| 1 | 0 | 3 | 4 | 3 | 4 |
2006 Mercury Milan repairs by problem area
Engine (32%)
Transmission and Drivetrain (8%)
Brakes and Traction Control (1%)
Suspension and Steering (8%)
Electrical and Air Conditioning (29%)
Paint, Rust, Leaks, Rattles, and Trim (12%)
Other (10%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 77 repairs.
2006 Mercury Milan electrical repair cost distribution
$2500+ (0%)
$1000 - $2499 (0%)
$500 - $999 (9%)
$100 - $499 (27%)
< $100 (64%)
Chart based on 22 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2006 Mercury Milan 4dr Sedan
221-horsepower 3.0L V6 6-speed automatic FWD
| 82000 mi | Door would not automatically lock/unlock - Dealer changed for free. |
| 63200 mi US $411 |
Sensor for air conditioning in the dash quit working Dash had to be removed--5.5 hour job+ 1 hr diagnosis. $411.00 |
| 85000 mi US $10 |
Headlight wiring melted |
| 126000 mi US $10 |
Replaced headlamp bulb |
| 133000 mi US $100 |
Replace battery |
| 15349 mi | Bad battery Replaced under warranty |
| 121000 mi US $82 |
battery replacement. It doesnt get driven much so battery dies |
2006 Mercury Milan 4dr Sedan
160-horsepower 2.3L I4 5-speed automatic FWD
| 115000 mi US $252 |
Master door lock |
| 35000 mi | Lumbar broke - repaired under warranty. Clock light stopped working, clock was replaced under warranty. |
| 76000 mi US $560 |
Starter and battery |
| 128000 mi | Had to R&R Battery, once installed dash "Air Bag" light popped on. Not repaired as of yet, still researching issue |
| 147000 mi US $153 |
with the onslaught of Arctic like temperatures...the battery was showing is weaknesses...replaced the battery withe a group 48 Sears Diehard gold AGM |
| 112700 mi US $130 |
no blinkers in the front of the car, left signal light would not shut off even when the car is shut off |
| 156000 mi | molex connector for blower motor started melting, cleaned up connector and reattached |
| 71000 mi | Radio/CD player reports "CD Error." Won't play CDs, cannot eject disks. $400 for repair - is Ford kidding? Can't even get my disks out, so add about $90 to the loss. |
| 68900 mi | Owner disconnected the battery to clean cables then noticed that the heater would not blow through the dash vents. Defroster and floor vents worked but vents did not. Owner repaired problem by disconnecting and reconnecting battery. |
| 54000 mi US $775 |
A/C Failure Replaced Evap Temperature sensor |
| 23000 mi | Air conditioning delay to start blowing cold air on hot day. |
| 96000 mi US $120 |
Replaced window right front window reg. |
| 123000 mi US $25 |
The Brake light switch was functioning at about 50% of the time. This caused the shift-interlock not to move out of park. If the brake lights didn't work the gear shift would not. The brake light switch just snaps in and the cable attach. |
| 143000 mi US $50 |
Blower motor and Blower Motor Control Module / Resistor were changed to to the blower not working. |
| 164000 mi US $40 |
A connector operation the fan for the AC was not working 100% of the time . The switch was replaced. |
See TrueDelta's information for all Sedans
See TrueDelta's information for all Mercury models.
