| 1 | 0 | 3 | 4 | 3 | 4 |
2007 Volvo S80 repairs by problem area
Engine (28%)
Transmission and Drivetrain (5%)
Brakes and Traction Control (7%)
Suspension and Steering (18%)
Electrical and Air Conditioning (35%)
Paint, Rust, Leaks, Rattles, and Trim (1%)
Other (6%)
Chart based on 88 repairs.
2007 Volvo S80 repair cost distribution
$2500+ (9%)
$1000 - $2499 (13%)
$500 - $999 (14%)
$100 - $499 (24%)
< $100 (40%)
Chart based on 70 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2007 Volvo S80
Engine not specified
| Volvo S80 in Oklahoma, United States Nov 2009 - Mar 2010 | |||
| Jan 2010 | Car locks up when turning engine off - will not release key, cannot restart. Seemed to reset itself w/in 20-30 minutes. Car was in shop over 30 days on 3 different occasions for same problem Last time replaced starter switch. Intermittent. | ||
2007 Volvo S80 4dr Sedan
turbocharged 182hp 2.4L I5 Diesel 6-speed shiftable automatic FWD
| Volvo S80 in Croatia (Hrvatska) Oct 2009 - Feb 2012 | |||
| Jan 201041540 mi | Diesel EGR valve motor failure, had to be replaced. | ||
2007 Volvo S80 4dr Sedan
311-horsepower 4.4L V8 6-speed shiftable automatic AWD
| Volvo S80 in Florida, United States Sep 2013 - Jun 2014 | |||
| Apr 201492700 miUS $2600 | Multiple modules were replaced. | ||
| Volvo S80 in Pennsylvania, United States Jan 2015 - Jun 2022 | |||
| Jan 201573000 miUS $40 | Transmission very infrequently shifts hard 1st to 2nd | ||
| Dec 201577000 miUS $130 | Replaced original Volvo battery dated February 2007. Starter sounded weaker than normal during the 25*F morning starts. No failure alarms or warnings from the car. | ||
| May 201678000 miUS $100 | AC compressor growling again, but cooled fine. Low refrigerant charge. | ||
| Jun 201679000 mi | Transmission always seemed to shift odd. I finally checked the fluid level as dealer said they could not due to transmission temperature. Dealer had changed fluid 12/2012. Found level 28 ounces low. No leaks. Shifts properly with correct fluid level. | ||
| Mar 201780199 miUS $497 | Replace four tire pressure transmitters due to failing battery | ||
| Volvo S80 in Minnesota, United States Feb 2013 - Jun 2018 | |||
| Apr 201340300 mi | Alarm/Siren Module was defective and throwing an error message on the dash. | ||
| Aug 201347000 mi | The AM radio did not work at all. Dealer fault traced and replaced the IAM. | ||
| Sep 201797500 miUS $4000 | ABS module failed Trailing arm bushing torn, needed to be replaced | ||
| Volvo S80 in North Carolina, United States Nov 2012 - Sep 2014 | |||
| Jan 201376800 miUS $700 | Tensioner & 2 belts | ||
| Volvo S80 in Pennsylvania, United States Feb 2012 - Oct 2016 | |||
| Jan 201353000 miUS $335 | I had taken my car in for Inspection and have new tire mounted. Before taking the car in one of the(TPMS)valve was leaking. The cost to replace $100.00. No other problem to report. | ||
| Mar 201653000 mi | Strut leaking in need of repair | ||
| Volvo S80 in Ontario, Canada Oct 2012 - Nov 2019 | |||
| Dec 201235340 mi | new rear diff. dem pump since a code that the Tech found was showing an intermittent short to ground. reimbursed by selling dealer. new right rear stay arm. selling dealer reimbursed. also front bpads and rotors due to rust on latter. | ||
| Jul 201743500 mi | I also took the right rear door panel apart due to a rattle. The tweeter was out of it's mounting and just dangling by it's wires! | ||
| Volvo S80 in Quebec, Canada Sep 2015 - Oct 2016 | |||
| Dec 201566340 miC $650 | Needed to replace alternator strap which suddenly broke for no apparent reason. AC compressor very noisy when activated. Flushed and replaced refrigerant after vacuum tested OK. | ||
| Volvo S80 in California, United States Mar 2016 - Sep 2017 | |||
| May 201687900 miUS $1200 | Regular maintenance found many unusual codes in engine computer. Might be caused by weak battery or alternator. Replaced battery. So far so good. Also updated software for adjustable suspension due to rough handling over bumps. | ||
| Volvo S80 in Nebraska, United States Feb 2018 - Jun 2018 | |||
| Apr 201840000 miUS $850 | Replaced shocks on the vehicle, it has active suspension. So they are special suspension system. | ||
| Volvo S80 in Iceland Jun 2017 - Jun 2022 | |||
| Apr 201886800 mi | Serpentine belt and rollers | ||
| Jun 2022116560 mi$380 | Alternator | ||
| Volvo S80 in Utah, United States Apr 2017 - Nov 2017 | |||
| Jun 201789000 miUS $5300 | Replaced both front struts. replaced brakes & rotors | ||
| Aug 201796000 mi | Leaking lower steering hose, window washer hose and radiator hose. | ||
| Volvo S80 in Minnesota, United States - Jan 2009 | |||
| Jan 200917500 mi | Low Coolant light active. Pressure test, no leaks. Filled back to limit now everything fine. | ||
| Volvo S80 in Colorado, United States Sep 2015 - Jul 2018 | |||
| Dec 201682000 mi | Replaced factory 4C electronic front struts with non electric struts. No issues after swap. | ||
| Jun 201790000 miUS $725 | Noise from front traced to broken control arm bolt. Had all bolts replaced. Had the drivers side axle boots repacked and replaced. alignment. | ||
| Mar 2018100000 miUS $80 | Xenon headlight bulbs | ||
| May 2018103000 miUS $1100 | Replaced motor mount. Had belts, idlers and tensioner replaced | ||
| Volvo S80 in New Mexico, United States Nov 2011 - Jun 2022 | |||
| May 2014105800 miUS $3200 | Replaced shocks Replaced fuel pressure regulator | ||
| Oct 2015125300 miUS $850 | O2 sensor was defective and had to be replaced | ||
| Dec 2016151000 miUS $2920 | Intake manifold replacement | ||
| Oct 2021205000 miUS $1006 | Replaced both low beam light bulbs and both ballasts | ||
| Volvo S80 in United Arab Emirates Aug 2011 - Dec 2014 | |||
| Oct 201140700 mi | Loud noise when starting and stopping. Turned out to be a bent subframe bolt and the nut could not tighten down, causing something to move that was attached to the bolt with each start or stop. Al Futtaim Volvo fixed it at no cost to me | ||
| Dec 201142780 mi | Air con made funny noise. Radiator replaced. | ||
| Jan 201345580 mi¤514 | Anti-roll bar bushing Power steering bushing o ring suspension bushing | ||
| Jun 201363240 mi¤1857 | Not sure, some kind of connecting bar | ||
| Sep 201366340 mi | Headlamp control unit failure. Dealer did not have parts and still do not have parts on october 21. Headlamp control unit failure. Dealer still does not have parts on january 2014 | ||
| Nov 201486140 mi¤1000 | Replaced radiator | ||
| Volvo S80 in Indiana, United States Dec 2009 - May 2014 | |||
| Jan 201157900 mi | Musty odor when air conditioning run. | ||
| Sep 201256000 miUS $100 | Replace exterior switch to lock door. Horrible moldy odor when air-conditioning on. | ||
| May 201470000 mi | Emissions pump failure. Check engine code P2402. Software updated by dealer, but that did not fix the problem. Apparently a very common problem with Volvos. | ||
| Volvo S80 in Nevada, United States Oct 2009 - Dec 2011 | |||
| Sep 201136000 miUS $600 | Electric trunk handle release broke at trunk. Trunk would not open. Release mechanism and related trim replaced. | ||
| Volvo S80 in Montana, United States Jun 2010 - Mar 2015 | |||
| May 201114650 mi | AC not working--recharged system and failed again. Believe it was O-ring's in connections and evaporator replaced. replace "O" rings and new evaporator unit | ||
| Jun 201220000 miUS $875 | AM radio not working. Car has only 20,000 but out of warranty (2007) and cost to repair (must replace entire module) is $875.00. Went out and bought $32 Sony AM Radio which I will use in my AUX out in car. What a rip off!!! Bad Volvo! | ||
2007 Volvo S80 4dr Sedan
235-horsepower 3.2L I6 6-speed shiftable automatic FWD
| Volvo S80 in California, United States May 2010 - Oct 2016 | |||
| Jul 201257000 miUS $1750 | struts leaking | ||
| Jul 201360000 miUS $495 | fuel regulator malfunction | ||
| Volvo S80 in Washington, United States Oct 2017 - Feb 2018 | |||
| Oct 2017105000 miUS $1100 | Multiple ignition coil failure. All six ignition coils and plugs replaced. | ||
| Volvo S80 in South Carolina, United States Jan 2010 - Dec 2015 | |||
| Mar 201026000 miUS $50 | premature wear on front leather seats; leather was replaced free of charge by volvo. | ||
| Jul 201029300 mi | dashboard airbag sensor lite up. had to order part brought car back when part arrived 7/22. replaced collision sensor "b" part# 30798511 Car fixed. | ||
| Nov 201031000 mi | tire pressure indicator lite on, checked all air pressure and replaced one sensor | ||
| Jun 201136000 mi | POWER STEERING PUMP NOT WORKING ON START UP...WORKED ONLY AFTER LETTING CAR IDLE FOR 3-4 MIN. DEALER HAD TO REPLACE RCK & PINION STEERING BOX. TWO YEARS AGO POWER STEERING PUMP AND RESERVOIR REPLACED ALSO. | ||
| Apr 201464500 miUS $235 | top engine mounts cracked both rubber bushing and aluminum housing were replaced. I questioned if the mount was defective, got their response, "it is a wear item" & I was liable for repairs. | ||
| Feb 201573000 miUS $400 | broken engine mount. 2nd time. similar problem a year ago when another engine mount broke. Is there a pattern here? I'm going to file a claim with Volvo. | ||
| Volvo S80 in Wisconsin, United States Jun 2017 - Oct 2019 | |||
| Sep 2017177000 miUS $200 | Brake hose blew a few days after inspection. | ||
| Volvo S80 in California, United States Dec 2009 - Sep 2013 | |||
| Oct 201039000 miUS $360 | Windows stopped working and 1 part replaced in driver's door and computer reflash was necessary | ||
| Jan 201256000 miUS $1600 | Replacement of broken right front strut and replacement of shocks. Calibration of active suspension. | ||
| Volvo S80 in Indiana, United States Nov 2009 - Mar 2022 | |||
| Dec 201691000 miUS $2600 | Replace the front struts (electronically controlled). | ||
| Aug 2021136800 mi | Replaced water pump, water pump/power steering coupler, rebuilt vacuum pump. | ||
| Mar 2022139000 miUS $130 | 15 year old blower motor was squeaking. Purchased motor ($79) and motor removal tool ($50) and did the work my self. | ||
| Volvo S80 in Montana, United States Nov 2009 - Jun 2022 | |||
| Apr 201034200 mi | Alternator light came on while driving. Local independant shop diagnosed alternator was not being driven. Called Volvo, flatbedded it 250 miles to the nearest dealer in Spokane. Replacing sprocket on alternator drive shaft. Dealer had never seen B4. | ||
| Feb 2016151100 miUS $1800 | Replaced original struts. They are the electrically adjustable for the sport suspension so are extremely expensive. | ||
| Volvo S80 in New Jersey, United States Apr 2012 - May 2012 | |||
| May 201239000 miUS $400 | car would stutter and stall. then they charged me $400 for a battery that died trying to start it. | ||
| Volvo S80 in Missouri, United States Jun 2011 - Jul 2017 | |||
| Oct 201360500 miUS $400 | The vehicle was leaking oil slightly from the top of the engine. Had to replace the entire vacuum pump as a non-serviceable seal was leaking. The vehicle was leaking oil slightly from the top of the engine. Had to replace the entire vacuum pump as a non-serviceable seal was leaking ($400). | ||
| Aug 201466300 miUS $100 | Engine would cut out, no warning. Running very rich when it would run, but ran very poorly. Replaced fuel pressure regulator on fuel rail as sensor was telling fuel pump it wasn't receiving enough fuel. Also replaced spark plugs as fouled | ||
| Volvo S80 in Iowa, United States Sep 2010 - May 2013 | |||
| Jan 201138000 mi | siren module in car alarm | ||
| Jan 201360900 mi | The assembly that holds the oil filter to the engine block failed. A gasket went bad, allowing air to be drawn in. | ||
| Volvo S80 in Wisconsin, United States Oct 2010 - May 2019 | |||
| Sep 2013114000 miUS $400 | Main parking assist module failed. After replacing it dealer also indicated right rear parking assist sensor needed to be replaced. | ||
| May 2014122300 miUS $200 | Trunk lock handle broke. | ||
| Sep 2017183000 miUS $200 | Parking assist sensor needed to be replaced. | ||
| Volvo S80 in Colorado, United States Oct 2009 - Dec 2015 | |||
| Jun 201034000 mi | Replaced relay that shorted heated seats, swiveling headlights and active chassis | ||
| Sep 201034000 miUS $2 | replaced gas cap due to broken seal | ||
| Jun 201139000 mi | Recall notice on coolant seal wear and tear causing leaks. I had noticed the leak but didnot know it was a recall until volvo informed me. | ||
| Aug 201139000 mi | TPS monitor light was on due to malfunctioning TPS sensor in one of the wheels. | ||
| Jun 201243000 miUS $80 | Dip stick tube seal | ||
| Apr 201347000 miUS $600 | Brake fluid leak | ||
| Volvo S80 in Texas, United States Jan 2010 - Sep 2011 | |||
| Jul 201047000 mi | |||
2006.5 Volvo S80 4dr Sedan
turbocharged 182hp 2.4L I5 Diesel 6-speed manual FWD
| Volvo S80 in Great Britain Jun 2010 - Jun 2011 | |||
| Aug 201099000 mi£60 | Sheared bolt on assembly for electronic handbrake - turned out this was reason for uneven disc wear, which was reason car was in, in first place. | ||
See TrueDelta's information for all Sedans
See TrueDelta's information for all Volvo models.
