| 1 | 0 | 3 | 4 | 3 | 4 |
2011 Ford Fusion repairs by problem area
Engine (26%)
Transmission and Drivetrain (14%)
Brakes and Traction Control (8%)
Suspension and Steering (14%)
Electrical and Air Conditioning (23%)
Paint, Rust, Leaks, Rattles, and Trim (6%)
Other (9%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 160 repairs.
2011 Ford Fusion electrical repair cost distribution
$2500+ (0%)
$1000 - $2499 (3%)
$500 - $999 (3%)
$100 - $499 (42%)
< $100 (52%)
Chart based on 33 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2011 Ford Fusion 4dr Sedan
263-horsepower 3.5L V6 6-speed shiftable automatic FWD
| 13300 mi | Sync system stopped playing USB music. System was reset by disconnecting power to fix. |
2011 Ford Fusion 4dr Sedan
263-horsepower 3.5L V6 6-speed shiftable automatic AWD
| 14880 mi | Replace cabin air blower motor. Warranty paid |
| 2980 mi | Lumbar support not working. |
2011 Ford Fusion 4dr Sedan
240-horsepower 3.0L V6 6-speed shiftable automatic FWD
| 16500 mi | Battery corrosion around battery terminals. |
| 29000 mi | Same problem battery terminal corrosion. Recleaned battery terminals. |
| 80000 mi | Driver Seat Heater element was replaced. |
| 55700 mi US $5 |
Replaced, for the 2nd time, right rear turn signal light. |
| 60000 mi US $100 |
Replace blower motor |
| 1700 mi | APIM module for SYNC system determined defective at earlier visit, dealer ordered part, was replaced. Seems to be functioning so far. |
| 80000 mi US $1500 |
Issue with air conditioning, believe it was the.blower motor and module |
2011 Ford Fusion 4dr Sedan
240-horsepower 3.0L V6 6-speed shiftable automatic AWD
| 54300 mi US $150 |
Battery lost a cell. |
2011 Ford Fusion 4dr Sedan
175-horsepower 2.5L I4 6-speed shiftable automatic FWD
| 99000 mi US $735 |
A/C compressor failed resulting in complete replacement of unit as well as flushing of complete system and evac/recharge |
| 105000 mi US $194 |
left front headlamp assembly required replacement due to a faulty socket |
| 9920 mi | External temperature sensor broke, car showed -33C all the time. |
2011 Ford Fusion 4dr Sedan
175-horsepower 2.5L I4 6-speed manual FWD
| 16000 mi | ECU failed while driving the car just shut off and would not turn back on. |
2011 Ford Fusion 4dr Sedan
175-horsepower 2.5L I4 6-speed automatic FWD
| 60000 mi US $75 |
Replaced compressor pulley due to high pitched whine. |
| 32200 mi US $100 |
car needed multiple jump starts. battery needed replacement. Also did the recall repair on the throttle body. |
| 106000 mi US $100 |
Blower motor intermittent. checked connections, still failing about half the time. |
| 113000 mi US $45 |
Blower motor resistor and control module failed. Contacts overheated and continuity was intermittent with increasing failure frequency. Dealer wanted 200 for part NAPA 175 Amazon $45. Works good now, not sure how long it will last. |
| 4200 mi | Sync system stopped accepting voice commands. Dealer updated Sync software. |
| 40800 mi US $95 |
Ticking noise when blower fan on low setting. Dealer first tells me 300+ for assy replacement, then finds TSB to replace fan only. Sadly out of warranty, so out of pocket. |
| 110000 mi US $400 |
HVAC controls quit working, entire control assembly in dash had to be replaced. |
| 58280 mi | High pitched whine - the car almost sounded like it had a turbo kicking in - which it did not. Known issue. Probably something to do with the alternator. |
| 90700 mi US $400 |
Battery cable was corroded and entire harness had to be replaced. Unable to just replace the positive battery cable. |
| 28000 mi | Heater fan made high pitch noises. It was replaced under warranty. |
| 35000 mi US $150 |
Battery gone bad and burned out signal light. |
| 34040 mi C $200 |
Battery was replaced. |
| 32000 mi | TPMS Failure |
| 54000 mi | Fan assembly squeaked when running. |
| 95800 mi US $175 |
Battery life low - did not replace |
2011 Ford Fusion 4dr Sedan
156-horsepower 2.5L I4 Hybrid CVT FWD
| 65005 mi US $130 |
Replaced factory 12 V battery. |
| 91760 mi C $75 |
Just replace a burnout headlamp. Two were replaced since it is recommended to replace two together. |
| 58200 mi US $290 |
The battery shorted out after 4 months of non-use sitting out in the Texas sun. |
| 89000 mi US $120 |
Replaced battery. |
| 75000 mi US $400 |
Window Regulator replacement |
2011 Ford Fusion 4-door
6-cylinder manual 2WD
| 28500 mi | air would start cold then turn hot |
See TrueDelta's information for all Sedans
See TrueDelta's information for all Ford models.
