| 1 | 0 | 3 | 4 | 3 | 4 |
2001 Volvo S60 repairs by problem area
Engine (37%)
Transmission and Drivetrain (14%)
Brakes and Traction Control (2%)
Suspension and Steering (27%)
Electrical and Air Conditioning (16%)
Paint, Rust, Leaks, Rattles, and Trim (1%)
Other (3%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 150 repairs.
2001 Volvo S60 transmission repair cost distribution
$2500+ (22%)
$1000 - $2499 (17%)
$500 - $999 (4%)
$100 - $499 (35%)
< $100 (22%)
Chart based on 23 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2001 Volvo S60
Engine not specified
2001 Volvo S60 4dr Sedan
turbocharged 247hp 2.3L I5 5-speed shiftable automatic FWD
| 33060 mi $4680 |
Car could not change gears. Transmission replaced. |
| 104160 mi $4000 |
Transmission failed and replaced. Later replaced two more times under warranty. |
| 114080 mi $875 |
Trans fluid contaminated because of broken breather valve. Drained and refilled 4 times. Breather valve was replaced. |
2001 Volvo S60 4dr Sedan
turbocharged 197hp 2.4L I5 5-speed shiftable automatic FWD
| 91500 mi US $175 |
INNER CV JOINTS 'LOOSE' CAUSING VIBRATION AT ALL SPEEDS WHILE ONLY UNDER LOAD [GIVING IT GAS];COASTING/OFF GAS PEDAL NO VIBRATION... REPLACED BOTH JUST IN CASE [PSSGR SIDE MOST PLAY]. |
| 90200 mi | trans clutch error code; software update... |
2001 Volvo S60 4dr Sedan
turbocharged 197hp 2.4L I5 5-speed automatic FWD
| 157500 mi US $3200 |
rebuild of transmission |
| 166000 mi US $330 |
cracked cv boot |
| 180000 mi | tranmission failing, traded car in. |
| 110000 mi US $3000 |
Transmission overhauled. Removed and rebuilt by myself after much study. Spent over $1800 on parts and another $400 on machine work. Transmission overhauled. Removed and rebuilt by myself after much study. Spent over $1800 on parts and another $400 on machine work. |
| 114000 mi | Tranny went out. |
| 174000 mi US $272 |
Full transmission flush required after experiencing transmission slips. Check engine light came on, and "transmission svc. req." msg appeared. Previous flush was >53K miles. Flush fixed problem. |
| 187000 mi | Transmission needed to be replaced, and would have cost more than the car is worth. Decided to register it as non-operational. |
2001 Volvo S60 4dr Sedan
168-horsepower 2.4L I5 5-speed manual FWD
| 117800 mi C $1500 |
Clutch replacement - disc, pressure plate, release bearing, slave cylinder, rear main seal |
| 120040 mi C $300 |
Noise from rf cv joint - replaced axle shaft with aftermarket part |
| 124620 mi C $160 |
replacement of driver's side axle shaft replaced left side axle shaft |
| 129260 mi C $150 |
replaced defectivea aftermarket right side axle shaft to address vibration under load - repeat of repair from last year |
2001 Volvo S60 4-door
turbocharged 5-cylinder automatic 2WD
| 83080 mi C $1600 |
Transmission failure due to gear slippage in gears 1, 2, and 3 (repair replaced the planetary gears and associated parts). |
| 95000 mi US $4000 |
TOTAL transmission failure. Rebuild uneconomical - new transmission needed and installed. |
2001 Volvo S60 4-door
5-cylinder automatic 2WD
| 102000 mi | Transmission failed, got rid of car. |
See TrueDelta's information for all Sedans
See TrueDelta's information for all Volvo models.
