| 1 | 0 | 3 | 4 | 3 | 4 |
2003 GMC Envoy repairs by problem area
Engine (36%)
Transmission and Drivetrain (10%)
Brakes and Traction Control (4%)
Suspension and Steering (19%)
Electrical and Air Conditioning (24%)
Paint, Rust, Leaks, Rattles, and Trim (2%)
Other (4%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 160 repairs.
2003 GMC Envoy electrical repair cost distribution
$2500+ (3%)
$1000 - $2499 (6%)
$500 - $999 (11%)
$100 - $499 (44%)
< $100 (36%)
Chart based on 36 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2003 GMC Envoy
Engine not specified
| 137000 mi US $80 |
right dashboard Bose speaker blown. Found used Bose speaker on eBay and replaced it. |
2003 GMC Envoy 4dr SUV, ext.
290-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| 140000 mi US $2641 |
replaced alternator, serpentine belt, |
| 25717 mi | Replaced evaporator vent solenoid under Warranty |
| 27905 mi | Emerg Repairs @ GM Garage (Leonardtown, Md), Would not start or shift from Park. Replaced ignition switch & fuel tank pressure sensor, also found left outer tie-rod with excessive play. Replaced tie-rod and performed alignment. Warranty |
| 79602 mi US $227 |
Replace VICM - Updated OnStar. |
| 108978 mi US $122 |
No Power Controls (Int Lites, Radio, Door, Window, Seat, etc.). Replaced Master Fuse, performed annual state inspection plus routine Lube/Oil/Fltr service. |
| 112051 mi US $262 |
Replace Blower Motor Resistor, Fixed Air Bag Light (Air Bag Light problem still exists) plus routine Lube/Oil/Fltr service. |
| 118134 mi US $442 |
Replace A/C Belt & Line, plug Rt front tire plus routine Lube/Oil/Fltr service. |
2003 GMC Envoy 4dr SUV, ext.
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 180000 mi US $85 |
AC working fine, Driver-side dash vent only blows hot air, while passenger-side works fine. Replace "heater blend door actuator" on driver side. |
| 198200 mi US $150 |
Charging System fault, replaced alternator. |
| 194800 mi US $20 |
Horn started a constant blurring after using remote to unlock vehicle. Remove "horn" fuse to stop blurring. Replaced Horn "Relay". |
| 228000 mi US $70 |
Horn not working and was randomly blowing its fuse. Replaced both "High Note & Low Note" horns. |
| 231000 mi US $13 |
Symptom: all 3 brake lights constant on, causing battery drain. Replaced "Stop Lamp Switch" (BWD Part#SL2043). It's located just above the brake pedal, attached to the braking mechanism. Mine was attached with a retaining clip, not screw, nut/bolt. |
| 135000 mi US $550 |
Heater blower was intermittent. Dealer replaced sensor. Problem reappeared within 2 weeks. Took to dealer again and they stated it was actually heater blower motor - which was replaced and fixed the problem. |
| 244000 mi US $180 |
Driver door window motor |
2003 GMC Envoy 4dr SUV
275-horsepower 4.2L I6 4-speed automatic RWD
| 92542 mi US $550 |
Replace instrument cluster |
2003 GMC Envoy 4dr SUV
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 6000 mi | Valve related to compressor on air conditioner. |
| 83000 mi US $7 |
Driver's side Headlight |
| 60760 mi C $500 |
speedometer not working properly |
| 80600 mi C $500 |
air conditioning recharged |
| 88000 mi US $250 |
Cruise control works intermittently; repair included placing map sensor; less then two weeks later cruise control still working intermittently; will be taking car back to repair shop in two days |
| 123700 mi US $430 |
dash lights very dim and speedometer went crazy. Replaced cluster to fix both problems. |
| 131000 mi US $101 |
replaced right front headlight bulb and connector |
| 134800 mi | removed cluster panel, install new stepper motors, this was a recall items, but mine started acting up after having to many miles for warranty, or extended warranty on this item |
| 144000 mi US $170 |
had to replace the windshield wiper motor |
| 162300 mi US $100 |
Low pressure cut off switch, recharge. |
| 164000 mi US $1300 |
Compressor electrical clutch failed. Replaced Compressor and Accumulator. Ventilation damper module replaced due to MODE not functioning. Battery replaced with this trip. |
| 169000 mi US $165 |
Replaced Alternator and serpentine belt. |
| 163500 mi US $150 |
Rear washer fluid pumps failed. Replaced both rear and front windsheild washer pump, rear had failed replaced both while apart. Removed and cleaned throttle body/SD chamber. Corrected rough idle and hesitation as well. |
| 115940 mi C $27 |
A/C evaporator freezing up and blowing warm air. A/C low pressure(cycling switch failed)Switch replaced successfully. |
| 145700 mi C $44 |
Both front headlamps sockets burned and chipped. Sockets and bulbs replaced |
| 147600 mi | Low pressure air conditioning switch failed |
| 150660 mi C $64 |
Headlight Control Module failed. (no headlights) Module replaced. |
| 154380 mi C $71 |
Passenger seat heater lower element replaced. |
| 154380 mi C $129 |
Battery failed, replaced. |
| 173600 mi C $1003 |
Air conditioning compressor worn. A/C working intermittently |
| 166000 mi US $135 |
replaced weak battery |
See TrueDelta's information for all SUVs
See TrueDelta's information for all GMC models.
