2008 Ford F-150 Ford F-150 2008

We are 106,000+ car owners sharing real-world car information.

Join Us

2008 Ford F-150 repairs by problem area

Engine (41%)

Transmission and Drivetrain (11%)

Brakes and Traction Control (7%)

Suspension and Steering (11%)

Electrical and Air Conditioning (20%)

Paint, Rust, Leaks, Rattles, and Trim (5%)

Other (2%)

Chart based on 56 repairs.
See TSBs and recalls for the 2008 Ford F-150.

2008 Ford F-150 repair cost distribution

$2500+ (2%)

$1000 - $2499 (14%)

$500 - $999 (14%)

$100 - $499 (37%)

< $100 (33%)

Worried about potential repair costs? An extended warranty can provide peace of mind.

Chart based on 43 repair trips. The repair cost chart excludes repairs made under warranty, do-it-yourself repairs, and repair trips that include maintenance.

2008 Ford F-150 4dr Regular Cab 8ft bed

248-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Texas, United States
May 2010 - Dec 2014
Sep 2011

102000 mi

US $335
Oil leaking from rear axle. Pinion seal replaced by dealer without incident. Satisfactory repair. 102,000 miles, first repair. 

Return to top

2008 Ford F-150 4dr Regular Cab 8ft bed

202-horsepower 4.2L V6 4-speed automatic RWD

Ford F-150 in Texas, United States
Jun 2017 - Jun 2017
May 2017

112000 mi

US $250
replace catalytic converter 

Return to top

2008 Ford F-150 4dr Regular Cab 6.5ft bed

202-horsepower 4.2L V6 5-speed manual RWD

Ford F-150 in Arkansas, United States
Aug 2009 - Aug 2012
Mar 2009

26000 mi
Dealer said it was dirt, but would check with ford dealer got ok to Fix said they replaced all rotating componants on engine 

Return to top

2008 Ford F-150 4dr Regular Cab 6.5ft bed

202-horsepower 4.2L V6 4-speed automatic RWD

Ford F-150 in North Carolina, United States
May 2010 - Jul 2018
Jan 2015

US $102
Had to check electrical system. Replaced left blinker and left backup light. 
Mar 2016

96000 mi

US $1500
Replaced valve cover gaskets due to oil leak. Sudden failure of 2 cylinders. Had to replace spark plugs, coils and wiring. Happened at 95k. Plugs were supposed to last 100k 
Mar 2018

121 mi

US $485
Replaced front rotors and pads 

Return to top

2008 Ford F-150 4dr Extended Cab 8ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Texas, United States
May 2010 - Jun 2011
Jun 2010

44000 mi
Throttle Body and Fuel Rails Cracked and with defective seals, likely exacerbated by ice. 
Ford F-150 in Montana, United States
Aug 2010 - Jun 2014
Dec 2010

20000 mi

US $47
Check engine light & ABS light. Check Gas cap light. Part was ordered,"Rear wheel speed sensor"? 

Return to top

2008 Ford F-150 4dr Extended Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Texas, United States
Dec 2014 - Dec 2014
Dec 2014

84000 mi
Driveshaft yoke wear, causing clunking during takeoff. Adjusted driveshaft yoke and regreased. Solved the problem. 
Ford F-150 in Washington, United States
Apr 2015 - Jun 2015
May 2015

120700 mi

US $40
Replaced the oil dipstick and tube 

Return to top

2008 Ford F-150 4dr Extended Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Pennsylvania, United States
Sep 2012 - Apr 2018
Apr 2015

80000 mi

US $500
Just needed to be replaced. Changed out wheel hubs also. 
Jun 2015

80000 mi

US $7200
Oil pump failed resulting in a blown motor 
Jul 2016

99000 mi

US $600
Replaced struts, sway bar links. Had to replace inner tie rod, upper and lower control arm. 
Apr 2017

113000 mi

US $300
My struts top bolts snapped had to replace and then get an alignment. 
Ford F-150 in Ontario, Canada
Jun 2010 - Aug 2013
Jul 2010

26040 mi

C $125
Air filter improperly installed at quick lube shop, caused rough idle and dirty maf sensor - fixed but not under warranty because of air filter. 
Jul 2012

52700 mi

C $150
blower fan lost first 3 speeds only works on 4. 
Aug 2013

68200 mi
Ongoing problem with 4x4 hubs ,solenoid switch was replaced but front left wheel grinds, there is a problem in vacuum system to engage in 4 wheel when not needed or on. tries to switch in 4 wheel and grinds,still diagnosing... battery light coming on,rebuilt alternator brushes. 
Ford F-150 in Alberta, Canada
Aug 2015 - Jun 2018
Dec 2015

205220 mi

C $480
Replaced transmission with rebuilt one. 
Jan 2016

C $1980
Rebuilt timing chain components including new phasers, timing chains, guides, VCT solenoids, etc. 
Oct 2016

216160 mi

C $500
Replaced broken driver's side leaf spring. Added wheel spacers to vehicle Added 2" Leveling Kit to the front 
Jun 2017

221960 mi

C $50
Replaced Front Brake pads 

Return to top

2008 Ford F-150 4dr Extended Cab 6.5ft bed

248-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Washington, United States
Oct 2012 - Apr 2015
Apr 2015

90000 mi
A sensor went out and had to be replaced 

Return to top

2008 Ford F-150 4dr Crew Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Missouri, United States
Feb 2011 - Jun 2018
May 2011

25000 mi
Dealer replaced blend valve. This part allowed AC and or Heat to be adjusted in small amounts. Before repair either to hot or to cold. 
Sep 2011

28000 mi
Transmission appeared to slip during downshift in slow speed. Had called this in after initial 36 month warrantee expired. Dealer said computer may need new program from ford. I indicated should be under warrantee. They fixed. No charge. 

Return to top

2008 Ford F-150 4dr Crew Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Alberta, Canada
Nov 2011 - Dec 2015
Mar 2012

63240 mi

C $625
Horn Assembly stopped working Rough shifting in 2nd gear when soft accelerating at 40kms/hr 
Oct 2012

70640 mi

C $1350
Exhaust leak in engine manifold 
Apr 2014

98660 mi

C $2120
Fuel Pump Module failure, fuel filter and fuel pump. Went just like that - no notice. 
Ford F-150 in Tennessee, United States
- Nov 2009
Nov 2009

38945 mi

US $100
Replaced the dashboard display cluster  

Return to top

2008 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Wisconsin, United States
Dec 2010 - Jun 2018
Feb 2011

38000 mi

US $988
TPMS fault and lite. Truck w/22" wheels, dlr replaced w/2010-17" wheels. No joy. Owner replaced tires, stem sensors in place, but unable to correct problem. 2008 model requires band sensors. Repair cost too much for the inconvenience now. RH mirror defroster inop. Replaced mirror glass. LH W/S cowling popped loose. Due to cold weather,and possibility of breaking the cowling, a temporary fix of drilling a hole and inserting a screw to attach to RH cowling was done. Will complete repair after spring gets here. Dlr installed 17" wheels with load rating 'E' tires causing truck to ride extremely stiff. Owner replaced with the correct load rating tires. 
Aug 2012

52300 mi

US $1200
replaced front and rear shocks. Ride starting to get a little harsh. Decided to replace while brakes were being done at the same time. 
Oct 2014

64000 mi

US $1250
Replaced serpentine belt. A/C not working. Replaced compressor, switch & relay. Serviced & road tested. 
Ford F-150 in Florida, United States
Jun 2010 - Sep 2012
Dec 2011

40000 mi

US $150
Door on overhead sunglass holder broke. 

Return to top

2008 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic AWD

Ford F-150 in Ontario, Canada
Mar 2011 - Jul 2011
Jun 2011

56420 mi

C $900
Radiator Faulty, lost coolant, towed to dealership. Dealer installed new rad, but did not properly reattach tranmission cooler lines, lost some coolant, fixed and topped up, no issues since 
Ford F-150 in Ohio, United States
Mar 2011 - Apr 2011
Apr 2011

21000 mi
heat/AC control unit malfunctioned 

Return to top

2008 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in New York, United States
Jan 2014 - Dec 2014
Nov 2014

110300 mi

US $450
Leaking Exhaust Manifold Gasket 
Ford F-150 in Iowa, United States
Feb 2011 - Sep 2016
Jun 2016

66000 mi

US $175
replaced Right exhaust manifold, 1 broken stud at manifold. replaced manifold 
Ford F-150 in Michigan, United States
Oct 2013 - Apr 2016
Jun 2014

74000 mi

US $100
Truck would make a growling sound - only when hot - dealer said pulleys were bad. Replaced both pulleys and the belt tensioner, along with new serpentine belt. 
Feb 2015

80000 mi

US $63
Engine howled when started -- intermittent -- then would stop. Dealer diagnosed bad alternator bearing, but wanted $560 for replacement. Performed repair myself -- howl is still there. 
Apr 2016

88000 mi
Took the truck to three different mechanics for the howl. They said it was because of how the air box was designed. Only did it below 40 degrees. 
Ford F-150 in Texas, United States
Aug 2011 - Aug 2013
Sep 2011

63000 mi
Dealer fixed the dash trim around stereo when I purchased it, a clip had come out. 
Jun 2013

88000 mi
Shifter won't shift out of Park, replaced the Brake pedal sensor, and this fixed it for a week or 2. starting to act up again may require replacing entire shifter assembly 
Aug 2013

88000 mi
Shocks were needing full replacement, as were Brakes, tires,  and shift lever was sticking in Park. 

Return to top

2008 Ford F-150 4dr Crew Cab 5.5ft bed

248-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in North Carolina, United States
Mar 2017 - Apr 2018
Apr 2018

100000 mi

US $815
Plugs, Wires, Throttle body, Filter, Fuel pump. 
Ford F-150 in New York, United States
Aug 2017 - Nov 2017
Jun 2017

88000 mi

US $50
tires 

Return to top

2008 Ford F-150 4dr Crew Cab 5.5ft bed

248-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Texas, United States
Mar 2013 - Sep 2015
Jul 2015

132700 mi

US $200
I had never replaced the antifreeze. The radiator sprang a leak, and after seeing the condition of the fluid I decided to replace everything but the heater core and lower radiator hose. 

Return to top

2007.5 Ford F-150 4dr Extended Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Saudi Arabia
Dec 2014 - Jan 2015
Dec 2014

171740 mi

﷼2
reduced engine power 

Return to top

2007 Ford F-150

Engine not specified

Ford F-150 in Texas, United States
Nov 2009 - Mar 2011
Mar 2010

17000 mi
Rough engine idle and low AC output. Both were addressed with TSB's and were resolved by dealer. 
Ford F-150 in Alberta, Canada
Nov 2010 - Mar 2011
Dec 2010

29760 mi

C $300
4x4 solenoid failed 

Return to top

2007 Ford F-150 4dr Regular Cab 8ft bed

202-horsepower 4.2L V6 4-speed automatic RWD

Ford F-150 in North Dakota, United States
Nov 2008 - Jun 2011
May 2010

25000 mi
replaced power steering pump 

Return to top

2007 Ford F-150 4dr Regular Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Quebec, Canada
Apr 2013 - Jun 2018
Jun 2013

65100 mi

C $510
replaced both tie rod ends and upper ball joints 
May 2014

70460 mi

C $540
r/h side exhaust manyfold broken due to water splashing on it and poor protection. Common problem on all F-150, part too thin compared to l/h side witch never breaks All connections and wires badly corroded due to lack of protection for this unit underneat the vehicule. Cost $180 for starter but no time charged because starter had to be removed to relace broken studs on manyfold. 
May 2015

73160 mi

C $205
Had to replace 2 power steering hoses badly corroded and leaking. parts $205 and almost 2 hours for replacement and bleeding the power steering system 

Return to top

2007 Ford F-150 4dr Regular Cab 6.5ft bed

202-horsepower 4.2L V6 5-speed manual RWD

Ford F-150 in New York, United States
Sep 2008 - Jul 2015
Jul 2008

7600 mi
Replaced both rear leaf springs and assembly due to squeaking.  
Aug 2008

8000 mi
Both sides of wiper cowl replaced. One side popping up. Common on all F150's in this generation. 
Sep 2008

8900 mi
Many part of the A/C system replaced. Will be going back to the dealer for the 5th time when a back ordered part arrives.  
Dec 2008

9500 mi
Parts of steering assembly replaced due to vibration in the steering wheel when turning. 
Jun 2009

11000 mi
Throttle body and assembly replaced.  
Nov 2009

14000 mi
Drivers seat fabric replaced. 
Dec 2009

15000 mi
Had lifters replaced. 
Jan 2010

16000 mi
All 4 rotors turned due to premature warping. After rotors were turned they warped even more and had to be completely replaced at 17k miles. 
Nov 2010

28000 mi
Oil leaking from gasket on oil pan. Dealer found oil leaking from front crank seal and found severely grooved harmonic balancer. Seal and balancer were replace, leak fixed. Oil leaking from gasket on oil pan. Currently being fixed at the dealer. 
Jun 2013

67000 mi
Second wheel bearing replaced on drivers front in a year. Both upper ball joints worn at 60k miles. Stock suspension, never off road. I replaced UCA's myself with Moog greaseable. 
Jul 2015

98000 mi

US $1089
Truck started making a horn like sound with ac on. Bearing went out in ac compressor. Compressor, clutch and serp belt replaced. Ac system evacuated. 

Return to top

2007 Ford F-150 4dr Regular Cab 6.5ft bed

202-horsepower 4.2L V6 4-speed automatic RWD

Ford F-150 in Ohio, United States
Apr 2015 - Dec 2015
Apr 2015

79000 mi

US $165
Fuel pump control module above spare tire. Known problem with case corroding and exposing electronic board inside. Exhibited cranking after key was released while starting. Computer evidently over rides the ignition switch. No start cond. 
Ford F-150 in Washington, United States
Apr 2015 - May 2015
May 2015

78000 mi

US $265
Door latch was loose. New door latch 
Ford F-150 in Louisiana, United States
Jun 2015 - Sep 2015
Aug 2015

107700 mi

US $380
NEEDED ROTORS AND BEARINGS AND TIRES BAD VIBRATIONS AND NOISE, axle 
Ford F-150 in Ontario, Canada
Jul 2010 - Jul 2014
Aug 2010

54560 mi
Replaced upper balljoints and wheel bearing, missed on safety 
May 2013

105400 mi

C $150
Replace serpentine belt, belt tensioner and idler pulleys 
Sep 2013

110360 mi

C $600
Upper control arms, ball joints on both sides 
May 2014

122140 mi

C $250
Replace broken left rear center spring 

Return to top

2007 Ford F-150 4dr Extended Cab 8ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Georgia, United States
Apr 2013 - Oct 2013
Aug 2013

190700 mi

US $292
EGR Valve 

Return to top

2007 Ford F-150 4dr Extended Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in British Columbia, Canada
Dec 2012 - Jan 2013
Jan 2013

49600 mi
Drive side power window does not work. 
Ford F-150 in Ontario, Canada
Oct 2012 - Jun 2017
Nov 2012

161920 mi

C $500
4x4 does not engage fully creating a racheting sound. Replaced 4x4hub and vacuum switch. Noise still occours occasionally. 
Sep 2013

163680 mi

C $1750
crankshaft sensors and crankshaft phasers 
Sep 2015

168020 mi

C $126
replace solenoid valve on the 4x4 vaccum system .this part only 1 year old 
Jun 2016

176700 mi
truck will not stay running.diagnostics show no problem when its running .when it stops they can get no readings,. 
Jul 2016

176800 mi
Truck would just stop running, and then not respond to turning the key. After sitting it would start and maybe run for a few days and then you would get in and it would not start. The fuel sending unit was fine. Replaced main brain with used one. 
Mar 2017

179800 mi
I have no reading on the screen for odometer or outdoor temp. it does illuminate but it is just blank I have not had this looked at This is since I changed the main computer board last spring. 
Ford F-150 in Georgia, United States
Feb 2012 - Apr 2013
Apr 2012

64300 mi

US $350
Small problem servicing took care of. 
Ford F-150 in New York, United States
May 2011 - Jan 2012
Oct 2011

46700 mi

US $600
Had to replace All 4 ball joints. Labor $400. Parts $200. 
Dec 2011

49000 mi

US $500
Alrernator Died. 
Ford F-150 in British Columbia, Canada
Jan 2012 - Jun 2018
Jan 2013

53320 mi

C $555
stiff steering - had to replace intermediate steering shaft because it was seizing (rust?). Mechanic sourced used shaft for $150.00. 
Jul 2013

55280 mi

C $766
power steering pump started leaking - hose connection rusted out.Extra labour needed because of rusty bolts. 
Jul 2016

68400 mi

C $625
replaced both upper control arms replaced noisy idler pulley and belt tensioner 
Mar 2018

75020 mi

C $400
had to replace faulty turn signal switch 
Jun 2018

76446 mi

C $270
Repaired engine misfire - had to replace spark plug and ignition coil on cyl #7 
Ford F-150 in Virginia, United States
Nov 2012 - Sep 2013
Feb 2013

88300 mi
Discovered truck has blown shocks. Indicator was tire cupping and vibration at highway speeds. 
Sep 2013

90000 mi
Ticking sound, bogging and dying at idle. Mechanic said the engine needed to be rebuilt or replaced because of damage due to lack of lubrication. 
Ford F-150 in Michigan, United States
Dec 2013 - Mar 2014
Jan 2014

103200 mi
replaced battery 
Ford F-150 in Ontario, Canada
Oct 2014 - Nov 2014
Nov 2014

74400 mi

C $383
leaf spring broke not fault of the truck 

Return to top

2007 Ford F-150 4dr Extended Cab 6.5ft bed

248-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Texas, United States
Jul 2012 - Jun 2018
Aug 2014

68600 mi

US $350
replace power steering pump 
Nov 2016

93000 mi

US $700
Replaced universal joints 
Ford F-150 in Nova Scotia, Canada
Nov 2011 - Jan 2012
Dec 2011

50840 mi

C $700
auto locking hubs not working....replaced 1 hub, hose, solenoid for system 
Ford F-150 in New Hampshire, United States
Jun 2010 - Apr 2012
Apr 2012

134000 mi
Engine was experiencing an issue where it was losing power and knocking loudly. Mechanic said it was a failure within the engine. Recommendation was to replace engine. Truck was immediately traded in. :-) 

Return to top

2007 Ford F-150 4dr Extended Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Texas, United States
- Mar 2008
Mar 2008

8000 mi
replace ill fitting cowl cover 

Return to top

2007 Ford F-150 4dr Extended Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Minnesota, United States
Feb 2013 - Mar 2018
Jan 2013

75000 mi
Work has not been completed as the cost is too high when weighed against need to have CD player functional 
Apr 2013

77000 mi

US $115
Battery did not hold charge. At end of life. 
Aug 2016

102900 mi

US $460
Engine idling rough, slight miss once in a while. Decided that I should change plugs. 2 spark plugs broke off and needed to get extracted This occurred at 103,000 miles 
Oct 2016

104200 mi

US $250
Engine still missing and running roughly when idling. When pulling a full rated load (9600 lbs) at highway speeds the truck shudders slightly as though it is missing. Decided to change my coil packs. 
Mar 2017

108000 mi

US $450
Fuel pump module mounted to frame above fuel tank in front of spare tire had corroded through and caused rough engine Spark plug was loose and blowing by Truck was brought in for tire rotation and balance, mechanics noticed rear pads were shot and damaged rotor 
Ford F-150 in Alberta, Canada
Feb 2011 - Mar 2011
Mar 2011

59520 mi

C $625
Replaced spark plugs before they were due because I'd been warned about not being able to get them out later. What a damn joke. Four plugs broke off, the other four were an absolute b*gger to get out. Cost me over $600 for 8 plugs! Junk. 

Return to top

2007 Ford F-150 4dr Extended Cab 5.5ft bed

248-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in New Mexico, United States
Mar 2011 - Apr 2012
Apr 2011

308500 mi

US $300
intake manifold cracked (actually March 2011) earlier intake manifold replacement had to be removed and replaced due to gasket failure. together with thermostat and water pump replacement (in October 2010) this finally fixed long list of cooling problems. 
Apr 2012

400000 mi
vehicle has had a vibration since day one have been to Ford alignment shops rebuilt driveline replaced wheels, wheel bearings, U-joints, tires, rebalanced tires (often two or three times per set of tires). going to try replacing harmonic balancer next 
Ford F-150 in Indiana, United States
Mar 2012 - Jul 2018
Sep 2015

125000 mi

US $896
Output housing failed. 
Ford F-150 in Alabama, United States
Dec 2012 - Dec 2016
Nov 2016

198700 mi

US $4000
Transmission went out completely 
Dec 2016

203000 mi

US $400
Shaking in the front end required replacement of upper and lower ball joints and outer tie-rod ends on both sides (front). 
Ford F-150 in Ohio, United States
Jan 2013 - Apr 2016
Apr 2016

95000 mi

US $700
Intake manifold replaced. 

Return to top

2007 Ford F-150 4dr Extended Cab 5.5ft bed

248-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Michigan, United States
Dec 2011 - Sep 2014
Sep 2014

94000 mi

US $700
replaced two coil packs and all plugs. Had weak fire on one cylinder and no fire on another. 

Return to top

2007 Ford F-150 4dr Crew Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Ohio, United States
Mar 2010 - Apr 2017
Aug 2010

17600 mi
Front "Ford" emblem peeled away and wiper shroud popping up. Dealer ordered replacement parts 
Sep 2010

19000 mi
Replaced front emblem and wiper shoud. 
Jan 2014 Rear calibers were frozen and HAD to replace. 
Feb 2014

69900 mi

US $22
Had to replace the fan motor variable resistor 
Dec 2016

130000 mi

US $675
I have a 5.4 engine that was sluggish on hills was told need tuneup. Seems like flaw in these engines sparkplugs break off and have to be drilled out. This is normal for 5.4 engine Should be a recall from Ford but isn't. Power steering hose leaking 
Feb 2017

132000 mi

US $350
Transmission lines needed to be replaced 
Ford F-150 in California, United States
Oct 2009 - Jun 2014
May 2014

95900 mi

US $270
New starter. 

Return to top

2007 Ford F-150 4dr Crew Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Virginia, United States
Apr 2010 - Dec 2011
Dec 2011

53000 mi

US $100
Bad Caliper, rotors and brake pads needed replacing 
Ford F-150 in California, United States
Apr 2012 - Aug 2012
May 2012

32800 mi

US $150
Battery discharged 
Ford F-150 in Illinois, United States
Nov 2011 - Jul 2018
Feb 2013

66900 mi

US $300
Replaced rf tie rod again 
Aug 2014

84300 mi

US $160
Upper right ball joint 
Jun 2015

95000 mi

US $250
Alternator 
Aug 2015

95800 mi

US $150
Spark plug change. 3 broken plugs. 
Dec 2015

100000 mi

US $310
Fuel pump driver module. 
Feb 2017

111000 mi

US $100
Steering shaft replacement. 
Feb 2018

121000 mi

US $100
Front wheel bearings. 
Ford F-150 in Maryland, United States
Apr 2014 - Sep 2015
Jul 2015

122700 mi

US $225
Pinion seal in rear end was leaking and had to be replaced. 
Ford F-150 in New Mexico, United States
May 2011 - Jun 2012
Oct 2011

34700 mi

US $500
vent door actuator was defective, replaced it to get proper heating selection for either defrost, vent, and floor. 

Return to top

2007 Ford F-150 4dr Crew Cab 5.5ft bed

supercharged 450hp 5.4L V8 4-speed automatic RWD

Ford F-150 in New Jersey, United States
Apr 2009 - Jun 2013
Jun 2011

39000 mi

US $300
Broken wire on camshaft sensor 

Return to top

2007 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Florida, United States
Mar 2007 - Mar 2010
Sep 2007

8000 mi
Replaced orifice tube, AC not blowing cold quick enough 
Ford F-150 in Texas, United States
Apr 2011 - Feb 2017
May 2011

52000 mi
Very slow to switch modes when selecting different vents, and system makes a groaning sound while switching modes Accessory 12V outlet not functional when we took delivery, submitted for free repair during first 30 days from Carmax. Switching on AC causes unsteady idle with noticeable vibration. Dealer (Carmax, not Ford) claims this is normal, will take to Ford dealer for 2nd opinion. 
Jun 2011

52000 mi
New blend door actuator installed after part arrived. 
Jul 2011

52000 mi

US $200
Excessive vibration when AC was on. Called normal by Carmax, completely eliminated by compressor replacement by Ford dealer, repair covered by Maxcare. 
Dec 2013

74000 mi

US $200
Rear bearing and bushing failed, brass found throughout transmission. Replaced with rebuilt unit. 
Feb 2016

94600 mi

US $200
Cracked exhaust manifold 
Ford F-150 in Texas, United States
Mar 2009 - Dec 2011
Aug 2011

99000 mi

US $987
Control head for odometer and computer failed. Replaced unit and rechecked mileage to car computer 

Return to top

2007 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in North Carolina, United States
Feb 2016 - Jun 2018
Sep 2017

119000 mi

US $800
replaced upper and lower ball joints in front 
Ford F-150 in California, United States
Sep 2010 - Nov 2011
Aug 2011

59000 mi

US $250
had to have the transmission software updated 
Ford F-150 in Wisconsin, United States
Dec 2011 - Jul 2018
Sep 2012

202000 mi

US $73
Replaced driver side cv axle. 
Jun 2013

227000 mi

US $179
replaced both rear u-joints. 
Ford F-150 in Minnesota, United States
Dec 2014 - Jun 2018
Dec 2015

84000 mi

US $100
Rough Idle - Dealer replaced cam phasers, and timing chain tensioners. Noise from front of vehicle on decel, dealer found left front wheel bearing bad, replaced noise is gone Reverse sensors not working - dealer replaced sensor and now working 
Ford F-150 in British Columbia, Canada
May 2011 - Nov 2011
Jun 2011

43400 mi

C $200
After market exhaust replaced. 
Ford F-150 in Louisiana, United States
Jul 2008 - Sep 2012
Sep 2008

24000 mi
Engine tick. 
Mar 2011

67000 mi

US $35
Blend door actuator replaced REPLACED BLEND DOOR ACTUATOR 

Return to top

2007 Ford F-150 4dr Crew Cab 5.5ft bed

248-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Oklahoma, United States
Jun 2014 - Jun 2018
Jan 2018

165000 mi

US $206
Driver Window 
Ford F-150 in Texas, United States
Apr 2011 - Dec 2016
Dec 2016

133000 mi
Started running rough, and intermittently VERY rough with CEL lit. It was narrowed down to the #8 cylinder, but checked both the coil pack and plug to be okay. Might have been a wiring issue. 

Return to top

2007 Ford F-150 4-door

8-cylinder automatic 2WD

Ford F-150 in Texas, United States
Mar 2008 - Mar 2010
Apr 2008

15000 mi
The F150 XLT Triton Logos were losing paint and beginning to peel. Ford Dealer removed and replaced. 

Return to top

2006 Ford F-150

Engine not specified

Ford F-150 in Texas, United States
Jul 2010 - Jun 2011
Aug 2010

60000 mi

US $1500
Rear end bearings were bad 
Ford F-150 in Florida, United States
May 2012 - Jun 2012
Apr 2012

US $700
spongy brakes dealer wanted 700 bucks.to much money so i am living with it. 

Return to top

2006 Ford F-150 4dr Regular Cab 8ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Georgia, United States
Mar 2010 - Jan 2018
Nov 2014

40000 mi

US $105
Check engine light diagnostic reported a problem with a connector under the spare tire. Dealer wanted $460 to lower the tire and replace the connector, $50. I refused their service and repaired the connector myself at home. 

Return to top

2006 Ford F-150 4dr Regular Cab 8ft bed

202-horsepower 4.2L V6 4-speed automatic RWD

Ford F-150 in Oklahoma, United States
May 2013 - Jun 2013
Jun 2013

140000 mi

US $1200
Forward gears were all out. 

Return to top

2006 Ford F-150 4dr Regular Cab 6.5ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in South Carolina, United States
Mar 2011 - Jun 2018
Mar 2012

64000 mi

US $100
passenger up, down switch would not move window down. Diagnosied as faulty window switch and replaced under extended warranty dash cupholder / ashtray would not pop out after being pushed in. 
May 2012

64600 mi
returned to dealer and window switch fixed with parts ordered under extended warranty. ashtray would not come out after pushed in. returned to dealer and fixed with parts ordered under extended warranty. 
Mar 2016

97000 mi

US $26
Replaced spark plugs with oem motorcraft sp-413 plugs 
Dec 2016

105000 mi
I had my truck detailed and the tech broke the sunglass holder door. I found a new one online from Ford and the detail co. bought it and I installed it. 
Feb 2018

114000 mi

US $23
Engine had definite miss,check engine light came on, Fixd displayed code P0303, misfire cyl #3 and P0171, fuel injection sys to lean. While removing coil on cyl. 3 I broke the line to the pcv valve. Plug looked good, no carbon tracking so switched coil and plug from #3 to #1 and replaced hose I broke with aftermarket rubber hose. Fired her up and didn't hear or feel any miss. Road test was great and Fixd didn't detect any codes!! 
Ford F-150 in Texas, United States
Aug 2015 - Jun 2016
Mar 2016

125000 mi
Low idle/engine dying when the AC compressor engaged. The problem was solved by cleaning throttle body. 
Ford F-150 in Florida, United States
Oct 2017 - Oct 2017
Oct 2017

215000 mi

US $65
engine miss replaced #7 coil pack 

Return to top

2006 Ford F-150 4dr Regular Cab 6.5ft bed

202-horsepower 4.2L V6 5-speed manual RWD

Ford F-150 in Ohio, United States
Apr 2011 - Oct 2015
Nov 2012

95900 mi

US $68
Diagnosed misfire and replaced coil pack. 
Jun 2014

118000 mi

US $180
Alternator seized, breaking serpentine belt. Replaced alternator and belt. Left front brake caliper seized and was replaced. 
Aug 2014

118900 mi

US $100
Coolant sensor failed 
Nov 2014

120000 mi

US $60
Replaced noisy idler pulleys and tensioner pulley (bad bearings). 
Jun 2015

124000 mi

US $90
Replaced front brake rotor to repair broken ABS trigger wheel 
Jul 2015

124000 mi

US $120
Fuel pump control module 
Ford F-150 in Florida, United States
Jul 2013 - Sep 2017
Apr 2017

127000 mi

US $5
Replace nylon linkage connector behind intake manifold. 

Return to top

2006 Ford F-150 4dr Extended Cab 8ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Ontario, Canada
Mar 2011 - Apr 2017
Nov 2012

97300 mi

C $3100
felt a strong thud while backing up like I ran into something, checked nothing, continued backing up.Little did I know reverse band broke however, used truck for several weeks and the odd time backing up the truck hesitated until it no long 
Feb 2013

100520 mi

C $1650
hanger bearing failed requiring new driveshaft, hanger bearing and driveshaft come as one unit only from Ford. Having long wheelbase ext cab and 8ft box Ford has used a hanger bearing where some shorter wheelbases don't. Expensive last 3 mon 
Jun 2013

104160 mi

C $310
control F2 ( fuel pump drivers module ) located above spare tire, case cracked tech surprised it was still operating usually vehicle towed to him 
Jun 2014

112840 mi
1 tie rod 1 exhaust manifold 
Ford F-150 in Ontario, Canada
Aug 2008 - Feb 2013
Mar 2008

35340 mi

C $75
Drivers window sqeally going up and down. Lubracated window slides on all windows. Dealer covered most of cost as only had truck for two months.  
Dec 2009

63860 mi

C $450
Belt tensioner bearing wore out and wore hole in timing case. Timing case repaired tensioner replaced.  
Jul 2010

71300 mi

C $800
Knocking, seen dealer poss Cam bearing. Bearing fine ended up having Timing chain tensiors and both Cyl Heads replaced. Poss VCT and Cam Phasers. Bought used engine for parts, did work myself. $550 for engine Plus all gaskets and bolts.  
Oct 2011

81600 mi
Upper Control arm and ball joint passenger side. All four rotors and pads replaced. 
Oct 2012

103120 mi

C $640
Hanger bearing on rear drive shaft failed Drive shaft carrier bearing failed, replaced complete drive shaft. Both sections 

Return to top

2006 Ford F-150 4dr Extended Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Georgia, United States
Nov 2012 - Jun 2018
Jul 2012

110000 mi

US $2800
Transmission wasn’t shifting correctly, making rough sounds. Transmission had to be rebuilt. 
Mar 2015

120000 mi

US $12000
Truck started jerking while driving and power was gone. Fuel injectors, spark plugs, clyliner heads all had to be replaced and fixed. 
Aug 2016

135000 mi

US $1000
Vibration and shudder coming from front of the truck. All of the front suspension had to be replaced 
Mar 2018

163000 mi
Truck has developed a shudder/vibration when starting off and accelerating. Problem has not been fixed because it hasn't been diagnosed. 
Ford F-150 in California, United States
Feb 2010 - Jul 2010
May 2010

55800 mi

US $1600
driveline yoke needed grease/repacked and differential clutches need rebuilding heater hose to heater core burst while driving 
Ford F-150 in Ontario, Canada
Mar 2008 - Feb 2011
Apr 2009

33480 mi
Clutch plates worn on limited slip differential 
Apr 2010

44020 mi

C $100
Rear leaf spring broke. 
May 2010

44520 mi

C $90
Driver side window switch no longer responding. Replaced myself. 
Dec 2010

50220 mi

C $113
Computer not acknowledging cruise when activated. Replaced computer. 
Ford F-150 in Texas, United States
May 2014 - Dec 2017
Jul 2014

112000 mi

US $520
evap system problem (code P0442). Shop replaced a purge valve on gas tank. 
Nov 2015

122000 mi

US $100
Replaced 5.5 year old battery 

Return to top

2006 Ford F-150 4dr Extended Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Oregon, United States
Apr 2008 - Jul 2010
Feb 2009

39000 mi
Third brake light it was leaking water into the back of the cab. 
Sep 2009

59000 mi
Front wheel bearings started making noise. Replaced both sides 
Jul 2010

81000 mi

US $100
Rear wheel seal was leaking so I replaced them both 
Ford F-150 in Maryland, United States
Apr 2009 - Mar 2018
Sep 2010

74000 mi
No. 8 cylinder ignition coil Front four wheel drive hub stripped 
Mar 2011

84000 mi

US $295
No heat, one of the control modules for the climate control was replaced under Ford extended warranty, flush transmission 
Oct 2011

97200 mi

US $300
Exhaust leak, part ordered 
Jun 2015

181000 mi

US $600
vacuum leak in 4 wheel drive system. replace left front hub 
Jun 2016

197000 mi

US $3200
Rebuild transmission 
Jan 2017

120700 mi
Catalytic converter Transmission replaced under warranty 
May 2017

209000 mi

US $2100
All new spark plugs and coils 
Mar 2018

220000 mi

US $2500
headers and new exhaust 
Ford F-150 in North Carolina, United States
Jan 2010 - Mar 2013
Feb 2013

52000 mi

US $150
Repair wiring on coil pack 
Ford F-150 in Missouri, United States
Mar 2010 - Jun 2011
May 2010

21000 mi
Pinion seal was rubbing and squeaking. 4WD was not engaging. Fixed under 30 day dealer warranty. Pinion seal was rubbing and squeaking. 4WD was not engaging. Fixed under 30 day dealer warranty. 
Ford F-150 in Florida, United States
Jun 2011 - Jan 2018
Jun 2013

93000 mi

US $1843
Had a occasional hard knock in what was thought to be an overdrive spring. It happened when shifting and accelerating into overdrive. After finding out it was not the spring and they had to drop the tranny I elected to have it overhauled. 
May 2017

129096 mi

US $436
A/C door actuator assembly. 
Jun 2017

129492 mi

US $206
replace shifter cable 
Ford F-150 in Virginia, United States
Jun 2017 - Apr 2018
Sep 2017

117500 mi

US $510
"Dreaded 5.4L V-8 tune-up" due to Cyl 1 & 3 misfire codes. R2 all 8 platinum spark plugs and one coil. Cleared codes. 
Apr 2018

120000 mi

US $1400
Replaced cracked pax side leaking exhaust manifold, with new stainless steel headers both sides. Replaced muffler and welded small leaks to pipes. 
Ford F-150 in Alberta, Canada
Mar 2017 - Jun 2018
Aug 2017

74400 mi

C $600
throttle body 
Ford F-150 in New York, United States
Aug 2014 - Jul 2017
Jan 2015

120000 mi

US $400
Solenoid failed on starter. Starter and solenoid on F-150 are one unit. Had to be replaced. 

Return to top

2006 Ford F-150 4dr Extended Cab 6.5ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Texas, United States
Jul 2014 - Sep 2016
Nov 2014

170000 mi

US $160
Transmission cooler in Radiator leaking Replaced Radiator and Thermostat. 

Return to top

2006 Ford F-150 4dr Extended Cab 6.5ft bed

231-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Alabama, United States
Aug 2013 - Jun 2018
Dec 2013

98000 mi
Original battery failing, and replaced. Original lasted eight years. 
Apr 2016

124700 mi

US $45
Right front caliper was dragging/stuck. 
Jan 2017

133000 mi
Brake light comes on (not ABS)for no reason. Fluid level is OK, fluid sensor is OK. It turns out the plug at the back of the instrument cluster causes the brake light to come on intermittently. 
Mar 2017

134000 mi

US $55
Caliper on left front was dragging. Replaced caliper. 
Jan 2018

141000 mi

US $90
Third/cabin brake light water seal was leaking. Unit was replaced. 

Return to top

2006 Ford F-150 4dr Extended Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Florida, United States
Dec 2008 - Feb 2018
Oct 2011

52000 mi

US $194
Front left and right power window regulators making noise. Replaced. Had to wait for parts. Interior blower motor not working on speed 1. Replaced resistor pack. Had to order part. Engine made clacking sound on cold start after sitting for multiple days. Could not duplicate issue. Will monitor. At least it's documented. Replaced orginal OEM battery. 
Jul 2012

59500 mi

US $289
Misfire #6 cylinder. Repalced #6 injector. 
Dec 2014

77000 mi

US $725
Replaced front struts and rear shocks. front end alignment. 
May 2015

80000 mi

US $160
Rubber bushings on front sway bar needed to be replaced. 
Oct 2016

95300 mi

US $34
Gas filler return spring boss broke. Replaced gas filler door mounting assembly 
Mar 2017

99000 mi

US $536
Rear axle seals, left and right, leaking. Changed seals. 

Return to top

2006 Ford F-150 4dr Extended Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Tennessee, United States
Feb 2014 - Dec 2017
Jun 2016

118000 mi

US $100
Quick recharge 
Ford F-150 in Ohio, United States
Apr 2011 - Sep 2014
May 2011

48000 mi

US $735
Frozen brake caliper left front wheel, had to replace both calipers,roters & pads. 
Oct 2011

49000 mi

US $500
Had to replace Throttle Body at a cost of $500.00 
Feb 2012

49600 mi
My 4 wheel drive has failed, on my 2006 F 150, but I don't want to spend $1,000 plus to repair it , so I will just go on with 2 wheel drive. 
May 2013

53200 mi

US $650
My front Wheel drive went out last winter, was going to let the next owner worry about it, but decided to fix it, Hd to have the hubs replaced. 

Return to top

2006 Ford F-150 4dr Extended Cab 5.5ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Texas, United States
Feb 2014 - Mar 2018
May 2014

79600 mi

US $700
High pressure AC hose leak 

Return to top

2006 Ford F-150 4dr Crew Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Wisconsin, United States
Jan 2010 - Apr 2011
Mar 2010

62000 mi

US $105
Replaced actuator and removed loose foam pieces causing wear to A/C unit(s) - Ford CPO warranty covered Replaced actuator and removed loose foam pieces causing wear to A/C unit(s) - Ford CPO warranty covered 
Sep 2010

69000 mi

US $110
Leaky seal in transmission replaced 
Oct 2010

69500 mi
Had to replace torque converter 
Ford F-150 in Texas, United States
Apr 2010 - Feb 2015
Jul 2010

59000 mi

US $100
Power driver's seat control sounded like gears were stripped Driver's side exterior mirror vibrates with road imperfections. Motor was replaced but problem still there. Have not returned for re-repair. 
Sep 2010

61000 mi
Told mirror vibration not a problem. 
May 2014

104000 mi

US $100
Blend motor assembly 

Return to top

2006 Ford F-150 4dr Crew Cab 6.5ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in California, United States
Jun 2013 - Jan 2016
Aug 2013

34600 mi

US $300
Replaced front passenger window regulator 

Return to top

2006 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Texas, United States
May 2010 - Jun 2012
Jun 2010

119000 mi

US $4500
Engine will be replaced or rebuilt. 
Feb 2011

119000 mi

US $1500
The intake valve broke on Cylinder #3. 
Oct 2011

124500 mi

US $5000
Intake valve broke and punctured a hole in the piston. 
Ford F-150 in Florida, United States
May 2006 - Mar 2009
Oct 2006

1100 mi
Replaced radio/cd player for cd's skipping 
Ford F-150 in Georgia, United States
Oct 2006 - Jun 2018
Aug 2006

4500 mi
Check engine light came on when the odometer rolled over to 4,500. Took to dealer and it was an ECU chip failure. Dealer had to order the chip and replace and reprogram. All under warranty. 
Jun 2018

165000 mi

US $1008
stuck valve in AC unit, had to replace entire unit plus repair rodent damage to wiring harness. Terrible creaking and slight popping while turning hard right. Replaced front struts. 

Return to top

2006 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Montana, United States
Jan 2010 - Feb 2012
Jan 2011

65000 mi

US $85
Throwing code (CEL). Replaced Driver side upstream O2 Sensor. 400 miles later and no CEL. 
Ford F-150 in British Columbia, Canada
Jul 2015 - Oct 2017
Jan 2016

C $250
Loose spark plug 
May 2017

117800 mi

C $700
U joints in steering column worn out. Replaced steering column. 
Jul 2017

118420 mi

C $250
Number 8 coil malfunctioning. Replaced. 
Ford F-150 in Ontario, Canada
Sep 2010 - Mar 2017
Apr 2011

136400 mi

C $300
Bad misfire on cylinder 5- replaced injector. problem solved.  
Oct 2011

146940 mi

C $200
Battery kept dying for no reason. Could not pinpoint the cause. Problem disappeared while diagnosing 
Aug 2012

164200 mi

C $450
Replaced hub assembly complete with bearing 
Dec 2012

179180 mi

C $700
Random misfires. Replaced coils 
Jun 2014

204600 mi

C $300
Cracked exhaust manifold 
May 2015

215140 mi

C $1500
Power steering fluid leaking, line was rusted through U joints in drive shaft replaced. Pinion seal and axle seals replaced Drivers side exhaust manifold was cracked 
Dec 2015

221340 mi

C $250
Fitting on transmission cooler broke 
Ford F-150 in Oregon, United States
Feb 2012 - Feb 2014
Nov 2012

101000 mi

US $460
Missing during acceleration. Most offten when going up hills. Replaced Spark plugs. Durring extraction two plugs broke (known problem on 3 valve 5.4l V8). Replaced two piece plugs with one piece plugs from champion. 
Ford F-150 in British Columbia, Canada
Nov 2011 - May 2014
Nov 2011

52700 mi

C $550
Water ingress from back window and brake light caused drivers and rear carpet to be soaked. 
Aug 2012

58900 mi

C $1800
Four wheel drive would partially engage while driving due to solenoid failure. Repaired but i believe there may have been some minor damage caused to the hubs notyet repaired. Engine temperature sensor failed causing risk of engine shut down. $100 part and 6 hours of dealer labor to get to the part... 
Dec 2012

63860 mi

C $180
Large leak under front drivers side cowling allowed water to come down inside by e brake, soaking carpet. required bodyshop to remove fender to access where water was penetrating. One of the fuel temp sensors bcame partially disengaged, causing the engine light to go on. They clean it and re attached securely and all good 
Feb 2013

65900 mi

C $600
The fuel pump driver module failed. Basically Ford in its wisdom mounts this electrical module above the spare tire where it eventually corrodes and fails. Totally disgusted in Ford, this is a design flaw. 
Jun 2013

70060 mi

C $900
Complete replacement of brakes, rotors, ball joints and control arms required at 112,000 kms 
Ford F-150 in California, United States
Jan 2012 - Jan 2013
Jul 2012

82000 mi

US $450
Alternator failed, should be noted when purchased use the truck had a battery with a dead cell which may have caused issues over time with the alternator. 
Sep 2012

87000 mi

US $150
Worn leaking rubber hoses to 4x4 acutators 
Ford F-150 in Iowa, United States
Jun 2012 - Dec 2014
May 2013

42500 mi
engines misses, check engine lite comes on, dealer could not replicate, yet again. no fix to problem 
Aug 2013

44100 mi

US $240
random miss/dead cylinder. dlr could not fix. replaced the last 6 coils on a v8. miss is gone. 
Dec 2013

47000 mi
both catalytic converters had to be replaced. truck would not run. threw a p030 code - random miss 
Jan 2014

41200 mi

US $325
ford front 4x4 axle. POS!! typical problem would not engage then not disengage the axles. 
Feb 2014

47000 mi
dealer once again could not fix the front axle problem. ford would not respond to me. i own 5 fords right now. 
Sep 2014

52000 mi

US $4
outside mirrors would not move. orange wire in door opening broke in half. 
Dec 2014

54000 mi
again, a front axle IWE failure caused by water in the line and freezing. dealer is clueless as to the source of the water. dealer is inept 
Ford F-150 in Florida, United States
- Sep 2006
Sep 2006

4500 mi
Replaced fuel quantity sending unit and flex fuel module for a p0406 engine code 
Ford F-150 in New Jersey, United States
May 2009 - Jan 2012
Jul 2010

48000 mi

US $200
needed 2 tie rod ends 
Dec 2010

51500 mi

US $600
need all new rotors also changed psds 
Ford F-150 in Tennessee, United States
Aug 2011 - Jun 2018
Sep 2012

125000 mi

US $450
Changed spark plugs 
Nov 2014

162900 mi

US $385
Replaced three spark plugs and three coils 
Jun 2015

172000 mi

US $500
Plugs 
Ford F-150 in Florida, United States
Aug 2011 - Jan 2015
Nov 2011

80000 mi

US $110
Replaced siezed rear differential pinion bearing 
May 2012

85700 mi

US $80
Engine would shut off while driving and indicate it was in fail-safe mode. Engine could then be re-started and would operate normally. Problem diagnosed to throttle position sensor on throttle body. Throttle body replaced. 
Sep 2014

113000 mi

US $28
Passenger door window regulator failed 
Jan 2015

82000 mi
4WD would not engage when a trailer was hooked up using the 7-pin connector. Later could not replicate. 
Ford F-150 in Colorado, United States
Aug 2010 - Dec 2017
Aug 2013

48900 mi

US $1000
Replaced drive front CV-joint 
Ford F-150 in Saskatchewan, Canada
Dec 2009 - Dec 2014
Jan 2009

60760 mi
replaced cam followers, covered under warranty 
Dec 2011

81840 mi

C $40
AC not blowing cold, problem diagnosed 
Jan 2014

91900 mi
battery failed, cables needed replacing 
Ford F-150 in California, United States
Jun 2015 - Dec 2016
Jan 2016

US $1500
One injector got stuck open and was flooding the cylinder. Repair means replacing the faulty injector and includes removing all injectors in the bank require replacing seals. While in shop having breaks done also. 
Ford F-150 in New Mexico, United States
Aug 2008 - Mar 2010
Aug 2008

34500 mi
noise coming from blend door actuator. covered under warranty. Ford has issued a service bulletin on this. 
Aug 2009

52000 mi

US $220
Mechanical portion of window regulator failure. Front left power window. 

Return to top

2006 Ford F-150 4dr Crew Cab 5.5ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Sonora, Mexico
Feb 2013 - Jun 2018
Jun 2013

79360 mi

$10
change the lock actuator of passenger door. 
Oct 2013

80800 mi
Change the fuel pump 
Mar 2016

96100 mi

$50
Wheel Bearing, front, passenger side 515 pesos = 34 dlls for the bearing 250 pesos ? 15 dlls labor 
Mar 2017

101060 mi

$300
front struts, and ball joints 
Oct 2017

104160 mi

$620
change catalytic converter passenger side, with O2 sensor 

Return to top

2006 Ford F-150 4dr Crew Cab 5.5ft bed

231-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Ontario, Canada
Oct 2009 - Apr 2012
Aug 2011

56980 mi

C $303
Driver side window power window button non-responsive leaving window stuck 'open' 

Return to top

2005 Ford F-150

Engine not specified

Ford F-150 in Dominican Republic
Apr 2014 - May 2014
May 2014

148800 mi

$450
INJECTORS WERE BAD, INTAKE WAS LEAKING, PULLEY HAVE SOME PLAY. 

Return to top

2005 Ford F-150 4dr Regular Cab 8ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Kentucky, United States
Jun 2015 - Oct 2016
Jul 2015

135000 mi

US $3300
Injector failed open on #7. Hydrolocked. Engine destroyed. Replaced with used engine (new injectors). 
Apr 2016

144800 mi
4WD stopped working. No repaired yet. 

Return to top

2005 Ford F-150 4dr Regular Cab 8ft bed

202-horsepower 4.2L V6 4-speed automatic RWD

Ford F-150 in Bahamas
Nov 2011 - Dec 2011
Dec 2011

68200 mi

$150
Stabilizer bar nuts worn out, and need replacing. Front passenger seatbelt was not deploying. 
Ford F-150 in British Columbia, Canada
Jun 2012 - Jun 2013
May 2013

176660 mi

C $200
alignment done, cooling system flushed. brake line leaked near abs controller 

Return to top

2005 Ford F-150 4dr Regular Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Illinois, United States
Dec 2015 - Dec 2016
Oct 2016

181700 mi

US $1165
out of balance drive shaft 

Return to top

2005 Ford F-150 4dr Regular Cab 6.5ft bed

231-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Mississippi, United States
Apr 2010 - Jul 2018
Mar 2010

187000 mi

US $50
Remove and replace IWE solenoid. 
Jun 2010

190000 mi
Replaced alternator 
Jan 2015

197000 mi

US $60
Replaced left front brake rotor. Brake light stayed on in the dash. Replaced the Reservoir bowl and switch. Still has loose connection in the wiring harness behind the gauge cluster causing the brake light to flicker. 
Jun 2016

218000 mi

US $30
AC was blowing warm air. Recharged system with AC Pro 

Return to top

2005 Ford F-150 4dr Regular Cab 6.5ft bed

202-horsepower 4.2L V6 4-speed automatic RWD

Ford F-150 in Georgia, United States
Mar 2016 - Jul 2018
Dec 2016

39000 mi

US $545
u joint causing vib in veh. complete new drive shaft from ford ready to install .repair completed . 

Return to top

2005 Ford F-150 4dr Extended Cab 8ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Maryland, United States
May 2010 - Oct 2011
Jun 2010

76000 mi

US $890
A/C Clutch failed, replaced complete A/C compressor including clutch 

Return to top

2005 Ford F-150 4dr Extended Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Arizona, United States
Aug 2009 - Oct 2017
Jul 2010

126000 mi

US $168
Bad ball joints were repaired. The ball joints were causing uneven tire wear. All tires were rebalanced and an alignment was performed. 
Sep 2011

153000 mi

US $552
New bearings were installed on front of truck both sides, even though only one side was bad. 
May 2013

188000 mi

US $230
Front wheel bearing and rotor were replaced. Rotor was replaced also since the bearing is pressed into the rotor. 
Jul 2013

190800 mi

US $50
Driver's side window regulator and motor were replaced. 
Sep 2014

205000 mi

US $13
The slip yoke on the drive shaft was greased to alleviate a "clunk" on acceleration from a stop. 
Dec 2014

208000 mi

US $20
Alternator regulator was replaced. 
Ford F-150 in Tennessee, United States
Jan 2013 - Dec 2017
Sep 2014

76000 mi

US $175
Rear differential pinion shaft leaking lube. My 42 year old F100 doesn't leak. 

Return to top

2005 Ford F-150 4dr Extended Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in California, United States
Mar 2015 - Mar 2015
Mar 2015

95000 mi

US $2000
Cam phasers, replaced front end. However integrated oil pump still causing an issue 
Ford F-150 in Nebraska, United States
Jun 2013 - May 2018
Aug 2014

122400 mi

US $80
Driver window would not close. Ordered new mechanism from Rock Auto. Found that it had already been replaced at least once before. Easy job but based on mileage I guess 50,000 miles is about as long as a window regulator will last. 
Jul 2015

130500 mi

US $60
Front passenger door window regulator failed. 
Feb 2017

146000 mi

US $15
Plastic tailgate handle broke. Tabs that engage the metal latch rods are weak and break easily. Inexpensive part but many torx screws have to be removed to access. 
Jun 2017

150000 mi

US $120
Slotted rotors from Rock Auto warped after only a year. Replaced rotors and pads (although pads turned out to be in great condition). 
Ford F-150 in Massachusetts, United States
Aug 2009 - Jul 2010
Nov 2009

77000 mi
Noise in engine under low rpm and idle. high pitch "spooling" sound under load. Exhaust leak at manifold, Excessive vibration under load from 1000-2000 rpm. Dealer replaced cam phaser and told me the rest was normal. Sound was still-did not fix After complaining they finally found the exhaust manifolds cracked and ordered parts Resistor replaced on heater control because #3 fan switch inop 
Dec 2009

78000 mi

US $100
Cyl 8 misfire. Mysteriously since I lost a cylinder the "spooling" noise that they said was normal is gone. going to replace coil with manifolds. Cyl 8 had 0lbs of comp. due to valves not seating. Dealer replaced complete engine Truck would not move in any forward gear only reverse. Dealer replaced transmission. 
Ford F-150 in California, United States
Feb 2013 - Jun 2018
Sep 2013

130000 mi

US $1100
Catalytic converter failed 
Apr 2015

150200 mi

US $600
Replaced spark plugs and coils 
May 2015

150900 mi

US $50
Rear pinion seal 
Mar 2016

156000 mi

US $2500
Failure of the main clutch pack, due to overheating, caused all of the clutches to fuse together. Transmission rebuilt. 
Dec 2016

157000 mi
First gear not staying engaged, until transmission warms up. Transmission re-rebuilt. 500 miles later, problem reappeared. Transmission rebuilt again. 
Ford F-150 in Washington, United States
Oct 2010 - Jun 2014
Jul 2013

107000 mi

US $1200
When the throttle is pushed more than 1/3 of the way, the truck bucks and surges and nearly dies. Replaced computer, TPS, MAF, Throttle body, fuel filter, 
Aug 2013

108300 mi

US $1897
The computer went out. The first shop changed part after part trying to figure out what the problem was. Took it to another shop and they finally figured it out. 
Ford F-150 in Indiana, United States
Mar 2011 - Dec 2017
Nov 2012

63600 mi

US $700
Lower ball joints & inner tie rod 
Aug 2016

89000 mi

US $150
Fuel door would not close. Replaced the assembly 
Ford F-150 in Texas, United States
Jan 2008 - Aug 2010
Dec 2008

74000 mi

US $450
Air Bag Light came on determined that wire broke under seat and that seat belt latch would have to be replaced. Elected to NOT complete repairs (I just ignore the light) 
Mar 2010

91000 mi

US $120
CD Player in Factory Radio Failed. Installed Aftermarket Stereo and Speakers CD player in radio failed. Installed Aftermarket radio and speakers. 
Ford F-150 in Kentucky, United States
Mar 2012 - Mar 2013
Nov 2012

74400 mi

US $1200
Trans noise when shifting. 
Ford F-150 in Washington, United States
Jan 2010 - Mar 2014
Mar 2014

77000 mi
Lost oil pressure and oil to the top end scorced the cams and valves were damaged. 
Ford F-150 in Pennsylvania, United States
Mar 2009 - Jun 2013
Feb 2009

52250 mi

US $533
Repaired the fuel pump module and a loud leaking warped header. The front passenger side CV joint was replaced.  They changed a bad IWE solenoid. 
Jan 2011

74250 mi

US $25
Changed out the serpentine belt. It was squealing on hard shifts. 
Sep 2011

89000 mi

US $225
I had my 4x4 partially engaging. Turns out that I had an accumulation of rust in the hub bearing. My vacuum hose was pulled at the hub and rust was blown out. A suction test was completed succussfully showing no suction leaks. 
Feb 2012

94300 mi

US $225
I had a bad ball joint in my driver's side front discovered during my yearly inspection. 
Aug 2012

102000 mi

US $40
Front differential gasket leak where the drive shaft enters the back of the differential. 
Ford F-150 in Minnesota, United States
Mar 2015 - Mar 2015
Mar 2015

138000 mi

US $650
Upper and Lower Ball Joints 
Ford F-150 in Tennessee, United States
Apr 2013 - Jun 2013
May 2013

63000 mi

US $125
Front Right hub replacement 

Return to top

2005 Ford F-150 4dr Extended Cab 6.5ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Virginia, United States
Aug 2007 - Jul 2018
Nov 2011

51000 mi

US $30
30K PCV replaced 
Apr 2015

80000 mi

US $75
Had to replace rear axle seals and change diff fluid. Understand this is a common problem after 75K 
Jan 2016

79500 mi

US $30
Return power steering line developed leak. Replaced line 
Mar 2016

82000 mi

US $300
Started out with misfire. Changing plugs and COP (all 8) noticed anti-freeze in 8-7-6 plug hole. Had to replace upper and lower intake manifold gasket to complete repair properly 
May 2018

103000 mi

US $100
tie rod end (outer) lower ball joint, upper control arm and ball joint replaced on both sides 
Ford F-150 in Missouri, United States
Jul 2012 - Jun 2018
Aug 2013

66000 mi

US $850
Cracked front spring 
Aug 2014

77000 mi

US $380
Front ball joints replaced 
Jan 2016

82000 mi

US $930
remove and replace intake manifold gasket, spark plugs, coil boots and fuel rail assembly 

Return to top

2005 Ford F-150 4dr Extended Cab 6.5ft bed

231-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Pennsylvania, United States
Jun 2012 - Jun 2018
Jun 2012

137000 mi

US $250
Replaced passenger side 4wd actuator, then the other side a few weeks later. Actually in April. 
Sep 2012

148000 mi

US $60
One of the dual pistons on the passenger side caliper froze while extended. 
May 2013

161000 mi

US $110
Fuel pump driver module. Apparently it is a 2005 problem according to Ford. They placed it on the steel frame behind the spare. Caused it to erode over time. 
Aug 2013

165000 mi

US $1426
Lost all forward gears. No symptoms prior. Here clutches were burnt. Full rebuild was needed. 
Dec 2013

170000 mi

US $215
The alternator went. I replaced it. Took about 45 minutes. 
Jun 2018

227000 mi

US $800
This set of repairs included 2 upper and 2 lower ball joints, new shocks, 2 new tires, and a CV axle. 
Ford F-150 in Maryland, United States
Jun 2011 - Sep 2011
Jul 2011

48000 mi

US $390
Rough idle. Diagnosed but not fix. Was told 'all of them do it' 

Return to top

2005 Ford F-150 4dr Extended Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Arkansas, United States
Oct 2009 - Jun 2018
Nov 2009

74000 mi

US $400
Window cable snapped - window fell down in track 
Dec 2014

99000 mi

US $400
Ball Joint 
Jan 2017

95300 mi

US $300
Replace spark plugs 

Return to top

2005 Ford F-150 4dr Extended Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Ohio, United States
Jun 2008 - Jun 2013
Dec 2010

80000 mi

US $591
HVAC Blower motor would only work on # 4, High speed -- 1,2,3 did not blow air. Fix by dealer service dept was to replace a resistor in the blower 
Ford F-150 in California, United States
Sep 2016 - Mar 2018
Jun 2017

157000 mi

US $10
When key was turned to start vehicle no starter activation. Other electrical items came on. Thought it was dead battery, hooked up jump start no help. Researched internet that showed history of start problems tied to transmission - rocked vehicle back and forth - and it started up 
Mar 2018

157000 mi

US $352
Normal worn out starter. 
Ford F-150 in Arizona, United States
Feb 2012 - Jun 2018
Jan 2015

75000 mi

US $1600
Seal between transmission and transfer case failed allowing all the transmission fluid into the transfer case. 
Mar 2017

88000 mi

US $75
Battery would not hold a charge so I replaced it. Works fine now. 

Return to top

2005 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Texas, United States
Aug 2007 - Jun 2014
Feb 2008

65000 mi

US $366
One of the engine's eight ignition coils had an intermittent short causing a misfire at times CEL came on. Faulty ignition coil (number eight cylinder) and spark plug were replced by dealer. I paid for repair in whole as the truck is out of warranty. 
Sep 2008

82000 mi

US $250
Coil replaced on cylinder 1 to fix miss and check engine light. Coil replaced, problem persists, will be replacing fuel injector soon myself in attempt to repair. 
Dec 2010

140000 mi

US $300
Brake lights and cruise control stopped working. Dealer parts man printed diagram and suggested switch behind brake pedal faulty. Purchased part, replaced myself, problem solved. Lower ball joints worn (originals from factory). Replaced by local tire store. Work completed in 2 hours. 
Aug 2011

154000 mi

US $990
A/C compressor making fast ticking noise beginning in May/June, got louder as our Texas summer progressed. By end of August, local mechanic decided A/C compressor failing. Performance within spec, replaced compressor, dryer anyway. 
Dec 2011

163000 mi

US $315
Alternator began failing on way home from hunting trip. Battery light illuminated occasionally. Made it home, checked alternator output, not within specs-voltage regulator bad. Replaced alternator with Motorcraft Part-all OK now. 
Jan 2014

203300 mi

US $600
Replaced front struts due to an annoying squeak. Bushings on original struts were worn.....to be expected at this mileage. 
Ford F-150 in Arizona, United States
Feb 2009 - Jan 2018
Dec 2010

71000 mi

US $150
Power window regulator cable broke and window was stuck down. Took door apart and replaced with an OEM power window regulator unit. 
May 2011

82000 mi

US $150
Power window regulator cable snapped on the driver's door(lasted 10K miles longer than the passenger side I guess). Window was stuck down. Repaired myself with a replacement part purchased from the dealer. 
Jul 2011

84000 mi

US $5
All 4 power windows stopped working. Replaced master switch, but problem persisted. Ultimately tracked it down to a broken ground wire in the wire bundle that runs between the door and the truck. Repaired with crimp connectors. 
Jan 2016

114200 mi

US $60
Driver side rear window regulator broke. Ordered a new one and replaced myself. I have plenty of experience doing this repair by now... 
Mar 2016

135000 mi

US $1080
Truck was hesitating and surging. Shop replaced all 8 spark plugs and boots. Problem fixed. Starter was making a grinding/screeching noise every so often. Starter failed testing and was replaced. 
Ford F-150 in California, United States
May 2009 - Nov 2009
Jun 2009

104000 mi

US $125
8 ignition coils replaced 
Aug 2009

105000 mi
Catalytic Converters Replaced under warranty from a recalled faulty fuel injector 
Ford F-150 in Florida, United States
Nov 2007 - Mar 2010
Jun 2009

216000 mi

US $300
Alternator went bad. Truck was stopped, new battery placed in truck, this managed to get us home as we were only 19 miles from our house. 
Aug 2009

226000 mi

US $306
too much fuel was getting in to the engine and causing it to smoke through the exhaust. So, when this happens, it is likely that the extra gas gets into the oil and that had to be changed. We did not have to replace the catalitic converter. Runs Great! 
Ford F-150 in Georgia, United States
Mar 2010 - May 2011
Nov 2010

75000 mi

US $120
Replaced driver side window regulator and motor assembly 

Return to top

2005 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Oregon, United States
Mar 2010 - Mar 2017
Apr 2012

82300 mi

US $700
Replaced a dead catalytic converter. 
Aug 2012

84700 mi

US $400
Replaced all 4 shocks; two (1 front, 1 rear) had blown out. 
Apr 2013

90000 mi

US $400
Replaced spark plugs. All 8 plugs broke on extraction. 
Jan 2014

79700 mi

US $240
2 coil-on-plug packs on one side failed. Replaced entire bank. 
Apr 2016

110300 mi

US $400
Replaced failing coil-on-plug packs. 
Ford F-150 in Virginia, United States
Nov 2010 - Jul 2012
Jul 2012

123000 mi

US $379
High side line developed a hole due to rubbing on other lines next to it. New line installed and system recharged. 
Ford F-150 in California, United States
Mar 2010 - Jul 2011
May 2010

55000 mi

US $150
replace battery 
Ford F-150 in Florida, United States
Jun 2015 - Dec 2015
Jul 2015

115300 mi

US $2679
Transmission was slipping. I had it checked out and it needed a transmission rebuild. 
Ford F-150 in California, United States
Feb 2013 - Jun 2014
Jul 2013

114300 mi

US $100
rear driver side power window motor broke. bought a new one and replaced it myself 
Oct 2013

116500 mi

US $400
Check Engine Light One with P0430 code 
Mar 2014

119000 mi

US $2
water leak via 3rd brake light. applied gasket seal around housing 
Ford F-150 in United Arab Emirates
Mar 2013 - Mar 2014
May 2013

188057 mi

¤987
Replaced Iner & outer Tie rods + Loer Ball Joint. 
Sep 2013

192727 mi

¤5800
Clutch started sliping in 1st gear. 
Ford F-150 in Illinois, United States
Feb 2013 - Dec 2013
Jan 2013

92441 mi

US $510
Replaced r/h IWE and IWE solenoid due to water ingress. 
Ford F-150 in Tennessee, United States
Nov 2010 - Nov 2011
Jul 2011

76000 mi

US $300
Window motor went out. 
Nov 2011

82000 mi

US $120
Driver side window motor went out. 
Ford F-150 in New York, United States
Nov 2011 - Nov 2014
Jun 2013

133000 mi

US $1000
wheel bearing seized burning itself and brakes 
Apr 2014

140300 mi
Parking brake seized and everything on the wheel was getting very warm. After having endured a seized bearing I took the car to the shop immediately. First sympton = rolling squeak that stopped when on throttle. SECOND TIME THIS HAPPENED. 
Ford F-150 in Idaho, United States
Dec 2012 - Dec 2013
Jan 2013

106000 mi

US $150
Replaced vct solenoids and gasket along with fuel filter. The vct solenoids were redesigned by Ford and the oil port was reduced in size to provide greater hot idle oil pressure to the cam phaser. Largely reduced a tick in the motor. 
Mar 2013

107000 mi

US $180
Slight miss at idel. Replaced all 8 spark plugs and coils. Made no difference. Miss is caused by bad cam phaser which will be next on the repair list when I can afford it. 
Dec 2013

114000 mi
Slight miss at idle, needed a cam phaser. Part of the reason I sold the truck. I could have had it repaired for 1200 dollars but I felt like putting that towards a new truck instead. 
Ford F-150 in California, United States
Aug 2010 - Aug 2011
Nov 2010

115000 mi

US $480
Alternator went out, battery went dead. 

Return to top

2005 Ford F-150 2-door

8-cylinder automatic 4WD

Ford F-150 in Illinois, United States
Jan 2014 - May 2017
Jun 2015

98000 mi

US $400
Spark plugs replaced. Idler replaced 
Sep 2016

110000 mi

US $1200
Replaced head gasket bolts on one side 

Return to top

2004 Ford F-150

Engine not specified

Ford F-150 in Washington, United States
Jul 2010 - Jun 2011
Aug 2010

41000 mi

US $330
Driver's side window fell down on it's own and wouldn't go back up. (Power Window) 

Return to top

2004 Ford F-150 4dr Regular Cab 8ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Virginia, United States
Apr 2013 - Dec 2013
Jul 2013

56300 mi

US $10
A/C cooling intermittently. Almost a yearly thing since new. Topped off refrigerant to meet specs. 

Return to top

2004 Ford F-150 4dr Regular Cab 8ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Newfoundland / Lab., Canada
Sep 2009 - Jun 2018
Oct 2009

35960 mi
ABS SENSOR FAILED; update: later fixed by braking hard on icy roads. 
Jun 2011

45880 mi
told airbag impact sensor was corroded and not functioning. update July 2013: never fixed, always wear seatbelt 
Aug 2014

60720 mi

C $60
idler pulley 
Nov 2014

63240 mi

C $275
Starter replaced 
Feb 2015

64480 mi

C $210
replaced: another idler pulley serpentine belt clamp around air filter assembly 
Jun 2015

66340 mi

C $170
Rear Brake line. Driver side. 
Mar 2016

70060 mi

C $55
rear pinion seal replaced 
Jun 2016

73160 mi

C $84
replace power steering return hose 
Feb 2017

72540 mi

C $250
leaking fuel injector 
Aug 2017

73780 mi

C $450
transmission tail piece 

Return to top

2004 Ford F-150 4dr Regular Cab 8ft bed

231-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in West Virginia, United States
Sep 2004 - Jun 2018
Jun 2004

8000 mi
Entire rear axle assembly replaced under warranty to eliminate whine and vibration problem. 
Nov 2013

58000 mi

US $56
4-wheel drive inoperative. Replaced defective switch in transfer case. 
Feb 2014

58000 mi

US $380
Driveline vibration caused by damaged rear driveshaft. There was no physical damage detected, but the shaft was very unbalanced and could not be rebalanced. Never in an accident. Replaced driveshaft. 
May 2015

60000 mi

US $485
Driveshaft that was replaced approximately one year ago developed a vibration. I had a new driveshaft custom built with serviceable u-joints to replace the OEM type disposable shaft and non-serviceable joints. Vibration eliminated. 
Apr 2017

65000 mi

US $250
Replaced muffler. Replaced rear rotors and pads. 
Aug 2017

67000 mi

US $420
Replaced front struts due to broken coil spring. 
Feb 2018

67000 mi

US $207
Replaced fuel pump control module. 

Return to top

2004 Ford F-150 4dr Regular Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Virginia, United States
May 2015 - May 2016
Apr 2016

225000 mi

US $339
Wheel bearings disintegrated. R&R d wheel hub. 
Ford F-150 in Virginia, United States
Nov 2009 - Jun 2018
Jun 2016

47000 mi

US $539
2 Exhaust manifold bolts were broken and caused manifold to warp. Replaced bolts and manifold. 
Ford F-150 in Ohio, United States
Jun 2011 - Sep 2012
May 2012

109900 mi

US $500
Front differential seal replaced and fluid topped back off. Diagnosed engine miss fire. Reset PCM for transmission shifting and engine RPM 

Return to top

2004 Ford F-150 4dr Extended Cab 8ft bed

231-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Virginia, United States
Dec 2014 - Jun 2018
Mar 2016

24000 mi

US $200
Spark plug blew out of head taking most of the threads with it. Mechanic said it actually happens alot. I was told earlier they are actually hard to remove and break. Lucky me. mechanic had to ream out plug hole and put in new insert. So fad 
Feb 2018

30000 mi

US $50
i had another spark plug failure. This plug worked itself loose and shorted itself out. i had 1 blow out 1 1/2 years ago. guess im lucky i caught this one. Decided to pull the rest of the plugs to make sure they werent coming loose. i had one. Serious design flaw. not enough threads in aluminum head, (less than 4 full turns) and very low torque rating. ive read where it has been upped from 16 ft pounds to 28 ft pounds. also dont use spark plug grease on the threads. 

Return to top

2004 Ford F-150 4dr Extended Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Florida, United States
Oct 2012 - Jan 2018
Sep 2013

115000 mi

US $280
Lash adjusters were seized and excessive play on a few roller rockers. Symptoms were ticking/tapping sounds. 
Jan 2014

US $30
Fog lamp housing leak. 
Feb 2014

122700 mi

US $1800
Transmission slipping bad. When In for a rebuild. 
Mar 2015

140000 mi

US $23
Drivers side rear door not opening. Repaired latch cable with ebay repair kit. 
Oct 2015

147000 mi

US $30
Rear door would not open. Replaced rubber cable boots with aftermarket aluminum parts. 
Feb 2017

163000 mi

US $20
Thermostat stuck open 
Dec 2017

175000 mi

US $53
Lean codes on both banks and cat efficiency on both banks. Symptoms were rough erratic idle and occasionally stalling. 
Jan 2018

175600 mi

US $1200
Bank one cam time retarded as a result of chain jump because chain tensioner not holding oil pressure. 
Ford F-150 in Alabama, United States
Sep 2008 - Jun 2018
Jan 2008

53900 mi

US $320
Replace Power Window Regulator on driver's door. 
Dec 2011

62000 mi

US $140
Passenger front door power window regulator failed. Bought part myself and small auto repair shop replaced it for a combined cost of $140. 
Ford F-150 in California, United States
Jan 2011 - Mar 2018
Dec 2011

84000 mi

US $800
check engine light came on. replace spark plugs and boots. then one injector coil. 
Ford F-150 in California, United States
Dec 2011 - Apr 2018
Jan 2013

132000 mi

US $376
Replaced alternator 
Jan 2014

126800 mi

US $100
Several months of below freezing temps. coupled with charging system repair killed battery. New battery installed 
Apr 2015

148700 mi

US $1500
Brakes and rotors, front hubs 
Apr 2018

165000 mi

US $50
Pulled and lubed driveshaft yoke. The transmission was making a “clunking” sound when accelerating from a stop. My mechanic said it was a known issue - this procedure helped but didn’t eliminate it entirely. Ultimately parts will need to be replaced. 
Ford F-150 in Ohio, United States
Dec 2014 - Mar 2016
Jan 2016

190500 mi

US $2300
New coils, upper and lower ball joints, saw bar links, tie rods, steering column, and idler pulley 

Return to top

2004 Ford F-150 4dr Extended Cab 6.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Tennessee, United States
Nov 2010 - Jul 2012
Apr 2011

93200 mi

US $135
I had to replace the suction hoses that go to the A/C compressor. The shop I called quoted me $284.00 to fix. It is a VERY hard job getting the hoses off/on, as the compressor is at the bottom of the engine, and you can't get to it easily. 
Apr 2012

101000 mi

US $36
The passenger side sway bar end link started clunking. Replaced both sides while I was doing the passenger side. 
May 2012

101200 mi

US $48
Passenger side downstream oxygen sensor went bad. Threw a check engine light and had to be replaced. Codes thrown were: P0054 & P2270. 
Ford F-150 in Wisconsin, United States
Feb 2011 - Apr 2018
Mar 2011

72000 mi
Parking brake would not hold. Found leaking axle seal in rear that damaged brake shoes. Dismantled, cleaned, replaced necessary parts. 
Jun 2016

134000 mi

US $300
Front passenger window regulator failed. Engine misfire - diagnosed as bad plug (2nd bad plug after replacing at 115k miles). 
Apr 2017

142000 mi

US $600
Covers for front and rear differentials were replaced and painted. Differentials were cleaned and greased. New running boards were also installed as the OEM nerf bars were falling off the truck. A standard oil change and tire rotation were performed at the same time. The running boards cost about $400 in addition to this repair. 
Sep 2017

148000 mi

US $400
New rear rotors, calipers, and pads. Also replaced parking brake shoes and readjusted line. 
Dec 2017

151000 mi

US $1150
Replaced passenger side exhaust manifold. Found broken right front spring. Replaced both front coil springs. 
Ford F-150 in Florida, United States
Oct 2008 - Sep 2010
Sep 2009

67000 mi

US $120
Turned rotors, replaced front pads, LF caliper replaced AND 4WD solenoid 4wd vacuum solenoid replaced because the integrated wheel ends would occasionally try to engage by itself. 
Sep 2010

82000 mi
ABS light flashing and brake light lit. Control Module Fault was the code. 
Ford F-150 in Minnesota, United States
Aug 2006 - Jun 2011
Oct 2006

16500 mi
Replaced pinion gears under warranty. 
Apr 2009

55000 mi

US $100
Replaced oil pan gasket 
Ford F-150 in Vermont, United States
Feb 2010 - Mar 2016
Mar 2010

54000 mi

US $236
Module that controls fuel flow to fuel pump became inoperable. Module is exposed to elements. New modules on back order; dealer found used one. 
Nov 2011

69300 mi

US $303
controls, including heated seat option, for the cushion on driver's captain chair were inoperative. Took over 3 hours to trace electric malfunction to wire in dash. Replaced section of wire. 
Mar 2012

71000 mi

US $41
reattached tonneau cover 
Sep 2012

72000 mi

US $1104
Ball joint replacement, new rotors and pads 
Dec 2012

72000 mi

US $100
Battery died - replaced with new unit 
Aug 2013

83000 mi

US $80
Fuel door became unhinged 
Sep 2013

83000 mi

US $683
Rear seal 
Aug 2014

93000 mi

US $838
Ti rod, stabilizer, shock Replaced 4x4 vacuum system 
May 2015

99000 mi

US $1614
Replaced Sway Bar Broken Spring 
Ford F-150 in North Carolina, United States
Feb 2010 - Sep 2013
Aug 2012

121900 mi

US $400
replaced front shocks front calipers 
Ford F-150 in Missouri, United States
Nov 2014 - Dec 2015
Feb 2015

135300 mi

US $375
Replace passenger window bracket, window fell down inside door. 
Jul 2015

137500 mi

US $2400
Overdrive not working. Transmission went into neutral when shifting to overdrive. 
Ford F-150 in Michigan, United States
Apr 2014 - Jun 2018
Nov 2015

142600 mi

US $500
Ball Joints, tie rod ends 
Apr 2018

176000 mi

US $636
Front brakes - calipers pads and rotors 

Return to top

2004 Ford F-150 4dr Extended Cab 6.5ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Michigan, United States
Jun 2013 - Jul 2018
Jul 2015

228000 mi

US $76
ignition coil failed in cylinder no.1 , replaced it Changed all spark plugs also had to can of throttle body cleaner. 
Dec 2016

235000 mi

US $19
Dorman Blower motor resistor. Allows the blower to have different speeds. Without it, the blower would only work on high. 
Jun 2017

246000 mi

US $100
break fluid leaking at master cylinder, replaced 2ft end to end. 
Ford F-150 in Ohio, United States
Apr 2013 - May 2013
May 2013

86000 mi

US $800
ABS light came. Brake pedal pulsating. Change front left sensor. Did not fix. Had to change rotors both sides and both sensors. Learned that the rotors I put on new from auto parts were defective after on the truck for 4 month. 
Ford F-150 in Illinois, United States
Oct 2013 - Jun 2018
Nov 2014

118100 mi

US $123
I finally decided to replace the original battery I was not hung out to dry it wasn't completely dead but I had to get rid of it. 
Jan 2015

117700 mi

US $333
Muffler baffles shifted inside the muffler assembly. Repeat replaced tailpipe and muffler 
Sep 2015

128000 mi

US $20
Emergency brake light engage will not go out replace the switch on the emergency brake pedal, worked well and then came back on inter-mitten lady 
Dec 2015

132000 mi

US $135
Cruise control quit working instrument panel brake light was still illuminated. Removed instrument panel and soldered resoldered all the cold solder joints reinstalled panel cruise control fixed brake light fixed 
Sep 2016

137000 mi

US $100
Rust came through left rear quarter Installed wheel arch flairs, after treating corrosion Soft spongy breaks, quart of fluid was bled through the system disks resurfaced pads scuffed but not replaced 
Apr 2018

155000 mi

US $75
Muffler rusted & I removed. Needed reinstalliation for emissions testing. I installed, passed test, and they then welded up securely. Power steering fitting into the power steering pump in line rusted leaking replaced him it’s good to go now 
May 2018

155000 mi

US $100
Power steering lines and hoses deteriorated rusted and leaking steering system power failed , lost all fluid in system. Muffler rusted through. I purchased A muffler tailpipe and an extension pipe and I made an attempt to do it myself had it all on but it wasn’t secure took it to a muffler shop and had them welded up 

Return to top

2004 Ford F-150 4dr Extended Cab 6.5ft bed

231-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in North Carolina, United States
Nov 2007 - Jun 2011
Oct 2007

104500 mi

US $250
driver side window regulator broke, window fell into door - regulator replaced. 
Mar 2008

110000 mi
Oil & Filter Change - (two bottles on fuel injector cleaner) Added Aftermarket intake, truck was sluggish in taking off and passing - this fixed the problem 
Oct 2008

119000 mi

US $750
Stock shocks changed out --- and wheels aligned 3rd brake light was leaking, seal was broken - replaced with aftermarket. - Oil & filter change, two bottles of fuel injector cleaner 
Nov 2008

119200 mi

US $75
Rough idle after warmed up --- reflashed computer for a reprogram. 
Dec 2008

120000 mi
Other Changes Done - Since Purchase in 09/07 1)Rear Brake/3rd Brake/Headlights for black outs 2)Hard Bed Cover (2 MPG Better) 3)Chrome Grill surround 4)Chrome handles, door & tailgate 5)chrome step plates 6)Replaced speakers 7)chrome bed rails 
Oct 2009

134000 mi

US $240
Front passenger window regulator replaced. Throttle body cleaned. Front passenger window regulator went out. Cost was $240.00 - Throttle body was cleaned at the same time as general maintenance with fuel injectors. Cost was $140.00 - Oil & filter change at the same time. 
Feb 2010

139750 mi

US $100
PCV valve changed. Replaced passenger airbag sensor. front/rear diff fluid, power steering fluid, brake fluid, tranny fluid, transfer case fluid, antifreeze flush (fluids flushed), oil change, tires balanced, rotated, aligned, PCV valve changed, fuel filter change - replaced pass airbag sensor 
Mar 2010

142000 mi

US $150
Driver front window would not roll up. Switch was broken. Replaced switch. 
Jun 2011

163000 mi
As soon as the truck hit 150,000 miles it was all down hill...3rd brake light allowed flood like waters in the cab. Tranny started slipping AC Blower Fan died Radio died Interior was falling apart, Was getting 10-12 MPG, Traded truck in 
Ford F-150 in Minnesota, United States
Aug 2009 - Dec 2014
Feb 2013

97000 mi

US $140
Front airbag sensor failure. 
Jul 2013

103000 mi

US $195
Rear axle seal leak on passenger side. 8.8" Rear differential. 
Ford F-150 in Vermont, United States
Nov 2008 - Sep 2015
Mar 2011

32000 mi

US $220
RF outer brake pad worn. Metal on metal. Found caliper seized. R&R both front rotors & pads. 
Aug 2014

47300 mi

US $100
Severe bind in steering wheel while turning thought to be the fluid or PS pump or PS piston binding issue. It was the support arms for the steering shaft extension under the hood rubbing on two guides. Lubrication only was the fix. 
Jul 2015

50200 mi

US $600
u-joint on steering shaft seized. Lubed same rear shoe's failed to fully retract - burning the shoes. 
Ford F-150 in North Carolina, United States
Nov 2009 - Mar 2013
Jan 2012

106000 mi

US $450
Occasional, inexplicable slight vibration at 50~60mph speed, building to dash-shaking vibration which was stopped by pulling over, backing up and resuming. Dealer replaced parking brake levers, lubed and freed mechanism and replaced parking brake shoes. 
Mar 2013

130000 mi

US $500
Alternator blew out. Acceptable repair. the truck is a beast! 

Return to top

2004 Ford F-150 4dr Extended Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Pennsylvania, United States
Jul 2009 - Jun 2011
Aug 2009

41000 mi

US $400
Rear passenger window came off internal track. Track had to be replaced. 
Oct 2010

53000 mi

US $400
Front passenger window regulator broke and was replaced. 
Ford F-150 in Texas, United States
Nov 2007 - Aug 2012
Aug 2008

55000 mi

US $110
Passenger window mechanism broke preventing the window from moving. 
Sep 2010

72000 mi

US $342
drivers side door window lift assembly broke and window would not close. 
Jan 2011

73000 mi

US $250
rear window lift mechanism broke 
May 2011

76000 mi

US $275
voltage regulator on the alternator failed, draining the battery and caused total loss of power to vehicle. 
Ford F-150 in Florida, United States
May 2009 - Mar 2010
Jun 2009

98000 mi

US $334
BRANDON FORD tried to charge me $1,300.00 to change the spark plugs because their TECH broke off the plugs AFTER I was quoted $308.00! Differential was replaced using 3rd party Extended Service Contract.IS IT ANY WONDER CAR MFG ARE GOING OUT OF BUSINESS? 

Return to top

2004 Ford F-150 4dr Extended Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Ontario, Canada
Nov 2012 - Aug 2014
Jan 2012

126500 mi

C $612
Left front wheel bearing worn beyond limits. 
Feb 2012

119040 mi

C $3041
Transmission suffered catastrophic failure. Required replacement with used transmission. 
Dec 2012

133579 mi

C $1835
Replaced rt frt wheel bearing, rt lower ball joint, rt frt hub sleeve, rt frt drive axle. Replaced rt frt wheel bearing, rt frt drive axle, rt lower ball joint, rt frt hub sleeve. 
Jun 2013

138260 mi

C $42
Front rotors and pads shot, springs heavily corroded, broke when removed, adjustment mechanism seized. Hell-of-a-time getting the rotors off. Bought drum brake kit from local Ford dealer. Springs alone were $62, but the entire kit was $42 - go figure! 
Nov 2013

146900 mi

C $495
Truck dead suddenly in a friends driveway. Had to be towed to local mechanic shop. Fuel pump module replaced. 
Jul 2014

156860 mi

C $150
Check engine light on. OBDII code P0171. Running through recommended diagnostics,still not cleared. Rough idle and stalls. 
Ford F-150 in Alberta, Canada
- Jan 2009
Sep 2008

132680 mi

C $1100
Replaced drive shaft (just needed ujoints but are a unit) 
Jan 2009

138880 mi

C $2300
Engine knock top and bottom right side 
Ford F-150 in Saskatchewan, Canada
May 2009 - Jun 2017
Jun 2015

176080 mi

C $1800
Front End work, Lower Tie Rods,  (1) CV shft, Front U-Joints, Rear Drive shaft (Non replaceable U-Joints) 
Dec 2016

189100 mi

C $2500
Installed new cam phasors/timing chain and guides. 
Ford F-150 in Arizona, United States
Feb 2008 - Oct 2016
Dec 2012

51000 mi

US $170
Replace worn, aging serpentine belt. 
Nov 2013

55000 mi

US $1700
Replace front struts, rear shocks, rear brake pads, resurface disks. 
Ford F-150 in Texas, United States
Dec 2008 - Sep 2013
Aug 2010

75000 mi

US $156
Failed right rear window regulator. replaced reg and motor. 
Oct 2010

75000 mi

US $2200
Rebuild transmission. 
Sep 2011

82000 mi

US $300
Window regulators front (both) failed and required replacement. 

Return to top

2004 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic RWD

Ford F-150 in Florida, United States
Sep 2017 - Jul 2018
Mar 2018

178000 mi

US $49
Front driver and rear passenger windows mechanism replacement 
May 2018

180012 mi

US $49
electric window mechanism 
Ford F-150 in Mississippi, United States
Jun 2009 - Dec 2012
Sep 2010

78000 mi

US $200
Power Window Regulator went out. 
Ford F-150 in Arizona, United States
Jun 2011 - Sep 2012
Jul 2011

153000 mi

US $505
One of the rear axle seals went bad. So I had both replaced. 
Ford F-150 in California, United States
Apr 2018 - Jun 2018
Jun 2018

180000 mi

US $250
Transmission mount replaced. 
Ford F-150 in Texas, United States
Jun 2009 - Jul 2013
Jun 2009

52659 mi

US $16
Replaced outside temperature sensor - didn't work, still shows erratic outside temperatures (way lower than actual). 
May 2010

60000 mi

US $89
Updated PCM per TSB 17261 for Ambient Temp and Climate Control fix. 
Nov 2011

72000 mi

US $1963
Misfires Replaced the left and right cam phasers and solenoids 
Jan 2012

73000 mi

US $2
Hose clamp not tight enough, power steering fluid leaking from hose/cooler. Replaced the hose clamp and topped off power steering fluid. 
Ford F-150 in Texas, United States
Nov 2010 - Feb 2011
Dec 2010

88000 mi

US $800
Bad wheel bearing. Rear rotors were also warped. Replaced all 4 rotors and new pads all around. 
Ford F-150 in California, United States
Jun 2014 - Jun 2018
Jun 2015

142000 mi

US $200
blend door broken, replaced 

Return to top

2004 Ford F-150 4dr Crew Cab 5.5ft bed

300-horsepower 5.4L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Utah, United States
May 2008 - Jun 2018
Jul 2010

47200 mi

US $270
Power window regulator replaced 
Aug 2011

55500 mi

US $60
Plastic part of the window regulator assembly broke. I found an after-market part (new) for $60 shipped. I replaced it myself to save dealer labor. 
Sep 2011

55000 mi
I had another window regulator plastic part break (common on these F-150's). I haven't repaired it yet. I've seen online where there's a possible two cent fix for the problem by using a screw to replace the broken part. 
Apr 2017

102000 mi

US $800
Replaced variable camshaft timing solenoids. 
Ford F-150 in Virginia, United States
Nov 2007 - Mar 2010
Nov 2008

85000 mi

US $3142
O/D band slipping. Rebuild tranny. 
Ford F-150 in California, United States
Aug 2007 - Jul 2012
Sep 2007

21000 mi
Rear end would shudder when turning. 
Nov 2007

23000 mi
Compressor seal failure in AC system. 
Dec 2008

28000 mi

US $200
Power window regulator failed on driver's side front door. Plastic guide broke apart causing the window to fall into the door cavity. Whole window regulator had to be replaced. 
Oct 2011

44000 mi

US $340
Rear passenger door power window regulator and rear sliding power window regulator both failed completely and needed replacement. 
Ford F-150 in Nevada, United States
Nov 2007 - Dec 2014
Nov 2009

115000 mi

US $200
left front and right rear power window regulator failure. 
Dec 2012

144000 mi

US $150
REPLACED LEFT FRONT HUB ASSEMBLY 
Jan 2014

137300 mi

US $200
left front hub assembly failure 
Ford F-150 in Connecticut, United States
Feb 2008 - Jun 2012
May 2008

46000 mi

US $300
Window motor assembly. 
Sep 2008

48000 mi

US $300
Replace window motor assembly... second window to have this problem. 
Jul 2009

54000 mi
rear end chatter on turns special friction additive put in 
Sep 2010

63000 mi

US $30
truck was making transmission type noises when wet. A friend of mine had similar problem and told me about it. The valve that regulates 2/4 wheel drive had to be replaced with an updated one. The sound I heard was the front hubs engaging 
Jul 2011

67200 mi

US $250
Had to replace another electric window assembly this summer , maybe July. The service manager gave it to me for $250 as he felt bad that the problem continues. Overall, all four window assemblies have been replaced and this is the second the drivers side. 
May 2012

70000 mi

US $100
ac metal hose had leak replaced metal hoses and recharged water leakage front passenger under carpet 
Jun 2012

70000 mi
water leakage front passenger under carpet not fixed 
Ford F-150 in Alberta, Canada
Jan 2008 - Jun 2011
Dec 2008

78740 mi

C $1100
Replace spark plugs, fuel rail cleaning, replace IWE solenoid (4x4). 
Dec 2009

97340 mi

C $1064
Vacuum actuator and left front hub failed (4x4 in -30 celcius weather). Actuator and hub replaced, tires rotated and balanced. 
Ford F-150 in Ohio, United States
Sep 2008 - Dec 2011
Oct 2008

71000 mi

US $380
Electronic 4x4 transfer went out 
Dec 2011

92000 mi
leaking exhaust manifold cam phasers going out, spark plugs impossible to remove from heads 
Ford F-150 in Massachusetts, United States
Feb 2010 - Jun 2011
Sep 2010

135000 mi

US $143
Alternator went-towed home-replace following day-charged battery 
Ford F-150 in Texas, United States
Oct 2012 - Jun 2018
Apr 2013

172700 mi

US $337
Truck would not start. Thought it was battery. Problem diagnosed as alternator. Replaced alternator...truck starts fine and battery is good. 
Aug 2013

177400 mi

US $119
Replaced worn Inner Tie-Rod Ends before installing new tires. 
Feb 2016

197600 mi

US $165
Replaced Thermostat 
May 2018

209850 mi

US $200
Rough idle and acceleration. Replaced faulty coil. 
Ford F-150 in New Jersey, United States
Nov 2013 - Apr 2017
Feb 2014

134600 mi

US $180
check engine light on changed spark plug coils and plugs still needs fuel filter done and exhaust system done 
Apr 2015

139300 mi

US $175
battery died and took out the starter. it went dead trying to start the truck. frame rust problem at gusset points on the front behind wheels front coil spring broken off at end 
Jun 2015

141000 mi

US $600
power stearing lines rusted out and rack and pinion was leaking with bad tierod ends had to replace all parts 
Sep 2015

141000 mi

US $200
transmission lines rusted out causing lose of fluid all lines had to be removed and replaced transmission cooler had to be removed do to rust 
Dec 2015

143000 mi
both rear cab conners have rusted through and will need extensive repair work 
Jan 2016

140000 mi

US $250
front coil spring broken on both sides. both back shocks rusted and no longer working correctly 
Mar 2016

145000 mi

US $351
quick change struts and rear shocks 
Apr 2016

145500 mi
cars running very poorly at this point 
Jul 2016

148300 mi

US $150
alternator died needed to replaced with a new one bought on e bay 
Dec 2016

151000 mi

US $1649
took truck to mt holly transmission for rebuilt transmission and trans oil lines the job was not done right the truck broke down a second time was at the shop for 4 weeks and was returned still broken and not fixed so I'm out the money. we have had to tow the truck home and go out and buy another suv a 2014 ford escape. 
Ford F-150 in Texas, United States
Feb 2017 - Jun 2018
Apr 2017

155000 mi

US $600
Front rotors were warped when I purchased. New pads and rotors on all 4 wheels 
Nov 2017

157000 mi

US $600
Replaced rusted muffler and exhaust 
Ford F-150 in Washington, United States
Sep 2011 - Jul 2014
Mar 2012

77000 mi

US $125
Gas filler door replaced for 2nd time 
Sep 2013

90000 mi

US $160
fuel door hinge 
Ford F-150 in Minnesota, United States
Sep 2012 - Jun 2016
Jan 2012

114250 mi

US $300
Replaced alternator due to cold weather shrieking noise. Replaced with motorcraft remanufactured unit. 
Aug 2012

119000 mi

US $900
Rear differential speed sensor replaced along with wiring harness (corroded). Also had airbag wiring harness recall performed. AC Compressor failed. Replaced Compressor, orifice tube, drier, etc... 
Oct 2012

120700 mi

US $30
Replaced Thermostat - failed open. Diagnosed with a scanguage. 
Sep 2013

135000 mi

US $160
Replaced Fuel Pressure Driver Module (FPDM) due to corrosion. 
Mar 2014

142000 mi

US $41
Replaced blower motor resistor. Had lost fan speeds 1 and 2. Smooth Idler Pulleys replaced. Bearings were shot in both. 
Jun 2014

147000 mi

US $1115
Bad upper and lower ball joints, driver side. Bad Sway Bar links, both sides. All replaced, with lifetime alignment. Transmission also serviced. 
Sep 2014

152000 mi

US $315
Passenger front wheel unit bearing failed. Replaced with Timken unit. 
Oct 2014

153000 mi

US $575
Broken Drivers Front Coil Spring. Replaced with Quick Strut Units, both sides and realigned. 
Nov 2014

154300 mi

US $315
Drivers window regulator failed. Replaced at local glass shop. 
Jun 2015

164000 mi

US $75
Coil pack #6 failed and replaced. 
Aug 2015

168000 mi

US $220
Intermediate steering shaft u-joints (lower one in particular) were binding resulting in stiff steering. Regreasing bought a few months, but a replacement was the only permanent fix (non-serviceable u-joints - must replace whole unit). 
Sep 2015

169000 mi
Headlamp Assembly cracked and was leaking water into the unit. Replaced with new unit. 
Dec 2015

175000 mi

US $30
Thermostat was sticking open. Replaced with another Motorcraft unit. 
Feb 2016

176100 mi

US $30
4x4 Control Solenoid failed. Replaced with unit with doghouse to prevent water from entering the unit. Drivers Window regulator failed. Replaced unit. 
Mar 2016

179000 mi

US $45
Coil Pack Cylinder #2 Failed (causing misfires). Replaced. 
Ford F-150 in Missouri, United States
Dec 2012 - Jun 2018
May 2015

160000 mi

US $4800
Intake valve fell into a cylinder, engine was replaced. 
May 2017

187000 mi

US $160
Cam phasers were replaced under new motor warranty 
Ford F-150 in New Jersey, United States
Nov 2006 - Mar 2010
Feb 2006

17225 mi
Sliding rear window rattles loudly. rear ac vent inopperable chrome cap on shifter knob broke off. all repaired under warranty 
Ford F-150 in California, United States
Feb 2011 - Jun 2015
Apr 2011

26000 mi

US $55
Right front brake caliper sticking causing pads to bind and overheat. Rebuilt caliper installed along with new pads. 
Sep 2011

31000 mi

US $81
Front Passenger side window regulator failed leaving window down. Ordered new regulator assembly and replaced. 
Ford F-150 in Washington, United States
Nov 2014 - Mar 2016
Dec 2015

139000 mi

US $400
Battery and Alternator was replaced. 
Ford F-150 in Alberta, Canada
Sep 2016 - Jun 2018
Nov 2016

123200 mi

C $500
Lower ball joints 
Jan 2017

124800 mi

C $400
Whirring noise. Replaced complete hub rhs of 4x4 axle 
Ford F-150 in Arkansas, United States
Jan 2011 - Mar 2011
Mar 2011

127000 mi

US $100
Alternator quit working and had to be replaced. 
Ford F-150 in Nebraska, United States
Jun 2010 - Dec 2011
Jul 2011

81000 mi

US $100
Window Regulator failed, window was stuck in down position.  
Ford F-150 in Alaska, United States
Dec 2010 - Nov 2013
Jun 2012

85000 mi

US $632
Original brakes after 8 years needed new rotors and pads. Calipers were rebuilt. 
Ford F-150 in Texas, United States
- Dec 2008
Mar 2008

155600 mi

US $80
fuel rail pressure sensor 
Dec 2008

170000 mi

US $150
front passenger window motor/regulator. 

Return to top

2004 Ford F-150 4dr Crew Cab 5.5ft bed

231-horsepower 4.6L V8 4-speed automatic RWD

Ford F-150 in Missouri, United States
Jul 2012 - Aug 2012
Aug 2012

152000 mi
Rear passenger window not operating when purchased...Dealer replaced window regulator. Otherwise vehicle in great condition. 

Return to top

2004 Ford F-150 4dr Crew Cab 5.5ft bed

231-horsepower 4.6L V8 4-speed automatic 4WD, part-time w/low range

Ford F-150 in Florida, United States
Jun 2017 - Jul 2018
Jun 2018

174000 mi

US $600
R&r tie rod ends. Alignment Oil change New front tires. 
Jul 2018

177000 mi

US $1600
Blew out 4th gear. It was replaced by neutral. Trans rebuild. 
Ford F-150 in Alabama, United States
Apr 2012 - Jul 2018
Jun 2012

88000 mi

US $80
Replaced 4x4 Integrated Wheel end, vacuum reservoir and vacuum solenoid. Water in the vacuum solenoid seemed to be the source of the problem. Replacement had a hood over it so water from the firewall doesn't pollute the system. 

Return to top

2004 Ford F-150 4-door

8-cylinder automatic 4WD

Ford F-150 in Ontario, Canada
Nov 2007 - Jun 2008
Dec 2007

60760 mi
When I test drove the truck in December I was noticing a shutter running through the vehicle when I started turning out of a stop. Apparently the wrong fluid had been put in the diff, they sent it to a Ford dealership to have it drained and replaced. 
Jun 2008

67580 mi
Oil change guy noticed that fluid was spewing out of the rear diff. Brought it back to the dealer who had it fixed immediately because it was about the seize up and cause more damage. 
Ford F-150 in Ohio, United States
Oct 2007 - Mar 2010
Dec 2007

29000 mi

US $1200
Trans Fault warning came on and trans starting acting funny. Had metal shavings in the pan and a new reman trans is being installed. 

Return to top

2004 Ford F-150 4-door

8-cylinder automatic 2WD

Ford F-150 in Florida, United States
Feb 2008 - May 2008
Apr 2008

47000 mi

US $100
Thermostat not opening properly. 
Ford F-150 in Indiana, United States
Sep 2007 - Mar 2010
Mar 2008

35000 mi

US $940
Clutches in rear end causing shudder when turning. 

Return to top

2004 Ford F-150 2-door

8-cylinder automatic 4WD

Ford F-150 in West Virginia, United States
Nov 2007 - Apr 2008
Feb 2008

66000 mi

US $637
Ball joint repair. 

Return to top

See TrueDelta's information for all Pickups
See TrueDelta's information for all Ford models.

2008 Ford F-150 Repair Histories

See our lemon odds and nada odds page to see vehicles with no repairs or vehicles with more than three repairs. To see how frequently 2008 Ford F-150 problems occur, check out our car reliability stats.