward from the rear window. Dealer says its the Upper Brake Light leaking, common problem. Not covered. Rear High Mount brakelight above the rear window leaked, dealer wouldnt cover repair under warranty. I called Ford, explained the situation and they decided to cover the repair. Replaced entire lens with new, updated unit. No issues since. | ||
Mar 201561000 mi | Passenger side portion of rear slider window randomly shattered. No evidence of any kind of impact causing the damage. Suspect it may be from the extreme cold this winter along with use of the rear defroster frequently. Insurance covered. | ||
Jun 201563000 mi | A heat sheild covering the driver side exhaust manifold wobbled loose and now makes a horrible vibrating noise while driving at low RPM. I put a clamp around it but it didnt hold because its so awkward and diffucult to get to this shield it | ||
Dec 201568000 miUS $50 | Brought the truck in to have the dealer remedy the heat shield rattle, they replicated it and they were able to get two clamps around the loose shield and it did stop the rattle. Bubbles in the paint on the rocker panel below the rear door have developed. Showed to service adviser and manager at dealership. They are looking into getting this repaired/refinished under corrosion warranty. | ||
Jan 201647500 miUS $40 | I had replaced the original serpentine belt (Motorcraft) with a new Dayco belt at 61,525 miles. It was purely preventative. The replacement belt however failed on me within 8k miles. It was a manufacturing defect. | ||
Jun 201886050 miUS $239 | Truck exhibited a constant whining noise and slight vibration from the front end while driving. Also, engagement into 4x4 was rougher then usual and when returning to 2x4 mode, there would be heavy whining and vibration for an extended period of time. Per research on the internet, the vacuum hub actuating system was checked. Determined the actuators themselves on both the left and right side of the vehicle were at fault. Replaced with genuine Ford actuators. | ||
Aug 201887000 miUS $18 | The lower rocker panels of the truck have significant subsurface corrosion. They are literally crumbling apart. I had purchased additional corrosion protection for the vehicle at time of purchase, went to the dealership to have this issue documented and have a claim submitted to the the third-party warranty service to see if repair will be covered under said protection plan. The plastic top portion of the engine oil dipstick seemed to have swelled with age and got stuck in the metal dipstick tube. After much effort, the dipstick was finally freed but the plastic portion was pretty mangled up. Replaced with a new one, grease will be applied to the portion that seals within the metal tube to hopefully prevent this from happening again. |
292-horsepower 4.6L V8 6-speed automatic RWD
Ford F-150 in Indiana, United States Feb 2015 - Dec 2022 | |||
Jan 2018126000 miUS $24 | Climate temperature actuator not working in cold weather (0 F degrees). Ordered new actuator. |
292-horsepower 4.6L V8 6-speed automatic 4WD, part-time w/low range
Ford F-150 in British Columbia, Canada Jul 2010 - Feb 2014 | |||
Sep 20107440 mi | squeal when rolling window down. window channels lubed | ||
Oct 20107440 mi | Squeaking Passenger Side Window again after about a week-and-a-half. Fixed with lube. | ||
Sep 201121080 mi | foam lining where glass meets dash popped out, parts ordered | ||
Apr 201335960 mi | Water leak found from exterior brake/reverse light as well as satellite antenna -> Fixed under warranty | ||
Aug 201341540 mi | Front Passenger side window was making squeaky noise |
Ford F-150 in Missouri, United States Oct 2010 - Jun 2013 | |||
Nov 20102900 mi | Replace rear shocks due to clunking noise Replace rear shocks due to clunking noise | ||
Jun 201117000 mi | Truck was having a slight miss under load. Dealer replaced throttle body. | ||
Dec 201251000 mi | Fluid leak from a transfer tube, per the work order. |
Ford F-150 in Massachusetts, United States Sep 2010 - Jun 2018 | |||
Mar 201111000 mi | Leaking satellite anteana during heavy rain. TSB for this. Loose foam strip between dash and wind shield |
Ford F-150 in Iowa, United States Apr 2017 - Jun 2018 | |||
Oct 201779000 miUS $56 | Replaced the Evap canister purge valve. It was causing a Check Fuel Inlet light. | ||
May 201893000 miUS $100 | The check engine light came on. Circuit board in PCM was corroded. Repaired by the dealer. Took less than 2 hours. The dealer saved me a lot of money by splicing the connections instead of replacing the PCM. |
Ford F-150 in Virginia, United States Feb 2010 - Jan 2022 | |||
Jul 201565300 miUS $40 | Limited slip differential continues to cause vibration when accelerating from a turn. Replaced the fluid and added friction modifier per previous recommendation from dealer. Unfortunately problem persists. |
Ford F-150 in Michigan, United States Apr 2018 - Jul 2022 | |||
Jun 202011500 miUS $350 | front end shimmy and clunking noise on passenger side - replaced front struts and springs, lower control arms and rear shocks. | ||
Nov 2020118000 miUS $1800 | R&R Exhaust Manifolds both sides | ||
Mar 2021123000 miUS $3500 | replaced driver and passenger rear wheel patches, cab corners, rocker panels - Paint affected areas | ||
Oct 2021130000 miUS $300 | Brakes were not working well and squishy. gas mileage had dropped and it felt like the brakes were dragging - replaced driver side rear caliper, rebuilt calipers on front to fix seized caliper pins. replaced pads on front and rear, replaced front rotors. | ||
Nov 2021130000 miUS $275 | grinding noise when engaging the 4x4 - replace passenger side actuator | ||
Jun 2022132000 mi | poor fuel economy and weak heater. Replaced thermostat gained 3 mph | ||
Jul 2022135000 miUS $250 | leaking anti-freeze. Replaced the water pump |
411-horsepower 6.2L V8 6-speed automatic 4WD, part-time w/low range
Ford F-150 in Rhode Island, United States Nov 2010 - Jun 2022 | |||
Dec 201342000 miUS $100 | clock winder affecting horn and cruise control. repaired under extended warrantee, deductible applied | ||
Jun 201448000 mi | driver and passenger cv leaking. dealer replaced driver side under warranty but manufacturer would not approve passenger side repair. two weeks later the passenger side failed and was then replaced under warranty | ||
Feb 201672600 miUS $200 | replace worn tie rods | ||
Dec 201682000 mi | navigation system not functioning properly | ||
Jan 2022136000 miUS $2300 | replaced entire under dash system | ||
Feb 2022136000 miUS $1500 | replaced all in dash components, the first repair was not properly done by another shop |
Ford F-150 in Michigan, United States Dec 2010 - Dec 2015 | |||
Nov 201477800 miUS $50 | Heated Seat Broke | ||
Oct 201596000 miUS $50 | Solenoid replaced |
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
Ford F-150 in Virginia, United States Jan 2012 - Jul 2015 | |||
Oct 201222500 mi | Third brake light water intrusion. |
Ford F-150 in Colorado, United States Dec 2016 - Sep 2018 | |||
Mar 2017114000 miUS $70 | Replaced sway bar end links | ||
Apr 2018126000 miUS $500 | All 4 shocks were leaking again. I rebuilt them myself this time. | ||
Sep 2018130000 miUS $21 | Passenger side blend door failed. I replaced it very easily and cheaply. |
310-horsepower 5.4L V8 6-speed automatic RWD
Ford F-150 in Alabama, United States Feb 2011 - Apr 2015 | |||
Mar 201383000 miUS $200 | Driver seat heater stopped working | ||
Aug 2014119300 miUS $100 | Sliding window seal had come loose; dealer reinstalled |
Ford F-150 in North Carolina, United States Aug 2013 - Aug 2014 | |||
Aug 2014125000 miUS $1100 | Blend Door actuator needed to be replaced |
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
Ford F-150 in Idaho, United States Sep 2016 - Mar 2018 | |||
Nov 201642500 mi | Tsb performed to lube the two piece driveshaft slip joints to eliminate clunk on takeoff. | ||
Mar 201745000 miUS $150 | Replaced spark plugs and coil packs, preventative maintenance |
Ford F-150 in Oklahoma, United States Feb 2010 - Apr 2012 | |||
Mar 20104000 mi | Thin paint on left side. Both doors and bed repainted on drivers side |
Ford F-150 in Washington, United States May 2010 - Apr 2015 | |||
Oct 201012000 mi | Passenger front window quit working after multiple uses in hot weather, then resumed working in a few minutes. Could not replicate for dealer. Front passenger seat controls for A/C and Heating quit working one time. Could not repeat or replicate. | ||
Apr 201224000 mi | Water leak in back seat. Dealer replaced roof brake light housing to repair. The shiny coating on the sliding rear window gasket was deteriorating and left an area about two inches long showing rough rubber. After photographing it and sending it to Ford, they elected to replace the entire rear window. Installed new window. | ||
May 201450900 miUS $50 | A/C Fan quit working |
Ford F-150 in Alberta, Canada Dec 2010 - Apr 2011 | |||
Apr 20115580 mi | Reflash transmission and replaced mechatronic |
Ford F-150 in Washington, United States Mar 2011 - Jan 2017 | |||
Dec 201229000 mi | Cab heater blend door actuator was faulty, warranty fix, no questions asked. | ||
Jan 201736000 miUS $100 | Navigation system antenna failed |
Ford F-150 in North Dakota, United States Dec 2014 - Jun 2022 | |||
Jan 2018195500 mi | Cylinder #8 missfire, replaced #8 spark plug and coil. Cyliner #8 still missfires, in particular on startup. Rotated fuel injectors #8 with #4, checked the codes. | ||
Mar 2018238000 miUS $3000 | I replaced the engine with a used engine that I purchased on line from a place in Florida. The engine I bought came out of a Lincoln Navigator, it had 57k miles on it. I have had the vehicle back now for about 10 days and I have put about 4 thousand miles on it. It seems to run just fine. |
Ford F-150 in Colorado, United States Jan 2011 - Jun 2018 | |||
Jan 201583700 miUS $1000 | Bad bearing in driveshaft. Replaced the driveshaft. Broken vacuum harness that controls the automatic locking hubs for the 4wd. Replaced harnesses and hubs. It appears that the vacuum harnesses was broken by an oil change shop when they were checking the fluid in the front differential. | ||
Oct 201567200 miUS $18 | Driver's side sun visor retention clip broke and needed to be replaced. | ||
Nov 201678800 miUS $425 | Passenger mixer door actuator broken. No temperature control for passenger heat. | ||
Jun 201892000 miUS $72 | AC coolant was low. No leaks found. TPS sensor in one tire failed. Needed replacement. |
Ford F-150 in Oregon, United States Jan 2012 - Feb 2012 | |||
Feb 20129000 mi | Fuel pump failure, Vehicle stalled on incline with 1/4 tank of gas |
Ford F-150 in Alberta, Canada Sep 2016 - Mar 2018 | |||
Feb 201779100 mi | cv boot replaced on the front driver side. | ||
Mar 201779980 mi | A rubbing sound from the passenger side occurred after having a cv boot replaced on the front driver side. The intermittent sound went back to the shop twice. Originally I thought the sound had come from repair on the cv boot but the shop thought otherwise. They change the bearing but the sound returned. The sound appeared to disappear when you engaged the four wheel drive. In the end it was determined that when the shop did the cv boot they inadvertently broke the seal on the four wheel drive system on the passenger side. No cost to me to fix the seal as it was their error. |
Ford F-150 in Wisconsin, United States Oct 2010 - Apr 2014 | |||
Nov 20104000 mi | Check engine light came on at mileage 3665. Was checked at dealer and code P2096 00.68 was given. This code does not exist. Was told there was a bulletin on this problem. Computer was reset per ford's recomendation. | ||
Dec 20104000 mi | Check engine light came on again. Code was ran and was told that I needed to replace an o2 sensor. O2 sensor was ordered. Also had an oil change and tires rotated at this appt. O2 sensor replaced. Codes in computer were p02270. H025 connector was also found to be out of spec and was repaired. |
Ford F-150 in New York, United States Sep 2010 - Jul 2022 | |||
Mar 201121000 mi | Power running board motor was seized - dealer replaced motor under warranty. | ||
Oct 201137000 miUS $100 | Passenger side climate control blew out hot air regardless of temperature setting - AC blend controller and blend door motor on passenger side were both replaced | ||
Dec 201265000 miUS $100 | Motor for driver's side power mirror malfunctioned - replaced mirror assembly | ||
Jun 2014102000 miUS $100 | Climate control blender motor was replaced. | ||
Mar 2016124000 miUS $1200 | High pressure line to power steering pump leaking Power running boards not retracting fully Oil pan was rusting thru, oil was weeping out of the bottom. Since this was rust perforation, extended warranty didn't cover replacement. | ||
Jul 2022204000 miUS $287 | Low refrigerant; refilled and added dye to check for subsequent leaks |
Ford F-150 in Quebec, Canada Mar 2012 - Oct 2012 | |||
Apr 201216520 mi | Shifting from 1st to 2nd (and 2nd to 1st)is hard. Was due to lack of grease in the universal joint between the two parts of driving shaft. Dark spot behind mirror surface |
Ford F-150 in Ontario, Canada Jan 2011 - Jun 2022 | |||
May 201115500 miC $125 | Complained of vibration between 50-60 mph. Dealer balanced all tires and replaced 1 tire that was out of spec. | ||
Jul 201118600 mi | Replaced rear differential clutch pack due to excessive grab when cornering. | ||
May 201236580 miC $1250 | Front speakers cutting out intermittently. Dealer replaced both front speakers but problem continued. On third visit, dealer replaced wiring harness. No issues since. | ||
Aug 201349600 mi | Vibration between 80-120 kph. Driveshaft was observed to be vibrating. Driveshaft replaced under warranty. Vibration solved. | ||
Jul 201459180 mi | Broken exhaust manifold studs due to warped manifold. Dealer replaced passenger-side manifold & studs under warranty. | ||
Oct 201463020 mi | Exhaust noise under load. Broken exhaust manifold studs on driver side. Dealer changed driver-side manifold and studs. | ||
Jan 201894860 miC $200 | Upper and lower ball joints | ||
Jun 201899820 miC $185 | Water accumulating in headlight | ||
Jun 2019112220 miC $125 | Right exhaust manifold leaking. | ||
Apr 2021130200 miC $138 | Right Exhaust manifold leak |
310-horsepower 5.4L V8 6-speed automatic RWD
Ford F-150 in Texas, United States Sep 2009 - Jul 2017 | |||
Jul 20118200 mi | Check A/C - Doesn't cool good, never has. I sweat in the Ford for 15 or 20 minutes before it cools enough to be comfortable. Ford says it's working fine. My Chevy much better, has to have blower reduced by the end of my 2 mile road or you will freeze. Low Fuel Mileage, down to a steady 16mpg from 19. |
Ford F-150 in Texas, United States Nov 2014 - Jun 2018 | |||
Oct 2015107200 miUS $192 | replaced original battery, battery failed | ||
Sep 2017130000 mi | truck went to limp mode while driving and got engine check light. shut truck down, after 5 minutes limp mode cleared. read code for check light , had issue with transmission solenoid. cleared code has not re lit believe it was a short. |
Ford F-150 in Louisiana, United States Jul 2010 - Nov 2011 | |||
Nov 201119000 mi | I had no repairs, but one of the releases on the bottom of the rear seats broke just before I traded it in. This latch allowed the release that let the seats back down. |
Ford F-150 in Texas, United States Feb 2011 - Jun 2016 | |||
Mar 201218000 mi | Lubricated CV |
Ford F-150 in Florida, United States Jul 2010 - Dec 2011 | |||
Sep 20105000 mi | Vibration at highway speed. Differential was re aligned |
Ford F-150 in Kentucky, United States Jul 2013 - Aug 2016 | |||
Aug 201374000 mi | replaced center driveshaft boot and regreased spline |
Ford F-150 in Texas, United States Jul 2013 - Dec 2019 | |||
Oct 201358000 mi | Heater vent controls stopped working. Only blowing cold air | ||
Mar 201585000 mi | REPLACED THERMOSTAT AND CLEARED ERROR CODE |
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
Ford F-150 in Utah, United States Feb 2013 - May 2015 | |||
Jun 201353000 miUS $100 | Driver side vents were blowing hot air while passenger side vents blew cold while running AC. Left side TEMP ACTUATOR replaced. AL3Z 19E616 A: MOTOR ASSEMBLY | ||
Jan 201457200 miUS $100 | This time it was the passenger side that was stuck on heat no matter what temperature setting was dialed in. Diverter box on that side was stuck to full heat. |
Ford F-150 in Iowa, United States Jan 2021 - Jun 2022 | |||
May 202197000 miUS $300 | Steering gear was corroded, very hard to turn the wheel |
Ford F-150 in Iowa, United States Mar 2013 - Mar 2015 | |||
Jun 201347000 miUS $500 | A/C quit working. Hole in the condenser. New condenser installed system re-charged. Everything OK. Aluminum condenser not very tough. |
Ford F-150 in Michigan, United States Apr 2016 - Jun 2022 | |||
Jul 201656700 miUS $850 | replaced compressor and some related parts, | ||
Feb 201769000 miUS $600 | brake pad wore out due to frozen caliper. One caliber, both rotors and both pads replaced. | ||
Jun 201775000 mi | AC went out. Bad compressor under warranty from June 2016. Shop did not charge me. | ||
Jun 201885000 miUS $900 | had a bad circuit for the fuel pump causing the fuse to blow. known issue to dealer. had to had a circuit to the fuse box for the fuel pump. | ||
Jun 2022115000 miUS $500 | Replaced trans pan seal, filter and fluid. |
Ford F-150 in New Jersey, United States Jan 2015 - Dec 2016 | |||
Sep 201684000 miUS $800 | Replaced left exhaust manifold |
Ford F-150 in Florida, United States Jul 2017 - Jun 2018 | |||
Dec 2017110000 miUS $155 | Accessory belt, idler pulleys, and tensioner. Tensioner and one idler pulley showed signs of the belt skidding on the pulley. Replaced others as precaution. Belt didn't need replacing but did it anyway. | ||
Mar 2018111000 miUS $150 | Replaced right side manifold due to crack. Used cast iron replacement part. |
Ford F-150 in Minnesota, United States Dec 2012 - Jun 2014 | |||
Sep 201343000 mi | The drivers side speaker kept cutting out. The dealer never fixed it correctly even after two more attempts at getting it right. I finally fixed it right myself and now there's no more issues with my speakers. |
Ford F-150 in Ontario, Canada Sep 2014 - Jul 2018 | |||
Oct 2015119040 miC $2500 | Both exhaust manifolds warped and leaking, replaced. Back up camera failed, replaced. | ||
Jun 2018175460 miC $2000 | Replaced warped exhaust manifolds again. Parts under warranty, paid for labour. Repaired corroded electrical wires controlling rear windows and locks. Rust under doors and in back corner of cab. Quoted $3000 to repair but unsure if I should just run vehicle and let it rust. |
Ford F-150 in Manitoba, Canada Dec 2015 - Mar 2018 | |||
Jan 201620560 mi | Alternator bearings scream when cold. Dealer states no problem, they all do it. Corrosion in the wheels mounting area on three wheels. Dealer acknowledged problem due to manufacturing error with no finish in area of corrosion. Ford Mo Co blamed owner and denied claim. Dealer had wheels refinished on their tab. | ||
Feb 201620960 mi | Door speakers cutting out. They have already been repaired/replaced on three other occasions. Dealer said unable to replicate. | ||
Sep 201622940 mi | Best fuel mileage able to achieve was 15L/100 Klm. Dealer said had to document over 2 full tanks of fuel but didn't think they could do anything. This is no where near figures from Ford for this vehicle. | ||
Nov 201623340 mi | Front struts are leaking. Rear shocks have already been replaced under warranty for same problem. |
Ford F-150 in Arkansas, United States Apr 2016 - Jun 2017 | |||
Jan 201767000 mi | Transmission fluid Leak |
Ford F-150 in Ontario, Canada Sep 2017 - Jun 2022 | |||
Dec 201791760 miC $156 | The driveshaft going into the transfer case was dry causing a ‘slip-bump’ when coming to and leaving from a full stop |
Ford F-150 in Ontario, Canada Mar 2014 - Jun 2018 | |||
Jan 201884196 miC $230 | CEL came on and after scanning the code (P0130) found the upstream O2 sensor (between cat and manifold) on passenger side failed. Replaced the sensor (DY-1165) myself. No more CEL :) |
Ford F-150 in Nebraska, United States Jun 2013 - Jul 2018 | |||
Feb 201674000 miUS $100 | Electric harness for driver side rear door broke that prohibited me from electronically locking and unlocking the door. |
Ford F-150 in Colorado, United States Mar 2011 - Jan 2017 | |||
Jan 2017139000 miUS $374 | Replaced leaking radiator |
Ford F-150 in Manitoba, Canada Jun 2010 - Sep 2011 | |||
May 201114260 mi | Strong wind noise on drivers side door since new. Ended up being a cracked rain gutter at top of door. Once identified, repair done and it's fine. |
Ford F-150 in Florida, United States Jun 2010 - Feb 2015 | |||
Oct 201338300 mi | Rear O2 Sensor Repaced | ||
Aug 201442300 mi | Torque Converter Shutter |
Ford F-150 in Utah, United States Jun 2010 - Mar 2017 | |||
Jul 201223300 mi | Driver seat retracting feature was noisy during operation. |
Ford F-150 in Arizona, United States Apr 2012 - Jun 2022 | |||
Feb 201216000 mi | Serpentine belt snapped and broke off the power steering pump in the process. | ||
Mar 201328000 mi | None of the rear lights working. | ||
Mar 201763000 mi | Transmission shifting hard around 40mph, fixed per Ford TSB. Software update, no charge. |
Ford F-150 in Wisconsin, United States Sep 2010 - Aug 2016 | |||
Jun 201111000 mi | Minor water leak from roof mounted satellite antenna. Dealer followed TSB to repair leak using RTV silicone. | ||
Jul 201339300 miUS $140 | Service noticed unusual wear on ujoint at previous oil/filter service. U-Joint wearing abnromally and needed to be replaced. | ||
Jun 201452000 miUS $96 | Heat shield clamp broke causing a harmonic vibration under cab at idle and at 37 mph. |
Ford F-150 in Texas, United States Aug 2010 - Jun 2022 | |||
May 20102500 mi | Passenger seat heater would not work, resulted in entire cab wiring harness being replaced. Repaired under warranty. | ||
Jun 20103000 mi | Sun visor retaining clips distorted and would no longer keep visors in place. | ||
Aug 201325100 miUS $250 | 3rd brake light / cargo light leaks water down back window during heavy rains. | ||
Feb 201645100 miUS $800 | Power steering cooler leak. | ||
Mar 201646000 miUS $600 | Blend motor failed | ||
Dec 201656000 miUS $250 | 3rd brake light was allowing water to leak into the interior. Leak was fixed. | ||
May 202290000 miUS $300 | Replaced leaking sensor connector. |
Ford F-150 in Alberta, Canada Jun 2010 - Aug 2020 | |||
Jun 201554560 miC $2500 | Warped exhaust headers Air compressor failed |
Ford F-150 in Ontario, Canada Mar 2010 - Jun 2011 | |||
Apr 20101240 mi | Split in seam of leather upholstery Split in seam of leather upholstery - incorrect part ordered | ||
May 20101240 mi | Split in seam of leather upholstery, part replaced |
Ford F-150 in Minnesota, United States Oct 2009 - Jun 2013 | |||
Oct 20107200 mi | Control switch for heater/air conditioner fan replaced |
Ford F-150 in Michigan, United States Oct 2009 - May 2014 | |||
Dec 20091000 mi | doors kept locking and unlocking - loose connection between door and cab. Connection had not seated properly. | ||
Jan 201017000 mi | Keyless entry key pad had a stuck button and the unit shorted out. Truck acted like it had a mind of its own locking and unlocking the doors. |
Ford F-150 in Missouri, United States Dec 2009 - Sep 2012 | |||
Sep 201114000 mi | Transmission shifting problem corrected with ECU reflash per TSB. Phone calls through Sync System are not heard very well by receiving party. Dealer could not duplicate. |
Ford F-150 in Colorado, United States Jan 2010 - Jun 2018 | |||
Mar 201233000 mi | Actuator failed - front passenger side blew hot air regardless of climate setting | ||
Apr 201473500 mi | Doors and tailgate paint is bubbling from beneath. | ||
Dec 201488000 mi | power deployable running board motor failed | ||
Jul 2016107500 miUS $500 | Intermittent check engine light leaking front strut |
Ford F-150 in California, United States Mar 2010 - Jun 2022 | |||
Jun 201132000 miUS $10 | the receiver end of sun visor broke so i had to purchase another one and luckily the part was in stock | ||
Nov 201256200 miUS $50 | The gas door hinge spring broke so door would not stay shut. I bought new hinge with spring and it was installed in 15 minutes. | ||
Jul 201366700 miUS $170 | The right rear shock was bent and was replaced with a new shock |
Ford F-150 in North Dakota, United States Jan 2010 - Sep 2012 | |||
Nov 201010000 mi | The rear end has a hop on concrete roads that is more than annoying. The hop drives up into the cab and is very noticeable when driving at speeds over 55. This is a common problem with Ford F150's that is being ignored by Ford Motor. |
Ford F-150 in Minnesota, United States Oct 2010 - Jun 2011 | |||
Feb 201118000 mi | Took truck in to the dealer for oil change and tire rotation. Mechanic discovered a slight leak at the pinion seal. Scheduled a time for repair the following week. Pinion seal was replaced. |
Ford F-150 in Ontario, Canada Aug 2010 - Dec 2014 | |||
Apr 201221280 mi | Leaking shock replaced rear left. |
Ford F-150 in California, United States Dec 2010 - Sep 2014 | |||
Mar 201217000 mi | Fuel filler door came off of its hinge. Dealer had to take it out and reset it onto the hinge. | ||
Feb 201444000 miUS $700 | 1 leaking rear shock and 1 leaking front strut. Ended up replacing all 4 out of pocket as factory warranty had expired 8k miles ago |
Ford F-150 in Minnesota, United States Mar 2010 - Sep 2012 | |||
Sep 20105705 mi | Reflashed the transmission control module memory. Reflashed the transmission control module memory. | ||
Apr 201222000 mi | Oil leaking at output shaft seal for rear driveshaft. Remove driveshaft and install new seal |
Ford F-150 in Oregon, United States Nov 2010 - Jun 2015 | |||
Mar 20113000 mi | hard dowshift from 2-1, shop did a reflash of transmission module |
Ford F-150 in Arizona, United States Aug 2009 - Nov 2018 | |||
Jul 20109000 mi | Transmission 1-2 upshift harshness fixed with reflash. Sync reflashed. Latch on center console replaced as it would not latch. | ||
Nov 201014000 mi | A/C not working well. By comparing high pressure readings against a new vehicle on the lot it was determined that a reflash of the PCM would remedy the situation. According to dealership, A/C pressures were the same following the reflash. It was determined that a front strut was leaking and not assembled correctly at the factory. A new strut and related hardware were ordered. Parts arrived (after dealer verified owner's observation of a leaking and misassembled front strut assembly on previous visit) and were installed at this time. | ||
Jun 201235000 mi | Despite a PCM reflash in 2010, the AC still was "underperforming" when temps exceeded 95 degrees. Tech found a later reflash which improved AC function to be more in line with what it should have been (41 degree discharge air/105 ambient). | ||
Jan 201310200 miUS $90 | Took in for wheel alignment prior to installing new tires. Mechanic noticed battery was cranking slowly, suggested replacing soon. Battery replaced by owner with Interstate battery from Costco. | ||
Mar 201682000 miUS $380 | A "bulkhead" connector developed a leak necessitating removal of the pan, to access the offending part. Parts included connector, pan gasket, replacement transmission fluid. | ||
Jun 201793000 miUS $305 | Replaced sun-deteriorated Urethane steering wheel with new leather steering wheel. |
Ford F-150 in New Hampshire, United States Oct 2010 - Sep 2011 | |||
Jan 2011 | Weatherstripping on rear doors was defective causing wind noise. Replaced under warranty. When key is removed from ignition the chime would still ding like the key was still in the ignition and easy exit feature did not work. Problem was intermittent. Dealer could not replicate. Dealer lubricated key slot. | ||
May 20114500 mi | Transmission was shifting hard. Dealer reprogrammed computer. Wind noise on highway. Dealer adjusted doors. Front passenger seat squeaks over bum | ||
Sep 20117000 mi | Glass in front of speedometer was scratched. Dealer stated ford would not repair. They did admit that it should not scratch that easily. |
292-horsepower 4.6L V8 6-speed automatic RWD
Ford F-150 in California, United States Sep 2010 - Jan 2020 | |||
Jul 201342500 miUS $300 | Dealer could not duplicate; test drove truck with diagnostic computer, no concerns noted; downloaded/installed latest PCM calibration. Would have cost $300 if didn't have maintenance contract. | ||
Dec 201349000 mi | Same as last reported issue. While decelerating from freeway speeds, engine would run very rough and then die when truck came to complete stop. Dealer replaced throttle body, flashed the ECM, and replaced the torque converter (for same problem). | ||
Aug 201571000 mi | Poor gas mileage. MPG down to 15mpg vs 17mpg over the previous 5 years | ||
Dec 201683000 miUS $550 | Transmission pan gasket was leaking and was replaced. Transmission bulb head connector was leaking and gasket was replaced. |
Ford F-150 in Texas, United States Jun 2019 - Jun 2022 | |||
Jun 2019110000 miUS $1200 | New Radiator and flush cooling system | ||
Aug 2019115000 miUS $400 | New Rotors and Pads on Front and Rear | ||
Feb 2020120000 miUS $325 | Replace Steering Wheel - Cover coming off |
Ford F-150 in Texas, United States Nov 2011 - Nov 2012 | |||
Mar 201249000 miUS $450 | third brake light leak, fomoco paid half out of warranty cost |
Ford F-150 in Texas, United States Jun 2014 - Jan 2015 | |||
Jun 201468000 miUS $30 | Driveshaft acting like it had slack in it | ||
Sep 201481000 mi | Again driveshaft acting like it had slack in it and it was lubed again | ||
Jan 2015 | Again the drive shaft ia acting like it has slack in it. I'm sure they will say it needs to be lubed with a special lube that onkly Ford has. This seems to be a problem in the 2010-2011's |
Ford F-150 in Mississippi, United States Jun 2010 - Feb 2013 | |||
Jan 20115000 mi | Harsh shift from 2nd to 1st when coming to stop at slow speed. Reflashed PCM/TCM to correct the issue. |
Ford F-150 in Oklahoma, United States Aug 2013 - Apr 2015 | |||
Oct 201317300 miUS $148 | Original battery had a bad cell. Replaced with Ford BXT-65-750 which is an upgrade from 650 cranking amps battery on the original. |
Ford F-150 in Tennessee, United States Jun 2010 - Jun 2012 | |||
Feb 20118000 mi | Two piece driveshaft free play causing clunk on downshifts and "slipping feeling" on takeoff from stop. Dealer lubed connecting shafts and put 2 clamps on the shafts. Fix may or may not hold up over time | ||
Jun 201224000 mi | Install shim kit to correct driveshaft angle. All warranty work. Also the slip yoke was again lubed with heavy grease to eliminate the "slip-bump" on take off. |
Ford F-150 in Oklahoma, United States Aug 2016 - Sep 2020 | |||
Sep 2016127000 miUS $54 | Replaced canister purge valve silenoid. |
Ford F-150 in Washington, United States Oct 2015 - Sep 2021 | |||
Dec 201548000 miUS $645 | Cluster replace | ||
Apr 201649000 miUS $26 | Regrease yolk joint to prevent binding. Sometimes needs replacement of the yoke with a chrome one (in the spline area). Dealer quoted $295. |
292-horsepower 4.6L V8 6-speed automatic 4WD, part-time w/low range
Ford F-150 in Illinois, United States Feb 2013 - Jan 2022 | |||
May 201441000 miUS $305 | The purge valve on the evaportative canister was replaced as related to TSB 11-1-5. Truck had rough idle, stalled twice while driving, and hard start condition after fueling. | ||
Apr 201682800 miUS $4500 | Transmission failed. Lost 5th gear and metal throughout. Took to dealer hoping Ford would help with the cost of the repair. After 12 days, Ford said no help. Now at trans shop waiting for re-manufactured transmission to be installed. | ||
Oct 2017117000 miUS $425 | Had 2 pulleys go bad. The tensioner pulley and the center ribbed pulley. Also replaced the Serpentine belt. The pulleys had been making noise for months, and thought it was the power steering pump. |
Ford F-150 in Connecticut, United States Jan 2016 - Jul 2022 | |||
Jul 2022148000 miUS $500 | Alternator failed |
Ford F-150 in Wisconsin, United States Nov 2010 - Aug 2013 | |||
Dec 20101000 mi | Ticking fuel injectors, all like that. Not fixed. | ||
Aug 201330000 mi | Left speakers occasionally did not work. |
248-horsepower 4.6L V8 4-speed automatic RWD
Ford F-150 in Texas, United States Sep 2010 - Jun 2022 | |||
Jul 2017127000 miUS $350 | AC not cooling, previously diagnosed by dealer as a hose leak. Worked better but there's still an issue. | ||
Jun 2021157000 miUS $3500 | replace ALL coils and plugs about $2,000 total replace cracked manifold..... repair cost about $1000 earlier replacement of break pads had to be redone because front pads had been installed incorrectly. warped rotors. total PITA. cost about $300. Problem caused by a DIFFERENT repair shop earlier in the summer of 2021 |
310-horsepower 5.4L V8 6-speed automatic 4WD, part-time w/low range
Ford F-150 in British Columbia, Canada Oct 2014 - Dec 2016 | |||
Dec 201455180 miC $50 | cataletic oxygen sensor. Dealer did not have in stock and ordered it and then replaced it the next day. Excellent service |
Ford F-150 in Michigan, United States Apr 2011 - Jun 2018 | |||
Nov 201124000 miUS $30 | The traction control system would indicate failure erratically. Sometimes weeks apart. No codes were in the computer when they checked at the dealer. | ||
Feb 201227000 mi | Clip that retained the drivers side sun visor was not holding properly. It was replaced. | ||
Sep 201235000 mi | Traction control failure light comes on intermittently. It has since vehicle was new. The transmission temperature indicator started to indicate erratically. It used to reach normal temperature in 4-5 miles of driving or less. At times now it takes 15 miles. One day both the fuel gauge and the trip computer's distance to empty were reading erratically. But no codes and dealer could find nothing wrong. Hasn't happened again since. | ||
May 201346000 miUS $26 | After backing down a long driveway (1/8 mile) the Check Engine light came on. The dealer found a code that said "turbine shaft speed discrepancy" caused the light. I had them cancel the code and it has not happened again. | ||
Jul 201348000 mi | FORD emblem on the front grill was corroding and peeling. | ||
Feb 201562000 miUS $250 | Noticed rust below the doors and behind the cab. It was fairly heavy rust and not light surface rust. Had body shop clean off the rust and spray Line-ex over the area. | ||
Oct 201568500 miUS $500 | Premature rust in painted areas. Tailgate and wheel wells. |
292-horsepower 4.6L V8 6-speed automatic RWD
Ford F-150 in Ontario, Canada Mar 2014 - Jun 2018 | |||
Nov 2017161820 miC $1780 | exhaust manifold bolts - only 2 on left side and 3 on right side were not broken. The rest were broken and had to be drilled. 4X2 truck - remove bolts on rear trans mount , remove front engine mount bolts, rotate engine to get at manifold bolts. | ||
Feb 2018172980 miC $574 | after driving 100km, stopped, put in reverse, stalled in 2 seconds. Started in park ok, stalled when put into D or R. Started and ran ok, Oil alarm said 2% left... not true, only 4,00km on oil. Towed to dealer, they had it 2 days - changed oil, -COULD NOT FIND ANY PROBLEM. - $575 for oil change and diagnosed 2 problems that they caused while working on the truck! Truck ran for 2 weeks.. now same problem and maybe torque converter gone...off to tranny shop now! |
Ford F-150 in Alberta, Canada Nov 2010 - Jun 2022 | |||
Sep 20116820 miC $175 | Remote start disabled by cab light switch | ||
Mar 20129300 mi | shudder on 321 downshifts | ||
Sep 201212400 mi | shudder on 321 downshift. TSB called for overhaul of Main control valve. | ||
Mar 201526040 miC $100 | Tailgate lock seized | ||
May 201632740 miC $300 | Driveshaft slip joint service |
248-horsepower 4.6L V8 4-speed automatic RWD
Ford F-150 in Ohio, United States Aug 2010 - Mar 2013 | |||
Oct 201238000 mi | 3rd brake light leaked |
Ford F-150 in Ontario, Canada Oct 2010 - Jul 2016 | |||
Aug 201223560 mi | Technician discovered leaking left-rear shock absorber during an oil change. Shock absorber replaced under warranty. | ||
Aug 201552560 mi | Heat-shield loose, causing a rattling noise. Mechanic replaced fasteners. |
Ford F-150 in Virginia, United States Jun 2014 - Jun 2018 | |||
Mar 2015112000 miUS $165 | Ignition coil replaced | ||
Jan 2016110800 miUS $1500 | New ignition coils Front caliper stuck, new rotors and pads for front | ||
Mar 2017135000 miUS $795 | Replaced intake head gasket. Leaking coolant and oil. |