| 1 | 0 | 3 | 4 | 3 | 4 |
2010 Mercury Milan repairs by problem area
Engine (27%)
Transmission and Drivetrain (15%)
Brakes and Traction Control (4%)
Suspension and Steering (12%)
Electrical and Air Conditioning (29%)
Paint, Rust, Leaks, Rattles, and Trim (10%)
Other (2%)
Select a problem area
- Engine
- Transmission and Drivetrain
- Brakes and Traction Control
- Suspension and Steering
- Electrical and Air Conditioning
- Paint, Rust, Leaks, Rattles, and Trim
- Other
Chart based on 92 repairs.
2010 Mercury Milan electrical repair cost distribution
$2500+ (0%)
$1000 - $2499 (4%)
$500 - $999 (4%)
$100 - $499 (8%)
< $100 (83%)
Chart based on 24 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.
2010 Mercury Milan 4dr Sedan
240-horsepower 3.0L V6 6-speed shiftable automatic FWD
| 111000 mi US $70 |
Hot air coming from vents (especially on the passenger side) when A/C is on....bad blend door actuator suspected (a common problem on a lot of cars). Replaced actuator under steering wheel, no change. The other two actuators can only be accessed reportedly by removing the dash...10 hours of labor for a $35 dollar part (dumb engineering)...living with the problem until I get the opportunity to try and get at the passenger side actuator.. |
| 39500 mi US $551 |
r/r Tail LED Light Assembly, 9n7z 13404a $550.15 not covered by Premium ESP Extended Warranty 37 months , 39000 miles on carrnOne side noticeable dimmer hard starting in morning or after long waits 37 months on car Dealer said battery bad, ESP Premium care - no coverage |
| 152800 mi | Drivers side LED tail light out. |
| 52865 mi US $131 |
Faulty steering wheel controls for blue-tooth related controls for cell phone operation. Replaced clockspring, switch asy-control, cover and contact. |
| 64000 mi | Right rear stop lights/running light partially out. Dealership, on a Friday, ordered replacement for over-night delivery. Replaced, in less than an hour on Saturday. Covered by a TSB. |
| 33700 mi | Starter motor was damaged by selling dealer and replaced by servicing dealer during transmission rebuild. |
2010 Mercury Milan 4dr Sedan
175-horsepower 2.5L I4 6-speed automatic FWD
| 37900 mi US $150 |
Battery had completely died. Self replaced from AutoZone. |
| 17000 mi | Battery died just before 3 yr. warranty was up. New battery installed no charge. |
| 28000 mi | Airbag warning light would go on periodically.Dealer traced problem to "clock spring" inside the steering wheel.No charge for this repair since it falls under Federal Law for airbag repairs (5 yrs. or 60K miles). |
| 42000 mi | Rear taillights failed, brake lights on instead of taillights. Known problem with LED taillights on Ford products. |
| 121000 mi US $1344 |
replaced the passenger seat power assembly |
| 124000 mi US $21 |
Drivers side headlight blew. I replaced both headlights. |
| 56000 mi US $60 |
Replaced chirping blower motor. $60 part, 5 minutes to replace. Three 5.5mm bolts from below glove compartment. Intermittent 'Blind Spot Not Available' error. Removed rear bumper, repaired splice on BLIS sensor harness. Total cost negligible, some heat shrink and dialetric grease. |
| 9000 mi US $1 |
radio fades in and out |
| 28000 mi | GPS sensor went out. Still working on getting repair in order. |
| 39000 mi | right headlamp failed. replacement requires access through a cover in the wheelwell; car too *** low for my portable floor jack so I took to dealer for replacement. |
| 76800 mi US $94 |
License plate lights rusted & nonworking. Parts were replaced. |
| 105800 mi | Headlamp on the left side (the first one on that side). |
| 14300 mi | Battery was failing. Dealer replaced under warranty. Dealer checked electrical system/draw, etc. Was at dealer for 3 hours approx. |
| 14200 mi | LED Brake lights came when parking lights/head lights were turned on. Dealer determined that both rh and lh LED tail lights were defective and replaced both tail light units. Tail lights are self contained LED's and required replacement. |
2010 Mercury Milan 4dr Sedan
156-horsepower 2.5L I4 Hybrid CVT FWD
| 9000 mi | The lower voltage battery failed. The dealer didn't have one in stock and it needed to be ordered |
| 20800 mi | Driver side Tail light stayed in the "bright" mode, as if the brake pedal was pushed. This is a LED systen and the entire module had to be replaced. Shop tells me the module price is over $300 if not covered by warranty |
| 65300 mi US $45 |
Drivers side headlamp needed to be replaced |
| 50000 mi | After the system reflash for the wrench light/pcm issue, left dealership and within 1/2 hour, the backup/rear parking aid warning speaker failed. Had to have this speaker replaced. I believe it was related to the reflash. |
| 55553 mi US $1300 |
AC condenser |
See TrueDelta's information for all Sedans
See TrueDelta's information for all Mercury models.
