| 1 | 0 | 3 | 4 | 3 | 4 |
2004 Dodge Durango repairs by problem area
Engine (41%)
Transmission and Drivetrain (22%)
Brakes and Traction Control (0%)
Suspension and Steering (13%)
Electrical and Air Conditioning (20%)
Paint, Rust, Leaks, Rattles, and Trim (0%)
Other (4%)
Select a problem area
Chart based on 46 repairs.
2004 Dodge Durango repair cost distribution
$2500+ (8%)
$1000 - $2499 (13%)
$500 - $999 (26%)
$100 - $499 (31%)
< $100 (23%)
Chart based on 39 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2004 Dodge Durango
Engine not specified
| Dodge Durango in Massachusetts, United States Feb 2011 - Jul 2013 | |||
| Mar 201159000 miUS $560 | Driver's side windshield wiper malfunctioned due to wiper transmission failer. Wiper transmission replaced (Part was $360.00 plus $200.00 for labor = $560.00). | ||
| Apr 201159500 miUS $850 | Front ball joints, $650. O2 sensors, $200. | ||
| Oct 201164500 miUS $200 | Fan clutch replaced. The engine kept over-heating, usually while idling at extended periods or while in heavy backed-up traffic. Added a gallon of antifreeze. | ||
| Dec 201276000 mi | Car was overheating while idling. It was low on antifreeze so he added a half gallon. There must be a very small leak in the radiator somewhere. I haven't had it fixed yet. | ||
| Jul 201380000 miUS $600 | Loud ticking noise coming from engine area when engine was cold (i.e every morning). The bolts holding the manifold were rusted and broken off. The mechanic replaced all of the bolts and gaskets. | ||
2004 Dodge Durango 4dr SUV
330-horsepower 5.7L V8 5-speed automatic RWD
| Dodge Durango in Bahrain Sep 2008 - Mar 2011 | |||
| Oct 200832240 mi$260 | Gas leakage, expansion valve was replaced | ||
| Mar 201040920 mi$100 | The alternator rectifier got damaged. The agent did not have the part, except the whole alternator which cost US 400, I asked the mechanic to replace the rectifier with any other vehicle rectifier. He put Ford parts, the car now runs well. | ||
| Mar 201144640 mi$400 | AC evaporator was replaced, it needed opening the dashboard | ||
| Dodge Durango in Texas, United States Apr 2012 - Dec 2017 | |||
| May 2013181500 miUS $1500 | Blew engine gasket. Needed new water pump, thermostat, gaskets and new head. | ||
| Jan 2017198000 miUS $1900 | fan clutch, upper ball joints (L&R). | ||
2004 Dodge Durango 4dr SUV
330-horsepower 5.7L V8 5-speed automatic AWD w/low range
| Dodge Durango in Michigan, United States Sep 2010 - Jun 2013 | |||
| Feb 2013105900 mi | front/rear shocks at 106k miles (was time) | ||
| Dodge Durango in Arizona, United States Aug 2010 - Dec 2015 | |||
| Oct 201050000 mi | We purchased the vehicle used in July, and discovered with a week that the 4WD did not work. It needed a new 4WD drive motor. SInce we had paid to transfer the remaining factory powertrain warranty, the repair was covered. We purchased the vehicle used in July and noticed a drivetrain rattle within a week. I discovered a TSB that seemed related so I asked the dealer to check it. Since we paid to transfer the factory powertrain warranty, the repair was covered. | ||
| Aug 201166000 miUS $369 | A/C started blowing hot. (on the hottest day of the year, no less) Coupler to rear A/C was broken and leaking. it was replaced. | ||
| May 201278300 miUS $511 | Rear A/C not working | ||
| Dec 201288000 mi | Slow leak of engine coolant when cold | ||
| Jul 201393800 miUS $515 | A/C clutch and clutch coli replaced. Had melted. | ||
| Apr 2015115300 miUS $750 | Drivers side exhausted header bolts snapped. Replaced bolts. | ||
| Dec 2015125000 miUS $85 | Passenger side windshield mister broke, replaced. Battery weak, would not start car after sitting for more than a few days. | ||
| Dodge Durango in Massachusetts, United States Nov 2011 - Jan 2012 | |||
| Jan 2012104000 mi | Left upper control arm Leak Detection Pump replaced original battery | ||
| Dodge Durango in Georgia, United States Sep 2016 - Nov 2020 | |||
| Mar 2016210000 miUS $2500 | cracked valve seat Rebuilt engine | ||
| Dodge Durango in Quebec, Canada Jun 2009 - May 2011 | |||
| Nov 201065280 miC $400 | Lower ball joint and two front shocks replaced due to a front end clunking | ||
| Dodge Durango in Virginia, United States May 2010 - Jun 2011 | |||
| Nov 2010183000 miUS $1350 | Transmission front pump failed. Transmission was replaced | ||
| Dodge Durango in Virginia, United States Nov 2009 - Jun 2011 | |||
| Mar 201035000 miUS $85 | 5.7 L HEMI low speed stalling happened. Found TSB 18-013-05A, had the dealer perform TSB, involved flashing the PCM with new firmware to avoid idle undershoot. No problem since | ||
| Dodge Durango in Virginia, United States Oct 2008 - Mar 2011 | |||
| Dec 2009101000 miUS $6500 | Engine threw a rod. No warning-just tried starting and huge rattling noise in engine. Found out this is not unusual for 04 Durango HEMIs, but Dodge not helpful and warranty for engine 70k | ||
| Dodge Durango in Nebraska, United States Aug 2008 - Jun 2013 | |||
| Apr 201293200 miUS $105 | Replaced battery, Car would not turn over | ||
| Dodge Durango in New Hampshire, United States Aug 2008 - Dec 2013 | |||
| Apr 2010127000 miUS $120 | rear axle seal, transmission gasket | ||
| Aug 2011136500 miUS $80 | egr valve replaced | ||
| Apr 2012140500 miUS $600 | check engine light on.had to replace oxygen sensor and fuel gauge with fuel pump because cover had deteriorated and was leaking. | ||
| Nov 2012146400 miUS $326 | locked in 4 wheel drive and svc 4x4 light on.had to replace transfer case motor. | ||
| Jul 2013152300 miUS $380 | replace right lower ball joint plus alignment | ||
| Dodge Durango in Delaware, United States Jun 2009 - Jul 2011 | |||
| Jun 200972000 miUS $100 | $100 deductible. Transmission valve body replacement needed due to shifting issues. Also under hard braking the engine would stall. This was due to the trans valve body. | ||
| Apr 201086000 miUS $3500 | Automatic 2nd to 3rd shifted real hard. Rebuilt transmission with heavier duty parts Transmissions Rebuild | ||
2004 Dodge Durango 4dr SUV
230-horsepower 4.7L V8 5-speed automatic RWD
| Dodge Durango in Maryland, United States Oct 2015 - Oct 2015 | |||
| Oct 2015195000 miUS $50 | Crankshaft position sensor failed; engine suddenly hard to start and ran very rough. | ||
| Dodge Durango in California, United States Aug 2008 - Mar 2010 | |||
| Mar 200942000 miUS $380 | Running hot | ||
2004 Dodge Durango 4dr SUV
230-horsepower 4.7L V8 5-speed automatic AWD w/low range
| Dodge Durango in Virgin Islands, U.S. Dec 2013 - Dec 2013 | |||
| Dec 201399200 miUS $600 | replace radiator | ||
| Dodge Durango in Ohio, United States May 2013 - Jun 2013 | |||
| Jun 2013130000 mi | Engine leaking fluids from rear cylinder heads; no work done. | ||
2004 Dodge Durango 4dr SUV
230-horsepower 4.7L V8 5-speed automatic AWD
| Dodge Durango in Indiana, United States Jul 2010 - Jul 2013 | |||
| Aug 2010152000 miUS $995 | The vehicle would randomly and momentarily hard lurch at highway speeds 65 to 70 mph, and randomly stall out at stop signs. The lurching was so aggressive it felt like the vehicle was going to flip. Replaced transmission valve body. | ||
| Jul 2013184000 miUS $2000 | Jumping out of, slipping, stalling. | ||
| Dodge Durango in Delaware, United States Sep 2010 - Jun 2011 | |||
| Nov 2010143000 mi | Hard down shifts, caught in between gears when accellerating from stop. Replacing valve body in attempts to correct. | ||
See TrueDelta's information for all SUVs
See TrueDelta's information for all Dodge models.
