| 1 | 0 | 3 | 4 | 3 | 4 |
2002 Volvo S60 repairs by problem area
Engine (33%)
Transmission and Drivetrain (11%)
Brakes and Traction Control (2%)
Suspension and Steering (27%)
Electrical and Air Conditioning (22%)
Paint, Rust, Leaks, Rattles, and Trim (1%)
Other (5%)
Chart based on 200 repairs.
2002 Volvo S60 repair cost distribution
$2500+ (4%)
$1000 - $2499 (17%)
$500 - $999 (17%)
$100 - $499 (30%)
< $100 (31%)
Chart based on 162 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2002 Volvo S60
Engine not specified
| Volvo S60 in Texas, United States Dec 2007 - Mar 2010 | |||
| Jan 200864000 miUS $425 | One of the sensors on the engine, it took one minute for him to put it on, but apparently I was paying an hour of labor to guarantee...whatever. | ||
| Volvo S60 in Minnesota, United States Jun 2014 - Feb 2015 | |||
| Jan 2015US $50 | A fuse was replaced! | ||
| Feb 2015130000 mi | Fuel pump leak (?) | ||
| Volvo S60 in Great Britain Jun 2009 - Mar 2010 | |||
| Jul 200991000 mi£50 | rear swaybar link broken. replaced myself with new part. | ||
2002 Volvo S60 4dr Sedan
turbocharged 247hp 2.3L I5 5-speed shiftable automatic FWD
| Volvo S60 in Oklahoma, United States Nov 2009 - Oct 2013 | |||
| Jan 2010125000 miUS $1250 | Leaking fuel pump replaced. | ||
| Dec 2010125000 miUS $252 | Replaced strut pads, A-arms, left sway bar link, and steering rod. Performed front end alignment. Replaced cv joint boots, right side. | ||
| Aug 2011133000 miUS $1100 | Timing sprocket on end of camshaft had worked loose, generating check engine light. Timing belt replaced at same time | ||
| Jan 2012117000 miUS $700 | alternator shaft wear causing alarming noise and shedding metal dust | ||
| Jan 2013149000 miUS $787 | replace lower A-arms, front, both sides replaced damaged CV boot on right front axle | ||
| May 2013153000 miUS $680 | Front struts worn out, and broken right front strut pad. | ||
| Sep 2013156000 miUS $120 | Car developed large oil leak at intake cam seal. $700. While accessing intake cam seal, replaced original water pump as a preventative action. Check engine light illuminated and "Transmission Service Required" message appeared. Software update/upgrade was performed. Fluid level was slightly low, was filled to correct level. Fluid quality was checked and found O.K. | ||
| Oct 2013156000 mi | Check engine light re-illuinated and repeat of transmission service required message. Dealer determined transmission solenoids going bad and recommended transmission replacement ($5,000). Car currently driveable, no telling how long before it isn't. | ||
| Volvo S60 in Indiana, United States Sep 2009 - Feb 2022 | |||
| Nov 200978000 miUS $1300 | Replaced timing belt, water pump, coolant, drive belt and had an alignment. | ||
| Jun 2012104000 miUS $28 | Evap Code being thrown. Researched and found that old rubber on gas cap was allowing vac leak. Replaced gas cap with new OEM and solved problem | ||
| Jun 2014108000 miUS $200 | Problem with Dash electrical. DIM unit was faulty and needed to reflow the solder on the circuit board. Everything works perfectly now. | ||
| Aug 2014108000 miUS $150 | Alignment, checked suspension and couldn't find source of noise Repaired and replace faulty tie-rod on front steering as well as refreshed the control arm bearing. Replaced the engine frame mount on the passenger side of K frame. | ||
| Jun 2017108000 miUS $400 | Replaced PCV hose and coolant line to engine due to worn and broken part in hose line. Removed most parts surrounding engine and replace all clamps and coolant hoses and gaskets. | ||
| Jul 2018108000 miUS $50 | Voltage regulator faulted resulting in a new part needing to be installed. Repaired with new OEM part. Most of the work was in removing other parts to gain access to the back of the alternator. | ||
| May 2020109000 miUS $400 | Transmisson would hesitate going into Reverse from Drive selector | ||
| Volvo S60 in New Zealand Feb 2015 - Dec 2016 | |||
| Jun 2015115320 mi$30 | Problem with shift flares and alarms with trans. remove solenoids, take apart and clean debris assemble and replace end cap. Refit to trans | ||
| Volvo S60 in California, United States Mar 2014 - Jul 2017 | |||
| Nov 2014135000 miUS $400 | Spark plugs and ignition coil replacement | ||
| Jun 2017167000 miUS $1500 | Replaced struts | ||
2002 Volvo S60 4dr Sedan
turbocharged 247hp 2.3L I5 5-speed manual FWD
| Volvo S60 in Illinois, United States Apr 2012 - Dec 2012 | |||
| Apr 2012113000 miUS $1000 | Before cat O2 sensor and timing belt according to man. recs. | ||
| Volvo S60 in Pennsylvania, United States Dec 2008 - Aug 2010 | |||
| Feb 2009112000 miUS $50 | Wrong coolant. Had it flushed and put Volvo stuff in. | ||
| Jul 2009116000 mi | Replaced rear main seal. | ||
| Aug 2009118000 miUS $1000 | Replaced front control arms/bushings. Replaced rear shock mounts. Replaced all struts/shocks. | ||
| Dec 2009124000 mi | Shop incorrectly installed owner-supplied rear-main-seal and refused to take responsibility for the part failing... After replacing the rear main seal, the axle fell out of the CV joint on the passenger's side rendering the car powerless. | ||
| Jun 2010125000 miUS $700 | Starter motor inconsistently not working. Was fixed by cleaning electrical connections. Inner tie-rods replaced due to being loose. | ||
| Volvo S60 in Michigan, United States Aug 2008 - Sep 2015 | |||
| Jun 2009110000 miUS $380 | Turbo sensor | ||
| Oct 2013147200 miUS $700 | AC condenser replaced and recharged | ||
| Dec 2013148000 mi | Leaking Pwr steering pump and rack and pinion. Estimated repair cost $1,500. | ||
| Jan 2014148000 mi | Took vehicle to another repair shop. They tightened clamp, no power steering problem now. Filled the reservoir. No charge. Incredible. | ||
| Aug 2014150000 miUS $350 | Intermittent problem with A/C clutch. Unclear if same issue as before, or a different one. New shop specializes in Volvos, will rebuild the clutch. | ||
| Jun 2015163000 miUS $10 | Head lamp connector melted. Required a new connector kit (installed myself). | ||
| Volvo S60 in Pennsylvania, United States Dec 2007 - May 2010 | |||
| Aug 200889000 miUS $200 | Upper spring and strut seat replaced. | ||
| Feb 2009101000 miUS $1500 | Old struts and shocks worn - replaced with Bilstein. Note - old struts wore quicker because car was lowered and they were original. Tie rods replaced. | ||
| May 2009108000 miUS $100 | TCV (waste gate solenoid) starting to fail. Replaced with IPD Heavy Duty TCV in anticipation of further modifications | ||
| Jun 2009110000 miUS $2000 | Slave Cylinder failed at 109,000 miles. Clutch, slave cylinder, throwout bearing replaced. Flywheel resurfaced. | ||
| Jul 2009111000 miUS $100 | CEL and hesitation. MAP sensor repaired 100 dollars and less than 1 minute | ||
| Aug 2009115000 miUS $250 | spring seats with only 10k failed - manufacturing issue - mechanic paid for 1/3rd (full price of parts) owned paid for labor. | ||
| Mar 2010129000 miUS $200 | Drivers side door handle did not open door - repair required replacement of entire door panel - mechanic repaired utilizing zip ties at fraction of cost. | ||
2002 Volvo S60 4dr Sedan
turbocharged 197hp 2.4L I5 5-speed shiftable automatic FWD
| Volvo S60 in Pennsylvania, United States Feb 2010 - Nov 2015 | |||
| Mar 201072000 miUS $300 | Front wheel bearing hub replacement | ||
| Feb 201180000 miUS $200 | Side marker light Engine mount | ||
| Jan 201288000 miUS $250 | Replaced inner tie rod and rubber boot. | ||
| Oct 201296200 miUS $31 | Replaced gas cap with faulty gasket. | ||
| Dec 2014117000 miUS $750 | Replace fuel pump | ||
| Jul 2015120000 miUS $300 | replace starter | ||
| Volvo S60 in California, United States Mar 2009 - Jun 2011 | |||
| Apr 200988000 miUS $425 | Rocker arm front and rear bushing on front suspension. | ||
| Sep 200991000 miUS $120 | oil leak at turbo oil inlet | ||
| Jun 2010101000 miUS $130 | Front end rattle when driving over rough surface. Outer tie rod and end links where replaced due to wear. | ||
| Oct 2010103000 miUS $223 | Replaced failed alternator. For preventive maintenance replaced serpentine belt and tensioner at the same time. | ||
| Volvo S60 in California, United States Sep 2010 - Jan 2012 | |||
| Oct 2010106000 miUS $1000 | Alternator failed | ||
| Jan 2011114900 miUS $1000 | Replaced front struts and strut bushings | ||
| Aug 2011117000 mi | Noise - a bit like a vacuum leak - mostly from drivers side. Steering column boot came loose. Noise - a bit like a vacuum leak - mostly from drivers side. Steering column boot came loose. | ||
| Volvo S60 in Kentucky, United States Nov 2015 - Dec 2015 | |||
| Dec 2015101000 mi | The ABS Failure Lamp has illuminated, as well as the Check Engine Lamp. Car was taken to dealer. Front drivers side wheel has a "strange, subdued vibration while driving". It's like driving over really flat pillows. | ||
| Volvo S60 in Washington, United States Jan 2007 - Nov 2009 | |||
| Feb 200751472 miUS $333 | upper engine strut replacement left rear door lock assembly internal malfunction,replaced lock | ||
| Dec 200764435 mi | radiator leak.Replaced radiator | ||
| Dec 200879239 mi | replaced worn RF sway bar link.covered under extended warranty | ||
| Oct 200991764 mi | Replaced RF door latch Installed RF door module covered under extended warranty. Replaced RF door latch. Installed RF door module. Covered under extended warranty. | ||
| Volvo S60 in California, United States Jan 2008 - Mar 2010 | |||
| Dec 2009140000 miUS $48500 | Needed automatic transmission replaced. | ||
2002 Volvo S60 4dr Sedan
turbocharged 197hp 2.4L I5 5-speed shiftable automatic AWD
| Volvo S60 in Colorado, United States Nov 2011 - Feb 2016 | |||
| Jun 2015134000 miUS $800 | Inner tie rods needed replaced. Caused need for new tires as well | ||
| Feb 2016156000 miUS $250 | Dash Cluster went out shop replaced using part I bought of Ebay | ||
| Volvo S60 in Minnesota, United States Aug 2011 - Sep 2011 | |||
| Sep 2011133000 miUS $1700 | Tie rod worn out, struts leaking. | ||
| Volvo S60 in British Columbia, Canada Jun 2012 - Jun 2013 | |||
| Jul 201276260 mi | Starting 110k, would not shift smoothly to 4th and 5th gear. the est. repair cost by a trust worthy independent mechanic was $2,8000CAD. | ||
| Nov 201276880 miC $3300 | Done a transmission overhaul to repair the problem shifting into 4th gear. 3,300 later, now the entire car kicks violently shifting when slowing down to turn and then accelerating halfway through the turn. | ||
| Jun 201376880 mi | in last transmission overhaul, mechanic introduced a mis fire whenever shifting down from 2nd to 1st then immediately back up to 2nd. did the overhaul again replacing control board and now it is much smoother, problem still exists. AC was not cooling the cabin, so setting the climate control would cause the AC to pump unceasingly, creating a very loud cabin. | ||
| Volvo S60 in California, United States Jan 2008 - May 2008 | |||
| Feb 200864000 miUS $781 | Column lock replacement. Safety interlock cable replacement. | ||
| Mar 200864000 miUS $800 | Oil leak at turbo seal. | ||
| Volvo S60 in Washington, United States Nov 2010 - Mar 2013 | |||
| Dec 201087000 miUS $295 | Gas filler door fell off, when opened in our driveway. Therefore it was recovered undamaged, but required parts to re attach it. | ||
| Mar 201188000 miUS $740 | Drivers heated seat failed; not repaired due to cost | ||
| Mar 201399000 mi | Driver's heated seat did not work. Suspension worn out. | ||
| Volvo S60 in Illinois, United States Apr 2011 - Jul 2011 | |||
| Jun 201175000 miUS $735 | Electrical system failed while driving, towed to the shop. Battery and alternator replaced. | ||
| Volvo S60 in British Columbia, Canada Jan 2011 - Sep 2016 | |||
| Feb 2011168640 mi | Intermittent CPU fault causing car to go into reduced power mode AWD system has stopped functioning no drive to rear wheels | ||
| Mar 2011168640 miC $250 | Noise in the right front suspension. Right front spring mount replaced. | ||
| May 2012174820 miC $85 | Turbo pressure solenoid changed | ||
| Oct 2012177940 mi | The S60 has problems again with the turbo boost control so I am letting her sleep for a while. | ||
| Oct 2014182880 miC $600 | installed rebuilt instrument cluster Turbo surging. I put in a Turbo control valve from IPD. | ||
| Dec 2014186000 mi | Hoses loose on turbo triggered engine fault light. | ||
| Apr 2015188480 miC $1200 | New fuel pump and filter New turbo hose | ||
| Oct 2015193420 miC $300 | replaced an ignition coil | ||
| Nov 2015194680 miC $397 | Left Front ball joint AWD Haldex System no power to back wheels | ||
| Feb 2016198840 miC $180 | replaced front and rear sway bar links replaced resonator | ||
2002 Volvo S60 4dr Sedan
turbocharged 197hp 2.4L I5 5-speed automatic FWD
| Volvo S60 in California, United States Nov 2013 - Aug 2018 | |||
| Dec 2013184000 miUS $1100 | Left and Right tie rod ends, lower control arms and upper spring seals were replaced. | ||
| Apr 2014188200 miUS $3214 | Out right axle boots were torn and replaced, as were the inner and outer CV boots Lower mounts had collapsed and needed to be replaced. | ||
| Aug 2014194700 miUS $6681 | AC was not cooling. Inspection disclosed that Compressor was not engaging the clutch, so the Compressor was changed. Fan/Blower (for AC) would fluctuate wildly. The Blower Motor Resistor was replaced. I was getting a SRS/Airbag warning. From the repair order: "Found DTC SRS-00D4 SRS Lamp Faulty Signal and DTC DIM-0003." Fault traced to DIM. Replaced it and reloaded software. Problem solved. Battery tested at 222 CCA, rated at 600 CCA. It was replaced. The Alternator (which is rated at 143A but tested at 97A) was replaced. Check engine lamp illuminated. "Scanned for stored DTCS, Found ECM-4201 3 way catalytic converter efficiency. Replaced Catalytic Converter and both Oxygen Sensors. This seems to be a recurring problem of late: Engine mounts. Car has almost 200,000 miles on it and recently I've been having issues with the wear on these parts. Replaced lower torque mount. | ||
| Apr 2017253975 miUS $2326 | Experiencing a coolant leak. Had to replace the radiator, radiator hoses (upper and lower) and the thermostat | ||
| Aug 2018278217 miUS $3319 | Right front headlamp out. The bulb harnesses (both sides) had fallen apart, so they were replaced, too. Also had multiple bulb failures in the rear of the vehicle. All lamps changed out. Windshield wipers replaced. Broken gear shift knob (on console) replaced. Replace motor mounts. Replace loose tie rods, ball joint and steering rod Two new tires. | ||
| Volvo S60 in Arizona, United States Dec 2009 - Jun 2013 | |||
| May 201065000 miUS $1200 | Suspension seats replaced | ||
| Nov 201073000 miUS $150 | Moonroof not functioning properly. Moonroof modesty panels were replaced. | ||
| May 201180000 miUS $1300 | Power steering pump leaking and drain hose were leaking. Problem repaired with replacement parts. | ||
| Jul 201296500 miUS $700 | Right-side engine mounts failed, replaced all failed engine mounts. | ||
| Jun 2013105000 miUS $500 | Hose for air conditioning broke. | ||
| Volvo S60 in Wisconsin, United States Jul 2008 - Mar 2010 | |||
| Aug 200870000 miUS $450 | 1 front stabalizer bar and the 2 rear stabalizer bars needed replacing. | ||
2002 Volvo S60 4dr Sedan
turbocharged 197hp 2.4L I5 5-speed automatic AWD
| Volvo S60 in Tennessee, United States Feb 2009 - Mar 2014 | |||
| Sep 2011141000 miUS $2300 | Replaced front struts and upper spring seats. Rear struts and lower ball joints, swaybar links, control arms front lower. Wheel alignment | ||
2002 Volvo S60 4dr Sedan
168-horsepower 2.4L I5 5-speed manual FWD
| Volvo S60 in Quebec, Canada Mar 2010 - Jul 2013 | |||
| Oct 201085560 miC $500 | wheel bearings had to be changed along with oil and tires | ||
| Oct 201197960 miC $1600 | replace clutch repair damaged ABS sensor | ||
| May 201299700 miC $1000 | Replace ball joint assembly | ||
| Volvo S60 in New York, United States Jan 2010 - May 2011 | |||
| Nov 201075000 mi | battery changed, 8 and half year old, original | ||
| Jan 201175300 miUS $3600 | various items, mainly the front wheel suspension and power steering mechanisms need repair. | ||
2002 Volvo S60 4dr Sedan
168-horsepower 2.4L I5 5-speed automatic FWD
| Volvo S60 in Ontario, Canada Jul 2013 - Aug 2017 | |||
| May 2015246140 miC $350 | Front spring mounts and sway bar links | ||
| Volvo S60 in Texas, United States Nov 2008 - Sep 2016 | |||
| Feb 201099000 miUS $800 | Bad Oxygen Sensor, decided to replace both | ||
| Apr 2011109000 miUS $8 | Thermostat stuck open so engine was not reaching operating temp..replaced thermostat gasket on gas cap had numerous cracks resulting in evaporative emissions leak error message..replaced gas cap with aftermarket | ||
| Jan 2012 | Thermostat was reading hot but engine was not overheated. | ||
| Jun 2012124000 miUS $1500 | AC Compressor seized, replaced compressor, drier, evacuator and recharge system | ||
| Sep 2012128000 mi | Condenser leaking | ||
| Nov 2012129700 mi | Radiator leaking near upper radiator hose. Diagnosed a hairline crack in the radiator | ||
| Dec 2013143000 miUS $16 | Passenger side turn signal socket went bad. Replaced with new OEM socket. | ||
| Jan 2015134800 miUS $20 | Security alarm module was bad. Purchased used module on ebay and had independent shop do the install. Ambient Air Temp Sensor was bad causing check engine light to come on. | ||
| Jun 2015156000 miUS $155 | Driver Information Module Failed. Rebuilt at independent shop. | ||
| Sep 2016164000 mi | Airbag light came on. | ||
| Volvo S60 in California, United States Oct 2014 - Jul 2016 | |||
| Nov 2014100700 miUS $610 | Wiring from central electronic control module was severed. Short was found, wires battery and spark plugs replaced. | ||
| Mar 2015104000 miUS $270 | minor transmission leak from axle seals. also passenger axle had a dislocated joint. replaced axle and both seals. | ||
| Jul 2016108000 mi | both front door handles came undone, doors could only be opened from outside | ||
| Volvo S60 in Connecticut, United States Feb 2008 - Feb 2014 | |||
| Nov 2008120000 miUS $550 | Oil drain plug female threads stripped. Heli-coil insert installed. | ||
| Dec 2008121000 miUS $17 | Left headlight replaced. | ||
| Jun 2010136000 miUS $1985 | Both front strut, upper and lower bushing/ball joints Rusted out exhaust hanger replaced | ||
| Jul 2010136000 miUS $941 | Alternator failed and had to be replaced | ||
| Aug 2010137000 miUS $240 | Drivability problems coming out of shop from alternator repair and CEL came on. Dealer said needed to clean throttle body. CEL light still on, but drives OK | ||
| Feb 2011139000 miUS $1010 | Rear struts and bearing plates, plus 4 wheel alignment. 5 spark plugs - no problem....never replaced in 139K | ||
| Sep 2012147000 miUS $1600 | Replaced catalytic converter and O2 sensor. CEL kept coming on and would not have passed emissions inspection. Like the car and wanted to keep it, but expensive repairs are a real issue. | ||
| Mar 2013147000 miUS $400 | O2 sensor broken upper motor mount | ||
| Aug 2013149300 miUS $741 | Replaced both front lower control arms. Replaced missing bolt in the rear control arm | ||
| Volvo S60 in California, United States Sep 2015 - Sep 2015 | |||
| Sep 2015144000 miUS $600 | sway bar had to be replaced | ||
| Volvo S60 in Pennsylvania, United States Dec 2008 - Mar 2009 | |||
| Jan 2009185000 miUS $1200 | Regulator failed, damaged alternator and battery. | ||
| Mar 2009185000 miUS $550 | Front End Links repaired (this has been a huge nuisance, needed every 45K or so.) $250. Engine Torsion Shock Mount (top) $300. | ||
| Volvo S60 in North Carolina, United States Jan 2009 - Jun 2011 | |||
| Feb 2009119000 miUS $240 | Car smells of gas and sometimes comes to complete stall. But also, I had the timing belt replaced and the service guy did it incorrectly and had to correct it. A sensor (actually 2 of them now, different ones) was replaced also, but problem still exists. | ||
| May 2009123000 mi | Check engine light on. Service tech says problem with ANOTHER SENSOR due to temperature sensor which controls fuel mixture..but not sure. I feel car needs new ETM , after online investigation. Appt with Volvo dealership 2 follow this Tuesday. 6/09/09 | ||
| Jun 2009125000 mi | Volvo dealership ran sweep test, which indicates ETM failure, but car DID NOT fail test.(but is indicating failure symptoms). They did software upgrade which is basically an override. Air bag warning light on. Not fixed, but it went out on its own. Heard noise in front end upon turning. Was told it may be cv joint or axle. was asked to come back but have not done so yet. | ||
| Nov 2009127000 mi | Car was bumping terribly, especially if a passenger was in car. Mechanic says it is the rim. I replaced it, but it is still not totally smooth. Am waiting for tires to see if that is the fix. | ||
| Jan 2010129000 miUS $1733 | Replaced power steering cable, right axle,& bushings. So the axle was the problem with the bumping in front end. (my past mechanics are idiots or just lazy) 1000 dollars in parts alone! Very strong gas odor since I bought car in 2008. Replaced fuel pump. | ||
| Jun 2010135000 miUS $365 | A/C doesnt work. Compressor problem etc ?? $1400 to fix, so on hold.. | ||
| Oct 2010140000 miUS $193 | check engine light on warned of car overheating. but it was hopefully loose wires going to sensor giving a faulty reading.. also some hoses were cracked and replaced. oil change included in price of repair.car surges at times using cruise | ||
| Mar 2011147600 mi | Check engine light which seems to be a permanent fixture on dash comes on and am told I need a thermostat.. Light goes off,, no repair... car still making noises in front end even after axle replacement.... gee.s.ss.s | ||
| Volvo S60 in California, United States Sep 2011 - Jun 2018 | |||
| Aug 2012115600 mi | Started smelling gas. Recall fuel pump replaced. CAR WOULDNT START | ||
| Nov 2013124100 miUS $5400 | I mentioned when going over pothole (etc) car would feel like I was driving on ice or oil for a second or two. my tires were bad, sd I was going to get new ones. Only changed oil. Next day I got 4 new tires and technician told me drivers side wheel was loose and wobbley, told me to go straight to shop and get it fixed. Ball joint broken. I had both front ones replaced. | ||
| Volvo S60 in Massachusetts, United States Aug 2011 - Jul 2013 | |||
| Sep 201197000 miUS $300 | Replaced EVAP Purge Valve; also replaced fuel pump as part of a recall. | ||
| Mar 2012103000 miUS $1600 | Fast idle. Replaced vacuum elbow. Adjusted and aimed headlights Replaced right front inner steering arm. Steering arm had play. Replaced left front ball joint Left front control arm bushings were found to be worn out; replaced. Worn out serpentine belt tensioner was replaced. | ||
| Apr 2012104000 miUS $155 | A/C was not blowing as cold as it should; system was recharged and nothing else was found to be wrong with it. | ||
| Dec 2012110000 miUS $400 | Power steering pump made rattling noise. Pump was replaced with warrantied used pump. Replaced power steering fluid as well. | ||
| Jan 2013US $300 | Parking brake suddenly locked up on one wheel during shopping trip. Car towed to dealer, found parking brake pads had delaminated. Replaced parking brake shoes and cables on both wheels and adjusted. | ||
| Volvo S60 in Florida, United States Aug 2010 - Jul 2021 | |||
| Sep 201078000 mi | Driver side door handle not functioning. Originally repaired with wire holding mechanism in broken clip. Repaired permanently with cotter pin after drilling into broken clip and glue on other side. | ||
| Jul 201182000 miUS $30 | Vacuum leak discovered at original gas cap. Gas cap replaced. | ||
| Sep 201183000 mi | Service Alarm System. Alarm goes off with key fob but not when locked door is opened from inside. Needs new module. | ||
| Mar 201597000 miUS $560 | Left turn signal with bright switch not functioning. All 5 solenoids and spark plugs needed to be replaced. | ||
| Jul 201598000 miUS $96 | Battery would not start the car every time. May have been weakened by the air ventilation sensor when engine turned off. | ||
| Volvo S60 in Florida, United States Jul 2010 - Jun 2011 | |||
| Aug 2010111000 miUS $850 | Right Fr. wheel bearing bad. while inspecting they found left frt. CV boots bad, so replaced and repacked | ||
| Nov 2010119000 mi | hood cable broke, dealer ordered parts, I installed | ||
| Volvo S60 in Tennessee, United States Feb 2013 - Sep 2014 | |||
| Sep 201499000 mi | Electronic throttle control failed and engine computer failed as well. Sold car for parts. | ||
| Volvo S60 in Texas, United States May 2009 - Nov 2012 | |||
| Jun 200982000 miUS $600 | Axle Replacement | ||
| Nov 2012105000 miUS $200 | Transmision Flush | ||
2002 Volvo S60 4-door
turbocharged 5-cylinder diesel manual 2WD
| Volvo S60 in Great Britain May 2008 - Mar 2010 | |||
| Aug 200876000 mi | The drivers side front driveshaft broke, This was due to collapsed ball joints in both of the CV Joints in that driveshaft. | ||
See TrueDelta's information for all Sedans
See TrueDelta's information for all Volvo models.
