| 1 | 0 | 3 | 4 | 3 | 4 |
2002 GMC Envoy repairs by problem area
Engine (31%)
Transmission and Drivetrain (8%)
Brakes and Traction Control (3%)
Suspension and Steering (19%)
Electrical and Air Conditioning (26%)
Paint, Rust, Leaks, Rattles, and Trim (7%)
Other (7%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 118 repairs.
2002 GMC Envoy electrical repair cost distribution
$2500+ (0%)
$1000 - $2499 (11%)
$500 - $999 (7%)
$100 - $499 (29%)
< $100 (54%)
Chart based on 28 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2002 GMC Envoy
Engine not specified
| 212000 mi US $225 |
When parked for a couple of days, would not start up. New battery took care of the problem. |
2002 GMC Envoy 4dr SUV, ext.
270-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 140000 mi US $2251 |
Airbags warning light was on all the time. Sensor had gone bad. |
| 141800 mi | Motor in console attempted to move rear-seat vent door--cycled making clicking sound. Mechanic disconnected motor. |
| 146000 mi US $90 |
Windshield washer pump failed. |
2002 GMC Envoy 4dr SUV
270-horsepower 4.2L I6 4-speed automatic RWD
| 213000 mi US $100 |
Cost was to diagnose A/C issue that was going to be approx $1500 to repair. At the same time, they found an issue with the water pump. Total repair was to be over $2000. Had put over $1000 into repairs in the prior 30 days; time to sell. |
2002 GMC Envoy 4dr SUV
270-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 168000 mi | AC compressor failure |
| 179000 mi | The airconditioning system was leaking freon in a couple of different places. |
| 7183 mi | Replaced 4WD selector switch |
| 7183 mi | Reprogrammed onstar module |
| 104410 mi US $154 |
Outside ambient air temp sensor replaced |
| 179000 mi | Recall on vehicle indicator lights. I had experienced intermittent failures of the left tail light for several years, and was surprised to find that a recall had been issued by GM many years ago. |
| 181295 mi US $20 |
L brake light inoperable since recall repair 3 mos ago. Removed and checked bulbs, Cleaned contacts, light now working. |
| 189000 mi US $456 |
Starter replaced |
| 120000 mi US $900 |
Replace AC compressor; recharge system. |
| 118000 mi US $198 |
External temp sensor went crazy making the A/C not function correctly Sensor replaced and all is well again. |
| 122000 mi US $1358 |
Replace inoperative passenger side door actuator for passenger side A/C. Leaking A/C switch |
| 124000 mi | Replaced Fuel Level Sensor after the replacement of the fuel cell. Existing sensor was corroded and replaced by the dealer at no cost to me. |
| 297700 mi US $560 |
Believed problem to be PS Actuator per panel discussion of hot air through passenger vents with AC on. Problem was actually temperature actuator, which has never been discussed. Problem none-the-less resolved. |
| 362000 mi US $1800 |
Air conditioning switch leaking and would shut down. System evacuated; dye tested; switch replaced; system charged. |
| 70000 mi US $300 |
Replaced alternator. |
| 91000 mi US $3 |
Driver's side temperature door actuator inoperative. |
| 102000 mi US $35 |
Outside Ait Temperature Sensor Replaced Underhood lamp replaced |
| 120000 mi US $65 |
Replaced front passenger window regulator assy. |
| 132000 mi US $160 |
Replaced rear wiper motor. |
| 135000 mi US $244 |
AC Compressor Replacement |
| 203000 mi | Electrical problem caused by lift gate - maybe a short?, drivers side and review mirror (interior) auto-dimming mode not functioning, drivers side mirror no defroster, ground issue (maybe) that causes static on the AM radio. |
| 61480 mi | Rear Wiper spray control doesn't work. Wipers work, but not the spray part when depressing the button. |
| 63100 mi | Check engine oil light (oil can icon) comes on upon starting, then goes away after 30 seconds. Oil levels well. |
| 52000 mi US $175 |
The fan switch would only turn on the fan at speeds 4-.5 |
See TrueDelta's information for all SUVs
See TrueDelta's information for all GMC models.
