65000 mi US $450	The built in garage door opener stop working. Wife most likely pushed to hard. They had to replace the whole unit. Had Extended Warranty Yea!
91500 mi US $700	Auto sliding door did not work anymore. Replaced parts on both doors.

62000 mi US $1200	Airbag light flashing intermittently. Required to replace airbag wiring service.Special warranty covered for 5 years is this happened and time was 5 years 7 months. Negotiated with Toyota to pay labor only...they paid for the part Bearing became really loud and alternator froze
63700 mi US $1500	A/C compressor clutch froze solid and AC always on

84940 mi €140

dead battery

95500 mi US $12	The sienna rear tailgate has parking bulbs, backup bulbs and license plate bulbs which can only be replaced by Carefully removing the inside plastic covering which snaps into place. See this video-https://www.youtube.com/watch?v=Uhn62Tli5pY
119325 mi US $80	Rear washer never worked and I researched on YouTube to find a guide to replacement. It required removing the right wheel well cover but then it was relatively easy and worked well.
144000 mi US $948	and replaced one bulb Owner replaced battery Compressor failed

154000 mi US $500

Multiple problems with blend doors and mode doors. They supposedly fixed a mode door, but now there no hot air blowing on the front passenger side.

80200 mi US $350

Corroded rear A/C union. Evacuated, recharged, leak check, clean up union, recharge again.

157000 mi US $350	Starter needed to be replaced
157700 mi US $700	sliding side doors not opening or closing when commanded. Motors replaced in both sliding side doors.
180000 mi US $900	Air bag light coming on because of passenger bag air bag sensor Replaced compressor and necessary components for new air conditioning system
198000 mi US $1200	air bag sensor light coming on. Repair needed for driver side air bag system sensor assembly noise coming from dash. hot/cold air blending switches not working

82240 mi C $200

leaking a/c lines. Went with sealer and recharge rather than replacing the lines.

93200 mi US $2000	Driver's side airbag system failure. Seems to be a common problem but no recall as of yet. Van out of warranty. Replaced Driver's side airbag unit and sensor.
148000 mi US $800	Replaced thermostat, recharged Ac, replaced electrical relay related to AC

70000 mi	Airbag failure light was flashing. Problem was due to disconnected passenger side airbag cable. Dealer reattached cable as goodwill, as this airbag module had failed previously under warranty.
85000 mi US $1651	The relay for the divider doors is starting to click incessantly again in the HVAC.
105000 mi	A/C motor (divider doors for floor and face vents) beginning to fail. There is a loud clicking noise as I am driving--whether fan or A/C is on or not. Happens randomly.

55000 mi US $760

Pipe to the rear vents was broken needed to be replaced

45000 mi

A/c operation was erratic. Controls did not function reliably. Replaced blower motor control (part #87165-45020)and Blower motor resistor. Works fine now.

28500 mi

The navigation system lost its ability to sync with the satellite. This required a firmware update. Toyota provided a replacement navigation disk that corrected the problem for free.

109120 mi C $200

Bought new tires from the dealer, after installing, tire pressure warning light came on. Brought it back to be fixed and they were unsuccessful - didn't actually test it, they just reset it. So no it's going back for a third trip.

122000 mi US $12	Replaced passenger sliding door latch motor.
136000 mi US $132	Rebuilt all three servo actuators due to them "hunting" for position which caused a chattering noise. This noise was most noticable on the lowest fan speed Replaced AC blower motor due to noise.

199000 mi US $162	A/C recharge after A/C began blowing out warn air
219000 mi US $187	Service A/C and recharge. Search for leaks. Replaced service fittings.
250000 mi US $33	Replaced headlights after one low beam burned out
269000 mi US $500	Lots of noise behind dash including "woodpecker sound" when fan blowing out only upper vents. Replace HVAC servo motor.
278000 mi US $395	Starter failed and was replaced.
296000 mi US $517	Troubleshoot battery drain problem.

100800 mi US $11

One headlight lamp burned out. Replaced both with new 9006 standard lamps.

112000 mi US $12

Right side power sliding door no longer opened automatically unless activated by hand, Replaced small motor in door with a replacement found online for about $5 (plus shipping) following directions found on youtube. Door now works as new.

171740 mi C $90

Engine block heater needed to be replaced.

102000 mi US $290

Starter needed replacing as it wouldn't turn on. Replaced starter and was good to go.

166000 mi US $100	Battery was completely dead after a very short stop. Figure the sudden hot weather killed it. Jumped it and went and replaced the battery with the auto supply store's help.
167000 mi	Battery was completely dead after we returned from a trip, had to have it jump started, which results in the car running oddly for a while, but it's all good now.
180000 mi US $100	The A/C was not as cool as it had been.

45000 mi US $1200

Couldn't get air to come out of upper-vents in rear seat area. Blend-door actuator found to have failed. Entire rear blower/heat-exchanger unit was replaced under warranty.

60000 mi US $1500

Servo motor replacement.

51000 mi	TPMS light turning on even though all pressures good and reset - "Hard reset" completed.
98000 mi US $20	Replace battery under warranty - charged 20.00 for labor.

143300 mi US $1113

AC leaking. Compressor/condensing unit replaced. Then system recharged.

148800 mi US $300

I was told there was a prob with my blower motor, but after they replaced it the problem remains. So no real repair actually completed. Prog is with my heater box (I think) and it clicks when I turn it on and makes a noise at some settings.

58000 mi	Airbag sensor light was blinking. Noticed TSB on siennnaclub.org and dealer confirmed problem on first trip. Repair took place on second trip to shop.
60000 mi	Sensor replaced on return visit after ordering from first visit.

41000 mi US $600	Radio/stereo made loud POP and go dead. Radio/stereo had to be replaced.
63900 mi US $200	Radio, CD player, stereo had to be replaced. Toyota dealer quoted $1,800 to replace with Toyota radio and CD player.

14958 mi	Battery needed to be replaced due to dead short in van. Dealer charged $112.98 to replace. I fought it and got a check back from them. Warranty after a fight. Short issue as of June 17th 2008 is still ongoing.
27173 mi	Van would not start all day, no crank no electric. Started the next day and taking to dealer who could not find a problem. I think part of dead short issue mentioned above. Still ongoing problem as of June 17th 2008.
47000 mi	DVD player once again is draining battery by staying on after shutdown. This is getting old. Told solution will be coming and to bring back when called.

47000 mi	airbag light flashing, wiring in passenger seat loose.
123000 mi US $600	power door actuator motor replaced
138000 mi US $180	battery died
177000 mi US $250	ac recharge, tighten belts

87000 mi

Air bag warning light indicates malfunction with one of the air bag modules. Declined to repair. Update: later cleared up on its own.

24000 mi

Rear AC did not blow cool air. Problem was faulty relay.

7000 mi

AC not cold enough.

54000 mi	The DVD player would no longer play DVDs. It was replaced under my extended warranty, there was n charge to me at all.
62000 mi US $245	The battery would no longer hold a charge, and the positive battery cable was corroded. Both the battery and cable were replaced. The lights on the homelink buttons on the overhead console had burnt out. The dealer replaced the bulbs.

39700 mi US $1400

air conditioning blowing hot air, fixed eventually under warranty but still had to paid half of filling with freon

130000 mi US $80	Replaced bad starter
155000 mi US $10	Drivers side low beam bulb blown. Replaced both drivers and passenger side with new bulbs. Other good one is now a spare.
156000 mi US $20	Topped off air condition with oil/sealer/ 134a charge.

44000 mi US $400	part of the 3rd row power seat would not come up.
55000 mi	DVD player gave out due to an electrical short. This problem had occured before when the car had around 36,000 miles on it.

54000 mi	Passenger side mirror does not unfold fully. Extended Warranty took care of all expenses.
104000 mi US $2300	The whole evaporator need replacement due to leaks.
133000 mi US $600	Navigation stop powering up. Replaced with unit from Ebay. Unit from dealer would have been over $4k

51000 mi

Driver's side air bag light on - at least 5 repair trips. began early in warranty period (new car). Kept recurring until present mileage. Repaired by loyal customer provision of Toyota - no cost, one time favor.

38700 mi	Low tire pressure indicator came on twice. Checked tires (all were ok) and reset indicator.
54800 mi	Sliding door stopped working.

161200 mi US $260	replace ac compressor clutch
210000 mi US $150	replace electronic vent control, door blend servo

50000 mi

One electro-mechanical failure was left unresolved: the motorized mirror on driver side. Motor switch probably failed as motor continued to run. However, the mirror control also stopped working at the same time. Dealer agreed to repair.

23000 mi	Air bag light flashing
28000 mi	Airbag light flashing. Replaced front passenger wiring harness and front passenger seat.

67580 mi C $800

Replaced front passenger airbag.

122500 mi US $240	Recall/Warranty replacement of power door cable/motor/etc. Replacement hinges not covered under warranty but were recommended to replace.
179000 mi US $100	Passenger side power sliding door would not open. Power latch actuator motor failed. Replaced power latch actuator.

145000 mi US $120	Evacuate, recharge, add dye to find leak in AC Spring popped out of driver side seatbelt floor latch, setting off dash light and making it almost impossible to buckle seat belt
145000 mi US $250	Replacement of driver side seat belt floor assembly Dye test showed leaks in rear AC lines; need to be replaced
146000 mi US $1800	Replace rear AC lines Airbag light always on for driver
146000 mi US $2400	Front AC lines leaking; no cold air

14000 mi	HVAC fan making high-pitched whining noise.
19000 mi	High-pitched whining noise in front climate control fan.

21000 mi

Nav system not able to locate address shown on map. Gen 4 sys w/6.1 map DVD. Toyota said for dlr to replace map DVD with current upgrade. Dlr only wants to install 5.1 map DVD, will not order 7.1 map DVD. Found new dlr, 7.1 map DVD installed OK now. Nav system not able to locate address shown on map. Gen 4 sys w/6.1 map DVD. Found new dlr, 7.1 map DVD installed OK now.

54000 mi US $51	noisy cabin fan. So annoying, do not use the fan, or have to turn up the radio to drown out the squealing. Problem returned within 3 days, haven't returned to get it repaired yet. Dealer said leaves in fan, cleaned out.
61000 mi US $433	Power passenger door will not open with buttons in van or remote. Needs manual assist to move. Replaced motor slide assembly and 3 clips. 2.5 hours labor Overhead console failing. Usually blank. Sporadic re-occurrence with partial numbers failing, but information, when available, is accurate. Quoted $800 to replace digital display.
62000 mi US $25	Bought used computer console for overhead console on eBay from a wreck. Replaced, as well as a few light bulbs in the home link console, and it works like new.
92400 mi US $448	Power passenger door would not work except as a manual door. Replaced door "computer".

78500 mi	RES DVD Player swallowed DVD and wouldn't eject. Dealer confirmed bad and ordered a new one. Had to return later for installation.
79100 mi	Driver's side rear view mirror retract motor quit working. Had to order the parts and replace. Power sliding doors hanging up on occasion. Dealer duplicated problems and ordered parts. Rear lift gate gas cylinders recalled for losing lift capability. Both replaced by dealer under warranty.
83000 mi	Both sliding pwr doors intermittent. Dealer saw when ordered parts. Warranty svc wouldn't allow install without reduplication. No dupe so no parts. Disappointed how long parts took to come in then no install.
88000 mi	Blower motor failure. Unsafe due to no defroster.

58900 mi C $1400	Motor and cable for power sliding door. The plastic jacket of the cable cracked and stuck in the gear. The complete motor and cable assembly had to be replaced.
76880 mi C $575	Power sliding door doesn't open automatically

59871 mi US $97	Battery was no longer holding a charge
90624 mi US $2201	The left passenger auto door open/close mechanism was faulty
97000 mi	Problem was a disconnected passenger air bag wire. Reconnection fixed the problem
112000 mi	Toyota had a recall to fix the wiring for the Air Bag warning light. Came on intermittently.
136000 mi US $450	The airbag warning light switched on and off.

78740 mi C $2400

Replaced Adaptive Cruise Laser Unit

57000 mi	Broken A/C, dealer suspected Broken O-ring. Charged A/C system and replaced ring at no cost. Blowing hot air again five days later.
57500 mi	Dealer suspected broken rear o-ring. Sanded down tube and charged system and replaced o-ring. Blowing lukewarm air again a week later.

147500 mi US $568	A/C stopped working. Problem was A/C Compressor Clutch. Replaced and recharged system. Now works perfectly.
155000 mi US $360	Louver in air system failed and stopped directing heat to driver side