Worried about potential repair costs? An extended warranty can provide peace of mind.
Chart based on 16 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
Purge valve needed replacement due to delayed closing
56000 mi
US $50
Air intake was no longer affixed to turbo causing increased turbo whine and decreased performance requiring replacement of bolts-not covered under warranty
Water pump found to be leaking during service and replaced under warranty recall repairs to coolant sensor performed
Replaced the purge valve assembly after check engine light revealed code P 01450. The Ford dealer fixed it while also doing the 60 thou mile service. Cost me the 100 dollar ESP care deductible. It was causing the car to have trouble starting after refueling.
26000 mi
Water pump was replaced
34000 mi
Engine vibrating at idle, both in gear or in neutral. Chaffed wires in dash were suggested as the culprit. Fixing them didn't fix the vibration.
Check engine light was on. Diagnosis was done but no fault was found. The check engine light was reset.
35000 mi
R&R timing chain cover due to oil leak.
6000 mi
When the car runs on the gas motor it vibrates thru the steering wheel, gas pedal, brake pedal.And makes a lot of noise from the engine. When it goes back to electric, it has no vibration & no noise. Dealer said this is normal for the hybrid
15000 mi
When the car runs in gas mode only the engine is very noisy and has a lot of vibration coming thru steering wheel, center console etc. The tech had me drive a new Fusion Hybrid & it did the same thing. Plan on getting rid of car ASAP.
21800 mi
US $45
Gas engine vibrates & makes excessive noise. Runs fine when in electric mode.
See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how
frequently 2014 Ford Fusion problems occur, check out our car reliability stats.