| 1 | 0 | 3 | 4 | 3 | 4 |
2003 GMC Envoy repairs by problem area
Engine (36%)
Transmission and Drivetrain (10%)
Brakes and Traction Control (4%)
Suspension and Steering (19%)
Electrical and Air Conditioning (24%)
Paint, Rust, Leaks, Rattles, and Trim (2%)
Other (4%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 160 repairs.
2003 GMC Envoy transmission repair cost distribution
$2500+ (0%)
$1000 - $2499 (27%)
$500 - $999 (40%)
$100 - $499 (13%)
< $100 (20%)
Chart based on 15 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2003 GMC Envoy 4dr SUV, ext.
290-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| 230520 mi C $850 |
New CV joint for transfer case |
| 231040 mi C $1500 |
Front diff actuater was not engaging. |
| 16175 mi | Transmission slips then bangs into gear - found 2 - 4 bands shot, clutch worn and metal shavings in pan. Dealer installed new transmission, under Warranty |
2003 GMC Envoy 4dr SUV, ext.
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 230091 mi US $1375 |
Replaced cv axles. |
2003 GMC Envoy 4dr SUV
290-horsepower 5.3L V8 4-speed automatic 4WD w/low range
| 70000 mi US $1490 |
Car made awful metal-on-metal noises when in 4WD. Mechanic said problem was due to faulty transfer case. |
2003 GMC Envoy 4dr SUV
275-horsepower 4.2L I6 4-speed automatic RWD
| 96000 mi US $275 |
Replaced trans shift cable |
| 142000 mi | gear shift linkage bushing had to be replaced on shifter cable |
| 175000 mi US $910 |
trannys 3rd gear went loco on me,mec told me to use it till i get repair money,rebuilt and running, $910.00 somolians cost of repair,ahh,and because im a friend.thank God had a bad job done in the tranny,used it 1 month and went total blank,like,nothing,mec no choice but repair it,but still giving me problems,sometimes when I accelerate too fast,it will slip,but recovers somewhat fast,and shifts. |
| 189000 mi US $950 |
just a bad job all together. had to repair a burned out tranny, pump, gears, drums etc, even the torque converter |
| 191200 mi US $600 |
I repaired that tranny, last year,round may, in march 13, it started leaking tranny oil, end up dropping it and repairing pump, |
| 129200 mi US $475 |
Replace both rear axle seals |
2003 GMC Envoy 4dr SUV
275-horsepower 4.2L I6 4-speed automatic 4WD w/low range
| 121000 mi US $1500 |
leak in front differential; then found that bearings needed to be replaced |
| 105400 mi C $620 |
Transmission lines rusted out and leaking causing a transmission fault code due to slippage from loss of fluid. New lines installed by dealer & fluid topped up. |
| 141000 mi | I have had an on-going problem with the communication link for the 4 wheel drive system. It requires a restart to clear. There is a technical bulletin on this as well. |
| 198000 mi US $700 |
Service 4WD light. Found that there was a bad transfer selector motor, replaced and repaired. |
See TrueDelta's information for all SUVs
See TrueDelta's information for all GMC models.
